MULTIPURPOSE
GARDEN CART
91121
ASSEMBLY & OPERATING INSTRUCTIONS
®
3491 Mission Oaks Blvd., Camarillo, CA 93011
Copyright© 2004 by Harbor Freight Tools®. All rights reserved. No portion of this manual or
any artwork contained herein may be reproduced in any shape or form without the
express written consent of Harbor Freight Tools.
For technical questions and replacement parts please call 1-800-444-3353.
Download from Www.Somanuals.com. All Manuals Search And Download.
9. Maintain products with care. Keep the Multipurpose Garden Cart in a dry location. Do not
expose it to prolonged sunlight or prolonged moisture.
10. Do not exceed the maximum weight capacity.
11. Do not allow children to play on, stand upon or climb on the Garden Cart. Adults should
not lean on or use the Garden Cart as a seat.
12. Keep plastic bags (not included) out of the reach of children and pets. Beware that plastic
trash bags (not included) used with the Garden Cart can be a hazard to children and pets.
Plastic bags if used incorrectly can cause choking, suffocation and other injury.
13. Do not overreach. Keep proper footing and balance at all times.
14. Use the right Garden Cart for the job. Do not attempt to force a small Garden Cart to do the
work of a larger Garden Cart. There are certain applications for which this Garden Cart was
designed. Do not modify this Garden Cart and do not use this Garden Cart for a purpose for
which it was not intended.
15. Do not use or assemble the Garden Cart if under the influence of alcohol or drugs. Read
warning labels on prescriptions to determine if your judgement or reflexes are impaired while
taking drugs. If there is any doubt, do not assemble or use the Garden Cart.
16. Only use the Garden Cart on a flat, level and solid surface. The surface must be able to
support the Garden Cart, as well as any tools, accessories or debris that is stored on the
Garden Cart.
WARNING: The warnings, cautions, and instructions discussed in this instruction manual cannot
cover all possible conditions and situations that may occur. It must be understood by
the operator that common sense and caution are factors which cannot be built into
this product, but must be supplied by the operator.
Assembly/ Operation
Your Multi-Purpose Garden Cart will require complete assembly. It is important that you read the
entire manual to become familiar with the product BEFORE you use the Multi-Purpose Garden
Cart. Before assembling the Garden Cart be sure that you have all parts described in the Parts List
and Assembly Diagram located on the last pages of this manual.
1.
Insert the Handle (1) down through the Upper Tray (2)-see Figure 1. Insert one Screw (3)
through each side of the Upper Tray (2) and into the Handle (1) as shown in Figure 1.
Figure 1
Handle (1)
Upper Tray (2)
Screw (3)
SKU 91121
Page 3
Download from Www.Somanuals.com. All Manuals Search And Download.
2.
Slide the Handle (1) down into the Body (4)-see Figure 2.
Figure 2
Figure 3
Handle (1)
Nut (9)
Middle
Tray (11)
Body (4)
Stretcher (15)
Pins
Wheel (7)
Sleeve (5)
Install Locking
Washers (10)
Lower Tray (12)
Axle (6)
3.
4.
Slide the Axle (6) through each of the eyelets located at each side on the bottom of the
Body (4). Slide one Sleeve (5) onto each end of the Axle (6)-see Figure 2.
Slide Wheel (7) over the Sleeve (5). Place Washer (8) on end of Axle (6) and thread on
Nut (9) to secure Wheel (7) in place-see Figure 3 (insert). Repeat for second side of the
Axle (7).
5.
Set the Stretcher (15) over the pins located on the sides of the Body (4) near its base-see
Figure 3. Install Locking Washers (10) on each side to secure Stretcher (15) in place.
6.
7.
Snap the Middle Tray (11) into place at the top of the Body (4) as shown in Figure 2.
The Lower Tray (12) is to be installed at the bottom of the Body with part of it resting on the
Platform (13)-see Figure 3. Place the hooks of the Lower Tray (12) over the bottom bar on
the Body (4).
8.
The Garden Cart can now be used to carry and tranport garden tools. Roll the Garden Cart
to the desired location. Locate a solid, firm and level location that is capable of supporting
the Garden Cart and it’s load. Fold out the Platform (13) so that the Platform (13) rests on
the ground. Make certain that the Platform snaps into place and is secured by the Quick
Lock/Unlock Mechanism (14)-see Figure 4. Be careful that tools being transported are
positioned so that they will not fall out of the cart.
9.
The Garden Cart can hold a plastic bag (not included) for collection of trash and debris. Pull
down on the Stretcher (15) until it is fully extended. Set a plastic Bag so that it rests over the
Stretcher (15), and roll and tuck the inside of the plastic bag (not included) into the slots on
the Body (4)-see Figure 5.
Lock/
Stretcher (15)
Unlock Mechanism (14)
Platform (13)
Figure 4
Figure 5
Bag not included
SKU 91121
Page 4
Download from Www.Somanuals.com. All Manuals Search And Download.
Unpacking
When unpacking the Multi-Purpose Garden Cart, check to make sure the following parts are
included. If any parts are missing or broken, please call HARBOR FREIGHT TOOLS at
1-800-444-3353.
Parts List
Part # Description
Quantity Part # Description
Quantity
1
2
3
4
5
6
7
8
9
Handle
Upper Tray
Screw
Body
Sleeve
Axle
Wheel
Washer
Nut
1
1
2
1
2
1
2
2
2
10
11
12
13
14
Locking Washer
Middle Tray
Lower Tray
2
1
1
1
Platform
Quick Lock/Unlock
Mechanism
Stretcher
1
1
15
Note: Some parts are listed and shown for illustration purposes only and are not available
individually as replacement parts.
Assembly/Parts Diagram
1
2
3
15
11
4
10
12
8,9
7
6
5
14
13
PLEASE READ THE FOLLOWING CAREFULLY
THE MANUFACTURER AND/OR DISTRIBUTOR HAS PROVIDED THE PARTS DIAGRAM IN THIS MANUAL AS A REFERENCE
TOOL ONLY. NEITHER THE MANUFACTURER NOR DISTRIBUTOR MAKES ANY REPRESENTATION OR WARRANTY OF ANY
KIND TO THE BUYER THAT HE OR SHE IS QUALIFIED TO MAKE ANY REPAIRS TO THE PRODUCT OR THAT HE OR SHE IS
QUALIFIED TO REPLACE ANY PARTS OF THE PRODUCT. IN FACT,THE MANUFACTURER AND/OR DISTRIBUTOR
EXPRESSLY STATES THAT ALL REPAIRS AND PARTS REPLACEMENTS SHOULD BE UNDERTAKEN BY CERTIFIED AND
LICENSED TECHNICIANS AND NOT BY THE BUYER.THE BUYER ASSUMES ALL RISK AND LIABILITY ARISING OUT OF HIS
OR HER REPAIRS TO THE ORIGINAL PRODUCT OR REPLACEMENT PARTS THERETO, OR ARISING OUT OF HIS OR HER
INSTALLATION OF REPLACEMENT PARTS THERETO.
SKU 91121
Page 5
Download from Www.Somanuals.com. All Manuals Search And Download.
|