1
02/04
P/N 211583
© COPYRIGHT 2000 by HUFFY SPORTS
Download from Www.Somanuals.com. All Manuals Search And Download.
ENGLISH INSTRUCTIONS
IMPORTANT! WRITE DOWN MODEL NUMBER FROM BOX ON
PAGE 1 OF THIS OWNERS MANUAL
OF NET. FIT OF NET MAY BE TIGHT TO FRAME
16. Attach upper brackets (38) to framework with bolts (39 ), nuts (17) and
washers (12) as shown.
1. Remove contents from tank (1).
17. Attach lower bracket “B” (37) to framework with bolts (39), nuts (17) and
washers (12) as shown.
2. Correctly identify each pole section and mark indicated distance from
ends with tape as shown.
3. IMPORTANT! Center alignment slot of middle pole section (5) in a
lower hole of top pole section (4) as shown. While maintaining
alignment, bounce pole top (4) and middle section (5) together as shown
until they no longer move toward taped reference mark. Upright
assembly. NOTE: Pole sections should have a 3-1/2" (9 cm) minimum
overlap.
18. Lift net assembly into place and attach to unit with hand knobs (41) ,
(42) as shown.
19. Install fiberglass rods (33) into pockets on net. Top and bottom ends of
rods are inserted into holes on framework. Attach pole pad as shown.
20 Attach snap clips on tarp to “D” ring on net as shown.
Thread straps on net through tarp as shown and tighten straps to
desired tarp tension.
4. IMPORTANT! Center alignment slot of lower pole section (6) in a
lower hole of middle pole section (5) as in step 4. While maintaining
alignment, bounce assembly and lower section (6) together as shown
until they no longer moved toward taped reference mark.
NOTE: Pole sections should have a 3-1/2" (9 cm) minimum overlap.
5. Install rod (7) through holes in bottom pole (6) section and eyebolt (8).
6. Install wheel axle (2) through wheel carriage (9) and install wheels (3)
onto wheel axle (3) with spacers (28) as shown. Insert pole assembly
into tank assembly as shown.Secure bottom pole (6) to tank, lower
bracket “A” (36) and wheel bracket as shown, a deep socket is
recommended.
NOTE: Two people recommended for this step.
IMPORTANT! DO NOT OVER TIGHTEN.
7. Secure tank struts (13) to pole. Rotate non-secured ends of tank struts
(13) outward to mounting holes in tank as shown.
WARNING: TIGHTEN BOLT (11) IN LOCK NUT (14) UNTIL FLUSH
(EVEN) WITH LOCK NUT’S OUTER EDGE.
8. Secure non-secured ends of tank struts (13) to tank as shown. Repeat
for opposite side.
WARNING: USE OF THIS PRODUCT WITHOUT PROPER
INSTALLATION OF NET CLIPS, OR WHEN ALL NET CLIPS ARE
NOT PRESENT COULD RESULT IN BODILY HARM. BE SURE TO
FOLLOW DIRECTIONS CAREFULLY.
9. Mount brackets (20), rim spacer (45) and rim (18) to backboard and
finger tighten. NOTE: Final adjustments will be made in Step 12.
IMPORTANT! For spring loaded rim assembly, refer to instructions
included with rim hardware.
10. Support pole and tank assembly over support table. Carefully slide
backboard components onto pole.
WARNING: TWO PERSON MINIMUM REQUIRED FOR THIS
PROCEDURE. NOT FOLLOWING RECOMMENDATION MAY
RESULT IN BODILY INJURY.
WARNING: DO NOT LEAVE ASSEMBLED UNIT UNATTENDED
WHEN EMPTY, MAY TIP OVER.
11. While still in the horizontal position, secure hardware at desired position
as shown and tighten all hardware completely at this time.
12. Install netclips and net as instructed on illustration page.
13. NOTE: Two people recommended for this procedure. Carefully upright
assembly. Apply moving system label (15) to front of pole as shown.
Regulation rim height is 10 feet (3.05 m).
WARNING: DO NOT LEAVE ASSEMBLED UNIT UNATTENDED
WHEN EMPTY, MAY TIP OVER.
WARRANTY CARD:
14. Place assembled unit to desired location. Fill tank with water (30 gallons
(114 liters)) or sand (360 lb. (163 kg)) and snap tank cap (30) in place.
Insert T-strap (29) through slot on back of base as shown. Secure unit to
ground by twisting tie down stake (27) into ground and hooking T-strap
(29) onto tie down stake (27).
Please remember to complete your product
registration form either on-line at:
www.huffysports.com/warrantycard or mail-in
the enclosed postcard.
IMPORTANT! Add two gallons (7.6 liters) of non-toxic antifreeze in
sub-freezing climates.
15. Slide framework halves into net and insert reduced end of frame into
expanded end as shown.
NOTE: TABS ON STRAPS SHOULD BE POSITIONED ON THE OUTSIDE
3
02/04
P/N 211583
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS LIST
(See Hardware Identifier)
Item Qty. Part No. Description
1
1
1
206645
200628
226401
900060
900166
900315
202820
202822
200924
203063
202541
203218
906206
203220
200439
203156
203100
Tank (Black)
2
Wheel Axle
3
2
Wheel
4
1
Top Pole Section
5
1
Bottom Pole Section
Middle Pole Section w/ Rivnut and Label
Rod, 3/8 O.D. x 4-3/4 Long
Eye Bolt, 3/8 x 16 x 3-3/4 Long
Wheel Bracket
6
1
7
1
8
1
9
1
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
1
Lock Nut, Nylon Insert, 3/8-16
Bolt, Hex Head, 5/16-18 x 3-3/4
Washer, 5/16 Flat
Tank Strut
1
10
2
1
Lock Nut, 5/16-18
Label, Moving System and Height Adjust.
Bolt, Hex Head, 5/16-18 x 1 Long
Nut, Hex Flange 5/16-18
Rim
1
2
10
1
12*
2
201219
900162
203309
203113
203231
203435
Clip, Net Holder
Backboard Mounting Bracket
Washer, 1 O.D.
4
4
Bolt, Hex Flange, 5/16-18 x 2-1/2 Long
Bolt, Carriage 5/16-18 x 3-1/2
Knob, Plastic, 1-3/4 Diameter
Net
2
2
1
1
206219
203124
201651
200929
203617
900314
900313
201554
201549
201548
900316
900317
900311
202739
201552
201558
201559
201585
201547
203365
Cap
1
Tie Down Stake
2
Spacer, Wheel Axle
T-Strap
1
1
Tank Cap
2
Sportstation Frame (tapered end)
Sportstation Frame
Rod, Fiberglass
2
2
1
Tarp, Soccer/Hockey
Tarp, Football/Baseball
Bracket, Lower ”A”
Bracket, Lower ”B”
Bracket, Upper
1
1
1
2
4
Bolt, 5/16-18 x 1-3/4 Long
End Cap, Square
4
1
Knob, 2”
1
Knob, 1”
1
Storage Bag
1
Net Assembly
1
Rim Spacer
* YOU MAY HAVE EXTRA PARTS WITH THIS MODEL.
4
P/N 211583
02/04
Download from Www.Somanuals.com. All Manuals Search And Download.
IMPORTANT! WRITE MODEL NUMBER FROM BOX ONTO PAGE 1 OF THIS OWNERS MANUAL
TOP
1
1.
2.
4
5
6
MIDDLE
5”
(13 cm)
BOTTOM
5”
(13 cm)
IMPORTANT!
(See Text Page)
4
IMPORTANT!
(See Text Page)
4.
3.
6
5.
7
5
5
8
6
WOOD SCRAP
4
Note
(See Text Page)
Note
(See Text Page)
6.
9
3
28
28
3
6
2
7
8
RIVNUT FACES
FRONT OF UNIT
36
10
5
02/04
P/N 211583
Download from Www.Somanuals.com. All Manuals Search And Download.
WARNING
(See Text Page)
7.
14
12
12
11
13
13
1
13
8.
13
13
16
12
1
12
17
6
P/N 211583
02/04
Download from Www.Somanuals.com. All Manuals Search And Download.
22
9.
21
18
45
IMPORTANT!
(See Text Page)
17
Note
(See Text Page)
20
IMPORTANT!
(See Text Page)
10.
11.
WARNING
(See Text Page)
Note
(See Text Page)
24
26
SAWHORSE OR SUPPORT TABLE
23
7
02/04
P/N 211583
Download from Www.Somanuals.com. All Manuals Search And Download.
Install net clips.
WARNING: Use of this product without proper installation of net
clips, or when all net clips are not present could result in bodily harm. Be sure
to follow directions carefully.
12.
CLIP “ARM”
CLIP “BODY”
Insert one “arm” of clip into ram as shown. Twist “body” of clip slightly so that
second “arm” slides over the top of the first “arm” as shown.
Push in direction indicated by arrows.
19
A
Push second “arm” back and into ram as shown.
B
Twist “body” of clip slightly again to spread “arms” of clip.
Clip “arms” must be flat and touching edge to edge as shown, not overlapping.
C
8
P/N 211583
02/04
Download from Www.Somanuals.com. All Manuals Search And Download.
Install net.
SIDE VIEW
NETCLIP
NET
Insert net into bottom of clip as shown.
SIDE VIEW
Twist net until it snaps into position.
Net must be centered through clip.
NETCLIP
NET
9
02/04
P/N 211583
Download from Www.Somanuals.com. All Manuals Search And Download.
13.
WARNING
(See Text Page)
Note
(See Text Page)
15
10 feet
(3.05 m)
29
IMPORTANT!
(See Text Page)
14.
30
29
27
27
29
10
P/N 211583
02/04
Download from Www.Somanuals.com. All Manuals Search And Download.
NET/GOAL ATTACHMENT
15.
32
44
TABS TO
OUTSIDE OF
NET
TABS TO
OUTSIDE OF
NET
31
16.
TOP
38
39
HOLE
DOWNWARD
12
17
11
02/04
P/N 211583
Download from Www.Somanuals.com. All Manuals Search And Download.
17.
BOTTOM
12
17
37
12
39
HOLE
UPWARD
18.
41
42
12
P/N 211583
02/04
Download from Www.Somanuals.com. All Manuals Search And Download.
19.
33
33
POLE PAD
13
02/04
P/N 211583
Download from Www.Somanuals.com. All Manuals Search And Download.
TARP ATTACHMENT
20.
14
P/N 211583
02/04
Download from Www.Somanuals.com. All Manuals Search And Download.
|