Download from Www.Somanuals.com. All Manuals Search And Download.
Introduction
Entry
The model and serial numbers are found on the inner case or back of refrigerator
compartment of this unit. These numbers are unique to this unit and not
available to others. You should record requested information here and retain
this guide as a permanent record of your purchase. Staple your receipt here.
Date of purchase
Dealer
:
:
:
:
:
:
Dealer address
Dealer phone no.
Model no.
Serial no.
Important safety instruction
Before use, this refrigerator must be properly installed and located in accordance with
the installation instructions in this manual.
Never unplug your refrigerator by pulling on the power cord. Always grip the plug firmly
and pull it straight out from the outlet.
When moving your appliance away from the wall, be careful not to roll over the power
cord or to damage it in any way. Do not crush or damage the water line.
After your refrigerator is in operation, do not touch the cold surfaces in the freezer
compartment, particularly when your hands are damp or wet. Skin could adhere to
these extremely cold surfaces.
Unplug the power cord from the power outlet for cleaning or other requirements. Never
touch it with wet hands because you can get an electric shock or be injured.
Never damage, bend, kink, pull out, or twist the power cord because damage to the
power cord can cause product failure, fire, or electric shock. If you have doubts the
appliance is properly grounded, consult a qualified electrician.
Never place glass products in the freezer because they may be broken from expansion
when their contents are frozen.
Never put your hands within the ice storage bin of the automatic icemaker. You can be
injured by the operation of the automatic icemaker.
The appliance is not intended for use by young children without supervision.
Young children should be supervised to ensure that they do not play with the appliance.
Never allow anyone to climb, sit, stand, or hang on the door. These actions may
damage the refrigerator and even tip it over, causing severe personal injury.
Before you move your refrigerator into its final location,
it is important to make sure you have the proper electrical
connection:
Recommended
Grounding
Method
A 115 Volt, 60 Hz., AC only 15, or 20 ampere fused, grounded
electrical supply is required. It is recommended that a separate
circuit serving only your refrigerator be provided. Use an outlet that
cannot be turned off by a switch. Do not use an extension cord.
The refrigerator-freezer should be so positioned that the supply plug
is accessible for quick disconnection in the event of an emergency.
Accessibility of
Supply Plug
If the supply cord is damaged, it must be replaced by the manufacturer or its service agent or
a similarly qualified person in order to avoid any hazard.
Supply Cord
Replacement
Do not modify or extend the Power Cord length.
Warning
ꢀ
It will cause electric shock or fire.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Introduction
Child Entrapment
Warning
DANGER: Risk of child entrapment.
Before you throw away your old refrigerator or freezer:
Take off the doors but leave the shelves in place so that children may not easily climb
inside.
The appliance is not intended for use by young children without supervision.
Young children should be supervised to ensure that they do not play with the appliance.
Don’t store or use gasoline or other flammable vapor and liquids in the vicinity of this or
any other appliance.
Don’t Store
In the event of an electric short circuit, grounding (earthing) reduces the risk of electric
shock by providing an escape wire for the electric current.
Grounding (Earthing)
In order to prevent possible electric shock, this appliance must be grounded.
improper use of the grounding plug can result in an electric shock. Consult a qualified
electrician or service person if the grounding instructions are not completely
understood, or if you have doubts on whether the appliance is properly grounded.
Identification of Parts
Freezer
Compartment
Refrigerator
Compartment
Dairy Corner
Water Filter
Lamp
Shelf
Door Rack
Automatic
Icemaker
Wine holder
Lamp
Shelf
Snack Drawer
Shelf
(steel or glass)
Egg Box
Lamp
Jet Freezing
Door Rack
Drawer
Vegetable Drawer
Door Rack
Optichill
Door Rack
Lower Cover
NOTE
•
If you find some parts missing from your unit, they may be parts only used in other
models. (i.c. the Optichill is not included in all models)
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Introduction
Where to Locate
1. Place your appliance where it is easy to use.
Select a Good
Location
2. Avoid placing the unit near heat sources, direct sunlight, or moisture.
3. To avoid vibrations, the appliance must be leveled.
4. Do not install this refrigerator in areas where the ambient temperature is below 41∞F.
It will have an adverse effect on performance.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Door removal
Warning
Electric Shock Hazard
Disconnect electrical supply to refrigerator before installing.
Failure to do so could result in death or serious injury.
If your entrance door is too narrow for the
refrigerator to pass through, remove the
refrigerator door and pass the refrigerator laterally.
Lower Cover
Remove Lower
Cover and
Water Feed Tube
Remove the lower cover by lifting upward, and
then pull up the water feed tube while pressing
Water Feed Tube
area
ꢁshown in the figure to the right.
NOTE
•
If a tube end is deformed or abraded, trim the part away.
Disconnecting the tube under the door causes about 1.5 litters water to flow out.
Please put up a big container to prevent it.
Hinge
Cover
Connection
Wires
Remove the
Freezer
Compartment
Door
1) Remove the hinge cover by loosening the
screws. Disconnect all connections except
the ground line.
Earth Line
Upper Hinge
Upper Hinge
Keeper
2) Remove the keeper by rotating it counter
clockwise and then lifting the upper
ꢁ
hinge up ꢂ.
NOTE
•
When removing the upper hinge, be careful that the door does not fall forward .
3) Remove the freezer compartment door by
lifting it upward. This time, the door should
be lifted enough for the water feed tube to
be completely pulled out.
Lower hinge
NOTE
•
After removing the door, take it into the kitchen where you are installing the
refrigerator. Lay it down on a blanket and be careful to avoid damaging the water
feed tube.
Remove the
Refrigerator
Door
1) Loosen the hinge cover screws and remove
the cover. Remove connection wire, if any,
except for the ground line.
Connection
Wires
Upper Hinge
Keeper
2) Remove keeper by rotating it clockwise
and then remove the upper hinge by lifting
it up
ꢁ
ꢂ
.
3) Remove the refrigerator compartment door
by lifting it up.
6
Lower Hinge
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Push the refrigerator sideways through the
entrance door as shown in the right picture.
Move the
Refrigerator
Door replacement
Mount the doors in the reverse order of removal after the refrigerator is brought to
the installation area.
Feed water tube installation
2
ꢀ
Before
Installation
Automatic icemaker operation needs water pressure of 21.3~121psi(lb/inch ) (That
is, a 7oz. paper cup will be filled within 3 sec.).
2
ꢀ
If water pressure does not reach the rated 21.3psi(lb/inch ) or below, it is necessary
to purchase a separate pressure pump for normal automatic icemaking and cool
water feed.
ꢀ
Keep the total length of the water feed tube within 40 feet and be careful not to
bend or kink the tube. If the tube is longer than 40 feet, the icemaker and water
dispenser will not operate properly.
ꢀ
Install the water feed tube at a place free from heat.
ꢀ
Connect to potable water supply only.
Refer to instructions with water filter kit for installation.
Warning
ꢀ
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Water Connection Instruction Guide
Connecting
the Refrigerator
to a Water Source
Read all directions carefully before you begin.
Warning
Connect to potable w ater supply only.
IMPORTANT
•
If operating the refrigerator before installing the water connection, turn icemaker
to the OFF position to prevent operation without water.
•
•
•
•
All installations must be in accordance with local plumbing code requirements.
Use copper tubing and check for leaks.
Install copper tubing only in areas where temperatures will remain above freezing.
It may take up to 24 hours for your icemaker to begin producing ice.
ꢀ
ꢀ
ꢀ
ꢀ
ꢀ
Tools Required
Standard screwdriver
7/16-inch and 1/2-inch open-end wrenches or two adjustable wrenches
1/4-inch nut driver
1/4-inch drill bit
Hand drill or electric drill (properly grounded)
NOTE
•
Your refrigerator dealer has a kit available with a 1/4-inch saddle-type shut-off valve,
a union, and copper tubing. Before purchasing, make sure a saddle-type valve
complies with your local plumbing codes. Do not use a piercing-type or 3/16-inch
saddle valve which reduces water flow and clogs more easily.
Cold Water Supply
The icemaker water valve contains a flow washer which is used as a water
pressure regulator.
The icemaker needs to be connected to a cold water line with water pressure
30~120psi(lb/inch2)
8
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Connect
the Tubing to
Water Line
1. Unplug refrigerator or disconnect power.
2. Turn OFF main water supply. Turn on the nearest faucet to relieve the pressure
on the line. It may help to open an outside faucet to allow the water to drain from
the line in the house.
3. Find a 1/2-inch to 1-1/4-inch vertical COLD water pipe near the refrigerator.
NOTE
•
Horizontal pipe will work, but the following precaution must be taken: Drill on the top of
the pipe, not the bottom. This will help keep water away from the drill. This also keeps
normal sediment from collecting in the valve.
4. To determine the length of copper tubing you will need, measure from the
connection on the lower left rear of the refrigerator to the water pipe. Add 7
feet (2.1m) to allow for moving refrigerator for cleaning. Use 1/4-inch O.D.
(outside diameter) copper tubing. Be sure both ends of copper tubing are cut
square.
5. Using a drill, drill a 1/4-inch hole in the cold water pipe you have selected.
6. Fasten shut-off valve to cold water pipe with pipe clamp. Be sure outlet end is
solidly in the 1/4-inch drilled hole in the water pipe and that the washer is
under the pipe clamp. Tighten packing nut. Tighten the pipe clamp screws
carefully and evenly so washer makes a watertight seal. Do not overtighten or
you may crush the copper tubing, especially if soft (coiled) copper tubing is
used. Now you are ready to connect the copper tubing.
7. Slip compression sleeve and compression nut on copper tubing as shown.
Insert end of tubing into outlet end squarely as far as it will go. Screw
compression nut onto outlet end with adjustable wrench. Do not over tighten.
8. Place the free end of the tubing into a container or sink, and turn ON main
water supply and flush out tubing until water is clear. Turn OFF shutoff valve
on the water pipe. Coil the copper tubing as shown below.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Operation Instruction Guide
Connect the Tubing
to the Refrigerator
Before m aking the connection to the refrigerator, be sure the refrigerator
pow er cord is not plugged into the w all outlet.
• If your refrigerator does not
have a water filter, we
"
recommend installing one. If
your water supply has sand or
particles that could clog the
"
screen of the refrigerator’s
water valve. Install the filter in
the water line near the
refrigerator.
1. Remove the plastic flexible
cap from the water valve.
2. Place the compression nut and
ferrule (sleeve) onto the end of
the tubing as shown.
3. Insert the end of the copper tubing into the connection as far as possible. While
holding the tubing, tighten the fitting.
Turn the Water On at
the Shutoff Valve
Tighten any connections that leak.
ꢀ
Plug In the Refrigerator
Arrange the coil of copper tubing behind the refrigerator so it does not vibrate
against the back of the refrigerator or against the wall. Push the refrigerator
back to the wall.
ꢀ
Start the lcem aker
Set the icemaking stop switch to the ON position The icemaker will not begin
to operate until it reaches its operating temperature of 15 °F (-9 °C). It will then
begin operation automatically if the icemaking stop switch is in the ON
position.
ꢀ
Automatic Ice maker
The automatic icemaker makes 8 cubes at a time, 120/150 pieces per day.
But these quantities may vary according to circumstance, including ambient
temperature, door openings, freezer load.etc.
ꢀ
The Icemaker stops when the bin is full.
NOTE
•
It is normal to hear a noise when ice drops into the bin.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
When Icemaker
Does Not Operate
Smoothly
Ice is clum ped together
ꢀ
When ice is clumped together, take the ice clumps out of the ice storage bin,
break them into small pieces, and then place them into the ice storage bin
again.
ꢀ
When the icemaker produces too small or clumped ice, the amount of water
supplied to the ice maker must be adjusted. Contact the service center.
ꢀ
If ice is not used frequently, it may clump together.
Pow er failure
ꢀ
Water may drop into the freezer compartment. Take the ice storage bin out and
discard all the ice. Dry the bin and replace it.
The unit is new ly installed
ꢀ
It takes about 12 hours for a newly installed refrigerator to make ice.
Throw away the ice.
CAUTION
The first ice and water may include particles or odor from the feed water pipe or
feed water box.
This is also necessary if the refrigerator has not been used for a long time.
Never store beverage cans or other foods in ice storage bin for the purpose of rapid
cooling.
Such actions may damage the automatic ice maker.
Never remove the icemaker cover.
Shake the bin occasionally to cause the ice to settle.
Ice may pile up just around the icemaker causing the icemaker to think that the ice
storage bin is full.
If discolored ice is dispensed, contact an Authorized Service Center immediately.
Do not use the ice or water until the problem is corrected.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Height Adjustment
Level the door by inserting flat (
screw and rotating it clockwise ꢁ.
-
type) driver into the groove of the left height adjusting
If the freezer
compartment door
is lower than the
refrigerator
compartment door
ꢁ
If the freezer
compartment door
is higher than the
refrigerator
Level the door by inserting flat (
adjusting screw and rotating it clockwise ꢁ.
-
type) driver into the groove of the right height
compartment door
ꢁ
After leveling the
door height
The refrigerator doors will close smoothly by adjusting the height adjusting screw. If
the doors do not close correctly, performance may be affected.
1. Wipe off all dust accumulated during shipping and clean your appliance thoroughly.
Next
2. Install accessories such as the ice cube box, cover evaporating tray, etc., in their
proper places. They are packed together to prevent possible damage during shipping.
3. Connect the power supply cord (or plug) to the outlet. Use this appliance on a
dedicated circuit.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
Operation
Starting
When your refrigerator is first installed, allow it to stabilize at normal operating
temperatures for 2-3 hours prior to filling it with fresh or frozen foods.
If operation is interrupted, wait 5 minutes before restarting.
Adjusting The Temperatures and Functions
13
Download from Www.Somanuals.com. All Manuals Search And Download.
Operation
1. Buzzer sound mute Mode
The buzzer sound is set to OFF.
It activates by sounding the recognition sound of “Ding~” after pressing and
holding “Express FRZ” button more than 4 seconds.
It inactivates when resetting the mode power.
2. Display Power saving Mode
It places display in standby mode until door is opened.
Press “Freezer” and “Express FRZ” buttons simultaneously to turn all leds ON and
then OFF with the recognition sound of “Ding~” after 5 seconds.
Once the mode activates, the display is OFF. Until door is opened or display button
is pressed. When 30 seconds has elapsed after closing door or pressing button,
the display turns OFF.
To deactivate this mode is same as the activation methods. The mode inactivates
when resetting the power.
3. To change temperature display from Fahrenheit to Celsius press and hold
“FREEZER” and “REFRIGERATOR” buttons simultaneously for more than 5
seconds. Do the same to convert back to Celsius.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
Operation
You can adjust temperature of freezer compartment and refrigerator
Compartment.
Freezer Compartment temperature adjustment
How to adjust the
temperature in
the freezer
Setting
temperature
compartment
COLDEST
COLD
COLDEST
COLD
COLDEST
COLD
COLDEST
COLD
COLDEST
COLD
BAR
Indication
How to adjust the
temperature in
the refrigerator
compartment
Refrigerator Compartment temperature adjustment
Setting
temperature
COLDEST
COLDEST
COLDEST
COLDEST
COLDEST
BAR
Indication
COLD
COLD
COLD
COLD
COLD
❇ Whenever pressing button, setting is repeated in the order of (Middle)
(Middle Strong) (Strong) (Weak) (Middle Weak).
The actual inner temperature varies depending on the food status, as the
❇
❇
❇
❇
ꢀ
indicated setting temperature is the target temperature, not actual temperature
within refrigerator.
ꢀ
Please adjust temperature as above after using refrigerator for minimum 2~3
days.
Dispenser
selection
You can select water or ice.
❇ Please select water, Crushed ice, or cubed ice by
pressing
button as you desire.
❇ Please press the button gently by pushing in cup.
ꢀ
You will hear a clap when the ice door closes
after ice is dispensed.
Pressing
Switch
•
Reference : Hold your cup in place for a couple of seconds after
dispensing ice or water so the last few drips go in
your cup instead of on the floor.
15
Download from Www.Somanuals.com. All Manuals Search And Download.
ꢀ
The automatic icemaker can automatically make 8 cubes at a time,
120~150 pieces per day. This quantity may vary by circumstance, including ambient
temperature, door opening, freezer load. etc.
Automatic
Icemaker
ꢀ
ꢀ
Icemaking stops when the ice storage bin is full.
If you don't want to use automatic icemaker, turn the icemaker switch to
OFF.
If you want to use automatic ice-maker again, change the switch to ON.
NOTE
•
It is normal that a noise is produced when ice drops into the ice storage bin.
Ice is lum ped together
When ice maker
does not operate
smoothly
ꢀ
ꢀ
If the ice lumps together, take it out, break it apart, and put it back into the storage
bin.
When the ice maker produces too small or lumped together ice, the amount of
water supplied to the ice maker needs to adjusted. Contact the service center.
❇
If ice is not used frequently, it may lump together.
Pow er failure
ꢀ
Ice may drop into the freezer compartment. Take the ice storage bin out and discard
all the ice then dry it and place it back. After the machine is powered again, crushed
ice will be automatically selected.
The unit is new ly installed
ꢀ
It takes about 12 hours for a newly installed refrigerator to make ice.
Please select this function for prom pt freezer.
Jet Freezer
ꢀ
”OFF❇ EXPRESS❇ JET❇ OFF” or
”OFF❇ ON❇ OFF” is repeated
whenever pressing
button.
ꢀ
The arrow mark graphic remains at the
On status after flickering 4 times when
selecting Special Refrigeration On
ꢀ
ꢀ
Prompt freezer function automatically
turns off after a fixed time passes.
JET FRZ : Not applicable to all models.
This button stops operation of different
button and dispenser function.
Lock
ꢀ
Locking or Release is repeated
whenever the
seconds.
is pressed more than 3
ꢀ
If you use the LOCK button, none of the other
buttons will work until you unlock them.
16
Download from Www.Somanuals.com. All Manuals Search And Download.
Operation
The Other
Functions
Am bient Tem perature Display Window.
ꢀ
Temperature is displayed only between 16∞F ~ 120∞F.
Temperature less than 15∞F is indicated with LO and
ꢀ
temperature more than 121∞F is indicated with HI.
Door open w arning
ꢀ
A warning tone will sound 3 times at thirty-second intervals if the refrigerator or freezer
door is left open for more than sixty seconds.
ꢀ
Please contact with the local service center if warning continue to sound even after
closing the door.
Diagnosis (failure detection) function
ꢀ
Diagnosis function automatically detects failure when failure is found in product during
the use of refrigerator.
ꢀ
If your refrigerator fails, do not turn off the power. Instead, contact a local Authorized
service center or call our support line for assistance. Turning off the appliance will
make it more difficult for the service technician to determine the problem.
Water is cooled while stored in the water tank in freezer door, and then sent to the
dispenser.
How Ice/Cold
Water is Supplied
Ice is made in the automatic icemaker and sent to the dispenser divided into crushed
or cubed ice.
ꢀ
How to Use
Dispenser
Select among crushed ice, water, and cubed ice and press the push switch with a
glass or other container.
Water
Crushed Ice
Cubed Ice
Light the water lamp
by pressing the
selection button.
Water will be dispensed
by pressing the push
switch with a glass.
Light the crushed ice
lamp by pressing the
selection button.
Light the cubed ice
lamp by pressing
the selection
•
•
C
rushed ice will be
button.
•
dispensed by pressing the
push switch with a glass.
Cubed ice will be dispensed
by pressing the push
switch with a glass.
17
Download from Www.Somanuals.com. All Manuals Search And Download.
Operation
LED
6 Filter Condition
(filter replacement
cycle) Display
Function
ꢀ
There is a replacement indicator light for the
water filter cartridge on the dispenser.
Water filter needs replacement once every six
months.
Filter light comes on to let you know when to
replace filter.
ꢀ
ꢀ
ꢀ
After replace the filter, press and hold the lock button more than 3seconds.
FILTER RESET, HOLD 3 SECS text turn off filter light.
Throw away the ice (about 20 pieces) and water (about 7 glasses) first made after
refrigerator installation.
Cautions
This is also necessary when the refrigerator has not been used for a long time.
Keep children away from the dispenser.
Children may play with or damage the controls.
Be careful that food does not block the ice passage.
If foods are placed at the entrance of ice passage, the
dispenser may malfunction. The passage may also become
blocked with frost if only crushed ice is used. Remove the
frost that accumulates.
Storing cans or other items in the ice bin may damage
the icemaker or the container may burst.
Never use thin crystal glass or crockery to collect ice.
Such glasses or containers may be broken.
Put ice first into a glass before filling water or other beverages.
Water may be splashed if ice is added to existing liquid in a glass.
Keep your hands and tools out of the ice door and passage.
You might break something or injure yourself.
Never remove the ice maker cover.
Shake the ice bin occasionally to level the ice in it.
Sometimes the ice piles up near the icemaker, causing the icemaker to misread the bin
level and stop producing ice.
If discovered ice or water is dispensed, contact an Authorized service center
immediately and discontinue use until the problem is corrected.
Never use too narrow or deep glass.
Ice may be jammed in ice passage and, thus, the refrigerator may be failed.
Keep the glass at a proper distance from ice outlet.
A glass too close to the outlet may hinder ice from coming out.
18
Download from Www.Somanuals.com. All Manuals Search And Download.
Operation
Shelf
Shelf Height
Adjustment
The refrigerator compartment shelf is movable so that you can place it at a height
according to space requirement of foods.
Pull out refrigerator tray to the front after
lifting it slightly.
NOTE
•
Make sure the shelf is horizontal. If not, it may drop.
Wine Holder
(Applicable to some models only)
Wine Holder
Adjustment
Bottles can be stored on their sides in this
wine rack. It can be mounted only at the
SLIDE SHELF.
Move to left to pull out after lifting slightly.
19
Download from Www.Somanuals.com. All Manuals Search And Download.
Operation
Egg Bin (Applicable to some models only)
You can place the egg box wherever you want it.
[Norm al]
[For Many Eggs]
NOTE
•
Never use the egg box as an ice storage bin. It can be broken.
•
Never store the egg box in the freezer compartment or fresh compartment.
Humidity control in the vegetable compartment
The humidity can be controlled by adjusting the humidity control switch to the left
or right when storing vegetabes or fruits.
High humidity
Humidity Control
High
Low
Low humidity
Humidity Control
High
Low
20
Download from Www.Somanuals.com. All Manuals Search And Download.
Operation
OptiChill Temperature Transition Corner
(Applicable to some models only)
By pressing the button, store vegetables,
fruits or other types of food such as meat to
be defrosted, raw fish, etc.
Temperature Change at OptiChill
You can select optimum temperature
range depending on types of foods
stored.
Method to Use
- four steps of temperature selection
are available, including 27°F,30°F,
39°F.Vegetables, fruits, cold storage
items requiring humidity
maintenance, meats, and fishes can
be stored under optimal conditions
by selectiong the correct storage
temperature for the foods being stored.
ꢀ
If you open the refrigerator door, an indicator lamp shows the status of the Optichill.
The lamp goes off when the door is closed.
ꢀ
Press the left SELECT button to cycle through FRUIT VEGE(39°F)
❇ CHILLED
ROOM(30°F) PARTIAL FREEZING(27°F) FRUIT VEGE(39°F).
❇
❇
OptiChill
ꢀ
First, remove the vegetable bin.
When Removing
OptiChill
ꢀ
After holding back and front of the OptiChillꢁand ꢂ
pull it outward.
ꢀ
ꢀ
Fit the OptiChill case on to the ledge ꢁand gently
slide it in ꢂ.
When Installing
OptiChill
When forced, the connecting parts can be damaged.
21
Download from Www.Somanuals.com. All Manuals Search And Download.
Suggestion on Food Storage
Location of Foods
(Refer to Identification of Parts)
Wine Holder
Store wine.
Drawer
Snack
Store small foods such as bread, snacks, etc.
Freezer
Compartment
Shelf
Store various frozen foods such as meat, fish,
ice cream, frozen snacks, etc.
ꢀ
Store small packed frozen food.
Temperature is likely to increase as door
opens. So, do not store long-term food such
ice cream, etc.
Freezer
Compartment
Door Rack
ꢀ
ꢀ
Store meat, fish, chicken, etc. after
wrapping them with thin foil.
Freezer
Compartment
Drawer
ꢀ
Store dry
.
Store milk products such as butter, cheese,
etc.
Milk Product
Corner
Egg Bin
Place this egg box in the proper location.
Store foods of frequent use such as beverage,
etc.
Refreshment
Center
Store side dishes or other foods at a proper
distance.
Refrigerator
Compartment
Shelf
Refrigerator
Compartment
Door Rack
Store small packed food or beverages such
as milk, juice, beer, etc.
Vegetable Drawer
Store vegetables or fruits.
22
Download from Www.Somanuals.com. All Manuals Search And Download.
Suggestion on Food Storage
Storing Foods
ꢀ
Store fresh food in the refrigerator compartment. How food is frozen and thawed is an
important factor in maintaining its freshness and flavor.
ꢀ
Do not store food which spoils easily at low temperatures, such as bananas and
melons.
ꢀ
Allow hot food to cool prior to storing, placing hot food in the refrigerator could spoil
other food, and lead to higher energy consumption.
ꢀ
When storing the food, cover it with vinyl wrap or store in a container with a lid. This
prevents moisture from evaporating, and helps food to keep its taste and nutrients.
ꢀ
Do not block air vents with food. Smooth circulation of chilled air keeps refrigerator
temperatures even.
ꢀ
Do not open the door frequently. Opening the door lets warm air enter the refrigerator,
and cause temperatures to rise.
ꢀ
Never keep too much food in door rack because they may push against by inner racks
so that the door cannot be fully closed.
ꢀ
Do not store bottles in the freezer compartment - they may break when frozen.
Freezer
Compartment
ꢀ
Do not refreeze food that has been thawed. This causes loss of taste and nutrient.
ꢀ
When storing frozen food like ice cream for a long period, place it on the freezer
shelf, not in the door rack.
ꢀ
Do not touch the cold foods or containers- especially made of metallic -, with wet
hands and place glass products in the freezer compartment.
- That’s why you may have chilblains and they may be broken when their inner matters
are frozen, causing personal injury.
ꢀ
Refrigerator
Avoid placing moist food in top refrigerator shelves, it could freeze from direct
contact with chilled air.
Compartment
ꢀ
Always clean food prior to refrigeration. Vegetables and fruits should be washed and
wiped, and packed food should be wiped, to prevent adjacent food from spoiling.
ꢀ
When storing eggs in their storage rack or box, ensure that they are fresh, and always
store them in an upright position, which keeps them fresh longer.
NOTE
•
If you keep the refrigerator in a hot and humid place, frequent opening of the door or
storing a lot of vegetables in it may cause condensation to form. Remove the
condensation with dust cloth free from care.
23
Download from Www.Somanuals.com. All Manuals Search And Download.
Care and Maintenance
How to Dismantle Parts
NOTE
•
Dismantling is done in the reverse sequence of assembly.
Be sure to unplug the power plug before dismantling and assembly.
Never apply severe force to dismantle parts. Parts may be damaged.
Freezer
Compartment
Lamp
Separate the lamp by pulling it out ❇ while
slightly striking ❇ and rotating ❇ the lamp cover.
Turn the bulb counterclockwise. Max. 40 W bulb
for refrigerator is used and can be purchased at
a service center.
Seperate the lamp by pulling it out, and then
remove the lamp. Max. 15 W bulb for
refrigerator is used and can be purchased at a
service center.
Dispenser Lamp
To remove a shelf, lift the left part of the shelf
a bit, push it to the direction ꢁ, lift the right part
to the direction ꢂ, and take it out.
Freezer
Compartment
Shelf
Door Rack and
Support
Lift the door rack holding both sides ꢁand
pull it out to ꢂdirection.
Lift the ice shelf as shown in the right figure
Ice Storage Bin
2
ꢁ
and pull it out ꢂ.
Hold the ice storage bin as shown in the right
figure and pull it out ❇ while slightly lifting it ❇.
1
ꢀ
It is recommended not to dismantle the ice
storage bin unless it is necessary.
ꢀ
Use both hands to remove the ice bin to avoid
dropping it.
ꢀ
If the ice bin does not slide into place easily,
twist the drive device slightly.
After Dispenser
Is Used
The water collector has no self-draining
function. It should be cleaned regularly.
Remove the cover by pulling the front side of
water collector cover and dry it with a cloth.
24
Download from Www.Somanuals.com. All Manuals Search And Download.
Care and Maintenance
To remove the lamp cover, press the protrusion under the lamp cover to the front and
then pull the lamp cover out.
Turn the bulb counterclockwise. Max. 40 W bulb for refrigerator is used and can be
purchased at a service center.
Lamp in
Refrigerator
Compartment
NOTE
•
Be sure to remove parts from the refrigerator door when removing the vegetable
compartment, snack drawer, and refreshment center cover.
ꢀ
Vegetable
Compartment
Cover
To remove the vegetable compartment
cover, pull out the vegetable compartment
a bit to the front ꢁ, lift the front part of the
vegetable compartment cover as shown by
ꢂ, and take it out.
Filter
Replacement
It is recommended that you replace the filter
when the water filter indicator light turns on or
your water dispenser or ice maker decreases
noticeably.
After changing the water filter cartridge, reset
the water filter status display and indicator light
by pressing and holding the BUTTON for 3
seconds.
1) Remove the old cartridge.
Rotate the knob of the cartridge counter clockwise.
When the cartridge is removed, you will feel it click
out of place.
Pull out the cartridge.
NOTE
•
Replacing filter causes small amount of water(around 25cc) to flow out.
Please put up a cup under the hole to prevent it.
2) Replace with a new cartridge.
Take the new cartridge out of its packaging and remove
protective cover from the o-rings. With cartridge knob in
the vertical position, push the new filter cartridge into
the cover until it stops.
If you can’t turn the filter from side to side, it isn’t fully
inserted. Push it in firmly and twist it into place. You will
hear the snap when it clicks into place. Using its handle,
twist the cartridge clockwise about 1/4 turn. You will hear
the snap when it clicks into place.
3) Flushing the Water System After Replacing Filter.
Dispense water through the water dispenser for 3
minutes to purge the system.
25
Download from Www.Somanuals.com. All Manuals Search And Download.
Care and Maintenance
General Information
During average length vacations, you will probably find it best to leave the refrigerator
in operation. Place freezable items in freezer for longer life.
Vacation Time
When you plan to store the refrigerator, remove all food, disconnect the power cord,
clean the interior thoroughly, and Block the doors open to prevent mold and mildew.
Be certain the stored refrigerator does not present a child entrapment danger.
Most power failures that are corrected in an hour or two will not affect your
refrigerator temperatures.
However, you should minimize the number of door openings while the power is off.
Power Failure
If You Move
Remove or securely fasten down all loose items inside the refrigerator.
To avoid damaging the height adjusting screws, turn them all the way into the base.
The outside wall of the refrigerator cabinet may sometimes get warm, especially just
after installation.
Don’t be alarmed. This is due to the anti-condensation pipe, which pumps hot
refrigerant to prevent sweating on the outer cabinet wall.
Anti-
Condensation
Pipe
Cleaning
It is important that your refrigerator be kept clean to prevent undesirable odors. Spilled
food should be wiped up immediately, since it may acidify and stain plastic surfaces if
allowed to settle.
Use a lukewarm solution of mild soap or detergent to clean the durable finish of your
refrigerator. Wipe with a clean damp cloth and then dry.
Exterior
Interior
Regular cleaning is recommended. Wash all compartments with a baking soda
solution or a mild detergent and warm water. Rinse and dry.
After Cleaning
Warning
Please verify that the power cord is not damaged, power plug is not overheated, or
power plug is well inserted into the power consent.
Always remove power cord from the wall outlet prior to cleaning in the vicinity of
electrical parts (lamps, switches, controls, etc.).
Wipe up excess moisture with a sponge or cloth to prevent water or liquid from
getting into any electrical part and causing an electric shock.
Never use metallic scouring pads, brushes, coarse abrasive cleaners, strong alkaline
solutions, flammable or toxic cleaning liquids on any surface.
Do not touch frozen surfaces with wet or damp hands, because damp object will stick
or adhere to extremely cold surfaces.
26
Download from Www.Somanuals.com. All Manuals Search And Download.
Care and Maintenance
Troubleshooting
Before calling for service, review this list. It may save you both time and expense.
This list includes common occurrences that are not the result of defective
workmanship or materials in this appliance.
Occurrence
Possible cause
Solution
Runing of refrigerator
Refrigerator control is off.
Set refrigerator control. See setting the
controls.
Refrigerator
compressor
does not run.
Refrigerator is in defrost cycle.
This is normal for a fully automatic
defrosting refrigerator. The defrost
cycle occurs periodically.
Plug at wall outlet is disconnected.
Power outage. Check house lights.
Make sure plug is tightly pushed into
outlet.
Call local electric company.
Refrigerator is larger than the previous
one you owned.
This is normal. Larger, more efficient
units run longer in these conditions.
Refrigerator
runs too much
or too long
It is normal for the refrigerator to work
longer under these conditions.
Room or outside weather is hot.
It takes some hours for the refrigerator
to cool down completely.
Refrigerator has recently been
disconnected for a period of time.
Large amounts of warm or hot food
may have been stored recently.
Warm food will cause the refrigerator to
run longer until the desired temperature
is reached.
Doors are opened too frequently or too
long.
Warm air entering the refrigerator
causes it to run longer. Open the door
less often.
Refrigerator or freezer door may be
slightly open.
Make sure the refrigerator is level.
Keep food and containers from
blocking door. See problem section.
OPENING/CLOSING of doors.
Set the refrigerator control to a
warmer setting until the refrigerator
temperature is satisfactory.
Refrigerator control is set too cold.
Clean or change gasket. Leaks in the
door seal will cause refrigerator to run
longer in order to maintain desired
temperatures.
Refrigerator or freezer gasket is dirty,
worn, cracked, or poorly fitted.
Thermostat is keeping the refrigerator
at a constant temperature.
This is normal. Refrigerator goes on and
off to keep the temperature constant.
27
Download from Www.Somanuals.com. All Manuals Search And Download.
Care and Maintenance
Occurrence
Possible cause
Solution
Refrigerator
compressor
does not run.
Thermostat is keeping the refrigerator
at a constant temperature.
This is normal. The refrigerator goes on
and off to keep the temperature constant.
Temperatures are too cold
Temperature in the
Set the freezer control to a warmer
setting until the freezer temperature is
satisfactory.
Freezer control is set too cold
freezer is too cold
but the refrigerator
temperature is
satisfactory.
Temperature in the
refrigerator is too
cold and the freezer
temperature
Refrigerator control is set too cold.
Refrigerator control is set too cold.
Set the refrigerator control to a
warmer setting
is satisfactory.
Food stored in
drawers freezes.
See above solution.
Temperatures are too warm
Freezer control is set too warm.
Temperatures in
the refrigerator
or freezer are
too warm.
Set the freezer or refrigerator control to
a colder setting until the freezer or
refrigerator temperature is satisfactory.
Refrigerator control is set too warm.
Refrigerator control has some effect on
freezer temperature.
Set the freezer or refrigerator control to a
colder setting until the freezer or
refrigerator temperature is satisfactory.
Doors are opened too frequently or too
long.
Warm air enters the refrigerator/ freezer
whenever the door is opened.
Open the door less often.
Door is slightly open.
Close the door completely.
Large amounts of warm or hot food
may have been stored recently.
Wait until the refrigerator or freezer
has a chance to reach its selected
temperature.
A refrigerator requires some hours to
cool down completely.
Refrigerator has recently been
disconnected for a period of time.
Temperature in the
refrigerator
Refrigerator control is set too warm.
Set the refrigerator control to a colder
setting.
is too warm but
the freezer
temperature is
satisfactory.
28
Download from Www.Somanuals.com. All Manuals Search And Download.
Care and Maintenance
Occurrence
Possible cause
Solution
Sound and noise
Louder sound
levels when
refrigerator is on.
Today’s refrigerators have increased
storage capacity and maintain more
even temperatures.
It is normal for sound levels to be higher.
Louder sound
levels when
compressor
comes on.
Refrigerator operates at higher pressures
during the start of the ON cycle.
This is normal. The sound will level off as
the refrigerator continues to run.
Vibrating or
rattling noise.
Floor is uneven or weak.
Refrigerator rocks on the floor when it is
moved slightly.
Be sure floor is level and solid and can
adequately support refrigerator.
Remove items.
Items placed on the top of the refrigerator
are vibrating.
Dishes are vibrating on the shelves in
the refrigerator.
It is normal for dishes to vibrate slightly.
Move dishes slightly.
Make sure refrigerator is level and firmly
set on floor.
Move refrigerator so that it does not
touch the wall or refrigerator.
Refrigerator is touching wall or cabinets.
Water/Moisture/Ice inside refrigerator
Moisture collects
on the inside walls
of the refrigerator.
The weather is hot and humid which
increases the rate of frost buildup
and internal sweating.
This is normal.
Door is slightly open.
See problem section opening/closing of
doors.
Open the door less often.
Door is opened too often or too long.
Water/Moisture/Ice outside refrigerator
Moisture forms
Weather is humid.
This is normal in humid weather.
When humidity is lower, the moisture
should disappear.
on the outside of
the refrigerator
or between doors.
This time, close the door completely.
Door is slightly open,causing cold air
from the inside the refrigerator to meet
warm air from the outside.
29
Download from Www.Somanuals.com. All Manuals Search And Download.
Care and Maintenance
Occurrence
Possible cause
Solution
Odors in refrigerator
Clean interior with sponge,warm water
and baking soda.
Interior needs to be cleaned.
Cover food completely.
Food with strong odor is in the refrigerator.
Some containers and wrapping materials
produce odors.
Use a different container or brand of
wrapping materials
.
Opening/Closing of doors/Drawers
Door(s) will not
close.
Move packages that keep door from
closing.
Food package is keeping door open.
Door(s) will not
close.
Door was closed too hard, causing other
door to open slightly.
Close both doors gently.
Refrigerator is not level. It rocks on the
floor when it is moved slightly.
Adjust the height adjusting screw.
Floor is uneven or weak.
Refrigerator rocks on the floor when it
is moved slightly.
Be sure floor is level and can adequately
support refrigerator.
Contact carpenter to correct sagging or
sloping floor.
Move refrigerator.
.
Refrigerator is touching wall or cabinets.
Drawers are
difficult to move.
Keep less food in drawer.
Food is touching shelf on top of the
drawer
Track that drawer slides on is dirty.
Clean drawer and track.
Dispenser
Dispenser will not
dispense ice
When the first supply of ice is dropped
into the bin, the dispenser should operate.
Ice storage bin is empty.
Turn the freezer control to a higher
setting so that ice cubes will be made.
When the first supply of ice is made,
the dispenser should operate.
Freezer temperature is set too warm.
Open household water line valve and
allow sufficient time for ice to be made.
When ice is made, dispenser should
operate.
Household water line valve is not open.
Refrigerator or freezer door is not closed.
Be sure both doors are closed.
30
Download from Www.Somanuals.com. All Manuals Search And Download.
Care and Maintenance
Occurrence
Possible cause
Solution
Ice has melted and frozen around auger
due to infrequent use, temperature
fluctuations and/or power outrages.
Remove ice storage bin, and thaw and
the contents. Clean bin, wipe dry and
replace in proper position.
Dispenser will
dispense
not
ice.
When new ice is made, dispenser should
operate.
Ice dispenser
is jammed.
Remove the ice cubes that are jamming
the dispenser.
Ice cubes are jammed between the ice
maker arm and back of the bin.
Ice cubes are frozen together.
Use the dispenser often so that cubes do
not freeze together.
Ice cubes that have been purchased or
made in some other way have been
used in the dispenser.
Only the ice cubes made by the ice maker
should be used with the dispenser.
Household water line valve is not open.
See problem Icemaker is not making
any ice.
Open household water line valve.
Dispenser will
not dispense
water.
Refrigerator or freezer door is not closed.
Water has been in the tank for too long.
Be sure both doors are closed.
Draw and discard 7 glasses of water
to freshen the supply. Draw and discard
an additional 7 glasses to completely rinse
out tank.
Water has an
odd taste
and/or odor.
Connect unit to cold water line which
supplies water to kitchen faucet.
Unit not properly connected to cold
water line.
This sound is normally made when automatically made ice is dropped into ice storage
bin. Volume may vary according to refrigerator’s location.
Sound of ice
dropping
This sound is normally made when ice maker is supplied with water after dropping
the automatically made ice.
Sound of water
supply
Other
Please thoroughly read Automatic icemaker and dispenser in this manual.
CUSTOMER ASSISTANCE NUMBERS:
ꢃTo Prove Warranty Coverage
Retain your Sales Receipt to prove date of purchase.
A copy of your Sales Receipt must be submitted at the time warranty service is provided.
ꢃTo Obtain Product, Customer or Service Assistance
Call Toll-free for Customer Service
Tel : 1-800-243-0000
ꢃTo Obtain Nearest Authorized Service Center
Call 1-800-243-0000, push option #1, 24 hours a day, 7days per week.
Please have your product type (Monitor, TV, VCR, MWO, Refrigerator) and ZIP code ready.
31
Download from Www.Somanuals.com. All Manuals Search And Download.
Your LG Refrigerator will be will repaired or replaced, at LG’s option, if it proves to be defective in material
or workmanship under normal use, during the warranty period ("Warranty Period") set forth below,
effective from the date ("Date of Purchase") of original consumer purchase of the product. This warranty
is good only to the original purchaser of the product and effective only when used in the United States,
including Alaska, Hawaii, and U.S. Territories.
WARRANTY PERIOD:
HOW SERVICE IS HANDLED:
REFRIGERATOR/FREEZER
In-Home Service (Except Model GR051):
Please retain dealer’s dated bill of sale or
delivery ticket as evidence of the Date of
Purchase for proof of warranty, and submit a
copy of the bill of sale to the service person at
the time warranty service is provided.
LABOR: One Year from the Date of Purchase.
PARTS: One Year from the Date of Purchase.
SEALED SYSTEM (Compressor, Condenser, and
Evaporator)
Please call 1-800-243-0000 and choose the
appropriate option to locate your nearest LG
Authorized Service Center. (Phones are
answered 24 hours a day, 365 days per year.)
LABOR: One Year from the Date of Purchase.
PARTS: Seven years from the Date of Purchase.
Replacement Units and Repair Parts are warranted
for the remaining portion of the original unit’s
warranty period.
THIS WARRANTY IS IN LIEU OF ANY OTHER WARRANTY, EXPRESS OR IMPLIED, INCLUDING
WITHOUT LIMITATION, ANY WARRANTY OF MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE. TO THE EXTENT ANY IMPLIED WARRANTY IS REQUIRED BY LAW, IT IS
LIMITED IN DURATION TO THE EXPRESS WARRANTY PERIOD ABOVE. NEITHER THE
MANUFACTURER NOR ITS U.S. DISTRIBUTOR SHALL BE LIABLE FOR ANY INCIDENTAL,
CONSEQUENTIAL, INDIRECT, SPECIAL, OR PUNITIVE DAMAGES OF ANY NATURE, INCLUDING
WITHOUT LIMITATION, LOST REVENUES OR PROFITS, OR ANY OTHER DAMAGE WHETHER
BASED IN CONTRACT, TORT, OR OTHERWISE. Some states do not allow the exclusion or limitation of
incidental or consequential damages or limitations on how long an implied warranty lasts, so the above
exclusion or limitation may not apply to you. This warranty gives you specific legal rights and you may
also have other rights that vary from state to state.
THIS LIMITED WARRANTY DOES NOT APPLY TO:
Service trips to your home to deliver, pick up, and/or install the product, instruct, or replace house fuses or
correct wiring, or correction of unauthorized repairs.
Damages or operating problems that result from misuse, abuse, operation outside environmental
specifications or contrary to the requirements of precautions in the Operating Guide, accident, vermin, fire,
flood, improper installation, acts of God, unauthorized modification or alteration, incorrect electrical current or
voltage, or commercial use, or use for other than intended purpose.
Repairs when your LG refrigerator is used in other than normal, single-family household use.
The cost of repair or replacement under these excluded circumstances shall be borne by the consumer.
CUSTOMER INTERACTIVE CENTER NUMBERS
Call 1-800-243-0000 (24 hours a day, 365 days per
To obtain Customer Assistance, Product Infor-
mation, or Dealer or Authorized Service Center
location:
year) and select the appropriate option from the menu.
TO CONTACT LG ELECTRONICS BY MAIL:
LG Customer Interactive Center
P. O. Box 240007
201 James Record Road
Huntsville, Alabama 35824
ATTN: CIC
Download from Www.Somanuals.com. All Manuals Search And Download.
Download from Www.Somanuals.com. All Manuals Search And Download.
|