Total Air Purification
Permanent HEPA
Air Purifier
Owner’s Manual
Model
30849
Form# 44069-01
20100618
©2010 Hunter Fan Co.
Download from Www.Somanuals.com. All Manuals Search And Download.
InTroduCTIon
Thank you for purchasing the Total Air Purification System
from Hunter Fan Company. You have purchased our
latest development in Portable Air Purification Systems.
This system has been developed to improve the quality of
the air you breathe.
Our Permanent HEPA Air Purification System out
performs other air purification systems by quickly and
effectively removing dust, smoke, and pollen particles as
small as 0.3 microns in size. The following innovative
features are included in your Hunter Air Purifier.
3 High Particulate Efficiency: The permanent
HEPA filter will remove up to 99.9% of particles as
small as 0.3 micron particles from the air that passes
through the filter.
3 Washable Pre-Filter: The washable pre-filter is
permanent and can be cleaned and reused.
3 UVC Lamp: This Hunter Air Purifier is equipped
with a UVC germicidal lamp. UVC technology is a
proven germicide that is accepted by the FDA and
EPA as having the ability to kill pathogens in air that
are exposed to UVC light.
3 Photocatalitic Oxidation: Reduces the amount
of toxic VOCs in the air caused by household cleaners
and products.
3 Oxygenating Catalyst: Converts ozone and
smog into oxygen for cleaner air and peace of mind.
3 Remote Operation: Convenient remote allows
operation of UVC and speed settings.
safeTy InsTruCTIons
IMPORTANT!
READ ALL INSTRUCTIONS BEFORE USING THIS AIR
PURIFIER.
1. WARNING: This Air Purifier emits UVC radiation that
may cause eye and/or skin irritation. RG-3. Avoid
exposing eyes and skin to unshielded UVC Lamp.
2. CAUTION: The UVC Lamp may shatter and cause
injury if it is dropped or sustains impact. Wear safety
glasses and gloves when handling the UVC Lamp.
©2010 Hunter Fan Co.
3
44069-01 20100618
Download from Www.Somanuals.com. All Manuals Search And Download.
Do not use excessive force when handling the UVC
Lamp. Dispose of the UVC bulb in accordance with
local or State guidelines as trace amounts of Mercury
are present.
3. This Air Purifier is designed for use on a level floor and
may not work properly on an uneven floor. ALWAYS
place the Air Purifier on a firm, level floor. ALWAYS
place the Air Purifier at least six (6) inches away from
walls and heat sources such as stoves, radiators, or
heaters.
4. Place the Air Purifier in an area that is out of the reach
of children.
5. Before using the Air Purifier, extend the cord and
inspect for any signs of damage. DO NOT use the
product if the cord has been damaged.
6. To reduce the risk of electric shock, this product has
a polarized plug (one blade is wider than the other)
as a safety feature. This plug will fit into a polarized
outlet only one way. If the plug does not fit fully into
the outlet, reverse the plug. If it still does not fit, contact
a qualified electrician. DO NOT attempt to defeat or
override this safety feature.
7. ALWAYS UNPLUG the Air Purifier while it is being
cleaned.
8. DO NOT move or tilt the Air Purifier while it is in
operation. Turn off and unplug before moving.
9. DO NOT immerse the Air Purifier in water at any time
because permanent damage will occur. To properly
clean your Air Purifier, follow the instructions in the
Maintenance section of this manual “Air Purifier
10. This equipment should be inspected frequently and
collected dirt removed from it regularly to prevent
excessive accumulation that could result in flashover
or risk of fire.
©2010 Hunter Fan Co.
4
44069-01 20100618
Download from Www.Somanuals.com. All Manuals Search And Download.
seTTIng up your aIr purIfIer
1. Take the Air Purifier out of the box and remove the
clear plastic protective bag and place the unit on a
firm, level surface.
Tab
2. Before turning on the Air Purifier, you need to confirm
that the filters are firmly in place and have not become
loose during shipping. To check the filters, push down
on the tab under the handle. Figure 1.
3. Gently pull the rear grill away from the unit and lift
away. Figure 2.
figure 1.
4. The washable Pre-Filter is mounted inside the back
grill of the unit. Confirm that it properly covers the
grill vents.
5. The Permanent HEPA Filter will be resting inside the
unit. If present, remove the plastic bag surrounding
the filter and place the filter back into the Air Purifier.
The filter should have arrows on the side to indicate
air flow and the direction the filter should be placed
back into the unit. Figure 3.
figure 2.
6. Set the tab on the bottom of the rear grill into the slot
in the base of the unit and rock the grill up until the
top tab snaps into place. Figure 4.
7. Plug the unit into a 120V electrical outlet.
Permanent
HEPA Filter
figure 3.
figure 4.
©2010 Hunter Fan Co.
5
44069-01 20100618
Download from Www.Somanuals.com. All Manuals Search And Download.
How THe sysTem works
Dust and other irritants are pulled into the Air Purifier by the fan. The Washable Pre-Filter
attracts larger particles like pet dander and hair and traps them on the Pre-Filter. Smaller
particles such as dust, mold, and pollen pass through the Pre-Filter and are captured by the
Permanent HEPA filter. Up to 99.9% of particles can be captured.
The UVC Light helps kill particles not trapped on the Permanent HEPA Filter and the
Photocatalytic Oxidation screen removes harmful VOC’s. Clean, purified air is then released
into the room through the front grill as the Oxygenating Catalyst converts smog and ozone
back into oxygen. Figure 5.
Unit
Washable
Pre-Filter
Photocatalytic
Oxidizer
Grill
UVC
Light
Permanent
HEPA Filter
Oxygenating Catalyst
figure 5.
©2010 Hunter Fan Co.
6
44069-01 20100618
Download from Www.Somanuals.com. All Manuals Search And Download.
UVC
on/off
operaTIng your aIr purIfIer
Ultra Low - No background noise.
Speed
Low speed - Recommended for use when soft
background noise is unwanted.
UV
SPEED
Medium speed - Typical usage setting. Soft
background noise is not an issue.
SPEED
UV
ON / OFF
High speed - Use when quick, efficient results
to a room’s air quality are desired.
figure 6.
The fan speed can be adjusted at any time by pressing
the
Speed button until the desired speed is selected.
ON
OFF
Press the
UVC function of your Air Purifier.
UVC Light Button to turn on and off the
UV
NOTE: The ON/OFF Indicator and the UVC Indicator
will stay lit while the fan and/or UVC is running.
figure 7.
remoTe operaTIon
See Figure 7.
ON
OFF
Turns the unit on or off.
Turns the UVC light on or off.
UV
Press
Down
Adjusts the speed of the air purifier between
high, medium, or low.
aIr purIfIer maInTenanCe
figure 8.
It is necessary to periodically check your Air Purifier for
performance. If the Pre-Filter and/or Permanent HEPA
Filter are covered in dust and other captured particles, it
will be necessary to clean one and or both. The Pre-Filter
and Filter should be checked at least every 6 months. The
UVC Light should be replaced every year.
NOTE: Some environments may require more frequent
cleaning of each filter. In these situations, adjust the time
you check your filters to ensure the filters stay clog free to
optimize performance.
©2010 Hunter Fan Co.
7
44069-01 20100618
Download from Www.Somanuals.com. All Manuals Search And Download.
Check or Clean your pre-filter
1. Turn the Air Purifier off and disconnect from the wall.
2. Remove the rear grill on the back of the unit by
pressing the tab at the top of the unit, under the
handle and pull the rear grill outward. Figure 8.
3. Turn the Rear grill over and gently remove the Pre-
Filter from the grill.
4. Check the Pre-Filter side facing the grill for particle
coverage.
figure 9.
5. If the Pre-Filter needs to be cleaned, It may be
submerged in warm soapy water to clean. Gently lift
and submerge the filter several times to clean.
6. When complete, rinse the filter with warm water and
allow to dry completely.
Screws
Note: Wet parts placed into the unit can cause damage
to the filters and or the motor of the Air Purifier.
Check or Clean your filter
figure 10.
1. Turn the Air Purifier off and disconnect from the wall.
2. Remove the rear grill on the back of the unit by
pressing the tab at the top of the unit, under the
handle and pull the rear grill outward. Figure 8.
3. Remove the Permanent HEPA Filter from the unit.
4. Check the Filter for particle build-up.
Screws
5. To clean, use a vacuum cleaner with an upholstery
brush attachment, gently run the upholstery brush
over the cleanable filter until all particles are removed
from the filter. An arrow indicating which side to clean
is present on the top of the filter. Figure 9.
figure 11.
Note: Filter discoloration is normal and will not be
removed by vacuuming. Do not attempt to wash the filter
as damage to the filter or Air Purifier may occur.
replace The uVC bulb
The UVC light should be replaced once yearly. Follow
these instructions to remove and replace the UVC bulb.
1. Unplug the unit from the wall outlet and remove the
back grill by pressing down on the top tab.
figure 12.
©2010 Hunter Fan Co.
8
44069-01 20100618
Download from Www.Somanuals.com. All Manuals Search And Download.
2. Remove the 2 screws holding the Photcatalytic Screen
in place and remove the screen. Figure 10.
3. Remove the 3 screws holding the UVC Guard in place
and remove it from the unit. Figure 11. & 12.
4. Grasp the bulb with your thumbs and forefingers at
the plastic top and bottom and gently roll the bulb to
the left. Figure 13.
5. When the bulb releases, slide the top of the bulb out
of the bracket and remove.
figure 13.
figure 14.
figure 15.
6. Partially remove the new UVC Bulb from it’s packaging
being careful not to let the bulb come in contact with
your skin.
Note: Oils from your skin can cause damage to the bulb
and will prevent it from working.
7. Using the bag the bulb came in to prevent skin contact
with the bulb, insert the base of the bulb into the lower
UVC socket in the unit, with the flat side of the base
facing the opening of the unit. Figure 14.
8. Insert the top part of the UVC bulb into the top socket
and roll the bulb to the right util it locks into place.
Note: If the UVC Bulb Guard is not re-installed correctly,
the unit will not run.
9. Reattach the UVC Guard by inserting the back tabs
into the Air Purifier and secure the 3 screws holding it
back in place. Figure 15.
10. Align the Photocatalytic Screen over the 2 holes in
the unit and screw it back into place.
11. Set the tab on the bottom of the rear grill into the slot
in the base of the unit and rock the grill up until the
top tab snaps into place.
Clean the unit
Clean the outside of the unit with a soft, damp cloth.
The rear grill can be cleaned in soapy water after it has
been removed from the unit and the pre-filter has been
removed.
NOTE: Ensure the grill is completely dry before
reinstalling it on the unit. Failure to do so could cause
damage to the filters or motor.
figure 16.
©2010 Hunter Fan Co.
9
44069-01 20100618
Download from Www.Somanuals.com. All Manuals Search And Download.
TroublesHooTIng
Problem:
Solution:
No Operation.
3 Confirm that the unit is plugged in.
3 Check the installation of the Rear grill.
3 Check the installation of the UVC Lamp Cover.
Problem:
Unit has reduced air flow or increased noise.
Solution:
3 The filter may be clogged and needs to be
cleaned. See “Check or Clean Your Filter” on
page 10.
Problem:
The UVC Lamp is not operating.
Solution:
3 Check the installation of the UVC Bulb.
TeCHnICal supporT
If you have any additional questions or problems with
your Hunter Air Purifier, please call:
USA: 1-888-830-1326
Canada: 1-866-268-1936
Hours of operation are from 7:00 am to 7:00 pm
Monday - Friday and 8:00 am to 5:00 pm on Saturday,
Central Time. You may also contact us over the Internet at
©2010 Hunter Fan Co.
10
44069-01 20100618
Download from Www.Somanuals.com. All Manuals Search And Download.
fIlTer orderIng
produCTs
Your Permanent HEPA filter and Washable pre-filters
should never need to be replaced. Follow the cleaning
instructions in this manual for care.
Ceiling Fans
Replacement UVC bulbs are available from the Hunter
Fan Company by contacting us at:
Humidifiers
Air Purifiers
Phone: 1-888-830-1326
* Applicable state and local taxes may apply.
* Prices are subject to change without notice.
All orders will be shipped USPS or UPS Ground, allow
12-15 working days for delivery.
part#
Type
30851
uVC bulb
warranTy
Thermostats
Bath Fans
Hunter Fan Company
Total Air Purification System
5 YEAR LIMITED WARRANTY
The Hunter Fan Company makes the following limited
warranty to the original residential user or consumer
purchaser of the Total Air Purification System:
If any part of your Total Air Purification System (“Air
Purifier”) motor fails during the first five (5) years from
the date of installation due to a defect in material or
workmanship, we will provide a replacement Air Purifier
free of charge. Installation is deemed to occur at the date
of purchase.
If the Air Purifier cord, ionizer, or rear grill fails any
time within one (1) year after installation due to a defect
in material or workmanship, we will replace or, at our
option, repair the unit free of charge at our nearest
service center or at our Service Department in Memphis,
Tennessee. You will be responsible for all parts and labor
costs after this one-year period.
Oscillating Fans
©2010 Hunter Fan Co.
11
44069-01 20100618
Download from Www.Somanuals.com. All Manuals Search And Download.
IF THE ORIGINAL RESIDENTIAL USER OR CONSUMER
PURCHASER CEASES TO OWN THE AIR PURIFIER,
THIS WARRANTY AND ANY IMPLIED WARRANTY
WHICH THEN REMAINS IN EFFECT, INCLUDING
BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR
PURPOSE, ARE VOIDED. NO WARRANTY, EXPRESSED
OR IMPLIED, INCLUDING ANY WARRANTY OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR
PURPOSE, IS MADE IN RESPECT TO THE FILTER
MATERIAL OR WASHABLE FILTER. THIS WARRANTY IS
IN LIEU OF ALL OTHER EXPRESS WARRANTIES. THE
DURATION OF ANY IMPLIED WARRANTY, INCLUDING
BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR
PURPOSE, IN RESPECT TO THE MOTOR IS EXPRESSLY
LIMITED TO THE PERIOD OF THE EXPRESS WARRANTY
SET FORTH ABOVE.
This warranty is voided if the air purifier is not purchased
and used in the USA or Canada.
This warranty excludes and does not cover defects,
malfunctions or failures of the Air Purifier which were
caused by repairs by persons not authorized by us, use of
parts or accessories not authorized by us, mishandling,
modifications, or damage to the Air Purifier while in
your possession, or unreasonable use, including failure
to provide reasonable and necessary maintenance. This
warranty does not cover Air Purifiers used in commercial
applications. There are no express or implied warranties
as to commercial purchasers or users.
To obtain service, contact the nearest Hunter authorized
service center or the Hunter Fan Company Service
Department, 7130 Goodlett Farms Pkwy., Suite 400,
Memphis, TN 38016, 1-888-830-1326. For the name
of our nearest authorized Hunter Fan Company Service
Center, write to the Hunter Fan Company at the preceding
address. You will be responsible for insurance and freight
or other transportation to our factory service center. We
will return the Air Purifier freight prepaid. The Air Purifier
should be properly packaged to avoid damage in transit
since we will not be responsible for any such damage.
Proof of purchase is required when requesting warranty
service. The purchaser must present sales receipt or other
document that establishes proof of purchase.
©2010 Hunter Fan Co.
12
44069-01 20100618
Download from Www.Somanuals.com. All Manuals Search And Download.
INNOEVENTSHALLHUNTERFANCOMPANYBELIABLE
FOR DIRECT, INDIRECT, SPECIAL CONSEQUENTIAL OR
INCIDENTAL DAMAGES IN EXCESS OF THE PURCHASE
PRICE OF THE AIR PURIFIER. YOUR SOLE REMEDY
WILL BE REPAIR OR REPLACEMENT AS PROVIDED
ABOVE. SOME AMERICAN STATES AND CANADIAN
PROVINCES DO NOT ALLOW LIMITATIONS ON HOW
LONG AN IMPLIED WARRANTY LASTS, SO THE ABOVE
LIMITATION MAY NOT APPLY TO YOU.
SOME AMERICAN STATES AND CANADIAN
PROVINCES DO NOT ALLOW THE EXCLUSION
OR LIMITATION OF DIRECT, INDIRECT SPECIAL,
INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE
ABOVE LIMITATION MAY NOT APPLY TO YOU. SOME
AMERICAN STATES AND CANADIAN PROVINCES
DO NOT ALLOW THE EXCLUSION OR INVALIDITY
OF EXPRESS OR IMPLIED WARRANTIES IF THE USER
CEASES TO OWN THE AIR PURIFIER, SO THE ABOVE
LIMITATION MAY NOT APPLY TO YOU.
THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS,
AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH
VARY FROM STATE TO STATE OR PROVINCE TO
PROVINCE.
Fan Company
7130 Goodlett Farms Pkwy., Suite 400
Memphis, Tennessee 38016
To learn more about Hunter
Fan Company products,
please see our Web page at:
www.hunterfan.com
©2010 Hunter Fan Co.
13
44069-01 20100618
Download from Www.Somanuals.com. All Manuals Search And Download.
|
