Sony CD Player CDX MP40 User Manual
CDX-MP40  
SERVICE MANUAL  
US Model  
Canadian Model  
AEP Model  
Ver 1.0 2003. 01  
UK Model  
• The tuner and CD sections have no adjustments.  
Model Name Using Similar Mechanism NEW  
CD Drive Mechanism Type  
Optical Pick-up Name  
MG-393MC-121  
KSS-721A  
AUDIO POWER SPECIFICATIONS (US Model)  
POWER OUTPUT AND TOTAL HARMONIC DISTORTION  
23.2 watts per channel minimum continuous average power into  
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more  
than 5% total harmonic distortion.  
SPECIFICATIONS  
CD player section  
Power amplifier section  
Signal-to-noise ratio  
Frequency response  
Wow and flutter  
90 dB  
10 – 20,000 Hz  
Below measurable limit  
Outputs  
Speaker outputs  
(sure seal connectors)  
4 – 8 ohms  
Speaker impedance  
Maximum power output 52 W × 4 (at 4 ohms) (US, Canadian Model)  
50 W × 4 (at 4 ohms) (AEP, UK Model)  
Tuner section  
FM  
General  
Outputs  
Tuning range  
87.5 – 107.9 MHz (US, Canadian Model)  
87.5 – 108.0 MHz (AEP, UK Model)  
External antenna connector  
Audio outputs (front/rear)  
Antenna terminal  
Intermediate frequency 10.7 MHz/450 kHz  
Usable sensitivity  
Selectivity  
Signal-to-noise ratio  
Power antenna relay control terminal  
Power amplifier control terminal  
Telephone ATT control terminal  
BUS control input terminal  
BUS audio input terminal  
Remote controller input terminal  
Antenna input terminal  
Low: ±10 dB at 60 Hz (XPLOD)  
Mid: ±10 dB at 1 kHz (XPLOD)  
High: ±10 dB at 10 kHz (XPLOD)  
9 dBf  
Inputs  
75 dB at 400 kHz  
67 dB (stereo),  
69 dB (mono)  
Harmonic distortion at 1 kHz  
0.5% (stereo),  
Tone controls  
0.3% (mono)  
35 dB at 1 kHz  
30 – 15,000 Hz  
Separation  
Frequency response  
– Continued on next page –  
AM (US, Canadian Model)  
Tuning range  
Antenna terminal  
530 – 1,710 kHz  
External antenna connector  
Intermediate frequency 10.7 MHz/450 kHz  
Sensitivity 30 µV  
MW/LW (AEP, UK Model)  
Tuning range  
MW : 531 – 1,602 kHz  
LW : 153 – 279 kHz  
External aerial connector  
Intermediate frequency 10.7 MHz/450 kHz  
FM/AM COMPACT DISC PLAYER  
Aerial terminal  
US, Canadian Model  
Sensitivity  
MW : 30 µV  
LW : 40 µV  
FM/MW/LW COMPACT DISC PLAYER  
AEP, UK Model  
9-877-000-01  
2003A0400-1  
© 2003. 01  
Sony Corporation  
e Vehicle Company  
Published by Sony Engineering Corporation  
CDX-MP40  
Notes on CD-Rs (recordable CDs)/CD-RWs (rewritable  
CDs)  
This unit can play the following discs:  
Type of discs  
Audio CD  
Label on the disc  
MP3 files  
• Some CD-Rs/CD-RWs (depending on the equipment used for  
its recording or the condition of the disc) may not play on this  
unit.  
∗
• You cannot play a CD-R/CD-RW that is not finalized .  
• You can play MP3 files recorded on CD-ROMs, CD-Rs, and  
CD-RWs.  
• A CD-R/CD-RW to which a session can be added can be played.  
∗ A process necessary for a recorded CD-R/CD-RW disc to be  
played on the audio CD player.  
EXTENSION CABLE AND SERVICE POSITION  
When repairing or servicing this set, connect the jig (extension cable)  
as shown below.  
• Connect the MAIN board (CNP701) and the SERVO board (CN1)  
with the extension cable (Part No. J-2502-062-1).  
MAIN BOARD CNP701  
SERVO BOARD CN1  
3
CDX-MP40  
TABLE OF CONTENTS  
1. GENERAL  
Location of Controls (US, Canadian Model) .......................... 5  
Location of Controls (AEP, UK Model) .................................. 5  
Connections (US, Canadian Model)........................................ 6  
Connections (AEP, UK Model) ............................................... 7  
2. DISASSEMBLY  
2-1. Sub Panel Assy (CD)........................................................... 9  
2-2. CD Mechanism Block ....................................................... 10  
2-3. Main Board ....................................................................... 10  
2-4. Heat Sink ........................................................................... 11  
2-5. Chassis (T) Sub Assy ........................................................ 11  
2-6. Lever Section..................................................................... 12  
2-7. Servo Board ....................................................................... 12  
2-8. Shaft Roller Assy, Load Sw Board .................................... 13  
2-9. Floating Block Assy .......................................................... 14  
2-10. Optical Pick-up Block ....................................................... 14  
3. DIAGRAMS  
3-1. IC Pin Descriptions ........................................................... 15  
3-2. Circuit Boards Location .................................................... 20  
3-3. Block Diagram –CD Section–........................................... 21  
3-4. Block Diagram –Main Section– ........................................ 22  
3-5. Block Diagram –Display Section– .................................... 23  
3-6. Printed Wiring Boards –CD Mechanism Section–............ 24  
3-7. Schematic Diagram –CD Mechanism Section (1/2)– ....... 26  
3-8. Schematic Diagram –CD Mechanism Section (2/2)– ....... 27  
3-9. Printed Wiring Boards –Main Section– ............................ 28  
3-10. Schematic Diagram –Main Section (1/2)– ........................ 29  
3-11. Schematic Diagram –Main Section (2/2)– ........................ 30  
3-12. Printed Wiring Board –Relay Section– ............................. 31  
3-13. Printed Wiring Board –Key Section  
(US, Canadian Model)– ............... 32  
3-14. Schematic Diagram –Relay, Key Section  
(US, Canadian Model)–.................. 33  
3-15. Printed Wiring Board –Key Section  
(AEP, UK Model)– ...................... 34  
3-16. Schematic Diagram –Relay, Key Section  
(AEP, UK Model)– ......................... 35  
3-17. IC Block Diagrams............................................................ 36  
4. EXPLODED VIEWS  
4-1. Chassis Section ................................................................. 38  
4-2. Front Panel Section ........................................................... 39  
4-3. CD Mechanism Section (1) ............................................... 40  
4-4. CD Mechanism Section (2) ............................................... 41  
4-5. CD Mechanism Section (3) ............................................... 42  
5. ELECTRICAL PARTS LIST ........................................ 43  
4
CDX-MP40  
SECTION 1  
GENERAL  
This section is extracted  
from instruction manual.  
(US, Canadian Model)  
(AEP, UK Model)  
5
CDX-MP40  
Connections (US, Canadian Model)  
6
CDX-MP40  
Connections (AEP, UK Model)  
7
7
CDX-MP40  
8
8
CDX-MP40  
SECTION 2  
DISASSEMBLY  
Note : This set can be disassemble according to the following sequence.  
SET  
2-5. CHASSIS (T) SUB ASSY  
(Page 11)  
2-1. SUB PANEL ASSY (CD)  
(Page 9)  
2-6. LEVER SECTION 2-7. SERVO BOARD  
2-2. CD MECHANISM BLOCK  
(Page 10)  
(Page 12)  
(Page 12)  
2-8.  
2-9.  
SHAFT ROLLER ASSY,  
LOAD SW BOARD  
(Page 13)  
2-3. MAIN BOARD  
(Page 10)  
2-4. HEAT SINK  
(Page 11)  
FLOATING BLOCK ASSY  
(Page 14)  
2-10. OPTICAL PICK-UP BLOCK  
(Page 14)  
Note : Follow the disassembly procedure in the numerical order given.  
2-1. SUB PANEL ASSY (CD)  
2 claws  
3 claws  
4 CN802  
1 PTT 2.6x6  
5 sub panel assy (CD)  
9
CDX-MP40  
2-2. CD MECHANISM BLOCK  
7 bracket (CD)  
5 CD mechanism block  
6 PTT 2.6x6  
2 PTT 2.6x6  
3
1 PTT 2.6x6  
4 CNP701  
2-3. MAIN BOARD  
3
screw (+BTT)  
5
MAIN board  
4
screws (+BTT)  
2
PTT 2.6x8  
1
PTT 2.6x8  
10  
CDX-MP40  
2-4. HEAT SINK  
6
heat sink  
5
PTT 2.6x8  
4
P 2.6x8  
3
PTT 2.6x12  
2
PTT 2.6x8  
1
PTT 2.6x8  
2-5. CHASSIS (T) SUB ASSY  
2
P 2x3  
3
P 2x3  
4
chassis (T) sub assy  
1
Unsoldering three lead wires.  
SERVO board  
(SIDE A)  
black  
red  
white  
11  
CDX-MP40  
2-6. LEVER SECTION  
5
guide (disc)  
6
lever (R)  
tension spring (LR)  
3
7
lever (L)  
special screw  
1
2
DISC IN SW board  
4
two claws  
2-7. SERVO BOARD  
9
SERVO board  
8
special screw  
7
special screws  
3
Removal the solders.  
2
CN2  
5
P2x3  
1
CN3  
4 Unsolder the  
lead wires.  
black  
yellow  
6
loading motor assy  
optical pick-up block  
12  
CDX-MP40  
2-8. SHAFT ROLLER ASSY, LOAD SW BOARD  
• When installing, take note of the positions  
arm (roller) and washers. (Fig. 1)  
3 retaining ring (RA)  
arm  
washer  
shaft retainer (roller)  
shaft retainer (roller)  
4 shaft retainer (roller)  
washer  
retaining ring (RA)  
arm  
Fig. 1  
6
special screw  
5 shaft roller assy  
2 arm (roller)  
7
LOAD SW board  
1
tension spring (RA)  
13  
CDX-MP40  
2-9. FLOATING BLOCK ASSY  
6
floating block assy  
7
compression spring (FL)  
1
tension spring (KF1)  
8
compression spring (FL)  
5
Turn loading ring in the  
direction of the arrow.  
4
Fit lever (D) in the direction of the arrow.  
2
damper (T)  
3
damper (T)  
2-10. OPTICAL PICK-UP BLOCK  
3
P 2x3  
1
P 2x3  
7 PICK-UP FLEXIBLE board  
4
plate spring (feed)  
2
sled motor assy (M902)  
5
optical pick-up (KSS-721A)  
6
shaft (feed) assy  
14  
CDX-MP40  
SECTION 3  
DIAGRAMS  
3-1. IC PIN DESCRIPTIONS  
• IC3 HD6432238RWN35TEI (CD MASTER CONTROL) (SERVO BOARD)  
Pin No.  
1
Pin Name  
TEST  
I/O  
I
Pin Description  
Test mode selection pin Not used. (Open)  
2
DECXRST  
DECSTBY  
NC  
O
O
O
I
Reset signal output to the DSP IC “L”: reset  
Standby mode control signal output to the DSP IC “H”: standby  
Not used. (Open)  
3
4 – 7  
8
PH3  
CD PH3 photo sensor detection signal input Not used. (Open)  
CD mechanism disc in switch detection signal input  
CD mechanism in-limit switch detection signal input  
CD mechanism down switch detection signal input  
System power supply pin (+3.3 V)  
9
INSW/PH2  
LIMIT_SW  
D_SW  
CVCC  
NC  
I
10  
I
11  
I
12  
—
O
—
O
I
13  
Not used. (Open)  
14  
VSS  
Ground pin  
15  
NC  
Not used. (Open)  
16  
PH1  
CD PH1 photo sensor detection signal input Not used. (Open)  
CD mechanism loading motor control signal output (eject operation)  
CD mechanism loading motor control signal output (load operation)  
Not used. (Open)  
17  
EJECT  
LOAD  
NC  
O
O
O
I
18  
19 – 26  
27  
FLAG  
RFOK  
NC  
Correction unable detection signal input  
RFOK signal input from the servo IC  
Not used. (Open)  
28  
I
29, 30  
31  
O
O
I
TXD  
UART TXD PC connection output Not used. (Open)  
UART RXD PC connection input Not used. (Open)  
Crystal oscillation control signal output to the servo IC  
CD text parameter strobe signal output to the servo IC  
Data strobe signal output to the servo IC  
Command/parameter identification signal output to the servo IC  
“L”: command, “H”: parameter  
32  
RXD  
33  
XTALEN  
TSTB  
STB  
O
O
O
34  
35  
36  
A0  
O
37  
38  
CD_RST  
PACK  
NC  
O
I
Reset signal output to the servo IC  
CD text pack sync signal input from the servo IC  
Not used. (Open)  
39  
O
I
40  
SELF_SW  
NC  
CD mechanism self load position detection switch signal input  
Not used. (Open)  
41  
O
—
O
I
42  
AVSS  
NC  
Ground for A/D converter  
43, 44  
45, 46  
47  
Not used. (Open)  
NC  
Not used. (Open)  
KEY0  
KEY1  
NC  
I
Key switch signal input in the test mode Not used. (Open)  
Mode switch signal input in the test mode Not used. (Open)  
Not used. (Open)  
48  
I
49 – 52  
53  
I
AVREF  
AVCC  
MD0  
—
—
—
—
—
—
I
Reference voltage for A/D converter  
54  
Power supply for A/D converter  
55  
CPU operation mode setting pin Connecting to +3.3 V in this set.  
CPU operation mode setting pin Connecting to +3.3 V in this set.  
Sub clock oscillator terminal Not used. (Open)  
Sub clock oscillator terminal Not used. (Open)  
Microcomputer reset signal input  
56  
MD1  
57  
X1A  
58  
X0A  
59  
RSTX  
NMI  
60  
—
—
—
—
—
—
I
Not used. (Fixed at “H”)  
61  
STBY  
VCC  
Not used. (Fixed at “H”)  
62  
Power supply pin (+3.3 V)  
63  
XTAL  
VSS  
Main clock oscillator pin (12.288 MHz)  
Ground pin  
64  
65  
XTEAL  
FWE  
Main clock oscillator pin (12.288 MHz)  
Flash write enable signal input  
66  
15  
CDX-MP40  
Pin No.  
67  
Pin Name  
MD2  
I/O  
—
I
Pin Description  
CPU operation mode setting pin  
68  
FL_BOOT  
FL_W  
Flash write selection signal input (“L”: flash write mode)  
Flash write control signal output connected to pin 66 (FWE)  
Not used. (Open)  
69  
O
O
O
I
70  
NC  
71  
CDMON  
DECINT  
CLOSE  
OPEN  
CD mechanism power supply control signal output  
Interrupt signal input from the DSP IC  
Front panel operation request output (Close)  
Front panel oparation request output (Open)  
LINK OFF signal output for UNI_LINK “H”: link off, “L”: link on  
Sony-Bus serial data output to the bus interface  
Sony-Bus serial data input from the bus interface  
Sony-Bus serial clock input from the bus interface  
Not used. (Open)  
72  
73  
O
O
O
O
I
74  
75  
LINKOFF  
UNI_SO  
UNI_SI  
UNI_CK  
NC  
76  
77  
78  
I
79  
O
I/O  
O
O
O
I
80  
SDA  
I2C interface data input/output  
81  
SCL  
I2C interface clock output  
82  
NC  
Not used. (Open)  
83  
TSO  
Serial data output to the servo IC  
84  
TSI  
Serial data input from the servo IC  
85  
TSCK  
O
O
O
O
O
I
Serial clock output to the servo IC  
86  
LEDDAT  
LEDCLK  
LEDLAT  
NC  
LED data output for the jig  
87  
LED clock output for the jig  
88  
LED latch signal output for the jig  
89, 90  
91  
Not used. (Open)  
BUSON  
BUCHK  
A-ATT  
CDON  
NC  
Sony-Bus BUS ON signal input from the bus interface  
Back up power supply detection signal input  
Audio muting control signal output  
Power control signal output for the CD servo “H”: servo on, “L”: during loading  
Not used. (Open)  
92  
I
93  
O
O
O
I
94  
95  
96  
U/J_SEL  
TEXTSEL  
NC  
Destination setting pin  
97  
I
CD text function setting pin  
98  
O
I
Not used. (Open)  
99  
CFSEL  
DOUT SEL  
Custom file function setting pin  
100  
I
Digital output selection setting pin “H”: digital output available  
16  
CDX-MP40  
• IC5 CXD9684R-005 (DSP) (SERVO BOARD)  
Pin No.  
1
Pin Name  
/RESET  
I/O  
I
Pin Description  
Reset input pin “L”: reset  
2
MIMD  
I
Microcomputer interface mode selection input “H”: I2C, “L”: TSB  
External SRAM address signal output  
Serial data input/output  
3, 4  
5
AD0, AD1  
MIDIO (I2C_SDA)  
MICK (I2C_SCL)  
AD2  
O
I/O  
I
6
Serial clock input  
7
O
External SRAM address signal output  
Power supply (3.3 V) for digital circuit  
Data output  
8
VDDT (3.3V)  
SDO  
—
O
9
10, 11  
12  
AD3, AD4  
SDI0  
O
External SRAM address signal output  
Data input 0  
I
13  
BCKIA  
I
Bit clock input A  
14  
LRCKIA  
AD5  
I
LR clock input A  
15  
O
External SRAM address signal output  
External SRAM chip enable signal output  
External SRAM output enable signal output  
Power supply pin (2.5 V) for digital circuit  
Standby mode control signal input “H”: STB, “L”: normal  
Ground pin for digital circuit  
16  
CE  
O
17  
OE  
O
18  
VDD (2.5V)  
STANDBY  
VSS (2.5VGND)  
VSSL (2.5VGND)  
VRAL  
—
I
19  
20  
—
—
—
O
21  
Ground pin for DAC Lch  
22  
Reference voltage pin for DAC Lch  
DAC Lch signal output (Open)  
23  
LO  
24  
VDAL (2.5V)  
VDAR (2.5V)  
RO  
—
—
O
Power supply pin (2.5 V) for DAC Lch  
Power supply pin (2.5 V) for DAC Rch  
DAC Rch signal output (Open)  
25  
26  
27  
VRAR  
—
—
I
Reference voltage pin for DAC Rch  
Ground pin for DAC Rch  
28  
VSSR (2.5VGND)  
TESTP  
29  
Pin for test “H”: test mode, “L”: normal (fixed at “L”)  
VCO selection input “H”: VCO, “L”: X1 input  
External SRAM address signal output  
Power supply pin (3.3 V) for digital circuit  
External SRAM address signal output  
Interrupt request signal output to the CD master control  
Ground pin for digital circuit  
30  
CKS  
I
31 – 34  
35  
AD12 to AD9  
VDDT (3.3V)  
AD8 to AD6  
REQ  
O
—
O
36 – 38  
39  
O
40  
VSS  
—
O
41, 42  
43  
AD13, AD14  
WR  
External SRAM address signal output  
External SRAM write signal output  
External SRAM address signal output  
External SRAM data input/output  
Ground pin for digital circuit  
O
44, 45  
46, 47  
48  
AD16, AD15  
IO0, IO1  
VSS  
O
I/O  
—
I/O  
—
I/O  
—
O
49 – 51  
52  
IO2 to IO4  
VDD (2.5V)  
IO5 to IO7  
VSSP  
External SRAM data input/output  
Power supply pin (2.5 V) for digital circuit  
External SRAM data input/output  
Ground pin for VCO circuit  
53 – 55  
56  
57  
PDO  
PLL phase error detection signal output  
VCO control voltage input  
58  
VCOI  
I
59  
VDDP  
—
I/O  
—
I
Power supply pin for VCO circuit  
External clock input, audio clock output Not used. (Open)  
Power supply pin for oscillation circuit  
Resonator pin  
60  
XRDE  
61  
VDDX (2.5V)  
XI  
62  
63  
XO  
O
Resonator pin  
64  
VSSX  
—
Ground pin for oscillation circuit  
17  
CDX-MP40  
• IC801 MN101C49KSJ (SYSTEM CONTROL) (MAIN BOARD)  
Pin No.  
Pin Name  
VREF–  
VSM  
I/O  
—
I
Pin Description  
Power supply pin for A/D converter  
1
2
S-meter voltage detection signal input from the tuner unit (TU601)  
Not used. (Connected to ground.)  
3
NIL  
I
4
KEYIN1  
KEYIN0  
RC_IN0  
QUALITY  
DST SEL  
NIL  
I
Key signal input  
5
I
Key signal input  
6
I
Rotary commander key signal input from the remote-in jack  
Noise detection signal input (AEP, UK model)/Connected to ground. (US, Canadian model)  
Destination setting pin (US, Canadian model)  
Not used. (Connected to ground.)  
7
I
8
I
9
I
10  
11  
12  
13  
14  
15  
16  
17  
18  
19  
20  
21 – 23  
24  
25  
26  
VREF+  
VDD  
—
—
O
I
Power supply pin for A/D converter  
Power supply pin  
OSCOUT  
OSCIN  
VSS  
High speed clock output (18.43 MHz)  
High speed clock input (18.43 MHz)  
Ground pin  
—
I
XIN  
Low speed clock input (32.768 kHz)  
Low speed clock output (32.768 kHz)  
Memory mode selection input “L”: single chip mode (connected to ground)  
Serial data output to the LCD driver  
Chip enable signal output to the LCD driver  
Serial clock output to the LCD driver  
Not used. (Open)  
XOUT  
O
—
O
O
O
O
O
O
I
MMOD  
LCDSO  
LCDCE  
LCDCKO  
NCO  
SYSRST  
BUSON  
KEYACK  
System reset signal output  
Bus on signal output to the bus interface  
Key acknowledge detection signal input  
RDS data block sync detection signal input (AEP, UK model)/Connected to  
ground. (US, Canadian model)  
27  
DAVN (NIL)  
I
28  
29  
BU_IN  
SIRCS  
TUATT IN  
NIL  
I
I
Back up power supply detection signal input  
Remote control signal input from the remote control receiver  
ATT control signal input from tuner unit.  
Not used. (Connected to ground.)  
30  
I
31  
I
32  
NIH  
I
Not used. (Connected to power supply.)  
Microcomputer reset signal input from the reset IC  
Front panel with/without detection signal input “L”: panel with  
Beep signal output to the power amplifier  
Not used. (Open)  
33  
RESET  
NOSE SW  
BEEP  
I
34  
I
35  
O
O
I
36  
NCO  
37  
TESTIN  
ACCIN  
NCO  
Test mode detection signal input  
38  
I
Accessory power supply detection signal input  
Not used. (Open)  
39  
O
I
40  
TELATT  
NIH  
TEL ATT detection signal input  
41  
I
Fixed at “H”.  
42  
BUSSO  
BUSSI  
BUSCKO  
I2CSIO  
NCO  
O
I
Sony_Bus serial data output to the bus interface IC  
Sony_Bus serial data input from the bus interface IC  
Sony_Bus serial clock output to the bus interface IC  
I2C bus serial data input/output  
43  
44  
O
I/O  
O
O
O
O
O
O
O
O
45  
46  
Not used. (Open)  
47  
I2CCKO  
NCO  
I2C bus serial clock output  
48  
Not used. (Open)  
49  
NCO  
Not used. (Open)  
50  
POW_ON  
NCO  
System power supply control signal output  
Not used. (Open)  
51 – 66  
67  
ATT  
System ATT control signal output  
68  
NCO  
Not used. (Open)  
18  
CDX-MP40  
Pin No.  
69  
Pin Name  
TU ON  
VOLATT  
NCO  
I/O  
O
O
O
O
O
O
O
O
O
O
I/O  
O
O
O
O
O
I
Pin Description  
Tuner power supply control signal output  
70  
Electronic volume ATT control signal output to the electronic volume  
Not used. (Open)  
71  
72  
AMPON  
NCO  
Power amplifier standby control signal output to the power amplifier  
Not used. (Open)  
73  
74  
AMPATT  
DOORIND  
NCO  
Power amplifier ATT control signal output to the power amplifier  
Sub panel power supply control signal output  
Not used. (Open)  
75  
76 – 84  
85  
NS MASK  
EE_CKO  
EE_SIO  
TUATT  
NCO  
Noise mask signal output  
86  
EEPROM serial clock output  
87  
EEPROM serial data input/output  
88  
Tuner ATT signal output to the tuner unit  
Not used. (Open)  
89, 90  
91  
XKEYON  
ILL ON  
NCO  
Power supply control signal to the function key  
Illumination power supply control signal output  
Not used. (Open)  
92  
93  
94  
DOORSW  
DAVSS  
NCO  
Front panel open/close detection signal input “L”: close, “H”: open  
Ground pin for D/A converter  
95  
—
O
I
96  
Not used. (Open)  
97  
FLASH W  
RC_IN1  
NCO  
Flash write detection signal input  
98  
I
Remote commander shift key signal input from the remote-in jack “L”: shift key on  
Not used. (Connected to ground.)  
99  
O
—
100  
DAVDD  
Power supply pin for D/A converter  
19  
CDX-MP40  
3-2. CIRCUIT BOARDS LOCATION  
SERVO board  
LIMIT SW board  
DISC IN SW board  
LOAD SW board  
SPEAKER board  
tuner unit  
(TUX501)  
MAIN board  
DISPLAY board (US, CND)  
KEY board (AEP, UK)  
RELAY board  
20  
CDX-MP40  
3-3. BLOCK DIAGRAM — CD SECTION —  
IC1  
RF AMP,DIGITAL SERVO  
DIGITAL SIGNAL PROCESSOR  
OPTICAL PICK-UP  
KSS-721A  
(Page 22)  
MAIN  
B
A
84  
SECTION  
LOUT  
ROUT  
D
A
IC3  
16  
12  
CDL  
D/A  
C
B
A
85  
82  
CD MASTER CONTROL  
RF  
EQ  
EFM  
CONV  
R-CH  
IC7  
DEMOD  
5V 3.3V  
PACK  
TSTB  
52  
56  
55  
54  
38 PACK  
3
17  
34 TSTB  
DSUB CODE  
PROCESS  
C
TSCK  
TSI  
I-V  
CONV.  
D
83  
6
SI  
SO  
14  
12  
7
8
7
6
5
4
3
83 TSO  
84 TSI  
FORCUS  
ERROR  
SCK  
8
85  
35  
36  
37  
TSCK  
STB  
I/F  
STB  
AO  
5
15  
11  
• R-ch is omitted due to  
13  
9
E
F
AO  
same as L-ch.  
• Signal path  
:CD  
E
F
87  
86  
RST  
TRACKING  
ERROR  
CD_RST  
SERVO  
CTL  
RFOK  
FLAG  
2
28  
RFOK  
27 FLAG  
28  
:CD-R/RW(MP3)  
APC  
XTALEN  
C16M  
PD  
LD  
16  
18  
4
2
9
33 XTALEN  
PD  
LD  
97  
98  
OSC  
IC5  
38  
DSP  
LD  
DRIVE  
Q1  
DIN  
A+5V  
29  
30  
X1  
62  
9
DOUT  
DECXRST  
DECSTBY  
DECINT  
SDA  
1
19  
39  
5
2
3
72  
80  
/RESET  
STANDBY  
REQ  
SDO  
SCKIN  
SCKO  
12 SDIO  
31  
32  
33  
34  
13  
BCKIA  
MIDIO(I2C_SDA)  
LRCKIN  
LRCK  
IC12  
14  
LRCKIA  
1
2
4
MICK(I2C_SCL)  
62 63 64 65  
23  
24  
6
81  
SCL  
MAIN  
SECTION  
IC2  
FOCUS/TRACKING COIL DRIVE,  
SLED/SPINDLE/LOADING MOTOR DRIVE  
IC4  
S-RAM  
A-ATT  
B
X1  
16.9344MHz  
A-ATT 93  
46,47  
DQ1-DQ3,  
IO4-IO8  
21-23  
25-29  
FCS-  
FCS+  
FOCUS  
15  
63  
65  
XTAL  
49-51 IO0-IO7  
53-55  
FD  
TD  
(Page 22)  
X2  
12.288MHz  
FOCUS  
COIL  
26  
COIL  
16  
DRIVE  
3,4  
7,10  
11,15  
EXTAL  
20-13  
3,2,31  
1,12,4  
11,7,10  
MAIN  
SECTION  
A0-A16  
38-36 AD0-AD16  
34-31  
TRK+  
TRK-  
TRACKING  
COIL  
DRIVE  
17  
18  
TRACKING  
COIL  
23  
41,42  
45,44  
SYSRST  
D_SW  
11  
C
SW5  
RSTX 59  
WR  
CS1  
5
30  
OE 32  
43  
17  
16  
WR  
OE  
CE  
(DOWN)  
(Page 22)  
40 SELF SW  
SW2  
(SELF)  
SL-  
SLED  
MOTOR  
DRIVE  
BU CHK  
BUSON  
M
SD  
M902  
(SLED)  
13  
14  
BUCHK 92  
BUSON 91  
UNI CK 78  
UNI_SI 77  
UNI_SO 76  
LINKOFF 75  
5
6
SL+  
INSW/PH2  
LIMIT_SW  
9
MAIN  
SECTION  
SW3  
(DISC IN)  
IC6  
BUS-CLK  
BUS-SI  
SP+  
SP-  
SPINDLE  
MOTOR  
DRIVE  
M
11  
12  
+2.5V  
REG  
M901  
MD  
10  
SW4  
(LIMIT)  
D
+2.5V  
(IC5)  
BU+3.3V  
3
2
(SPINDLE)  
(Page 22)  
BUS-SO  
LINK-OFF  
LOAD  
EJECT  
LD-  
LOADING  
MOTOR  
DRIVE  
M
9
1
2
18 LOAD  
17 EJECT  
M903  
(LOADING)  
LD+  
10  
Q913,914  
CDM ON  
SWITCH  
71  
CDMON  
Q916,D927  
CD+5V  
REG  
A+5V  
D925  
Q915  
CD ON  
SWITCH  
AU+5V  
D+5V  
94 CDON  
Q912,D926  
DR+6V  
CD DRIVE+6V  
REG  
BATT  
21  
21  
                   
CDX-MP40  
3-4. BLOCK DIAGRAM — MAIN SECTION —  
PJ401  
L
-1  
-2  
-5  
-6  
-3  
BUS AUDIO IN  
R
L
R-CH  
R-CH  
R-CH  
AUDIO OUT FRONT  
AUDIO OUT REAR  
R
L
IC401  
INPUT SELECTOR,  
ELECTRONIC VOLUME,  
SIGNAL PROCESSOR  
R
-4  
IC501  
POWER AMP  
CNP901  
5
8
AUX L  
CD R  
R-CH  
CDL  
CDR  
1
9
FL+  
FL-  
5
3
OUT LF 19  
12  
11  
(Page 21)  
CD  
SECTION  
TU501  
TUNER UNIT  
2
10  
RL+  
RL-  
9
7
9
7
CD L  
A
OUT LR 18  
PJ601  
(ANTENNA)  
Q402  
MUTE  
Q401  
MUTE  
ANT  
L
2
4
3
RADIO L  
16 AUX  
STBY  
4
12  
FR+  
FR-  
OUT RF 21  
OUT RR 20  
R
4
R-CH  
R-CH  
22 MUTE  
27 SDA  
26 SCL  
25 MUTE  
3
11  
RR+  
RR-  
R-CH  
D921  
DELAY  
Q904,905  
LINE MUTE  
SWITCH  
BATT  
(Page 21)  
CD  
SECTION  
IC801 (1/2)  
A-ATT  
D701  
D819  
AEP,UK MODEL  
SYSTEM CONTROL  
B
QUALITY  
QUALITY  
7
70  
5
67  
35  
72  
74  
40  
ATT  
VOL ATT  
BEEP  
AMP ON  
AMP ATT  
TEL ATT  
Q901  
TEL  
ATT  
Q602  
NS MASK  
SWITCH  
13  
7
ATT  
NS_MASK  
85  
Q902  
ACC  
DETECT  
38  
37  
ACC  
TEST  
ACC IN  
15  
TEST IN  
IC902  
S-METER  
SDA  
6
14  
13  
2
VSM  
BU+5V  
Q920  
AMP B+  
SWITCH  
45 I2C SIO  
47 I2C CKO  
+3.3V  
REG  
Q903,D916  
+5V REG  
BATT  
BU+3.3V  
5
3
2
BATT  
AMP R  
SCL  
TUNER  
+8V  
+8V  
Q922  
ANT B+  
SWITCH  
TU MUTE  
MUTE CONDITION  
6
8
7
8
88 TU MUTE  
30 TU ATT IN  
ANT R  
GND  
Q911,D918,919  
TUNER +5V  
REG  
Q909,910  
Q906,D917  
+8V REG  
TUNER  
+5V  
BATT  
TUNER ON  
SWITCH  
SDA(EEP)  
SCL(EEP)  
17  
16  
87 EE SIO  
86 EE CKO  
19  
17  
BATT  
Q921  
Q917  
Q907,908  
POWER ON  
CONTROL  
AMP REM  
CONTROL  
SWITCH  
ANT REM  
CONTROL  
SWITCH  
CD  
SYSRST  
AEP,UK MODEL  
C
SECTION  
F901  
10A  
IC601  
RDS DECODER  
(Page 21)  
18  
16  
69  
TU ON  
RDS DET  
9
16  
MPX  
+B (BATT)  
POW ON 50  
9
10  
SDA  
SCL  
IC802  
RESET  
D810  
4
5
OSCO  
OSCI  
X601  
4.332MHz  
BU+5V  
RESET 33  
1
2
8
27  
DAVN(NIL)  
DAVN  
CNJ801  
BUS  
S801  
IC803  
BUS INTERFACE  
CONTROL IN  
D808  
• R-ch is omitted due to same as L-ch.  
RESET  
8
Q802  
SWITCH  
• Signal path  
:FM  
BUSON  
1
6
5
4
3
2
1
SYSRST 24  
BUSON 25  
BUSSI 43  
BUSCKO 44  
BUSSO 42  
BU IN 28  
13 RST  
12 BUSON  
DATA OUT  
11 CLK IN  
DATA IN  
DATA I/O  
CLK  
6
4
:AM(MW/LW)  
:CD  
8
7
9
BATT  
10 B/U-C  
:CD-R/RW(MP3)  
IC701  
BUFFER  
RST  
2
3
BU-CHECK  
D802  
D818  
BUSON  
BUS-SI  
BUS-CLK  
BATT  
2
6
BATT  
BATT  
5
3
Q801,D801  
BATT DET  
CD  
7
1
D
SECTION  
(Page 21)  
Q804  
BUS-SO  
SWITCH  
BUS-SO  
Q805,806  
LIMNKOFF  
SWITCH  
LINK-OFF  
22  
22  
                       
CDX-MP40  
• Waveforms  
3-5. BLOCK DIAGRAM — DISPLAY SECTION —  
THIS NOTE IS COMMON FOR PRINTED WIRING  
BOARDS AND SCHEMATIC DIAGRAMS.  
(In addition to this, the necessary note is  
printed in each block.)  
— SERVO Board —  
(MODE: CD PLAY)  
IC901  
LCD DRIVER  
— MAIN Board —  
(US,Canadian MODEL)  
(AEP,UK MODEL)  
IC801 (2/2)  
1V/DIV,20ns/DIV  
1
2
3
4
5
SYSTEM CONTROL  
for schematic diagram:  
2V/DIV,100ns/DIV  
6
7
8
• All capacitors are in µF unless otherwise noted. pF: µµF  
50 WV or less are not indicated except for electrolytics  
and tantalums.  
AEP,UK :S902,903,931,LSW901(1/2),904(1/2)-910(1/2)  
US,CND:S901,903,931,LSW901(1/2)-907(1/2)  
FUNCTION SWITCH  
KEY IN0  
5
4
1
I
S1  
I
S64  
• All resistors are in Ω and 1/4 W or less unless otherwise  
specified.  
64  
LCDSO  
LCDCKO  
LCDCE  
DATA  
CLK  
CE  
18  
20  
19  
78  
77  
76  
2.8 Vp-p  
5.5 Vp-p  
59 ns  
IC1 wd (XTAL)  
LCD901  
LIQUID  
CRYSTAL  
DISPLAY  
230 ns  
IC601 4 (OSCD)  
•
•
%
f
: indicates tolerance.  
: internal component.  
AEP,UK :S911,LSW912(1/2)-922(1/2)  
US,CND:S902,LSW908(1/2)-917(1/2)  
FUNCTION SWITCH  
KEY IN1  
• C : panel designation.  
500mV/DIV,1µs/DIV  
65  
|
COM1  
|
COM4 68  
2V/DIV,40ns/DIV  
Note:  
Note:  
Les composants identifiés par  
une marque 0 sont critiques  
pour la sécurité.  
Ne les remplacer que par une  
piéce portant le numéro  
spécifié.  
The components identi-  
fied by mark 0 or dotted  
line with mark 0 are criti-  
cal for safety.  
Replace only with part  
number specified.  
D809  
Q803  
KEY  
DETECT  
KEY ACK  
26  
91  
1.7 Vp-p  
3.2 Vp-p  
54 ns  
IC1 uj (RFO)  
XKEYON  
DOOR  
IND  
IC801 qs (OSCOUT)  
75  
92  
• A : B+ Line.  
• Power voltage is dc 14.4V and fed with regulated dc power  
supply from ACC and BATT cords.  
• Voltages are taken with a VOM (Input impedance 10 MΩ).  
Voltage variations may be noted due to normal produc-  
tion tolerances.  
• Waveforms are taken with a oscilloscope.  
Voltage variations may be noted due to normal produc-  
tion tolerances.  
LED930,931  
100mV/DIV,20µs/DIV  
2V/DIV,20µs/DIV  
DOOR IND  
SW  
BATT  
D807  
Q923,924  
RC IN1  
RC IN0  
98  
6
CNP801  
(REMOTE IN)  
ILL B+  
Q919  
ILL ON  
SWITCH  
3.8 Vp-p  
ILLON  
Approx. 200m Vp-p  
30.5 µs  
AEP,UK :LED933,934  
US,CND:LED910,911  
IC951(US,Canadian MODEL)  
IC971(AEP,UK MODEL)  
IC1 oa (FEO)  
IC801 qh (XOUT)  
Q918  
ILL B+  
SWITCH  
LCD BACK  
• Circled numbers refer to waveforms.  
• Signal path.  
BATT  
(
)
REMOTE  
CONTROL  
RECEIVER  
LIGHT  
100mV/DIV,20µs/DIV  
2
29 SIRCS  
F
f
J
c
: FM  
: AM/MW/LW  
: CD  
AEP,UK :LED903,911,951-954,LSW901(2/2),  
904(2/2)-910(2/2),912(2/2)-922(2/2)  
US,CND:LED901-906,LSW901(2/2)-917(2/2)  
34 NOSE SW  
: CD-R/RW (MP3)  
KEY  
S802  
(NOSE DET)  
Approx. 300m Vp-p  
(
)
ILLUMINATION  
for printed wiring boards:  
• X : parts extracted from the component side.  
• Y : parts extracted from the conductor side.  
IC1 od (TEO)  
OSC OUT 12  
OSC IN  
XIN  
15  
16  
X801  
18.432MHz  
1V/DIV,40ns/DIV  
•
•
•
x
: parts mounted on the conductor side.  
: Through hole.  
: Pattern from the side which enables seeing.  
X802  
32.768kHz  
13  
a
XOUT  
(The other layer’s patterns are not indicated.)  
Caution:  
Pattern face side: Parts on the pattern face side seen from the  
1.2 Vp-p  
82 ns  
IC3 yd (XTAL)  
(Side B)  
pattern face are indicated.  
Parts face side: Parts on the parts face side seen from the  
(Side A)  
parts face are indicated.  
23  
23  
                     
CDX-MP40  
3-6. PRINTED WIRING BOARDS — CD MECHANISM SECTION — • Refer to page 20 for Circuit Boards Location.  
14  
13  
12  
11  
10  
9
8
7
6
5
4
3
2
1
A
B
C
D
E
F
G
H
I
• Semiconductor  
Location  
Ref. No. Location  
IC1  
IC2  
IC3  
IC4  
IC5  
(IC6)  
IC7  
E-8  
H-8  
D-3  
G-2  
G-4  
E-3  
F-6  
E-4  
(IC12)  
C6  
C3  
(Q1)  
C-8  
(
): SIDE B  
Q1  
C16  
C78  
C44  
R5  
R114  
R121  
C15  
C19  
C20  
C23  
R9  
R8  
R105  
JR5  
C29  
IC6  
R107  
IC12  
C35  
C38  
L4  
C70  
C62  
C60  
C63  
C67  
R130  
R90  
R55  
C77  
R76  
R54  
C75  
FB6  
R77  
R91  
R45  
R46  
R94  
R92  
R47  
C81  
C30  
R48  
R67  
C55  
C57  
C22  
C58  
R7  
JR14  
24  
24  
 
CDX-MP40  
1
2
3
4
5
6
7
8
9
10  
11  
12  
13  
14  
A
B
C
D
E
F
G
H
I
CN2  
C43  
R29  
R118  
R111  
C11  
C4  
R109  
R100  
C9  
CN1  
FB3  
R117  
SW3  
(Page 28)  
C39  
C17  
C18  
R148  
C40  
IC3  
R102  
R78  
X2  
R124  
R128  
IC1  
SW2  
C113  
C27  
R136  
SW5  
X1  
C61  
R132  
C59  
JR15  
R153  
R131  
IC7  
R71  
R143  
R14  
R93  
SW4  
IC4  
R145  
R95  
R96  
R87  
C68  
IC5  
R12 R10  
R144  
JR12  
R142  
R146  
R70  
CN13  
IC2  
R83  
R88  
R85  
C56  
R89 R50  
C21  
CN3  
25  
25  
             
CDX-MP40  
• Refer to page 23 for Waveforms.  
3-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 36 for IC Block Diagram.  
Note:  
• Voltage is dc with respect to ground under no-signal  
conditions.  
no mark : CD PLAY  
M902  
SW4  
: Impossible to measure  
∗
CN13  
CN2  
CN3  
C1  
TP8  
C4  
C6  
C5  
TP9  
IC6  
C59  
C60  
L6  
C65  
Q1  
C3  
L8  
R152  
C19  
C24  
FB2  
R153  
TP89  
C18  
L4  
IC4  
C61  
C35  
C68  
C62  
TP10  
C67  
TP45  
TP44  
C63  
C14  
C13  
R5  
TP43  
TP42  
TP41  
JR21  
C56  
R69  
R70  
C57  
C77  
C11  
C81  
TP40  
R82  
TP39  
TP38  
R83  
R84  
JR14  
R68  
TP37  
R85  
RB2  
IC1  
R65  
FB6  
C58  
TP7 C15  
C10  
C55  
C38  
TP36  
TP12  
R142  
R144  
CN1  
C9  
C54  
TP50  
TP51  
TP11  
RB1  
R81  
TP52  
R146  
TP53  
JR13  
TP54  
TP55  
C8  
R86  
R87  
R49  
R50  
R51  
TP56  
R98  
R97  
R96  
R48  
R47  
R46  
TP57  
TP58  
R52  
R95  
R94  
IC5  
C36  
TP59  
C16  
R93  
R78  
R77  
R76  
TP60  
TP61  
R45  
R117  
R118  
R53  
R54  
R116 TP62  
TP63  
IC B/D  
X1  
R75  
TP64  
C53  
R74  
R55  
TP66  
R73  
TP67  
TP68  
(Page 30)  
C39  
R90 R91  
C34  
C44  
C78  
JR15  
TP70  
TP71  
R71  
C69  
R72  
C51  
TP72  
C29  
C45  
TP73  
R92  
TP76  
TP75  
TP49  
C79  
C41  
C27  
JR3  
JR6  
JR5  
JR1  
TP65  
FB3  
(Page 27)  
(Page 27)  
26  
26  
                 
CDX-MP40  
• Refer to page 23 for Waveform.  
3-8. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 36 for IC Block Diagrams.  
(Page 26)  
R105  
(Page 26)  
TP4  
TP3  
TP2  
TP1  
C114  
SW3  
SW2  
TP92  
TP33  
BP2  
R109  
R111  
R113  
TP31  
BP1  
IC B/D  
TP30TP32  
R15  
SW5  
R7  
R154  
IC B/D  
R12  
R14  
R100  
TP15  
BP3  
BP4  
TP21  
MD14  
R130  
R104  
R133  
R134  
R115  
C111  
IC12  
R10  
TP18  
C102  
C22  
C21  
R135  
R136  
IC2  
JR17  
IC3  
TP90  
C30  
C70  
TP87  
TP86  
R131  
TP17  
TP20  
TP27  
TP29  
M903  
R129  
TP91  
R107  
R132  
TP16  
TP19  
TP26  
TP28  
R106  
R119  
R124  
C113  
C112  
BP6  
R102  
R121  
R114  
X2  
Note:  
• Voltage is dc with respect to ground under no-signal  
conditions.  
no mark : CD PLAY  
: Impossible to measure  
∗
27  
27  
             
CDX-MP40  
• Refer to page 20 for Circuit Boards Location.  
3-9. PRINTED WIRING BOARDS — MAIN SECTION — • Refer to page 30 for Semiconductor Location.  
1
2
3
4
5
6
7
8
9
10  
11  
12  
13  
14  
PJ401  
CNP801  
A
B
C
D
E
F
G
H
I
PJ601  
CNJ801  
JW133  
CNP901  
JR401  
JW202  
JW201  
JW203  
D907  
D906  
JW204  
JW206  
JW208  
F901  
C415  
JW205  
JW207  
C421  
IC501  
JW23  
R406  
R412  
C418  
R410  
C419  
JW129  
R414  
JW24  
R806  
JW12  
JW13  
JR402  
R408  
Q402  
JW25  
JW3  
JW91  
C804  
Q912  
C408  
C405  
C407  
C406  
JW26  
JW27  
JW28  
JW29  
D923  
R903  
JW137  
US,Canadian Model  
TH900  
D912  
JR403  
C916  
JW130  
R409  
C905  
D911  
D910  
JW14  
C428  
JW30  
R407  
C425  
R805  
C413  
JW15  
JW16  
C409  
C429  
C902  
Q904  
JW20  
JW17  
C907  
C629  
C717  
L900  
C427  
TUX501  
JW21  
JW22  
JW18  
JW19  
R420  
R417  
C426  
D921  
R932  
R906 R907  
R418  
D806  
R804  
JR906  
JW123  
R909  
R913  
JW31  
JW32  
Q924  
Q901  
L703  
JW56  
JW120  
JW121  
C201  
D805  
Q909  
Q923  
D915  
C910  
L704  
D804  
R924  
JW33  
Q903  
R101  
R201  
JW124  
R926  
R935  
R934  
R104  
C714  
C922  
C503  
R202  
JW34  
Q914  
R502  
JW122  
C101  
JW35  
JW61  
R203  
JW39  
JW138  
JW117  
JW115  
C713  
C703  
Q910  
Q917  
TH901  
R111  
JW37  
JW38  
R927  
JR405  
C507  
D927  
Q920  
AEP,UK Model  
R112  
R102  
R204  
C210  
C211  
L702  
C712  
JW114  
C715  
C718  
Q802  
JW43  
Q922  
Q804  
R103  
JW134  
JW51  
JR116  
JW47  
Q921  
Q908  
(Page 25)  
R931  
JW106  
R925  
JW40  
C202  
C106  
R826  
Q806  
R707  
IC902  
D701  
Q906  
JW152  
JW118  
JW90  
R708  
IC701  
R505  
C207  
R843  
D802  
C705  
D917  
Q911  
R802  
JW125  
JW190  
R911  
D818  
JW80  
JW54  
C805  
Q915  
Q805  
FMB6  
JW89  
JW88  
JW135  
D810  
C918  
C917  
CNP701  
JR803  
JW82  
JW87  
C616  
JW141  
JW98  
Q907  
R608  
C704  
JW73  
D925  
R801  
JW41  
C617  
JW100  
JW102  
R824  
R821  
JW49  
R868  
R612  
JW96  
R829  
R607  
R830  
C813  
R820  
R823  
C621  
C821  
JW81  
Q801  
JR806  
C623  
C624  
C815  
JW86  
C622  
C615  
R812  
R609  
JW160  
R813  
R814  
R815  
JW78  
JW109  
JW116  
Q602  
IC801  
R620  
C807  
R811  
R870  
JR602  
D809  
JW128  
R866  
IC802  
X801  
C823  
JW191  
JW59  
JW79  
C817  
R836  
R819  
FMB5  
JW108  
R832  
R834  
C827  
R825  
R833  
CNP802  
S801  
S802  
FB701  
J
(Page 31)  
28  
28  
                   
CDX-MP40  
• Refer to page 23 for Waveform.  
3-10. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 36 for IC Block Diagrams.  
PJ601  
C629  
JR601  
Q602  
PJ401  
R620  
C421  
C420  
C717  
JW87  
JW82  
IC401  
IC B/D  
C503  
C419  
C418  
R103  
R102  
R112  
C215  
C213  
JW96  
R502  
C106  
C429 R416 R415 C417  
C212  
C505  
C506  
C211  
C210  
R111  
R204  
R203  
C416  
C428 R414 R413  
R404  
R403  
R401  
TUX501  
C208  
R201  
C209  
C204  
C203  
C206  
R402  
JR401  
R202  
C507  
C101  
C201  
C205  
C109  
L704  
R101  
R104  
C701  
R505  
C207  
C202  
C702  
C415 C413  
IC501  
D901  
D902  
IC B/D  
C401  
C424  
C425  
C402  
R405  
R406  
C405  
Q401  
Q402  
D903  
D904  
D905  
C615 C617 C618  
FB601  
R408  
R407  
C406  
C407  
C408  
X601  
R609  
R608  
R607  
CNP901  
D906  
D907  
D908  
C403 R409  
Q403  
Q404  
R410  
C426  
C427  
C404  
IC601  
R412  
R411  
R612  
C624  
R901  
C621  
C622  
C623  
R903  
Q904  
D921  
C412  
C907  
C409  
R904  
Q905  
C905  
D912  
C902  
R420  
C411  
R417  
R418  
R419  
L900  
F901  
D909  
R932  
C423  
D911  
D910  
Q922  
D923  
R905  
C901  
Q920  
Q906  
TH901  
Q911  
Q909  
R906  
Q903  
D915  
R913  
R911  
R934  
Q907  
R925  
Q901  
IC802  
Q902  
R910  
R930  
R811  
C807  
R935  
R924  
R923  
R922  
D917  
R931  
D918  
C918  
C917  
C922  
C920  
R909  
C909  
Q921  
Q917  
R908  
Q910  
C910  
R907  
C806  
Q908  
C814  
C817  
D919  
(Page 30)  
Note:  
• Voltage is dc with respect to ground under no-signal  
conditions.  
no mark : FM  
(
) : AM/MW/LW  
29  
29  
         
CDX-MP40  
• Refer to page 23 for Waveforms.  
3-11. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 36 for IC Block Diagram.  
(Page 29)  
R707  
R706  
R801  
R802  
D802  
D801  
R705  
IC701  
D808  
D818  
C716  
C715  
IC902  
Q801  
Q804  
C718  
D810  
IC B/D  
TH900  
IC803  
CNJ801  
R824  
FB801  
C818  
CNP701  
R702  
C812  
C813  
R823  
C802  
R821 R822  
D920  
Q803  
R826  
R805  
R804  
C804  
C805  
C803  
R812  
C815  
R868  
R825  
R843  
C704  
R708  
D701  
Q805  
Q802  
Q806  
Q918  
R806  
R807  
R813  
C705  
CNP801  
R814  
R815  
L701  
X802  
C816  
C808  
C809  
(Page  
26)  
D807  
R918  
12  
R914  
Q923  
IC801  
2W  
C822  
R816  
C823  
C712  
C719  
R915  
X801  
D819  
R820  
JR801  
Q919  
D809  
L702  
Q924  
R817  
R818  
JR906  
JR805  
R819  
C714 L703  
C713  
C703  
C810  
CNP802  
R834  
R832  
R833  
R830  
R829  
C825  
Q916  
Q912  
(Page 33)  
(Page 35)  
Q913  
R836  
R831  
R870  
R828  
R927  
R926  
C916  
D925  
Q915  
R835  
C826  
C827  
Q914  
S801  
S802  
D927  
C811  
JW174  
D926  
FB701  
• Semiconductor Location  
Ref. No. Location Ref. No. Location  
Ref. No. Location  
Ref. No. Location  
Ref. No. Location  
Ref. No. Location  
Ref. No. Location  
D701  
D801  
D802  
D804  
D805  
D806  
D807  
D808  
D809  
D810  
D811  
D812  
D813  
F-5  
G-9  
G-9  
D-9  
D-9  
D-9  
I-4  
G-8  
I-2  
G-8  
J-3  
J-2  
J-2  
D814  
D815  
D816  
D817  
D818  
D819  
D901  
D902  
D903  
D904  
D905  
D906  
D907  
J-3  
J-3  
I-2  
D908  
D909  
D910  
D911  
D912  
D915  
D916  
D917  
D918  
D919  
D920  
D921  
D923  
C-5  
C-9  
D-8  
C-8  
C-8  
D-6  
E-7  
G-10  
F-2  
E-2  
G-6  
D-5  
C-7  
D925  
D926  
D927  
G-9  
C-10  
E-7  
Q401  
Q402  
Q403  
Q404  
Q602  
Q801  
Q802  
Q803  
Q804  
Q805  
Q806  
Q901  
C-4  
C-3  
C-3  
C-4  
H-3  
H-9  
F-9  
H-8  
F-9  
G-9  
F-9  
D-6  
Q902  
Q903  
Q904  
Q905  
Q906  
Q907  
Q908  
Q909  
Q910  
Q911  
Q912  
Q913  
D-6  
E-7  
Q914  
Q915  
Q916  
Q917  
Q918  
Q919  
Q920  
Q921  
Q922  
Q923  
Q924  
E-7  
G-9  
E-7  
D-5  
D-5  
F-10  
G-9  
F-10  
D-9  
E-9  
F-2  
C-10  
E-8  
J-2  
G-8  
F-5  
C-6  
C-6  
C-6  
C-6  
C-5  
B-7  
B-7  
E-9  
IC401  
IC501  
IC601  
IC701  
IC801  
IC802  
IC803  
IC902  
E-3  
B-5  
H-3  
F-7  
H-7  
I-10  
F-9  
F-4  
G-10  
H-10  
E-10  
F-10  
F-8  
Note:  
• Voltage is dc with respect to ground under no-signal  
conditions.  
no mark : FM  
(
D-5  
D-4  
) : AM/MW/LW  
> : CD PLAY  
<
30  
30  
             
CDX-MP40  
3-12. PRINTED WIRING BOARD — RELAY SECTION — • Refer to page 20 for Circuit Boards Location.  
1
2
3
4
5
6
7
8
9
10  
(Page 32)  
(Page 34)  
A
B
C
D
E
F
G
H
I
LED931  
S931  
R932  
R931  
R930  
CNP902  
LED930  
FMA3  
(Page 28)  
CNP903  
J
31  
31  
   
CDX-MP40  
3-13. PRINTED WIRING BOARD — KEY SECTION (US, Canadian MODEL) — • Refer to page 20 for Circuit Boards Location.  
1
2
3
4
5
6
7
8
9
10  
11  
12  
13  
14  
A
B
C
D
E
F
G
H
I
LED901  
LSW913  
S901  
LSW903  
LSW911  
LSW904  
LED911  
LED902  
S902  
LED903  
LED905  
LED904  
LED906  
LCD901  
LED910  
LSW906  
IC951  
S903  
LSW912  
LSW905  
LSW902  
LSW901  
LSW917  
LSW910  
LSW915  
LSW907  
LSW908  
LSW916  
LSW909  
LSW914  
R920  
R977  
R909  
R917  
R910  
R919  
R918  
R916  
R975  
R914  
C953  
R951  
D951  
C955  
R959  
R962  
R958  
CN901  
C956  
C954  
C951  
R973  
R981  
• Semiconductor Location  
Ref. No. Location Ref. No. Location  
Ref. No. Location  
Ref. No. Location  
D901  
D902  
D903  
D904  
D905  
H-10  
H-10  
H-10  
H-10  
G-10  
D907  
D951  
G-12  
H-13  
LED901  
LED902  
LED903  
LED904  
A-2  
LED905  
LED906  
LED910  
LED911  
C-1  
C-12  
C-4  
C-14  
C-14  
C-2  
(Page 31)  
IC901  
IC951  
G-8  
C-13  
C-11  
J
32  
32  
     
CDX-MP40  
3-14. SCHEMATIC DIAGRAM — RELAY, KEY SECTION (US, Canadian MODEL) —  
R951  
R972  
R974  
R976  
R978  
R980  
R982  
R966  
R967 R940  
R941  
LSW901(2/2)  
LSW914(2/2)  
LSW910(2/2)  
LSW905(2/2)  
LSW902(2/2)  
C951  
IC951  
LED910  
LED911  
LED906  
LSW915(2/2)  
LSW912(2/2)  
LSW909(2/2)  
LSW906(2/2)  
LED904  
LED905  
LED901  
R952  
C954  
C956  
C955  
R958  
R962  
R959  
R960  
R957  
R953  
R954  
R955  
R956  
IC901  
LSW911(2/2)  
LSW913(2/2)  
LSW916(2/2)  
LSW917(2/2)  
LSW908(2/2)  
LSW907(2/2)  
LED902  
LED903  
LSW903(2/2)  
LSW904(2/2)  
C953  
C952  
R968  
R969 R942  
R943  
R961  
R973  
R975  
R977  
R979  
R981  
R983  
D905  
S902  
R912  
LSW913(1/2)  
LSW911(1/2)  
LSW912(1/2)  
R901  
LSW901(1/2)  
S901  
R932  
R931  
R930  
CNP902  
CN901  
LED931  
LED930  
R913  
R914  
R915  
S931  
R902  
R903  
C973  
CNP903  
S903  
D907  
LSW903(1/2) R904  
LSW914(1/2)  
LSW915(1/2)  
LSW916(1/2)  
LSW917(1/2)  
LSW910(1/2)  
LSW909(1/2)  
LSW908(1/2)  
LCD901  
R905  
R906  
R907  
R908  
R909  
LSW904(1/2)  
LSW905(1/2)  
LSW906(1/2)  
LSW902(1/2)  
LSW907(1/2)  
C974  
R917  
R918  
R919  
R920  
R916  
R910  
(Page 30)  
Note:  
• Voltage is dc with respect to ground under no-signal  
conditions.  
no mark : FM  
33  
33  
     
CDX-MP40  
3-15. PRINTED WIRING BOARD — KEY SECTION (AEP, UK MODEL) — • Refer to page 20 for Circuit Boards Location.  
1
2
3
4
5
6
7
8
9
10  
11  
12  
13  
14  
A
B
C
D
E
F
G
H
I
LED954  
LSW913  
S902  
LSW904  
LSW912  
LSW905  
R966  
LED933  
LED952  
LED934  
LSW907  
IC971  
S903  
S911  
LSW914  
LSW906  
LSW901  
LSW919  
LSW922  
LSW920  
LSW915  
LSW909  
LSW910  
LSW917  
LSW918  
LSW916  
LSW921  
LSW908  
R920  
R917  
FMB5  
R916  
R915  
R914  
R934  
C971  
R918  
R901  
R971  
R946  
IC901  
R982  
C985  
R989  
R970  
CN901  
D901  
R962  
R927  
R929  
FMB6  
R961  
R960  
R975  
• Semiconductor Location  
Ref. No. Location Ref. No. Location  
Ref. No. Location  
D901  
D902  
D981  
D983  
H-10  
H-11  
G-6  
IC971  
C-13  
LED934  
LED951  
LED952  
LED953  
LED954  
C-4  
C-14  
C-12  
C-1  
(Page 31)  
LED903  
LED911  
LED933  
C-2  
C-14  
C-11  
J
H-6  
A-2  
IC901  
G-8  
34  
34  
     
CDX-MP40  
3-16. SCHEMATIC DIAGRAM — RELAY, KEY SECTION (AEP, UK MODEL) —  
R981 R982 R983  
R972  
IC971  
LSW912(2/2)  
LSW913(2/2)  
LED933  
LSW905(2/2)  
LSW915(2/2)  
LSW919(2/2)  
LSW920(2/2)  
LSW921(2/2)  
LSW922(2/2)  
LED903  
LED953  
C971  
LED954  
R927  
R930  
R931  
R935  
R936  
R950  
R951  
D981  
LSW916(2/2)  
LSW917(2/2)  
LSW918(2/2)  
R990  
C986  
R928  
C981  
C985  
IC901  
R986  
R987  
R988  
R985  
C982  
LED952  
R989  
LSW906(2/2)  
LSW904(2/2)  
C983  
LED911  
LED951  
R934  
R960  
C984  
R979  
R980  
R978  
R961  
R962  
R966  
R967  
R929  
LSW914(2/2)  
LSW909(2/2)  
LSW910(2/2)  
R941  
R946  
LED934  
LSW901(2/2)  
LSW908(2/2)  
LSW907(2/2)  
R942  
R947  
R970  
R911  
R912  
R913  
R914  
R915  
R916  
R917  
R918  
R919  
R920  
R921  
LSW913(1/2) LSW914(1/2)  
LSW915(1/2) LSW916(1/2) LSW917(1/2) LSW918(1/2) LSW919(1/2) LSW920(1/2) LSW921(1/2) LSW922(1/2)  
S911  
LSW912(1/2)  
R901  
R902  
S902  
R903  
R904  
R905  
R906  
R907  
R908  
R909  
R910  
LSW901(1/2)  
LSW908(1/2) LSW909(1/2) LSW910(1/2)  
LSW905(1/2)  
LSW907(1/2)  
LSW904(1/2)  
LSW906(1/2)  
R932  
R931  
R930  
CNP902  
CN901  
R971  
S903  
LED931  
LED930  
S931  
C973  
CNP903  
D902  
C974  
R975  
R976  
R977  
(Page 30)  
D901  
LCD901  
Note:  
• Voltage is dc with respect to ground under no-signal  
conditions.  
no mark : FM  
35  
35  
     
CDX-MP40  
3-17. IC BLOCK DIAGRAMS  
IC1 µPD63711GC-8EU  
IC2 BA5810FP-E2  
IC12 TC7SH08FU-TE85R  
BIAS  
FWD  
REV  
28  
1
5
4
VCC  
OUT  
IN B  
IN A  
GND  
1
2
3
75  
74  
73  
72 71 70 69 68  
67  
66  
65  
64  
63  
62  
61 60 59  
58  
57  
56  
55  
54  
53  
52  
51  
LOADING PRE  
FWD REV  
2
OPIN4+  
OPIN4–  
27  
26  
–
MICROCOMPUTER INTERFACE  
AGCI  
RFO  
EQ2  
EQ1  
RF-  
AGND  
A
C2D3  
C2D2  
C2D1  
C1D2  
C1D1  
76  
77  
78  
79  
80  
81  
82  
83  
84  
85  
86  
87  
88  
89  
90  
91  
92  
93  
94  
EFM  
50  
49  
48  
47  
46  
LDCONT  
PS  
X3  
3
4
COMPARATOR  
POWER  
SAVE  
CD-TEXT DECODER  
OPOUT4  
25  
EFM  
D/A  
IN1  
IN2  
5
6
OPIN3+  
OPIN3–  
24  
23  
SUB-CODE PROCESSOR  
–
16K  
SRAM  
MEMORY  
PROCESSOR  
AUTO GAIN  
FD/TD/SD/MD  
CONTROLLER  
CONTROLLER  
PREVCC  
(PRE.LOADING)  
+
+
DGND  
PLCK  
45  
44  
OPOUT3  
MUTE  
22  
21  
DIGITAL PLL  
ADDER  
PREVCC  
POWVCC  
7
8
EFM DEMODULATOR  
TIMING GENERATOR  
FEOFS  
TEOFS  
POWVCC12  
(CH1.CH2)  
IC803 MM1175XFF  
MIRR/WFCK  
43  
C
SVDRAM  
CH1-4  
MUTE  
+
+
SVCRAM  
ROM  
MULTIPLIER  
SVROM  
B
RFCK  
42  
41  
40  
39  
38  
37  
36  
35  
34  
33  
32  
31  
30  
29  
RF  
POWVCC34  
(CH3,CH4)  
D
LOCK  
DVDD  
TSOI  
VCC  
RST  
14  
13  
1
BUSON  
RST  
DECODER  
AMP BLOCK  
VOL–  
VOL+  
9
F
POWVCC  
GND  
20  
19  
RESET  
SWITCH  
2
EFM  
E
10  
CLV  
AVDD  
REFOUT  
FE-  
C16M  
DGND  
TX  
BATT  
SWITCH  
10k  
PROCESSOR  
10k  
3
4
5
12  
11  
10  
BATT  
CLK  
BUSON  
CLK-IN  
10k  
10k  
–
–
–
–
VO2–  
VO2+  
VO3–  
VO3+  
11  
12  
18  
17  
LEVEL  
SHIFT  
LEVEL  
SHIFT  
DIGITAL  
AUDIO  
INTERFACE  
SWITCH  
DEFECT  
DEFECT  
COMPARATOR  
10k  
10k  
10k  
10k  
10k  
10k  
D/A  
10k  
10k  
FEO  
TE-  
HOLD/WDCK  
LRCK  
LRCKIN  
SCKO  
SCKIN  
DOUT  
DIN  
VREF  
INTERFACE  
CIRCUIT  
B/U-C  
FOK  
A3T  
RFENV  
MIRENV  
–
–
–
–
VO1–  
VO1+  
VO4–  
VO4+  
13  
14  
16  
15  
DATA  
I/O  
LEVEL  
SHIFT  
LEVEL  
SHIFT  
6
7
9
8
DATA IN  
TEO  
TE2  
DE-EMPHASIS CIRCUIT  
MIRR  
TRACKING  
REGISTER  
GND  
DATA OUT  
10k  
10k  
10k  
10k  
FEO  
TEO  
TEC 95  
FOCUS  
REGISTER  
OCTUPLED  
OVERSAMPLING DIGITAL FILTER  
AGND  
96  
97  
COMPARATOR  
PD  
NOISE SHAVER NOISE SHAVER  
OUTPUT BUFFER OUTPUT BUFFER  
LD 98  
PN 99  
28 FLAG  
EMPH  
DVDD  
27  
26  
AVDD  
100  
MICROCOMPUTER INTERFACE  
SCF  
OSC  
IC601 SAA6588T/V2-518  
1
2
3
4
5
6
7
8
9
10  
11  
12  
13  
14 15 16 17 18  
19  
20  
21 22 23  
24  
25  
20  
19  
18  
17  
16  
15  
14  
13  
12 11  
POWER SUPPLY  
& RESET  
PAUSE  
DETECTOR  
MULTI  
PATH  
DETECTOR  
57kHz  
8th ORDER  
BAND-PASS FILTER  
CLOCKED  
COMPARATOR  
SIGNAL QUALITY  
DECODER  
4
5
4
CLOCK  
CLOCK  
DATA  
RDS/RDBS  
DEMODULATOR  
RDS/RDBS  
DECODER  
INTERFACE  
REGISTER  
DATA  
TEST  
CONTROL  
OSCILLATOR  
& CLOCK  
IIC BUS SLAVE  
TRANSCEIVER  
1
2
3
4
5
6
7
8
9
10  
36  
36  
         
CDX-MP40  
IC401 BD3802F (MAIN Board)  
OUT-  
FR  
21  
OUT-  
RR  
20  
OUT-  
FL  
19  
OUT-  
RL  
18  
D-GND  
28  
SDA  
27  
SCL  
26  
MUTE  
25  
SEL  
24  
ADJ  
23  
VCC  
22  
DS32 DS22 DS12  
17  
16  
15  
VCC  
FADER  
FADER  
(0~-58,  
-∞dB)  
FADER  
FADER  
I2C BUS  
LOGIC  
(0~-58,  
(0~-58,  
(0~-58,  
VCO  
-∞dB)  
-∞dB)  
-∞dB)  
ON  
OFF  
ON  
OFF  
EFFECT (OFF,6dB,  
10dB,14dB)  
EFFECT (OFF,6dB,  
10dB,14dB)  
TONE  
PASS  
TONE  
PASS  
BASS,TREBLE, MIDDLE  
(-15dB~+15dB,1dB STEP)  
BASS,TREBLE, MIDDLE  
(-15dB~+15dB,1dB STEP)  
VOLUME  
(+23~-79dB,-∞dB  
1dB STEP)  
VOLUME  
(+23~-79dB,-∞dB  
1dB STEP)  
INPUT GAIN  
(0~15dB,1dB STEP)  
INPUT GAIN  
(0~15dB,1dB STEP)  
MUTE  
MUTE  
INPUT SELECTOR  
(4 STEREO INCLUDE 1 ISOLATION INPUT)  
VCC/2  
1
2
FIL  
3
BUS-  
RCH  
4
AN  
5
6
7
TU-  
LCH  
8
CD-  
RCH  
9
CD-  
LCH  
10  
D1  
11 12  
D2 DS11 DS21 DS31  
13 14  
A-GND  
BUS- TU-  
LCH RCH  
37  
 
CDX-MP40  
SECTION 4  
EXPLODED VIEWS  
NOTE:  
• The mechanical parts with no reference  
number in the exploded views are not supplied.  
• Items marked “*” are not stocked since  
they are seldom required for routine service.  
Some delay should be anticipated  
when ordering these items.  
• Color Indication of Appearance Parts  
Example :  
The components identified by  
mark 0 or dotted line with mark  
0 are critical for safety.  
Replace only with part number  
specified.  
KNOB, BALANCE (WHITE) ... (RED)  
R
R
Parts Color Cabinet’s Color  
• Accessories are given in the last of this  
• -XX and -X mean standardized parts, so  
they may have some difference from the  
original one.  
parts list.  
• Abbreviation  
CND: Canadian model  
Les composants identifiés par une  
marque 0 sont critiques pour  
la sécurité.  
Ne les remplacer que par une piéce  
portant le numéro spécifié.  
4-1. CHASSIS SECTION  
9
10  
MG-393MC-121  
#1  
15  
#1  
#3  
#3  
#5  
not  
supplied  
11  
#4  
#3  
not supplied  
13  
#3  
14  
#3  
12  
not  
supplied  
TUX501  
4
F901  
not supplied  
(RELAY board)  
1
5
not supplied  
8
11  
6
#1  
7
2
#2  
#1  
#2  
#2  
3
#1  
not supplied  
not supplied  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
1
2
3
X-3382-626-1 PANEL ASSY (CD), SUB  
3-246-030-01 BUTTON (EJECT)  
1-792-173-11 CABLE, FLAT (FFC) 12P  
X-3376-686-4 GEAR ASSY  
12  
12  
13  
A-3274-739-A MAIN BOARD, COMPLETE (US,CND)  
A-3274-742-A MAIN BOARD, COMPLETE (AEP,UK)  
3-041-261-11 BRACKET (TR)  
4
* 14  
3-019-565-01 BRACKET (IC)  
* 5  
X-3376-689-2 BRACKET (GEAR) ASSY  
15  
3-223-913-11 LABEL (OP CAUTION) (AEP,UK)  
6
7
8
9
9
3-030-909-03 DAMPER, OIL  
3-713-786-51 SCREW +P 2X3  
X-3376-687-2 LOCK ASSY  
1-776-207-82 CORD (WITH CONNECTOR) (POWER) (US,CND)  
1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)  
(AEP,UK)  
F901  
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A  
TUX501 A-3220-887-A TUNER UNIT (TUX-030)  
#1  
#2  
#3  
7-685-792-09 SCREW +PTT 2.6X6 (S)  
7-621-772-20 SCREW +B 2X5  
7-685-793-09 SCREW +PTT 2.6X8 (S)  
#4  
#5  
7-685-795-09 SCREW +PTT 2.6X12 (S)  
7-685-134-19 SCREW +P 2.6X8 TYPE2 NON-SLIT  
10  
11  
3-246-007-01 BRACKET (CD)  
3-922-535-11 SCREW (+BTT)  
38  
CDX-MP40  
4-2. FRONT PANEL SECTION  
not supplied  
(DISPLAY board (US, CND))  
(KEY board (AEP, UK))  
#6  
not supplied  
#6  
not supplied  
LCD901  
57  
56  
55  
not supplied  
not supplied  
not  
not supplied  
not supplied  
54  
supplied  
52  
53  
not  
supplied  
51  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
51  
51  
52  
52  
53  
A-3337-163-A OVERALL ASSY, FRONT PANEL (AEP,UK)  
A-3337-442-A PANEL COMPLETE ASSY, FRONT (US,CND)  
X-3382-827-1 PANEL (S) ASSY, FRONT (AEP,UK)  
X-3383-151-1 PANEL (S) ASSY, FRONT (US,CND)  
3-246-534-01 SPRING (RELEASE) (US,CND)  
56  
56  
57  
57  
X-3382-625-1 PANEL ASSY, FRONT BACK (US,CND)  
X-3382-702-1 PANEL ASSY, FRONT BACK (AEP,UK)  
X-3378-390-3 CASE ASSY (for FRONT PANEL) (US,CND)  
X-3378-490-2 CASE (PANEL) ASSY (for FRONT PANEL)  
(AEP,UK)  
LCD901 1-805-084-11 DISPLAY PANEL, LIQUID CRYSTAL  
#6 7-685-106-19 SCREW +P 2X10 TYPE2 NON-SLIT  
53  
54  
54  
55  
55  
3-246-778-01 SPRING (OPEN) (AEP,UK)  
X-3383-105-1 BUTTON ASSY (S) (AEP,UK)  
X-3383-169-1 BUTTON ASSY (S) (US,CND)  
1-694-976-11 CONDUCTIVE BOARD, CONNECTION (AEP,UK)  
1-694-989-11 CONDUCTIVE BOARD, CONNECTION (US,CND)  
39  
CDX-MP40  
4-3. CD MECHANISM SECTION (1)  
(MG-393MC-121)  
102  
#7  
#7  
104  
103  
107  
101  
116  
109  
#8  
117  
114  
106  
115  
105  
114  
105  
113  
108  
110  
M903  
#9  
112  
#7  
111  
#8  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
101  
102  
103  
104  
105  
A-3274-253-A DISC IN SW BOARD, COMPLETE  
3-040-039-03 CHASSIS (T)  
3-040-038-01 SPRING (LR), TENSION  
3-040-050-01 LEVER (L)  
3-040-022-01 RETAINER (ROLLER), SHAFT  
112  
113  
114  
115  
116  
3-221-779-02 BRACKET (MOTOR)  
3-040-034-01 SPRING (RA), TENSION  
3-040-042-01 WASHER  
3-043-880-01 RING (RA), RETAINING  
3-044-206-11 SCREW, SPECIAL  
106  
107  
108  
109  
110  
3-040-044-01 ROLLER (S)  
3-040-067-01 LEVER (R)  
A-3301-980-A SHAFT ROLLER ASSY  
3-040-037-01 GUIDE (DISC)  
3-040-040-03 ARM (ROLLER)  
117  
M903  
#7  
#8  
#9  
1-685-337-11 LOAD SW BOARD  
A-3315-039-A MOTOR SUB ASSY, LO (LOADING)  
7-627-553-37 SCREW, PRECISION +P 2X3 TYPE 3  
7-628-253-00 SCREW, SPECIAL  
7-627-553-17 SCREW, PRECISION +P 2X2 TYPE 3  
111  
A-3274-698-A SERVO BOARD, COMPLETE  
40  
CDX-MP40  
4-4. CD MECHANISM SECTION (2)  
(MG-393MC-121)  
154  
151  
156  
157  
157  
158  
164  
160  
not supplied  
162  
153  
155  
163  
161  
159  
152  
152  
152  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
151  
152  
153  
154  
155  
3-040-025-02 ARM, CHUCKING  
3-040-031-01 DAMPER (T)  
3-040-056-01 LEVER (D)  
3-040-024-01 RETAINER (DISC)  
3-040-054-01 WHEEL (LW), WORM  
158  
159  
160  
161  
162  
3-040-033-01 SPRING (KF1), TENSION  
A-3307-422-A CHASSIS (M) COMPLETE ASSY  
3-040-059-01 SPRING (TR), TENSION  
3-040-057-01 LEVER (LOCK)  
3-040-058-01 GEAR (MDL)  
156  
157  
3-040-026-01 SPRING (CH), TENSION  
3-040-032-01 SPRING (FL), COMPRESSION  
163  
164  
3-040-052-01 WHEEL (U), WORM  
3-040-051-02 LEVER (TR)  
41  
CDX-MP40  
4-5. CD MECHANISM SECTION (3)  
(MG-393MC-121)  
201  
not supplied  
207  
202  
208  
M902  
203  
209  
#10  
#7  
204  
211  
205  
206  
210  
209  
The components identified by Les composants identifiés par une  
mark 0 or dotted line with mark marque 0 sont critiques pour  
0 are critical for safety.  
Replace only with part number Ne les remplacer que par une piéce  
specified.  
portant le numéro spécifié.  
la sécurité.  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
201  
202  
203  
204  
205  
A-3337-193-A FLOATING BLOCK ASSY  
3-040-029-01 SPRING (SL), TORSION  
3-040-045-01 BASE (DRIVING)  
3-040-194-01 GEAR (MIDWAY)  
A-3301-983-A SHAFT (FEED) ASSY  
208  
209  
0210  
211  
A-3274-254-A LIMIT SW BOARD, COMPLETE  
3-909-607-01 SCREW  
8-820-165-06 OPTICAL PICK-UP KSS-721A/C-RP  
1-676-707-11 PICK-UP FLEXIBLE BOARD  
A-3301-985-A MOTOR ASSY, SLED (SLED)  
M902  
206  
207  
3-040-030-01 SPRING (FEED), PLATE  
1-823-951-11 CABLE, FLEXIBLE FLAT (16 CORE)  
#7  
#10  
7-627-553-37 SCREW, PRECISION +P 2X3 TYPE 3  
7-627-850-28 SCREW, PRECISION +P 1.4X3  
42  
CDX-MP40  
SECTION 5  
ELECTRICAL PARTS LIST  
DISC IN SW DISPLAY  
NOTE:  
• Due to standardization, replacements in  
the parts list may be different from the  
parts specified in the diagrams or the  
components used on the set.  
• -XX and -X mean standardized parts, so  
they may have some difference from the  
original one.  
• Items marked “*” are not stocked since  
they are seldom required for routine service.  
Some delay should be anticipated  
when ordering these items.  
• SEMICONDUCTORS  
In each case, u : µ, for example:  
uA.. : µA.. uPA.. : µPA..  
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..  
• CAPACITORS  
The components identified by  
mark 0 or dotted line with mark  
0 are critical for safety.  
Replace only with part number  
specified.  
Les composants identifiés par une  
marque 0 sont critiques pour  
la sécurité.  
• RESISTORS  
All resistors are in ohms.  
METAL:Metal-film resistor.  
METAL OXIDE: Metal oxide-film resistor.  
F:nonflammable  
uF : µF  
• COILS  
uH : µH  
Ne les remplacer que par une piéce  
portant le numéro spécifié.  
• Abbreviation  
CND: Canadian model  
When indicating parts by reference  
number, please include the board.  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
A-3274-253-A DISC IN SW BOARD, COMPLETE  
**************************  
*************************************************************  
LED903 8-719-053-09 LED SML-310VT-T86 (EQ3) (US,CND)  
LED904 8-719-053-09 LED SML-310VT-T86 (DSO) (US,CND)  
LED905 8-719-053-09 LED SML-310VT-T86 (DSO) (US,CND)  
LED906 8-719-053-09 LED SML-310VT-T86 (SEEK) (US,CND)  
DISPLAY BOARD (US,CND)  
LED910 6-500-459-01 LED NSCW505T-ARS (LCD BACK LIGHT)  
**************  
(US,CND)  
1-694-989-11 CONDUCTIVE BOARD, CONNECTION (US,CND)  
< CAPACITOR >  
LED911 6-500-459-01 LED NSCW505T-ARS (LCD BACK LIGHT)  
(US,CND)  
< SWITCH >  
C951  
C952  
C953  
C954  
C955  
1-164-227-11 CERAMIC CHIP 0.022uF 10%  
25V  
(US,CND)  
10V  
(US,CND)  
50V  
(US,CND)  
25V  
(US,CND)  
16V  
(US,CND)  
LSW901 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (OFF)  
1-125-891-11 CERAMIC CHIP 0.47uF  
1-162-927-11 CERAMIC CHIP 100PF  
10%  
5%  
(US,CND)  
LSW902 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (MODE)  
(US,CND)  
LSW903 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SEL)  
(US,CND)  
1-164-227-11 CERAMIC CHIP 0.022uF 10%  
LSW904 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (VOLUME +)  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
< CONNECTOR >  
10%  
10%  
(US,CND)  
LSW905 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (VOLUME –)  
(US,CND)  
C956  
16V  
(US,CND)  
LSW906 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (ATT)  
(US,CND)  
LSW907 1-771-883-31 SWITCH, TACTILE (WITH LED) (SENS)  
(US,CND)  
CN901 1-817-158-11 PLUG, CONNECTOR 14P (US,CND)  
< DIODE >  
LSW908 1-771-883-31 SWITCH, TACTILE (WITH LED) (1/DISC –)  
(US,CND)  
LSW909 1-771-883-31 SWITCH, TACTILE (WITH LED) (2/DISC +)  
(US,CND)  
D901  
D902  
D903  
D904  
D905  
8-719-083-66 DIODE UDZS-TE-17-18B (US,CND)  
8-719-978-33 DIODE DTZ-TT11-6.8B (US,CND)  
8-719-978-33 DIODE DTZ-TT11-6.8B (US,CND)  
8-719-978-33 DIODE DTZ-TT11-6.8B (US,CND)  
8-719-988-61 DIODE 1SS355TE-17 (US,CND)  
LSW910 1-771-883-31 SWITCH, TACTILE (WITH LED) (3/REP)  
(US,CND)  
LSW911 1-771-476-11 SWITCH, KEYBOARD (WITH LED)  
(+ > M SEEK) (US,CND)  
LSW912 1-771-476-11 SWITCH, KEYBOARD (WITH LED)  
D907  
D951  
8-719-978-33 DIODE DTZ-TT11-6.8B (US,CND)  
8-719-069-54 DIODE UDZS-TE-17-5.1B (US,CND)  
(SEEK m . –) (US,CND)  
LSW913 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (DSPL)  
(US,CND)  
< IC >  
LSW914 1-771-883-31 SWITCH, TACTILE (WITH LED) (BTM)  
(US,CND)  
IC901  
IC951  
8-759-826-21 IC LC75874W (US,CND)  
8-749-017-35 IC KSM-401N (US,CND)  
LSW915 1-771-883-31 SWITCH, TACTILE (WITH LED) (6) (US,CND)  
LSW916 1-771-883-31 SWITCH, TACTILE (WITH LED) (5) (US,CND)  
LSW917 1-771-883-31 SWITCH, TACTILE (WITH LED) (4/SHUF)  
(US,CND)  
< LIQUID CRYSTAL DISPLAY >  
LCD901 1-805-084-11 DISPLAY PANEL, LIQUID CRYSTAL (US,CND)  
< DIODE >  
< RESISTOR >  
R901  
1-216-819-11 METAL CHIP  
680  
5%  
1/10W  
LED901 8-719-053-09 LED SML-310VT-T86 (SOURCE) (US,CND)  
LED902 8-719-053-09 LED SML-310VT-T86 (EQ3) (US,CND)  
(US,CND)  
43  
 
CDX-MP40  
DISPLAY KEY  
Ref. No.  
R902  
Part No.  
Description  
Remark  
Ref. No.  
R960  
Part No.  
Description  
Remark  
1-216-819-11 METAL CHIP  
1-216-819-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-823-11 METAL CHIP  
1-216-823-11 METAL CHIP  
680  
680  
1K  
5%  
5%  
5%  
5%  
5%  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
1-216-821-11 METAL CHIP  
1-216-857-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-815-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1K  
5%  
5%  
5%  
5%  
5%  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
R903  
R904  
R905  
R906  
R961  
R962  
R966  
R967  
1M  
1K  
1.5K  
1.5K  
330  
470  
(US,CND)  
(US,CND)  
R907  
R908  
R909  
R910  
R912  
1-216-825-11 METAL CHIP  
1-216-827-11 METAL CHIP  
1-216-834-11 METAL CHIP  
1-216-832-11 METAL CHIP  
1-216-819-11 METAL CHIP  
2.2K  
3.3K  
12K  
8.2K  
680  
5%  
5%  
5%  
5%  
5%  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
R968  
R969  
R972  
R973  
R974  
1-216-815-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
330  
470  
100  
100  
100  
5%  
5%  
5%  
5%  
5%  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
1/10W  
(US,CND)  
(US,CND)  
R913  
R914  
R915  
R916  
R917  
1-216-819-11 METAL CHIP  
1-216-819-11 METAL CHIP  
1-216-826-11 METAL CHIP  
1-218-867-11 METAL CHIP  
1-216-823-11 METAL CHIP  
680  
5%  
5%  
5%  
5%  
5%  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
R975  
R976  
R977  
R978  
R979  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-811-11 METAL CHIP  
1-216-811-11 METAL CHIP  
100  
100  
100  
150  
150  
5%  
5%  
5%  
5%  
5%  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
680  
2.7K  
6.8K  
1.5K  
(US,CND)  
(US,CND)  
R918  
R919  
R920  
R940  
R941  
1-216-825-11 METAL CHIP  
1-216-827-11 METAL CHIP  
1-216-829-11 METAL CHIP  
1-216-815-11 METAL CHIP  
1-216-817-11 METAL CHIP  
2.2K  
3.3K  
4.7K  
330  
5%  
5%  
5%  
5%  
5%  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
R980  
R981  
R982  
R983  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
100  
100  
100  
100  
5%  
5%  
5%  
5%  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
470  
(US,CND)  
< SWITCH >  
R942  
R943  
R951  
R952  
R953  
1-216-815-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-815-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1-216-821-11 METAL CHIP  
330  
470  
330  
2.2K  
1K  
5%  
5%  
5%  
5%  
5%  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
S901  
S902  
S903  
1-771-884-31 SWITCH, TACTILE (WITH LED) (SOURCE)  
(US,CND)  
1-771-884-31 SWITCH, TACTILE (WITH LED) (EQ3)  
(US,CND)  
(US,CND)  
1-771-884-31 SWITCH, TACTILE (WITH LED) (DSO)  
**************************************************************  
1/10W  
KEY BOARD (AEP,UK)  
(US,CND)  
**********  
R954  
R955  
R956  
R957  
R958  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-850-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1K  
5%  
5%  
5%  
5%  
5%  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
(US,CND)  
1/10W  
1-694-976-11 CONDUCTIVE BOARD, CONNECTION (AEP,UK)  
< CAPACITOR >  
1K  
1K  
C971  
C981  
C982  
C983  
C984  
1-107-826-11 CERAMIC CHIP 0.1uF  
10%  
16V  
(AEP,UK)  
270K  
100  
1-164-227-11 CERAMIC CHIP 0.022uF 10%  
1-164-227-11 CERAMIC CHIP 0.022uF 10%  
25V  
(AEP,UK)  
25V  
(US,CND)  
(AEP,UK)  
16V  
(AEP,UK)  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
10%  
10%  
R959  
1-216-821-11 METAL CHIP  
1K  
5%  
1/10W  
(US,CND)  
16V  
(AEP,UK)  
44  
CDX-MP40  
KEY  
Ref. No.  
C985  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
50V  
(AEP,UK)  
16V  
LSW918 1-771-883-31 SWITCH, TACTILE (WITH LED) (5/ALBUM –)  
(AEP,UK)  
LSW919 1-771-883-31 SWITCH, TACTILE (WITH LED) (4/SHUF)  
(AEP,UK)  
C986  
1-127-715-11 CERAMIC CHIP 0.22uF  
< CONNECTOR >  
10%  
(AEP,UK)  
LSW920 1-771-883-31 SWITCH, TACTILE (WITH LED) (3/REP)  
(AEP,UK)  
LSW921 1-771-883-31 SWITCH, TACTILE (WITH LED) (2/DISC +)  
(AEP,UK)  
LSW922 1-771-883-31 SWITCH, TACTILE (WITH LED) (1/DISC –)  
(AEP,UK)  
CN901 1-817-158-21 PLUG, CONNECTOR 14P (AEP,UK)  
< DIODE >  
D901  
D902  
D981  
D983  
8-719-085-72 DIODE UMZ6.8ENTR (AEP,UK)  
8-719-083-66 DIODE UDZS-TE-17-18B (AEP,UK)  
8-719-069-54 DIODE UDZS-TE-17-5.1B (AEP,UK)  
8-719-404-50 DIODE MA111-TX (AEP,UK)  
< RESISTOR >  
1-216-819-11 METAL CHIP  
1-216-819-11 METAL CHIP  
1-216-819-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-823-11 METAL CHIP  
R901  
R902  
R903  
R904  
R905  
680  
680  
680  
1K  
5%  
5%  
5%  
5%  
5%  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
< IC >  
IC901  
IC971  
8-759-826-21 IC LC75874W (AEP,UK)  
6-600-163-01 IC RS-770 (AEP,UK)  
< LIQUID CRYSTAL DISPLAY >  
1.5K  
(AEP,UK)  
LCD901 1-805-084-11 DISPLAY PANEL, LIQUID CRYSTAL (AEP,UK)  
< DIODE >  
R906  
R907  
R908  
R909  
R910  
1-216-823-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1-216-827-11 METAL CHIP  
1-216-829-11 METAL CHIP  
1-218-867-11 METAL CHIP  
1.5K  
2.2K  
3.3K  
4.7K  
6.8K  
5%  
5%  
5%  
5%  
5%  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
LED903 6-500-450-01 LED CL-195SR-CD-T (DSO) (AEP,UK)  
LED911 6-500-450-01 LED CL-195SR-CD-T (EQ3) (AEP,UK)  
LED933 6-500-459-01 LED NSCW505T-ARS (LCD BACK LIGHT)  
(AEP,UK)  
LED934 6-500-459-01 LED NSCW505T-ARS (LCD BACK LIGHT)  
(AEP,UK)  
LED951 6-500-450-01 LED CL-195SR-CD-T (EQ3) (AEP,UK)  
(AEP,UK)  
LED952 6-500-450-01 LED CL-195SR-CD-T (SEEK) (AEP,UK)  
LED953 6-500-450-01 LED CL-195SR-CD-T (DSO) (AEP,UK)  
LED954 6-500-450-01 LED CL-195SR-CD-T (SOURCE) (AEP,UK)  
R911  
R912  
R913  
R914  
R915  
1-216-819-11 METAL CHIP  
1-216-819-11 METAL CHIP  
1-216-819-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-823-11 METAL CHIP  
680  
680  
680  
1K  
5%  
5%  
5%  
5%  
5%  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
< SWITCH >  
LSW901 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (OFF)  
(AEP,UK)  
LSW904 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SEL)  
(AEP,UK)  
1.5K  
LSW905 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (VOLUME +)  
(AEP,UK)  
R916  
R917  
R918  
R919  
R920  
1-216-823-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1-216-827-11 METAL CHIP  
1-216-829-11 METAL CHIP  
1-218-867-11 METAL CHIP  
1.5K  
2.2K  
3.3K  
4.7K  
6.8K  
5%  
5%  
5%  
5%  
5%  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
LSW906 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (VOLUME –)  
(AEP,UK)  
LSW907 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (ATT)  
(AEP,UK)  
LSW908 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (MODE)  
(AEP,UK)  
LSW909 1-771-883-31 SWITCH, TACTILE (WITH LED) (AF) (AEP,UK)  
LSW910 1-771-883-31 SWITCH, TACTILE (WITH LED) (SENS/BTM)  
(AEP,UK)  
(AEP,UK)  
LSW912 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (DSPL)  
R921  
R927  
R928  
R929  
R930  
1-216-833-11 METAL CHIP  
1-216-025-11 RES-CHIP  
1-216-021-00 METAL CHIP  
1-216-033-00 METAL CHIP  
1-216-017-11 RES-CHIP  
10K  
100  
68  
5%  
5%  
5%  
5%  
5%  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
LSW913 1-771-476-11 SWITCH, KEYBOARD (WITH LED)  
(+ > M SEEK) (AEP,UK)  
LSW914 1-771-476-11 SWITCH, KEYBOARD (WITH LED)  
(SEEK m . –) (AEP,UK)  
LSW915 1-771-883-31 SWITCH, TACTILE (WITH LED) (TA) (AEP,UK)  
LSW916 1-771-883-31 SWITCH, TACTILE (WITH LED) (PTY/LIST)  
(AEP,UK)  
220  
47  
(AEP,UK)  
LSW917 1-771-883-31 SWITCH, TACTILE (WITH LED) (6/ALBUM +)  
(AEP,UK)  
45  
 
CDX-MP40  
KEY  
LIMIT SW  
LOAD SW  
MAIN  
Ref. No.  
R931  
Part No.  
Description  
Remark  
Ref. No.  
R989  
Part No.  
Description  
Remark  
1-216-041-00 METAL CHIP  
1-216-017-11 RES-CHIP  
1-216-025-11 RES-CHIP  
1-216-021-00 METAL CHIP  
1-216-025-11 RES-CHIP  
470  
47  
5%  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
1-216-840-11 METAL CHIP  
39K  
1M  
5%  
5%  
1/10W  
(AEP,UK)  
1/10W  
R934  
R935  
R936  
R941  
5%  
5%  
5%  
5%  
R990  
1-216-857-11 METAL CHIP  
(AEP,UK)  
100  
68  
< SWITCH >  
S902  
S903  
S911  
1-771-884-31 SWITCH, TACTILE (WITH LED) (SOURCE)  
(AEP,UK)  
1-771-884-31 SWITCH, TACTILE (WITH LED) (DSO)  
100  
(AEP,UK)  
(AEP,UK)  
(AEP,UK)  
R942  
R946  
R947  
R950  
R951  
1-216-021-00 METAL CHIP  
1-216-025-11 RES-CHIP  
1-216-021-00 METAL CHIP  
1-216-025-11 RES-CHIP  
1-216-021-00 METAL CHIP  
68  
5%  
5%  
5%  
5%  
5%  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1-771-884-31 SWITCH, TACTILE (WITH LED) (EQ3)  
100  
68  
*************************************************************  
A-3274-254-A LIMIT SW BOARD, COMPLETE  
*************************  
100  
68  
< CONNECTOR >  
1/10W  
(AEP,UK)  
CN13  
1-816-275-21 CONNECTOR, FFC/FPC 6P  
*************************************************************  
R960  
R961  
R962  
R966  
R967  
1-216-025-11 RES-CHIP  
1-216-025-11 RES-CHIP  
1-216-029-00 METAL CHIP  
1-216-025-11 RES-CHIP  
1-216-037-00 METAL CHIP  
100  
100  
150  
100  
330  
5%  
5%  
5%  
5%  
5%  
1/10W  
(AEP,UK)  
1/10W  
1-685-337-11 LOAD SW BOARD  
***************  
(AEP,UK) *************************************************************  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
A-3274-739-A MAIN BOARD, COMPLETE (US,CND)  
A-3274-742-A MAIN BOARD, COMPLETE (AEP,UK)  
*********************  
(AEP,UK)  
*
3-019-565-01 BRACKET (IC)  
3-041-261-11 BRACKET (TR)  
R970  
R971  
R972  
R975  
R976  
1-216-864-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
0
5%  
5%  
5%  
5%  
5%  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
7-685-134-19 SCREW +P 2.6X8 TYPE2 NON-SLIT  
7-685-793-09 SCREW +PTT 2.6X8 (S)  
7-685-795-09 SCREW +PTT 2.6X12 (S)  
1K  
100  
470  
470  
< CAPACITOR >  
C101  
C106  
C109  
C201  
C202  
1-136-154-00 FILM  
0.012uF 5%  
50V  
25V  
50V  
50V  
50V  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-162-965-11 CERAMIC CHIP 0.0015uF 10%  
(AEP,UK)  
1-136-154-00 FILM  
0.012uF 5%  
1-162-965-11 CERAMIC CHIP 0.0015uF 10%  
R977  
R978  
R979  
R980  
R981  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-811-11 METAL CHIP  
470  
470  
470  
470  
150  
5%  
5%  
5%  
5%  
5%  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
C203  
C204  
C205  
C206  
C207  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
50V  
50V  
50V  
50V  
50V  
1-164-160-11 CERAMIC CHIP 20PF  
5%  
C208  
C209  
C210  
C211  
C212  
1-126-160-11 ELECT  
1-126-160-11 ELECT  
1-115-467-11 CERAMIC CHIP 0.22uF  
1-115-467-11 CERAMIC CHIP 0.22uF  
1uF  
1uF  
20%  
20%  
10%  
10%  
20%  
50V  
50V  
10V  
10V  
50V  
R982  
R983  
R985  
R986  
R987  
1-216-811-11 METAL CHIP  
1-216-811-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
150  
150  
0
5%  
5%  
5%  
5%  
5%  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
1-126-160-11 ELECT  
1uF  
C213  
C215  
C401  
C402  
C403  
1-126-160-11 ELECT  
1-104-946-11 ELECT  
1-128-428-11 ELECT  
1-128-428-11 ELECT  
1-128-428-11 ELECT  
1uF  
20%  
20%  
20%  
20%  
20%  
50V  
35V  
35V  
35V  
35V  
10uF  
10uF  
10uF  
10uF  
1K  
1K  
C404  
C405  
C406  
C407  
C408  
1-128-428-11 ELECT  
10uF  
20%  
10%  
10%  
10%  
10%  
35V  
10V  
10V  
10V  
10V  
(AEP,UK)  
1-125-891-11 CERAMIC CHIP 0.47uF  
1-125-891-11 CERAMIC CHIP 0.47uF  
1-125-891-11 CERAMIC CHIP 0.47uF  
1-125-891-11 CERAMIC CHIP 0.47uF  
R988  
1-216-821-11 METAL CHIP  
1K  
5%  
1/10W  
(AEP,UK)  
46  
CDX-MP40  
MAIN  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
C409  
C411  
C412  
C413  
C415  
1-164-227-11 CERAMIC CHIP 0.022uF 10%  
25V  
16V  
35V  
50V  
16V  
C808  
C809  
C810  
C811  
C812  
1-162-918-11 CERAMIC CHIP 18PF  
1-164-160-11 CERAMIC CHIP 20PF  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
5%  
5%  
50V  
50V  
16V  
16V  
25V  
1-124-233-11 ELECT  
1-128-428-11 ELECT  
1-136-177-00 MYLAR  
10uF  
10uF  
1uF  
20%  
20%  
5%  
10%  
1-107-826-11 CERAMIC CHIP 0.1uF  
10%  
C416  
C417  
C418  
C419  
C420  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-927-11 CERAMIC CHIP 100PF  
5%  
5%  
5%  
5%  
5%  
50V  
50V  
50V  
50V  
50V  
C813  
C813  
1-162-927-11 CERAMIC CHIP 100PF  
5%  
5%  
5%  
10%  
50V  
(AEP,UK)  
1/10W  
(US,CND)  
50V  
25V  
10V  
1-216-864-11 METAL CHIP  
0
C814  
C815  
C816  
1-164-160-11 CERAMIC CHIP 20PF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-109-982-11 CERAMIC CHIP 1uF  
C421  
C423  
C424  
C425  
C426  
1-162-927-11 CERAMIC CHIP 100PF  
5%  
20%  
5%  
5%  
5%  
50V  
50V  
50V  
50V  
50V  
1-126-160-11 ELECT  
1uF  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-927-11 CERAMIC CHIP 100PF  
C817  
C818  
C821  
C822  
C823  
1-124-589-11 ELECT  
47uF  
20%  
10%  
5%  
5%  
5%  
10V  
6.3V  
50V  
50V  
50V  
1-125-837-11 CERAMIC CHIP 1uF  
1-164-160-11 CERAMIC CHIP 20PF  
1-164-160-11 CERAMIC CHIP 20PF  
1-164-160-11 CERAMIC CHIP 20PF  
C427  
C428  
C429  
C503  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
5%  
50V  
50V  
50V  
16V  
(AEP,UK)  
50V  
C825  
C826  
C827  
C901  
C902  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
10%  
16V  
50V  
50V  
16V  
10V  
(AEP,UK)  
1-124-259-11 ELECT  
4.7uF  
20%  
C505  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-135-473-21 ELECT  
3300uF  
20%  
1-115-156-11 CERAMIC CHIP 1uF  
C506  
C507  
C615  
50V  
16V  
50V  
1-124-589-11 ELECT  
47uF  
20%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
C905  
1-115-156-11 CERAMIC CHIP 1uF  
10V  
(AEP,UK)  
16V  
(AEP,UK)  
50V  
(AEP,UK)  
(AEP,UK)  
16V  
50V  
6.3V  
6.3V  
C616  
C617  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-162-916-11 CERAMIC CHIP 12PF  
10%  
5%  
C907  
C909  
C910  
C916  
1-125-972-61 ELECT  
1-126-160-11 ELECT  
1-126-154-11 ELECT  
100uF  
1uF  
47uF  
20%  
20%  
20%  
10%  
1-125-837-11 CERAMIC CHIP 1uF  
C618  
C621  
C622  
C623  
C624  
1-162-916-11 CERAMIC CHIP 12PF  
1-164-360-11 CERAMIC CHIP 0.1uF  
1-162-959-11 CERAMIC CHIP 330PF  
1-125-838-11 CERAMIC CHIP 2.2uF  
1-164-739-11 CERAMIC CHIP 560PF  
5%  
50V  
(AEP,UK)  
16V  
(AEP,UK)  
50V  
(AEP,UK)  
6.3V  
(AEP,UK)  
50V  
C917  
C918  
C920  
C922  
1-124-584-00 ELECT  
100uF  
20%  
10%  
10%  
5%  
10V  
16V  
16V  
50V  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-162-927-11 CERAMIC CHIP 100PF  
5%  
< CONNECTOR >  
10%  
5%  
CNJ801 1-580-907-31 PLUG, CONNECTOR (BUS CONTROL IN)  
CNP701 1-815-260-11 CONNECTOR, BOARD TO BOARD 30P  
CNP802 1-569-907-11 SOCKET, CONNECTOR 12P  
CNP901 1-774-701-11 PIN, CONNECTOR 16P  
(AEP,UK)  
C629  
C701  
C702  
C703  
C704  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
20%  
10%  
25V  
16V  
25V  
50V  
50V  
1-124-589-11 ELECT  
47uF  
< JACK >  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-164-160-11 CERAMIC CHIP 20PF  
CNP801 1-764-270-21 JACK, STEREO MINIATURE (DIA.3.5)  
5%  
(REMOTE IN)  
C705  
C712  
C713  
C714  
C715  
1-164-160-11 CERAMIC CHIP 20PF  
5%  
50V  
10V  
10V  
10V  
6.3V  
< DIODE >  
1-124-584-00 ELECT  
1-124-584-00 ELECT  
1-124-584-00 ELECT  
1-128-057-11 ELECT  
100uF  
100uF  
100uF  
330uF  
20%  
20%  
20%  
20%  
D701  
D801  
D802  
D804  
D805  
8-719-991-33 DIODE 1SS133T-77  
8-719-083-66 DIODE UDZS-TE-17-18B  
8-719-069-56 DIODE UDZS-TE-17-6.2B  
8-719-058-24 DIODE RB501V-40TE-17  
8-719-083-66 DIODE UDZS-TE-17-18B  
C716  
C717  
C718  
C719  
C802  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-125-837-11 CERAMIC CHIP 1uF  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-927-11 CERAMIC CHIP 100PF  
25V  
25V  
6.3V  
50V  
50V  
10%  
10%  
D806  
D807  
D808  
D809  
D810  
8-719-083-66 DIODE UDZS-TE-17-18B  
8-719-991-33 DIODE 1SS133T-77  
8-719-988-61 DIODE 1SS355TE-17  
8-719-988-61 DIODE 1SS355TE-17  
8-719-988-61 DIODE 1SS355TE-17  
5%  
C803  
C804  
C805  
C806  
C807  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
20%  
10%  
25V  
16V  
25V  
5.5V  
25V  
1-126-940-11 ELECT  
330uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-128-647-11 DOUBLE LAYERS 0.1F  
1-164-156-11 CERAMIC CHIP 0.1uF  
D811  
D812  
D813  
D814  
8-719-978-33 DIODE DTZ-TT11-6.8B  
8-719-978-33 DIODE DTZ-TT11-6.8B  
8-719-978-33 DIODE DTZ-TT11-6.8B  
8-719-978-33 DIODE DTZ-TT11-6.8B  
47  
CDX-MP40  
MAIN  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
D815  
D816  
D817  
D818  
D819  
8-719-978-33 DIODE DTZ-TT11-6.8B  
8-719-978-33 DIODE DTZ-TT11-6.8B  
8-719-978-33 DIODE DTZ-TT11-6.8B  
8-719-988-61 DIODE 1SS355TE-17  
8-719-988-61 DIODE 1SS355TE-17  
JR806 1-216-864-11 METAL CHIP  
JR807 1-216-864-11 METAL CHIP  
JR904 1-216-864-11 METAL CHIP  
JR906 1-216-864-11 METAL CHIP  
0
0
0
0
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
< COIL >  
D901  
D902  
D903  
D904  
D905  
8-719-200-82 DIODE 11ES2  
8-719-200-82 DIODE 11ES2  
8-719-200-82 DIODE 11ES2  
8-719-200-82 DIODE 11ES2  
8-719-200-82 DIODE 11ES2  
L701  
L702  
L703  
L704  
L900  
1-216-864-11 METAL CHIP  
1-414-398-11 INDUCTOR  
1-469-144-21 FERRITE, EMI (SMD)  
1-414-398-11 INDUCTOR  
1-419-476-31 COIL, CHOKE  
0
5%  
1/10W  
10uH  
10uH  
250uH  
D906  
D907  
D908  
D909  
D910  
8-719-053-18 DIODE 1SR154-400TE-25  
8-719-053-18 DIODE 1SR154-400TE-25  
8-719-200-82 DIODE 11ES2  
8-719-049-38 DIODE 1N5404TU  
8-719-200-82 DIODE 11ES2  
< JACK >  
PJ401 1-774-700-11 JACK, PIN 6P (BUS AUDIO IN,  
AUDIO OUT REAR/FRONT)  
PJ601 1-793-598-11 JACK (ANTENNA)  
D911  
D912  
D915  
D916  
D917  
8-719-200-82 DIODE 11ES2  
8-719-978-33 DIODE DTZ-TT11-6.8B  
8-719-200-82 DIODE 11ES2  
8-719-069-55 DIODE UDZS-TE-17-5.6B  
8-719-929-15 DIODE HZS9.1N-B2  
< TRANSISTOR >  
Q401  
Q402  
Q403  
Q404  
Q602  
8-729-920-21 TRANSISTOR DTC314TK-T-146  
8-729-920-21 TRANSISTOR DTC314TK-T-146  
8-729-920-21 TRANSISTOR DTC314TK-T-146  
8-729-920-21 TRANSISTOR DTC314TK-T-146  
8-729-055-96 TRANSISTOR SRC1203SF (AEP,UK)  
D918  
D919  
D920  
D921  
D923  
8-719-988-61 DIODE 1SS355TE-17  
8-719-109-89 DIODE RD5.6ES-B2  
8-719-988-61 DIODE 1SS355TE-17  
8-719-988-61 DIODE 1SS355TE-17  
8-719-200-82 DIODE 11ES2  
Q801  
Q802  
Q803  
Q804  
Q805  
8-729-055-96 TRANSISTOR SRC1203SF  
8-729-055-92 TRANSISTOR SRA2203SF  
8-729-055-92 TRANSISTOR SRA2203SF  
8-729-055-96 TRANSISTOR SRC1203SF  
8-729-055-96 TRANSISTOR SRC1203SF  
D925  
D926  
D927  
8-719-978-33 DIODE DTZ-TT11-6.8B  
8-719-921-63 DIODE MTZJ-7.5B  
8-719-069-55 DIODE UDZS-TE-17-5.6B  
Q806  
Q901  
Q902  
Q903  
Q904  
8-729-055-92 TRANSISTOR SRA2203SF  
8-729-049-40 TRANSISTOR 2SC5343SFG  
8-729-049-40 TRANSISTOR 2SC5343SFG  
8-729-015-11 TRANSISTOR 2SD1802FAST-TL  
8-729-055-92 TRANSISTOR SRA2203SF  
< FERRITE BEAD >  
FB601 1-414-235-22 INDUCTOR, FERRITE BEAD (AEP,UK)  
FB701 1-469-144-21 FERRITE, EMI (SMD)  
FB801 1-414-235-22 INDUCTOR, FERRITE BEAD  
Q905  
Q906  
Q907  
Q908  
Q909  
8-729-055-96 TRANSISTOR SRC1203SF  
8-729-019-00 TRANSISTOR 2SD2394-G  
8-729-055-92 TRANSISTOR SRA2203SF  
8-729-055-96 TRANSISTOR SRC1203SF  
8-729-049-43 TRANSISTOR STB1132Y  
< IC >  
IC401  
IC501  
IC601  
IC701  
IC801  
6-703-304-01 IC BD3802F-FE2  
8-759-827-14 IC TA8268AH  
6-703-809-01 IC SAA6588T/V2-518 (AEP,UK)  
8-759-679-05 IC TC7WH34FU(TE12R)  
6-802-685-01 IC MN101C49KSJ  
Q910  
Q911  
Q912  
Q913  
Q914  
8-729-055-96 TRANSISTOR SRC1203SF  
8-729-049-40 TRANSISTOR 2SC5343SFG  
8-729-019-00 TRANSISTOR 2SD2394-G  
8-729-055-92 TRANSISTOR SRA2203SF  
8-729-055-96 TRANSISTOR SRC1203SF  
IC802  
IC803  
IC902  
6-701-405-01 IC PST3443UL  
8-759-096-16 IC MM1175XFF  
6-703-986-01 IC NJU7222U33-TE1  
Q915  
Q916  
Q917  
Q918  
Q919  
8-729-055-96 TRANSISTOR SRC1203SF  
8-729-920-85 TRANSISTOR 2SD1664-QR  
8-729-055-96 TRANSISTOR SRC1203SF  
8-729-049-43 TRANSISTOR STB1132Y  
8-729-055-96 TRANSISTOR SRC1203SF  
< JUMPER RESISTOR >  
JR115 1-216-864-11 METAL CHIP  
JR116 1-216-864-11 METAL CHIP  
0
0
5%  
5%  
1/10W  
1/10W  
50V  
JR401 1-162-964-11 CERAMIC CHIP 0.001uF 10%  
JR402 1-216-864-11 METAL CHIP  
JR403 1-216-864-11 METAL CHIP  
0
0
5%  
5%  
1/10W  
1/10W  
Q920  
Q921  
Q922  
Q923  
Q924  
8-729-820-46 TRANSISTOR 2SB1202FAS  
8-729-055-96 TRANSISTOR SRC1203SF  
8-729-820-46 TRANSISTOR 2SB1202FAS  
8-729-055-92 TRANSISTOR SRA2203SF  
8-729-055-96 TRANSISTOR SRC1203SF  
JR405 1-216-864-11 METAL CHIP  
JR601 1-216-864-11 METAL CHIP  
0
0
5%  
5%  
1/10W  
1/10W  
(AEP,UK)  
1/10W  
1/10W  
JR602 1-216-864-11 METAL CHIP  
JR801 1-216-845-11 METAL CHIP  
0
5%  
5%  
< RESISTOR >  
100K  
(US,CND)  
1/10W  
R101  
R102  
R103  
R104  
1-216-833-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-833-11 METAL CHIP  
10K  
100  
100  
10K  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
JR803 1-216-864-11 METAL CHIP  
JR805 1-216-864-11 METAL CHIP  
0
0
5%  
5%  
1/10W  
48  
 
CDX-MP40  
MAIN  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
R111  
R112  
R201  
R202  
R203  
1-218-882-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-825-11 METAL CHIP  
30K  
10K  
10K  
10K  
2.2K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
R821  
R822  
R823  
R824  
R825  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-821-11 METAL CHIP  
100  
100  
10K  
10K  
1K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
R204  
R401  
R402  
R403  
R404  
1-216-825-11 METAL CHIP  
1-247-807-31 CARBON  
1-247-807-31 CARBON  
1-247-807-31 CARBON  
1-247-807-31 CARBON  
2.2K  
100  
100  
100  
100  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/4W  
1/4W  
1/4W  
1/4W  
R826  
R827  
R828  
R829  
R830  
1-216-864-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-247-807-31 CARBON  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
0
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/4W  
1/10W  
1/10W  
100K  
100  
100  
100  
R405  
R406  
R407  
R408  
R409  
1-247-807-31 CARBON  
100  
47K  
100  
47K  
100  
5%  
5%  
5%  
5%  
5%  
1/4W  
R831  
R832  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
100K  
100K  
5%  
5%  
1/10W  
1/10W  
(US,CND)  
1/10W  
1-216-841-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1/10W  
1/10W  
1/10W  
1/10W  
R833  
R834  
1-216-821-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1K  
100K  
5%  
5%  
1/10W  
(AEP,UK)  
1/10W  
R410  
R411  
R412  
R413  
R414  
1-216-841-11 METAL CHIP  
1-247-807-31 CARBON  
1-216-841-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-833-11 METAL CHIP  
47K  
100  
47K  
1K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/4W  
1/10W  
1/10W  
1/10W  
R835  
1-216-845-11 METAL CHIP  
100K  
5%  
R836  
R843  
R866  
R867  
R868  
1-216-864-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
0
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
100K  
100K  
100K  
100K  
10K  
R415  
R416  
R417  
R418  
R419  
1-216-821-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
10K  
47K  
2.2K  
1K  
R870  
R901  
R903  
R904  
R905  
1-216-845-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-214-00 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-841-11 METAL CHIP  
100K  
1K  
4.7K  
1K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/8W  
1/10W  
1/10W  
R420  
R502  
R505  
R607  
1-216-833-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-817-11 METAL CHIP  
10K  
0
0
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
(AEP,UK)  
1/10W  
47K  
R906  
R907  
R908  
R909  
R910  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-829-11 METAL CHIP  
10K  
10K  
47K  
47K  
4.7K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
470  
R608  
1-216-797-11 METAL CHIP  
10  
5%  
(AEP,UK)  
R609  
R612  
R620  
1-216-827-11 METAL CHIP  
1-216-797-11 METAL CHIP  
1-216-809-11 METAL CHIP  
3.3K  
10  
5%  
5%  
5%  
1/10W  
(AEP,UK)  
1/10W  
(AEP,UK)  
1/10W  
R911  
R913  
R914  
R915  
R918  
1-216-845-11 METAL CHIP  
1-249-427-11 CARBON  
1-216-825-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1-216-445-11 METAL OXIDE  
100K  
6.8K  
2.2K  
2.2K  
12  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/4W  
1/10W  
1/10W  
2W  
100  
(AEP,UK)  
1/10W  
1/10W  
R702  
R705  
1-216-845-11 METAL CHIP  
1-216-864-11 METAL CHIP  
100K  
0
5%  
5%  
R922  
R923  
R924  
R925  
R926  
1-247-815-11 CARBON  
1-216-845-11 METAL CHIP  
1-249-421-11 CARBON  
1-216-821-11 METAL CHIP  
1-249-413-11 CARBON  
220  
100K  
2.2K  
1K  
5%  
5%  
5%  
5%  
5%  
1/4W  
1/10W  
1/4W  
1/10W  
1/4W  
R706  
R707  
R708  
R801  
R802  
1-216-864-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-249-417-11 CARBON  
1-249-431-11 CARBON  
0
0
0
1K  
15K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/4W  
470  
R927  
R930  
R931  
R932  
R934  
1-249-417-11 CARBON  
1-216-845-11 METAL CHIP  
1-249-421-11 CARBON  
1-216-805-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1K  
5%  
5%  
5%  
5%  
5%  
1/4W  
1/10W  
1/4W  
1/10W  
1/10W  
1/4W  
100K  
2.2K  
47  
R804  
R805  
R806  
R807  
R811  
1-247-807-31 CARBON  
1-216-809-11 METAL CHIP  
1-469-144-21 FERRITE, EMI (SMD)  
1-469-144-21 FERRITE, EMI (SMD)  
1-216-845-11 METAL CHIP  
100  
100  
5%  
5%  
1/4W  
1/10W  
100K  
R935  
1-249-421-11 CARBON  
< SWITCH >  
2.2K  
5%  
1/4W  
100K  
5%  
1/10W  
R812  
R813  
R814  
R815  
R816  
1-216-841-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-813-11 METAL CHIP  
47K  
1K  
1K  
1K  
220  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
S801  
S802  
1-762-638-21 SWITCH, TACTILE (RESET)  
1-786-458-11 SWITCH, PUSH (1 KEY) (NOSE DET)  
R817  
R818  
R819  
R820  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-837-11 METAL CHIP  
1-216-809-11 METAL CHIP  
100  
100  
22K  
100  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
49  
CDX-MP40  
MAIN RELAY  
SERVO  
Ref. No.  
Part No.  
Description  
< THERMISTOR (POSITIVE) >  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
C13  
C14  
C15  
C16  
C17  
1-162-916-11 CERAMIC CHIP 12PF  
1-125-837-11 CERAMIC CHIP 1uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
5%  
50V  
6.3V  
25V  
25V  
25V  
10%  
10%  
10%  
10%  
TH900 1-801-792-21 THERMISTOR, POSITIVE  
TH901 1-810-940-11 THERMISTOR, POSITIVE  
< TUNER >  
TUX501 A-3220-887-A TUNER UNIT (TUX-030)  
< VIBRATOR >  
C18  
C19  
C20  
C21  
C22  
1-162-966-11 CERAMIC CHIP 0.0022uF 10%  
50V  
16V  
16V  
25V  
25V  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
10%  
10%  
10%  
X601  
X801  
X802  
1-760-556-31 VIBRATOR, CRYSTAL (4.332MHz) (AEP,UK)  
1-795-165-11 VIBRATOR, CERAMIC (18.43MHz)  
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)  
C23  
C24  
C25  
C27  
C29  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-125-837-11 CERAMIC CHIP 1uF  
10%  
10%  
10%  
10%  
25V  
25V  
25V  
6.3V  
50V  
*************************************************************  
RELAY BOARD  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
************  
C30  
C34  
C35  
C36  
C38  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-125-837-11 CERAMIC CHIP 1uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
10%  
10%  
10%  
10%  
25V  
6.3V  
25V  
25V  
25V  
1-792-173-11 CABLE, FLAT (FFC) 12P (CNP903)  
< CAPACITOR >  
C973  
C974  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
10%  
10%  
16V  
16V  
C39  
C40  
C41  
C43  
C44  
1-126-391-11 ELECT CHIP  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-967-11 CERAMIC CHIP 0.0033uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
47uF  
20%  
10%  
10%  
6.3V  
16V  
25V  
50V  
50V  
< CONNECTOR >  
CNP902 1-817-159-11 SOCKET, CONNECTOR 14P  
< DIODE >  
C45  
C51  
C53  
C54  
C55  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
10%  
10%  
10%  
10%  
10%  
25V  
16V  
16V  
16V  
16V  
D901  
D902  
D903  
D904  
D905  
8-719-978-33 DIODE DTZ-TT11-6.8B  
8-719-978-33 DIODE DTZ-TT11-6.8B  
8-719-978-33 DIODE DTZ-TT11-6.8B  
8-719-978-33 DIODE DTZ-TT11-6.8B  
8-719-978-33 DIODE DTZ-TT11-6.8B  
C56  
C57  
C58  
C59  
C60  
1-128-934-11 CERAMIC CHIP 0.33uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-162-966-11 CERAMIC CHIP 0.0022uF 10%  
1-104-609-11 ELECT CHIP  
1-107-826-11 CERAMIC CHIP 0.1uF  
20%  
10%  
10V  
16V  
50V  
4V  
D906  
D907  
8-719-978-33 DIODE DTZ-TT11-6.8B  
8-719-978-33 DIODE DTZ-TT11-6.8B  
100uF  
20%  
10%  
LED930 8-719-082-38 LED CL-270SR-C-TS (CD WINDOW)  
16V  
LED931 8-719-053-09 LED SML-310VT-T86 (Z)  
C61  
C62  
C63  
C65  
C67  
1-126-391-11 ELECT CHIP  
47uF  
20%  
10%  
10%  
10%  
20%  
6.3V  
16V  
16V  
16V  
10V  
< RESISTOR >  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
R930  
R931  
R932  
1-216-823-11 METAL CHIP  
1-216-823-11 METAL CHIP  
1-216-823-11 METAL CHIP  
1.5K  
1.5K  
1.5K  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1-104-851-11 TANTAL. CHIP  
10uF  
C68  
C69  
C70  
C75  
C77  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
10%  
10%  
10%  
10%  
10%  
16V  
16V  
16V  
16V  
16V  
< SWITCH >  
S931  
1-771-884-31 SWITCH, TACTILE (WITH LED) (Z)  
*************************************************************  
A-3274-698-A SERVO BOARD, COMPLETE  
C78  
C79  
C81  
C102  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
50V  
6.3V  
16V  
50V  
25V  
**********************  
1-125-837-11 CERAMIC CHIP 1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
10%  
5%  
< CAPACITOR >  
C111  
10%  
C1  
C3  
C4  
C5  
C6  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
10%  
20%  
10%  
10%  
25V  
25V  
4V  
25V  
6.3V  
C112  
C113  
C114  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
10%  
10%  
10%  
16V  
25V  
16V  
1-104-609-11 ELECT CHIP  
100uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-125-837-11 CERAMIC CHIP 1uF  
< CONNECTOR >  
C8  
C9  
C10  
C11  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-162-924-11 CERAMIC CHIP 56PF  
1-162-924-11 CERAMIC CHIP 56PF  
1-162-909-11 CERAMIC CHIP 4PF  
10%  
5%  
5%  
16V  
50V  
50V  
CN1  
CN2  
CN3  
1-815-352-11 CONNECTOR, BOARD TO BOARD 30P  
1-794-153-21 CONNECTOR, FPC (ZIF) 16P  
1-816-275-21 CONNECTOR, FFC/FPC 6P  
0.25PF 50V  
50  
CDX-MP40  
SERVO  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
< FERRITE BEAD >  
R53  
R54  
R55  
R64  
R65  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-819-11 METAL CHIP  
100  
100  
100  
100  
680  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
FB2  
FB3  
FB6  
1-216-864-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-469-144-21 FERRITE, EMI (SMD)  
0
0
5%  
5%  
1/10W  
1/10W  
< IC >  
R67  
R68  
R69  
R70  
R71  
1-216-845-11 METAL CHIP  
1-216-857-11 METAL CHIP  
1-216-813-11 METAL CHIP  
1-216-813-11 METAL CHIP  
1-216-809-11 METAL CHIP  
100K  
1M  
220  
220  
100  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
IC1  
IC2  
IC3  
IC4  
IC5  
8-759-699-98 IC uPD63711GC-8EU  
8-759-658-87 IC BA5810FP-E2  
6-703-905-01 IC HD6432238RWN35TEI  
6-702-661-01 IC UT62L1024LC-55LLI  
6-702-153-01 IC CXD9684R-005  
R72  
R73  
R74  
R75  
R76  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
100  
100  
100  
100  
100  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
IC6  
IC7  
IC12  
8-759-645-31 IC RN5RZ25BA-TL-FA  
8-759-491-50 IC TC74VHCT244AFT(EL)  
8-759-196-96 IC TC7SH08FU-TE85R  
< JUMPER RESISTOR >  
R77  
R78  
R81  
R82  
R83  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
100  
100  
100K  
100K  
100K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
JR1  
JR3  
JR5  
JR6  
JR12  
1-216-821-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1K  
0
1K  
0
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
0
R84  
R85  
R86  
R87  
R88  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
100K  
100K  
100K  
100K  
100K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
JR13  
JR14  
JR15  
JR17  
JR21  
1-216-864-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-864-11 METAL CHIP  
0
0
0
0
0
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
R89  
R90  
R91  
R92  
R93  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-809-11 METAL CHIP  
100K  
100K  
100K  
100K  
100  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
< COIL >  
L4  
L6  
L8  
1-216-001-00 METAL CHIP  
10  
5%  
1/10W  
1-469-144-21 FERRITE, EMI (SMD)  
1-414-398-11 INDUCTOR 10uH  
R94  
R95  
R96  
R97  
R98  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-837-11 METAL CHIP  
1-216-834-11 METAL CHIP  
100  
100  
100  
22K  
12K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
< TRANSISTOR >  
Q1  
8-729-904-87 TRANSISTOR 2SB1197K-R  
< RESISTOR >  
R100  
R102  
R103  
R104  
R105  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
100K  
100K  
100K  
100K  
100K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
R3  
R5  
R7  
R8  
R9  
1-216-806-11 METAL CHIP  
1-218-344-11 METAL CHIP  
1-216-839-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-840-11 METAL CHIP  
56  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
7.5K  
33K  
10K  
39K  
R106  
R107  
R109  
R111  
R113  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1K  
1K  
100K  
100K  
100K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
R10  
R12  
R13  
R14  
R15  
1-216-835-11 METAL CHIP  
1-216-837-11 METAL CHIP  
1-216-807-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-841-11 METAL CHIP  
15K  
22K  
68  
47K  
47K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
R114  
R115  
R116  
R117  
R118  
1-216-845-11 METAL CHIP  
1-216-837-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
100K  
22K  
100  
100  
100  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
R26  
R29  
R30  
R45  
R46  
1-216-806-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
56  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
10K  
10K  
100K  
100K  
R119  
R121  
R124  
R126  
R127  
1-216-821-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-837-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1K  
100K  
22K  
100K  
100K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
R47  
R48  
R49  
R50  
R51  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
100K  
100K  
100K  
100  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
100  
R128  
R129  
R130  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-809-11 METAL CHIP  
100K  
100K  
100  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
R52  
1-216-809-11 METAL CHIP  
100  
5%  
1/10W  
51  
 
CDX-MP40  
SERVO  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
R131  
R132  
R133  
R134  
R135  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
100  
100  
100  
100  
100  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
PARTS FOR INSTALLATION AND CONNECTIONS  
***************************************  
251  
252  
253  
254  
255  
X-3382-647-1 FRAME ASSY, FITTING  
X-3366-405-1 SCREW ASSY (EXP), FITTING (AEP,UK)  
3-246-035-01 COLLAR  
3-934-325-01 SCREW (+K 5X8 TP) (US,CND)  
1-465-459-21 ADAPTOR, ANTENNA (AEP,UK)  
R136  
R142  
R143  
R144  
R145  
1-216-809-11 METAL CHIP  
1-216-815-11 METAL CHIP  
1-218-484-11 METAL CHIP  
1-216-812-11 METAL CHIP  
1-216-817-11 METAL CHIP  
100  
330  
750  
180  
470  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
256  
257  
1-776-207-82 CORD (WITH CONNECTOR) (POWER) (US,CND)  
1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)  
(AEP,UK)  
R146  
R147  
R148  
R149  
R150  
1-216-815-11 METAL CHIP  
1-218-484-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-814-11 METAL CHIP  
1-216-821-11 METAL CHIP  
330  
750  
100  
270  
1K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
258  
3-246-471-01 KEY (FRAME)  
251  
252  
R151  
R152  
R153  
R154  
1-216-825-11 METAL CHIP  
1-216-813-11 METAL CHIP  
1-216-818-11 METAL CHIP  
1-216-809-11 METAL CHIP  
2.2K  
220  
560  
100  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
253  
256  
254  
257  
255  
258  
< NETWORK RESISTOR >  
RB1  
RB2  
1-233-576-11 RES, CHIP NETWORK 100X4  
1-233-576-11 RES, CHIP NETWORK 100X4  
< VIBRATOR >  
X1  
X2  
1-795-520-11 VIBRATOR, CERAMIC (16.9344MHz)  
1-795-127-21 VIBRATOR, CERAMIC (12.288MHz)  
*************************************************************  
MISCELLANEOUS  
***************  
9
9
1-776-207-82 CORD (WITH CONNECTOR) (POWER) (US,CND)  
1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)  
(AEP,UK)  
207  
0210  
211  
1-823-951-11 CABLE, FLEXIBLE FLAT (16 CORE)  
8-820-165-06 OPTICAL PICK-UP KSS-721A/C-RP  
1-676-707-11 PICK-UP FLEXIBLE BOARD  
F901  
M902  
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A  
A-3301-985-A MOTOR ASSY, SLED (SLED)  
M903  
A-3315-039-A MOTOR SUB ASSY, LO (LOADING)  
*************************************************************  
ACCESSORIES  
************  
1-476-526-34 REMOTE COMMANDER (RM-X115)  
3-230-047-01 LID, BATTERY CASE (for RM-X115)  
3-251-806-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH)  
(US,CND)  
3-251-806-31 MANUAL, INSTRUCTION (ENGLISH,GERMAN,  
FRENCH,ITALIAN,DUTCH) (AEP,UK)  
3-251-853-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,  
FRENCH) (US,CND)  
3-251-853-31 MANUAL, INSTRUCTION, INSTALL (ENGLISH,  
GERMAN,FRENCH,ITALIAN,DUTCH) (AEP,UK)  
X-3378-390-3 CASE ASSY (for FRONT PANEL) (US,CND)  
X-3378-490-2 CASE (PANEL) ASSY (for FRONT PANEL)  
(AEP,UK)  
*************************************************************  
The components identified by Les composants identifiés par une  
mark 0 or dotted line with mark marque 0 sont critiques pour  
0 are critical for safety.  
Replace only with part number Ne les remplacer que par une piéce  
specified. portant le numéro spécifié.  
la sécurité.  
52  
CDX-MP40  
MEMO  
53  
CDX-MP40  
REVISION HISTORY  
Clicking the version allows you to jump to the revised page.  
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised  
page.  
Ver.  
Date  
Description of Revision  
1.0  
2003. 01  
New  

Superior Z258C User Manual
Sony Ericsson WALKMAN PHONE W980 User Manual
Siemens U15 User Manual
Siemens C70 CT70 User Manual
Samsung T749 User Manual
Samsung SGH E840 User Manual
Samsung SPH A660 User Manual
Philips SPD5250 User Manual
Philips CDR796 User Manual
Oregon Scientific BAR332ES User Manual