ThinkPad T520, T520i, and W520
Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
ThinkPad T520, T520i, and W520
Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Note
Before using this information and the product it supports, be sure to read the general information under
Notices.
Third Edition (April 2011)
© Copyright Lenovo 2011.
LIMITED AND RESTRICTED RIGHTS NOTICE: If data or software are delivered pursuant a General Services
Administration “GSA” contract, use, reproduction, or disclosure is subject to restrictions set forth in Contract No.
GS-35F-05925.
Download from Www.Somanuals.com. All Manuals Search And Download.
Contents
Power management
38
38
38
39
39
40
41
42
43
43
43
44
Hibernation mode
General safety .
1
2
3
Electrical safety .
Numeric error codes
Safety inspection guide .
Error messages
Beep symptoms .
No-beep symptoms .
discharge.
3
4
4
Grounding requirements .
Safety notices (multilingual translations) .
Laser compliance statement (multilingual
translations) .
17
23
24
45
Configuring the system UEFI BIOS to enable
embedded SATA RAID functionality
45
45
46
board
24
24
Deleting RAID volumes
GAV .
24
24
FRU identification for CTO, CMV, and GAV
products .
25
What to do first
27
28
28
30
31
32
33
33
33
34
Retaining serial numbers.
55
56
Diagnostics using PC-Doctor for DOS.
unit
56
56
57
FRU tests .
Checking the ac adapter .
Checking operational charging
W520 .
60
60
1020 Serial Ultrabay Enhanced device or travel
bezel
61
62
63
Restoring the factory contents by using Recovery
Disc Set .
35
36
36
36
37
37
37
1040 DIMM (bottom slot).
Passwords .
65
67
70
71
© Copyright Lenovo 2011
iii
Download from Www.Somanuals.com. All Manuals Search And Download.
Rear view.
Bottom view
105
106
107
73
76
78
79
80
82
84
86
87
90
92
1120 Backup battery .
Overall .
110
151
158
159
160
161
162
162
163
164
165
166
1140 Speaker assembly .
LCD FRUs
Miscellaneous parts
AC adapters
Power cords
Recovery discs
1150 Thermal module .
1160 CPU
1170 LCD unit .
1190 I/O sub card
structure frame, and modem daughter card
(MDC) .
93
97
98
99
2020 LED sub card .
Common service tools
hinges .
99
102
168
168
iv ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
About this manual
This manual contains service and reference information for the following ThinkPad® products.
ThinkPad T520 and T520i
MT 4239, 4240, 4241, 4242, 4243, 4244, and 4246
ThinkPad W520
MT 4249, 4260, 4270, 4276, 4281, 4282, and 4284
Use this manual along with the advanced diagnostic tests to troubleshoot problems.
Important: This manual is intended only for trained service technicians who are familiar with ThinkPad
products. Use this manual along with the advanced diagnostic tests to troubleshoot problems effectively.
Before servicing a ThinkPad product, be sure to read all the information under Safety information and
© Copyright Lenovo 2011
v
Download from Www.Somanuals.com. All Manuals Search And Download.
vi ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Chapter 1. Safety information
This chapter presents following safety information that you need to be familiar with before you service
a ThinkPad Notebook.
• General safety
General safety
Follow these rules to ensure general safety:
• Observe good housekeeping in the area of the machines during and after maintenance.
• When lifting any heavy object:
1. Make sure that you can stand safely without slipping.
2. Distribute the weight of the object equally between your feet.
3. Use a slow lifting force. Never move suddenly or twist when you attempt to lift.
4. Lift by standing or by pushing up with your leg muscles; this action removes the strain from the
muscles in your back. Do not attempt to lift any object that weighs more than 16 kg (35 lb) or that
you think is too heavy for you.
• Do not perform any action that causes hazards to the customer, or that makes the equipment unsafe.
• Before you start the machine, make sure that other service technicians and the customer's personnel are
not in a hazardous position.
• Place removed covers and other parts in a safe place, away from all personnel, while you are servicing
the machine.
• Keep your toolcase away from walk areas so that other people will not trip over it.
• Do not wear loose clothing that can be trapped in the moving parts of a machine. Make sure that your
sleeves are fastened or rolled up above your elbows. If your hair is long, fasten it.
• Insert the ends of your necktie or scarf inside clothing or fasten it with a nonconductive clip, about 8
centimeters (3 inches) from the end.
• Do not wear jewelry, chains, metal-frame eyeglasses, or metal fasteners for your clothing.
Attention: Metal objects are good electrical conductors.
• Wear safety glasses when you are hammering, drilling, soldering, cutting wire, attaching springs, using
solvents, or working in any other conditions that might be hazardous to your eyes.
• After service, reinstall all safety shields, guards, labels, and ground wires. Replace any safety device
that is worn or defective.
• Reinstall all covers correctly before returning the machine to the customer.
• Fan louvers on the machine help to prevent overheating of internal components. Do not obstruct fan
louvers or cover them with labels or stickers.
© Copyright Lenovo 2011
1
Download from Www.Somanuals.com. All Manuals Search And Download.
Electrical safety
Observe the following rules when working on electrical equipment.
Important: Use only approved tools and test equipment. Some hand tools have handles covered with a soft
material that does not insulate you when working with live electrical currents.Many customers have, near
their equipment, rubber floor mats that contain small conductive fibers to decrease electrostatic discharges.
Do not use this type of mat to protect yourself from electrical shock.
• Find the room emergency power-off (EPO) switch, disconnecting switch, or electrical outlet. If an electrical
accident occurs, you can then operate the switch or unplug the power cord quickly.
• Do not work alone under hazardous conditions or near equipment that has hazardous voltages.
• Disconnect all power before:
– Performing a mechanical inspection
– Working near power supplies
– Removing or installing main units
• Before you start to work on the machine, unplug the power cord. If you cannot unplug it, ask the customer
to power-off the wall box that supplies power to the machine, and to lock the wall box in the off position.
• If you need to work on a machine that has exposed electrical circuits, observe the following precautions:
– Ensure that another person, familiar with the power-off controls, is near you.
Attention: Another person must be there to switch off the power, if necessary.
– Use only one hand when working with powered-on electrical equipment; keep the other hand in your
pocket or behind your back.
Attention: An electrical shock can occur only when there is a complete circuit. By observing the above
rule, you may prevent a current from passing through your body.
– When using testers, set the controls correctly and use the approved probe leads and accessories for
that tester.
– Stand on suitable rubber mats (obtained locally, if necessary) to insulate you from grounds such as
metal floor strips and machine frames.
Observe the special safety precautions when you work with very high voltages; Instructions for these
precautions are in the safety sections of maintenance information. Use extreme care when measuring
high voltages.
• Regularly inspect and maintain your electrical hand tools for safe operational condition.
• Do not use worn or broken tools and testers.
• Never assume that power has been disconnected from a circuit. First, check that it has been powered off.
• Always look carefully for possible hazards in your work area. Examples of these hazards are moist floors,
nongrounded power extension cables, power surges, and missing safety grounds.
• Do not touch live electrical circuits with the reflective surface of a plastic dental mirror. The surface is
conductive; such touching can cause personal injury and machine damage.
• Do not service the following parts with the power on when they are removed from their normal operating
places in a machine:
– Power supply units
– Pumps
– Blowers and fans
– Motor generators
– Similar units to listed above
This practice ensures correct grounding of the units.
• If an electrical accident occurs:
– Use caution; do not become a victim yourself.
– Switch off power.
2
ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
– Send another person to get medical aid.
Safety inspection guide
The purpose of this inspection guide is to assist you in identifying potentially unsafe conditions. As each
machine was designed and built, required safety items were installed to protect users and service technicians
from injury. This guide addresses only those items. You should use good judgment to identify potential
safety hazards due to attachment of non-ThinkPad features or options not covered by this inspection guide.
If any unsafe conditions are present, you must determine how serious the apparent hazard could be and
whether you can continue without first correcting the problem.
Consider these conditions and the safety hazards they present:
• Electrical hazards, especially primary power (primary voltage on the frame can cause serious or fatal
electrical shock)
• Explosive hazards, such as a damaged CRT face or a bulging capacitor
• Mechanical hazards, such as loose or missing hardware
To determine whether there are any potentially unsafe conditions, use the following checklist at the beginning
of every service task. Begin the checks with the power off, and the power cord disconnected.
Checklist:
1. Check exterior covers for damage (loose, broken, or sharp edges).
2. Power off the computer. Disconnect the power cord.
3. Check the power cord for:
a. A third-wire ground connector in good condition. Use a meter to measure third-wire ground
continuity for 0.1 ohm or less between the external ground pin and the frame ground.
b. The power cord should be the type specified in the parts list.
c. Insulation must not be frayed or worn.
4. Check for cracked or bulging batteries.
5. Remove the cover.
6. Check for any obvious non-ThinkPad alterations. Use good judgment as to the safety of any
non-ThinkPad alterations.
7. Check inside the unit for any obvious unsafe conditions, such as metal filings, contamination, water or
other liquids, or signs of fire or smoke damage.
8. Check for worn, frayed, or pinched cables.
9. Check that the power-supply cover fasteners (screws or rivets) have not been removed or tampered with.
Handling devices that are sensitive to electrostatic discharge
Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to
electrostatic discharge (ESD.) ESD damage can occur when there is a difference in charge between objects.
Protect against ESD damage by equalizing the charge so that the machine, the part, the work mat, and the
person handling the part are all at the same charge.
Notes:
1. Use product-specific ESD procedures when they exceed the requirements noted here.
2. Make sure that the ESD protective devices you use have been certified (ISO 9000) as fully effective.
Chapter 1. Safety information
Download from Www.Somanuals.com. All Manuals Search And Download.
3
When handling ESD-sensitive parts:
• Keep the parts in protective packages until they are inserted into the product.
• Avoid contact with other people.
• Wear a grounded wrist strap against your skin to eliminate static on your body.
• Prevent the part from touching your clothing. Most clothing is insulative and retains a charge even when
you are wearing a wrist strap.
• Use a grounded work mat to provide a static-free work surface. The mat is especially useful when
handling ESD-sensitive devices.
• Select a grounding system, such as those listed below, to provide protection that meets the specific
service requirement.
Note: The use of a grounding system to guard against ESD damage is desirable but not necessary.
– Attach the ESD ground clip to any frame ground, ground braid, or green-wire ground.
– When working on a double-insulated or battery-operated system, use an ESD common ground or
reference point. You can use coax or connector-outside shells on these systems.
– Use the round ground prong of the ac plug on ac-operated computers.
Grounding requirements
Electrical grounding of the computer is required for operator safety and correct system function. Proper
grounding of the electrical outlet can be verified by a certified electrician.
Safety notices (multilingual translations)
The safety notices in this section are provided in the following languages:
• English
• Arabic
• German
• Hebrew
• Japanese
• Korean
• Spanish
DANGER
Before the computer is powered on after FRU replacement, make sure all screws, springs, and other small
parts are in place and are not left loose inside the computer. Verify this by shaking the computer and listening
for rattling sounds. Metallic parts or metal flakes can cause electrical shorts.
4
ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
DANGER
Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery,
recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances
or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result
in ignition or explosion of the battery.
DANGER
The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or
short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the
battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result
in ignition or explosion of the battery.
DANGER
The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized
connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water.
Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate
parts listing. Use of an incorrect battery can result in ignition or explosion of the battery.
DANGER
If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash
the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are
present after washing.
DANGER
To avoid shock, do not remove the plastic cover that protects the lower part of the inverter card.
DANGER
Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to
burn personnel or combustible materials.
Chapter 1. Safety information
Download from Www.Somanuals.com. All Manuals Search And Download.
5
DANGER
Unless hot swap is allowed for the FRU being replaced, do as follows before removing it: power off the
computer, unplug all power cords from electrical outlets, remove the battery pack, and disconnect any
interconnecting cables.
6
ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
PERIGO
Antes de ligar o computador após a substituição da FRU, certifique-se de que todos os parafusos, molas e
outras peças pequenas estejam no lugar e não estejam soltos dentro do computador. Verifique isso sacudindo
o computador e procurando ouvir sons de peças soltas. Peças metálicas ou lascas de metal podem causar
curto-circuito.
PERIGO
Algumas baterias reserva contêm uma pequena quantidade de níquel e cádmio. Não desmonte uma bateria
reserva, recarregue-a, jogue-a no fogo ou na água, ou deixe-a entrar em curto-circuito. Descarte a bateria
conforme requerido pelas leis ou regulamentos locais. Use somente a bateria nas partes listadas apropriadas.
O uso de uma bateria incorreta pode resultar em combustão ou explosão da bateria.
PERIGO
O pacote da bateria contém uma pequena quantidade de níquel. Não o desmonte, jogue-o no fogo ou na
água, ou deixe-o entrar em curto-circuito. Descarte o pacote da bateria conforme requerido pelas leis ou
regulamentos locais. Use somente a bateria nas partes listadas apropriadas ao substituir o pacote da bateria.
O uso de uma bateria incorreta pode resultar em combustão ou explosão da bateria.
PERIGO
Chapter 1. Safety information
Download from Www.Somanuals.com. All Manuals Search And Download.
7
A bateria de lítio pode causar incêndio, explosão ou graves queimaduras. Não a recarregue, remova seu
conector polarizado, desmonte-a, aqueça-a acima de 100°C (212°F), incinere-a, ou exponha o conteúdo de
sua célula à água. Descarte a bateria conforme requerido pelas leis ou regulamentos locais. Use somente
a bateria nas partes listadas apropriadas. O uso de uma bateria incorreta pode resultar em combustão
ou explosão da bateria.
PERIGO
Se o LCD quebrar e o fluido de dentro dele entrar em contato com seus olhos ou com suas mãos, lave as
áreas afetadas imediatamente com água durante pelo menos 15 minutos. Procure cuidados médicos se algum
sintoma causado pelo fluido surgir após a lavagem.
PERIGO
Para evitar choque elétrico, não remova a capa plástica que protege a parte inferior da placa inversora.
PERIGO
Embora as principais baterias possuam baixa voltagem, uma bateria em curto-circuito ou aterrada pode
produzir corrente o bastante para queimar materiais de pessoal ou inflamáveis.
PERIGO
A menos que uma hot swap seja permitida para a FRU que está sendo substituída, faça o seguinte antes de
removê-la: desligue o computador, desconecte todos os cabos de energia das tomadas, remova o pacote de
baterias e desconecte quaisquer cabos de interconexão.
DANGER
Avant de remettre l'ordinateur sous tension après remplacement d'une unité en clientèle, vérifiez que tous les
ressorts, vis et autres pièces sont bien en place et bien fixées. Pour ce faire, secouez l'unité et assurez-vous
qu'aucun bruit suspect ne se produit. Des pièces métalliques ou des copeaux de métal pourraient causer
un court-circuit.
DANGER
8
ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Certaines batteries de secours contiennent du nickel et du cadmium. Ne les démontez pas, ne les rechargez
pas, ne les exposez ni au feu ni à l'eau. Ne les mettez pas en court-circuit. Pour les mettre au rebut,
conformez-vous à la réglementation en vigueur. Lorsque vous remplacez la pile de sauvegarde ou celle de
l'horloge temps réel, veillez à n'utiliser que les modèles cités dans la liste de pièces détachées adéquate. Une
batterie ou une pile inappropriée risque de prendre feu ou d'exploser.
DANGER
La batterie contient du nickel. Ne la démontez pas, ne l'exposez ni au feu ni à l'eau. Ne la mettez pas en
court-circuit. Pour la mettre au rebut, conformez-vous à la réglementation en vigueur. Lorsque vous remplacez
la batterie, veillez à n'utiliser que les modèles cités dans la liste de pièces détachées adéquate. En effet, une
batterie inappropriée risque de prendre feu ou d'exploser.
DANGER
La pile de sauvegarde contient du lithium. Elle présente des risques d'incendie, d'explosion ou de brûlures
graves. Ne la rechargez pas, ne retirez pas son connecteur polarisé et ne la démontez pas. Ne l'exposez pas à
une temperature supérieure à 100°C, ne la faites pas brûler et n'en exposez pas le contenu à l'eau. Mettez la
pile au rebut conformément à la réglementation en vigueur. Une pile inappropriée risque de prendre feu ou
d'exploser.
DANGER
Si le panneau d'affichage à cristaux liquides se brise et que vous recevez dans les yeux ou sur les mains une
partie du fluide, rincez-les abondamment pendant au moins quinze minutes. Consultez un médecin si des
symptômes persistent après le lavage.
DANGER
Afin d'éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure
de la carte d'alimentation.
DANGER
Bien que le voltage des batteries principales soit peu élevé, le court-circuit ou la mise à la masse d'une
batterie peut produire suffisamment de courant pour brûler des matériaux combustibles ou causer des
brûlures corporelles graves.
Chapter 1. Safety information
Download from Www.Somanuals.com. All Manuals Search And Download.
9
DANGER
Si le remplacement à chaud n'est pas autorisé pour l'unité remplaçable sur site que vous remplacez,
procédez comme suit avant de retirer l'unité : mettez l'ordinateur hors tension, débranchez tous les
cordons d'alimentation des prises de courant, retirez le bloc de batterie et déconnectez tous les câbles
d'interconnexion.
VORSICHT
Bevor nach einem FRU-Austausch der Computer wieder angeschlossen wird, muß sichergestellt werden, daß
keine Schrauben, Federn oder andere Kleinteile fehlen oder im Gehäuse vergessen wurden. Der Computer muß
geschüttelt und auf Klappergeräusche geprüft werden. Metallteile oder-splitter können Kurzschlüsse erzeugen.
VORSICHT
Die Bereitschaftsbatterie, die sich unter dem Diskettenlaufwerk befindet, kann geringe Mengen Nickel
und Cadmium enthalten. Sie darf nur durch die Verkaufsstelle oder den IBM Kundendienst ausgetauscht
werden. Sie darf nicht zerlegt, wiederaufgeladen, kurzgeschlossen, oder Feuer oder Wasser ausgesetzt
werden. Die Batterie kann schwere Verbrennungen oder Verätzungen verursachen. Bei der Entsorgung die
örtlichen Bestimmungen für Sondermüll beachten. Beim Ersetzen der Bereitschafts-oder Systembatterie nur
Batterien des Typs verwenden, der in der Ersatzteilliste aufgeführt ist. Der Einsatz falscher Batterien kann
zu Entzündung oder Explosion führen.
VORSICHT
Akkus enthalten geringe Mengen von Nickel. Sie dürfen nicht zerlegt, wiederaufgeladen, kurzgeschlossen,
oder Feuer oder Wasser ausgesetzt werden. Bei der Entsorgung die örtlichen Bestimmungen für Sondermüll
beachten. Beim Ersetzen der Batterie nur Batterien des Typs verwenden, der in der Ersatzteilliste aufgeführt
ist. Der Einsatz falscher Batterien kann zu Entzündung oder Explosion führen.
VORSICHT
Die Systembatterie ist eine Lithiumbatterie. Sie kann sich entzünden, explodieren oder schwere Verbrennungen
hervorrufen. Batterien dieses Typs dürfen nicht aufgeladen, zerlegt, über 100°C erhitzt oder verbrannt werden.
Auch darf ihr Inhalt nicht mit Wasser in Verbindung gebracht oder der zur richtigen Polung angebrachte
Verbindungsstecker entfernt werden. Bei der Entsorgung die örtlichen Bestimmungen für Sondermüll
beachten. Beim Ersetzen der Batterie nur Batterien des Typs verwenden, der in der Ersatzteilliste aufgeführt
ist. Der Einsatz falscher Batterien kann zu Entzündung oder Explosion führen.
10 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
VORSICHT
Die Leuchtstoffröhre im LCD-Bildschirm enthält Quecksilber. Bei der Entsorgung die örtlichen Bestimmungen
für Sondermüll beachten. Der LCD-Bildschirm besteht aus Glas und kann zerbrechen, wenn er unsachgemäß
behandelt wird oder der Computer auf den Boden fällt. Wenn der Bildschirm beschädigt ist und die darin
befindliche Flüssigkeit in Kontakt mit Haut und Augen gerät, sollten die betroffenen Stellen mindestens 15
Minuten mit Wasser abgespült und bei Beschwerden anschließend ein Arzt aufgesucht werden.
VORSICHT
Aus Sicherheitsgründen die Kunststoffabdeckung, die den unteren Teil der Spannungswandlerplatine umgibt,
nicht entfernen.
VORSICHT
Obwohl Hauptbatterien eine niedrige Spannung haben, können sie doch bei Kurzschluß oder Erdung genug
Strom abgeben, um brennbare Materialien zu entzünden oder Verletzungen bei Personen hervorzurufen.
VORSICHT
Wenn ein Austausch der FRU bei laufendem Betrieb nicht erlaubt ist, gehen Sie beim Austausch der FRU wie
folgt vor: Schalten Sie den Computer aus, ziehen Sie alle Netzkabel von den Netzsteckdosen ab, entfernen
Sie den Akku und ziehen Sie alle miteinander verbundenen Kabel ab.
Chapter 1. Safety information 11
Download from Www.Somanuals.com. All Manuals Search And Download.
14 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Antes de encender el sistema despues de sustituir una FRU, compruebe que todos los tornillos, muelles y
demás piezas pequeñas se encuentran en su sitio y no se encuentran sueltas dentro del sistema. Compruébelo
agitando el sistema y escuchando los posibles ruidos que provocarían. Las piezas metálicas pueden causar
cortocircuitos eléctricos.
Algunas baterías de reserva contienen una pequeña cantidad de níquel y cadmio. No las desmonte, ni
recargue, ni las eche al fuego o al agua ni las cortocircuite. Deséchelas tal como dispone la normativa local.
Utilice sólo baterías que se encuentren en la lista de piezas. La utilización de una batería no apropiada
puede provocar la ignición o explosión de la misma.
Las baterías contienen pequeñas cantidades de níquel. No las desmonte, ni recargue, ni las eche al fuego
o al agua ni las cortocircuite. Deséchelas tal como dispone la normativa local. Utilice sólo baterías que se
encuentren en la lista de piezas al sustituir la batería. La utilización de una batería no apropiada puede
provocar la ignición o explosión de la misma.
La batería de repuesto es una batería de litio y puede provocar incendios, explosiones o quemaduras graves.
No la recargue, ni quite el conector polarizado, ni la desmonte, ni caliente por encima de los 100°C (212°F), ni
la incinere ni exponga el contenido de sus celdas al agua. Deséchela tal como dispone la normativa local.
Si la LCD se rompe y el fluido de su interior entra en contacto con sus ojos o sus manos, lave inmediatamente
las áreas afectadas con agua durante 15 minutos como mínimo. Obtenga atención medica si se presenta
algún síntoma del fluido despues de lavarse.
Para evitar descargas, no quite la cubierta de plástico que rodea la parte baja de la tarjeta invertida.
Aunque las baterías principales tienen un voltaje bajo, una batería cortocircuitada o con contacto a tierra
puede producir la corriente suficiente como para quemar material combustible o provocar quemaduras en
el personal.
Chapter 1. Safety information 15
Download from Www.Somanuals.com. All Manuals Search And Download.
Salvo que se permita el intercambio en caliente para la unidad sustituible localmente, realice lo siguiente antes
de extraerla: apague el sistema, desconecte todos los cables de alimentación de las tomas de alimentación
eléctrica, extraiga la batería y desconecte los cables de interconexión.
16 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Laser compliance statement (multilingual translations)
The laser compliance statements in this section are provided in the following languages:
• English
• Arabic
• German
• Hebrew
• Japanese
• Korean
• Spanish
Chapter 1. Safety information 17
Download from Www.Somanuals.com. All Manuals Search And Download.
Chapter 2. Important service information
This chapter presents following important service information that applies to all machine types supported by
this manual:
Important: Advise customers to contact the Lenovo Customer Support Center if they need any assistance
in obtaining or installing any software fixes, drivers, and UEFI BIOS downloads. Telephone numbers for
Lenovo Support are available at:
System Disassembly/Reassembly videos that show the FRU removals or replacements for the Lenovo®
authorized service technicians are available in the following support site:
Advise customers to contact the Customer Support Center at 800-426-7378 if they need assistance in
obtaining or installing any software fixes, drivers, and UEFI BIOS downloads.
Customers in Canada should call the Customer Support Center at 800-565-3344 for assistance or download
information.
Strategy for replacing FRUs
Before replacing parts:
Make sure that all software fixes, drivers, and UEFI BIOS downloads are installed before replacing any
FRUs listed in this manual.
After a system board is replaced, ensure that the latest UEFI BIOS is loaded to the system board before
completing the service action.
To download software fixes, drivers, and UEFI BIOS, do as follows:
2. Enter the product number of the computer or press Auto-detect button on the screen.
3. Select Downloads and drivers.
4. Follow the directions on the screen and install the necessary software.
Use the following strategy to prevent unnecessary expense for replacing and servicing FRUs:
• If you are instructed to replace a FRU but the replacement does not correct the problem, reinstall
the original FRU before you continue.
• Some computers have both a processor board and a system board. If you are instructed to replace either
the processor board or the system board, and replacing one of them does not correct the problem,
reinstall that board, and then replace the other one.
© Copyright Lenovo 2011
23
Download from Www.Somanuals.com. All Manuals Search And Download.
• If an adapter or a device consists of more than one FRU, any of the FRUs may be the cause of the error.
Before replacing the adapter or device, remove the FRUs, one by one, to see if the symptoms change.
Replace only the FRU that changed the symptoms.
Attention: The setup configuration on the computer you are servicing may have been customized. Running
Automatic Configuration may alter the settings. Note the current configuration settings (using the View
Configuration option); then, when service has been completed, verify that those settings remain in effect.
Strategy for replacing a hard disk drive
Always try to run a low-level format before replacing a hard disk drive. This will cause all customer data on
the hard disk to be lost. Be sure that the customer has a current backup of the data before doing this task.
Attention: The drive startup sequence in the computer you are servicing may have been changed. Be
extremely careful during write operations such as copying, saving, or formatting. If you select an incorrect
drive, data or programs can be overwritten.
Important notice for replacing a system board
Some components mounted on a system board are very sensitive. Improper handling of a system board can
cause damage to those components, and may cause a system malfunction.
Attention: When handling a system board:
• Do not drop a system board or apply any excessive force to it.
• Avoid rough handling of any kind.
• Avoid bending a system board and hard pushing to prevent cracking at each BGA (Ball Grid Array) chipset.
How to use error message
Use the error codes displayed on the screen to diagnose failures. If more than one error code is displayed,
begin the diagnosis with the first error code. Whatever causes the first error code may also cause false error
codes. If no error code is displayed, see whether the error symptom is listed in the Symptom-to-FRU
Index for the computer you are servicing.
Strategy for replacing FRUs for CTO, CMV, and GAV
Product definition
Dynamic Configure To Order (CTO)
This provides the ability for a customer to configure a Lenovo solution from an eSite, and have this
configuration sent to fulfillment, where it is built and shipped directly to the customer. The machine label,
Product Entitlement Warehouse (PEW), eSupport, and the HMM will load these products as the 4-digit MT
and 3-digit model, where model = “CTO” (Example: 1829-CTO).
Custom Model Variant (CMV)
This is a unique configuration that has been negotiated between Lenovo and the customer. A unique 4-digit
MT and 3-digit model is provided to the customer to place orders (Example: 1829-W15). A CMV is a special
bid offering. Therefore, it is NOT generally announced.
• The MTM portion of the machine label is the 4-digit MT and 3-digit model, where model = “CTO”
(Example: 1829-CTO). The PRODUCT ID portion of the machine label is the 4-digit MT and 3-digit CMV
model (Example: 1829-W15).
• The PEW record is the 4-digit MT and 3-digit model, where model = “CTO” (Example: 1829-CTO).
24 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
• eSupport will show both the CTO and CMV machine type models (Example: 1829-CTO and 1829-W15
will be found on the eSupport site.)
• The HMM will have the 4-digit MT and 3-digit CTO model only (Example: 1829-CTO). Again, CMVs are
custom models and are not found in the HMM.
General Announce Variant (GAV)
This is a standard model (fixed configuration). GAVs are announced and offered to all customers. The MTM
portion of the machine label is a 4-digit MT and 3-digit model, where model = a “fixed part number”, not
“CTO” (Example: 1829-F1U). Also, PEW, eSupport, and the HMM will list these products under the same
fixed model number.
FRU identification for CTO, CMV, and GAV products
There are three information resources to identify which FRUs are used to support CTO, CMV, and GAV
products. These sources are PEW, eSupport, and the HMM.
Using PEW
• PEW is the primary source for identifying FRU part numbers and FRU descriptions for the key commodities
for CTO, CMV and GAV products at a MT - serial number level. An example of key commodities are hard
disk drives, system boards, microprocessors, Liquid Crystal Displays (LCDs), and memory.
• Remember, all CTO and CMV products are loaded in PEW under the 4-digit MT and 3-digit model, where
model = “CTO” (Example: 1829-CTO). GAVs are loaded in PEW under the 4-digit MT and 3-digit model,
where model = a “fixed part number”, not “CTO” (Example: 1829-F1U).
• PEW can be accessed at the following Web site:
Select Warranty lookup. Input the MT and the Serial number and the list of key commodities will be
returned in the PEW record under COMPONENT INFORMATION.
Using eSupport
For Key Commodities (Examples - hard disk drive, system board, microprocessor, LCD, and memory)
• eSupport can be used to view the list of key commodities built in a particular machine serial (this is the
same record found in PEW).
• eSupport can be accessed at the following Web site:
• To view the key commodities, click on PARTS INFORMATION, then PARTS LOOKUP. Type in the model
type and serial number. The key commodities will be returned in the eSupport record under PARTS
SHIPPED WITH YOUR SYSTEM.
For the Remaining FRUs (the complete list of FRUs at the MT Model level)
• eSupport can be used to view the complete list of FRUs for a machine type and model.
• To view the complete list of FRUs, type in the machine type and model (Example: 1829-CTO) under
QUICK PATH. Under “View by Document Type” select PARTS INFORMATION. Under “Filter by Category”
select SERVICE PARTS. Under “Parts Information by Date” select SYSTEM SERVICE PARTS. The list of
service parts by description, with applicable machine type model and FRU will be displayed.
Using the HMM
For Key Commodities (Examples - hard disk drive, system board, microprocessor, LCD, and memory)
Use the HMM as a back-up to PEW and eSupport to view the complete list of FRUs at the MT Model level.
Chapter 2. Important service information 25
Download from Www.Somanuals.com. All Manuals Search And Download.
26 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Chapter 3. General checkout
This chapter presents following information:
• Checkout guide
The descriptions in this chapter apply to any ThinkPad model that supports the PC-Doctor® for DOS
diagnostics program. Some descriptions might not apply to your particular computer.
Before you go to the checkout guide, be sure to read the following important notes.
Important:
• Only certified trained personnel should service the computer.
• Before replacing any FRU, read the entire page on removing and replacing FRUs.
• When you replace FRUs, use new nylon-coated screws.
• Be extremely careful during such write operations as copying, saving, or formatting. Drives in the
computer that you are servicing sequence might have been altered. If you select an incorrect drive,
data or programs might be overwritten.
• Replace a FRU only with another FRU of the correct model. When you replace a FRU, make sure that
the model of the machine and the FRU part number are correct by referring to the FRU parts list.
• A FRU should not be replaced because of a single, unreproducible failure. Single failures can occur
for a variety of reasons that have nothing to do with a hardware defect, such as cosmic radiation,
electrostatic discharge, or software errors. Consider replacing a FRU only when a problem recurs. If you
suspect that a FRU is defective, clear the error log and run the test again. If the error does not recur, do
not replace the FRU.
• Be careful not to replace a nondefective FRU.
What to do first
When you do return a FRU, you must include the following information in the parts exchange form or
parts return form that you attach to it:
• Name and phone number of service technician
• Date of service
• Date on which the machine failed
• Date of purchase
• Failure symptoms, error codes appearing on the display, and beep symptoms
• Procedure index and page number in which the failing FRU was detected
• Failing FRU name and part number
• Machine type, model number, and serial number
• Customer's name and address
Note for warranty: During the warranty period, the customer may be responsible for repair costs if the
computer damage was caused by misuse, accident, modification, unsuitable physical or operating
environment, or improper maintenance by the customer. Following is a list of some common items that
are not covered under warranty and some symptoms that might indicate that the system was subjected
to stress beyond normal use.
© Copyright Lenovo 2011
27
Download from Www.Somanuals.com. All Manuals Search And Download.
Before checking problems with the computer, determine whether the damage is covered under the warranty
by referring to the following list:
The following are not covered under warranty:
• LCD panel cracked from the application of excessive force or from being dropped
• Scratched (cosmetic) parts
• Distortion, deformation, or discoloration of the cosmetic parts
• Plastic parts, latches, pins, or connectors that have been cracked or broken by excessive force
• Damage caused by liquid spilled into the system
• Damage caused by the improper insertion of a PC Card or the installation of an incompatible card
• Improper disc insertion or use of an optical drive
• Diskette drive damage caused by pressure on the diskette drive cover, foreign material in the drive,
or the insertion of a diskette with multiple labels
• Damaged or bent diskette eject button
• Fuses blown by attachment of a nonsupported device
• Forgotten computer password (making the computer unusable)
• Sticky keys caused by spilling a liquid onto the keyboard
• Use of an incorrect ac adapter on laptop products
The following symptoms might indicate damage caused by nonwarranted activities:
• Missing parts might be a symptom of unauthorized service or modification.
• If the spindle of a hard disk drive becomes noisy, it may have been subjected to excessive force,
or dropped.
Checkout guide
Use the following procedures as a guide in identifying and correcting problems with the ThinkPad Notebook.
Note: The diagnostic tests are intended to test only ThinkPad products. The use of non-ThinkPad products,
prototype cards, or modified options can lead to false indications of errors and invalid system responses.
1. Identify the failing symptoms in as much detail as possible.
2. Verify the symptoms. Try to re-create the failure by running the diagnostic test or by repeating the
operation.
Diagnostics using PC-Doctor for DOS
The ThinkPad Notebook has a test program called PC-Doctor for DOS (hereafter called PC-Doctor.) You can
detect errors by running the diagnostics test included in PC-Doctor.
To create the PC-Doctor diagnostic CD, follow the instructions on the Web site.
For some possible configurations of the computer, PC-Doctor might not run correctly. To avoid this problem,
you need to initialize the computer setup by use of the ThinkPad Setup before you run PC-Doctor.
To enter ThinkPad Setup, do as follows:
1. Turn on the computer.
2. When the ThinkPad logo comes up, immediately press F1 to enter the ThinkPad Setup.
Note: If a supervisor password has been set by the customer, ThinkPad Setup menu appears after the
password is entered. You can start ThinkPad Setup by pressing Enter instead of entering the supervisor
password; however, you cannot change the parameters that are protected by the supervisor password.
28 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
On the ThinkPad Setup screen, press F9, Enter, F10, and then Enter.
Note: When you initialize the computer configuration, some devices are disabled, such as the serial port. If
you test one of these devices, you will need to enable it by using Configuration utility for DOS. The utility is
PC-Doctor cannot be used to test a device that is in the docking station, even if the computer supports the
docking station. To test a USB device, connect it to the USB connector of the computer.
Testing the computer
Note: The PC-Doctor diagnostic CD does not support any optical drives connected through USB devices or
any others. It supports only the internal optical drive of the ThinkPad Notebook.
To run the test, do as follows:
1. Turn off the computer.
2. Make sure that the internal optical drive that is supported as a startup device is attached to the computer.
check the power sources.
4. When the ThinkPad logo comes up, immediately press F12 to enter the Boot Menu.
5. Insert the PC-Doctor CD into the internal optical drive.
6. Press cursor keys to select ATAPI CDx (x: 0, 1, ...) and then press Enter.
7. Follow the instructions on the screen.
8. The main panel of PC-Doctor appears.
9. Select Diagnostics with the arrow keys, and press Enter.
Note: You can select an item not only with the arrow keys, but also with the TrackPoint® pointer.
Instead of pressing Enter, click the left button.
A pull-down menu appears. (Its exact form depends on the model.)
Note: PC-Doctor menu does not mean the formal support device list. Some unsupported device names
may appear in the PC-Doctor menu.
Diagnostics
Interactive Tests
Hardware Info
Utility
Quit
F1=Help
Run Normal Test
Run Quick Test
CPU/Coprocessor
System Memory
Systemboard
Video Adapter
Fixed Disks
Diskette Drives
Other Devices
Communication
Wireless LAN
PC-DOCTOR 2.0 Copyright 2008 PC-Doctor, Inc. All Rights Reserved.
Use the cursor keys and ESC to move in menus. Press ENTER to select.
The options on the test menu are as follows:
Chapter 3. General checkout 29
Download from Www.Somanuals.com. All Manuals Search And Download.
Diagnostics
Interactive Tests
• Run Normal Test
• Run Quick Test
• CPU/Coprocessor
• System Memory
• System board
• Video Adapter
• Fixed Disks
• Diskette Drives
• Other Devices
• ThinkPad Devices
• Communication
• Wireless LAN
• Keyboard
• Video
• Internal Speaker
• Mouse
• Diskette
• System Load
• Optical Drive Test
• Intel WLAN Radio Test
Notes:
• In the Keyboard test in Interactive Tests, the Fn key should be held down for at least 2 seconds; otherwise, it
cannot be sensed.
• Video Adapter test supports only the LCD display on the ThinkPad Notebook. If you have an external monitor
attached to your computer, detach it before running PC-Doctor for DOS.
• To test Digital Signature Chip, the security chip must be set to Active.
10. Run the applicable function test.
11. Follow the instructions on the screen. If there is a problem, PC-Doctor shows messages describing it.
12. To exit the test, select Quit — Exit Diag. To cancel the test, press Esc.
Note: After running PC-Doctor, check the time and date on the system and reset them if they are incorrect.
Detecting system information with PC-Doctor
PC-Doctor can detect the following system information:
Hardware Info
• System Configuration
• Memory Contents
• Physical Disk Drives
• VGA Information
• ATA Drive Info
• PCI Information
• SMBIOS Info
• VESA LCD Info
• Hardware Events Log
Utility
• Run Enternal Tests
• Benchmark System
• DOS Shell
• Tech Support Form
• Battery Rundown
• Erase Drive Contents
• View PCDR Host Log
Lenovo ThinkVantage Toolbox
Lenovo ThinkVantage® Toolbox is a diagnostic program that works through the Windows operating system.
It enables you to view symptoms of computer problems and solutions for them, and includes automatic
notification when action is required, computing assistance, advanced diagnostics, and diagnostic history.
30 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Note: The latest Lenovo ThinkVantage Toolbox is available at the following Web site:
http://web.lenovothinkvantagetoolbox.com/
To install the latest Lenovo ThinkVantage Toolbox on the computer, follow the instructions on the Web site.
To run this program, do as follows:
For Windows 7:
While the Windows operating system is running, press the ThinkVantage button.
You can also run this program as the following:
• Click Start ➙ Control Panel ➙ System and Security ➙ Lenovo - System Health and Diagnostics.
For Windows Vista and Windows XP:
Click Start ➙ All Programs ➙ ThinkVantage ➙ Lenovo ThinkVantage Toolbox.
Follow the instructions on the screen. Lenovo ThinkVantage Toolbox also has problem determination aids
that determine software and usage problems.
For additional information about this program, see the Help for the program.
FRU tests
The following table shows the test for each FRU.
Table 1. FRU tests
FRU
Applicable test
System board
1. Diagnostics ➙ CPU/Coprocessor
2. Diagnostics ➙ Systemboard
3. If the docking station or the port replicator is attached to the ThinkPad Notebook,
detach it.
4. Place the computer on a horizontal surface, and run Diagnostics ➙ ThinkPad
Devices ➙ HDD Active Protection Test.
Note: Do not apply any physical shock to the computer while the test is running.
Diagnostics ➙ ThinkPad Devices ➙ AC Adapter, Battery 1 , or Battery2
Power
1. Diagnostics ➙ Video Adapter
2. Interactive Tests ➙ Video
LCD unit
Audio
Enter the ThinkPad Setup and change Serial ATA (SATA) setting to Compatibility, and
run Diagnostics ➙ Other Device ➙ Conexant Audio
Speaker
Interactive Tests ➙ Internal Speaker
Note: Once Audio test is done, the no sound is heard this test. In this case, turn off
and turn on the computer. Then, run this test again.
Keyboard
1. Diagnostics ➙ Systemboard ➙ Keyboard
2. Interactive Tests ➙ Keyboard
Chapter 3. General checkout 31
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 1. FRU tests (continued)
FRU
Applicable test
Hard disk drive or solid state
drive
Enter the ThinkPad Setup and change Serial ATA (SATA) setting to Compatibility, and
run Diagnostics ➙ Fixed Disks
You can also diagnose the drive without starting up the operating system. To diagnose
the drive from the ThinkPad Setup, do as follows:
1. Remove any diskette from the diskette drive, and then turn off the computer.
2. Turn on the computer.
3. While the message, “To interrupt normal startup, press the blue ThinkVangate
button,” is displayed at the lower left of the screen, press F1 to enter the ThinkPad
Setup.
4. Using cursor keys, select HDD diagnostic program. Press enter.
5. Using cursor keys, select Main hard disk drive or Ultrabay hard disk drive.
6. Press Enter to start the diagnostic program.
Diskette drive
Optical drive
Memory
1. Diagnostics ➙ Diskette Drives
2. Interactive Tests ➙ Diskette
1. Diagnostics ➙ Other Devices ➙ Optical Drive
2. Interactive Tests ➙ Optical Drive Test
1. If two DIMMs are installed, remove one of them and run Diagnostics ➙ System
Memory.
2. If the problem does not recur, return the DIMM to its place, remove the other one,
and run the test again.
TrackPoint or pointing
device
If the TrackPoint does not work, check the configuration as specified in the ThinkPad
Setup. If the TrackPoint is disabled, select Automatic to enable it.
After you use the TrackPoint, the pointer may drift on the screen for a short time. This
drift can occur when a slight, steady pressure is applied to the TrackPoint pointer.
This symptom is not a hardware problem. If the pointer stops after a short time, no
service action is necessary.
If enabling the TrackPoint does not correct the problem, continue with the following:
• Interactive Tests ➙ Mouse
Touch Pad
If the Touch Pad does not work, check the configuration as specified in the ThinkPad
Setup. If the Touch Pad is disabled, select Automatic to enable it. If enabling the
Touch Pad does not correct the problem, continue with the following:
• Interactive Tests ➙ Mouse
Power system checkout
To verify a symptom, do the following:
1. Turn off the computer.
2. Remove the battery pack.
3. Connect the ac adapter.
4. Check that power is supplied when you turn on the computer.
5. Turn off the computer.
6. Disconnect the ac adapter and install the charged battery pack.
7. Check that the battery pack supplies power when you turn on the computer.
If you suspect a power problem, see the appropriate one of the following power supply checkouts:
32 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Checking the ac adapter
You are here because the computer fails only when the ac adapter is used.
• If the power problem occurs only when the docking station or the port replicator is used, replace the
docking station or the port replicator.
• If the power-on indicator does not turn on, check the power cord of the ac adapter for correct continuity
and installation.
To check the ac adapter, do the following:
1. Unplug the ac adapter cable from the computer.
2. Measure the output voltage at the plug of the ac adapter cable. See the following figure:
Pin
1
Voltage (V dc)
+20
0
3
2
2
3
Ground
1
(20V)
Note: Output voltage of pin no.2 of the ac adapter may different from the one you are servicing.
3. If the voltage is not correct, replace the ac adapter.
4. If the voltage is acceptable, do the following:
• Replace the system board.
Note: Noise from the ac adapter does not always indicate a defect.
Checking operational charging
To check whether the battery charges properly during operation, use a discharged battery pack or a battery
pack that has less than 50% of the total power remaining when installed in the computer.
Perform operational charging. If the battery status indicator or icon does not turn on, remove the battery
pack and let it return to room temperature. Reinstall the battery pack. If the charge indicator or icon still does
not turn on, replace the battery pack.
If the charge indicator still does not turn on, replace the system board. Then reinstall the battery pack. If it is
still not charged, go to the next section.
Checking the battery pack
Battery charging does not start until the Power Manager Battery Gauge shows that less than 96% of the
total power remains; under this condition the battery pack can charge to 100% of its capacity. This protects
the battery pack from being overcharged or from having a shortened life.
To check your battery, move your cursor to the Power Manager Battery Gauge icon in the icon tray of the
Windows taskbar and wait for a moment (but do not click), and the percentage of battery power remaining
is displayed. To get detailed information about the battery, double-click the Power Manager Battery
Gauge icon.
Chapter 3. General checkout 33
Download from Www.Somanuals.com. All Manuals Search And Download.
Note: If the battery pack becomes hot, it may not be able to charge. Remove it from the computer and leave
it at room temperature for a while. After it cools down, reinstall and recharge it.
To check the battery pack, do the following:
1. Power off the computer.
2. Remove the battery pack and measure the voltage between battery terminals 1 (+) and 7 (-). See the
following figure:
Terminal
Voltage (V dc)
+ 0 to + 12.6
Ground (-)
1
7
7(-)
6(-)
5
4
3
2(+)
1(+)
3. If the voltage is less than +11.0 V dc, the battery pack has been discharged.
Note: Recharging will take at least 3 hours, even if the indicator does not turn on.
If the voltage is still less than +11.0 V dc after recharging, replace the battery.
4. If the voltage is more than +11.0 V dc, measure the resistance between battery terminals 5 and 7.
The resistance must be 4 to 30 K Ω. If the resistance is not correct, replace the battery pack. If the
resistance is correct, replace the system board.
Checking the backup battery
Do the following:
1. Power off the computer, and unplug the ac adapter from it.
2. Turn the computer upside down.
5. Measure the voltage of the backup battery. See the following figure.
Wire
Red
Voltage (V dc)
+2.5 to +3.2
Ground
Black
• If the voltage is correct, replace the system board.
• If the voltage is not correct, replace the backup battery.
• If the backup battery discharges quickly after replacement, replace the system board.
34 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Chapter 4. Related service information
This chapter presents following information:
• Passwords
• Power management
• Symptom-to-FRU index
Service Web site:
When the latest maintenance diskette and the system program service diskette become available, they will
Restoring the factory contents by using Recovery Disc Set
When the hard disk drive (HDD) or solid state drive (SSD) is replaced because of a failure, no product
recovery program is on the new drive. In this case, you must use the Recovery Disc Set for the computer.
Order the Recovery Disc Set and the drive at the same time so that you can recover the new drive with the
pre-installed software when they arrive. For information on which discs to order, see Recovery discs.
The recovery disc set consists of the user instructions and the following set of DVDs to restore the computer
to the original factory configuration.
Operating System Recovery Disc (one disc)
This disc restores the Microsoft® Windows operating system. Use this disc to start the recovery process.
Applications and Drivers Recovery Disc (one or more discs)
This disc restores the preinstalled applications and drivers on the computer.
Supplemental Recovery Disc
This disc contains additional content, such as updates to the software that was preinstalled on the computer.
Not all recovery disc sets come with a Supplemental Recovery Disc.
Notes:
• You must have a DVD drive to use the recovery discs. If you do not have an internal DVD drive, you
can use an external USB DVD drive.
• During the recovery process, all data on the drive will be deleted. If possible, copy any important data
or personal files that you want to keep onto removable media or a network drive before you start the
recovery process.
To restore the computer to the original factory configuration using the recovery disc set, do the following:
Note: Recovery takes several hours. The length of time depends on the method you use. If you use recovery
discs, recovery takes at least five hours.
1. Make the CD/DVD drive the first startup device in the startup sequence using the following procedure:
a. Press and hold down the F1 key, and then turn on the computer. When the logo screen is displayed
or if you hear repeating beeps, release the F1 key. The Setup Utility program opens.
b. Use the arrow keys to select Startup ➙ Boot.
c. Select the CD/DVD drive as the 1st Boot Device.
2. Insert the Operating System Recovery Disc into the DVD drive.
© Copyright Lenovo 2011
35
Download from Www.Somanuals.com. All Manuals Search And Download.
3. Press F10 to save the Setup Utility configuration changes. Follow the instructions on the screen to
begin the recovery process.
4. Select your language and click Next.
5. Read the license. If you agree with the terms and conditions, select I accept these terms and
conditions and then click Next. If you do not agree with the terms and conditions, follow the
instructions on the screen.
6. Click Yes in the displayed window to begin the operating system recovery process.
7. Insert the Applications and Drivers Recovery Disc when prompted and then click OK to begin the
applications and drivers recovery process.
8. If you have a Supplemental Recovery Disc, insert it when prompted and click Yes. If you do not have a
Supplemental Recovery Disc, click No.
9. When all of the data has been copied from the last disc in the set and has been processed, remove the
disc and restart the computer.
Note: The rest of the recovery process is fully automated and no action is required by you. The
computer will restart into the Microsoft Windows desktop several times and you might experience
periods when no activity is apparent on the screen for several minutes at a time. This is normal.
10. When the recovery process is complete, the Set Up Windows screen is displayed. Follow the
instructions on the screen to complete the Windows setup.
11. After you have completed the Windows setup, you might want to restore the original startup sequence.
Start the Setup Utility program and then press F9 to restore the default settings. Press F10 to save and
exit the Setup Utility.
Note: After restoring a drive to the factory default settings, you might need to reinstall some device drivers.
Passwords
As many as three passwords may be needed for any ThinkPad Notebook: the power-on password (POP),
the hard-disk password (HDP), and the supervisor password (SVP).
If any of these passwords has been set, a prompt for it appears on the screen whenever the computer is
turned on. The computer does not start until the password is entered.
Note: If only an SVP is installed, the password prompt does not appear when the operating system is booted.
Power-on password
A power-on password (POP) protects the system from being powered on by an unauthorized person. The
password must be entered before an operating system can be booted. For how to remove the POP, see
Hard-disk password
There are two hard-disk passwords (HDPs):
• User HDP—for the user
• Master HDP—for the system administrator, who can use it to get access to the hard disk even if the user
has changed the user HDP
Note: There are two modes for the HDP: User only and Master + User. The Master + User mode requires
two HDPs; the system administrator enters both in the same operation. The system administrator then
provides the user HDP to the system user.
Attention: If the user HDP has been forgotten, check whether a master HDP has been set. If it has, it can be
used for access to the hard disk drive. If no master HDP is available, neither Lenovo nor Lenovo authorized
36 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
service technicians provide any services to reset either the user or the master HDP, or to recover data from
the hard disk drive. The hard disk drive can be replaced for a scheduled fee.
Supervisor password
A supervisor password (SVP) protects the system information stored in the ThinkPad Setup. The user must
enter the SVP in order to get access to the ThinkPad Setup and change the system configuration.
Attention: If the SVP has been forgotten and cannot be made available to the service technician, there is no
service procedure to reset the password. The system board must be replaced for a scheduled fee.
How to remove the power-on password
(A) If no SVP has been set:
To remove a POP that you have forgotten, do the following:
1. Turn off the computer.
4. Turn on the computer and wait until the POST ends. After the POST ends, the password prompt does
not appear. The POP has been removed.
5. Reinstall the backup battery and the battery pack.
(B) If an SVP has been set and is known by the service technician:
1. Turn on the computer.
2. When the ThinkPad logo comes up, immediately press F1 to enter ThinkPad Setup. When Power-On
Password icon is appearing on the screen, enter the Power-On Password.
3. Type the supervisor password when the system requires it and press enter. The ThinkPad Setup
window opens.
4. Select Security, using the cursor directional keys to move the menu.
5. Select Password.
6. Select Power-On Password.
7. Type the current Power-On Password in the Enter Current Password field. then leave the Enter
New Password field blank, and press Enter twice.
8. In the “Changes have been saved” window, press Enter.
9. Press F10; then, in the Setup confirmation window, select Yes.
How to remove the hard-disk password
Attention: If User only mode is selected and the user HDP has been forgotten and cannot be made
available to the service technician, neither Lenovo nor Lenovo authorized service technicians provide any
services to reset the user HDPs or to recover data from the hard disk drive. The hard disk drive can be
replaced for a scheduled fee.
To remove a user HDP that has been forgotten, when the SVP and the master HDP are known, do the
following:
1. Turn on the computer.
2. When the ThinkPad logo comes up, immediately press F1 to enter ThinkPad Setup. When Power-On
Password icon is appearing on the screen, enter the Power-On Password.
3. Select Security, using the cursor directional keys to move the menu.
Chapter 4. Related service information 37
Download from Www.Somanuals.com. All Manuals Search And Download.
4. Select Password.
5. Select Hard-disk x password, where x is the letter of the hard disk drive. A pop-up window opens.
6. Select Master HDP.
7. Type the current master HDP in the Enter Current Password field. then leave the Enter New Password
field blank, and press Enter twice.
8. Press F10.
9. Select Yes in the Setup Configuration window. Both user HDP and master HDP will have been removed.
Power management
To reduce power consumption, the computer has three power management modes: screen blank, sleep
(standby in Windows XP), and hibernation.
Screen blank mode
If the time set on the “Turn off monitor” timer in the operating system expires, the LCD backlight turns off.
To put the computer into screen blank mode, do as follows:
1. Press Fn+F3. A panel for selecting a power plan (in Windows XP, power scheme) appears.
2. Select Power off display (keep current power plan) (in Windows XP, keep current power scheme).
You can also put the computer into screen blank mode, press ThinkVantage button and use the ThinkVantage
Toolbox.
To end screen blank mode and resume normal operation, press any key.
Sleep (standby) mode
When the computer enters sleep (standby) mode, the following events occur in addition to what occurs
in screen blank mode:
• The LCD is powered off.
• The hard disk drive is powered off.
• The CPU stops.
To enter sleep (standby) mode, press Fn+F4.
Note: You can change the action of the Fn+F4 key combination by changing the settings in Power Manager.
In certain circumstances, the computer goes into sleep (standby) mode automatically:
• If a “suspend time” has been set on the timer, and the user does not do any operation with the keyboard,
the TrackPoint, the hard disk, the parallel connector, or the diskette drive within that time.
• If the battery indicator blinks orange, indicating that the battery power is low.
Note: Even if you do not set the low-battery alarm, the charge indicator notifies you when the battery is low,
and then the computer enters the power-saving mode automatically.
To cause the computer to return from sleep (standby) mode and resume operation, do one of the following:
• Press the Fn key.
• Open the LCD cover.
• Turn on the power switch.
38 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Also, in either of the following events, the computer automatically returns from sleep (standby) mode and
resumes operation:
• The ring indicator (RI) is signaled by a serial device or a PC Card device. ( does not support the ring
indicator (RI) resume by PC Card device.)
• The time set on the resume timer elapses.
Note: The computer does not accept any input immediately after it enters sleep (standby) mode. Wait a
few seconds before taking any action to reenter operation mode.
Hibernation mode
In hibernation mode, the following occurs:
• The system status, RAM, VRAM, and setup data are stored on the hard disk.
• The system is powered off.
Note: If the computer enters the hibernation mode while it is docked to the docking station, do not undock it
before resuming normal operation. If you do undock it and then try to resume normal operation, you will get
an error message, and you will have to restart the system.
To cause the computer to enter hibernation mode, do any of the following:
• Press the Fn+F12 keys.
• If you have defined one of the following actions as the event that causes the system to go into hibernation
mode, perform that action.
– Closing the lid.
– Pressing the power button.
– Pressing Fn+F4 keys.
Also, the computer goes into hibernation mode automatically in either of the following conditions:
• If a “hibernation time” has been set on the timer, and if the user does not do any operation with the
keyboard, the TrackPoint, the hard disk drive, the parallel connector, or the diskette drive within that time.
• If the timer conditions are satisfied in suspend mode.
When the power is turned on, the computer returns from hibernation mode and resumes operation. The
hibernation file in the boot record on the hard disk drive is read, and system status is restored from the
hard disk drive.
Symptom-to-FRU index
This section contains following information:
• LCD-related symptoms
• Intermittent problems
The symptom-to-FRU index in this section lists symptoms and errors and their possible causes. The most
likely cause is listed first, in boldface type.
Chapter 4. Related service information 39
Download from Www.Somanuals.com. All Manuals Search And Download.
Note: Do the FRU replacement or other actions in the sequence shown in the column headed “FRU or
action, in sequence.” If replacing a FRU does not solve the problem, put the original part back in the
computer. Do not replace a nondefective FRU.
This index can also help you determine, during regular servicing, what FRUs are likely to need to be
replaced next.
A numeric error is displayed for each error detected in POST or system operation. In the displays, n can
be any number.
If no numeric code is displayed, check the narrative descriptions of symptoms. If the symptom is not
Note: For a device not supported by diagnostic codes in the ThinkPad Notebooks, see the manual for
that device.
Numeric error codes
Table 2. Numeric error codes
FRU or action, in sequence
System board
Symptom or error
0177
Bad SVP data, stop POST task—The checksum of the
supervisor password in the EEPROM is not correct.
0182
1. Run ThinkPad Setup. Press F9, and Enter to load
the default setting. Then save the current setting
by pressing F10.
Bad CRC2. Enter UEFI BIOS Setup and load Setup
defaults.—The checksum of the CRS2 setting in the
EEPROM is not correct.
2. System board
0183
Bad CRC of Security Settings in EFI Variable. Enter
ThinkPad Setup.
0187
System board
System board
System board
EAIA data access error—The access to EEPROM is failed.
0188
Invalid RFID Serialization Information Area.
0189
Invalid RFID configuration information area—The
EEPROM checksum is not correct.
0190
1. Charge the battery pack.
2. Battery pack
Critical low-battery error
0191
1. Run ThinkPad Setup, and then save current
setting by pressing F10.
System Security—Invalid Remote Change requested.
2. System board
0199
1. Run ThinkPad Setup, and then save the current
setting by pressing F10.
2. System board
System Security— Security password retry count
exceeded.
0251
1. Charge the backup battery for more than 8 hours
by connecting the ac adapter.
2. Replace the backup battery and run ThinkPad Setup
to reset the time and date.
System CMOS checksum bad— Default configuration
used.
0271
Run ThinkPad Setup to reset the time and date.
Real-time clock error. Check date and time settings.
40 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 2. Numeric error codes (continued)
FRU or action, in sequence
Symptom or error
1802
1. Remove Mini PCI network card.
2. System board
Unauthorized network card is plugged in—Turn off and
remove the miniPCI network card.
1820
Remove all but the reader that you set up for the
authentication.
More than one external fingerprint reader is attached.
Power off and remove all but the reader that you set up
within your main operating system.
2000
1. Undock docking station or port replicator if it is
attached to the ThinkPad Notebook.
2. Place the Notebook on a horizontal surface. Do not
apply any physical shock to the computer.
3. Run Diagnostics ➙ ThinkPad Devices ➙ HDD
Active Protection Test.
Hard Drive Active Protection sensor diagnostics failed.
Press <Esc> to continue. Press <F1> to enter SETUP
2100
1. Reseat the hard disk drive.
2. Main hard disk drive
3. System board
Detection error on HDD0 (Main HDD)
2101
1. Reseat the hard disk drive.
2. Ultrabay hard disk drive
3. System board
Detection error on HDD1 (Ultrabay HDD)
2102
1. Reseat the Mini SATA device.
2. Mini SATA device
Detection error on HDD2 (Mini SATA)
3. System board
2110
1. Reseat the hard disk drive.
2. Main hard disk drive
3. System board
Read error on HDD0 (Main HDD)
2111
1. Reseat the hard disk drive.
2. Ultrabay hard disk drive
3. System board
Read error on HDD1 (Ultrabay HDD)
2112
1. Reseat the Mini SATA device.
2. Mini SATA device
Read error on HDD2 (Mini SATA)
3. System board
2200
System board
Machine Type and Serial Number are invalid.
2201
System board
Machine UUID is invalid.
Error messages
Table 3. Error messages
Symptom or error
Fan error.
FRU or action, in sequence
1. Fan
2. Thermal grease
3. System board
Thermal sensing error.
System board
Chapter 4. Related service information 41
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 3. Error messages (continued)
FRU or action, in sequence
Symptom or error
This system does not support batteries that are not
genuine Lenovo-made or authorized. The system will
continue to boot, but may not charge unauthorized
batteries.
Replace the battery.
Attention: Lenovo has no responsibility for the
performance or safety of unauthorized batteries, and
provides no warranties for failures or damage arising out
of their use.
The connected AC adapter has a lower wattage than the
recommended model which was shipped with the system.
This will increase the time to charge the battery, and
system performance will be adjusted to match the
available power.
Charge the ac power adapter.
Please connect the AC adapter which was shipped with
the system for best system performance.
Press the ESC key to continue. Docking station is
removed or its ID is different, press F3 to power off
system and restore correct docking station, press F4 to
normal boot.
Beep symptoms
Table 4. Beep symptoms
FRU or action, in sequence
Symptom or error
One beep and a blank, unreadable, or flashing LCD.
1. Reseat the LCD connector
2. LCD assembly
3. External CRT
4. System board
One long and two short beeps, and a blank or unreadable
LCD.
1. System board
2. LCD assembly
3. DIMM
Two short beeps with error codes.
Two short beeps and a blank screen.
1. System board
2. DIMM
Two or more beeps, or a continuous beep. Operating
system starts successfully.
If a mini-PCI Ethernet card is installed, confirm that Alert
On LAN 2 in ThinkPad Setup is disabled.
Three short beeps, pause, three more short beeps, and
one short beep.
1. DIMM
2. System board
One short beep, pause, three short beeps, pause, three
more short beeps, and one short beep.
Reinstall the operating system.
System board (security chip)
System board
Only the cursor appears.
Four cycles of four short beeps and a blank screen.
Five short beeps and a blank screen.
42 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
No-beep symptoms
Table 5. No-beep symptoms
Symptom or error
FRU or action, in sequence
1. Make sure that every connector is connected
tightly and correctly.
No beep, power-on indicator on, LCD blank, and no
POST.
2. DIMM
3. System board
1. Reseat DIMM.
No beep, power-on indicator on, and LCD blank during
POST.
2. System board
The power-on password prompt appears.
The hard-disk password prompt appears.
A power-on password or a supervisor password is set.
Type the password and press Enter.
A hard-disk password is set. Type the password and
press Enter.
LCD-related symptoms
Important: The TFT LCD for the notebook computer contains many thin-film transistors (TFTs). The
presence of a small number of dots that are missing, discolored, or always lighted is characteristic of TFT
LCD technology, but excessive pixel problems can cause viewing concerns.If the LCD you are servicing has
two or less visible defective pixels, it should not be considered faulty. However, if the LCD has three or more
visible defective pixels, it will be deemed as defective by Lenovo and it should be replaced.
Note:
• This policy applies to all ThinkPad Notebooks purchased on 1 January, 2008 or later.
• Lenovo will not provide replacement if the LCD is within specification as we cannot guarantee that
any replacement LCD will have zero pixel defects.
• One pixel consists of R, G, B sub-pixels.
Table 6. LCD-related symptoms
FRU or action, in sequence
Symptom or error
No beep, power-on indicator on, and a blank LCD during System board
POST.
• LCD backlight not working
• LCD too dark
• LCD brightness cannot be adjusted.
• LCD contrast cannot be adjusted.
1. Reseat the LCD connectors.
2. LCD assembly
3. System board
• LCD screen unreadable
• Characters missing pixels
• Screen abnormal
1. See important note for “LCD-related symptoms.”
2. Reseat all LCD connectors.
3. LCD assembly
• Wrong color displayed
4. System board
Horizontal or vertical lines displayed on LCD
LCD assembly
Intermittent problems
Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardware
defect, such as cosmic radiation, electrostatic discharge, or software errors. FRU replacement should be
considered only when a problem recurs.
When analyzing an intermittent problem, do the following:
1. Run the diagnostic test for the system board in loop mode at least 10 times.
Chapter 4. Related service information 43
Download from Www.Somanuals.com. All Manuals Search And Download.
2. If no error is detected, do not replace any FRUs.
3. If any error is detected, replace the FRU shown by the FRU code. Rerun the test to verify that no
more errors exist.
Undetermined problems
If the diagnostic tests did not identify the adapter or device that has failed, if wrong devices are installed,
or if the system simply is not operating, follow these procedures to isolate the failing FRU (do not isolate
FRUs that have no defects).
Verify that all attached devices are supported by the computer.
Verify that the power supply being used at the time of the failure is operating correctly. (See Power system
1. Turn off the computer.
2. Visually check each FRU for damage. Replace any damaged FRU.
3. Remove or disconnect all of the following devices:
a. Non-ThinkPad devices
b. Devices attached to the docking station or the port replicator
c. Printer, mouse, and other external devices
d. Battery pack
e. Hard disk drive
f. External diskette drive or optical drive
g. DIMM
h. Optical disk or diskette in the internal drive
i. PC Cards
4. Turn on the computer.
5. Determine whether the problem has been solved.
6. If the problem does not recur, reconnect the removed devices one at a time until you find the failing FRU.
7. If the problem remains, replace the following FRUs one at a time (do not replace a nondefective FRU):
a. System board
b. LCD assembly
44 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Chapter 5. Installing and configuring RAID
This chapter presents following information about attaching SATA devices and configuring RAID for the
RAID-supported models in this product.
Note: When the UEFI BIOS was formatted or the system board was replaced in the RAID-supported models,
RAID is enabled by default.
Important notices for setting RAID:
Before you install and configure RAID, make sure of the current RAID setting on the computer you are
servicing.
This product supports either RAID Level 0 (RAID 0) or RAID Level 1 (RAID 1). Confirm the RAID setting
information provided from the customer at first, then proceed with the installation.
Good or non failing drives have to be in HDD bay 0 if you have RAID 1.
• Supported RAID configurations
Supported RAID configurations
The following RAID configurations are supported on ThinkPad W520:
RAID Level 0 (RAID 0) – Striped disk array
Better performance and no fault tolerance.
RAID Level 1 (RAID 1) – Mirrored disk array
Improved read performance and 100% redundancy.
Configuring the system UEFI BIOS to enable embedded SATA RAID
functionality
To configure the UEFI BIOS for RAID, do as follows:
1. Press F1 to enter the ThinkPad Setup menu.
2. Select Config.
3. Select Serial ATA (SATA).
4. Select SATA Controller Mode Option
5. Select RAID
6. Press F10 to save the settings.
Note: SATA Controller Mode Option is recovered to RAID by default. When you use other mode before
load default setting in ThinkPad Setup menu such as F9 key, you have to restore the setting as you like.
Creating RAID volumes
This section describes how to use the Intel® Rapid Storage Technology option ROM Configuration Utility to
create RAID volumes.
© Copyright Lenovo 2011
45
Download from Www.Somanuals.com. All Manuals Search And Download.
To create RAID volumes, do as follows:
1. Turn on the computer.
2. During the startup, when a prompt to press Ctrl+I to enter the Configuration Utility is displayed on the
screen, press and hold the Ctrl key, and press the I key.
3. The screen for Intel Rapid Storage Technology option ROM is displayed. Select “Create RAID Volume”
and press Enter.
4. Using the up and down arrow keys, Tab keys, and Enter key select the RAID level and fill in other fields.
5. Select “Create Volume” by pressing the Enter key. When the dialog box appears, press the Y key.
Attention: All existing data will be erased while the RAID volume is being created.
6. Exit the Configuration Utility.
Deleting RAID volumes
This section describes how to use the Intel Rapid Storage Technology option ROM Configuration Utility to
delete RAID volumes.
To delete RAID volumes, do as follows:
1. Turn on the computer.
2. During the startup, when a prompt to press Ctrl+I to enter the Configuration Utility is displayed on the
screen, press and hold the Ctrl key, and press the I key.
3. The screen for Intel Rapid Storage Technology option ROM is displayed. Select the RAID volume to be
deleted, and press Delete.
4. When prompted, press Y key to confirm the deletion of the selected RAID volume.
5. After deleting a RAID volume, you can:
• Return to step 2 to delete additional RAID volume.
• Use the arrow keys to select Exit and press Enter.
• Use the arrow keys to select Resetting disks to non-RAID, and press Enter.
Attention: If the Serial ATA item in the ThinkPad Setup menu of the computer you are servicing was set to
AHCI when it was manufactured, then to create a RAID array you must first enable RAID in UEFI BIOS, create
RAID volume, and then reinstall the operating system. All data on the hard disks will be erased during this
46 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 7. Status indicators
Indicator
Meaning
1
Speaker mute
The speaker is on mute. To set the
speakers on mute or unmute, press the
speaker mute button.
Orange:
2
3
Microphone mute
Orange:
Green:
The microphone is on mute. None of the
recording devices is available while the
microphone mute is on by default.
Wireless LAN,
Wireless WAN, or
WiMAX status
The wireless LAN feature (the IEEE
802.11 b/g standard, 802.11 a/b/g,
or 802.11n), wireless WAN feature, or
WiMax feature is on, and the radio link
is ready for use.
Blinking green:
Green:
Data is being transmitted.
4
5
Bluetooth wireless
status
The Bluetooth wireless feature is on, and
the radio link is ready for use.
R
Blinking green:
Data is being transmitted.
Device access
Green:
Data is being read from or written to the
hard disk drive, the diskette drive, or the
drive in the Serial Ultrabay Enhanced
device. When this indicator is on, do not
put the computer into sleep (standby)
mode or turn off the computer.
Note: Do not move the system while the green device access light is on. Sudden
physical shock could cause drive errors.
6
7
Power on
The computer is on and ready to use.
This indicator stays lit around the
power-on button whenever the computer
is on and is not in sleep (standby) mode.
Green:
Serial Ultrabay
Enhanced device
status
Green:
A Serial Ultrabay Enhanced device is
installed and in use.
Blinking green:
Turn off:
A Serial Ultrabay Enhanced device is in
the process of being detached.
A Serial Ultrabay Enhanced device is
ready to be attached or detached.
8
Fingerprint reader
status
Green:
The fingerprint reader is ready to swipe.
Blinking green:
The fingerprint is being authenticated or
has been authenticated.
Blinking orange:
The fingerprint could not be
authenticated.
48 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 7. Status indicators (continued)
Indicator
Meaning
9
Caps lock
Green:
Caps Lock mode is enabled. To enable
or disable Caps Lock mode, press the
Caps Lock key.
10
11
Sleep (standby for
Windows XP) status
Green:
The computer is in sleep (standby) mode.
Blinking green:
The computer is entering sleep (standby)
mode or hibernation mode, or is
resuming normal operation.
Battery status
Green:
The battery has more than 20% charge.
Orange:
The battery has between 5% and 20%
charge.
Fast blinking orange:
Slow blinking orange:
Slow blinking green:
The battery has less than 5% charge.
Note: The battery may be charging.
The battery is being charged. When it
reaches 20%, the blinking color changes
to green.
The battery has between 20% and 80%
charge, and charging is continuing.
When the battery reaches 80% charge,
blinking stops, but the charging may
continue until the battery is 100%
charged.
Note: If the computer is operating
on battery power, the battery status
indicator does not work while the
computer is turned off or is in sleep
(standby) mode or hibernation mode.
An error has been occurred in the battery.
Quick blinking orange:
The battery status indicator is off:
The battery pack of the computer is
detached.
12
Color sensor status
Green:
Calibration is complete. When the lid is
opened, the indicator turns off.
Blinking green:
Display colors are being calibrated.
Chapter 6. Status indicators 49
Download from Www.Somanuals.com. All Manuals Search And Download.
50 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Chapter 7. Fn key combinations
The following table shows the function of each combination of Fn with a function key.
Table 8. Fn key combinations
Key combination
Fn+F1
Description
Reserved.
Fn+F2
Lock the computer.
Fn+F3
Select a power plan (in Windows XP, power scheme) that has been created by Power Manager,
or adjust the power level by using the slider control. When you press this combination, a
panel for selecting a power plan (power scheme) appears.
Notes:
To use this combination of the keys, ThinkPad PM device driver must have been installed
on the computer.
If you have logged on with an administrator user ID in Windows XP, and you press Fn+F3,
the panel for selecting a power scheme appears. If you have logged on with another user
ID in Windows XP, and you press Fn+F3, the panel does not appear.
Fn+F4
Put the computer in sleep (standby) mode. To return to normal operation, press the Fn key
only, without pressing a function key.
Notes:
To use this combination of the keys, ThinkPad PM device driver must have been installed
on the computer.
If you want to use the combination to put the computer into hibernation mode or
do-nothing mode (in Windows XP, shut the computer down or show the panel for turning
off the computer), change the settings in the Power Manager.
Fn+F5
Enable or disable the built-in wireless networking features. If you press Fn+F5, a list of wireless
features is displayed. You can quickly change the power state of each feature in the list.
Notes: If you want to use Fn+F5 to enable or disable the wireless features, the following
device drivers must be installed on the computer beforehand:
• Power Management driver
• OnScreen Display Utility
• Wireless device drivers
Fn+F6
Fn+F7
Change the camera and audio settings. When you press Fn+F6, the camera and audio setting
window is opened and the camera preview is turned on.
Note: The camera settings area only appears if the computer has an integrated camera.
Apply a presentation scheme directly, with no need to start Presentation Director.
To disable this function and use the Fn+F7 key combination for switching a display output
location, start Presentation Director, and change the settings.
Note: If the computer is an Windows 7 model, it does not support presentation schemes,
however the Fn+F7 combination might still be used to switch display output location.
© Copyright Lenovo 2011
51
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 8. Fn key combinations (continued)
Key combination
Description
Fn+F7
For Windows 7:
Switch between the computer display and an external monitor. Windows will show these
display options:
• Computer display only (LCD)
• Computer display and external monitor (same image)
• Computer display and external monitor (extended desktop function)
• External monitor only
Note: To switch between the computer display and an external monitor, the Win+P key
combination is also available.
For Windows Vista and Windows XP:
Switch between the computer display and an external monitor. If an external monitor is
attached, computer output is displayed in the following three patterns by turns:
• External monitor (CRT display)
• Computer display and external monitor (LCD + CRT display)
• Computer display (LCD)
Notes:
• This function is not supported if different desktop images are displayed on the computer
display and the external monitor (the Extend desktop function).
• This function does not work while a DVD movie or a video clip is playing.
• As for ThinkPad W520 models, the CRT connector does not work in the DOS environment
at NVIDIA Optimus mode or Integrated Graphics mode, you need to change to Discrete
Graphics mode to turn on the CRT monitor. If there is no display to change the ThinkPad
Setup setting, press F7 to switch to the Discrete Graphics mode right after power-on.
To enable this function, start Presentation Director, and change the settings.
Note: Multiple users can log on to a single operating system by using different user IDs. Each
user needs to do the following: Click Start ➙ All Programs ➙ ThinkVantage ➙ Presentation
Director, and change the Fn+F7 settings.
Fn+F8
Change the settings of the UltraNav® pointing device.
Fn+F9
Reserved.
Reserved.
Reserved.
Fn+F10
Fn+F11
Fn+F12
Put the computer into hibernation mode. To return to normal operation, press the power
button for less than four seconds.
Notes:
To use this combination of the keys, ThinkPad PM device driver must have been installed
on the computer.
Though the screen fades out immediately after Fn+F12 are pressed, the computer
does not enter the hibernation mode immediately. Do not move the system until the
sleep (standby) status indicator stops blinking. Moving the computer when it is entering
hibernation might cause corruption of the hard disk drive.
Fn+PgUp
Turn the ThinkLight® on or off.
Note: This function is supported only on the ThinkPad Notebooks that have the ThinkLight.
The on or off status of the ThinkLight is shown on the screen for a few seconds when you
press Fn+PgUp.
52 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 8. Fn key combinations (continued)
Key combination
Description
Fn+Home
The computer display becomes brighter.
The purpose of this method is to change the brightness level temporarily. On Windows Vista,
the default brightness level is loaded after sleep (standby), hibernation, reboot, or detaching or
attaching an ac adapter. To change the default brightness level, change the settings of the
Power Option in the Control Panel or use the Power Manager.
Fn+End
The computer display becomes dimmer.
The purpose of this method is to change the brightness level temporarily. On Windows Vista,
the default brightness level is loaded after sleep (standby), hibernation, reboot, or detaching or
attaching an ac adapter. To change the default brightness level, change the settings of the
Power Option in the Control Panel or use the Power Manager.
Fn+Spacebar
Fn+PrtSc
Enable the FullScreen Magnifier function.
Have the same function as the SysRq key.
Fn+ScrLk
Enable or disable the numeric keypad. The indicator of numeric lock will be displayed on
the screen.
Fn+Pause
Have the same function as the Break key.
Fn+cursor keys
These key combinations work with Windows Media Player. They have the following functions:
• Fn + down arrow key: Play or Pause
• Fn + up arrow key: Stop
• Fn + right arrow key: Next Track
• Fn + left arrow key: Previous Track
Chapter 7. Fn key combinations 53
Download from Www.Somanuals.com. All Manuals Search And Download.
54 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Chapter 8. FRU replacement notices
This chapter presents notices related to removing and replacing parts. Read this chapter carefully before
replacing any FRU.
Screw notices
Loose screws can cause a reliability problem. In the ThinkPad Notebook, this problem is addressed with
special nylon-coated screws that have the following characteristics:
• They maintain tight connections.
• They do not easily come loose, even with shock or vibration.
• They are harder to tighten.
• Each one should be used only once.
Do the following when you service this machine:
• Always use new screws.
• Use a torque screwdriver if you have one.
Tighten screws as follows:
• Plastic to plastic
Turn an additional 90 degrees after the screw head touches the surface of the plastic part:
• Logic card to plastic
Turn an additional 180 degrees after the screw head touches the surface of the logic card:
• Torque driver
If you have a torque driver, refer to the “Torque” column for each step.
– Make sure that you use the correct screw. If you have a torque screwdriver, tighten all screws firmly
to the torque shown in the table. Never use a screw that you removed. Use a new one. Make
sure that all of the screws are tightened firmly.
– Ensure torque screw drivers are calibrated correctly following country specifications.
© Copyright Lenovo 2011
55
Download from Www.Somanuals.com. All Manuals Search And Download.
Retaining serial numbers
This section includes the following descriptions:
Restoring the serial number of the system unit
When the computer was manufactured, the EEPROM on the system board was loaded with the serial
numbers of the system and all major components. These numbers need to remain the same throughout
the life of the computer.
If you replace the system board, you must restore the serial number of the system unit to its original value.
Before replacing the system board, save the original serial number by doing the following:
1. Install the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later, and restart the
computer.
2. From the main menu, select 1. Set System Identification.
3. Select 2. Read S/N data from EEPROM.
The serial number of each device in your computer is displayed; the serial number of the system unit is
listed as follows:
• 20: Serial number
Write down that number.
Note: The serial number of the system unit is also written on the label attached to the bottom of the computer.
After you have replaced the system board, restore the serial number by doing the following:
1. Install the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later and restart the
computer.
2. From the main menu, select 1. Set System Identification.
3. Select 1. Add S/N data from EEPROM. Follow the instructions on the screen.
If the MTM and Product ID numbers differ from each other on the rear label, use what is shown for the
Product ID field. See example below:
MTM on rear label:
TTTT-CTO S/N SSSSSSS
Product ID on rear label:
TTTT-MMM (Use this number when setting Serial Number)
In the example, the Serial Number to be input is '1STTTTMMMSSSSSSS'.
Retaining the UUID
The Universally Unique Identifier (UUID) is a 128-bit number uniquely assigned to your computer at
production and stored in the EEPROM of your system board.
The algorithm that generates the number is designed to provide unique IDs until the year A.D. 3400. No two
computers in the world have the same number.
56 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
When you replace the system board, you must set the UUID on the new system board as follows:
1. Install the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later, and restart the
computer.
2. From the main menu, select 4. Assign UUID. A new UUID is created and written. If a valid UUID already
exists, it is not overwritten.
Reading or writing the ECA information
Information on Engineering Change Announcements (ECA) are stored in the EEPROM of the system board.
The electronic storage of this information simplifies the procedure to check if the ECA has been previously
applied to a machine. The machine does not need to be disassembled to check for the ECA application.
To check what ECAs have been previously applied to the machine, use the ECA Information Read/Write
function on the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later.
1. Insert the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later, and restart the
computer.
2. From the main menu, select 6. Set ECA Information.
3. To read ECA information, select 2. Read ECA/rework number from EEPROM and follow the
instruction.
4. To read box build date, select 5. Read box build date from EEPROM, and follow the instruction on
the screen.
After an ECA has been applied to the machine, the EEPROM must be updated to reflect the ECA's
application. Use the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later to update the
EEPROM.
Note: Only the ECA number is stored in the EEPROM. The machine type of the ECA is assumed be the same
as the machine type of the machine that had the ECA applied to it.
1. Insert the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later, and restart the
computer.
2. From the main menu, select 6. Set ECA Information.
3. To write ECA information, select 1. Write ECA/rework number from EEPROM, and follow the
instruction.
4. To write box build date, select 4. Write box build date from EEPROM, and follow the instruction on
the screen.
If the system board is being replaced, try to read the ECA information from the old system board and transfer
the information to the new system. If the system board is inoperable, this will not be possible.
Chapter 8. FRU replacement notices 57
Download from Www.Somanuals.com. All Manuals Search And Download.
58 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Chapter 9. Removing and replacing a FRU
This chapter presents directions and drawings for use in removing and replacing a FRU. Be sure to observe
the following general rules:
1. Do not try to service any computer unless you have been trained and certified. An untrained person runs
the risk of damaging parts.
3. Begin by removing any FRUs that have to be removed before the failing FRU. Any such FRUs are listed
at the top of the page. Remove them in the order in which they are listed.
4. Follow the correct sequence in the steps for removing the FRU, as given in the drawings by the
numbers in square callouts.
5. When turning a screw to replace a FRU, turn it in the direction as given by the arrow in the drawing.
6. When removing the FRU, move it in the direction as given by the arrow in the drawing.
7. To put the new FRU in place, reverse the removal procedure and follow any notes that pertain to
replacement. For information about connecting and arranging internal cables, see Locations.
8. When replacing a FRU, use the correct screw as shown in the procedures.
DANGER
Before removing any FRU, turn off the computer, unplug all power cords from electrical outlets,
remove the battery pack, and then disconnect any interconnecting cables.
Attention: After replacing a FRU, do not turn on the computer until you have made sure that all screws,
springs, and other small parts are in place and none are loose inside the computer. Verify this by shaking
the computer gently and listening for rattling sounds. Metallic parts or metal flakes can cause electrical
short circuits.
Attention: The system board is sensitive to, and can be damaged by, electrostatic discharge. Before
touching it, establish personal grounding by touching a ground point with one hand or by using an
electrostatic discharge (ESD) strap (P/N 6405959).
© Copyright Lenovo 2011
59
Download from Www.Somanuals.com. All Manuals Search And Download.
Before servicing ThinkPad T520, T520i, and W520
Table 9. Removal steps of SIM card
Some models of the ThinkPad T520, T520i, and W520 you are servicing might have the SIM card that the customer
has installed.
If the computer you are servicing has the SIM card, remove it before you start the servicing.
After you finish the servicing, make sure that you insert the card back into the slot firmly.
1010 Battery pack
Important notice for replacing a battery pack:
ThinkVantage Toolbox have an automatic battery diagnostic that determines if the battery pack is defective.
A battery pack FRU should not be replaced unless this diagnostic shows that the battery is defective.
The only exception to this is if the battery pack is physically damaged or a customer is reporting a possible
safety issue.
If ThinkVantage Toolbox is not installed in the computer, the customer should download this program
before a non-physically damaged battery pack is replaced. Note that a physically damaged battery pack
is non-warranty replacement.
Table 10. Removal steps of battery pack
DANGER
Use only the battery specified in the parts list for your computer. Any other battery could ignite or explode.
Unlock the battery latch 1 . Holding the battery latch in the unlocked position 2 , remove the battery pack in
the direction shown by arrow 3 .
60 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 10. Removal steps of battery pack (continued)
1
2
3
When installing: Install the battery pack in the slot, and then make sure that the battery latch is in the locked position.
1020 Serial Ultrabay Enhanced device or travel bezel
For access, remove this FRU:
Table 11. Removal steps of Serial Ultrabay Enhanced device or travel bezel
Holding the bay lock latch in the unlocked position 1 , slide the bay eject latch 2 , and then pull out the Serial
Ultrabay Enhanced device or the travel bezel in the direction shown by arrow 3 .
Chapter 9. Removing and replacing a FRU 61
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 11. Removal steps of Serial Ultrabay Enhanced device or travel bezel (continued)
1
2
3
1030 DIMM slot cover
For access, remove this FRU:
Table 12. Removal steps of DIMM slot cover
Note: Loosen the screws 1 , but do not remove them.
62 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 13. Removal steps of DIMM (bottom slot)
For ThinkPad T520 and T520i:
1
2
1
64 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 13. Removal steps of DIMM (bottom slot) (continued)
For ThinkPad W520:
a
b
1
2
1
Note: If only one DIMM is used on the computer you are servicing, the card must be installed in SLOT-0 a , but
not in SLOT-2 b .
When installing: Insert the notched end of the DIMM into the socket. Press the DIMM firmly, and pivot it until it
snaps into the place. Make sure that it is firmly fixed in the slot and does not move easily.
1050 Hard disk drive slot cover, hard disk drive (HDD) and HDD rubber
rails or solid state drive (SSD) and storage converter
For access, remove this FRU:
Attention:
• Do not drop the drive or apply any physical shock to it. The drive is sensitive to physical shock.
Improper handling can cause damage and permanent loss of data.
• Before removing the drive, have the user make a backup copy of all the information on it if possible.
• Never remove the drive while the system is operating or is in suspend mode.
Chapter 9. Removing and replacing a FRU 65
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 14. Removal steps of hard disk drive slot cover, HDD and HDD rubber rails or SSD and storage converter
Note: Loosen the screw 1 , but do not remove it.
1
2
3
Table 15. Removal steps of HDD and HDD rubber rails
4
4
66 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 16. Removal steps of SSD and SSD spacers
4
4
When installing: Make sure that the SSD connector or HDD connector is attached firmly.
1060 Keyboard
For access, remove these FRUs in order:
Table 17. Removal steps of keyboard
1
1
Torque
Step
Screw (quantity)
Color
1
Black
0.181 Nm
M2 × 14 mm, wafer-head, nylon-coated (2)
(1.85 kgfcm)
Chapter 9. Removing and replacing a FRU 67
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 17. Removal steps of keyboard (continued)
1. Push down the keyboard a little toward the arrow 2 until the front edge of the keyboard is detached from
the keyboard bezel.
2
2. Lift the keyboard a little in the direction shown by arrow 3 , and then detach the connector 4 .
3
4
When installing the keyboard, do as follows:
68 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 18. Installation steps of keyboard
1. Attach the keyboard connector 1 .
1
2. Attach the keyboard so that the keyboard edges a are under the frame as shown in this figure.
a
a
Chapter 9. Removing and replacing a FRU 69
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 18. Installation steps of keyboard (continued)
3. Gently press the keys with your thumbs and try to slide the keyboard toward you.
4. Make sure that the front side of the keyboard ( b ) is housed firmly.
b
b
b
5. Secure the keyboard by tightening the screws from the bottom side of the computer.
1070 DIMM (upper slot)
For access, remove these FRUs in order:
70 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 19. Removal steps of DIMM (upper slot)
1
2
1
Note: For ThinkPad W520, if only one DIMM is used on the computer you are servicing, the card must be installed in
SLOT-0 a , but not in SLOT-2 b .
a
b
When installing: Insert the notched end of the DIMM into the socket. Press the DIMM firmly, and pivot it until it
snaps into the place. Make sure that it is firmly fixed in the slot and does not move easily.
1080 PCI Express Mini Card for wireless LAN
For access, remove these FRUs in order:
Chapter 9. Removing and replacing a FRU 71
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 20. Removal steps of PCI Express Mini Card for wireless LAN
In step 1 , unplug the jacks by using the antenna RF connector removal tool (P/N: 08K7159) or pick the connectors
with your fingers and gently unplug them in direction of the arrow.
Note: Some models might have only two antenna cables in step 1 .
1
1
1
2
3
Torque
Step
Screw (quantity)
Color
2
0.181 Nm
M2 × 3 mm, wafer-head, nylon-coated (1)
Silver
(1.85 kgfcm)
72 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 20. Removal steps of PCI Express Mini Card for wireless LAN (continued)
4
When installing:
• In models with wireless LAN card that has two antenna connectors, plug the gray cable into the jack labeled
MAIN or M, and the black cable into the jack labeled AUX or A on the card. If the computer you are servicing has
three cables, put the white cable in the cable protection tube as shown in this figure.
• In models with wireless LAN card that has three antenna connectors, plug the gray cable (MAIN) into the jack
labeled TR1, the white cable (3rd) into jack labeled RO or TR3, and the black cable (AUX) into jack labeled
TR2 on the card.
1090 PCI Express Mini Card for wireless WAN or mSATA solid state drive
For access, remove these FRUs in order:
Note: WWAN card and mSATA solid state drive are exclusive to each other.
Chapter 9. Removing and replacing a FRU 73
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 21. Removal steps of PCI Express Mini Card for wireless WAN
In step 1 , unplug the jacks by using the antenna RF connector removal tool (P/N: 08K7159) or pick the connectors
with your fingers and gently unplug them in direction of the arrow.
1
1
2
3
Torque
Step
Screw (quantity)
Color
2
0.181 Nm
M2 × 3 mm, wafer-head, nylon-coated (1)
Silver
(1.85 kgfcm)
74 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 21. Removal steps of PCI Express Mini Card for wireless WAN (continued)
4
Note: Plug the orange cable into the jack labeled MAIN, and the blue cable into the jack labeled AUX on the card.
If your computer is equipped with an mSATA solid state drive, follow the below removal steps.
Attention:
• Do not drop the drive or apply any physical shock to it. The drive is sensitive to physical shock. Improper
handling can cause damage and permanent loss of data.
• Before removing the drive, have the user make a backup copy of all the information on it if possible.
• Never remove the drive while the system is operating or is in suspend mode.
Table 22. Removal steps of mSATA
1
2
Torque
Step
Screw (quantity)
Color
2
0.181 Nm
M2 × 3 mm, wafer-head, nylon-coated (1)
Silver
(1.85 kgfcm)
Chapter 9. Removing and replacing a FRU 75
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 22. Removal steps of mSATA (continued)
3
1100 Keyboard bezel assembly
For access, remove these FRUs in order:
Attention: Before removing the keyboard bezel assembly, make sure that you have removed ExpressCard
blank bezel or any card in the slot.
Table 23. Removal steps of ExpressCard blank bezel or ExpressCard
When you press the ExpressCard blank bezel or ExpressCard 1 , it pops out 2 .
1
2
76 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 23. Removal steps of ExpressCard blank bezel or ExpressCard (continued)
When installing: Make sure that the bezel or the card is correctly oriented as shown in this figure.
Table 24. Removal steps of keyboard bezel assembly
Note: The speaker assembly is attached to the keyboard bezel.
2
2
1
1
1
2
2
2
1
Torque
Step
Screw (quantity)
Color
1
Black
0.181 Nm
M2 × 4 mm, bind-head, nylon-coated (4)
(1.85 kgfcm)
2
Black
0.181 Nm
M2 × 14 mm, bind-head, nylon-coated (7)
(1.85 kgfcm)
Chapter 9. Removing and replacing a FRU 77
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 25. Removal steps of BDC-3.0
1
2
Torque
Step
Screw (quantity)
Color
1
0.181 Nm
M2 × 3 mm, wafer-head, nylon-coated (1)
Silver
(1.85 kgfcm)
When installing: Make sure that the connector is attached firmly.
1120 Backup battery
For access, remove these FRUs in order:
DANGER
Use only the battery specified in the parts list for your computer. Any other battery could ignite
or explode.
Chapter 9. Removing and replacing a FRU 79
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 26. Removal steps of backup battery
2
1
When installing: Make sure that the battery connector is attached firmly.
1130 Smart Card or Smart Card dummy spacer
For access, remove these FRUs in order:
80 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 27. Removal steps of Smart Card
3
3
4
1
2
Torque
Step
Screw (quantity)
Color
3
0.181 Nm
M2 × 3 mm, wafer-head, nylon-coated (3)
Silver
(1.85 kgfcm)
5
6
5
Chapter 9. Removing and replacing a FRU 81
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 28. Removal steps of dummy card and spacer
3
1
1
2
Torque
Step
Screw (quantity)
Color
1
0.181 Nm
M2 × 3 mm, wafer-head, nylon-coated (3)
Silver
(1.85 kgfcm)
1140 Speaker assembly
For access, remove these FRUs in order:
82 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 29. Removal steps of speaker assembly
2
1
1
3
2
1
1
Torque
Step
Screw (quantity)
Color
1
0.181 Nm
M2 × 3 mm, wafer-head, nylon-coated (4)
Silver
(1.85 kgfcm)
5
4
4
4
4
5
5
5
5
4
When installing: Make sure that the speaker connector is attached firmly. Then route the cables and secure
them properly as shown in the figure above.
Chapter 9. Removing and replacing a FRU 83
Download from Www.Somanuals.com. All Manuals Search And Download.
1150 Thermal module
For access, remove these FRUs in order:
Table 30. Removal steps of thermal module
1
When installing: Make sure that the connectors are attached firmly.
Note: Loosen the screws 3a to 3d in order, but do not remove them. Some models do not have screws 4 .
For those models, skip step 4 .
2
4
4
3a
3d
3c
3b
84 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 30. Removal steps of thermal module (continued)
6
When installing: Before you attach the fan assembly to the computer, apply thermal grease, at an amount of 0.2
grams, on the parts marked a as in the following figures. Either too much or too less application of grease can
cause a thermal problem due to imperfect contact with a component. For the new CPU thermal device/fan, you
need to peel the thin film off from the rubbers marked b .
For Switchable Graphics models:
a
b
b
a
b
Chapter 9. Removing and replacing a FRU 85
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 30. Removal steps of thermal module (continued)
For Integrated Graphics models:
a
For Workstation models:
a
a
1160 CPU
For access, remove these FRUs in order:
Attention: CPU is extremely sensitive. When you service the CPU, avoid any kind of rough handling.
86 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 31. Removal steps of CPU
Rotate the head of the screw in the direction shown by arrow 1 to release the lock; then remove the CPU 2 .
2
1
a
When installing: Place the CPU on the CPU socket, and then rotate the head of the screw in the direction shown
by arrow a to secure the CPU.
1170 LCD unit
For access, remove these FRUs in order:
• 1050 Hard disk drive slot cover, hard disk drive (HDD) and HDD rubber rails or solid state drive (SSD)
Chapter 9. Removing and replacing a FRU 87
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 32. Removal steps of LCD unit
2
1
2
1
Torque
Step
Screw cap
Screw (quantity)
Color
1
Black
0.392 Nm
M2.5 × 6 mm, wafer-head, nylon-coated (2)
(4.0 kgfcm)
2
—
Black
0.392 Nm
M2.5 × 6 mm, wafer-head, nylon-coated (2)
(4.0 kgfcm)
3
3
Torque
Step
Screw (quantity)
Color
3
Black
0.392 Nm
M2.5 × 6 mm, wafer-head, nylon-coated (2)
(4.0 kgfcm)
88 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 32. Removal steps of LCD unit (continued)
7
7
9
8
6
4
4
5
5
4
Torque
Step
Screw (quantity)
M2 × 4 mm, wafer-head, nylon-coated (2)
Color
7
Black
0.181 Nm
(1.85 kgfcm)
When installing:
• Make sure that you attach the LCD connector firmly.
• Make sure that you route the cables firmly and tape up in the proper positions as shown in this figure.
• When you route the cables, make sure that they are not subjected to any tension. Tension could cause the cables
to be damaged by the cable guides, or a wire to be broken.
Chapter 9. Removing and replacing a FRU 89
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 32. Removal steps of LCD unit (continued)
10
10
1180 Base cover assembly
For access, remove these FRUs in order:
• 1050 Hard disk drive slot cover, hard disk drive (HDD) and HDD rubber rails or solid state drive (SSD)
90 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 33. Removal steps of base cover assembly
3
1
2
2
Torque
Step
Screw (quantity)
Color
1
0.181 Nm
M2 × 3 mm, wafer-head, nylon-coated (1)
Silver
(1.85 kgfcm)
2
3
Black
Black
0.181 Nm
(1.85 kgfcm)
M2 × 14 mm, wafer-head, nylon-coated (2)
M2 × 4 mm, wafer-head, nylon-coated (1)
0.181 Nm
(1.85 kgfcm)
5
4
Note: Applying labels to the base cover
The new base cover FRU is shipped with a kit containing labels of several kinds. When you replace the
base cover, you need to apply the following labels:
13
FCC label
14
Serial number label
15
Homologation label
Following labels need to be peeled off from the old base cover, and need to be put on the new base cover.
1
Windows license label (COA)
2
Information label
3
IMEI barcode label
Chapter 9. Removing and replacing a FRU 91
Download from Www.Somanuals.com. All Manuals Search And Download.
4
Mac address label
5
Vodafone label
6
Israel label
7
Modem label (only for PRC models)
China wireless WAN label
Modem AMOM label (only for Brazil)
Bluetooth label (only for Brazil)
Wireless card label (only for Brazil)
SIRIM label
8
9
10
11
12
16
Asset tag label
For some models, you also need to apply one or two FCC labels. Check the old base cover; if it has one or
two FCC labels, find duplicates of them in the label kit and apply them to the new base cover.
For the location of each label, refer the following figure:
1
2
4
3
16
15
2005, 2010
5
14
13
12
11
10
9
8
7
6
1190 I/O sub card
Note: The I/O sub card contains an Ethernet port and a USB port.
For access, remove these FRUs in order:
• 1050 Hard disk drive slot cover, hard disk drive (HDD) and HDD rubber rails or solid state drive (SSD)
92 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 34. Removal steps of I/O sub card
1
1
2
Torque
Step
Screw (quantity)
Color
1
0.181 Nm
M2 × 7 mm, wafer-head, nylon-coated (2)
Silver
(1.85 kgfcm)
When installing: Make sure that the connector is attached firmly.
1200 System board assembly, magnesium structure frame, and modem
daughter card (MDC)
Note: The system board does not contain the Ethernet port, the ac power connector, and the modem port.
structure frame. If the computer is equipped with an MDC, the modem port is also installed on the
magnesium structure frame.
For access, remove these FRUs in order:
• 1050 Hard disk drive slot cover, hard disk drive (HDD) and HDD rubber rails or solid state drive (SSD)
Chapter 9. Removing and replacing a FRU 93
Download from Www.Somanuals.com. All Manuals Search And Download.
Important notices for RAID setting:
Before you replace the system board, make sure that you read Installing and configuring RAID, and have the
necessary information. After you replaced the system board, RAID mode is recovered as default. To confirm
the SATA mode setting, you can see the setting in ThinkPad Setup menu as follows:
Config ➙ Serial ATA (SATA) ➙ SATA Controller Mode Option ➙ RAID/Compatibility/AHCI
Important notices for handling the system board:
When handling the system board, bear the following in mind.
• The system board has an accelerometer, which can be broken by applying several thousands of G-forces.
Note: Dropping a system board from a height of as little as 6 inches so that it falls flat on a hard bench can subject
the accelerometer to as much as 6,000 G's of shock.
• Be careful not to drop the system board on a bench top that has a hard surface, such as metal, wood, or composite.
• If a system board is dropped, you must test it, using PC-Doctor for DOS, to make sure that the HDD Active
Protection still functions (see below).
Note: If the test shows that HDD Active Protection is not functioning, be sure to document the drop in any reject
report, and replace the system board.
• Avoid rough handling of any kind.
• At every point in the process, be sure not to drop or stack the system board.
• If you put a system board down, be sure to put it only on a padded surface such as an ESD mat or conductive
corrugated material.
After replacing the system board, run PC-Doctor for DOS to make sure that HDD Active Protection still functions. The
procedure is as follows:
1. Place the computer on a horizontal surface.
2. Run Diagnostics ➙ ThinkPad Devices ➙ HDD Active Protection Test.
Attention: Do not apply physical shock to the computer while the test is running.
Table 35. Location of major sensitive components on the system board
Following components soldered on the top side of the system board are extremely sensitive. When you service
the system board, avoid any kind of rough handling.
a
CPU
b
Accelerometer chip for the HDD Active Protection System™
c
PCH (Platform Controller Hub)
d
Graphics
Note: d (Graphics) is only for the Switchable Graphics models and Workstation models. The system
board in Integrated Graphics models does not have this chip.
94 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 35. Location of major sensitive components on the system board (continued)
For Integrated Graphics models:
a
b
c
For Switchable Graphics models:
a
d
b
c
For Workstation models:
a
d
b
c
Chapter 9. Removing and replacing a FRU 95
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 36. Removal steps of system board and magnesium structure frame
2
4
2
3
1
1
Torque
Step
Screw (quantity)
Color
1
0.392 Nm
Hex stud, nylon-coated (2)
Silver
(4.0 kgfcm)
2
3
0.181 Nm
(1.85 kgfcm)
M2 × 7 mm, wafer-head, nylon-coated (2)
M2 × 3 mm, wafer-head, nylon-coated (1)
Silver
Silver
0.181 Nm
(1.85 kgfcm)
When installing When you replace the system board, attach thermal rubbers as shown in this figure. Depending on
the models you are servicing, the number of thermal rubbers are different. Check the thermal rubbers on the old
system board, and find duplicates of them in the new FRU package and apply them to the new system board.
b
a
c
d
96 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 37. Removal steps of MDC
Note: Only some selected models are installed with a MDC.
Torque
Step
Screw (quantity)
Color
1
0.181 Nm
M2 × 3 mm, wafer-head, nylon-coated (2)
Silver
(1.85 kgfcm)
2010 LCD bezel assembly
For access, remove this FRU:
Table 38. Removal steps of LCD bezel assembly
1
1
1
Torque
Step
Screw cap
Screw (quantity)
M2.5 × 6 mm, wafer-head, nylon-coated (3)
Color
1
Black
0.392 Nm
(4.0 kgfcm)
Chapter 9. Removing and replacing a FRU 97
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 38. Removal steps of LCD bezel assembly (continued)
2
2
2
2
2
2
2
2
3
When installing: Make sure that all the latches are attached firmly.
2020 LED sub card
For access, remove these FRUs in order:
Table 39. Removal steps of LED sub card
Note: Some models do not have connector 1a .
2
1a
1
When installing: Make sure that the connectors are attached firmly and the card is installed as shown in this figure.
98 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
2030 Integrated camera
For access, remove these FRUs in order:
Table 40. Removal steps of integrated camera
1
3
2
Torque
Step
Screw (quantity)
Color
Silver
1
0.181 Nm
M2 × 3 mm, wafer-head, nylon-coated (1)
(1.85 kgfcm)
When installling: Make sure that the connector of the integrated camera is attached firmly.
2040 LCD cable, camera cable, LCD panel, and hinges
For access, remove these FRUs in order:
• 1050 Hard disk drive slot cover, hard disk drive (HDD) and HDD rubber rails or solid state drive (SSD)
Chapter 9. Removing and replacing a FRU 99
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 41. Removal steps of LCD cable, camera cable, LCD panel, and hinges
In step 1 , release the antenna cables from the left and right hinges.
1
1
2
2
2
2
Torque
Step
Screw (quantity)
M2.5 × 6 mm, wafer-head, nylon-coated (4)
Color
2
Black
0.392 Nm
(4.0 kgfcm)
When installing: When attaching the LCD panel to the cover, press the left and right edges covered with metal
gently with your fingers. DO NOT press the surface of the panel or apply any excessive force to the panel.
100 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 41. Removal steps of LCD cable, camera cable, LCD panel, and hinges (continued)
3
4
5
5
5
6
7
8
When installing: Make sure that the LCD cable connector is attached firmly.
Chapter 9. Removing and replacing a FRU 101
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 41. Removal steps of LCD cable, camera cable, LCD panel, and hinges (continued)
9
10
9
9
10
9
Torque
Step
Screw (quantity)
Color
9
0.181 Nm
M2 × 3 mm, wafer-head, nylon-coated (4)
Silver
(1.85 kgfcm)
2050 Antenna kit and LCD rear cover assembly
For access, remove these FRUs in order:
• 1050 Hard disk drive slot cover, hard disk drive (HDD) and HDD rubber rails or solid state drive (SSD)
Table 42. Removal steps of antenna kit and LCD rear cover assembly
3
1
3
2
3
2
3
2
2
1
102 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 42. Removal steps of antenna kit and LCD rear cover assembly (continued)
Cable routing: When you install the antenna kit, route the cables as shown in the figures below. As you route the
cables, make sure that they are not subjected to any tension. Tension could cause the cables to be damaged by
the cable guides, or a wire to be broken.
a : Wireless WAN antenna, AUX (blue)
b : Wireless LAN antenna, AUX (black)
c : Wireless LAN antenna, 3rd (white)
d : Wireless LAN antenna, MAIN (gray)
e : Wireless WAN MAIN (orange)
a
b
c
d
e
Chapter 9. Removing and replacing a FRU 103
Download from Www.Somanuals.com. All Manuals Search And Download.
104 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Chapter 10. Locations
This chapter presents the location of ThinkPad T520, T520i, and W520 features and hardware.
Front view
1
Status indicators
2
Built-in microphone
3
Integrated camera (for some models)
4
ThinkLight
5
Power switch
6
Security keyhole
7
RJ-45 (Ethernet) connector
8
Built-in stereo speakers
9
Serial Ultrabay Enhanced drive or travel bezel
10
Combo audio jack
11
Media Card Reader slot
12
ExpressCard slot
13
Fingerprint reader (for some models)
14
Color sensor (for ThinkPad W520)
15
Touch pad buttons
16
Touch pad
17
TrackPoint buttons
18
TrackPoint pointing stick
19
UltraNav
20
ThinkVantage button
21
Volume control buttons
© Copyright Lenovo 2011
105
Download from Www.Somanuals.com. All Manuals Search And Download.
1
2
3
4
2
21
8
20
18
17
5
6
16
19
7
15
8
14
9
13
10
12
11
Rear view
1
Status indicators
Smart Card slot (for some models)
Wireless radio switch
2
3
4
IEEE 1394 connector
5
USB/eSATA combo connector (for some models)
Universal serial bus (USB) connectors
External monitor connector
6
7
8
DisplayPort
9
AC power connector
10
11
RJ-11 (modem) connector (for some models)
USB connector
106 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
1
2
11
3
10
4
5
6
9
7
8
Bottom view
1
Battery pack
2
3
4
5
6
7
8
Battery pack latch
Docking connector
Solid state drive (SSD) or hard disk drive (HDD) slot
DIMM slot (bottom)
LCD cover latch
Serial Ultrabay Enhanced lock latch
Serial Ultrabay Enhanced eject latch
1
8
7
2
3
6
5
4
Chapter 10. Locations 107
Download from Www.Somanuals.com. All Manuals Search And Download.
108 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Chapter 11. Parts list
This chapter contains following lists of the service parts.
• Overall
• LCD FRUs
• Keyboard
• Recovery discs
Notes:
• Each FRU is available for all types or models, unless specific types or models are specified.
• FRU with specific models listed and described as xxU (where U is an example of a country designator)
should be used for all models ending in U.
• FRU with specific models listed and described as 3Dx (where 3D is an example of a unique configuration)
should be used for all of these models, unless specific country or region designator is specified.
• A CRU (customer replaceable unit) is identified by a single asterisk (*) or two asterisks (**) in the CRU ID
column. An N in the CRU ID column means that the part is not a CRU. A single asterisk (*) means that the
part is a Self-service CRU; two asterisks (**) means that the part is an Optional-service CRU.ThinkPad
Notebooks contain the following types of CRUs:
Self-service CRUs
These CRUs unplug or are held by no more than two screws. Examples of these types of CRUs include
the ac power adapter, power cord, battery, and hard disk drive. Other Self-service CRUs depending on
product design may include the memory module, wireless card, and keyboard.
Optional-service CRUs
These CRUs are isolated parts within the computer that are concealed by an access panel that is typically
secured by more than two screws. Once the access panel is removed, the specific CRU is visible.
• FRUs marked with OP are available as options.
© Copyright Lenovo 2011
109
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall
No.
FRU no.
FRU (Overall)
CRU
ID
a -
d
LCD unit (see LCD FRUs.)
1
2
04W1365
N
Palmrest assembly, no-Fingerprint Reader (FPR), no-Color Sensor (CS), with SmartCard
Reader
• 4239-CTO, 22x, 4Cx
• 4240-CTO
• 4241-CTO
• 4242-CTO, 3Ex, 3Fx, 3Gx, 58x, 59x
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO, 2Ux, 2Vx, 4Bx
• 4284-CTO, 4Bx
2
2
04W1366
04W1367
N
N
Palmrest assembly, no FPR, CS, with SmartCard Reader
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO, 45x
• 4284-CTO
Palmrest assembly, FPR, no-CS, with SmartCard Reader
• 4239-CTO, 25x, 2Zx, 32x, 33x, 3Nx
• 4240-CTO, 2Ux, 2Vx, 2Xx, 2Yx, 47x
• 4241-CTO
• 4242-CTO, 2Ex, 2Fx, 2Lx, 2Vx, 3Jx, 3Kx, 3Lx, 3Qx, 44x, 4Ex, 4Fx, 4Gx, 4Hx, 4Qx
• 4243-CTO, 3Wx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 24x, 25x
• 4281-CTO
• 4282-CTO, 28x, 29x, 2Ax, 2Yx, 2Zx, 32x, 3Qx, 4Cx
• 4284-CTO, 4Cx, 4Dx
2
04W1368
N
Palmrest assembly, FPR, CS, with SmartCard Reader
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 23x, 2Rx, 2Sx, 2Tx, 36x
• 4281-CTO
• 4282-CTO, 2Bx, 2Cx, 33x, 3Kx, 3Lx, 3Px, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x
• 4284-CTO, 48x
Chapter 11. Parts list 111
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
2
04W1369
N
Palmrest assembly, FPR, no-CS, no-SmartCard Reader
• 4239-CTO, 23x, 24x, 26x, 27x, 28x, 34x, 35x, 36x, 37x, 38x, 39x, 3Ax, 42x, 43x, 44x,
45x, 48x, 49x, 4Ax, 4Bx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx,
2Tx, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx,
3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 46x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx,
4Jx, 4Kx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x
• 4242-CTO, 23x, 24x, 25x, 28x, 2Ax, 2Bx, 2Cx, 2Dx, 2Jx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx,
2Tx, 2Ux, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x, 3Ax, 3Bx, 3Cx, 3Dx, 3Hx,
3Nx, 3Px, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Dx, 4Mx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx,
4Xx, 4Yx, 4Zx, 52x, 53x, 54x, 55x, 56x, 57x
• 4243-CTO, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Xx, 3Yx, 3Zx, 4Bx, 4Jx, 4Kx, 4Ux, 4Vx, 4Wx, 4Xx,
4Yx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 27x, 28x, 29x, 2Vx, 2Wx, 34x, 35x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 2Fx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Qx, 2Rx, 2Tx, 2Xx, 36x, 37x, 38x,
3Bx, 3Cx, 3Dx, 3Fx, 3Gx, 3Rx, 3Sx
• 4284-CTO, 45x, 46x, 47x, 4Ax
3
3
4
5
04W1571
04W1572
02K7078
60Y3257
N
N
N
**
Speaker assembly
Speaker assembly
Backup battery
Gobi 3000 wireless WAN adapter
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
112 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
5
60Y3283
**
**
**
Gobi 3000 wireless WAN adapter for Malaysia SKU
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
5
60Y3279
Ericsson F5521gw Other – Wireless WAN card
• 4239-CTO, 34x
• 4240-CTO, 2Ax, 2Jx, 2Lx, 2Nx, 2Qx, 2Sx, 2Vx, 3Px, 3Qx, 4Cx
• 4241-CTO
• 4242-CTO, 2Qx, 2Rx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 34x, 35x, 36x, 3Cx, 3Dx, 4Dx
• 4243-CTO, 3Rx, 3Tx, 3Ux, 3Vx, 3Xx, 3Zx, 4Bx, 4Xx, 4Yx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 27x, 28x, 29x, 2Kx, 2Lx, 2Mx, 2Nx
• 4281-CTO
• 4282-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Rx, 2Tx, 2Zx, 33x, 34x, 3Bx, 3Gx, 3Hx
• 4284-CTO, 43x, 49x, 4Dx
5
60Y3267
Ericsson F5521gw Other – Wireless WAN card for Malaysia
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
Chapter 11. Parts list 113
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
5
45N8259
**
mSATA solid state drive, 80GB
• 4239-CTO
• 4240-CTO, 4Kx, 4Lx
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 24x, 2Ax
• 4281-CTO
• 4282-CTO, 2Yx, 3Jx, 3Xx, 3Yx, 3Zx, 42x
• 4284-CTO
6
6
60Y3241
60Y3247
**
**
Intel® Centrino® Wireless-N 1000
• 4239-CTO, 47x, 48x, 49x, 4Bx
• 4240-CTO, 3Vx, 3Wx, 3Zx, 4Bx, 4Cx, 4Dx, 4Mx, 4Nx
• 4241-CTO, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 4Qx
• 4243-CTO
• 4244-CTO
• 4246-CTO
ThinkPad 1x1 b/g/n Wireless LAN Mini-PCI Express Adapter II
• 4239-CTO, 27x, 28x, 2Zx, 32x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Nx, 44x
• 4240-CTO, 2Cx, 2Ex, 2Yx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx
• 4241-CTO, 42x, 43x
• 4242-CTO, 2Dx, 3Ax, 3Bx, 3Ex, 3Fx, 3Gx, 47x, 48x
• 4243-CTO, 3Sx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 33x, 34x, 35x
• 4281-CTO
• 4282-CTO
• 4284-CTO
114 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
6
60Y3253
**
Intel Centrino Advanced-N 6205
• 4239-CTO, 22x, 23x, 24x, 25x, 34x, 42x, 43x, 45x, 46x, 4Ax, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Dx, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx,
2Sx, 2Tx, 2Ux, 2Vx, 2Xx, 3Cx, 3Dx, 3Mx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Xx, 3Yx, 46x,
47x, 48x, 49x, 4Ax, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx, 4Px, 4Qx
• 4241-CTO, 26x
• 4242-CTO, 22x, 23x, 24x, 25x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx,
2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Tx, 2Ux, 2Vx, 2Wx, 2Yx, 2Zx, 32x, 33x, 34x, 35x, 36x,
37x, 38x, 39x, 3Cx, 3Dx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 44x, 45x, 46x, 49x, 4Ax,
4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Mx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x, 53x,
55x, 56x, 57x, 58x, 59x
• 4243-CTO, 27x, 28x, 29x, 3Rx, 3Wx, 3Xx, 3Yx, 4Bx, 4Ux, 4Vx, 4Wx, 4Yx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 23x, 24x, 25x, 27x, 28x, 29x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx,
2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 36x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx,
2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 32x, 35x, 36x, 37x, 38x, 3Bx, 3Cx, 3Dx, 3Ex, 3Px, 3Qx,
3Rx, 3Sx, 3Ux, 4Bx, 4Cx
• 4284-CTO, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 48x, 4Bx, 4Cx
6
60Y3233
**
Intel Centrino Advanced-N 6300
• 4239-CTO, 26x, 33x
• 4240-CTO
• 4241-CTO
• 4242-CTO, 2Rx, 2Sx, 2Xx, 3Qx, 54x
• 4243-CTO, 3Tx, 3Ux, 3Vx, 3Zx, 4Jx, 4Kx, 4Xx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x, 2Ax, 2Sx, 2Tx, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx
• 4281-CTO
• 4282-CTO, 23x, 24x, 2Bx, 2Cx, 2Nx, 2Px, 2Qx, 2Rx, 2Yx, 2Zx, 33x, 34x, 3Fx, 3Gx, 3Hx,
3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Tx, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 45x
• 4284-CTO, 23x, 24x, 43x, 45x, 46x, 47x, 49x, 4Ax, 4Dx
6
60Y3195
**
Intel Centrino Advanced-N + WiMAX 6250
• 4239-CTO
• 4240-CTO, 3Bx
• 4241-CTO
• 4242-CTO, 4Rx
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
Chapter 11. Parts list 115
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
6
60Y3209
**
Intel Centrino Advanced-N + WiMAX 6250, Russia SKU
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
7
75Y5117
*
DVD-ROM drive
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
116 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
7
75Y5115
*
DVD-RAM/RW drive
• 4239-CTO, 22x, 23x, 24x, 25x, 26x, 27x, 28x, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x, 39x,
3Ax, 3Nx, 42x, 43x, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Bx, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px,
2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Xx, 2Yx, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx,
3Lx, 3Mx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 46x, 47x, 48x, 49x,
4Ax, 4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x,
33x, 34x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px,
3Qx, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Mx, 4Qx, 4Rx,
4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x, 53x, 54x, 55x, 56x, 57x, 58x, 59x
• 4243-CTO, 27x, 28x, 29x, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Jx, 4Kx,
4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 22x, 23x, 24x, 25x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 33x, 34x,
35x, 36x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx,
2Kx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 34x, 35x, 36x,
37x, 38x, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 3Rx,
3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 45x, 4Bx, 4Cx
• 4284-CTO, 23x, 24x, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 43x, 45x, 46x,
47x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx
Chapter 11. Parts list 117
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
7
75Y5113
*
DVD-RAM/RW drive
• 4239-CTO, 22x, 23x, 24x, 25x, 26x, 27x, 28x, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x, 39x,
3Ax, 3Nx, 42x, 43x, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Bx, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px,
2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Xx, 2Yx, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx,
3Lx, 3Mx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 46x, 47x, 48x, 49x,
4Ax, 4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x,
33x, 34x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px,
3Qx, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Mx, 4Qx, 4Rx,
4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x, 53x, 54x, 55x, 56x, 57x, 58x, 59x
• 4243-CTO, 27x, 28x, 29x, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Jx, 4Kx,
4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 22x, 23x, 24x, 25x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 33x, 34x,
35x, 36x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx,
2Kx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 34x, 35x, 36x,
37x, 38x, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 3Rx,
3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 45x, 4Bx, 4Cx
• 4284-CTO, 23x, 24x, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 43x, 45x, 46x,
47x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx
118 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
7
75Y5111
*
DVD-RAM/RW drive
• 4239-CTO, 22x, 23x, 24x, 25x, 26x, 27x, 28x, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x, 39x,
3Ax, 3Nx, 42x, 43x, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Bx, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px,
2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Xx, 2Yx, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx,
3Lx, 3Mx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 46x, 47x, 48x, 49x,
4Ax, 4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x,
33x, 34x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px,
3Qx, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Mx, 4Qx, 4Rx,
4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x, 53x, 54x, 55x, 56x, 57x, 58x, 59x
• 4243-CTO, 27x, 28x, 29x, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Jx, 4Kx,
4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 22x, 23x, 24x, 25x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 33x, 34x,
35x, 36x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx,
2Kx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 34x, 35x, 36x,
37x, 38x, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 3Rx,
3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 45x, 4Bx, 4Cx
• 4284-CTO, 23x, 24x, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 43x, 45x, 46x,
47x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx
7
7
60Y5513
60Y5512
*
*
RAID adapter for workstation models
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO, 2Cx, 2Lx, 2Mx, 33x, 3Zx, 42x
• 4284-CTO
Travel bezel
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO, 3Ex, 3Fx, 3Gx
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
Chapter 11. Parts list 119
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
8
55Y3715
**
1-GB DDR3-1333 SDRAM SO-DIMM card
• 4239-CTO, 2Zx
• 4240-CTO, 2Xx, 3Gx, 3Zx
• 4241-CTO, 46x
• 4242-CTO, 4Zx, 52x
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 25x
• 4281-CTO
• 4282-CTO
• 4284-CTO
8
55Y3716
**
2-GB DDR3-1333 SDRAM SO-DIMM card
• 4239-CTO, 22x, 23x, 25x, 27x, 28x, 2Zx, 32x, 33x, 35x, 36x, 48x, 49x, 4Bx
• 4240-CTO, 2Bx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx,
2Xx, 2Yx, 3Bx, 3Cx, 3Gx, 3Hx, 3Mx, 3Sx, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Cx, 4Dx, 4Mx,
4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 23x, 27x, 28x, 29x, 2Bx, 2Cx, 2Dx, 2Hx, 2Px, 2Qx, 2Rx, 39x, 3Ax, 3Bx, 3Cx,
3Dx, 3Mx, 3Nx, 3Px, 44x, 45x, 46x, 4Mx, 4Qx, 4Rx, 4Sx, 4Xx, 4Zx, 52x, 56x, 57x
• 4243-CTO, 27x, 28x, 29x, 3Sx, 3Xx, 3Yx, 4Yx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x, 24x, 25x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx,
2Rx, 2Vx
• 4281-CTO
• 4282-CTO, 25x, 2Vx, 2Wx, 3Cx, 3Hx, 3Ux
• 4284-CTO, 25x, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 43x, 45x
120 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
8
55Y3717
**
4-GB DDR3-1333 SDRAM SO-DIMM card
• 4239-CTO, 24x, 26x, 34x, 37x, 38x, 39x, 3Ax, 3Nx, 42x, 43x, 44x, 45x, 46x, 47x, 4Ax, 4Cx
• 4240-CTO, 29x, 2Ax, 2Cx, 2Dx, 2Ux, 2Vx, 3Dx, 3Ex, 3Fx, 3Jx, 3Kx, 3Lx, 3Px, 3Qx, 3Rx,
3Tx, 3Ux, 46x, 47x, 48x, 49x, 4Ax, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx
• 4241-CTO
• 4242-CTO, 22x, 24x, 25x, 2Ax, 2Ex, 2Fx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Sx, 2Tx, 2Ux,
2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx,
3Lx, 3Qx, 47x, 48x, 49x, 4Ax, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Tx, 4Ux, 4Vx, 4Wx, 4Yx,
53x, 54x, 55x, 58x, 59x
• 4243-CTO, 3Rx, 3Tx, 3Ux, 3Vx, 3Wx, 3Zx, 4Bx, 4Jx, 4Kx, 4Ux, 4Vx, 4Wx, 4Xx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 22x, 23x, 27x, 28x, 29x, 2Ax, 2Px, 2Qx, 2Sx, 2Tx, 2Wx, 2Xx, 2Yx, 2Zx, 33x,
34x, 35x, 36x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx,
2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x, 35x, 36x,
37x, 38x, 3Bx, 3Dx, 3Ex, 3Fx, 3Gx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx,
3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 45x, 4Bx, 4Cx
• 4284-CTO, 23x, 24x, 26x, 46x, 47x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx
8
9
DIMM dummy card for workstation models
04W1395 **
04W1563
42T4883
N
*
I/O sub card (contains a USB port and an Ethernet port)
10
Battery pack, Li-ion (4 cell)
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
10
42T4885
*
Battery pack, Li-ion (4 cell)
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
Chapter 11. Parts list 121
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
10
42T4791
*
Battery pack, Li-ion (6 cell)
• 4239-CTO, 22x, 25x, 27x, 28x, 2Zx, 32x, 33x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Nx, 42x, 43x,
44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Bx, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx,
2Rx, 2Sx, 2Tx, 2Xx, 2Yx, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Px,
3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 4Ax, 4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx,
4Kx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx,
2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x,
35x, 36x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px,
44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Ex, 4Fx, 4Gx, 4Hx, 4Mx, 4Qx, 4Rx, 4Sx, 4Tx,
4Wx, 4Xx, 4Yx, 4Zx, 52x, 56x, 57x
• 4243-CTO, 29x, 3Rx, 3Sx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Jx, 4Kx, 4Wx, 4Yx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x, 24x, 25x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx,
2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 34x, 35x
• 4281-CTO
• 4282-CTO, 27x, 2Dx, 2Ex, 2Sx, 3Cx, 3Dx, 3Ex, 3Lx, 3Px, 3Qx, 3Tx, 3Ux, 3Vx, 3Wx
• 4284-CTO, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 46x, 47x, 48x
10
42T4793
*
Battery pack, Li-ion (6 cell)
• 4239-CTO, 22x, 25x, 27x, 28x, 2Zx, 32x, 33x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Nx, 42x, 43x,
44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Bx, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx,
2Rx, 2Sx, 2Tx, 2Xx, 2Yx, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Px,
3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 4Ax, 4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx,
4Kx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx,
2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x,
35x, 36x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px,
44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Ex, 4Fx, 4Gx, 4Hx, 4Mx, 4Qx, 4Rx, 4Sx, 4Tx,
4Wx, 4Xx, 4Yx, 4Zx, 52x, 56x, 57x
• 4243-CTO, 29x, 3Rx, 3Sx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Jx, 4Kx, 4Wx, 4Yx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x, 24x, 25x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx,
2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 34x, 35x
• 4281-CTO
• 4282-CTO, 27x, 2Dx, 2Ex, 2Sx, 3Cx, 3Dx, 3Ex, 3Lx, 3Px, 3Qx, 3Tx, 3Ux, 3Vx, 3Wx
• 4284-CTO, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 46x, 47x, 48x
122 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
10
42T4795
*
Battery pack, Li-ion (6 cell)
• 4239-CTO, 22x, 25x, 27x, 28x, 2Zx, 32x, 33x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Nx, 42x, 43x,
44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Bx, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx,
2Rx, 2Sx, 2Tx, 2Xx, 2Yx, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Px,
3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 4Ax, 4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx,
4Kx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx,
2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x,
35x, 36x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px,
44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Ex, 4Fx, 4Gx, 4Hx, 4Mx, 4Qx, 4Rx, 4Sx, 4Tx,
4Wx, 4Xx, 4Yx, 4Zx, 52x, 56x, 57x
• 4243-CTO, 29x, 3Rx, 3Sx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Jx, 4Kx, 4Wx, 4Yx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x, 24x, 25x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx,
2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 34x, 35x
• 4281-CTO
• 4282-CTO, 27x, 2Dx, 2Ex, 2Sx, 3Cx, 3Dx, 3Ex, 3Lx, 3Px, 3Qx, 3Tx, 3Ux, 3Vx, 3Wx
• 4284-CTO, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 46x, 47x, 48x
10
42T4911
*
Battery pack, Li-ion (6 cell)
• 4239-CTO, 22x, 25x, 27x, 28x, 2Zx, 32x, 33x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Nx, 42x, 43x,
44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Bx, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx,
2Rx, 2Sx, 2Tx, 2Xx, 2Yx, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Px,
3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 4Ax, 4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx,
4Kx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx,
2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x,
35x, 36x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px,
44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Ex, 4Fx, 4Gx, 4Hx, 4Mx, 4Qx, 4Rx, 4Sx, 4Tx,
4Wx, 4Xx, 4Yx, 4Zx, 52x, 56x, 57x
• 4243-CTO, 29x, 3Rx, 3Sx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Jx, 4Kx, 4Wx, 4Yx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x, 24x, 25x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx,
2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 34x, 35x
• 4281-CTO
• 4282-CTO, 27x, 2Dx, 2Ex, 2Sx, 3Cx, 3Dx, 3Ex, 3Lx, 3Px, 3Qx, 3Tx, 3Ux, 3Vx, 3Wx
• 4284-CTO, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 46x, 47x, 48x
Chapter 11. Parts list 123
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
10
42T4817
*
*
*
Battery pack, Li-ion (6 cell)
• 4239-CTO
• 4240-CTO, 46x, 47x
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
10
42T4819
Battery pack, Li-ion (6 cell)
• 4239-CTO
• 4240-CTO, 46x, 47x
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
10
42T4799
Battery pack, Li-ion (9 cell)
• 4239-CTO, 23x, 24x, 26x, 34x
• 4240-CTO, 2Hx, 2Ux, 2Vx, 48x, 49x, 4Hx, 4Jx
• 4241-CTO
• 4242-CTO, 27x, 28x, 37x, 38x, 3Qx, 4Dx, 4Ux, 4Vx, 53x, 54x, 55x, 58x, 59x
• 4243-CTO, 27x, 28x, 3Tx, 3Ux, 3Vx, 4Ux, 4Vx, 4Xx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 23x, 27x, 28x, 29x, 2Ax, 2Px, 2Qx, 2Xx, 2Yx, 2Zx, 33x, 36x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 25x, 26x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx,
2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x,
38x, 3Bx, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Mx, 3Nx, 3Rx, 3Sx, 3Xx, 3Yx, 3Zx, 42x, 45x, 4Bx, 4Cx
• 4284-CTO, 23x, 24x, 25x, 26x, 43x, 45x, 49x, 4Ax, 4Bx, 4Cx, 4Dx
124 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
10
42T4801
*
Battery pack, Li-ion (9 cell)
• 4239-CTO, 23x, 24x, 26x, 34x
• 4240-CTO, 2Hx, 2Ux, 2Vx, 48x, 49x, 4Hx, 4Jx
• 4241-CTO
• 4242-CTO, 27x, 28x, 37x, 38x, 3Qx, 4Dx, 4Ux, 4Vx, 53x, 54x, 55x, 58x, 59x
• 4243-CTO, 27x, 28x, 3Tx, 3Ux, 3Vx, 4Ux, 4Vx, 4Xx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 23x, 27x, 28x, 29x, 2Ax, 2Px, 2Qx, 2Xx, 2Yx, 2Zx, 33x, 36x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 25x, 26x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx,
2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x,
38x, 3Bx, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Mx, 3Nx, 3Rx, 3Sx, 3Xx, 3Yx, 3Zx, 42x, 45x, 4Bx, 4Cx
• 4284-CTO, 23x, 24x, 25x, 26x, 43x, 45x, 49x, 4Ax, 4Bx, 4Cx, 4Dx
10
42T4803
*
Battery pack, Li-ion (9 cell)
• 4239-CTO, 23x, 24x, 26x, 34x
• 4240-CTO, 2Hx, 2Ux, 2Vx, 48x, 49x, 4Hx, 4Jx
• 4241-CTO
• 4242-CTO, 27x, 28x, 37x, 38x, 3Qx, 4Dx, 4Ux, 4Vx, 53x, 54x, 55x, 58x, 59x
• 4243-CTO, 27x, 28x, 3Tx, 3Ux, 3Vx, 4Ux, 4Vx, 4Xx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 23x, 27x, 28x, 29x, 2Ax, 2Px, 2Qx, 2Xx, 2Yx, 2Zx, 33x, 36x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 25x, 26x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx,
2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x,
38x, 3Bx, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Mx, 3Nx, 3Rx, 3Sx, 3Xx, 3Yx, 3Zx, 42x, 45x, 4Bx, 4Cx
• 4284-CTO, 23x, 24x, 25x, 26x, 43x, 45x, 49x, 4Ax, 4Bx, 4Cx, 4Dx
11 Base cover assembly, integrated
04W1587
N
• 4239-CTO, 22x, 25x, 27x, 28x, 2Zx, 35x, 3Nx, 46x, 47x, 48x, 49x, 4Bx, 4Cx
• 4240-CTO, 29x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Sx, 2Tx, 2Xx, 3Bx,
3Cx, 3Hx, 3Jx, 3Lx, 3Mx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Zx, 46x, 4Ax, 4Bx, 4Dx, 4Ex,
4Kx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 47x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Px, 2Qx,
2Rx, 2Zx, 32x, 34x, 39x, 3Ax, 3Bx, 3Cx, 3Ex, 3Fx, 3Hx, 3Kx, 3Mx, 3Nx, 3Px, 44x, 45x, 47x,
48x, 4Ax, 4Ex, 4Qx, 4Rx, 4Sx, 4Wx, 56x, 57x, 58x
• 4243-CTO, 29x, 3Rx, 3Sx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Wx, 4Yx
• 4244-CTO
• 4246-CTO
Chapter 11. Parts list 125
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
11 Base cover assembly, discrete
04W1673
N
• 4239-CTO, 23x, 24x, 26x, 32x, 33x, 34x, 36x, 37x, 38x, 39x, 3Ax, 42x, 43x, 44x, 45x, 4Ax
• 4240-CTO, 2Ax, 2Hx, 2Nx, 2Px, 2Qx, 2Rx, 2Ux, 2Vx, 2Yx, 3Dx, 3Ex, 3Fx, 3Gx, 3Kx, 3Px,
3Qx, 3Xx, 3Yx, 47x, 48x, 49x, 4Cx, 4Fx, 4Gx, 4Hx, 4Jx, 4Lx
• 4241-CTO, 43x, 44x, 45x, 46x
• 4242-CTO, 27x, 28x, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 33x,
35x, 36x, 37x, 38x, 3Dx, 3Gx, 3Jx, 3Lx, 3Qx, 46x, 49x, 4Cx, 4Dx, 4Fx, 4Gx, 4Hx, 4Mx, 4Tx,
4Ux, 4Vx, 4Xx, 4Yx, 4Zx, 52x, 53x, 54x, 55x, 59x
• 4243-CTO, 27x, 28x, 3Tx, 3Ux, 3Vx, 4Jx, 4Kx, 4Ux, 4Vx, 4Xx, 5Ax
• 4244-CTO
• 4246-CTO
11 Base cover assembly, workstation
04W1588
N
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 22x, 23x, 24x, 25x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 33x, 34x,
35x, 36x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x,
33x, 34x, 35x, 36x, 37x, 38x, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx,
3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 45x, 4Bx, 4Cx
• 4284-CTO, 23x, 24x, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 43x, 45x, 46x,
47x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx
11 Base cover assembly for Taiwan 65W
• 4239-CTO
04W1589
04W1590
04W1591
N
N
N
• 4240-CTO, 2Kx, 2Mx, 2Tx
• 4241-CTO
• 4242-CTO, 29x, 4Wx
• 4243-CTO, 29x, 4Wx
• 4244-CTO
• 4246-CTO
11 Base cover assembly for Taiwan 90W
• 4239-CTO
• 4240-CTO, 2Px, 2Rx, 2Yx
• 4241-CTO
• 4242-CTO, 27x, 28x, 4Ux, 4Vx
• 4243-CTO, 27x, 28x, 4Ux, 4Vx
• 4244-CTO
• 4246-CTO
11 Base cover assembly for Taiwan 135W
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
126 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
11 Base cover assembly for Taiwan 170W
• 4249-CTO
04W1592
N
• 4260-CTO
• 4270-CTO
• 4276-CTO, 2Ex, 2Dx, 2Cx, 2Bx
• 4281-CTO
• 4282-CTO, 23x, 24x, 25x, 26x, 4Bx, 4Cx
• 4284-CTO, 23x, 24x, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Wx, 4Bx, 4Cx
12 DIMM slot cover
60Y5501
60Y5500
41V9756
**
**
**
13 Hard disk drive cover
14 HDD rubber rails
14 7.0 mm HDD rubber rails for 9.5 mm bay
04W1640 **
04W1641 **
14
15
7.0 mm SSD spacer rails for 9.5 mm bay
45N7217
**
SATA hard disk drive, 250 GB, 5,400 rpm
• 4239-CTO, 34x
• 4240-CTO, 3Zx
• 4241-CTO, 47x
• 4242-CTO
• 4243-CTO, 3Rx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO, 2Dx, 2Ux, 2Vx, 2Wx
• 4284-CTO
15
42T1153
**
SATA hard disk drive, 250 GB, 5,400 rpm
• 4239-CTO, 34x
• 4240-CTO, 3Zx
• 4241-CTO, 47x
• 4242-CTO
• 4243-CTO, 3Rx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO, 2Dx, 2Ux, 2Vx, 2Wx
• 4284-CTO
Chapter 11. Parts list 127
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
15
45N7229
**
**
**
SATA hard disk drive, 250 GB, 5,400 rpm
• 4239-CTO, 34x
• 4240-CTO, 3Zx
• 4241-CTO, 47x
• 4242-CTO
• 4243-CTO, 3Rx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO, 2Dx, 2Ux, 2Vx, 2Wx
• 4284-CTO
15
42T1167
SATA hard disk drive, 250 GB, 5,400 rpm
• 4239-CTO, 34x
• 4240-CTO, 3Zx
• 4241-CTO, 47x
• 4242-CTO
• 4243-CTO, 3Rx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO, 2Dx, 2Ux, 2Vx, 2Wx
• 4284-CTO
15
45N7305
SATA hard disk drive, 250 GB, 5,400 rpm
• 4239-CTO, 34x
• 4240-CTO, 3Zx
• 4241-CTO, 47x
• 4242-CTO
• 4243-CTO, 3Rx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO, 2Dx, 2Ux, 2Vx, 2Wx
• 4284-CTO
128 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
15
45N7285
**
**
**
SATA hard disk drive, 250 GB, 5,400 rpm
• 4239-CTO, 34x
• 4240-CTO, 3Zx
• 4241-CTO, 47x
• 4242-CTO
• 4243-CTO, 3Rx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO, 2Dx, 2Ux, 2Vx, 2Wx
• 4284-CTO
15
45N7219
SATA hard disk drive, 320 GB, 5,400 rpm
• 4239-CTO, 27x
• 4240-CTO, 2Ex, 2Jx, 2Kx, 2Lx, 2Mx, 3Hx
• 4241-CTO
• 4242-CTO, 3Nx, 4Qx, 57x
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
15
42T1155
SATA hard disk drive, 320 GB, 5,400 rpm
• 4239-CTO, 27x
• 4240-CTO, 2Ex, 2Jx, 2Kx, 2Lx, 2Mx, 3Hx
• 4241-CTO
• 4242-CTO, 3Nx, 4Qx, 57x
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
Chapter 11. Parts list 129
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
15
45N7315
**
**
**
SATA hard disk drive, 320 GB, 5,400 rpm
• 4239-CTO, 27x
• 4240-CTO, 2Ex, 2Jx, 2Kx, 2Lx, 2Mx, 3Hx
• 4241-CTO
• 4242-CTO, 3Nx, 4Qx, 57x
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
15
45N7307
SATA hard disk drive, 320 GB, 5,400 rpm
• 4239-CTO, 27x
• 4240-CTO, 2Ex, 2Jx, 2Kx, 2Lx, 2Mx, 3Hx
• 4241-CTO
• 4242-CTO, 3Nx, 4Qx, 57x
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
15
45N7287
SATA hard disk drive, 320 GB, 5,400 rpm
• 4239-CTO, 27x
• 4240-CTO, 2Ex, 2Jx, 2Kx, 2Lx, 2Mx, 3Hx
• 4241-CTO
• 4242-CTO, 3Nx, 4Qx, 57x
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
130 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
15
45N7251
**
**
**
SATA hard disk drive, 160 GB, 7,200 rpm
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 25x
• 4281-CTO
• 4282-CTO
• 4284-CTO
15
42T1157
SATA hard disk drive, 160 GB, 7,200 rpm
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 25x
• 4281-CTO
• 4282-CTO
• 4284-CTO
15
45N7271
SATA hard disk drive, 160 GB, 7,200 rpm
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 25x
• 4281-CTO
• 4282-CTO
• 4284-CTO
Chapter 11. Parts list 131
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
15
42T1169
**
**
**
SATA hard disk drive, 160 GB, 7,200 rpm
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 25x
• 4281-CTO
• 4282-CTO
• 4284-CTO
15
45N7317
SATA hard disk drive, 160 GB, 7,200 rpm
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 25x
• 4281-CTO
• 4282-CTO
• 4284-CTO
15
42T1163
SATA hard disk drive, 250 GB, 7,200 rpm
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
132 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
15
45N7255
**
SATA hard disk drive, 320 GB, 7,200 rpm
• 4239-CTO, 22x, 23x, 25x, 46x, 47x, 4Bx, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Fx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 3Bx, 3Cx, 3Dx,
3Gx, 3Jx, 3Kx, 3Lx, 3Rx, 3Sx, 4Bx, 4Dx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 48x
• 4242-CTO, 22x, 24x, 27x, 29x, 2Bx, 2Cx, 2Ex, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Px, 2Qx,
2Rx, 2Sx, 2Tx, 2Ux, 2Xx, 2Yx, 32x, 35x, 37x, 38x, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Px, 44x, 4Ex,
4Hx, 4Rx, 4Sx, 4Tx, 56x, 58x, 59x
• 4243-CTO, 27x, 29x, 3Tx, 3Wx, 4Bx, 4Yx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 24x, 27x, 2Bx, 2Fx, 2Kx
• 4281-CTO
• 4282-CTO, 25x, 27x, 29x, 2Ax, 2Bx, 2Ex, 2Fx, 2Hx, 2Px, 2Qx, 2Rx, 2Tx, 2Xx, 37x, 38x,
3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Jx, 4Bx
• 4284-CTO, 25x, 3Tx, 3Xx, 4Ax, 4Bx
15
42T1159
**
SATA hard disk drive, 320 GB, 7,200 rpm
• 4239-CTO, 22x, 23x, 25x, 46x, 47x, 4Bx, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Fx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 3Bx, 3Cx, 3Dx,
3Gx, 3Jx, 3Kx, 3Lx, 3Rx, 3Sx, 4Bx, 4Dx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 48x
• 4242-CTO, 22x, 24x, 27x, 29x, 2Bx, 2Cx, 2Ex, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Px, 2Qx,
2Rx, 2Sx, 2Tx, 2Ux, 2Xx, 2Yx, 32x, 35x, 37x, 38x, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Px, 44x, 4Ex,
4Hx, 4Rx, 4Sx, 4Tx, 56x, 58x, 59x
• 4243-CTO, 27x, 29x, 3Tx, 3Wx, 4Bx, 4Yx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 24x, 27x, 2Bx, 2Fx, 2Kx
• 4281-CTO
• 4282-CTO, 25x, 27x, 29x, 2Ax, 2Bx, 2Ex, 2Fx, 2Hx, 2Px, 2Qx, 2Rx, 2Tx, 2Xx, 37x, 38x,
3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Jx, 4Bx
• 4284-CTO, 25x, 3Tx, 3Xx, 4Ax, 4Bx
Chapter 11. Parts list 133
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
15
45N7275
**
SATA hard disk drive, 320 GB, 7,200 rpm
• 4239-CTO, 22x, 23x, 25x, 46x, 47x, 4Bx, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Fx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 3Bx, 3Cx, 3Dx,
3Gx, 3Jx, 3Kx, 3Lx, 3Rx, 3Sx, 4Bx, 4Dx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 48x
• 4242-CTO, 22x, 24x, 27x, 29x, 2Bx, 2Cx, 2Ex, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Px, 2Qx,
2Rx, 2Sx, 2Tx, 2Ux, 2Xx, 2Yx, 32x, 35x, 37x, 38x, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Px, 44x, 4Ex,
4Hx, 4Rx, 4Sx, 4Tx, 56x, 58x, 59x
• 4243-CTO, 27x, 29x, 3Tx, 3Wx, 4Bx, 4Yx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 24x, 27x, 2Bx, 2Fx, 2Kx
• 4281-CTO
• 4282-CTO, 25x, 27x, 29x, 2Ax, 2Bx, 2Ex, 2Fx, 2Hx, 2Px, 2Qx, 2Rx, 2Tx, 2Xx, 37x, 38x,
3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Jx, 4Bx
• 4284-CTO, 25x, 3Tx, 3Xx, 4Ax, 4Bx
15
42T1171
**
SATA hard disk drive, 320 GB, 7,200 rpm
• 4239-CTO, 22x, 23x, 25x, 46x, 47x, 4Bx, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Fx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 3Bx, 3Cx, 3Dx,
3Gx, 3Jx, 3Kx, 3Lx, 3Rx, 3Sx, 4Bx, 4Dx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 48x
• 4242-CTO, 22x, 24x, 27x, 29x, 2Bx, 2Cx, 2Ex, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Px, 2Qx,
2Rx, 2Sx, 2Tx, 2Ux, 2Xx, 2Yx, 32x, 35x, 37x, 38x, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Px, 44x, 4Ex,
4Hx, 4Rx, 4Sx, 4Tx, 56x, 58x, 59x
• 4243-CTO, 27x, 29x, 3Tx, 3Wx, 4Bx, 4Yx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 24x, 27x, 2Bx, 2Fx, 2Kx
• 4281-CTO
• 4282-CTO, 25x, 27x, 29x, 2Ax, 2Bx, 2Ex, 2Fx, 2Hx, 2Px, 2Qx, 2Rx, 2Tx, 2Xx, 37x, 38x,
3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Jx, 4Bx
• 4284-CTO, 25x, 3Tx, 3Xx, 4Ax, 4Bx
134 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
15
45N7319
**
SATA hard disk drive, 320 GB, 7,200 rpm
• 4239-CTO, 22x, 23x, 25x, 46x, 47x, 4Bx, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Fx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 3Bx, 3Cx, 3Dx,
3Gx, 3Jx, 3Kx, 3Lx, 3Rx, 3Sx, 4Bx, 4Dx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 48x
• 4242-CTO, 22x, 24x, 27x, 29x, 2Bx, 2Cx, 2Ex, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Px, 2Qx,
2Rx, 2Sx, 2Tx, 2Ux, 2Xx, 2Yx, 32x, 35x, 37x, 38x, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Px, 44x, 4Ex,
4Hx, 4Rx, 4Sx, 4Tx, 56x, 58x, 59x
• 4243-CTO, 27x, 29x, 3Tx, 3Wx, 4Bx, 4Yx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 24x, 27x, 2Bx, 2Fx, 2Kx
• 4281-CTO
• 4282-CTO, 25x, 27x, 29x, 2Ax, 2Bx, 2Ex, 2Fx, 2Hx, 2Px, 2Qx, 2Rx, 2Tx, 2Xx, 37x, 38x,
3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Jx, 4Bx
• 4284-CTO, 25x, 3Tx, 3Xx, 4Ax, 4Bx
15
45N7257
**
SATA hard disk drive, 500 GB, 7,200 rpm
• 4239-CTO, 24x, 28x, 2Zx, 32x, 33x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Nx, 42x, 43x, 44x,
45x, 48x, 49x, 4Ax
• 4240-CTO, 2Gx, 2Hx, 2Ux, 2Xx, 2Yx, 3Ex, 3Fx, 3Mx, 3Px, 3Qx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx,
3Yx, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx
• 4241-CTO, 45x, 46x
• 4242-CTO, 23x, 28x, 2Dx, 2Nx, 2Vx, 2Wx, 33x, 36x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Qx, 45x,
46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Dx, 4Fx, 4Gx, 4Mx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x,
53x, 54x, 55x
• 4243-CTO, 28x, 3Sx, 3Ux, 3Vx, 3Xx, 3Yx, 3Zx, 4Jx, 4Kx, 4Ux, 4Vx, 4Wx, 4Xx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 23x, 28x, 29x, 2Ax, 2Cx, 2Dx, 2Ex, 2Gx, 2Hx, 2Jx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx,
2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 2Xx, 2Yx, 33x, 34x, 35x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 26x, 28x, 2Cx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Yx, 2Zx, 33x, 34x,
35x, 36x, 3Bx, 3Hx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx,
3Yx, 3Zx, 42x, 45x, 4Cx
• 4284-CTO, 23x, 24x, 26x, 3Ux, 3Vx, 3Wx, 3Yx, 3Zx, 42x, 45x, 46x, 47x, 48x, 49x, 4Cx, 4Dx
Chapter 11. Parts list 135
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
15
45N7277
**
SATA hard disk drive, 500 GB, 7,200 rpm
• 4239-CTO, 24x, 28x, 2Zx, 32x, 33x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Nx, 42x, 43x, 44x,
45x, 48x, 49x, 4Ax
• 4240-CTO, 2Gx, 2Hx, 2Ux, 2Xx, 2Yx, 3Ex, 3Fx, 3Mx, 3Px, 3Qx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx,
3Yx, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx
• 4241-CTO, 45x, 46x
• 4242-CTO, 23x, 28x, 2Dx, 2Nx, 2Vx, 2Wx, 33x, 36x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Qx, 45x,
46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Dx, 4Fx, 4Gx, 4Mx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x,
53x, 54x, 55x
• 4243-CTO, 28x, 3Sx, 3Ux, 3Vx, 3Xx, 3Yx, 3Zx, 4Jx, 4Kx, 4Ux, 4Vx, 4Wx, 4Xx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 23x, 28x, 29x, 2Ax, 2Cx, 2Dx, 2Ex, 2Gx, 2Hx, 2Jx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx,
2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 2Xx, 2Yx, 33x, 34x, 35x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 26x, 28x, 2Cx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Yx, 2Zx, 33x, 34x,
35x, 36x, 3Bx, 3Hx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx,
3Yx, 3Zx, 42x, 45x, 4Cx
• 4284-CTO, 23x, 24x, 26x, 3Ux, 3Vx, 3Wx, 3Yx, 3Zx, 42x, 45x, 46x, 47x, 48x, 49x, 4Cx, 4Dx
15
45N7321
**
SATA hard disk drive, 500 GB, 7,200 rpm
• 4239-CTO, 24x, 28x, 2Zx, 32x, 33x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Nx, 42x, 43x, 44x,
45x, 48x, 49x, 4Ax
• 4240-CTO, 2Gx, 2Hx, 2Ux, 2Xx, 2Yx, 3Ex, 3Fx, 3Mx, 3Px, 3Qx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx,
3Yx, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx
• 4241-CTO, 45x, 46x
• 4242-CTO, 23x, 28x, 2Dx, 2Nx, 2Vx, 2Wx, 33x, 36x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Qx, 45x,
46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Dx, 4Fx, 4Gx, 4Mx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x,
53x, 54x, 55x
• 4243-CTO, 28x, 3Sx, 3Ux, 3Vx, 3Xx, 3Yx, 3Zx, 4Jx, 4Kx, 4Ux, 4Vx, 4Wx, 4Xx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 23x, 28x, 29x, 2Ax, 2Cx, 2Dx, 2Ex, 2Gx, 2Hx, 2Jx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx,
2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 2Xx, 2Yx, 33x, 34x, 35x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 26x, 28x, 2Cx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Yx, 2Zx, 33x, 34x,
35x, 36x, 3Bx, 3Hx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx,
3Yx, 3Zx, 42x, 45x, 4Cx
• 4284-CTO, 23x, 24x, 26x, 3Ux, 3Vx, 3Wx, 3Yx, 3Zx, 42x, 45x, 46x, 47x, 48x, 49x, 4Cx, 4Dx
136 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
15
45N7995
**
**
**
SATA 2.5" solid state drive, 128 GB, 7 mm height
• 4239-CTO, 26x
• 4240-CTO, 2Vx
• 4241-CTO
• 4242-CTO, 25x, 2Fx, 2Zx, 34x, 3Ex, 3Fx, 3Gx
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
15
45N8007
SATA 2.5" solid state drive, 128 GB, 7 mm height
• 4239-CTO, 26x
• 4240-CTO, 2Vx
• 4241-CTO
• 4242-CTO, 25x, 2Fx, 2Zx, 34x, 3Ex, 3Fx, 3Gx
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
15
45N7981
SATA 2.5" solid state drive, 128 GB, 7 mm height
• 4239-CTO, 26x
• 4240-CTO, 2Vx
• 4241-CTO
• 4242-CTO, 25x, 2Fx, 2Zx, 34x, 3Ex, 3Fx, 3Gx
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
Chapter 11. Parts list 137
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
15
45N8057
**
SATA 2.5" solid state drive, 160 GB, 7 mm height
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO, 2Ax
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x, 2Zx, 36x
• 4281-CTO
• 4282-CTO,2Sx, 32x
• 4284-CTO, 43x
16
04W2020
N
System board assembly for T520 and T520i, integrated, AMT, TPM
• 4239-CTO, 22x, 25x, 46x
• 4240-CTO, 29x, 2Dx, 2Fx, 2Gx, 2Jx, 2Kx, 3Bx, 3Cx, 3Mx, 46x, 4Ax, 4Ex, 4Px, 4Qx
• 4241-CTO, 26x
• 4242-CTO, 22x, 23x, 24x, 25x, 29x, 2Ax, 2Bx, 2Cx, 2Ex, 2Fx, 2Gx, 2Hx, 2Px, 2Qx, 2Rx,
2Zx, 32x, 34x, 39x, 3Hx, 3Kx, 3Mx, 3Nx, 3Px, 45x, 4Ax, 4Ex, 4Rx, 4Sx, 4Wx, 56x, 57x, 58x
• 4243-CTO, 29x, 3Rx, 3Wx, 3Zx, 4Bx, 4Wx, 4Yx
• 4244-CTO
• 4246-CTO
16
04W2021
N
System board assembly for T520 and T520i, optimus, AMT, TPM
• 4239-CTO, 23x, 24x, 26x, 34x, 42x, 43x, 45x
• 4240-CTO, 2Ax, 2Hx, 2Nx, 2Px, 3Dx, 3Px, 3Qx, 47x, 48x, 49x, 4Gx, 4Hx, 4Jx, 4Lx
• 4241-CTO
• 4242-CTO, 27x, 28x, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 33x,
35x, 36x, 37x, 38x, 3Lx, 3Qx, 46x, 49x, 4Cx, 4Dx, 4Fx, 4Gx, 4Mx, 4Tx, 4Ux, 4Vx, 4Zx,
52x, 53x, 54x, 59x
• 4243-CTO, 27x, 28x, 3Tx, 3Ux, 3Vx, 4Jx, 4Kx, 4Ux, 4Vx, 4Xx, 5Ax
• 4244-CTO
• 4246-CTO
16
16
04W2022
04W2023
N
N
System board assembly for T520 and T520i, integrated, AMT, non-TPM
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO, 44x
• 4243-CTO
• 4244-CTO
• 4246-CTO
System board assembly for T520 and T520i, optimus, AMT, non-TPM
• 4239-CTO, 33x
• 4240-CTO
• 4241-CTO
• 4242-CTO, 4Hx
• 4243-CTO
• 4244-CTO
• 4246-CTO
138 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
16
04W2024
N
System board assembly for T520 and T520i, integrated, non-AMT, TPM
• 4239-CTO, 27x, 28x, 35x, 3Nx, 47x, 48x, 49x, 4Bx, 4Cx
• 4240-CTO, 2Bx, 2Cx, 2Ex, 2Lx, 2Mx, 2Sx, 2Tx, 2Xx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 4Bx,
4Dx, 4Kx, 4Mx, 4Nx
• 4241-CTO, 42x, 47x, 48x
• 4242-CTO, 2Dx, 3Ax, 3Bx, 3Cx, 3Ex, 3Fx, 47x, 48x, 4Qx
• 4243-CTO, 3Sx, 3Xx, 3Yx
• 4244-CTO
• 4246-CTO
16
16
16
16
04W2025
04W2026
04W2027
04W2028
N
N
N
N
System board assembly for T520 and T520i, optimus, non-AMT, TPM
• 4239-CTO, 36x, 37x, 38x, 39x, 3Ax, 44x, 4Ax
• 4240-CTO, 2Qx, 2Rx, 2Ux, 2Vx, 2Yx, 3Xx, 3Yx, 4Cx, 4Fx
• 4241-CTO, 43x, 44x, 45x, 46x
• 4242-CTO, 3Dx, 3Gx, 3Jx, 4Xx, 4Yx, 55x
• 4243-CTO
• 4244-CTO
• 4246-CTO
System board assembly for T520 and T520i, integrated, non-AMT, non-TPM
• 4239-CTO, 2Zx
• 4240-CTO, 3Hx, 3Jx, 3Lx, 3Zx
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
System board assembly for T520 and T520i, optimus, non-AMT, non-TPM
• 4239-CTO, 32x
• 4240-CTO, 3Ex, 3Fx, 3Gx, 3Kx
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
System board assembly for W520 Q1, AMT, TPM, no RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 25x, 27x, 28x, 29x, 2Bx, 2Cx, 2Dx, 2Kx, 2Lx, 2Mx, 2Px, 2Rx, 2Vx, 2Wx, 37x,
38x, 39x
• 4281-CTO
• 4282-CTO, 25x, 26x, 27x, 29x, 2Ax, 2Bx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Nx, 2Px,
2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 32x, 35x, 36x, 37x, 38x, 3Bx, 3Cx, 3Dx, 3Ex,
3Fx, 3Gx, 3Hx, 3Px, 3Rx, 3Sx, 3Ux, 45x, 4Bx, 4Cx
• 4284-CTO, 25x, 26x, 3Tx, 3Ux, 3Vx, 45x, 46x, 47x, 48x, 4Ax, 4Bx, 4Cx, 4Dx
16
04W2030
N
System board assembly for W520 Q1, AMT, non-TPM, no RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 2Fx, 2Gx, 2Hx
• 4281-CTO
• 4282-CTO, 3Qx
• 4284-CTO, 3Xx, 3Yx, 3Zx
Chapter 11. Parts list 139
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
16
04W2029
N
N
N
N
N
N
System board assembly for W520 Q3, AMT, TPM, no RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x, 23x, 24x, 2Ax, 2Ex, 2Nx, 2Qx, 2Sx, 2Tx, 2Xx, 2Yx, 2Zx
• 4281-CTO
• 4282-CTO, 23x, 24x, 28x, 2Yx, 2Zx, 34x, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Tx, 3Vx, 3Wx, 3Xx, 3Yx
• 4284-CTO, 23x, 24x, 3Wx, 43x, 49x
16
16
16
16
16
04W2031
04W2032
04W2034
04W2033
04W2035
System board assembly for W520 Q3, AMT, non-TPM, no RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 2Jx, 36x
• 4281-CTO
• 4282-CTO
• 4284-CTO, 42x
System board assembly for W520 Q1, AMT, TPM, with RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO, 2Mx
• 4284-CTO
System board assembly for W520 Q1, AMT, non-TPM, with RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
System board assembly for W520 Q3, AMT, TPM, with RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO, 2Cx, 2Lx, 33x, 3Zx, 42x
• 4284-CTO
System board assembly for W520 Q3, AMT, non-TPM, with RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
140 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
16
04W2036
N
N
N
N
N
N
System board assembly for W520 Q1, non-AMT, TPM, no RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
16
16
16
16
16
04W2038
04W2037
04W2039
04W2040
04W2042
System board assembly for W520 Q1, non-AMT, non-TPM, no RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 34x, 35x
• 4281-CTO
• 4282-CTO
• 4284-CTO
System board assembly for W520 Q3, non-AMT, TPM, no RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
System board assembly for W520 Q3, non-AMT, non-TPM, no RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 33x
• 4281-CTO
• 4282-CTO
• 4284-CTO
System board assembly for W520 Q1, non-AMT, TPM, with RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
System board assembly for W520 Q1, non-AMT, non-TPM, with RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
Chapter 11. Parts list 141
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
16
04W2041
N
N
N
System board assembly for W520 Q3, non-AMT, TPM, with RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
16
17
04W2043
04W0495
System board assembly for W520 Q3, non-AMT, non-TPM, with RAID adapter
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
CPU assembly, Intel® CoreTM i3-2310M Processor (2.66 GHz)
• 4239-CTO, 27x, 35x, 36x, 3Nx, 47x, 48x, 49x, 4Bx
• 4240-CTO, 2Lx, 2Mx, 2Qx, 2Rx, 2Sx, 2Tx, 2Xx, 3Gx, 3Hx, 3Rx, 3Sx, 3Vx, 3Wx, 3Zx,
4Dx, 4Mx, 4Nx
• 4241-CTO, 42x, 43x, 44x, 45x, 46x, 47x
• 4242-CTO, 3Ax
• 4243-CTO
• 4244-CTO
• 4246-CTO
17
04W0496
CPU assembly, Intel Core i5-2410M Processor (2.66 GHz)
• 4239-CTO, 27x, 35x, 36x, 3Nx, 47x, 48x, 49x, 4Bx
• 4240-CTO, 2Lx, 2Mx, 2Qx, 2Rx, 2Sx, 2Tx, 2Xx, 3Gx, 3Hx, 3Rx, 3Sx, 3Vx, 3Wx, 3Zx,
4Dx, 4Mx, 4Nx
• 4241-CTO
• 4242-CTO, 3Bx, 3Cx, 3Dx, 3Jx, 4Xx, 4Yx, 55x
• 4243-CTO, 3Xx, 3Yx
• 4244-CTO
• 4246-CTO
17
04W0492
N
CPU assembly, Intel Core i5-2520M Processor (2.50 GHz)
• 4239-CTO, 22x, 39x, 45x, 46x
• 4240-CTO, 29x, 2Fx, 2Jx, 2Kx, 2Nx, 2Px, 2Yx, 3Bx, 3Cx, 3Dx, 3Fx, 3Jx, 3Mx, 46x, 47x,
49x, 4Ax, 4Gx, 4Lx, 4Px, 4Qx
• 4241-CTO, 26x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 27x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx,
2Kx, 2Lx, 2Mx, 2Nx, 3Ex, 3Hx, 3Kx, 3Mx, 3Nx, 44x, 45x, 46x, 47x, 48x, 4Ex, 4Hx, 4Mx,
4Qx, 4Rx, 4Sx, 4Tx, 4Vx, 4Wx, 4Zx, 56x, 57x
• 4243-CTO, 27x, 29x, 3Sx, 3Wx, 4Bx, 4Vx, 4Wx, 4Yx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 25x, 2Bx, 2Fx, 2Kx, 2Rx, 2Sx
• 4281-CTO
• 4282-CTO, 2Hx, 2Wx, 3Px, 3Tx, 3Ux
• 4284-CTO, 3Tx, 3Xx, 4Ax
142 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
17
04W0493
N
CPU assembly, Intel Core i5-2540M Processor (2.60 GHz)
• 4239-CTO, 23x, 24x, 25x, 2Zx, 32x, 44x
• 4240-CTO, 2Dx, 2Gx, 2Hx
• 4241-CTO
• 4242-CTO, 28x, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 37x, 39x, 3Fx, 3Lx, 3Px, 49x,
4Ax, 52x, 53x, 58x, 59x
• 4243-CTO, 28x, 3Rx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 24x, 2Cx, 2Gx, 2Lx
• 4281-CTO
• 4282-CTO, 25x, 35x, 3Cx, 3Vx
• 4284-CTO, 25x, 3Ux, 3Yx
17
04W0494
N
CPU assembly, Intel Core i7-2620M Processor (2.70 GHz)
• 4239-CTO, 26x, 33x, 34x, 3Ax, 42x, 43x
• 4240-CTO, 2Ax, 3Ex, 3Px, 48x, 4Ex, 4Hx
• 4241-CTO
• 4242-CTO, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x, 35x, 36x, 38x, 3Gx, 3Qx, 4Gx, 4Ux
• 4243-CTO, 3Tx, 3Vx, 3Zx, 4Ux, 4Xx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 2Dx, 2Hx, 2Mx, 2Px, 35x
• 4281-CTO
• 4282-CTO, 26x, 27x, 2Gx, 2Ux, 2Vx, 2Xx, 3Dx, 3Ex, 3Rx, 3Wx, 4Bx
• 4284-CTO, 26x, 3Vx, 3Zx, 48x, 4Bx
17
04W1801
N
CPU assembly, Intel Core i7-2630QM Processor (2.00 GHz)
• 4239-CTO
• 4240-CTO, 4Jx
• 4241-CTO
• 4242-CTO
• 4243-CTO, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO, 3Xx
• 4284-CTO, 4Dx
Chapter 11. Parts list 143
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
17
04W1360
N
N
N
CPU assembly, Intel Core i7-2720QM Processor (2.20 GHz)
• 4239-CTO
• 4240-CTO, 3Qx
• 4241-CTO
• 4242-CTO, 4Cx, 4Fx, 54x
• 4243-CTO, 3Ux, 4Jx, 4Kx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 27x, 28x, 2Ex, 2Jx, 2Nx, 2Qx, 2Tx, 2Vx, 2Wx, 2Xx, 34x, 37x, 38x
• 4281-CTO
• 4282-CTO, 24x, 28x, 29x, 2Ax, 2Dx, 2Ex, 2Sx, 36x, 37x, 38x, 3Fx, 3Gx, 3Jx, 3Lx, 3Mx,
3Nx, 3Sx, 3Yx, 4Cx
• 4284-CTO, 24x, 3Wx, 42x, 46x, 47x, 4Cx
17
04W1361
CPU assembly, Intel Core i7-2820QM Processor (2.30 GHz)
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO, 4Dx
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x, 29x, 2Yx, 2Zx, 33x, 39x
• 4281-CTO
• 4282-CTO, 23x, 2Bx, 2Fx, 2Jx, 2Kx, 2Lx, 2Mx, 2Px, 2Qx, 2Rx, 2Tx, 2Yx, 3Bx, 3Hx, 3Kx,
3Qx, 3Zx, 45x
• 4284-CTO, 23x, 45x, 49x
17
04W1510
CPU assembly, Intel Core i7-2920XM Processor (2.50 GHz)
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 23x, 2Ax, 36x
• 4281-CTO
• 4282-CTO, 2Cx, 2Nx, 2Zx, 32x, 33x, 34x, 42x
• 4284-CTO, 43x
144 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
18
60Y3271
N
Bluetooth daughter card (BDC-3.0)
• 4239-CTO, 23x, 24x, 25x, 26x, 27x, 28x, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x, 39x, 3Ax,
3Nx, 42x, 43x, 44x, 45x, 46x, 48x, 49x, 4Ax, 4Bx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx,
2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Xx, 2Yx, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx,
3Mx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 46x, 47x, 48x, 49x, 4Ax,
4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Hx, 2Jx, 2Kx,
2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x,
35x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx,
3Px, 3Qx, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Mx, 4Qx,
4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x, 53x, 54x, 55x, 56x, 57x
• 4243-CTO, 28x, 29x, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Jx, 4Kx, 4Ux,
4Vx, 4Wx, 4Xx, 4Yx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 22x, 23x, 24x, 25x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 33x, 34x,
35x, 36x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Fx, 2Gx, 2Jx, 2Kx, 2Lx,
2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Tx, 2Ux, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x, 3Bx,
3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux,
3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 45x, 4Bx, 4Cx
• 4284-CTO, 23x, 24x, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 43x, 45x, 46x,
47x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx
Chapter 11. Parts list 145
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
18
60Y3275
N
Bluetooth daughter card (BDC-3.0)
• 4239-CTO, 23x, 24x, 25x, 26x, 27x, 28x, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x, 39x, 3Ax,
3Nx, 42x, 43x, 44x, 45x, 46x, 48x, 49x, 4Ax, 4Bx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx,
2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Xx, 2Yx, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx,
3Mx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 46x, 47x, 48x, 49x, 4Ax,
4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Hx, 2Jx, 2Kx,
2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x,
35x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx,
3Px, 3Qx, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Mx, 4Qx,
4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x, 53x, 54x, 55x, 56x, 57x
• 4243-CTO, 28x, 29x, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Jx, 4Kx, 4Ux,
4Vx, 4Wx, 4Xx, 4Yx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 22x, 23x, 24x, 25x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 33x, 34x,
35x, 36x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Fx, 2Gx, 2Jx, 2Kx, 2Lx,
2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Tx, 2Ux, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x, 3Bx,
3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux,
3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 45x, 4Bx, 4Cx
• 4284-CTO, 23x, 24x, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 43x, 45x, 46x,
47x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx
146 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
19
60Y3207
N
Modem Daughter Card
• 4239-CTO, 22x, 23x, 25x, 26x, 27x, 28x, 34x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Nx, 42x,
43x, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Cx
• 4240-CTO, 2Ex, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Xx, 2Yx,
3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx,
46x, 47x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx
• 4241-CTO, 42x, 43x, 44x, 45x, 46x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx,
2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x, 35x,
36x, 37x, 38x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px,
3Qx, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Ex, 4Fx, 4Gx, 4Hx, 4Mx, 4Qx, 4Ux, 4Vx, 4Wx,
4Xx, 4Yx, 4Zx, 52x, 53x, 54x, 55x, 58x, 59x
• 4243-CTO, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Jx, 4Kx, 4Ux, 4Vx, 4Wx,
4Xx, 4Yx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 22x, 23x, 24x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx,
2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Wx, 2Xx, 2Yx, 2Zx, 33x, 34x, 35x, 36x,
37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 25x, 26x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx,
2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x,
35x, 36x, 37x, 38x, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px,
3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 45x, 4Bx, 4Cx
• 4284-CTO, 23x, 24x, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 43x, 45x, 46x,
47x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx
20 Magnesium structure frame for T520 and T520i discrete models
• 4239-CTO, 23x, 24x, 26x, 32x, 33x, 34x, 36x, 37x, 38x, 39x, 3Ax, 42x, 43x, 44x, 45x, 4Ax
• 4240-CTO, 2Ax, 2Hx, 2Nx, 2Px, 2Qx, 2Rx, 2Ux, 2Vx, 2Yx, 3Dx, 3Ex, 3Fx, 3Gx, 3Kx, 3Px,
3Qx, 3Xx, 3Yx, 47x, 48x, 49x, 4Cx, 4Fx, 4Gx, 4Hx, 4Jx, 4Lx
• 4241-CTO, 43x, 44x, 45x, 46x
04W1671
N
• 4242-CTO, 27x, 28x, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 33x,
35x, 36x, 37x, 38x, 3Dx, 3Gx, 3Jx, 3Lx, 3Qx, 46x, 49x, 4Cx, 4Dx, 4Fx, 4Gx, 4Hx, 4Mx, 4Tx,
4Ux, 4Vx, 4Xx, 4Yx, 4Zx, 52x, 53x, 54x, 55x, 59x
• 4243-CTO, 27x, 28x, 3Tx, 3Ux, 3Vx, 4Jx, 4Kx, 4Ux, 4Vx, 4Xx, 5Ax
• 4244-CTO
• 4246-CTO
20 Magnesium structure frame for T520 and T520i integrated models
• 4239-CTO, 22x, 25x, 27x, 28x, 2Zx, 35x, 3Nx, 46x, 47x, 48x, 49x, 4Bx, 4Cx
• 4240-CTO, 29x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Sx, 2Tx, 2Xx, 3Bx,
3Cx, 3Hx, 3Jx, 3Lx, 3Mx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Zx, 46x, 4Ax, 4Bx, 4Dx, 4Ex,
4Kx, 4Mx, 4Nx, 4Px, 4Qx
04W1573
N
• 4241-CTO, 26x, 42x, 47x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Px, 2Qx,
2Rx, 2Zx, 32x, 34x, 39x, 3Ax, 3Bx, 3Cx, 3Ex, 3Fx, 3Hx, 3Kx, 3Mx, 3Nx, 3Px, 44x, 45x, 47x,
48x, 4Ax, 4Ex, 4Qx, 4Rx, 4Sx, 4Wx, 56x, 57x, 58x
• 4243-CTO, 29x, 3Rx, 3Sx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Wx, 4Yx
• 4244-CTO
• 4246-CTO
20 Magnesium structure frame for workstation models
04W1672
N
Chapter 11. Parts list 147
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
21 Thermal module for T520 and T520i discrete graphics models
• 4239-CTO, 23x, 24x, 26x, 32x, 33x, 34x, 36x, 37x, 38x, 39x, 3Ax, 42x, 43x, 44x, 45x, 4Ax
• 4240-CTO, 2Ax, 2Hx, 2Nx, 2Px, 2Qx, 2Rx, 2Ux, 2Vx, 2Yx, 3Dx, 3Ex, 3Fx, 3Gx, 3Kx, 3Px,
3Qx, 3Xx, 3Yx, 47x, 48x, 49x, 4Cx, 4Fx, 4Gx, 4Hx, 4Jx, 4Lx
• 4241-CTO, 43x, 44x, 45x, 46x
04W0439
N
N
N
N
• 4242-CTO, 27x, 28x, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 33x,
35x, 36x, 37x, 38x, 3Dx, 3Gx, 3Jx, 3Lx, 3Qx, 46x, 49x, 4Cx, 4Dx, 4Fx, 4Gx, 4Hx, 4Mx, 4Tx,
4Ux, 4Vx, 4Xx, 4Yx, 4Zx, 52x, 53x, 54x, 55x, 59x
• 4243-CTO, 27x, 28x, 3Tx, 3Ux, 3Vx, 4Jx, 4Kx, 4Ux, 4Vx, 4Xx, 5Ax
• 4244-CTO
• 4246-CTO
21 Thermal module for T520 and T520i discrete graphics models
• 4239-CTO, 23x, 24x, 26x, 32x, 33x, 34x, 36x, 37x, 38x, 39x, 3Ax, 42x, 43x, 44x, 45x, 4Ax
• 4240-CTO, 2Ax, 2Hx, 2Nx, 2Px, 2Qx, 2Rx, 2Ux, 2Vx, 2Yx, 3Dx, 3Ex, 3Fx, 3Gx, 3Kx, 3Px,
3Qx, 3Xx, 3Yx, 47x, 48x, 49x, 4Cx, 4Fx, 4Gx, 4Hx, 4Jx, 4Lx
• 4241-CTO, 43x, 44x, 45x, 46x
04W1578
04W1579
04W0440
• 4242-CTO, 27x, 28x, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 33x,
35x, 36x, 37x, 38x, 3Dx, 3Gx, 3Jx, 3Lx, 3Qx, 46x, 49x, 4Cx, 4Dx, 4Fx, 4Gx, 4Hx, 4Mx, 4Tx,
4Ux, 4Vx, 4Xx, 4Yx, 4Zx, 52x, 53x, 54x, 55x, 59x
• 4243-CTO, 27x, 28x, 3Tx, 3Ux, 3Vx, 4Jx, 4Kx, 4Ux, 4Vx, 4Xx, 5Ax
• 4244-CTO
• 4246-CTO
21 Thermal module for T520 and T520i discrete graphics models
• 4239-CTO, 23x, 24x, 26x, 32x, 33x, 34x, 36x, 37x, 38x, 39x, 3Ax, 42x, 43x, 44x, 45x, 4Ax
• 4240-CTO, 2Ax, 2Hx, 2Nx, 2Px, 2Qx, 2Rx, 2Ux, 2Vx, 2Yx, 3Dx, 3Ex, 3Fx, 3Gx, 3Kx, 3Px,
3Qx, 3Xx, 3Yx, 47x, 48x, 49x, 4Cx, 4Fx, 4Gx, 4Hx, 4Jx, 4Lx
• 4241-CTO, 43x, 44x, 45x, 46x
• 4242-CTO, 27x, 28x, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 33x,
35x, 36x, 37x, 38x, 3Dx, 3Gx, 3Jx, 3Lx, 3Qx, 46x, 49x, 4Cx, 4Dx, 4Fx, 4Gx, 4Hx, 4Mx, 4Tx,
4Ux, 4Vx, 4Xx, 4Yx, 4Zx, 52x, 53x, 54x, 55x, 59x
• 4243-CTO, 27x, 28x, 3Tx, 3Ux, 3Vx, 4Jx, 4Kx, 4Ux, 4Vx, 4Xx, 5Ax
• 4244-CTO
• 4246-CTO
21 Thermal module for T520 and T520i integrated graphics models
• 4239-CTO, 22x, 25x, 27x, 28x, 2Zx, 35x, 3Nx, 46x, 47x, 48x, 49x, 4Bx, 4Cx
• 4240-CTO, 29x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Sx, 2Tx, 2Xx, 3Bx,
3Cx, 3Hx, 3Jx, 3Lx, 3Mx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Zx, 46x, 4Ax, 4Bx, 4Dx, 4Ex,
4Kx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 47x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Px, 2Qx,
2Rx, 2Zx, 32x, 34x, 39x, 3Ax, 3Bx, 3Cx, 3Ex, 3Fx, 3Hx, 3Kx, 3Mx, 3Nx, 3Px, 44x, 45x, 47x,
48x, 4Ax, 4Ex, 4Qx, 4Rx, 4Sx, 4Wx, 56x, 57x, 58x
• 4243-CTO, 29x, 3Rx, 3Sx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Wx, 4Yx
• 4244-CTO
• 4246-CTO
148 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
21 Thermal module for T520 and T520i integrated graphics models
• 4239-CTO, 22x, 25x, 27x, 28x, 2Zx, 35x, 3Nx, 46x, 47x, 48x, 49x, 4Bx, 4Cx
• 4240-CTO, 29x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Sx, 2Tx, 2Xx, 3Bx,
3Cx, 3Hx, 3Jx, 3Lx, 3Mx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Zx, 46x, 4Ax, 4Bx, 4Dx, 4Ex,
4Kx, 4Mx, 4Nx, 4Px, 4Qx
04W1580
N
• 4241-CTO, 26x, 42x, 47x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Px, 2Qx,
2Rx, 2Zx, 32x, 34x, 39x, 3Ax, 3Bx, 3Cx, 3Ex, 3Fx, 3Hx, 3Kx, 3Mx, 3Nx, 3Px, 44x, 45x, 47x,
48x, 4Ax, 4Ex, 4Qx, 4Rx, 4Sx, 4Wx, 56x, 57x, 58x
• 4243-CTO, 29x, 3Rx, 3Sx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Wx, 4Yx
• 4244-CTO
• 4246-CTO
21 Thermal module for T520 and T520i integrated graphics models
• 4239-CTO, 22x, 25x, 27x, 28x, 2Zx, 35x, 3Nx, 46x, 47x, 48x, 49x, 4Bx, 4Cx
• 4240-CTO, 29x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Sx, 2Tx, 2Xx, 3Bx,
3Cx, 3Hx, 3Jx, 3Lx, 3Mx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Zx, 46x, 4Ax, 4Bx, 4Dx, 4Ex,
4Kx, 4Mx, 4Nx, 4Px, 4Qx
04W1581
N
• 4241-CTO, 26x, 42x, 47x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Px, 2Qx,
2Rx, 2Zx, 32x, 34x, 39x, 3Ax, 3Bx, 3Cx, 3Ex, 3Fx, 3Hx, 3Kx, 3Mx, 3Nx, 3Px, 44x, 45x, 47x,
48x, 4Ax, 4Ex, 4Qx, 4Rx, 4Sx, 4Wx, 56x, 57x, 58x
• 4243-CTO, 29x, 3Rx, 3Sx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Wx, 4Yx
• 4244-CTO
• 4246-CTO
21 Thermal module for W520, 55W
04W0437
04W1574
04W1575
N
N
N
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x, 23x, 24x, 2Ax, 2Ex, 2Jx, 2Nx, 2Qx, 2Sx, 2Tx, 2Xx, 2Yx, 2Zx, 33x, 36x
• 4281-CTO
• 4282-CTO, 23x, 24x, 28x, 2Cx, 2Lx, 2Yx, 2Zx, 33x, 34x, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Tx,
3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x
• 4284-CTO, 23x, 24x, 3Wx, 42x, 43x, 49x
21 Thermal module for W520, 55W
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x, 23x, 24x, 2Ax, 2Ex, 2Jx, 2Nx, 2Qx, 2Sx, 2Tx, 2Xx, 2Yx, 2Zx, 33x, 36x
• 4281-CTO
• 4282-CTO, 23x, 24x, 28x, 2Cx, 2Lx, 2Yx, 2Zx, 33x, 34x, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Tx,
3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x
• 4284-CTO, 23x, 24x, 3Wx, 42x, 43x, 49x
21 Thermal module for W520, 55W
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x, 23x, 24x, 2Ax, 2Ex, 2Jx, 2Nx, 2Qx, 2Sx, 2Tx, 2Xx, 2Yx, 2Zx, 33x, 36x
• 4281-CTO
• 4282-CTO, 23x, 24x, 28x, 2Cx, 2Lx, 2Yx, 2Zx, 33x, 34x, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Tx,
3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x
• 4284-CTO, 23x, 24x, 3Wx, 42x, 43x, 49x
Chapter 11. Parts list 149
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
21 Thermal module for W520, 45W
04W0438
N
N
N
N
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 25x, 27x, 28x, 29x, 2Bx, 2Cx, 2Dx, 2Fx, 2Gx, 2Hx, 2Kx, 2Lx, 2Mx, 2Px, 2Rx,
2Vx, 2Wx, 34x, 35x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 25x, 26x, 27x, 29x, 2Ax, 2Bx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Mx, 2Nx,
2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 32x, 35x, 36x, 37x, 38x, 3Bx, 3Cx, 3Dx,
3Ex, 3Fx, 3Gx, 3Hx, 3Px, 3Qx, 3Rx, 3Sx, 3Ux, 45x, 4Bx, 4Cx
• 4284-CTO, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Xx, 3Yx, 3Zx, 45x, 46x, 47x, 48x, 4Ax, 4Bx, 4Cx, 4Dx
21 Thermal module for W520, 45W
04W1576
04W1577
04W1564
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 25x, 27x, 28x, 29x, 2Bx, 2Cx, 2Dx, 2Fx, 2Gx, 2Hx, 2Kx, 2Lx, 2Mx, 2Px, 2Rx,
2Vx, 2Wx, 34x, 35x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 25x, 26x, 27x, 29x, 2Ax, 2Bx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Mx, 2Nx,
2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 32x, 35x, 36x, 37x, 38x, 3Bx, 3Cx, 3Dx,
3Ex, 3Fx, 3Gx, 3Hx, 3Px, 3Qx, 3Rx, 3Sx, 3Ux, 45x, 4Bx, 4Cx
• 4284-CTO, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Xx, 3Yx, 3Zx, 45x, 46x, 47x, 48x, 4Ax, 4Bx, 4Cx, 4Dx
21 Thermal module for W520, 45W
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 25x, 27x, 28x, 29x, 2Bx, 2Cx, 2Dx, 2Fx, 2Gx, 2Hx, 2Kx, 2Lx, 2Mx, 2Px, 2Rx,
2Vx, 2Wx, 34x, 35x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 25x, 26x, 27x, 29x, 2Ax, 2Bx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Mx, 2Nx,
2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 32x, 35x, 36x, 37x, 38x, 3Bx, 3Cx, 3Dx,
3Ex, 3Fx, 3Gx, 3Hx, 3Px, 3Qx, 3Rx, 3Sx, 3Ux, 45x, 4Bx, 4Cx
• 4284-CTO, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Xx, 3Yx, 3Zx, 45x, 46x, 47x, 48x, 4Ax, 4Bx, 4Cx, 4Dx
22
Smart Card module
• 4239-CTO, 22x, 25x, 2Zx, 32x, 33x, 3Nx, 4Cx
• 4240-CTO, 2Ux, 2Vx, 2Xx, 2Yx, 47x
• 4241-CTO
• 4242-CTO, 2Ex, 2Fx, 2Lx, 2Vx, 3Ex, 3Fx, 3Gx, 3Jx, 3Kx, 3Lx, 3Qx, 44x, 4Ex, 4Fx, 4Gx,
4Hx, 4Qx, 58x, 59x
• 4243-CTO, 3Wx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 23x, 24x, 25x, 2Rx, 2Sx, 2Tx, 36x
• 4281-CTO
• 4282-CTO, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Ux, 2Vx, 2Yx, 2Zx, 32x, 33x, 3Kx, 3Lx, 3Px, 3Qx,
3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 45x, 4Bx, 4Cx
• 4284-CTO, 48x, 4Bx, 4Cx, 4Dx
23
24 TrackPoint caps
91P9642
*
150 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 43. Parts list—Overall (continued)
No.
FRU no.
FRU (Overall)
CRU
ID
—
—
Thermal grease
91P8835
N
LCD FRUs
In ThinkPad T520, T520i, and W520, there are following types of LCDs:
• 15.6-inch High Definition (HD) LED-backlight LCD
• 15.6-inch HD+ LED-backlight LCD
• 15.6-inch Full High Definition (FHD) RG-ph LED-backlight LCD
• 15.6-inch Full High Definition (FHD) RG-ph LED-backlight LCD with Multi touch panel
Chapter 11. Parts list 151
Download from Www.Somanuals.com. All Manuals Search And Download.
1
2
3
10
9
8
4
5
6
7
Table 44. Parts list—ThinkPad T520, T520i and W520 LCD FRUs
No.
FRU no.
FRU (ThinkPad T520, T520i and W520 LCD)
CRU
ID
1
1
60Y5482
60Y5483
N
N
LCD bezel assembly
LCD bezel assembly (touch panel)
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x
• 4281-CTO
• 4282-CTO
• 4284-CTO
152 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 44. Parts list—ThinkPad T520, T520i and W520 LCD FRUs (continued)
No.
FRU no.
FRU (ThinkPad T520, T520i and W520 LCD)
CRU
ID
2
04W1364
N
Integrated camera (2.0 MP)
• 4239-CTO, 22x, 23x, 24x, 25x, 26x, 27x, 28x, 2Zx, 32x, 33x, 35x, 36x, 37x, 38x, 39x,
3Ax, 3Nx, 42x, 43x, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx,
2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Xx, 2Yx, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx,
3Kx, 3Lx, 3Mx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 46x, 47x, 48x,
49x, 4Ax, 4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x
• 4242-CTO, 22x, 23x, 24x, 25x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x,
33x, 34x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx,
3Lx, 3Mx, 3Px, 3Qx, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx,
4Mx, 4Qx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x, 53x, 54x, 55x
• 4243-CTO, 27x, 28x, 29x, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Xx, 3Yx, 3Zx, 4Jx, 4Kx, 4Ux,
4Vx, 4Wx, 4Xx, 4Yx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 22x, 23x, 24x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx,
2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 33x, 34x,
35x, 36x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 25x, 26x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Gx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx,
2Px, 2Qx, 2Rx, 2Yx, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx,
3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx,
3Yx, 3Zx, 42x, 45x, 4Cx
• 4284-CTO, 23x, 24x, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 43x, 45x, 46x,
47x, 48x, 49x, 4Ax, 4Cx, 4Dx
3
3
3
3
Hinge kit
Hinge kit
Hinge kit
60Y5484
60Y5485
60Y5486
60Y5487
N
N
N
N
Hinge kit (touch panel)
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x
• 4281-CTO
• 4282-CTO
• 4284-CTO
4
4
LED cable
04W1714
04W1715
N
N
LED cable (touch panel)
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x
• 4281-CTO
• 4282-CTO
• 4284-CTO
5
5
Antenna kit
Antenna kit
45M2897
45M2898
N
N
Chapter 11. Parts list 153
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 44. Parts list—ThinkPad T520, T520i and W520 LCD FRUs (continued)
No.
FRU no.
FRU (ThinkPad T520, T520i and W520 LCD)
CRU
ID
5
6
6
Antenna kit
45M2899
04W1567
04W1568
N
N
N
LCD rear cover assembly
LCD rear cover assembly (touch panel)
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x
• 4281-CTO
• 4282-CTO
• 4284-CTO
7
8
9
04W1566
04W1565
04W1362
N
N
N
Clear plate
LCD cable
LED sub card, without microphone
• 4239-CTO
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
154 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 44. Parts list—ThinkPad T520, T520i and W520 LCD FRUs (continued)
No.
FRU no.
FRU (ThinkPad T520, T520i and W520 LCD)
CRU
ID
9
LED sub card, with microphone
04W1363
N
• 4239-CTO, 22x, 23x, 24x, 25x, 26x, 27x, 28x, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x,
39x, 3Ax, 3Nx, 42x, 43x, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Bx, 4Cx
• 4240-CTO, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx,
2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Xx, 2Yx, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx,
3Kx, 3Lx, 3Mx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 46x, 47x, 48x,
49x, 4Ax, 4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 22x, 23x, 24x, 25x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx,
32x, 33x, 34x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx,
3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Cx, 4Dx, 4Ex, 4Fx,
4Gx, 4Hx, 4Mx, 4Qx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x, 53x, 54x,
55x, 56x, 57x, 58x, 59x
• 4243-CTO, 27x, 28x, 29x, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 4Bx, 4Jx, 4Kx,
4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 22x, 23x, 24x, 25x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx,
2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx,
33x, 34x, 35x, 36x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x,
33x, 34x, 35x, 36x, 37x, 38x, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx,
3Nx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 45x, 4Bx, 4Cx
• 4284-CTO, 23x, 24x, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 43x, 45x,
46x, 47x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx
10
04W0428
N
LCD module, 15.6-inch HD LED-backlight
• 4239-CTO, 22x, 25x, 27x, 28x, 2Zx, 32x, 33x, 35x, 36x, 3Nx, 46x, 47x, 48x, 4Bx, 4Cx
• 4240-CTO, 29x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx,
2Tx, 2Yx, 3Mx, 3Rx, 3Sx, 3Vx, 3Xx, 3Zx, 46x, 4Ax, 4Bx, 4Dx, 4Ex, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 23x, 24x, 25x, 27x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx,
2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Zx, 32x, 34x, 35x, 39x, 3Ax, 3Bx, 3Cx, 3Ex, 3Fx, 3Gx,
3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 45x, 46x, 48x, 4Ex, 4Qx, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x,
53x, 54x, 55x, 58x, 59x
• 4243-CTO, 27x, 29x, 3Rx, 3Sx, 3Yx, 4Jx, 4Kx, 4Vx, 4Wx, 4Yx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 25x, 2Bx, 2Cx, 2Dx, 2Fx, 2Gx, 2Hx, 2Kx, 2Lx, 2Mx
• 4281-CTO
• 4282-CTO, 27x, 2Dx, 2Ex, 2Sx, 2Wx, 32x, 38x, 3Px
• 4284-CTO, 3Tx, 3Ux, 3Vx, 3Xx, 3Yx, 3Zx, 46x, 47x, 48x
Chapter 11. Parts list 155
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 44. Parts list—ThinkPad T520, T520i and W520 LCD FRUs (continued)
No.
FRU no.
FRU (ThinkPad T520, T520i and W520 LCD)
CRU
ID
10
04W0424
N
LCD module, 15.6-inch HD LED-backlight
• 4239-CTO, 22x, 25x, 27x, 28x, 2Zx, 32x, 33x, 35x, 36x, 3Nx, 46x, 47x, 48x, 4Bx, 4Cx
• 4240-CTO, 29x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx,
2Tx, 2Yx, 3Mx, 3Rx, 3Sx, 3Vx, 3Xx, 3Zx, 46x, 4Ax, 4Bx, 4Dx, 4Ex, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 23x, 24x, 25x, 27x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx,
2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Zx, 32x, 34x, 35x, 39x, 3Ax, 3Bx, 3Cx, 3Ex, 3Fx, 3Gx,
3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 45x, 46x, 48x, 4Ex, 4Qx, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x,
53x, 54x, 55x, 58x, 59x
• 4243-CTO, 27x, 29x, 3Rx, 3Sx, 3Yx, 4Jx, 4Kx, 4Vx, 4Wx, 4Yx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 25x, 2Bx, 2Cx, 2Dx, 2Fx, 2Gx, 2Hx, 2Kx, 2Lx, 2Mx
• 4281-CTO
• 4282-CTO, 27x, 2Dx, 2Ex, 2Sx, 2Wx, 32x, 38x, 3Px
• 4284-CTO, 3Tx, 3Ux, 3Vx, 3Xx, 3Yx, 3Zx, 46x, 47x, 48x
10
04W0430
N
LCD module, 15.6-inch HD LED-backlight
• 4239-CTO, 22x, 25x, 27x, 28x, 2Zx, 32x, 33x, 35x, 36x, 3Nx, 46x, 47x, 48x, 4Bx, 4Cx
• 4240-CTO, 29x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx,
2Tx, 2Yx, 3Mx, 3Rx, 3Sx, 3Vx, 3Xx, 3Zx, 46x, 4Ax, 4Bx, 4Dx, 4Ex, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 23x, 24x, 25x, 27x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx,
2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Zx, 32x, 34x, 35x, 39x, 3Ax, 3Bx, 3Cx, 3Ex, 3Fx, 3Gx,
3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 45x, 46x, 48x, 4Ex, 4Qx, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x,
53x, 54x, 55x, 58x, 59x
• 4243-CTO, 27x, 29x, 3Rx, 3Sx, 3Yx, 4Jx, 4Kx, 4Vx, 4Wx, 4Yx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 25x, 2Bx, 2Cx, 2Dx, 2Fx, 2Gx, 2Hx, 2Kx, 2Lx, 2Mx
• 4281-CTO
• 4282-CTO, 27x, 2Dx, 2Ex, 2Sx, 2Wx, 32x, 38x, 3Px
• 4284-CTO, 3Tx, 3Ux, 3Vx, 3Xx, 3Yx, 3Zx, 46x, 47x, 48x
156 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 44. Parts list—ThinkPad T520, T520i and W520 LCD FRUs (continued)
No.
FRU no.
FRU (ThinkPad T520, T520i and W520 LCD)
CRU
ID
10
42T0743
N
N
N
LCD module, 15.6-inch HD+ LED-backlight
• 4239-CTO, 23x, 24x, 34x, 37x, 38x, 39x, 42x, 44x, 45x, 49x, 4Ax
• 4240-CTO, 2Ax, 2Gx, 2Hx, 2Ux, 2Vx, 2Xx, 3Bx, 3Cx, 3Dx, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx,
3Lx, 3Px, 3Qx, 3Tx, 3Ux, 3Wx, 3Yx, 47x, 48x, 49x, 4Cx, 4Fx, 4Gx, 4Hx, 4Kx, 4Lx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 22x, 28x, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 33x, 36x, 37x, 38x, 3Dx, 3Px,
44x, 47x, 49x, 4Ax, 4Gx, 4Hx, 4Mx, 4Rx, 4Sx, 4Tx, 4Ux
• 4243-CTO, 28x, 3Tx, 3Xx, 3Zx, 4Bx, 4Ux, 4Xx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 24x, 27x, 28x, 2Rx, 2Sx, 2Vx, 35x, 38x
• 4281-CTO
• 4282-CTO, 25x, 28x, 29x, 2Ax, 2Bx, 2Fx, 2Hx, 2Jx, 2Tx, 2Ux, 2Vx, 2Xx, 2Zx, 35x, 36x,
37x, 3Bx, 3Cx, 3Dx, 3Fx, 3Lx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 4Bx
• 4284-CTO, 25x, 4Ax, 4Bx, 4Dx
10
93P5681
LCD module, 15.6-inch HD+ LED-backlight
• 4239-CTO, 23x, 24x, 34x, 37x, 38x, 39x, 42x, 44x, 45x, 49x, 4Ax
• 4240-CTO, 2Ax, 2Gx, 2Hx, 2Ux, 2Vx, 2Xx, 3Bx, 3Cx, 3Dx, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx,
3Lx, 3Px, 3Qx, 3Tx, 3Ux, 3Wx, 3Yx, 47x, 48x, 49x, 4Cx, 4Fx, 4Gx, 4Hx, 4Kx, 4Lx
• 4241-CTO, 26x, 42x, 43x, 44x, 45x, 46x, 47x, 48x
• 4242-CTO, 22x, 28x, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 33x, 36x, 37x, 38x, 3Dx, 3Px,
44x, 47x, 49x, 4Ax, 4Gx, 4Hx, 4Mx, 4Rx, 4Sx, 4Tx, 4Ux
• 4243-CTO, 28x, 3Tx, 3Xx, 3Zx, 4Bx, 4Ux, 4Xx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 24x, 27x, 28x, 2Rx, 2Sx, 2Vx, 35x, 38x
• 4281-CTO
• 4282-CTO, 25x, 28x, 29x, 2Ax, 2Bx, 2Fx, 2Hx, 2Jx, 2Tx, 2Ux, 2Vx, 2Xx, 2Zx, 35x, 36x,
37x, 3Bx, 3Cx, 3Dx, 3Fx, 3Lx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 4Bx
• 4284-CTO, 25x, 4Ax, 4Bx, 4Dx
10
04W1544
LCD module, 15.6-inch FHD LED-backlight
• 4239-CTO, 26x, 3Ax, 43x
• 4240-CTO, 3Ex, 4Jx
• 4241-CTO
• 4242-CTO, 3Qx, 4Cx, 4Dx, 4Fx, 56x, 57x
• 4243-CTO, 3Ux, 3Vx, 3Wx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 23x, 29x, 2Ax, 2Ex, 2Jx, 2Nx, 2Px, 2Qx, 2Tx, 2Wx, 2Xx, 2Yx, 2Zx, 33x,
34x, 36x, 37x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 26x, 2Cx, 2Gx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Yx, 33x,
34x, 3Ex, 3Gx, 3Hx, 3Jx, 3Kx, 3Mx, 3Nx, 3Qx, 3Rx, 3Sx, 3Zx, 42x, 45x, 4Cx
• 4284-CTO, 23x, 24x, 26x, 3Wx, 42x, 43x, 45x, 49x, 4Cx
Chapter 11. Parts list 157
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 44. Parts list—ThinkPad T520, T520i and W520 LCD FRUs (continued)
No.
FRU no.
FRU (ThinkPad T520, T520i and W520 LCD)
CRU
ID
10
04W1511
N
LCD module, 15.6-inch FHD LED-backlight, with touch panel
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO, 22x
• 4281-CTO
• 4282-CTO
• 4284-CTO
Keyboard
Table 45. Parts list—Keyboard
Language
FRU no.
CRU
ID
Arabic
45N2216 45N2076 45N2146 **
45N2217 45N2077 45N2147
45N2215 45N2075 45N2145
45N2218 45N2078 45N2148
45N2213 45N2073 45N2143
45N2212 45N2072 45N2142
45N2219 45N2079 45N2149
45N2220 45N2080 45N2150
45N2090 45N2160 45N2230
45N2097 45N2167 45N2237
45N2222 45N2082 45N2152
45N2223 45N2083 45N2153
45N2224 45N2084 45N2154
45N2225 45N2085 45N2155
45N2226 45N2086 45N2156
45N2227 45N2087 45N2157
45N2228 45N2088 45N2158
45N2242 45N2102 45N2172
45N2229 45N2089 45N2159
45N2103 45N2173 45N2243
45N2074 45N2144 45N2214
45N2091 45N2161 45N2231
45N2092 45N2162 45N2232
45N2093 45N2163 45N2233
45N2094 45N2164 45N2234
45N2095 45N2165 45N2235
45N2096 45N2166 45N2236
Belgian
Brazilian Portuguese
Bulgarian
Canadian French (058)
Canadian French (Acnor)
Czech
Danish
Dutch
Finnish, Swedish
French
German
Greek (U.S. English and Greek layout)
Hebrew
Hungarian
Icelandic
Italian
Japanese
Kazakhstan
Korean
Latin American Spanish
Norwegian
Polish
Portuguese
Russian
Slovak
Slovenian
158 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 45. Parts list—Keyboard (continued)
Language
FRU no.
CRU
ID
45N2081 45N2151 45N2221
45N2098 45N2168 45N2238
45N2105 45N2175 45N2245
45N2104 45N2174 45N2244
60Y9552 60Y9554 60Y9550
45N2099 45N2169 45N2239
45N2100 45N2170 45N2240
45N2101 45N2171 45N2241
45N2071 45N2141 45N2211
Spanish
Swiss
Thai
Traditional Chinese
Turkish F Type
Turkish
U.K. English
U.S. English
U.S. English (International, with a Euro symbol)
Miscellaneous parts
Table 46. Parts list—Miscellaneous parts
FRU
FRU no.
CRU
ID
04W1585
N
Screw kit:
• M2 × 2 mm, black (10)
• M2 × 3 mm, silver (30)
• M2 × 4 mm, black (20)
• M2 × 7 mm, black (40)
• M2 × 14 mm, black (40)
• M2.5 × 6 mm, black (20)
• M3 × 5 mm, black (20)
• Hex stud (10)
• Screw cap, oval (10)
• Screw cap, square (15)
Tape kit:
04W1586
N
• Screw cap, oval
• Screw cap, square
• Mylar, cable A
• Mylar, cable B
• Mylar, speaker cable
Chapter 11. Parts list 159
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 46. Parts list—Miscellaneous parts (continued)
FRU
FRU no.
CRU
ID
Base miscellaneous parts:
• Rubber foot (rear)
• Rubber foot (front)
• Gasket, DIMM (L)
• Gasket, DIMM (R)
• Gasket, HDD
04W1583
N
• Wireless switch
• Knob, wireless switch
• ODD bracket assembly
• ODD bar
• ODD switch assembly
• ODD switch spring
• Mesh A, base cover
• Mylar, slice hook
• Mylar, base cover, docking post
• Gasket, docking
• Mylar, DIMM
• Mylar, base cover screw
• Mylar, base cover, docking
04W1584
N
System miscellaneous parts:
• (a) ExpressCard dummy
• (b) Smart Card spacer
• (c) Smart Card dummy
• (d) Smart Card cable
• DC-in cable
• DC-in cable, 170W
• Color sensor dummy
• RJ11 cable
• RJ11 bracket
• RJ11 dummy
04W1582
N
System board miscellaneous parts:
• Thermal pad A
• Thermal pad C
• Thermal pad D
• Thermal pad E
• CPU bracket, UMA/hybrid
• CPU holder assembly, workstation
• Sink holder
• Sponge, keyboard, hybrid/workstation
• Sponge, keyboard, UMA
9-cell slice battery
42T4739
OP
AC adapters
Table 47. Parts list—2-pin ac adapters for ThinkPad T520 and T520i
FRU
FRU no.
CRU
ID
42T5282
42T4423
42T4419
*
2-pin (65 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)
2-pin (65 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)
2-pin (65 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)
160 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 47. Parts list—2-pin ac adapters for ThinkPad T520 and T520i (continued)
FRU
FRU no.
CRU
ID
42T4427
42T4431
42T4435
42T4439
45N0055
45N0059
45N0080
2-pin (90 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)
2-pin (90 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)
2-pin (90 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)
2-pin (90 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)
2-pin (135 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)
2-pin (135 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)
2-pin (135 W, 20 V) adapter (models CTO, xxP)
Table 48. Parts list—2-pin ac adapters for ThinkPad W520
FRU
FRU no.
CRU
ID
45N0114
45N0118
*
2-pin (170 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)
2-pin (170 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)
Table 49. Parts list—3-pin ac adapters for ThinkPad T520 and T520i
FRU
FRU no.
CRU
ID
42T5283
42T4421
42T4417
42T4425
42T4429
42T4433
45N0068
45N0053
45N0057
*
3-pin (65 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)
3-pin (65 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)
3-pin (65 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)
3-pin (90 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)
3-pin (90 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)
3-pin (90 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)
3-pin (90 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)
3-pin (135 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)
3-pin (135 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)
Table 50. Parts list—3-pin ac adapters for ThinkPad W520
FRU
FRU no.
CRU
ID
45N0112
45N0116
*
3-pin (170 W, 20 V) adapte (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)
3-pin (170 W, 20 V) adapte (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)
Power cords
A ThinkPad power cord for a specific country or region is usually available only in that country or region:
Chapter 11. Parts list 161
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 51. Parts list—2-pin power cords
Region
P/N
CRU ID
Argentina
• models -CTO, xxY
42T5020
42T5105
42T5183
42T5093
42T5099
*
Brazil
• models -CTO, xxP
42T5180
42T5008
42T5014
Canada, U.S.
• models -CTO, xxF, xxL, xxS, xxU
Japan
• models -CTO, xxE, xxJ
Table 52. Parts list—3-pin power cords
Region
P/N
CRU ID
Australia, New Zealand
• models -CTO, xxG, xxM
42T5050
42T5135
42T5141
42T5089
42T5150
42T5126
42T5114
42T5168
42T5147
42T5132
42T5162
42T5129
42T5156
42T5120
*
42T5056
42T5004
42T5065
42T5041
42T5029
42T5083
42T5062
42T5047
42T5077
42T5044
42T5071
42T5035
Bangladesh, Sri Lanka, South Africa
• models -CTO, xxG
Canada, U.S.
• models -CTO, xxF, xxL, xxS, xxU
China (P.R.C.) (other than Hong Kong S.A.R.)
• models -CTO, xxC
Denmark
• models -CTO, xxG
European countries
• models -CTO, xxG
India
• models -CTO, xxG
Israel
• models -CTO, xxG
Italy
• models -CTO, xxG
Korea
• models -CTO, xxK
Switzerland
• models -CTO, xxG
Taiwan
• models -CTO, xxV
U.K., China (Hong Kong S.A.R.)
• models -CTO, xxB, xxG, xxH
Recovery discs
Windows 7 Home Basic (32 bit) DVDs
Windows 7 Home Basic (32 bit) is preinstalled as the operating system in the following models:
• 4239-CTO, 36x, 35x
• 4240-CTO, 3Mx, 3Xx, 3Yx
• 4241-CTO, 42x, 43x, 44x, 45x, 46x
162 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
• 4242-CTO, 45x, 46x, 4Xx, 4Zx, 52x
• 4243-CTO
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO
Table 53. Parts list—Windows 7 Home Basic (32 bit) recovery DVDs
Language
P/N
CRU
ID
Arabic
03W7850
03W7851
03W7862
03W7853
03W7854
03W7856
03W7857
03W7859
03W7852
03W7858
03W7860
*
Brazilian Portuguese
English
English (for India)
French
Portuguese
Russian
Serbian-Latin
Simplified Chinese
Spanish
Turkish
Windows 7 Home Premium (64 bit) DVDs
Windows 7 Home Premium (64 bit) is preinstalled as the operating system in the following models:
• 4239-CTO, 37x, 4Cx
• 4240-CTO
• 4241-CTO
• 4242-CTO
• 4243-CTO, 4Jx, 4Kx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
• 4281-CTO
• 4282-CTO
• 4284-CTO, 46x, 47x
Chapter 11. Parts list 163
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 54. Parts list—Windows 7 Home Premium (64 bit) recovery DVDs
Language
P/N
CRU
ID
Arabic
03W7866
03W7867
03W7870
03W7889
03W7888
03W7890
03W7891
03W7892
03W7872
03W7874
03W7873
03W7875
03W7877
03W7878
03W7879
03W7880
03W7881
03W7882
03W7883
03W7886
03W7868
03W7884
03W7885
03W7869
03W7876
03W7887
*
Brazilian Portuguese
Czech
English
English (modem-disabled)
English, Danish, Finnish, Norwegian, and Swedish
English, French, German, Italian, and Dutch
English, Slovenian, and Croatian
French
German
Greek
Hebrew
Hungarian
Japanese
Korean
Polish
Portugese
Romanian
Russian
Serbian-Latin
Simplified Chinese
Slovak
Spanish
Traditional Chinese
Traditional Chinese (Hong Kong S.A.R.)
Turkish
Windows 7 Professional (32 bit) DVDs
Windows 7 Professional (32 bit) is preinstalled as the operating system in the following models:
• 4239-CTO, 34x, 4Bx
• 4240-CTO, 2Bx, 3Gx, 3Hx, 4Mx, 4Nx, 4Px, 4Qx
• 4241-CTO, 47x
• 4242-CTO, 23x, 24x, 25x, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Hx, 2Jx, 2Px, 2Qx, 2Rx, 2Sx, 3Ax, 3Bx, 3Cx,
3Dx, 3Fx, 3Gx, 44x, 56x, 57x
• 4243-CTO, 3Sx, 3Xx, 3Yx
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO
• 4276-CTO
164 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
• 4281-CTO
• 4282-CTO, 29x, 3Px
• 4284-CTO, 48x
Table 55. Parts list—Windows 7 Professional (32 bit) recovery DVDs
Language
P/N
CRU
ID
English
03W7818
03W7817
03W7816
*
Japanese
Simplified Chinese
Windows 7 Professional (64 bit) DVDs
Windows 7 Professional (64 bit) is preinstalled as the operating system in the following models:
• 4239-CTO, 22x, 23x, 24x, 25x, 26x, 38x, 39x, 3Ax, 42x, 43x, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax
• 4240-CTO, 29x, 2Ax, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx,
2Ux, 2Vx, 2Xx, 2Yx, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Jx, 3Kx, 3Lx, 3Px, 3Qx, 3Rx, 3Tx, 3Vx, 3Wx, 46x, 47x,
48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx
• 4241-CTO, 26x, 48x
• 4242-CTO, 22x, 27x, 28x, 29x, 2Ax, 2Gx, 2Kx, 2Lx, 2Mx, 2Nx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x,
33x, 34x, 35x, 36x, 37x, 38x, 39x, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 47x, 48x, 49x, 4Ax, 4Cx, 4Dx,
4Ex, 4Fx, 4Gx, 4Hx, 4Mx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Yx, 53x, 54x, 55x, 58x, 59x
• 4243-CTO, 27x, 28x, 29x, 3Rx, 3Tx, 3Ux, 3Vx, 3Wx, 3Zx, 4Bx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 5Ax
• 4244-CTO
• 4246-CTO
• 4249-CTO
• 4260-CTO
• 4270-CTO, 26x
• 4276-CTO, 22x, 23x, 24x, 25x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx,
2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 33x, 34x, 35x, 36x, 37x, 38x, 39x
• 4281-CTO
• 4282-CTO, 23x, 24x, 25x, 26x, 27x, 28x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx,
2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x, 3Bx,
3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx,
3Yx, 3Zx, 42x, 45x, 4Bx, 4Cx
• 4284-CTO, 23x, 24x, 25x, 26x, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 43x, 45x, 49x, 4Ax, 4Bx, 4Cx, 4Dx
Table 56. Parts list—Windows 7 Professional (64 bit) recovery DVDs
Language
P/N
CRU ID
Arabic
03W7819
03W7820
03W7823
03W7842
03W7841
03W7824
03W7843
03W7844
03W7845
03W7825
*
Brazilian Portuguese
Czech
English
English (modem-disabled)
English (for India)
English, Danish, Finnish, Norwegian, and Swedish
English, French, German, Italian, and Dutch
English, Slovenian, and Croatian
French
Chapter 11. Parts list 165
Download from Www.Somanuals.com. All Manuals Search And Download.
Table 56. Parts list—Windows 7 Professional (64 bit) recovery DVDs (continued)
Language
P/N
CRU ID
03W7827
03W7826
03W7828
03W7830
03W7831
03W7832
03W7833
03W7834
03W7835
03W7836
03W7839
03W7821
03W7837
03W7838
03W7822
03W7829
03W7840
German
Greek
Hebrew
Hungarian
Japanese
Korean
Polish
Portugese
Romanian
Russian
Serbian-Latin
Simplified Chinese
Slovak
Spanish
Traditional Chinese
Traditional Chinese (Hong Kong S.A.R.)
Turkish
Common service tools
Table 57. Parts list—Common service tools
Tool
P/N
95F3598
1650840
93F2838
00P6967
08K7159
40Y8687
40Y8704
05K9283
27L3452
42W7820
—
Screwdriver kit
1/4" drive spinner handle
1/4" Sq. to 1/4" hex torx adapter
TR7-TR-10 tamper resistant torx bits
Antenna RF connector removal tool
USB 2.0 CD-RW/DVD-ROM combo drive II
USB cable
USB floppy diskette drive for maintenance diskette
USB floppy diskette drive tool kit
Test card for integrated Smart Card
LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later
166 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Appendix A. Notices
Lenovo may not offer the products, services, or features discussed in this document in all countries. Consult
your local Lenovo representative for information on the products and services currently available in your
area. Any reference to a Lenovo product, program, or service is not intended to state or imply that only that
Lenovo product, program, or service may be used. Any functionally equivalent product, program, or service
that does not infringe any Lenovo intellectual property right may be used instead. However, it is the user’s
responsibility to evaluate and verify the operation of any other product, program, or service.
Lenovo may have patents or pending patent applications covering subject matter described in this
document. The furnishing of this document does not give you any license to these patents. You can send
license inquiries, in writing, to:
Lenovo (United States), Inc.
1009 Think Place - Building One
Morrisville, NC 27560
U.S.A.
Attention: Lenovo Director of Licensing
LENOVO PROVIDES THIS PUBLICATION “AS IS” WITHOUT WARRANTY OF ANY KIND, EITHER EXPRESS
OR IMPLIED, INCLUDING, BUT NOT LIMITED TO, THE IMPLIED WARRANTIES OF NON-INFRINGEMENT,
MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. Some jurisdictions do not allow
disclaimer of express or implied warranties in certain transactions, therefore, this statement may not apply
to you.
This information could include technical inaccuracies or typographical errors. Changes are periodically
made to the information herein; these changes will be incorporated in new editions of the publication.
Lenovo may make improvements and/or changes in the product(s) and/or the program(s) described in this
publication at any time without notice.
The products described in this document are not intended for use in implantation or other life support
applications where malfunction may result in injury or death to persons. The information contained in this
document does not affect or change Lenovo product specifications or warranties. Nothing in this document
shall operate as an express or implied license or indemnity under the intellectual property rights of Lenovo
or third parties. All information contained in this document was obtained in specific environments and is
presented as an illustration. The result obtained in other operating environments may vary.
Lenovo may use or distribute any of the information you supply in any way it believes appropriate without
incurring any obligation to you.
Any references in this publication to non-Lenovo Web sites are provided for convenience only and do not in
any manner serve as an endorsement of those Web sites. The materials at those Web sites are not part of
the materials for this Lenovo product, and use of those Web sites is at your own risk.
Any performance data contained herein was determined in a controlled environment. Therefore, the result
obtained in other operating environments may vary significantly. Some measurements may have been
made on development-level systems and there is no guarantee that these measurements will be the same
on generally available systems. Furthermore, some measurements may have been estimated through
extrapolation. Actual results may vary. Users of this document should verify the applicable data for their
specific environment.
© Copyright Lenovo 2011
167
Download from Www.Somanuals.com. All Manuals Search And Download.
Electronic emissions notices
For electronic emission information on Class B digital devices, refer to the corresponding information in
the User Guide.
Trademarks
The following terms are trademarks of Lenovo in the United States, other countries or both:
Active Protection System
Lenovo
ThinkLight
ThinkPad
ThinkVantage
TrackPoint
Ultrabay
UltraNav
The following terms are trademarks of Microsoft Corporation in the United States, other countries, or both:
Windows
Windows Vista
The following terms are trademarks of Intel Corporation or its subsidiaries in the United States, other
countries, or both:
Intel
Intel Centrino
Intel Core
Other company, product, or service names may be the trademarks or service marks of others.
168 ThinkPad T520, T520i, and W520 Hardware Maintenance Manual
Download from Www.Somanuals.com. All Manuals Search And Download.
Download from Www.Somanuals.com. All Manuals Search And Download.
Part Number: 0A60078_02
Printed in
(1P) P/N: 0A60078_02
*0A60078_02*
Download from Www.Somanuals.com. All Manuals Search And Download.
|
