Sony CDX CA400 User Manual
CDX-CA400/CA530X/CA580X  
SERVICE MANUAL  
US Model  
Canadian Model  
Ver 1.0 2001. 12  
CDX-CA400  
E Model  
CDX-CA530X/CA580X  
Photo: CDX-CA400  
• The tuner and CD sections have no adjustments.  
Model Name Using Similar Mechanism CDX-L300/L460X  
CD Drive Mechanism Type  
Optical Pick-up Name  
MG-393XA-121//K  
KSS-720A  
AUDIO POWER SPECIFICATIONS (US Model)  
POWER OUTPUT AND TOTAL HARMONIC DISTORTION  
23 watts per channel minimum continuous average power into  
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more  
than 5% total harmonic distortion.  
SPECIFICATIONS  
CD player section  
General  
Outputs  
Signal-to-noise ratio  
Frequency response  
Wow and flutter  
90 dB  
10 – 20,000 Hz  
Below measurable limit  
Audio outputs  
Power antenna relay control lead  
Power amplifier control lead  
Tone controls  
Bass ±10 dB at 20 Hz (CDX-CA400)  
Bass ±9 dB at 100 Hz (CDX-CA530X/CA580X)  
Treble ±10 dB at 20 kHz (CDX-CA400)  
Treble ±9 dB at 10 kHz (CDX-CA530X/CA580X)  
12 V DC car battery  
(negative ground)  
Approx. 178 × 50 × 177 mm  
(7 1/8 × 2 × 7 in.) (w/h/d)  
Tuner section  
FM  
Tuning range  
Antenna terminal  
87.5 – 107.9 MHz  
External antenna connector  
Power requirements  
Dimensions  
Intermediate frequency 10.7 MHz  
Usable sensitivity  
Selectivity  
Signal-to-noise ratio  
11 dBf  
75 dB at 400 kHz  
65 dB (stereo),  
68 dB (mono)  
Mounting dimensions Approx. 182 × 53 × 161 mm  
(7 1/4 × 2 1/8 × 6 3/8 in.) (w/h/d)  
Approx. 1.2 kg  
Mass  
Harmonic distortion at 1 kHz  
0.7% (stereo),  
(2 lb. 10 oz.)  
Parts for installation and connections (1 set)  
Front panel case (1)  
Card remote commander  
RM-X115 (CA400/CA580X)  
Supplied accessories  
0.5% (mono)  
Separation  
Frequency response  
33 dB at 1 kHz  
30 – 15,000 Hz  
AM  
Note  
Tuning range  
Antenna terminal  
530 – 1,710 kHz  
External antenna connector  
This unit cannot be connected to a digital preamplifier or an equalizer.  
Intermediate frequency 10.7 MHz/450 kHz  
Sensitivity 30 µV  
Design and specifications are subject to change without  
notice.  
Power amplifier section  
Outputs  
Speaker outputs  
(sure seal connectors)  
4 – 8 ohms  
Speaker impedance  
Maximum power output 50 W × 4 (at 4 ohms)  
FM/AM COMPACT DISC PLAYER  
9-873-433-01  
2001L0400-1  
© 2001. 12  
Sony Corporation  
e Vehicle Company  
Published by Sony Engineering Corporation  
CDX-CA400/CA530X/CA580X  
TABLE OF CONTENTS  
3. DIAGRAMS  
1. GENERAL  
Location of controls (CDX-CA400)........................................ 4  
Location of controls (CDX-CA530X/CA580X) ..................... 4  
Connections (CDX-CA400) .................................................... 5  
Connections (CDX-CA530X/CA580X).................................. 6  
3-1. IC Pin Description ............................................................. 13  
3-2. Block Diagram –CD Section–........................................... 15  
3-3. Block Diagram –Tuner Section– ....................................... 16  
3-4. Block Diagram –Display Section– .................................... 17  
3-5. Circuit Boards Location .................................................... 17  
3-6. Printed Wiring Boards –CD Mechanism Section–............ 18  
3-7. Schematic Diagram –CD Mechanism Section– ................ 20  
3-8. Printed Wiring Board –Main Section– .............................. 21  
3-9. Schematic Diagram –Main Section (1/2)– ........................ 22  
3-10. Schematic Diagram –Main Section (2/2)– ........................ 23  
3-11. Printed Wiring Board –Display Section– .......................... 24  
3-12. Schematic Diagram –Display Section–............................. 25  
2. DISASSEMBLY  
2-1. Panel (1) Assy, Sub ............................................................. 7  
2-2. CD Mechanism Block ......................................................... 8  
2-3. Main Board ......................................................................... 8  
2-4. Heat Sink ............................................................................. 9  
2-5. Chassis (T) Sub Assy .......................................................... 9  
2-6. Lever Section .................................................................... 10  
2-7. Servo Board....................................................................... 10  
2-8. Shaft Roller Assy .............................................................. 11  
2-9. Floating Block Assy .......................................................... 11  
2-10. Optical Pick-up Block ....................................................... 12  
4. EXPLODED VIEWS  
4-1. Chassis Section ................................................................. 28  
4-2. Front panel Section ........................................................... 29  
4-3. CD Mechanism Section (1) ............................................... 30  
4-4. CD Mechanism Section (2) ............................................... 31  
4-5. CD Mechanism Section (3) ............................................... 32  
5. ELECTRICAL PARTS LIST ........................................ 33  
EXTENSION CABLE AND SERVICE POSITION  
When repairing or servicing this set, connect the jig (extension cable)  
as shown below.  
• Connect the MAIN board (CNP701) and the SERVO board (CN1)  
with the extension cable (Part No. J-2502-062-1).  
MAIN BOARD CNP701  
SERVO BOARD CN1  
3
CDX-CA400/CA530X/CA580X  
SECTION 1  
GENERAL  
This section is extracted  
from instruction manual.  
(CDX-CA400)  
(CDX-CA530X/CA580X)  
(CDX-CA530X/CA580X)  
(CDX-CA400)  
4
CDX-CA400/CA530X/CA580X  
Connections (CDX-CA400)  
5
CDX-CA400/CA530X/CA580X  
Connections (CDX-CA530X/CA580X)  
6
CDX-CA400/CA530X/CA580X  
SECTION 2  
DISASSEMBLY  
Note : This set can be disassemble according to the following sequence.  
SET  
2-5. CHASSIS (T) SUB ASSY  
(Page 9)  
2-1. PANEL (1) ASSY, SUB  
(Page 7)  
2-6. LEVER SECTION 2-7. SERVO BOARD  
2-2. CD MECHANISM BLOCK  
(Page 8)  
(Page 10)  
(Page 10)  
2-8.  
2-9.  
SHAFT ROLLER ASSY  
(Page 11)  
2-3. MAIN BOARD  
(Page 8)  
FLOATING BLOCK ASSY  
(Page 11)  
2-4. HEAT SINK  
(Page 9)  
2-10. OPTICAL PICK-UP BLOCK  
(Page 12)  
Note : Follow the disassembly procedure in the numerical order given.  
2-1. PANEL (1) ASSY, SUB  
claws  
3 claw  
1 PTT 2.6x6  
4 claws  
2 PTT 2.6x6  
5 panel (1) assy, sub  
7
CDX-CA400/CA530X/CA580X  
2-2. CD MECHANISM BLOCK  
7 bracket (CD)  
5 CD mechanism block  
6 PTT 2.6x6  
2 PTT 2.6x6  
3
1 PTT 2.6x6  
4 CNP701  
2-3. MAIN BOARD  
3 screw (+BTT)  
5 MAIN board  
4 screws (+BTT)  
2 PTT 2.6x8  
1 PTT 2.6x8  
8
CDX-CA400/CA530X/CA580X  
2-4. HEAT SINK  
6 heat sink  
5 PTT 2.6x8  
4 PTT 2.6x8  
3 PTT 2.6x12  
2 PTT 2.6x8  
1 PTT 2.6x8  
2-5. CHASSIS (T) SUB ASSY  
2 P 2x3  
3 P 2x3  
1 Unsolder the  
4 chassis (T) sub assy  
lead wires.  
black  
red  
white  
9
CDX-CA400/CA530X/CA580X  
2-6. LEVER SECTION  
5 guide (disc)  
6 lever (R)  
3 tension spring (LR)  
7 lever (L)  
1 special screw  
2 IN SELF SW board  
4 claws  
2-7. SERVO BOARD  
7 SERVO board  
6 special screw  
5 special screws  
2 Removal the solders.  
8 connector  
1 CN3  
3 P 2x3  
4 loading motor assy  
optical pick-up block  
10  
CDX-CA400/CA530X/CA580X  
2-8. SHAFT ROLLER ASSY  
• When installing, take note of the positions  
arm (roller) and washers. (Fig. 1)  
3 retaing ring (RA)  
shaft retainer  
4 shaft retainer  
arm  
washer  
washer  
shaft retainer  
retaing ring (RA)  
arm  
Fig. 1  
5 shaft roller assy  
2 arm (roller)  
1 tension spring (RA)  
2-9. FLOATING BLOCK ASSY  
6 floating block assy  
7 compression spring (FL)  
1 tension spring (KF1)  
8 compression spring (FL)  
4 Fit lever (D) in the  
direction of the arrow.  
5 Turn loading ring in the  
direction of the arrow.  
2 damper (T)  
3 damper (T)  
11  
CDX-CA400/CA530X/CA580X  
2-10. OPTICAL PICK-UP BLOCK  
4 P 2x3  
1 P 2x3  
5 spring (feed), plate  
2 sled motor assy  
3 optical pick-up block  
6 shaft (feed) assy  
12  
CDX-CA400/CA530X/CA580X  
SECTION 3  
DIAGRAMS  
3-1. IC PIN DESCRIPTION  
• IC801 µPD780076GK-520-9ET (SYSTEM CONTROLLER)  
Pin No.  
1
Pin Name  
PH1  
I/O  
I
Pin Description  
PH1 detection input (Not used in this set.)  
2
D SW  
I
Down switch detection input  
Disc in switch detection input  
Loading motor drive output (Loading)  
Loading motor drive output (Eject)  
Line out mute control output  
Power amplifier mute control output  
PLL IC data input  
3
IN SW/PH2  
LM LD  
LM EJ  
I
4
O
O
O
O
I
5
6
ATT  
7
AATT  
8
PLL DI  
VSSO  
9
—
—
O
O
O
O
O
O
O
I
Ground pin  
10  
11  
12  
13  
14  
15  
16  
17  
18  
19  
20  
21  
22  
23  
24  
25  
26  
27  
28  
29  
30  
31  
32  
33  
34  
35  
36  
37  
38  
39  
40  
41  
42  
43  
44  
45  
46  
47  
48  
49  
50  
51  
VDDO  
PLL CLK  
PLL DO  
PLL CE  
BEEP  
Power supply pin (+5 V)  
PLL IC clock output  
PLL IC data output  
PLL IC chip enable output  
BEEP output of key beep, caution alarm  
Electric volume, LCD chip enable output  
Electric volume, LCD data output  
Electric volume, LCD clock output  
BUS interface serial input  
L V CE  
L V DO  
L V CLK  
BUS SI  
BUS SO  
BUS CLK  
BUS CK GEN  
AM ON  
FM ON  
VDD1  
O
I
BUS interface serial output  
BUS interface serial clock input  
BUS interface serial clock output  
Tuner AM power supply control output  
Tuner FM power supply control output  
Power supply pin (+5 V)  
O
O
O
—
—
I
AVSS  
Ground pin  
ST IND  
PH3  
FM stereo detection input  
I
PH3 detection input (Not used in this set.)  
S meter signal input  
S METER  
KEY0  
I
I
A/D key input 0  
KEY1  
I
A/D key input 1  
ROTARY (AD)  
DST SEL  
TEST  
I
Not used in this set.  
I
Destination select input (Connect to ground in this set.)  
Force test mode input  
I
AVREF  
LCD INH  
RESET  
XT2  
—
O
I
A/D converter power supply pin (+5 V)  
INHIBIT control output of LCD  
Reset input (“L”: reset detection)  
Sub clock output (32.768 kHz)  
Sub clock input (32.768 kHz)  
Connect to ground in this set.  
Master clock output (8.38 MHz)  
Master clock input (8.38 MHz)  
Ground pin  
O
I
XT1  
IC  
—
O
I
X2  
X1  
VSS1  
—
I
KEY ACK  
SIRCS  
Key acknowledge detection input  
Wireless remote control signal input  
Self switch detection input  
I
SELF SW  
BU IN  
I
I
Backup power supply detection input  
Front panel attachment detection input  
Illumination power supply control output  
External amplifier remote control output  
CD mechanism deck power supply control output  
CD DSP IC 16 MHz X’tal on/off control output  
NOSE  
I
ILL ON  
A REMO  
CDM ON  
XCD ON  
O
O
O
O
13  
CDX-CA400/CA530X/CA580X  
Pin No.  
52  
Pin Name  
SHIFT  
I/O  
—
O
O
O
O
I
Pin Description  
Not used in this set.  
53  
BUS ON  
SB RST  
PW ON  
X SO  
Enable output of bus IC  
Reset output of bus IC  
54  
55  
System power supply control output  
CD DSP IC serial data output  
56  
57  
X SI  
CD DSP IC serial data input  
58  
X SCK  
RFOK  
O
I
CD DSP IC serial clock output  
59  
CD servo IC RFOK signal input  
60  
CD RST  
ACC IN  
O
I
CD DSP IC reset control output  
61  
Accessory power supply detection input  
CD servo IC command/parameter discrimination signal output  
“L”: Command, “H”: Parameter  
62  
X AO  
O
63  
64  
STB  
O
I
CD servo IC data strobe signal output  
CD sled limit switch detection input  
L SW  
14  
CDX-CA400/CA530X/CA580X  
3-2. BLOCK DIAGRAM — CD SECTION —  
RF AMP,DIGITAL SERVO  
DIGITAL SIGNAL PROCESSOR  
IC1  
OPTICAL PICK-UP  
KSS-720A  
(Page 16)  
TUNER  
B
A
84  
SECTION  
LOUT  
ROUT  
D
A
SYSTEM CONTROL  
IC801(1/3)  
16  
12  
CDL  
D/A  
C
B
A
85  
82  
RF  
EQ  
EFM  
DEMOD  
CONV  
R-CH  
PACK  
TSTB  
52  
56  
55  
54  
DSUB CODE  
PROCESS  
C
TSCK  
TSI  
I-V  
CONV.  
D
83  
SI  
SO  
8
7
6
5
4
3
56 X_SO  
57 X_SI  
FORCUS  
ERROR  
SCK  
58  
63  
62  
60  
X_SCK  
STB  
I/F  
STB  
AO  
E
F
X A0  
E
F
87  
86  
RST  
TRACKING  
ERROR  
CD_RST  
SERVO  
CTL  
RFOK  
2
9
APC  
59  
RFOK  
PD  
PD  
LD  
97  
TUNER  
SECTION  
(Page 16)  
XTALEN  
OSC  
X EN  
LD  
DRIVE  
Q1  
B
A5V  
LD  
98  
62 63 64 65  
23  
24  
FOCUS/TRACKING COIL DRIVE,  
SLED/SPINDLE/LOADING MOTOR DRIVE  
IC2  
X1  
16.9344MHz  
FCS-  
FCS+  
FOCUS  
COIL  
DRIVE  
15  
16  
FD  
FOCUS  
COIL  
26  
2
D_SW  
SW1  
(DOWN)  
45 SELF_SW  
SW2  
TRK+  
TRK-  
TRACKING  
COIL  
(SELF)  
TD  
17  
18  
TRACKING  
COIL  
23  
DRIVE  
IN_SW  
L_SW  
3
SW3  
(DISC IN)  
64  
SW4  
(LIMIT)  
SL-  
IC902  
RESET  
SLED  
MOTOR  
DRIVE  
M
M
SD  
M902  
13  
14  
5
6
(SLED)  
SL+  
U_COM+5V  
RESET 36  
1
2
SP+  
SP-  
SPINDLE  
MOTOR  
DRIVE  
11  
12  
M901  
(SPINDLE)  
MD  
S901  
(RESET)  
LOAD  
EJECT  
LD-  
LOADING  
MOTOR  
DRIVE  
M
9
1
2
4
5
LM _LD  
LM_ EJ  
M903  
(LOADING)  
LD+  
10  
CD MECHANISM  
ON SWITCH  
Q905,906  
50  
CDM ON  
CD+5V  
• Signal path  
:CD  
A_5V  
REG  
D909  
Q910,D910  
CD ON  
SWITCH  
Q921  
AU_5V  
D_5V  
51 XCD_ON  
• R-ch is omitted due to  
same as L-ch.  
CD DRIVE  
+6V REG  
Q907,D908  
DR_6V  
BATT  
15  
15  
         
CDX-CA400/CA530X/CA580X  
3-3. BLOCK DIAGRAM — TUNER SECTION —  
PJ401  
-3  
L
BUS AUDIO IN  
-4  
-1  
-2  
R
R-CH  
R-CH  
L
AUDIO OUT REAR  
R
POWER AMP  
IC101  
ELECTRONIC VOLUME  
IC401  
CNP901  
1
9
FL+  
FL–  
15 BUS L  
23 BUS R  
5
3
A
FL OUT  
5
4
12  
11  
R-CH  
TUNER UNIT  
TU601  
CD  
CDL  
14 AU-L  
(Page 15)  
SECTION  
2
10  
RL+  
RL–  
9
7
CNJ601  
(ANTENNA)  
2
1
16  
17  
24  
18 L1  
17 L2  
RL OUT  
FM_ANT  
AM_ANT  
L-CH  
R-CH  
DET_OUT  
R-CH  
16 AUX-IN  
4
12  
FR+  
FR–  
R2  
21  
33  
34  
FR OUT  
RR OUT  
LINE MUTE  
Q102  
LINE MUTE  
Q101  
R-CH  
4
STBY  
22 MUTE  
LCD CE  
LCD DO  
LCD CLK  
CE  
DI  
2
1
R-CH  
DISPLAY  
SECTION  
(Page 17)  
3
RR+  
C
36 CL  
11  
RR–  
R-CH  
LINE MUTE  
CONTROL  
Q401,402  
SYSTEM CONTROL  
IC801 (2/3)  
PLL  
IC601  
LV CLK  
17  
16  
15  
LV DO  
LV CE  
6
ATT  
BEEP  
8
3
4
LCL  
AM_DX/LCL  
FM_DX/LCL  
14  
55  
7
PW ON  
A_ATT  
ACC IN  
ACC  
CHECK  
Q902  
11  
15  
16  
FM_VCO  
AM_VCO  
FM/AM_OSC  
7
61  
ACC  
6
PLL_DI  
8
D_OUT  
D_IN  
CK  
15  
33  
TEST  
4
5
3
PLL_DO  
PLL_CLK  
PLL_CE  
TEST  
12  
11  
13  
18  
19  
20  
6
14  
FM_CP  
VT  
AM_CP  
FM_VT  
AM_VT  
AMP/ANT  
REMOTE CONTROL  
Q911,917  
CE  
5
AMP REM  
ANT REM  
GND  
BATT  
6
8
19  
20  
2
OSC  
SEEK  
IFC  
OSC-IN  
IF_COUNT  
49  
A REMO  
10  
13  
11  
1
XO  
XI  
13  
•
FM/AM_VCC  
24  
MONO  
25  
COM+8V REG  
Q918,919,929,D923  
19  
17  
COM+8V  
X601  
10.25MHz  
FM POWER  
CONTROL  
Q605,606  
18  
19  
20  
21  
BUS SI  
BUS SO  
BUS CLK  
12 FM_VCC  
TU+8V  
F901  
10A  
S_METER  
SD/ST_IND  
21  
22  
28 S_METER  
26 SD_IND  
U_COM+5 V REG  
Q920,D930,D999  
U_COM+5V  
BATT  
18  
16  
BUS CK GEN  
+B (BATT)  
AM POWER  
CONTROL  
Q603,604  
53  
54  
BUS ON  
SB RST  
BUS INTERFACE  
IC802  
9
CNJ801  
AM_VCC  
BUS  
BU IN 46  
CONTROL IN  
23  
32 DST_SEL  
FM_ON  
8
BUS ON OUT  
1
6
4
22  
AM_ON  
8
9
11  
6
5
4
3
2
1
DATA OUT  
DATA IN  
CLK IN  
DATA IN/OUT  
CLK OUT  
7
D931  
CD  
X EN  
B
• Signal path  
SECTION  
12 BUS ON IN  
BATT  
TUNER ON  
CONTROL  
Q909,912  
(Page 15)  
13  
RST OUT  
:FM  
D932  
RST OUT  
2
3
BATT  
DET  
Q904,D907  
:AM  
BATT CHECK  
BATT  
10  
BATT  
BATT  
TUNER +8V  
REG  
Q913,D913  
:CD  
D854  
BATT  
TU+8V  
• R-ch is omitted due to  
same as L-ch.  
16  
16  
             
CDX-CA400/CA530X/CA580X  
3-4. BLOCK DIAGRAM — DISPLAY SECTION —  
3-5. CIRCUIT BOARDS LOCATION  
LCD DO  
LCD CLK  
LCD CE  
SERVO board  
TUNER  
SECTION  
(Page 16)  
C
IN SELF SW board  
SPEAKER board  
SYSTEM CONTROL  
IC801 (3/3)  
LCD DRIVE  
IC551  
1
|
23  
•
KEY 0  
KEY 0  
KEY 1  
29  
30  
DATA  
CLK  
CE  
62  
61  
60  
KEY MATRIX  
S501-519  
SEG1  
|
KEY 1  
SEG52 25  
|
53  
LCD  
LCD501  
INH  
LCD INH  
35  
57  
64  
COM1  
•
•
63  
COM2  
KEY ACK  
43  
REMOTE CONTROL  
RECEIVER  
tuner unit  
(TU601)  
IC552  
SIRCS  
ILL ON  
OUT  
VCC  
44  
48  
1
3
ILL B+  
DISPLAY board  
MAIN board  
SL SW board  
ILL POWER  
CONTROL  
Q914  
D561-587  
KEY  
(
(
)
ILLUMINATION  
ILL B+  
SWITCH  
Q915  
BATT  
• Waveforms  
LCD BACK  
)
LIGHT  
X2  
X1  
40  
41  
XT2  
XT1  
37  
38  
X801  
8.38MHz  
— Servo Board —  
(MODE: CD PLAY)  
X802  
32.768kHz  
PL551,552  
— Main Board —  
1
1
2Vp-p  
5Vp-p  
16.9344MHz  
32.768kHz  
(XTAL)  
(XT2)  
IC1  
IC801  
ej  
wd  
2
3
4
5
2
3Vp-p  
5Vp-p  
3.2msec  
8.38MHz  
(X2)  
IC801  
(PACK)  
IC1  
r;  
ts  
1.2Vp-p  
(RFO)  
IC1  
uj  
0V  
Approx. 100mVp-p  
(FEO)  
IC1  
oa  
0V  
Approx. 100mVp-p  
(TEO)  
IC1  
od  
17  
17  
                     
CDX-CA400/CA530X/CA580X  
3-6. PRINTED WIRING BOARDS — CD MECHANISM SECTION — • Refer to page 17 for Circuit Boards Location.  
12  
11  
10  
9
8
7
6
5
4
3
2
1
A
B
THIS NOTE IS COMMON FOR PRINTED WIRING  
BOARDS AND SCHEMATIC DIAGRAMS.  
(In addition to this, the necessary note is  
printed in each block.)  
for schematic diagram:  
• All capacitors are in µF unless otherwise noted. pF: µµF  
50 WV or less are not indicated except for electrolytics  
and tantalums.  
• All resistors are in Ω and / W or less unless otherwise  
specified.  
1
4
•
•
%
f
: indicates tolerance.  
: internal component.  
CN2  
• C : panel designation.  
Note:  
Note:  
C
Les composants identifiés par  
une marque 0 sont critiques  
pour la sécurité.  
Ne les remplacer que par une  
piéce portant le numéro  
spécifié.  
The components identi-  
fied by mark 0 or dotted  
line with mark 0 are criti-  
cal for safety.  
Replace only with part  
number specified.  
• A : B+ Line.  
• Power voltage is dc 14.4V and fed with regulated dc power  
supply from ACC and BATT cords.  
• Voltages are taken with a VOM (Input impedance 10 MΩ).  
Voltage variations may be noted due to normal produc-  
tion tolerances.  
• Waveforms are taken with a oscilloscope.  
Voltage variations may be noted due to normal produc-  
tion tolerances.  
D
E
F
G
H
I
• Circled numbers refer to waveforms.  
• Signal path.  
F
f
J
: FM  
: AM  
: CD  
for printed wiring boards:  
• X : parts extracted from the component side.  
• Y : parts extracted from the conductor side.  
•
•
•
x
: parts mounted on the conductor side.  
: Through hole.  
: Pattern from the side which enables seeing.  
a
(The other layer’s patterns are not indicated.)  
Caution:  
Pattern face side: Parts on the pattern face side seen from the  
(Side B)  
Parts face side: Parts on the parts face side seen from the  
(Side A) parts face are indicated.  
pattern face are indicated.  
SW1  
J
18  
18  
CDX-CA400/CA530X/CA580X  
1
2
3
4
5
6
7
8
9
10  
11  
12  
13  
14  
A
B
C
D
E
F
G
H
I
• Semiconductor  
Location  
Ref. No. Location  
IC1  
IC2  
E-7  
H-7  
TP78  
TP77  
C4  
TP7  
Q1  
C-6  
TP63  
TP62  
C1  
C5  
R30  
Q1  
TP82  
TP81  
TP84  
R29  
TP48  
TP66  
TP80  
C43  
TP83  
TP9  
TP11  
R3  
C6  
SW3  
TP60  
TP50  
FB7  
TP47  
TP12  
R5  
R22  
R26  
TP8  
TP64  
C9 C10  
C8  
TP10  
TP89  
(Page 21)  
TP51  
C11  
C14  
TP59  
FB6  
R21  
C15  
TP52  
TP56  
C18  
CN1  
C20  
C19  
C16  
TP70  
C40  
R18  
TP71  
C23  
R8  
C24  
TP22  
TP24  
TP25  
R9  
C17  
FB1  
C25  
R17  
TP72  
SW2  
TP58  
TP61  
TP23  
R19  
C41  
C45  
C34  
C27  
IC1  
TP76  
TP88  
TP74  
C29  
TP69  
TP68  
TP75  
C36  
TP34  
TP45  
TP35  
TP46  
C38  
TP49  
X1  
C35  
TP37  
TP38  
TP57  
R20  
TP36  
SW4  
TP44  
TP43  
TP41  
C26  
TP92  
FB3  
FB2  
TP39  
C44  
TP18  
FB4  
TP85  
TP55  
TP30  
TP21  
R24  
R25  
TP32  
TP73  
TP53  
TP6  
R7  
R6  
R15  
TP91  
TP90  
TP86  
TP87  
TP5  
C22  
IC2  
C37  
TP26  
C21  
TP29  
C30  
TP4  
TP19  
CN3  
TP20  
TP28  
TP3  
TP54  
TP17  
TP2  
TP1  
TP27  
TP16  
J
19  
19  
     
CDX-CA400/CA530X/CA580X  
• Refer to page 17 for Waveforms.  
3-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION — • Refer to page 26 for IC Block Diagrams.  
CN2  
Q1  
TP9 TP8  
C23  
C20  
FB4  
FB2  
C19  
C18  
C24  
R9  
R3 R26  
R29  
R30  
TP77  
TP78  
C35  
C4  
C1  
C5  
TP89  
C43  
C6  
C3  
TP79  
TP80  
C14  
C11  
TP81  
TP82  
TP83  
TP84  
TP45  
TP44  
TP43  
TP42  
TP41  
TP10  
C13  
R5  
TP40  
TP39  
TP38  
TP37  
SW4  
TP7  
C15  
C10  
C9  
IC1  
TP46  
TP36  
C38  
TP12  
TP11  
CN13  
CN3  
C8  
TP85  
TP35  
TP34  
M902  
C16  
C36  
M901  
IC B/D  
C25  
C29  
C44  
TP92  
CN1  
C40  
C17  
TP61  
TP76  
TP60  
TP75  
TP59  
TP74  
TP58  
TP73  
TP57  
TP72  
TP56  
TP71  
TP55  
TP70  
TP54  
TP69  
TP53  
TP68  
TP52  
SW1  
R18  
C34  
TP1  
TP5  
FB3  
R19  
R20  
R17  
TP6  
TP4  
TP2  
SW2  
SW3  
R7  
TP3  
(Page 22)  
TP30  
R15  
TP32  
TP66  
TP51  
TP21  
TP18  
R24  
R25  
R12  
R22 FB7  
R21 FB6  
TP50  
TP64  
TP49  
R14  
C22  
C21  
R10  
IC2  
TP90  
TP48  
TP63  
TP47  
TP62  
C30  
C37  
TP91  
TP17  
TP27  
TP29  
TP26  
TP28  
R6  
TP20  
TP16  
TP19  
TP87  
IC B/D  
M903  
TP86  
Note:  
• Voltage is dc with respect to  
ground under no-signal conditions.  
no mark : CD PLAY  
20  
20  
     
CDX-CA400/CA530X/CA580X  
3-8. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 17 for Circuit Boards Location.  
1
2
3
4
5
6
7
8
9
10  
11  
12  
13  
14  
15  
PJ401  
A
B
C
D
E
F
G
H
I
CNJ601  
CNJ801  
CNP901  
C672  
C671  
JW72  
JW70  
IC101  
C407  
R206  
R852  
C101  
C201  
JW69  
C426  
R208  
R222  
R221  
R121  
R105  
R106  
Q907  
R107  
JW68  
JW78  
C202  
JW64  
JW67  
R122  
JW36  
R108  
JW79  
JW80  
C851  
JW66  
JW65  
JW40  
R207  
JW63  
JW73  
JW74  
TH851  
JW62  
JW82  
C931  
D933  
JW39  
JW83  
JW81  
R906  
JW77  
L669  
C401  
JW75  
R408  
R407  
R854  
CP601  
JW60  
D401  
JW88  
C204  
C104  
C103  
JW34  
TU601  
L901  
C432  
R410  
D851  
D852  
JW89  
JW90  
D903  
JW58  
JW57  
JW35  
IC802  
R113  
C435  
C208  
C210  
C211  
C108  
D854  
D907  
R404  
JW149  
JW153  
C669  
C110  
C111  
C113  
R115  
IC401  
JW56  
JW148  
JW147  
JW146  
JW152  
JW151  
JW150  
R213  
JW55  
C213  
C603  
C604  
R907  
R851  
R911  
C214  
C907  
D910  
R444  
C847  
C701  
R809  
R215  
C215  
C116  
C216  
C904  
D908  
JW98  
C115  
L703  
C702  
C905  
C706  
R714  
C219  
JW31  
JW30  
JW102  
TH901  
JW28  
JW27  
C220  
JW99  
C120  
JW53  
JW52  
Q910  
C919  
Q909  
R716  
C707  
• Semiconductor Location  
JW100  
C703  
C119  
C218  
JW26  
JW29  
Ref. No. Location  
Ref. No. Location  
L701  
R602  
C605  
C606  
JR607  
JW51  
JW101  
D401  
D402  
D444  
D604  
D802  
D803  
D804  
D805  
D806  
D807  
D808  
D809  
D851  
D852  
D853  
D854  
D901  
D903  
D907  
D908  
D909  
D910  
D913  
D915  
D916  
D917  
D918  
D919  
D920  
D921  
D922  
D923  
D930  
D931  
D932  
D933  
D999  
D-4  
D-7  
E-6  
E-2  
I-4  
I-3  
I-3  
I-3  
I-3  
IC101  
IC401  
IC601  
IC801  
IC802  
IC902  
B-6  
E-4  
G-3  
H-7  
D-7  
I-9  
JW54  
JW50  
JR606  
L603  
R603  
R601  
D923  
R704  
C704  
R913  
R613  
C611  
Q917  
R612  
R934  
Q921  
C631  
JR110  
JW47  
JW46  
R706  
R707  
JW48  
R933  
C610  
C612  
C613  
R606  
R611  
C633  
C651  
D909  
R912  
JW103  
R708  
R709  
Q919  
JW104  
R620  
R622  
C614  
R607  
Q101  
Q102  
Q201  
Q202  
Q401  
Q402  
Q603  
Q604  
Q605  
Q606  
Q902  
Q904  
Q905  
Q906  
Q907  
Q909  
Q910  
Q911  
Q912  
Q913  
Q914  
Q915  
Q917  
Q918  
Q919  
Q920  
Q921  
Q929  
C-3  
C-3  
C-4  
C-4  
D-6  
E-6  
H-2  
H-4  
H-2  
H-3  
E-9  
E-10  
G-8  
H-8  
C-10  
F-9  
E-8  
H-8  
G-9  
G-10  
H-8  
H-9  
F-10  
F-8  
JW45  
R619  
JW105  
IC601  
R932  
Q913  
R917  
R710  
R711  
(Page 19)  
JW44  
CNP701  
JW107  
JW106  
I-3  
I-3  
I-3  
D913  
C913  
C620  
R609  
JW43  
JW42  
JW41  
C626  
Q912  
Q905  
R931  
R608  
X601  
C625  
D-9  
D-9  
D-9  
E-10  
D-9  
D-8  
E-10  
E-10  
G-10  
E-7  
G-10  
D-6  
D-6  
D-6  
D-6  
B-7  
B-7  
C-6  
C-5  
F-8  
H-9  
I-4  
JW108  
R604  
R628  
C848  
C914  
Q920  
Q915  
D999  
R930  
C623  
R849  
C909  
R848  
R847  
R810  
Q911  
L604  
R605  
IC801  
R811  
R812  
JW12  
D930  
R845  
R846  
R844  
JW11  
R919  
JW112  
X801  
C608  
JW10  
JW9  
R617  
R840  
R813  
JW122  
JW8  
JW7  
D931  
C810  
R814  
R920  
R835  
JW3  
C801  
JW4  
R923  
C916  
JR903  
C809  
R819  
JW117  
G-8  
H-9  
F-9  
CNP801  
S901  
J
H-4  
D-8  
G-10  
F-8  
(Page 24)  
21  
21  
               
CDX-CA400/CA530X/CA580X  
3-9. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 17 for Waveforms.  
IC802  
R853  
R852  
R851  
Q907  
Q919  
TH901  
R933  
Q910  
D854  
Q906  
D909  
Q918  
Q905  
R912  
Q917  
R905  
R932  
JR929  
R913  
Q921  
R934  
C919  
Q904  
R911  
Q929  
Q911  
C905  
D923  
D907  
C907  
R714  
R716  
C706  
C707  
TH851  
R821  
CNJ801  
X802  
C801  
R408  
C802  
X801  
R407  
C869  
D853  
D852  
D930  
C909  
Q920  
R854  
(Page 23)  
C851  
D851  
R931  
R930  
R819  
D999  
R815  
R814  
R813  
Q909  
C847  
L703  
Q912  
R840  
C810  
R917  
IC801  
Q913  
R918  
(Page  
20)  
C913  
D913  
C701  
R844  
CNP701  
R845  
R846  
R812  
C914  
C846  
L701  
C702  
L702  
R707  
C916  
C703  
R920  
R919  
Q914  
Q915  
C704  
IC902  
R704  
R705  
R706  
R809  
R712  
R711  
R710  
JR903  
S901  
R709  
R708  
C915  
D931  
D932  
R922  
R923  
CNP801  
R824  
JR904  
R835  
(Page 25)  
Note:  
• Voltage is dc with respect  
to ground under no-signal  
(detuned) condition.  
no mark : FM  
C809  
(
) : AM  
<
> : CD PLAY  
22  
22  
           
CDX-CA400/CA530X/CA580X  
3-10. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 26 for IC Block Diagrams.  
R105  
R206  
L901  
C901  
C931  
D901  
D933  
R109  
C103  
C205  
C105  
CNP901  
Q101  
Q102  
R107  
R108  
C401  
R401  
C671  
R121  
PJ401  
F901  
C121  
C221  
R122  
R222  
IC101  
C104  
R110  
R209  
R221  
R106  
R205  
D922  
D444  
C201  
C202  
C102  
C101  
C203  
C204  
Q201  
Q202  
Q401  
R207  
R208  
R444  
D921  
D920  
D919  
D917  
CNJ601  
R210  
R410  
D402  
D918  
D915  
C432  
CP601  
D916  
C672  
TU601  
R901  
C904  
R908  
R906  
Q402  
L669  
Q902  
C407  
C426  
L601  
C669  
R404  
R909 R907  
D903  
C603  
C604  
D401  
IC B/D  
IC401  
R601  
C619  
JR110  
IC B/D  
R612  
R606  
R609  
C609  
Note:  
C605  
C435  
C611  
• Voltage is dc with respect to ground under  
no-signal (detuned) condition.  
no mark : FM  
(
<
IC601  
R613  
R611  
C208  
C211  
C610  
L603  
C612  
C613  
C108  
R213  
C210  
R602  
R603  
C606  
C110  
R113  
) : AM  
> : CD  
C111  
C113  
R215  
R619  
C631  
C633  
C213  
C214  
R115  
C115  
JR605  
C615  
C614  
C114  
C215  
C216  
R607  
R608  
C217  
C220  
C116  
C117  
C618  
C617  
C620  
C621  
JR606  
(Page22)  
C120  
R610 C626  
R620  
R622  
C218  
C219  
C622  
C623  
C650  
C119  
C625  
L604  
C624  
X601  
C651  
R605  
R604  
C848  
C652  
C118  
JR607  
R628  
C608  
Q605  
Q603  
R618  
R617  
R614  
JR603  
R616  
R615  
Q606  
C842  
Q604  
C627  
D604  
C841  
23  
23  
         
CDX-CA400/CA530X/CA580X  
3-11. PRINTED WIRING BOARD — DISPLAY SECTION — • Refer to page 17 for Circuit Boards Location.  
1
2
3
4
5
6
7
8
9
10  
11  
12  
13  
14  
A
B
C
D
E
F
G
H
I
R554  
D555  
D567  
IC552  
D582  
D573  
D570  
D571  
D575  
D574  
D577  
D576  
D578  
D564  
D583  
D568  
D585  
D572  
D579  
D569  
D561  
D584  
D565  
D566  
D563  
D580  
D586  
D587  
D562  
D581  
S504  
S501  
JR503  
S505  
S511  
R502  
LCD501  
S513  
S506  
R513  
PL552  
D556  
S503  
PL551  
D551  
S514  
S512  
R511  
S510  
R515  
JR506  
S502  
D553  
R517  
D554  
S517  
CNP552  
JR507  
S516  
R516  
R519  
R518  
S515  
S518  
S519  
S509  
S508  
S507  
• Semiconductor Location  
Ref. No. Location Ref. No. Location  
Ref. No. Location  
Ref. No. Location  
(Page 21)  
D551  
D553  
D554  
D555  
D556  
D561  
D562  
D563  
D564  
G-5  
H-5  
H-6  
A-13  
G-5  
C-1  
D-1  
C-3  
B-2  
D565  
D566  
D567  
D568  
D569  
D570  
D571  
D572  
D573  
C-2  
C-2  
A-1  
B-1  
C-1  
A-5  
A-4  
B-3  
A-8  
D574  
D575  
D576  
D577  
D578  
D579  
D580  
D581  
D582  
A-7  
A-6  
A-9  
A-10  
A-11  
B-12  
C-12  
D-13  
B-13  
D583  
D584  
D585  
D586  
D587  
B-14  
C-14  
C-13  
C-13  
C-14  
IC551  
IC552  
G-8  
A-13  
24  
24  
     
CDX-CA400/CA530X/CA580X  
3-12. SCHEMATIC DIAGRAM — DISPLAY SECTION —  
D551  
R552  
C552  
C551  
R551  
D556  
C553  
R554  
CNP551  
CNP552  
R555  
D555  
D567  
D570  
D571  
D573  
D574  
D575  
D576  
D577  
D578  
D579  
D580  
D582  
PL551  
D561  
D562  
D563  
D564  
D585  
D586  
D587  
JR507  
JR508  
IC552  
IC551  
JR505  
(Page 22)  
D565  
D566  
D568  
D569  
D583  
D584  
PL552  
D553  
D572  
D581  
JR506  
S501  
JR503  
R501  
R502  
R503  
S502  
S503  
S511  
S512  
R511  
R512  
R513  
S504  
S505  
R504  
R505  
LCD501  
S513  
R514  
R515  
S514  
S515  
R506  
S506  
R516  
R517  
R507  
R508  
S507  
S508  
S516  
S517  
R509  
R510  
R518  
R519  
S509  
S510  
S518  
S519  
Note:  
• Voltage is dc with respect to ground under no-signal  
(detuned) condition.  
no mark : FM  
25  
25  
     
CDX-CA400/CA530X/CA580X  
• IC BLOCK DIAGRAMS  
IC1 µPD63711GC-8EU  
IC2 BA5810FP-E2  
BIAS  
FWD  
REV  
28  
1
75  
74  
73  
72 71 70 69 68  
67  
66  
65  
64  
63  
62  
61 60 59  
58  
57  
56  
55  
54  
53  
52  
51  
LOADING PRE  
FWD REV  
2
OPIN4+  
OPIN4–  
27  
26  
–
MICROCOMPUTER INTERFACE  
AGCI  
RFO  
EQ2  
EQ1  
RF-  
AGND  
A
C2D3  
C2D2  
C2D1  
C1D2  
C1D1  
76  
77  
78  
79  
80  
81  
82  
83  
84  
85  
86  
87  
88  
89  
90  
91  
92  
93  
94  
EFM  
50  
49  
48  
47  
46  
LDCONT  
PS  
X3  
3
4
COMPARATOR  
POWER  
SAVE  
CD-TEXT DECODER  
OPOUT4  
25  
EFM  
D/A  
IN1  
IN2  
5
6
OPIN3+  
OPIN3–  
24  
23  
SUB-CODE PROCESSOR  
–
16K  
SRAM  
MEMORY  
PROCESSOR  
AUTO GAIN  
FD/TD/SD/MD  
CONTROLLER  
CONTROLLER  
PREVCC  
(PRE.LOADING)  
+
+
DGND  
PLCK  
45  
44  
OPOUT3  
MUTE  
22  
21  
DIGITAL PLL  
ADDER  
PREVCC  
POWVCC  
7
8
EFM DEMODULATOR  
TIMING GENERATOR  
FEOFS  
TEOFS  
POWVCC12  
(CH1.CH2)  
MIRR/WFCK  
43  
C
SVDRAM  
CH1-4  
MUTE  
+
+
SVCRAM  
ROM  
MULTIPLIER  
SVROM  
B
RFCK  
42  
41  
40  
39  
38  
37  
36  
35  
34  
33  
32  
31  
30  
29  
RF  
POWVCC34  
(CH3,CH4)  
D
LOCK  
DVDD  
TSOI  
DECODER  
AMP BLOCK  
VOL–  
9
F
POWVCC  
GND  
20  
19  
EFM  
E
VOL+  
10  
CLV  
AVDD  
REFOUT  
FE-  
C16M  
DGND  
TX  
10k  
PROCESSOR  
10k  
10k  
10k  
–
–
–
–
VO2–  
VO3–  
11  
12  
18  
17  
LEVEL  
SHIFT  
DIGITAL  
AUDIO  
INTERFACE  
LEVEL  
SHIFT  
SWITCH  
DEFECT  
VO2+  
VO3+  
DEFECT  
COMPARATOR  
10k  
10k  
10k  
10k  
10k  
10k  
D/A  
10k  
10k  
FEO  
TE-  
HOLD/WDCK  
LRCK  
LRCKIN  
SCKO  
SCKIN  
DOUT  
DIN  
INTERFACE  
CIRCUIT  
FOK  
A3T  
RFENV  
MIRENV  
–
–
–
–
VO1–  
VO4–  
13  
14  
16  
15  
LEVEL  
SHIFT  
LEVEL  
SHIFT  
TEO  
TE2  
DE-EMPHASIS CIRCUIT  
VO1+  
VO4+  
MIRR  
TRACKING  
REGISTER  
10k  
10k  
10k  
10k  
FEO  
TEO  
TEC 95  
FOCUS  
REGISTER  
OCTUPLED  
OVERSAMPLING DIGITAL FILTER  
AGND  
96  
97  
COMPARATOR  
PD  
NOISE SHAVER NOISE SHAVER  
OUTPUT BUFFER OUTPUT BUFFER  
LD 98  
PN 99  
28 FLAG  
EMPH  
DVDD  
27  
26  
AVDD  
100  
MICROCOMPUTER INTERFACE  
SCF  
OSC  
IC601 TB2118F-EL-S  
1
2
3
4
5
6
7
8
9
10  
11  
12  
13  
14 15 16 17 18  
19  
20  
21 22 23  
24  
25  
OSCILLATOR  
XO  
24 XI  
1
A-GND  
23  
22 REG  
REGULATOR  
2
OSC  
ON/OFF  
BUFFER  
SEEK/RECP  
VCC  
21 VCC  
REFERENCE  
DIVIDER  
AM_CP  
20  
–
19 VT  
PHASE  
COMPARATOR  
SEEK/RECP  
40BIT SHIFT  
REGISTER  
–
18 FM_CP  
17 D-GND  
CE  
D_IN  
CK  
3
4
5
6
18BIT  
18BIT  
SERIAL  
INTERFACE  
12BIT  
PROGRAMMABLE  
COUNTER  
4BIT SWALLOW  
COUNTER  
PRESCALLER  
D_OUT  
AMP  
AMP  
AM_VCO  
16  
SR  
7
8
LCL  
15 FM_VCO  
I/O  
PORT  
I/O-2  
SEEK  
9
14 VDD  
22BIT  
VDD  
AMP  
10  
11  
20BIT  
IF COUNTER  
OUTPUT  
PORT  
IFC  
13  
MONO  
VDD2  
VDD2  
12  
26  
26  
     
CDX-CA400/CA530X/CA580X  
IC401 LC75421M-TLM-E  
DI  
CE  
1
CL  
36  
35  
2
3
VDD  
VSS  
LROUT  
LFOUT  
RROUT  
RFOUT  
4
5
34  
33  
+
+
+
+
CCB  
INTERFACE  
LFIN  
RFIN  
6
7
32  
31  
ROUT  
LOUT  
+
+
+
+
+
+
LSB  
RSB  
8
9
30  
29  
LBASS2  
RBASS2  
CONTROL  
CIRCUIT  
LOGIC  
CIRCUIT  
CONTROL  
CIRCUIT  
LBASS1  
RBASS1  
10  
28  
LVREF  
RVREF  
LTRE  
LIN  
RTRE  
RIN  
11  
12  
13  
27  
26  
+
+
LSELO  
25 RSELO  
L5  
L4  
14  
15  
24  
23  
22  
R5  
R4  
R3  
L3 16  
L2  
17  
21  
R2  
–
–
L1 18  
20 R1  
19  
VREF  
27  
 
CDX-CA400/CA530X/CA580X  
SECTION 4  
EXPLODED VIEWS  
NOTE:  
• The mechanical parts with no reference  
number in the exploded views are not supplied.  
• Items marked “*” are not stocked since  
they are seldom required for routine service.  
Some delay should be anticipated  
when ordering these items.  
• -XX and -X mean standardized parts, so  
they may have some difference from the  
original one.  
• Color Indication of Appearance Parts  
Example :  
The components identified by  
mark 0 or dotted line with mark  
0 are critical for safety.  
Replace only with part number  
specified.  
KNOB, BALANCE (WHITE) ... (RED)  
R
R
Parts Color Cabinet’s Color  
• Accessories are given in the last of this  
parts list.  
Les composants identifiés par une  
marque 0 sont critiques pour  
la sécurité.  
Ne les remplacer que par une piéce  
portant le numéro spécifié.  
4-1. CHASSIS SECTION  
3
5
MG-393XA-121//K  
#1  
#2  
4
#2  
#2  
6
#3  
10  
#2  
11  
#2  
2
#2  
9
7
8
TU601  
F901  
12  
6
13  
#1  
#1  
#1  
15  
1
#1  
14  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
* 1  
2
3
3-224-612-01 CHASSIS (CD)  
3-224-309-21 COVER  
1-776-206-21 CORD (WITH CONNECTOR) (POWER)  
3-024-285-01 CUSHION (RUBBER)  
11  
* 12  
13  
3-041-261-11 BRACKET (TR)  
3-048-259-01 SHEET (E)  
X-3380-594-3 LOCK ASSY (S)  
* 4  
14  
X-3381-269-1 PANEL (1) ASSY, SUB  
* 5  
3-041-173-11 BRACKET (CD)  
15  
3-231-472-01 SCREW (+B 2X4)  
6
7
8
3-922-535-11 SCREW (+BTT)  
A-3283-245-A MAIN BOARD, COMPLETE  
3-236-922-01 HEAT SINK  
3-019-565-01 BRACKET (IC)  
1-683-830-11 SPEAKER BOARD  
F901  
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A  
TU601 A-3220-835-A TUNER UNIT (TUX-010)  
#1  
#2  
#3  
7-685-792-09 SCREW +PTT 2.6X6 (S)  
7-685-793-09 SCREW +PTT 2.6X8 (S)  
7-685-795-09 SCREW +PTT 2.6X12 (S)  
* 9  
10  
28  
CDX-CA400/CA530X/CA580X  
4-2. FRONT PANEL SECTION  
69  
70  
#4  
67  
LCD501  
71  
#4  
72  
68  
66  
61  
60  
not supplied  
(DISPLAY board)  
65  
64  
62  
55  
63  
54  
53  
52  
59  
58  
57  
56  
51  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
51  
51  
51  
52  
53  
X-3381-640-1 PANEL (S) ASSY, FRONT (CA400)  
X-3381-641-1 PANEL (S) ASSY, FRONT (CA530X)  
X-3381-642-1 PANEL (S) ASSY, FRONT (CA580X)  
3-236-909-01 BUTTON (OFF)  
63  
64  
* 65  
66  
3-236-906-01 BUTTON (SEL)  
3-236-921-01 PLATE (LCD), GROUND  
3-229-751-01 SHEET (LCD.UP)  
3-236-920-01 SHEET (LCD), DIFFUSION  
X-3381-357-1 HOLDER (LCD) ASSY  
3-236-912-01 BUTTON (EJECT)  
67  
54  
55  
56  
57  
58  
3-236-908-01 BUTTON (MBP)  
3-236-910-01 BUTTON (1-6)  
3-236-905-01 BUTTON (D-BASS)  
X-3381-356-1 RING (SEEK) ASSY  
3-236-904-01 BUTTON (SOURCE)  
68  
69  
70  
70  
70  
3-236-902-01 PANEL, FRONT BACK  
X-3380-054-2 CASE ASSY (for FRONT PANEL)  
A-3337-073-A PANEL COMPLETE ASSY, FRONT (CA400)  
A-3337-074-A PANEL COMPLETE ASSY, FRONT (CA530X)  
A-3337-075-A PANEL COMPLETE ASSY, FRONT (CA580X)  
59  
60  
61  
62  
X-3381-355-1 RING (VOL) ASSY  
3-236-911-01 BUTTON (RELEASE)  
3-229-774-01 SPRING (RELEASE)  
3-236-907-01 BUTTON (MODE)  
* 71  
72  
3-227-293-01 SHEET (LCD)  
3-236-926-01 CUSHION (LCD)  
LCD501 1-804-626-11 DISPLAY PANEL, LIQUID CRYSTAL  
#4 7-685-106-19 SCREW +P 2X10 TYPE2 NON-SLIT  
29  
CDX-CA400/CA530X/CA580X  
4-3. CD MECHANISM SECTION (1)  
(MG-393XA-121//K)  
102  
#8  
#8  
104  
103  
107  
109  
101  
116  
115  
114  
106  
114  
105  
111  
C
105  
113  
117  
C
110  
#9  
M903  
#7  
112  
#7  
108  
#8  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
101  
102  
103  
104  
105  
1-683-283-11 IN SELF SW BOARD  
3-040-039-02 CHASSIS (T)  
3-040-038-01 SPRING (LR), TENSION  
3-040-050-01 LEVER (L)  
3-040-022-01 RETAINER (ROLLER), SHAFT  
112  
113  
114  
115  
116  
3-221-779-01 BRACKET (MOTOR)  
3-040-034-01 SPRING (RA), TENSION  
3-040-042-01 WASHER  
3-043-880-01 RING (RA), RETAINING  
3-044-206-11 SCREW, SPECIAL  
106  
107  
108  
109  
110  
3-040-044-01 ROLLER (S)  
3-040-067-01 LEVER (R)  
A-3301-980-A SHAFT ROLLER ASSY  
3-040-037-01 GUIDE (DISC)  
3-040-040-02 ARM (ROLLER)  
117  
M903  
#7  
#8  
#9  
1-683-284-11 FLEXIBLE BOARD  
A-3315-039-A MOTOR SUB ASSY, LO (LOADING)  
7-628-253-00 SCREW, SPECIAL  
7-627-553-37 SCREW, PRECISION +P 2X3 TYPE3  
7-627-553-17 SCREW, PRECISION +P 2X2 TYPE3  
111  
A-3283-233-A SERVO BOARD, COMPLETE  
30  
CDX-CA400/CA530X/CA580X  
4-4. CD MECHANISM SECTION (2)  
(MG-393XA-121//K)  
154  
151  
156  
157  
157  
D
158  
164  
160  
not supplied  
162  
153  
155  
163  
161  
D
159  
152  
152  
152  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
151  
152  
153  
154  
155  
3-040-025-01 ARM, CHUCKING  
3-040-031-01 DAMPER (T)  
3-040-056-01 LEVER (D)  
3-040-024-01 RETAINER (DISC)  
3-040-054-01 WHEEL (LW), WORM  
158  
159  
160  
161  
162  
3-040-033-01 SPRING (KF1), TENSION  
A-3307-422-A CHASSIS (M) COMPLETE ASSY  
3-040-059-01 SPRING (TR), TENSION  
3-040-057-01 LEVER (LOCK)  
3-040-058-01 GEAR (MDL)  
156  
157  
3-040-026-01 SPRING (CH), TENSION  
3-040-032-01 SPRING (FL), COMPRESSION  
163  
164  
3-040-052-01 WHEEL (U), WORM  
3-040-051-02 LEVER (TR)  
31  
CDX-CA400/CA530X/CA580X  
4-5. CD MECHANISM SECTION (3)  
(MG-393XA-121//K)  
201  
M901  
207  
202  
M902  
203  
208  
#10  
209  
210  
#8  
204  
205  
206  
#11  
The components identified by Les composants identifiés par une  
mark 0 or dotted line with mark marque 0 sont critiques pour  
0 are critical for safety.  
Replace only with part number Ne les remplacer que par une piéce  
specified. portant le numéro spécifié.  
la sécurité.  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
201  
202  
203  
204  
205  
X-3378-480-1 CHASSIS (OP) ASSY (including M901)  
3-040-029-01 SPRING (SL), TORSION  
3-040-045-01 BASE (DRIVING)  
3-040-194-01 GEAR (MIDWAY)  
A-3301-983-A SHAFT (FEED) ASSY  
208  
209  
0210  
M902  
#8  
1-683-282-11 SL SW BOARD  
3-909-607-01 SCREW  
8-820-103-11 PICK-UP, OPTICAL KSS-720A/C-RP  
A-3301-985-A MOTOR ASSY, SLED (SLED)  
7-627-553-37 SCREW, PRECISION +P 2X3 TYPE3  
206  
207  
3-040-030-01 SPRING (FEED), PLATE  
1-823-641-11 CABLE, FLEXIBLE FLAT (6 CORE)  
#10  
#11  
7-627-850-28 SCREW, PRECISION +P 1.4X3  
7-685-780-01 SCREW +PTT 2X3 (S)  
32  
CDX-CA400/CA530X/CA580X  
DISPLAY  
SECTION 5  
ELECTRICAL PARTS LIST  
NOTE:  
• Due to standardization, replacements in  
the parts list may be different from the  
parts specified in the diagrams or the  
components used on the set.  
• -XX and -X mean standardized parts, so  
they may have some difference from the  
original one.  
• Items marked “*” are not stocked since  
they are seldom required for routine service.  
Some delay should be anticipated  
when ordering these items.  
• SEMICONDUCTORS  
In each case, u : µ, for example:  
uA.. : µA.. uPA.. : µPA..  
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..  
• CAPACITORS  
The components identified by  
mark 0 or dotted line with mark  
0 are critical for safety.  
Replace only with part number  
specified.  
Les composants identifiés par une  
marque 0 sont critiques pour  
la sécurité.  
• RESISTORS  
All resistors are in ohms.  
METAL:Metal-film resistor.  
METAL OXIDE: Metal oxide-film resistor.  
F:nonflammable  
uF : µF  
• COILS  
uH : µH  
Ne les remplacer que par une piéce  
portant le numéro spécifié.  
When indicating parts by reference  
number, please include the board.  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
DISPLAY BOARD  
**************  
D569  
D570  
D570  
D571  
D571  
8-719-078-21 LED SML-310PTT86 (SEEK3) (CA400)  
8-719-038-05 LED CL-190FG-CD-T (6) (CA400)  
8-719-053-09 LED SML-310VTT86 (6) (CA530X/CA580X)  
8-719-038-05 LED CL-190FG-CD-T (SENS) (CA400)  
8-719-053-09 LED SML-310VTT86 (SENS)  
(CA530X/CA580X)  
*
*
3-227-293-01 SHEET (LCD)  
3-229-751-01 SHEET (LCD.UP)  
3-236-920-01 SHEET (LCD), DIFFUSION  
3-236-921-01 PLATE (LCD), GROUND  
X-3381-357-1 HOLDER (LCD) ASSY  
D572  
D572  
D573  
D573  
8-719-053-08 LED SML-310DTT86 (BTM) (CA530X/CA580X)  
8-719-053-09 LED SML-310VTT86 (BTM) (CA400)  
8-719-038-05 LED CL-190FG-CD-T (3/REP) (CA400)  
8-719-053-09 LED SML-310VTT86 (3/REP)  
(CA530X/CA580X)  
< CAPACITOR >  
C551  
C552  
C553  
1-164-315-11 CERAMIC CHIP 470PF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-162-927-11 CERAMIC CHIP 100PF  
5%  
5%  
50V  
25V  
50V  
D574  
D574  
8-719-038-05 LED CL-190FG-CD-T (4/SHUF) (CA400)  
8-719-053-09 LED SML-310VTT86 (4/SHUF)  
(CA530X/CA580X)  
< CONNECTOR >  
D575  
D575  
D576  
D576  
8-719-038-05 LED CL-190FG-CD-T (5) (CA400)  
8-719-053-09 LED SML-310VTT86 (5) (CA530X/CA580X)  
8-719-038-05 LED CL-190FG-CD-T (2/DISC +) (CA400)  
8-719-053-09 LED SML-310VTT86 (2/DISC +)  
(CA530X/CA580X)  
* CNP551 1-779-131-11 PIN, CONNECTOR 2P  
CNP552 1-794-312-21 PIN, CONNECTOR 12P  
< DIODE >  
D551  
D553  
D554  
D555  
D556  
8-719-073-15 DIODE SDZ5V1  
8-719-067-70 DIODE SDZ6V2  
8-719-068-68 DIODE SDZ6V2WA  
8-719-073-15 DIODE SDZ5V1  
8-719-067-70 DIODE SDZ6V2  
D577  
D577  
8-719-038-05 LED CL-190FG-CD-T (1/DISC –) (CA400)  
8-719-053-09 LED SML-310VTT86 (1/DISC –)  
(CA530X/CA580X)  
8-719-038-05 LED CL-190FG-CD-T (ATT) (CA400)  
8-719-053-09 LED SML-310VTT86 (ATT) (CA530X/CA580X)  
8-719-053-08 LED SML-310DTT86 (DSPL)  
(CA530X/CA580X)  
D578  
D578  
D579  
D561  
8-719-053-09 LED SML-310VTT86 (SEEK2)  
(CA530X/CA580X)  
D561  
D562  
D562  
D563  
8-719-078-21 LED SML-310PTT86 (SEEK2) (CA400)  
8-719-053-09 LED SML-310VTT86 (Z) (CA530X/CA580X)  
8-719-038-05 LED CL-190FG-CD-T (Z) (CA400)  
D579  
D580  
D580  
D581  
D581  
8-719-053-09 LED SML-310VTT86 (DSPL) (CA400)  
8-719-053-08 LED SML-310DTT86 (SEL) (CA530X/CA580X)  
8-719-053-09 LED SML-310VTT86 (SEL) (CA400)  
8-719-038-05 LED CL-190FG-CD-T (MODE) (CA400)  
8-719-053-09 LED SML-310VTT86 (MODE)  
(CA530X/CA580X)  
8-719-053-08 LED SML-310DTT86 (MBP) (CA530X/CA580X)  
D563  
D564  
8-719-053-09 LED SML-310VTT86 (MBP) (CA400)  
8-719-053-09 LED SML-310VTT86 (SEEK5)  
(CA530X/CA580X)  
8-719-078-21 LED SML-310PTT86 (SEEK5) (CA400)  
8-719-053-09 LED SML-310VTT86 (DSO) (CA530X/CA580X)  
8-719-078-21 LED SML-310PTT86 (DSO) (CA400)  
D582  
8-719-053-09 LED SML-310VTT86 (VOL3)  
(CA530X/CA580X)  
8-719-078-21 LED SML-310PTT86 (VOL3) (CA400)  
8-719-053-09 LED SML-310VTT86 (VOL4)  
(CA530X/CA580X)  
D564  
D565  
D565  
D582  
D583  
D566  
8-719-053-09 LED SML-310VTT86 (SEEK1)  
(CA530X/CA580X)  
8-719-078-21 LED SML-310PTT86 (SEEK1) (CA400)  
8-719-038-05 LED CL-190FG-CD-T (OFF) (CA400)  
8-719-053-09 LED SML-310VTT86 (OFF) (CA530X/CA580X)  
8-719-053-09 LED SML-310VTT86 (SEEK4)  
(CA530X/CA580X)  
D583  
D584  
8-719-078-21 LED SML-310PTT86 (VOL4) (CA400)  
8-719-053-09 LED SML-310VTT86 (VOL5)  
(CA530X/CA580X)  
D566  
D567  
D567  
D568  
D584  
D585  
8-719-078-21 LED SML-310PTT86 (VOL5) (CA400)  
8-719-053-09 LED SML-310VTT86 (SOURCE)  
(CA530X/CA580X)  
D585  
D586  
8-719-078-21 LED SML-310PTT86 (SOURCE) (CA400)  
8-719-053-09 LED SML-310VTT86 (VOL2)  
(CA530X/CA580X)  
D568  
D569  
8-719-078-21 LED SML-310PTT86 (SEEK4) (CA400)  
8-719-053-09 LED SML-310VTT86 (SEEK3)  
(CA530X/CA580X)  
D586  
8-719-078-21 LED SML-310PTT86 (VOL2) (CA400)  
33  
CDX-CA400/CA530X/CA580X  
DISPLAY IN SELF SW  
Ref. No.  
D587  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
8-719-053-09 LED SML-310VTT86 (VOL1)  
R561  
R562  
R563  
R564  
R565  
1-216-806-11 RES-CHIP  
1-216-806-11 RES-CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
56  
56  
470  
470  
470  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
(CA530X/CA580X)  
D587  
8-719-078-21 LED SML-310PTT86 (VOL1) (CA400)  
< IC >  
IC551  
IC552  
8-759-369-90 IC LC75822ED  
8-749-017-35 IC KSM-401N  
R566  
R567  
R568  
R569  
R570  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
470  
470  
470  
470  
470  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
< JUMPER RESISTOR >  
JR503 1-216-864-11 METAL CHIP  
0
0
0
0
0
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
JR504 1-216-864-11 METAL CHIP  
JR505 1-216-864-11 METAL CHIP  
JR506 1-216-864-11 METAL CHIP  
JR507 1-216-864-11 METAL CHIP  
R571  
R572  
R573  
R574  
R575  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
470  
470  
470  
470  
470  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
JR508 1-216-864-11 METAL CHIP  
0
5%  
1/16W  
R576  
R577  
R578  
R579  
R580  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
470  
470  
470  
470  
470  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
< LIQUID CRYSTAL DISPLAY >  
LCD501 1-804-626-11 DISPLAY PANEL, LIQUID CRYSTAL  
< PILOT LAMP >  
< SWITCH >  
PL551 1-518-753-11 LAMP, PILOT (LCD BACK LIGHT) (CA400)  
PL551 1-518-754-11 LAMP, PILOT (LCD BACK LIGHT)  
(CA530X/CA580X)  
PL552 1-518-753-11 LAMP, PILOT (LCD BACK LIGHT) (CA400)  
PL552 1-518-754-11 LAMP, PILOT (LCD BACK LIGHT)  
S501  
S502  
S503  
S504  
S505  
1-572-704-31 SWITCH, KEYBOARD (Z)  
1-572-704-31 SWITCH, KEYBOARD (OFF)  
1-572-704-31 SWITCH, KEYBOARD (SOURCE)  
1-572-704-31 SWITCH, KEYBOARD (MODE)  
1-572-704-31 SWITCH, KEYBOARD (SEL)  
(CA530X/CA580X)  
< RESISTOR >  
1-219-286-11 RES-CHIP  
1-219-286-11 RES-CHIP  
1-219-286-11 RES-CHIP  
1-218-847-11 RES-CHIP  
1-218-851-11 RES-CHIP  
S506  
S507  
S508  
S509  
S510  
1-771-290-11 SWITCH, SLIDE (VOL)  
1-572-704-31 SWITCH, KEYBOARD (ATT)  
1-572-704-31 SWITCH, KEYBOARD (1/DISC –)  
1-572-704-31 SWITCH, KEYBOARD (2/DISC +)  
1-572-704-31 SWITCH, KEYBOARD (DSPL)  
R501  
R502  
R503  
R504  
R505  
680  
680  
680  
1K  
2%  
2%  
2%  
2%  
2%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
1.5K  
S511  
S512  
S513  
S514  
S515  
1-572-704-31 SWITCH, KEYBOARD (MBP)  
1-572-704-31 SWITCH, KEYBOARD (D-BASS)  
1-771-290-11 SWITCH, SLIDE (SEEK/AMS)  
1-572-704-31 SWITCH, KEYBOARD (BTM)  
1-572-704-31 SWITCH, KEYBOARD (SENS)  
R506  
R507  
R508  
R509  
R510  
1-218-851-11 RES-CHIP  
1-218-855-11 RES-CHIP  
1-218-859-11 RES-CHIP  
1-218-863-11 RES-CHIP  
1-218-867-11 RES-CHIP  
1.5K  
2.2K  
3.3K  
4.7K  
6.8K  
2%  
2%  
2%  
2%  
2%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
S516  
S517  
S518  
S519  
1-572-704-31 SWITCH, KEYBOARD (6)  
1-572-704-31 SWITCH, KEYBOARD (5)  
1-572-704-31 SWITCH, KEYBOARD (4/SHUF)  
1-572-704-31 SWITCH, KEYBOARD (3/REP)  
R511  
R512  
R513  
R514  
R515  
1-219-286-11 RES-CHIP  
1-219-286-11 RES-CHIP  
1-219-286-11 RES-CHIP  
1-218-847-11 RES-CHIP  
1-218-851-11 RES-CHIP  
680  
680  
680  
1K  
2%  
2%  
2%  
2%  
2%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
*************************************************************  
1.5K  
1-683-283-11 IN SELF SW BOARD  
****************  
R516  
R517  
R518  
R519  
R551  
1-218-851-11 RES-CHIP  
1-218-855-11 RES-CHIP  
1-218-859-11 RES-CHIP  
1-218-863-11 RES-CHIP  
1-218-331-11 RES-CHIP  
1.5K  
2.2K  
3.3K  
4.7K  
51K  
2%  
2%  
2%  
2%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
< SWITCH >  
SW2  
SW3  
1-529-566-31 SWITCH, PUSH (1 KEY) (SELF)  
1-529-566-31 SWITCH, PUSH (1 KEY) (DISC IN)  
*************************************************************  
R552  
R554  
R555  
R559  
R560  
1-216-819-11 METAL CHIP  
1-216-807-11 METAL CHIP  
1-216-819-11 METAL CHIP  
1-216-806-11 RES-CHIP  
1-216-806-11 RES-CHIP  
680  
68  
680  
56  
56  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
34  
 
CDX-CA400/CA530X/CA580X  
MAIN  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
A-3283-245-A MAIN BOARD, COMPLETE (including  
C608  
C609  
C610  
C611  
C612  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
25V  
25V  
16V  
50V  
50V  
SPEAKER BOARD)  
10%  
20%  
5%  
*********************  
3-019-565-01 BRACKET (IC)  
1-104-396-11 ELECT  
10uF  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-927-11 CERAMIC CHIP 100PF  
*
5%  
3-041-261-11 BRACKET (TR)  
3-236-922-01 HEAT SINK  
7-685-793-09 SCREW +PTT 2.6X8 (S)  
7-685-795-09 SCREW +PTT 2.6X12 (S)  
C613  
C614  
C615  
C617  
C618  
1-162-927-11 CERAMIC CHIP 100PF  
5%  
50V  
25V  
16V  
16V  
50V  
1-164-174-11 CERAMIC CHIP 0.0082uF 10%  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
< CAPACITOR >  
C101  
C102  
C103  
C104  
C105  
1-164-346-11 CERAMIC CHIP 1uF  
1-164-346-11 CERAMIC CHIP 1uF  
16V  
16V  
16V  
16V  
50V  
C619  
C620  
C621  
C622  
C623  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
50V  
10V  
16V  
1-104-665-11 ELECT  
1-104-396-11 ELECT  
100uF  
10uF  
20%  
20%  
1-104-396-11 ELECT  
1-104-396-11 ELECT  
10uF  
10uF  
20%  
20%  
1-162-911-11 CERAMIC CHIP 6PF  
0.5PF 50V  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-912-11 CERAMIC CHIP 7PF  
0.5PF 50V  
C108  
C110  
C111  
C113  
C114  
1-109-982-11 CERAMIC CHIP 1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-677-11 CERAMIC CHIP 0.033uF 10%  
1-124-257-00 ELECT 2.2uF 20%  
10%  
10V  
25V  
25V  
16V  
50V  
C624  
C625  
C626  
C627  
C631  
1-162-915-11 CERAMIC CHIP 10PF  
1-162-963-11 CERAMIC CHIP 680PF  
1-164-315-11 CERAMIC CHIP 470PF  
1-164-156-11 CERAMIC CHIP 0.1uF  
0.5PF 50V  
10%  
5%  
50V  
50V  
25V  
16V  
1-104-396-11 ELECT  
10uF  
20%  
C115  
C116  
C117  
C118  
C119  
1-162-965-11 CERAMIC CHIP 0.0015uF 10%  
50V  
10V  
10V  
16V  
16V  
C633  
C650  
C651  
C652  
C669  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-164-245-11 CERAMIC CHIP 0.015uF 10%  
1-164-245-11 CERAMIC CHIP 0.015uF 10%  
1-164-227-11 CERAMIC CHIP 0.022uF 10%  
50V  
25V  
25V  
25V  
50V  
1-109-982-11 CERAMIC CHIP 1uF  
1-109-982-11 CERAMIC CHIP 1uF  
1-164-346-11 CERAMIC CHIP 1uF  
1-164-346-11 CERAMIC CHIP 1uF  
10%  
10%  
1-162-919-11 CERAMIC CHIP 22PF  
5%  
C120  
C121  
C201  
C202  
C203  
1-164-346-11 CERAMIC CHIP 1uF  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-164-346-11 CERAMIC CHIP 1uF  
16V  
50V  
16V  
16V  
16V  
C671  
C672  
C701  
C702  
C703  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
10%  
20%  
20%  
20%  
25V  
25V  
10V  
10V  
10V  
1-124-584-00 ELECT  
1-124-584-00 ELECT  
1-124-584-00 ELECT  
100uF  
100uF  
100uF  
1-164-346-11 CERAMIC CHIP 1uF  
1-104-396-11 ELECT  
10uF  
20%  
20%  
C204  
C205  
C208  
C210  
C211  
1-104-396-11 ELECT  
10uF  
16V  
50V  
10V  
25V  
25V  
C704  
C706  
C707  
C801  
C802  
1-124-584-00 ELECT  
100uF  
20%  
10V  
50V  
50V  
16V  
25V  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-109-982-11 CERAMIC CHIP 1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
10%  
1-104-396-11 ELECT  
10uF  
20%  
1-164-156-11 CERAMIC CHIP 0.1uF  
C213  
C214  
C215  
C216  
C217  
1-164-677-11 CERAMIC CHIP 0.033uF 10%  
1-124-257-00 ELECT 2.2uF 20%  
1-162-965-11 CERAMIC CHIP 0.0015uF 10%  
16V  
50V  
50V  
10V  
10V  
C803  
C804  
C809  
C810  
C841  
1-162-918-11 CERAMIC CHIP 18PF  
1-164-160-11 CERAMIC CHIP 20PF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
5%  
5%  
50V  
50V  
25V  
50V  
50V  
1-109-982-11 CERAMIC CHIP 1uF  
10%  
1-109-982-11 CERAMIC CHIP 1uF  
10%  
C218  
C219  
C220  
C221  
C401  
1-164-346-11 CERAMIC CHIP 1uF  
16V  
16V  
16V  
50V  
50V  
C842  
C846  
C847  
C848  
C851  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-164-346-11 CERAMIC CHIP 1uF  
50V  
50V  
16V  
50V  
16V  
1-124-234-00 ELECT  
22uF  
20%  
1-164-346-11 CERAMIC CHIP 1uF  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-126-163-11 ELECT  
4.7uF  
20%  
1-124-119-00 ELECT  
330uF  
20%  
C407  
C426  
C432  
C435  
C603  
1-104-396-11 ELECT  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-124-589-11 ELECT  
1-124-589-11 ELECT  
1-164-227-11 CERAMIC CHIP 0.022uF 10%  
10uF  
20%  
16V  
50V  
16V  
16V  
25V  
C869  
C901  
C904  
C905  
C907  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
20%  
20%  
25V  
16V  
50V  
25V  
25V  
1-135-473-21 ELECT  
1-126-160-11 ELECT  
3300uF  
1uF  
47uF  
47uF  
20%  
20%  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
C604  
C605  
C606  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
20%  
20%  
25V  
10V  
10V  
C909  
C913  
C914  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
25V  
25V  
10V  
1-104-665-11 ELECT  
1-104-665-11 ELECT  
100uF  
100uF  
1-104-665-11 ELECT  
100uF  
20%  
35  
CDX-CA400/CA530X/CA580X  
MAIN  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
C915  
C916  
C919  
C931  
1-110-654-11 DOUBLE LAYERS 0.047F  
1-164-156-11 CERAMIC CHIP 0.1uF  
5.5V  
25V  
10V  
25V  
D933  
D999  
8-719-074-47 DIODE CRS02(TE85L)  
8-719-991-33 DIODE 1SS133T-77  
1-124-229-00 ELECT  
33uF  
20%  
1-164-156-11 CERAMIC CHIP 0.1uF  
< IC >  
< JACK >  
IC101  
IC401  
IC601  
IC801  
IC802  
8-759-827-14 IC TA8268AH  
8-759-827-11 IC LC75421M-TLM-E  
8-759-586-59 IC TB2118F-EL-S  
6-801-302-01 IC uPD780076GK-520-9ET  
8-759-096-16 IC MM1175XFF  
CNJ601 1-793-598-11 JACK (ANTENNA)  
< CONNECTOR >  
CNJ801 1-580-907-31 PLUG, CONNECTOR (BUS CONTROL IN)  
CNP701 1-815-260-11 CONNECTOR, BOARD TO BOARD 30P  
CNP801 1-794-311-21 PLUG, CONNECTOR 12P  
IC902  
8-759-837-07 IC S7139SF  
< JUMPER RESISTOR >  
CNP901 1-774-701-11 PIN, CONNECTOR 16P  
JR110 1-216-864-11 METAL CHIP  
JR603 1-216-864-11 METAL CHIP  
JR605 1-216-864-11 METAL CHIP  
JR606 1-216-864-11 METAL CHIP  
JR607 1-216-864-11 METAL CHIP  
0
0
0
0
0
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
< SURGE ABSORBER >  
CP601 1-803-335-21 ABSORBER, CHIP SURGE  
< DIODE >  
JR903 1-216-864-11 METAL CHIP  
JR904 1-216-864-11 METAL CHIP  
JR929 1-216-864-11 METAL CHIP  
0
0
0
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
D401  
D402  
D444  
D604  
D802  
8-719-991-33 DIODE 1SS133T-77  
8-719-988-61 DIODE 1SS355TE-17  
8-719-988-61 DIODE 1SS355TE-17  
8-719-109-85 DIODE RD5.1ES-B2  
8-719-109-97 DIODE RD6.8ES-B2  
< COIL >  
L601  
L603  
L604  
L669  
L701  
1-410-508-11 INDUCTOR  
1-412-006-31 INDUCTOR  
1-410-750-41 INDUCTOR  
1-424-759-21 COIL (AM ANT)  
1-410-513-11 INDUCTOR  
8.2uH  
10uH  
0.47uH  
D803  
D804  
D805  
D806  
D807  
8-719-109-97 DIODE RD6.8ES-B2  
8-719-109-97 DIODE RD6.8ES-B2  
8-719-109-97 DIODE RD6.8ES-B2  
8-719-109-97 DIODE RD6.8ES-B2  
8-719-109-97 DIODE RD6.8ES-B2  
22uH  
L702  
L703  
L901  
1-410-513-11 INDUCTOR  
1-410-513-11 INDUCTOR  
1-419-476-31 COIL, CHOKE  
22uH  
22uH  
250uH  
D808  
D809  
D851  
D852  
D853  
8-719-109-97 DIODE RD6.8ES-B2  
8-719-109-97 DIODE RD6.8ES-B2  
8-719-420-51 DIODE MA729  
8-719-017-95 DIODE MA8180-TX  
8-719-017-95 DIODE MA8180-TX  
< JACK >  
PJ401 1-774-699-12 JACK, PIN 4P (AUDIO OUT REAR,  
BUS AUDIO IN)  
D854  
D901  
D903  
D907  
D908  
8-719-109-97 DIODE RD6.8ES-B2  
8-719-049-38 DIODE 1N5404TU  
8-719-977-12 DIODE DTZ6.8B  
8-719-110-49 DIODE RD18ES-B2  
8-719-921-63 DIODE MTZJ-7.5B  
< TRANSISTOR >  
Q101  
Q102  
Q201  
Q202  
Q401  
8-729-920-21 TRANSISTOR DTC314TK-T-146  
8-729-920-21 TRANSISTOR DTC314TK-T-146  
8-729-920-21 TRANSISTOR DTC314TK-T-146  
8-729-920-21 TRANSISTOR DTC314TK-T-146  
8-729-055-92 TRANSISTOR SRA2203SF  
D909  
D910  
D913  
D915  
D916  
8-719-109-97 DIODE RD6.8ES-B2  
8-719-109-89 DIODE RD5.6ES-B2  
8-719-110-14 DIODE RD9.1ES-B3  
8-719-110-49 DIODE RD18ES-B2  
8-719-110-49 DIODE RD18ES-B2  
Q402  
Q603  
Q604  
Q605  
Q606  
8-729-055-96 TRANSISTOR SRC1203SF  
8-729-030-51 TRANSISTOR 2SA1515S-R-TP  
8-729-055-96 TRANSISTOR SRC1203SF  
8-729-030-51 TRANSISTOR 2SA1515S-R-TP  
8-729-055-96 TRANSISTOR SRC1203SF  
D917  
D918  
D919  
D920  
D921  
8-719-110-49 DIODE RD18ES-B2  
8-719-110-49 DIODE RD18ES-B2  
8-719-053-18 DIODE 1SR154-400TE-25  
8-719-053-18 DIODE 1SR154-400TE-25  
8-719-110-49 DIODE RD18ES-B2  
Q902  
Q904  
Q905  
Q906  
Q907  
8-729-049-40 TRANSISTOR 2SC5343SFG  
8-729-055-96 TRANSISTOR SRC1203SF  
8-729-055-96 TRANSISTOR SRC1203SF  
8-729-055-92 TRANSISTOR SRA2203SF  
8-729-019-00 TRANSISTOR 2SD2394-G  
D922  
D923  
D930  
D931  
D932  
8-719-110-49 DIODE RD18ES-B2  
8-719-110-14 DIODE RD9.1ES-B3  
8-719-109-89 DIODE RD5.6ES-B2  
8-719-988-61 DIODE 1SS355TE-17  
8-719-988-61 DIODE 1SS355TE-17  
Q909  
8-729-055-96 TRANSISTOR SRC1203SF  
36  
 
CDX-CA400/CA530X/CA580X  
MAIN  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
Q910  
Q911  
Q912  
Q913  
Q914  
8-729-920-85 TRANSISTOR 2SD1664-QR  
8-729-055-96 TRANSISTOR SRC1203SF  
8-729-055-92 TRANSISTOR SRA2203SF  
8-729-019-00 TRANSISTOR 2SD2394-G  
8-729-055-96 TRANSISTOR SRC1203SF  
R618  
R619  
R620  
R622  
R628  
1-216-845-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-829-11 METAL CHIP  
100K  
470  
470  
470  
4.7K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
Q915  
Q917  
Q918  
Q919  
Q920  
8-729-049-43 TRANSISTOR STB1132Y  
8-729-820-46 TRANSISTOR 2SB1202FAS  
8-729-055-92 TRANSISTOR SRA2203SF  
8-729-920-85 TRANSISTOR 2SD1664-QR  
8-729-920-85 TRANSISTOR 2SD1664-QR  
R704  
R705  
R706  
R707  
R708  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-247-887-00 CARBON  
1K  
1K  
0
220K  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/4W  
1-216-821-11 METAL CHIP  
1/16W  
Q921  
Q929  
8-729-055-96 TRANSISTOR SRC1203SF  
8-729-055-96 TRANSISTOR SRC1203SF  
R709  
R710  
R711  
R712  
R714  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1K  
1K  
1K  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
< RESISTOR >  
2.2K  
R107  
R108  
R109  
R110  
R113  
1-216-841-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-218-867-11 RES-CHIP  
47K  
47K  
100  
100  
6.8K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R716  
R806  
R807  
R808  
R809  
1-216-825-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
2.2K  
1K  
1K  
1K  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R115  
R121  
R122  
R207  
R208  
1-216-834-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-841-11 METAL CHIP  
12K  
1K  
47K  
47K  
47K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R810  
R811  
R812  
R813  
R814  
1-216-813-11 METAL CHIP  
1-249-409-11 CARBON  
1-249-409-11 CARBON  
1-216-837-11 METAL CHIP  
1-216-809-11 METAL CHIP  
220  
220  
220  
22K  
100  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/4W  
1/4W  
1/16W  
1/16W  
R209  
R210  
R213  
R215  
R221  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-218-867-11 RES-CHIP  
1-216-834-11 METAL CHIP  
1-216-821-11 METAL CHIP  
100  
100  
6.8K  
12K  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R815  
R819  
R821  
R824  
R835  
1-216-809-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-849-11 METAL CHIP  
1-216-849-11 METAL CHIP  
1-216-821-11 METAL CHIP  
100  
0
220K  
220K  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R222  
R401  
R404  
R407  
R408  
1-216-841-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-249-437-11 CARBON  
47K  
10K  
1K  
47K  
6.8K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/4W  
R840  
R844  
R845  
R846  
R847  
1-216-821-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
100  
100  
100  
100  
1-218-867-11 RES-CHIP  
1/16W  
R410  
R444  
R601  
R602  
R603  
1-216-805-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-249-417-11 CARBON  
1-216-821-11 METAL CHIP  
1-249-407-11 CARBON  
47  
0
1K  
1K  
150  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/4W  
1/16W  
1/4W  
R848  
R849  
R851  
R852  
R853  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-249-421-11 CARBON  
1-216-809-11 METAL CHIP  
1-247-807-31 CARBON  
100  
100  
2.2K  
100  
100  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/4W  
1/16W  
1/4W  
R604  
R605  
R606  
R607  
R608  
1-216-821-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-827-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
47K  
47K  
3.3K  
10K  
R854  
R855  
R901  
R905  
R906  
1-216-841-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-249-425-11 CARBON  
1-216-864-11 METAL CHIP  
1-216-821-11 METAL CHIP  
47K  
1K  
4.7K  
0
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/4W  
1/16W  
1/16W  
1K  
R609  
R610  
R611  
R612  
R613  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-218-867-11 RES-CHIP  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
100  
100  
6.8K  
10K  
10K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R907  
R908  
R909  
R911  
R912  
1-216-841-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-828-11 METAL CHIP  
1-249-417-11 CARBON  
1-249-413-11 CARBON  
47K  
47K  
3.9K  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/4W  
470  
1/4W  
R614  
R615  
R616  
R617  
1-247-807-31 CARBON  
100  
5%  
5%  
5%  
5%  
1/4W  
1-216-825-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-825-11 METAL CHIP  
2.2K  
100K  
2.2K  
1/16W  
1/16W  
1/16W  
R913  
R917  
R918  
1-249-417-11 CARBON  
1-249-409-11 CARBON  
1-216-845-11 METAL CHIP  
1K  
220  
100K  
5%  
5%  
5%  
1/4W  
1/4W  
1/16W  
37  
CDX-CA400/CA530X/CA580X  
SERVO  
MAIN  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
R919  
R920  
R922  
R923  
R924  
1-249-421-11 CARBON  
1-216-849-11 METAL CHIP  
1-208-806-11 RES-CHIP  
1-208-806-11 RES-CHIP  
1-249-404-00 CARBON  
2.2K  
220K  
10K  
10K  
82  
5%  
5%  
1/4W  
1/16W  
C19  
C20  
C21  
C22  
C23  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
10%  
10%  
10%  
10%  
16V  
16V  
25V  
25V  
25V  
0.5% 1/10W  
0.5% 1/10W  
5%  
1/4W  
R925  
R926  
R927  
R928  
R929  
1-249-404-00 CARBON  
1-249-404-00 CARBON  
1-249-404-00 CARBON  
1-249-404-00 CARBON  
1-249-404-00 CARBON  
82  
82  
82  
82  
82  
5%  
5%  
5%  
5%  
5%  
1/4W  
1/4W  
1/4W  
1/4W  
1/4W  
C24  
C25  
C26  
C27  
C29  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
10%  
20%  
10%  
10%  
25V  
25V  
6.3V  
25V  
25V  
1-126-391-11 ELECT CHIP  
47uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
R930  
R931  
R932  
R933  
R934  
1-249-395-11 CARBON  
1-218-867-11 RES-CHIP  
1-249-421-11 CARBON  
1-216-821-11 METAL CHIP  
1-249-409-11 CARBON  
15  
5%  
5%  
5%  
5%  
5%  
1/4W  
1/16W  
1/4W  
1/16W  
1/4W  
C30  
C34  
C35  
C36  
C37  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
10%  
10%  
10%  
20%  
25V  
25V  
25V  
25V  
10V  
6.8K  
2.2K  
1K  
220  
1-126-393-11 ELECT CHIP  
33uF  
< SWITCH >  
C38  
C40  
C41  
C43  
C44  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
10%  
10%  
25V  
16V  
25V  
50V  
6.3V  
S901  
1-762-638-11 SWITCH, TACTILE (RESET)  
< THERMISTOR (POSITIVE) >  
1-162-967-11 CERAMIC CHIP 0.0033uF 10%  
1-125-837-91 CERAMIC CHIP 1uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
< CONNECTOR >  
10%  
TH851 1-801-792-21 THERMISTOR, POSITIVE  
TH901 1-809-148-11 THERMISTOR PTH8L07AR2R0M1B510  
C45  
10%  
25V  
< TUNER >  
TU601 A-3220-835-A TUNER UNIT (TUX-010)  
< VIBRATOR >  
CN1  
CN3  
1-815-352-11 CONNECTOR, BOARD TO BOARD 30P  
1-816-275-11 CONNECTOR, FFC/FPC 6P  
< JUMPER RESISTOR >  
X601  
X801  
X802  
1-781-246-21 VIBRATOR, CRYSTAL (10.25MHz)  
1-795-259-11 VIBRATOR, CERAMIC (8.38MHz)  
1-567-098-41 VIBRATOR, CRYSTAL (32kHz)  
FB1  
FB2  
FB3  
FB4  
FB6  
1-216-864-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-864-11 METAL CHIP  
0
0
0
0
0
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
*************************************************************  
A-3283-233-A SERVO BOARD, COMPLETE  
**********************  
FB7  
1-216-864-11 METAL CHIP  
< IC >  
0
5%  
1/16W  
1-683-284-11 FLEXIBLE BOARD  
< CAPACITOR >  
IC1  
IC2  
8-759-699-98 IC uPD63711GC-8EU  
8-759-658-87 IC BA5810FP-E2  
C1  
C3  
C4  
C5  
C6  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
10%  
20%  
10%  
10%  
25V  
25V  
4V  
25V  
25V  
< TRANSISTOR >  
8-729-904-87 TRANSISTOR 2SB1197K-R  
< RESISTOR >  
1-104-609-11 ELECT CHIP  
100uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
Q1  
C8  
C9  
C10  
C11  
C13  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-162-924-11 CERAMIC CHIP 56PF  
1-162-924-11 CERAMIC CHIP 56PF  
1-162-909-11 CERAMIC CHIP 4PF  
1-162-916-11 CERAMIC CHIP 12PF  
10%  
5%  
5%  
0.25PF 50V  
5%  
16V  
50V  
50V  
R3  
R5  
R6  
R7  
R8  
1-216-797-11 METAL CHIP  
1-218-344-11 RES-CHIP  
1-216-837-11 METAL CHIP  
1-216-839-11 METAL CHIP  
1-216-833-11 METAL CHIP  
10  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
7.5K  
22K  
33K  
10K  
50V  
C14  
C15  
C16  
C17  
C18  
1-125-837-91 CERAMIC CHIP 1uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
10%  
10%  
10%  
6.3V  
25V  
25V  
25V  
50V  
R9  
1-216-840-11 METAL CHIP  
1-216-835-11 METAL CHIP  
1-216-837-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-841-11 METAL CHIP  
39K  
15K  
22K  
47K  
47K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R10  
R12  
R14  
R15  
1-162-966-11 CERAMIC CHIP 0.0022uF 10%  
38  
 
CDX-CA400/CA530X/CA580X  
SERVO  
SL SW SPEAKER  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
R17  
R18  
R19  
R20  
R21  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-821-11 METAL CHIP  
100  
100  
100  
100  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
ACCESSORIES  
************  
1-476-526-31 REMOTE COMMANDER (RM-X115)  
(CA400/CA580X)  
3-230-047-01 LID, BATTERY CASE (for RM-X115)  
(CA400/CA580X)  
3-238-717-11 MANUAL, INSTRUCTION, INSTALL  
(ENGLISH,FRENCH) (CA400)  
3-238-719-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH)  
(CA400)  
R22  
R24  
R25  
R26  
R29  
1-216-821-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-864-11 METAL CHIP  
1-216-797-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1K  
0
0
10  
10K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
3-238-722-11 MANUAL, INSTRUCTION, INSTALL  
(ENGLISH,SPANISH) (CA530X/CA580X)  
R30  
SW1  
X1  
1-216-833-11 METAL CHIP  
< SWITCH >  
10K  
5%  
1/16W  
3-238-723-11 MANUAL, INSTRUCTION (ENGLISH,SPANISH)  
(CA530X/CA580X)  
X-3380-054-2 CASE ASSY (for FRONT PANEL)  
1-762-944-12 SWITCH, DETECTION (SMALL TYPE) (DOWN)  
< VIBRATOR >  
*************************************************************  
PARTS FOR INSTALLATION AND CONNECTIONS  
**************************************  
1-795-520-21 VIBRATOR, CERAMIC (16.9344MHz)  
*************************************************************  
251  
252  
3-014-370-21 FRAME, FITTING  
X-3366-405-1 SCREW ASSY (EXP), FITTING  
1-683-282-11 SL SW BOARD  
************  
(CA530X/CA580X)  
253  
254  
255  
3-934-325-01 SCREW (+K 5X8 TP)  
3-030-929-04 SPRING, FITTING  
3-236-923-01 COLLAR  
< SWITCH >  
SW4  
1-529-565-41 SWITCH, PUSH (1 KEY) (LIMIT)  
*************************************************************  
256  
1-776-206-21 CORD (WITH CONNECTOR) (POWER)  
1-683-830-11 SPEAKER BOARD (supplied with  
MAIN BOARD, COMPLETE)  
251  
252  
**************  
*************************************************************  
MISCELLANEOUS  
***************  
25
3
201  
207  
0210  
1-776-206-21 CORD (WITH CONNECTOR) (POWER)  
X-3378-480-1 CHASSIS (OP) ASSY (including M901)  
1-823-641-11 CABLE, FLEXIBLE FLAT (6 CORE)  
8-820-103-11 PICK-UP, OPTICAL KSS-720A/C-RP  
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A  
F901  
M902  
M903  
A-3301-985-A MOTOR ASSY, SLED (SLED)  
A-3315-039-A MOTOR SUB ASSY, LO (LOADING)  
*************************************************************  
The components identified by Les composants identifiés par une  
mark 0 or dotted line with mark marque 0 sont critiques pour  
0 are critical for safety.  
Replace only with part number Ne les remplacer que par une piéce  
specified. portant le numéro spécifié.  
la sécurité.  
39  
CDX-CA400/CA530X/CA580X  
REVISION HISTORY  
Clicking the version allows you to jump to the revised page.  
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised  
page.  
Ver.  
Date  
Description of Revision  
1.0  
2001. 12  
New  

Vivitar Camera Lens VIV 35MM S User Manual
Vista Davis &amp; Sanford ATTARAS3H User Manual
Topfield TF 6060 CI User Manual
Sunfire True Subwoofer Super Junior User Manual
Stoelting F144 User Manual
Sony TRV715 User Manual
Sony Car Stereo System XR CA370 User Manual
SanDisk 80 11 00943 User Manual
Samsung Camcorder HMX Q10TN User Manual
Rosen Entertainment Systems HK CY0801 G52 User Manual