Sportster® II
Dual-Fuel™
Stove
®
CSA B140.9.2-2008 Proposed
Portable Pressurized Type Liquid
Petroleum Fuelled Camp Stoves
Dual-FuelTM Stove
Instructions for use
®
© 2008 The Coleman Company, Inc.
533 Series
IMPORTANT
CONSUMER/USER: This instruction manual
contains important information necessary for the
proper assembly and safe use of the appliance.
Read and follow all warnings and instructions before
assembling and using the appliance. Follow all
warnings and instructions when using the appliance.
Keep this manual for future reference.
If you have questions about assembly, operation, servicing or repair of this
appliance, please call Coleman at 1-800-835-3278 or TDD: 316-832-8707. In
Canada call 1-800-387-6161.
English
Download from Www.Somanuals.com. All Manuals Search And Download.
WARNING
WARNING
This multi-fuel appliance may be fueled by
Coleman® Liquid Fuel or unleaded gasoline.
• BURN HAZARD
• Never leave stove unattended when hot
or in use.
• Never use kerosene or leaded automotive fuel.
• Store fuel in a clean, properly marked
container away from flame (including pilot
lights), other sources of ignition, or
excessive heat.
• Keep out of reach of children.
DANGER
DANGER
• CARBON MONOXIDE HAZARD
• This stove is a combustion appliance. All com-
bustion appliances produce carbon monoxide
(CO) during the combustion process. This
product is designed to produce extremely
minute, non-hazardous amounts of CO if used
and maintained in accordance with all warn-
ings and instructions. Do not block air flow into
or out of the stove.
• Carbon Monoxide (CO) poisoning produces
flu-like symptoms, watery eyes, headaches,
dizziness, fatigue and possibly death. You
can’t see it and you can’t smell it. It’s an invisi-
ble killer. If these symptoms are present dur-
ing operation of this product get fresh
air immediately!
• EXPLOSION - FIRE HAZARD
• During lighting and operation, this product can
be a source of ignition. Never use the stove in
spaces that contain or may contain volatile or
airborne combustibles, or products such as
gasoline, solvents, paint thinner, dust particles
or unknown chemicals. Minimum clearances
from combustible materials: 24 inches from the
sides and 48 inches from the top.
• Provide adequate clearances around air
openings into the combustion chamber.
• For outdoor use only.
DANGER
• Never use inside house, camper, tent, vehi-
cle or other unventilated or enclosed
areas. This stove consumes air (oxygen).
Do not use in unventilated or enclosed
areas to avoid endangering your life.
• EXPLOSION - FIRE HAZARD
• Coleman® fuel and gasoline are extremely
flammable; handle with care. Fuel vapors are
invisible, explosive, and can be ignited by
ignition sources may feet away.
CAUTION
• Always fill outdoors.
• SERVICE SAFETY
• Never open a pressurized Coleman® fuel tank
or fill fuel tank near flame (including pilot
lights), or other ignition sources. It is normal
for a pressurized fuel tank to vent a small
amount of fuel mist when unscrewing the fuel
cap. Be sure stove has no flame before
unscrewing the fuel cap.
• Keep all connections and fittings clean.
Inspect fuel cap for dirt or damage after refill-
ing the fuel tank. Wipe up any spilled fuel and
dispose of in a safe place.
• Use as a cooking appliance only. Never alter
in any way or use with any device or part not
expressly approved by Coleman.
• Clean stove frequently to avoid grease
accumulation and possible grease fires.
• Check all connections for leaks. Liquid
Coleman® fuel present at connections
indicates a leak.
WARNING
Not for home or recreational vehicle use.
We cannot foresee every use which may be
made of our products.
Check with your local fire safety authority
if you have questions about use.
Other standards govern the use of fuel and
heat producing products for specific uses.
Your local authorities can advise you about
these.
• Use only Coleman® accessories or parts.
• During stove set-up, check all fittings for
leaks using soapy water. Never use a flame.
English-2
Download from Www.Somanuals.com. All Manuals Search And Download.
Thank you for purchasing your new
Coleman® multi-fuel stove. We
recommend operating your new stove
in a safe location outside your home
to familiarize yourself with its multi-fuel
operation before your next outdoor
experience.
Technical
Characteristics
Input: 10,500 BTU/HR Coleman® fuel
or unleaded gasoline.
Category: Direct pressure
multi-fuel stove
Fuel: Coleman® fuel or
unleaded gasoline
Helpful Hints
• Liquid Coleman® fuel is recommended
when using the stove in temperatures
below 40° F or in high elevation.
• For best results, always use Coleman®
Filter/Funnel Part No. 5103A700T.
• If necessary, unleaded gasoline may
be substituted for liquid Coleman® fuel.
• Do not use kerosene in this stove.
WARNING
1. Coleman® Fuel is extremely
flammable, handle with extreme
care. Fuel vapors are invisible,
explosive, and can be ignited by
ignition sources many feet away.
2. Always fill outdoors. Never open or
fill fuel tank near flame (including
pilot lights), or other ignition
sources. It is normal for a pressur-
ized fuel tank to vent a small
amount of fuel mist when
To Set Up
DANGER
unscrewing the fuel cap.
• CARBON MONOXIDE HAZARD
• For outdoor use only.
3. Always light and use stove
outdoors; never inside house,
camper, tent, or other unventilated
or enclosed areas.
4. This stove consumes air
(oxygen). Do not use in
• Never use inside house, camper, tent, vehicle
or other unventilated or enclosed areas. This
lantern consumes air (oxygen). Do not use in
unventilated or enclosed areas to avoid
endangering your life.
unventilated or enclosed areas
to avoid endangering your life.
5. This stove is designed to use
Coleman® Fuel or unleaded
gasoline.
6. Store fuel in a clean, properly
marked container away from
flame (including pilot lights),
other sources of ignition, or
excessive heat.
Filling the tank
Always fill outdoors. Never fill tank,
loosen or remove fuel cap near flame
(including pilot lights), or other ignition
sources.
■ With stove on level surface, move red
fuel lever to off position. (Fig. 1)
7. Use for cooking only. Never alter
in any way or use with any device
or part not expressly approved
by Coleman. Never use as a
space heater. Never leave stove
unattended while burning.
8. Keep stove away from flamma-
bles. Never allow fabric, clothing,
or any flammable material come
within 48 inches of the top and 24
inches of all sides of the stove.
9. When stove is in use, all metal
parts of the stove assembly and
generator become extremely hot.
DO NOT TOUCH.
Fig. 1
10. Never place heavy or large
capacity utensils on stove.
11. Keep out of reach of children.
English-3
Download from Www.Somanuals.com. All Manuals Search And Download.
■ Close PUMP KNOB firmly. (Fig. 2)
■ Close PUMP KNOB. (Fig. 7)
Fig. 7
Fig. 2
■ Remove FUEL CAP. Using a funnel
or suitable filling device, fill with
clean, fresh fuel (Fig. 3). Do not tip
stove.
Leak Check
■ Make sure FUEL VALVE is fully
■ Replace FUEL CAP on fuel container.
Tighten firmly. Move fuel container
away from stove. WIPE UP ANY
SPILLED FUEL AND DISPOSE OF
IN A SAFE PLACE.
“OFF”.
■ CHECK FOR LEAKS in one or more
ways. Look for fuel mist or a wet
appearance of fuel on surfaces. Listen
for hiss of escaping gas. Smell for fuel
odor. Never use a flame. Do not use if
leaking. (Fig. 8)
CHECK FOR
LEAKS
CHECK
CHECK
FOR
LEAKS
FOR
LEAKS
Fig. 3
Fig. 8
Pumping
Be sure RED FUEL LEVER is in off
position. (Fig. 4)
To Light
■ Open PUMP KNOB one full turn.
(Fig. 5)
WARNING
• Perform leak test outdoors.
• Extinguish all open flames.
• NEVER leak test when smoking.
• Do not use the outdoor stove until connection
has been leak tested and does not leak.
WARNING
Fig. 4
Fig. 5
■ With thumb over hole in PUMP
KNOB, pump approximately 30 full
strokes. (Fig. 6)
• BURN HAZARD
• Never leave stove unattended
when hot or in use.
• Keep out of reach of children.
Fig. 6
English-4
Download from Www.Somanuals.com. All Manuals Search And Download.
NEVER FILL OR LIGHT STOVE INSIDE ■ Additional pumping may be required
HOUSE, CAMPER, OR TENT for full heat output (Fig. 14)
.
■ Hold lit match at BURNER, then turn
RED FUEL LEVER to high (LIGHT)
position. (Fig. 9)
Fig. 14
For temperatures below
freezing
■ Note: In temperatures below freezing
preheating paste may be required.
Place a generous amount of PRE-
HEATING PASTE on BURNER CAP
beneath the GENERATOR. (Fig. 15)
Fig. 9
■ When burner lights, open PUMP
KNOB one turn (Fig. 10) and pump for
30 full strokes (Fig. 11).
Fig. 10
Fig. 11
Fig. 15
■ Close PUMP KNOB. (Fig. 12)
■ Light the paste (Fig. 16). After the
paste is almost consumed, follow the
previous lighting instructions.
Fig. 12
■ CAUTION: If fuel or flames appear
below BURNER, immediately turn
RED FUEL LEVER off. Allow stove to
cool. Turn stove upside down to
empty any fuel accumulated in burner
and wipe dry. Review instructions
then relight stove.
Fig. 16
To Turn Off
■ Move RED FUEL VALVE from off to
high” several times. (Fig. 17)
■ Adjust flame to desired heat with
RED FUEL LEVER. (Fig. 13)
Fig. 17
Fig. 13
English-5
Download from Www.Somanuals.com. All Manuals Search And Download.
■ Latch Red FUEL VALVE in off
position. (Fig. 18)
To Store
■ Make sure stove is cool.
■ Move stove away from flame (includ-
ing pilot lights) and other ignition
sources.
• MAINTENANCE
• Keep stove area clear and free
from combustible materials,
gasoline and other flammable
vapors and liquids.
Fig. 18
• Do not obstruct the flow of
combustion and ventilation air.
• A good flame should be blue with
minimal yellow tip. Some yellow
tips on flames are acceptable as
long as no carbon or soot deposits
appear.
• Wipe clean with soft cloth and mild
dish detergent. Do not use abra-
sives.
■ Be sure flame is extinguished. Flame
will linger on burner for 1-2 minutes
after fuel valve is “OFF”.
WARNING
• Always turn fuel valve off before
unscrewing fuel cap from fuel tank. Never
remove fuel cap near ignition sources,
while stove is lit, or hot to touch.
English-6
Download from Www.Somanuals.com. All Manuals Search And Download.
Troubleshooting
Problem
Solution
Symptom
Fuel tank empty.
Refill fuel tank with clean and
fresh Coleman® fuel or unleaded
fuel.
Burner will not
light or flame self-
extinguished.
Little or no pressure in fuel
tank.
Check that fuel cap is tight and
pump 30 strokes.
Burner will not
light or flame is
low or flame self-
extinguished.
Generator is not fully
warmed up.
In temperatures below freezing
preheating paste may be
required. Place a generous
amount of preheating paste on
burner cap beneath the generator.
Burner self-
extinguishes
during one minute
warm-up.
A yellow flame is normal until the
generator warms up. If yellow
flame persists, turn off stove,
allow flame to self-extinguish and
the stove to cool. If necessary,
invert stove to remove excess
liquid fuel from the burner. Follow
lighting instructions.
Excess fuel in burner.
Yellow flame.
Turn red fuel lever back and forth
several times to clean generator
tip. Be sure to use only fresh and
clean fuel.
Generator tip plugged.
Faulty generator.
Low heat.
Low heat.
Replace with a new generator.
This is a normal periodic
maintenance procedure. The
generator life is dependent on the
type of fuel used. Generator life is
extended by using clean
Coleman® fuel.
Faulty generator.
Replace with a new generator.
Persistent small
yellow flame.
Failure in the fuel delivery
system.
May need to replace pump
assembly. Please contact
Persistent high
yellow flame.
Consumer Service (see page 9).
Spider webs, insects, or
other obstruction in the
burner and air tube.
Remove burner to inspect and
clean the burner and air tube.
Yellow smokey
flame.
Squirt a few drops of oil in the
OIL HOLE in the pump cap. This
will keep the pump functioning
properly (Fig. 19). If this does not
correct the problem, replace the
pump seals or purchase a new
pump assembly.
Pump seals are dry or
worn.
Pump does not
pressurize the
liquid fuel
canister.
Flame requires adjustment.
Adjust the flame to a slightly
higher level with the red fuel lever.
Intermittent yellow
flame after
extended use on
low heat setting.
English-7
Download from Www.Somanuals.com. All Manuals Search And Download.
Replacement Parts List
No.
1
Part No.
220C1401
220A6201
533-5891
508A5571
400-3451
413C3021
400-5401
639-1091
400-5261
400A1261
400-0601
200-6381
400B5151
Description
Fuel Cap
2
Pump Repair Kit
Generator
3
4
Valve Assembly
Burner Ring Set
Burner Bowl
5
6
7
Grate
8
Pump Cup & Nut
Burner Box Assembly
Generator Bracket
Screw Pkg. (6)
Check Valve & Stem Assy.
Valve Stem Assy.
9
10
11
12
13
7
5
3
13
10
6
8
2
4
11
9
1
12
English-8
Download from Www.Somanuals.com. All Manuals Search And Download.
Things You Should Know
Warranty
1. Preheating paste is available at most stores
that sell backpacking equipment.
2. Rinse tank twice a year with fresh fuel to
remove sediment, gum formations, and
moisture accumulations.
3. Seasonally or before storage, squirt a few
drops of oil into the OIL HOLE in the pump
cap. This will keep the pump functioning
properly. (Fig. 19)
Limited Five Year Warranty
The Coleman Company, Inc. (“Coleman”) warrants that
for a period of five years from the date of original retail
purchase, this product will be free from defects in material
and workmanship. Coleman, at its option, will repair or
replace this product or any component of the product found
to be defective during the warranty period. Replacement
will be made with a new or remanufactured product or
component. If the product is no longer available, replacement
may be made with a similar product of equal or greater value.
This is your exclusive warranty.
This warranty is valid for the original retail purchaser from
the date of initial retail purchase and is not transferable. Keep
the original sales receipt. Proof of purchase is required to
obtain warranty performance. Coleman dealers, service
centers, or retail stores selling Coleman® products do not
have the right to alter, modify or in any way change the terms
and conditions of this warranty.
4. The red fuel lever moves a small needle in
and out of the generator gas tip. If stove is
hard to light or does not produce full heat
output, turn red fuel lever back and forth
several times to clean generator.
5. Unleaded fuels may vary in quality and can
affect generator life and performance. If you
are having a problem with your stove or
generator using unleaded fuel, replace the
generator and try a different brand of
unleaded fuel.
6. The usual storage areas for camping and
picnic equipment are the basement, attic, or
garage. To avoid the accumulation of dust,
cobwebs, etc., that is common in these
areas, place your stove in a plastic bag and
seal it with a rubber band.
7. For repair service call one of the numbers
listed below for location of your nearest
Coleman Service Center. If stove must be
mailed to a Service Center, attach to the
product a tag that includes your name,
address, daytime telephone number and a
description of problem. Do NOT send LPG
canister. Carefully package the product and
send either by courier or insured mail with
shipping and insurance prepaid to:
What This Warranty Does Not Cover
This warranty does not cover normal wear of parts, parts
that are not genuine Coleman® parts, or damage resulting
from any of the following: negligent use or misuse of the
product; use on improper voltage or current; commercial use
of the product; use contrary to the operating instructions;
disassembly, repair or alteration by anyone other than
Coleman or an authorized service center. Further, the
warranty does not cover Acts of God, such as fire, flood,
hurricanes and tornadoes. Warranty void if damage to
product results from the use of a part other than a genuine
Coleman® part.
COLEMAN SHALL NOT BE LIABLE FOR DEFECTS THAT
ARE CAUSED BY THE USE OF UNAUTHORIZED PARTS
OR SERVICE. COLEMAN SHALL NOT BE LIABLE FOR
ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES
CAUSED BY THE BREACH OF ANY EXPRESS OR
IMPLIED WARRANTY OR CONDITIONS. EXCEPT TO THE
EXTENT PROHIBITED BY APPLICABLE LAW, ANY
IMPLIED WARRANTY OF MERCHANTABILITY OR
FITNESS FOR A PARTICULAR PURPOSE IS LIMITED IN
DURATION TO THE DURATION OF THE ABOVE
WARRANTY OR CONDITIONS. SOME STATES,
PROVINCES, OR JURISDICTIONS DO NOT ALLOW THE
EXCLUSION OR LIMITATION OF INCIDENTAL OR
CONSEQUENTIAL DAMAGES OR LIMITATIONS ON HOW
LONG AN IMPLIED WARRANTY LASTS, SO THE ABOVE
LIMITATIONS OR EXCLUSION MAY NOT APPLY TO YOU.
THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS,
AND YOU MAY ALSO HAVE OTHER RIGHTS THAT VARY
FROM STATE TO STATE OR PROVINCE TO PROVINCE.
For products purchased in the United States:
The Coleman Company, Inc.
3600 N. Hydraulic • Wichita, KS 67219 U.S.A.
1-800-835-3278 • TDD: 316-832-8707
How to Obtain Warranty Service
Take the product to an authorized Coleman service center.
You can find the nearest authorized Coleman service center
TDD 316-832-8707 in the United States or 1 800 387-6161 in
Canada. If a service center is not conveniently located, attach
to the product a tag that includes your name, address,
daytime telephone number and description of the problem.
Include a copy of the original sales receipt. Carefully package
the product and send either by courier or insured mail with
shipping and insurance prepaid to:
For products purchased in Canada:
Sunbeam Corporation (Canada) Limited
DBA Jarden Consumer Solutions
20B Hereford Street
Brampton, ON L6Y 0M1
1-800-387-6161
8. If not completely satisfied with the
performance of this product, please call one
of the numbers listed above.
For products purchased in the United States:
The Coleman Company, Inc.
3600 North Hydraulic
Wichita, KS 67219
For products purchased in Canada:
Sunbeam Corporation (Canada) Limited
DBA Jarden Consumer Solutions
20B Hereford Street
Brampton, ON L6Y 0M1
OIL HOLE
The costs of transporting the product to Coleman or an
authorized service center for warranty service is the
responsibility of the purchaser.
Do not mail products with fuel in tanks, or with disposable
LPG canisters. Remove glass globes from lanterns and wrap
separately.
DO NOT RETURN THIS PRODUCT TO THE PLACE OF
PURCHASE.
If you have any questions regarding this warranty please
call 1-800-835-3278 or TDD 316-832-8707 in the United
States or 1 800 387-6161 in Canada.
Fig. 19
English-9
Download from Www.Somanuals.com. All Manuals Search And Download.
Notes:
Download from Www.SomanuaEls.ncogmli.sAhl-l 1M0anuals Search And Download.
The Coleman Company, Inc. • 3600 North Hydraulic • Wichita, KS 67219 U.S.A.
1-800-835-3278 • TDD: 316-832-8707
Sunbeam Corporation (Canada) Limited • DBA Jarden Consumer Solutions
20B Hereford Street
Brampton, ON L6Y 0M1 • 1 800 387-6161
© 2008 The Coleman Company, Inc. All rights reserved. Coleman®, Sportster®, and
are registered trademarks and Dual Fuel™ is a trademark of The Coleman Company, Inc.
© 2008 The Coleman Company, Inc. Tous droits réservés. Coleman®, Sportster®, et
sont des marques déposées alors que Dual Fuel™ est une marque de commerce de The Coleman Company, Inc.
© 2008 The Coleman Company, Inc. Todos los derechos reservados. Coleman®, Sportster®,
y
son marcas registradas Dual Fuel™ es una marca de la compañía The Coleman Company, Inc.
y
4010003165 (20080310)
Download from Www.Somanuals.com. All Manuals Search And Download.
|