O u t d o o r G r i l l i n g P r o d u c t s
PORTABLE ELECTRIC GRILL
MODEL: CEG-980 OWNER’S GUIDE
m You must read this Owner’s Guide m This grill is intended for outdoor household use
only. Do not use indoors or for commenercial
cooking. Fuel, such as charcoal briquettes, is not
before operating your electric grill
This appliance is rated for
• 120volts – 50/60Hz,
• Output: 1500W
• Use only AUONE, type TP-W51-01 temperature-
controlling plug.
to be used with appliance.
The supply cord should be regularly examined for
signs of damage and the appliance is not to be used
if the cord is damaged.
When using electrical appliances, basic safety precautions should always be followed including the following:
Read all instructions
m IMPORTANT SAFEGUARDS
• CAUTION: To ensure continued protection against risk of
electric shock, connect to properly grounded three prong
GFI outlets only. Do not use a two prong adapter
and before cleaning. Allow to cool before handling.
• Do not operate any appliance with a damaged cord or
plug or after the appliance malfunctions or is dropped
or damaged in any manner. Return appliance to the near-
est authorized service facility for examination
repair, or adjustment.
• Read all instructions.
• WARNING: Use only outdoors, do not expose to rain.
This is to prevent electric shock which can cause serious
bodily injury or death.
• Do not let cord hang over edge of table or counter or
touch hot surfaces.
• WARNING: Disconnect appliance from supply circuit
before performing maintenance and cleaning.
• Where applicable, always attach plug to appliance and
check that the control is OFF before plugging cord into
wall outlet. To disconnect, turn the control to OFF, then
remove plug from wall outlet.
• WARNING: For protection against risk of electric shock,
connect to properly grounded outlets only.
• WARNING: For protection against risk of electric shock,
keep extension cord connection dry and off the ground.
• Do not use appliance for other than intended use.
• Avoid contacting moving parts.
• CAUTION: Store Temperature Controller Indoors when
not in use.
• Fuel, such as charcoal briquettes, is not to be used with
appliance.
• Do not clean with metal scouring pads. Pieces can break
off the pad and touch electrical parts, creating a risk of
electric shook.
• To protect against electrical shock do not immerse cord,
plugs, portable appliances in water or liquid.
• Do not use charcoal in this appliance.
• The use of accessory attachments not recommended by
the appliance manufacturer may cause injuries.
• Do not touch surfaces that may be hot. Use handles or
knobs provided.
• Do not place on or near a hot gas or electric burner, or in
a heated oven.
• To protect against electrical shock do not immerse cord,
plugs, protable applicnces (or other specific part or
parts) in water or other liquid.
• Extreme caution must be used when moving an
appliance containing hot oil or other hot liquids.
• Close supervision is necessary when any appliance is
used by or near children.
• USE ONLY AUONE, TYPE TP-W51 TEMPERATURE
CONTROLLING PLUG.
• Make sure appliance is OFF and remove plug from outlet • Household use only.
when not in use, before putting on or taking off parts,
1
SAVE THESE INSTRUCTIONS
Download from Www.Somanuals.com. All Manuals Search And Download.
1. IMPORTANT SAFEGUARDSns
Table of Contents
DANGER
Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result
in serious bodily injury or death, or in fire or an explosion causing damage to property.
1. Important Safeguards
2. Illustrated Parts List
3. Exploded View
4. Assembly Instructions
5. Warnings
3
4
WARNINGS:
m WARNING: Do not use charcoal or other combustible fuels in this grill. This grill is not designed
for charcoal use and a fire could result. The fire could create an unsafe condition and damage to
the grill.
• Always plug Temperature Controller into grill before • To prevent grill from being splashed or falling into
plugging power cord into outlet.
water, do not set grill within 10 feet of any body of
water such as a pool or pond.
5
• Do not operate unit if plug receptacle is damaged.
• Operate grill only on a level, stable surface.
• Do not in any way alter this product or its use.
• Do not operate grill with a Temperature Controller
that has a damaged cord or plug. Call The Fulham
Group for a replacement Temperature Controller.
The Temperature Controller is made specifically for
this grill.
6
• If using an extension cord it must be rated no less
than that of the appliance. Extension cords must be
marked with the letter “W” and with a tag stating,
“Suitable for use with outdoor appliance”.
• Pulling Temperature Controller by the knob could
cause the knob to come off.
10
10
10
11
11
• Use shortest length extension cord possible. Do not
connect 2 or more extension cords together.
• Do not allow cord to touch the grill when it is hot.
• This grill is intended for outdoor household use
only. Do not use indoors or for commercial cooking.
• Do not immerse grill or Temperature Controller in
water when cleaning.
• If a flare up occurs, do not use water to put out fire.
Turn grill to OFF. Unplug power cord and wait for
grill to cool.
6. Operating Instructions
7. Cleaning
• Do not leave Temperature Controller in the ON posi-
tion during periods of non-use.
• Do not leave grill unattended when in use.
• Make sure no other high wattage appliances are
plugged into the same circuit when using grill.
• Keep children and pets away from grill when in use.
• Do not clean this product with a water spray or the
like.
• Young children should be supervised to ensure that
they do not play with the appliance.
• Unplug grill when not in use and cover when cool.
Properly store the appliance indoors when not in
use – out of the reach of children.
• This appliance is not intended for use by young
children or infirm persons unless they have been
adequately supervised by a responsible person to
ensure that they can use the appliance safely.
8. Storage
• Use this grill only as described in this manual. Any
other use not recommended in this manual may
cause fire, electric shock, or injury to persons.
• Clean drip tray regularly.
9. Warranty
• Locate power cord away from traffic areas. Arrange
the cord so that it will not be pulled or tripped over.
• Always ensure that electrical socket being used has
the correct rating. Socket must be rated no less
than 120V AC, 13Amps.
• Do not use grill near combustible materials such as
dry grass, shrubs, etc.
• This appliance conforms to technical standards and
the safety requirements for electrical devices.
• Do not allow grill to come into close contact with
flammable materials such as paper, walls, draperies,
towels, chemicals, etc.
• The dip tray must be in place at all times during grill
operation.
• Do not use as a heater.
• Do not build this model of grill in any built-in or
slide-in construction. Ignoring this warning could
cause a fire or an explosion that may damage
property or cause serious bodily injury or death.
• Do not move the grill while it is in use. Allow the
appliance to cool before moving, cleaning or
storing it.
• Do not use grill when raining or snowing.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
3. Exploded Diagram
2. Illustrated Parts List
A.
Lid & Firebox
Left Foot
1 pc
1 pc
1 pc
1 pc
1 pc
B.
C.
D.
E.
F.
Right Foot
Cooking Grate
Drip Tray
1
2
Lid
15
16
17
18
19
20
21
22
23
24
25
Probe Decoration Panel
Lock Handle
30
31
32
33
34
35
36
37
38
39
40
41
42
43
Decoration Panel
Upper Leg
Lid Handle Base Assy
Lid Handle
3
Probe Assembly
Firebox Assembly
Lock Spring
Button
4
Hook
Sliding Lock
Spring
5
Lid Inner Panel
Cooking Grate
Upper Part Lid Hinge
Stopper
6
Lock
Button Spring
Lower Leg Fixing Part
Upper Leg Fixing Part
Lower Leg End Cap
Lower Leg
7
Drip Pan Assembly
Drip Tray Right Bracket
Drip Tray Left Bracket
Leg Assembly Bracket
Stop Panel
8
9
Heating Element
Lid Cushion
10
11
Lower Part Lid Hinge
Left Foot
Temperature Controller 1 pc
12 Lid Hinge Pin Assembly 26
13 Reflector Assembly 27
Upper Leg End Cap
Upper Leg Pin
Right Foot
Rubber Feet
Probe Guard
14 Control Panel Assembly 28
29
Upper Leg Holder
Pin
North American Distributor: The Fulham Group, Newton, MA 02466
4
5
Download from Www.Somanuals.com. All Manuals Search And Download.
4. Assembly Instructions
Remove all the contents from packaging, and make sure
all parts are present before attempting to assemble!
Step 4: Lift Grill to Height
Hold both sides of the chassis and lift up
until the legs standing on the ground.
Step 1: Attach Feet
Put the left foot and right foot on the lower leg as illustrated. The feet and
legs have color coded arrows on them. When properly aligned, two ar-
rows of the same color will be pointing at each other.
Step 2: Extend Legs to mid position.
Move the left foot and right foot as illustrated until the end.
Step 5:
Put the grill down and check if the legs are
in the position as illustrated.
If only mid height is desired, skip to step 4.
Step 3: Extend legs
to high position
Push the button and pull
Leg tip should be
visible through
bracket hole
Button
the legs out until the end.
6
7
Download from Www.Somanuals.com. All Manuals Search And Download.
To Collapse grill
4. Assembly Instructions (cont.)
Step 1: Wait for Grill to cool completely
Step 6: Put the Drip Tray to the correct position as shown.
Step 2 : Be sure gas bottle or supply hose is disconnected
Step 3 : Place one foot on each
grill foot and lift grill chassis up-
wards to unlock legs
Step 7: Put the probe into the correct position in the frame as shown.
Step 4: While holding grill off
the ground,swing the legs apart and
lower the grill slowly at the same
time, continue until grill is flat on the
ground with legs to the sides
Step 5: Push legs inward toward
grill chassis. You must push the leg
release button (as shown) to collapse
legs under grill
8
9
Download from Www.Somanuals.com. All Manuals Search And Download.
5. WARNINGS
8. STORAGE
STORAGE AND/OR NON-USE
• During periods of non-use, the Temperature Controller
with power cord should be in the “OFF” position. Store
grill indoors.
• Cover grill or store in weather protected area when not in
use.
m WARNING: The grill is not intended for installation in
or on recreational vehicles, SUVs and/or boats.
m WARNING: To protect against electrical shock, do not
immerse any part of this appliance in water or any other
liquid.
m WARNINGS
• Any modification of the appliance may be dangerous.
• Visually inspect cord, plug and Temperature Controller
for damage and wear before operation.
• Clean the grate and cookbox between uses.
– Warning: Do not use the barbecue within 60 cm (24in)
of combustible materials from the back or sides of the
grill. Do not use under any combustible construction.
– Warning: The entire cooking box gets hot when in use.
Do not leave unattended.
– Warning: Keep any electrical power cord away from
any heated surface.
– Warning: Keep the cooking area clear of inflammable
vapors and liquids such as petrol, kerosene, alcohol,
etc., and other combustible materials.
OPERATING
• When heating the grill for the first time, it may give off a
slight burning odor. The grill is burning off excess lubri-
cants found on the heating element. This does not affect
the safety of your grill.
m WARNING: The grill must not be used upon any
Outside surface – Use a warm soapy water solution to
clean , then rinse with water.
combustible surface such as dry grass, shrubs, etc.
• To prevent fire or electric shock, always use a certified
electrician should new circuits or outlets be required.
• Improperly grouded outlets could cause electrical shock.
• The use of an extension cord is not recommended. If
you must use an extension cord, use the shortest length
extension cord possible. Do not connect 2 or more ex-
tension cords together. Keep connections off the ground
and dry. Do not let cord hang over edge of table top
where it can be tripped over or pulled by children. Only
use extension cord labeled for outdoor use.
9. WARRANTY and REPLACEMENT PARTS
– Warning: When cooking, the appliance must be on a
level, stable surface in an area clear of combustible
material.
This warranty covers defects in parts and workmanship for a period of 3 years from the original
purchase date. Any damage claim regarding the enameling must be submitted within 30 days of
purchase to be covered by the warranty.
– Warning: Keep cord clear of cookbox.
The following conditions are NOT covered by this warranty:
• Unevenness and color variations in the enamel coating.
• Damage caused by improper assembly or disregard of the manual.
• Use of spare parts not supplied by manufacturer.
• Damage resulting from modifications or inappropriate use.
• Abuse of the grill
• Damage caused by improper maintenance or repairs by an unauthorized person.
6. OPERATING INSTRUCTIONS
7. CLEANING
Dangers
Cleaning the outside surface:
– Place the grill on a stable, non-combustible surface
– Do not use indoors, or in a recreational vehicle or on a
boat
– Ensure temperature controller is plugged fully into grill
before proceeding
1. Wipe surface grime off with a clean cloth and mild
dishwashing detergent or baking soda.
2. For stubborn surface dirt, use warm soapy water
solution and a nylon scrubbing brush.
3. Clean the rinse with water.
Limitations and exclusions:
1. This warranty applies only to the original purchaser and may not be transferred.
2. If you can not verify the purchase date of the grill the warranty period will begin on the date the
grill was manufactured.
3. Replacement or repair parts are warranted for the remaining period of the original part warranty.
4. Allow surfaces to dry fully before use.
COOkING
1) Open lid
Cleaning the Heating Element:
Your obligations:
1. Ensure the grill is unplugged from the power source and
the temperature control unit is removed.
2. Remove the cooking grate.
2) Ensure cooking grate is properly positioned in grill,
and that firebox is free from debris.
3) Preheat grill
This grill must be assembled, installed, operated and maintained in accordance with all applicable
codes and the instruction manual furnished with this grill. You must keep an invoice, cancelled
check or payment record to verify the purchase date of the grill.
3. Remove the heating element by unscrewing the wing
nuts and lifting the element out.
– Turn knob clockwise to MAX. Red light indicates that
power is on.
4. Gently clean the heating element with a damp cloth. Do
not scratch the element’s surface or immerse in water.
5. Reinstall the heating element.
6. Inspect the temperature controller and the power cord
for by any possible damage, and then reinstall.
Any other servicing should be performed by an authorized
service representative.
4) Close lid and allow grill to heat for 5-10 minutes
(longer in clod weather)
5) When beginning to cook, a lower temperature may be
selected by turning knob counterclockwise.
6) When cooking is complete, turn knob counter
clockwise to OFF. Unplug temperature controller.
See storage section for additional requirements.
10
11
Download from Www.Somanuals.com. All Manuals Search And Download.
|