SERVICE MANUAL
MODEL
––––––
COMMANDER DEST. CHASSIS NO.
–––––––––––– ––––– –––––––––––
MODEL
––––––
COMMANDER DEST. CHASSIS NO.
–––––––––––– ––––– –––––––––––
FDL-PT222
US
LCD COLOR TV
MICROFILM
∗ Please file according to model size. .......
2.2
Download from Www.Somanuals.com. All Manuals Search And Download.
SECTION 1
GENERAL
The operating instructions mentioned here are partial abstracts from the
Operating Instructions Manual. The page numbers of the Operating
Instruction Manual remain as in the manual. (Part no : 4-083-376-11)
Download from Www.Somanuals.com. –All3Ma–nuals Search And Download.
Download from Www.Soman–ual4s.c–om. All Manuals Search And Download.
FDL-PT222
SECTION 2
DISASSEMBLY
2-1. CABINETS
1. Remove the battery cover 8.
2. Push two claws with a screwdriver or equivalent on the bottom and
remove them.
1 front cabinet
2 channel button
3 B board
claw
4 A board
3. While pushing the rear cabinet, remove claws of joints with
the front cabinet.
4. Insert a screwdriver or equivalent to the gap on the upper side of the
cabinet, and while pushing the lock spring, put it down to the rear cabinet
side.
6 screw (+PTP2X6)
5. Remove the channel button 2.
6. Disconnect CN501 (for speaker) on the A board.
7. Remove the B board 3 and the A board 4.
8. Remove solder for the lead wire (BLK) 9.
9. Remove a screw (+PTP2X6) 6 secured the T board 5.
5 T1 board
10. Release the T1 board 5 from two claws (right and left) on the rear cabinet.
9 lead wire (BLK)
claw
front cabinet
7 rear cabinet
rear cabinet
lock spring
8 battery cover
Download from Www.Somanuals.com. All Manuals Search And Download.
– 5 –
FDL-PT222
2-2. SERVICE POSITION
Cable for service
1-900-211-84
CN602
A board
CN601
Cable for service
1-900-211-84
B board
CN301
T1 board
CN201
J101
Mini-jack
Antenna
AC power adaptor
Download from Www.Somanuals.com. All Manuals Search And Download.
– 6 –
FDL-PT222
SECTION 3
CIRCUIT ADJUSTMENTS
3-1.A BOARD ADJUSTMENT
[VIF.AFT COARSE ADJUSTMNT (T201, T202)]
[SETUP]
[+4.5V ALIGNMENT (RV601)]
1. Set S601 on the A board to VHF position.
2. Apply no signal to JL18 (RF).
3. Connect a 1 kΩ resistor between JL77 (+4.5V) and
JL28 (RF AGC).
Using a digital voltmeter measuring the voltage between
JL32 (+4.5V) and JL33 (GND). Adjust RV601 to obtain
the value shown below.
4. Apply a sweep signal across JL26 (IF) and JL27(IF GND).
(Fig. 3-1)
Standard Value = 4.45V± 0.05VDC
S601 position = UHF position
Note : Set the sweep signal for JL26 to -30±5dBm. Keep the
[+30.0V CHECK]
distance to the ATT output JL26 as short as possible.
Check the voltage across JL29 (+30.0V) and JL33 (GND) .
Standard Value = 30.5V±1.5VDC
[AUDIO OUTPUT CHECK]
1. Feed the audio signal 1kHz 100% modulated.
2. Set RV501 to maximum.
3. Connect an oscilloscope between JL23 (SP) and JL15 (SP
GND).
0.01µF
SWEEP
MARKER
GENERATOR
ATT
JL26
75Ω 6dB
4. Check the waveform on the oscilloscope becomes the stan-
dard value.
fo=45.75MHz±5kHz
Standard Value = 1.5V-2.8Vp-p
Fig. 3-1
3-2.T1 BOARD ADJUSTMENT
[ADJUSTMNT]
1. Connect an oscilloscope between JL72 (VIDEO) and JL71
(A.GND) and apply an external voltage (MGC) to JL26 to
obtain a waveform as shown in Fig. 3-2 (make sure not to
clip the extremely short portion).Adjust T202 so that the po-
sition at 45.75 MHz is the lowest point.
- T1 board - (Component side)
T201 T202
RV201
Note : Align JL51 (MGC) external voltage for approximately
a 1.0 Vp-p. Make sure that the JL51 (MGC) external
voltage does not exceed 4.3VDC.
2. Remove the external voltage (MGC) from JL51.
3. Connect an oscilloscope between JL31 (AFT) and JL30
(D.GND) and make a coarse adjustment of T201 so that wave-
form is close to zero at the 45.75 MHz position.
4. Remove the 1 kilohm resistor connected between JL77 (+4.5V)
and JL28 (RF AGC).
RV002
TU101
RV004
RV001
1Vp-p
45.75MHz
0
Fig. 3-2
Download from Www.Somanuals.com. All Manuals Search And Download.
– 7 –
FDL-PT222
[AFT FINE ADJUSTMENT(T201)]
3-3.B BOARD ADJUSTMENT
1. Connect a 1 kilohm resistor between JL77 (+4.5V) and JL28
(RF AGC).
Note : Perform this adjustment as the last step in the
process since drift may occur due to aging.
2. Switch the sweep signal to CW.
- B board -
(Component side)
RV301
fo= 45.75 MHz±5 kHz, -30±5dBm
Apply the above signal between JL26 (IF) and JL27 (IF GND)
and then make a fine adjustment of T201 so that the level be-
tween JL31 (AFT) and JL30 (D.GND) reaches2.2V±0.4VDC.
3. Remove the 1 kilohm resistor connected between JL77 (+4.5V)
and JL28 (RF AGC).
RV402
[RF. AGC ADJUSTMENT (RV201)]
1. Set S601 to VHF position and receive a VHF color bar signal
issued from a signal generator.
2. Adjust RV201 and align the screen for the optimal point so
that the snow noise disappears.
[CONTRAST ADJUSTMENT (RV402)]
1. Receive the stepped waveform signal in 10 steps.
2. Observe the waveform across JL83(G) and JL67(GND).
3. Check the contrast changes by turning RV402.
4. Connect an oscilloscope between JL84 (AUTO CB) and JL67
(D. GND) and adjust RV402 so that the voltage of A portion
becomes 2.2+-0.2V.
5. Check the waveform as shown in Fig. 3-5.
6. At the same time, check the points C and D are within the
period as shown in Fig. 3-5.
[CHANNEL DISPLAY POSITION ADJUSTMENT
(RV001, RV002, RV004)]
1. Set S601 to VHF position, a potentiometer (47kΩ±15kΩ)
across JL25(CS) and JL77 (+4.5 V) as shown in Fig. 2-6 and
short the points JL21(CH CAL) and JL30 (D.GND).
2. Receive channel 2 and align the channel display positions with
RV002(VP).
3. Receive channel 13 and align the display bar with RV004(VA).
4. Align while performing tracking to mutual interference in the
above steps 2 and 3.
100 IRE
5. Receive channels 3 & 4 and confirm that the display bar is
within the standards.
Contrast changes
JL83
6. Set S601 to UHF.
7. Receive channel 14 and align the display position with
RV001(UP).
0 IRE
D
8. Receive channel 69 and confirm that the display bar is within
the standards.
C
JL84
Once again receive channel 14 and confirm that the display
bar is within the standards.
A=2.2±0.2VDC
Note : Use caution since shifting channel 69 will also
cause channel 14 to shift.
9. Remove the potentiometer (47kΩ+15kΩ) you connected be-
tween JL25(CS) and JL77(+4.5V).Also remove the short you
connected between points JL21 (CH CAL)and JL30(D.GND).
Fig. 3-5
[COLOR PHASE (TINT) ADJUSTMENT (RV301)]
1. Receive the color bar signal from the signal generator.
2. Observe the waveform across JL81(B) and JL67(D.GND).
3. Adjust RV301 (TINT) so that the waveform level becomes as
shown in Fig. 3-6.
Display bar
JL77(+4.5V)
JL25 (CS)
Channel No.
15kΩ
6
VR(47kΩ)
*Channel No. and display
bar are to be in line.
Fig. 3-4
Fig. 3-3
Fig. 3-6
Download from Www.Somanuals.com. All Manuals Search And Download.
– 8 –
SECTION 4
DIAGRAMS
4-1. BLOCK DIAGRAM (1)
BALUN
T101
CN201
12
UB
STRAP
2
VHF
ANTENNA
3
H.P
J101
EXT ANT
IC201 VIF/SIF DET
IF
IF
IF
IF
IF
ANT
IF
6
7
IF AMP
Q201
FILTER
SWF201
IF AMP
IF
LLD
UB
REF COIL
REF COIL
AGC OUT
AGC DL
19
20
TU101
TUNER
VIDEO
DET
AGC
3
4
AGC IF
IC001
TUNER CONTROOL
3
RV201
RF AGC
BS
BS
HB
LB
28
27
SWITCH
Q010-012
COMPOSITION
DEF
FH
DEFEAT
14
1
OUTPUT
TUNING
CONTROL
U/V
BAND
SELECT
AUDIO
E-VDL
FM DET
LIM
AUDIO
SIF
SIGNAL
DEFECT
INV.
Q205
FH SWITCH
Q005
14
15
16
BUFFER
LIMITER
13
10
5
AUDIO
FM
DET
TO
A BOARD
CN502
BAND
SELECT
AUDIO
CF202
H SYNC
AFC
SYNC
AFT
AUTO
SYNC
SEP
4
5
23
17
21
CF203
AUDIO
RETURN
+4.5V
VIDEO
DET OUT
VIDEO
AMP
BUFFER
Q202
MB
COMPARATOR
AFT
18
22
9
VIDEO
Q007
AFC SWITCH
AFT
AFT COIL
SYNC SEP
SUD
CS
6
CF201
7
8
H SYNC
IND
CHARGE/
DISCHARGE
CIRCUIT
BT
UP
UA
BUFFER
Q001
AMP
Q002
BT
GEN.
INITIAL
SET
TU
26
18
22
INV., SWITCH
Q003,004
10
RV001
BAR
DISPLAY
CHANNEL DISPLAY
POSITION CH13
V
U
POSITION
ADJUST
BAR
OUTPUT
30
31
11 UP DOWN SW
20
19
VLP
VHP
CHANNEL DISPLAY RV002
POSITION CH1
V LOW
23
24
VHA
VLA
RV004
V HI
CHANNEL DISPLAY
POSITION CH12
T1 (TUNER, VIF/SIF DET)
Download from Www.Somanuals.com. All Manuals Search And Download.
– 10 –
– 9 –
4-2. BLOCK DIAGRAM (2)
IC401
MONITOR CONTROL
CN502
12
2
UB
VHF
CN601
CN301
CP 24
CP 40
BUFFER
Q403
2
3
VHF
H.P
2
3
40 R2
CP
CL2
CLB
CLA
D2
1
2
3
4
5
6
7
8
9
H.P
3
37 HSO
CL2 22
CL2 38
UHF
CLB 21
CLB 37
S601
(1/2)
+4.5V
VHF
OFF
CLA 20
CLA 36
D2 12
D2 28
IC501 HEADPHONE AMP
VCC
D3 11
D3 27
AUDIO
D3
3
2
J501
10
D4 26
6
D4
2
AUDIO
AUDIO
5
D1
9
RV501
VOL
D1
D1 25
SPEAKER
AUDIO
V+
7
RES 13
RES 29
BESTB
TO
T1 BOARD
CN201
TPR2
TPR1
VM 23
VM 39
2
6
TPR1B 12
TPR1 13
VM BUFFER
Q407
VIDEO
VIDEO
VIDEO
SYNC. SEP.
Q303
VIDEO
9
9
VIDEO
9
34 V IN
LCD
MONITOR
VM
VSS
4
3
SWITCH
Q406
DB 10
H SYNC
IND
7
8
7
8
H SYNC
IND
7
8
35 H IN
38 INB
IND SWITCH
Q408
40
R
S601
(2/2)
T601
IC301 Y/C JUNGLE
UHF
9
8
1
6
7
3
+30V
INV.
Q302
1
2
VIDEO IN
SYNC SEP
HD IN
CONTRAST
5
9
PORT SWITCH
Q601-603
VHF
OFF
+4.5V
F601
23 AUTO CB
28 R IN
RV601
+4.5V
19 TINT CONT
21 VCXO IN
R OUT 10
G OUT 11
B OUT 12
XT1 20
XTD 21
RV301
TINT
X401
4.5MHz
4
+4.5V
UP DOWN SW 11
29 G IN
23 VCXO OUT
27 B IN
TGL VL 30
S001
-
S002
+
X301
3.58MHz
RV402
CH
CONTRAST
BUFFER
Q401
+30V
BATTERY
VDG 17
VDR 18
VDG 33
VDR 34
VDB 16
VDB 32
VS2 15
VS2 31
BUFFER
Q402
11
BRT
11
RV450
BRT
T701
3
2
DRIVE
Q701
J701
D701
8
6
DRIVE
Q702
4
1
5
FR701
LCD
BACK LIGHT
DC IN 4.5V
A (POWER SUPPLY, LCD BACK LIGHT, HEADPHONE AMP)
B (Y/C JUNGLE, MONITOR CONTROL)
Download from Www.Somanuals.com. All Manuals Search And Download.
– 11 –
– 12 –
4-3. CIRCUIT BOARDS LOCATION
Note:The symbol
display is on the component slde.
MEMO
The components identified by shading and mark
are critical for safety. Replace only with part number
specified.
B
The symbol
indicate fast operating fuse.
Replace only with fuse of same rating as maked.
Terminal name of semiconductors in silk screen
printed circuit (
)
*
Circuit
Device
Printed symbol
Terminal name
Collector
Transistor
1
Emitter
Collector
Emitter
Base
A
T1
Transistor
Diode
2
3
Base
Cathode
Anode
4-4. PRINTED WIRING BOARDS AND
SCHEMATIC DIAGRAMS
Cathode
4
5
6
7
8
Diode
Diode
Diode
Diode
(NC)
Anode
Note:
Cathode
• Capacitors without voltage indication are all 50V.
• All resistors are in ohms.
kΩ=1000Ω, MΩ=1000kΩ
• Indication of resistance, which dose not have one for rating electrical power, is
as follows.
(NC)
Anode
Common
Anode Cathode
Common
Pitch : 5mm
Rating electrical power : 1/ 4 W
Anode Cathode
Common
Diode
Diode
Diode
•
•
: nonflammable resistor.
: fusible resistor.
Anode
Common
Anode
9
0
•
•
: internal component.
Anode Anode
Common
: panel designation and adjustment for repair.
• All variable and adjustable resistors have characteristic curve B, unless otherwise
Cathode
Cathode
noted.
Common
!¡ Diode
•
: earth-chassis.
Cathode
Cathode
Anode
Anode
Cathode
Cathode
Anode
Anode
• As to the voltage volue shown by the semiconductors on the Shematic Diagram,
see the another list
Diode
!™
• Readings are taken with a color-bar signal input.
• Readings are taken with a 10MΩ digital multimeter.
• Voltages are dc with respect to ground unless otherwise noted.
• Voltage variations may be noted due to normal production tolerances.
• All voltages are in V.
Source
Gate
Transistor
(FET)
Drain
Drain
!£
!¢
!∞
!§
!¶
!•
!ª
@º
@¡
@™
D
D
S
G
G
Source
Gate
Transistor
(FET)
S
D
D
Source
Drain
Gate
Transistor
(FET)
• Circled numbers are waveform references.
G
G
S
S
•
•
: B+ bus.
: B– bus.
Emitter
Collector
Base
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
C1
E1
C1
C2
E2
C2
•
: signal path.
C2 B1 E1
B1
B2
B2
B2
E2 B2 C1
Reference information
RESISTOR : RN
: RC
METAL FILM
SOLID
C1 B2 E2
E1 B1 C2
: FPRD NONFLAMMABLE CARBON
: FUSE NONFLAMMABLE FUSIBLE
B1
C1 B2 E2
E1 B1 C2
E1
E1
E2
E2
: RW
: RS
: RB
:
NONFLAMMABLE WIREWOUND
NONFLAMMABLE METAL OXIDE
NONFLAMMABLE CEMENT
ADJUSTMENT RESISTOR
C1 B2 E2
E1 B1 C2
B1
B1
B1
B1
C1
C1(B2)
C2
C2
COIL
: LF-8L MICRO INDUCTOR
E2
B1 E1
C2
C1(B2)
CAPACITOR : TA
TANTALUM
STYROL
POLYPROPYLENE
MYLAR
E2
E2
E2
: PS
: PP
: PT
E1(B2)
(B2)
B1 E1
C1
E2
C2
C1
E1(B2)
C2
C2
(B2)
: MPS METALIZED POLYESTER
: MPP METALIZED POLYPROPYLENE
E2 E1
B1
C1
@£
C2
C1
C2
: ALB
: ALT
: ALR
BIPOLAR
HIGH TEMPERATURE
HIGH RIPPLE
Discrete semiconductot
–
Ver.1.5
(Chip semiconductors that are not actually used are included.)
Download from Www.Somanuals.com. All Manuals Search And Download.
– 14 –
– 13 –
T1 BOARD : IC001 AN5707NFAP
STOP
13
DEF CHCAL BRT
L/H U/V
27
Vcc 5V
8
14
15
17
7
DEFEAT
OUT
BAND
SW
AFC
5
COMPARATOR
H.P.
M.M.
H.syn
FH
3
2
4
1
6
TUNING
CONTROL
28 BS
BS ADD
PLUSE WIDTH
SET
• T1 BOARD WAVEFORMS
SIGNAL
DET
UP
DN
1
2
3
B
STOP
30 V OUT
31 U OUT
INPUT
CONTROL
BAR OUTPUT
3.4Vp-p (H)
3.7Vp-p (H)
0.9Vp-p (H)
SUD
18 UP
BAR DISPLAY
POSITION
ADJUST
20 VLP
19 VHP
21 CON
22 UA
10
3
4
11
1
5
6
7
8
9
2
AUTO
RETURN
STRAP
CHARGE/
DISCHAGE
ANTENNA
EXT ANT
J101
BT GENERATOR
INITIAL RESET
T101
A
TU101
1
2
3
6
4
G
29
GND
9
16 25 32
26
12
MANU
10
C.S.
11
CHA
23
24
IF
CN201
12P
NC NC NC NC
BT
VHA VLA
R032
2.2k
1
2
D.GND
VHF
:CHIP
R101
100
3
H.P
4.5V
AUDIO
30V
:CHIP
4
C015
100p
B
C
AUDIO
5
TO
A BOARD
CN602
CH:CHIP
6
7
H.SYNC
IND
VIDEO
A.GND
UP DOWN SW
UB
8
VIDEO
A.GND
T1 BOARD : IC201 M51348AFP
9
4.5V
10
11
12
L201
15µH
C234
0.01
C202
0.01
R201
680
:FR-CP
B:CHIP
B:CHIP
:CHIP
R202
220
Q007
VIDEO
R240
VIDEO
AUDIO OUT 13
E-VDL 14
BUFFER
12 GND (SIF)
11 DC F/B
10 SIF IN
:CHIP
R242
C235
UN211D-TX
470
0.001
1
2
:CHIP
R241
180k
B:CHIP
Q202
2SB709A-R
4.5V
T201
T202
10k
CF201
:CHIP
45.75MHZ
AFT
45.75MHZ
:CHIP
Q003
TPS4.5MC
3
UN2210-TX
IF
C016
0.1
LLD
T1
R001
100k
R012
330k
3
C204
0.001
R031
82k
25V
:CHIP
6
4
1
2
3
LIMITER
:CHIP
F:CHIP
B:CHIP
:CHIP
1
2
C205
TUNER,
VIF, SIF DET
C001 C002
C011
10
R233
100
:CHIP
10
16V
:7L
4.7
25V
:7L
47
6.3V
:7L
R208
FM DET IN 15
FM DET
680 :CHIP
Q004
16V
:7L
R029
470
UN2110-TX
R021
:CHIP
C207
10p
100k
:CHIP
D001
CH:CHIP
R228
10k
C228
0.01
MA152WK-TX
LIMITER OUT 16
AFT OUT 17
9
8
7
6
Vcc (SIF)
GND (VIF)
IF IN
L205
R215
10
R214
1k
C005
0.01
B:CHIP
:CHIP
4.5V
B:CHIP
Q201
0.82µH
R022
27k
4.5V
IF
:CHIP
:CHIP
2SC3837KT146Q
:FR-CP
:CHIP
1
3
D
E
R234
R013
R216
C229
2
1.2k
56k :CHIP
1.2k 0.01
AFT
VIDEO AMP
ULOW
R243
22k
:CHIP
:CHIP B:CHIP
BRT
UP
VCC
UH
24
23
22
21
20
19
18
17
16
15
14
13
SWF201
F1248
C021
R218
RV001
R014
39k
3
:CHIP
68
0.1 25V
F:CHIP
47k
C209
:CHIP
:CHIP
:CHIP
0.01
C003
VHP
VLP
CON
UA
SUD
AFC
B:CHIP
C006
I
O
560p
VLOW
1
3
2
4
R016
39k
0.1
1
CH:CHIP
VIDEO OUT 18
REF COIL 19
25V
G
SWF
O
IC201
IC001
AN5707NFAP
:CHIP
F:CHIP
2nd
Amp
1st
Amp
M51348AFP
HSYNC
H.P
RV002
47k
R010
2.2
:CHIP
C014
C004
47
C210
0.01
R219
390
R220
47
:CHIP
C211
0.01
B:CHIP
0.1 25V F:CHIP
R002
100k
:CHIP
6.3V
:7L
B:CHIP
2
:CHIP
IF IN
VHA
VLA
M.M
FH
1
2
3
4
5
6
7
8
9
SIF
10
11
12
:CHIP
C007
IF
C213
0.01
0.001 B:CHIP
VIDEO
DET
R030 R003
IF
RV004
100k
B:CHIP
VHI
0
68k
R018
R017
:CHIP
:CHIP
:CHIP
100k
R235
C236
22
C215
18k :CHIP
:CHIP
5.6k
47
6.3V
:7L
REF COIL 20
AFT COIL 21
5
4
Vcc (VIF)
R023
:CHIP
6.3V
:7L
2
1
Q001
0
C008
0.47
IF
:CHIP
2SB709A-R
25V
3
F:CHIP
R005
150k
R004
47k
:CHIP
C222
10
R224
1.5k
RF AGC DELAY
30V
6
:CHIP
16V
:7L
C218
0.01
:CHIP
4
1
R223
Q002
B:CHIP
1k
AGC
XN4601
2
:CHIP
RV201
1k
R226
R008
270k
R225
4.7k
:CHIP
3.3k
C223 :CHIP
1
SYNC SEP IN 22
SYNC OUT 23
3
2
RF AGC OUT
5
3
:RN-CP
:CHIP
SYNC
SEP
R229
8.2k
R009
C012
1
33k
R011
10k
:RN-CP
:CHIP
16V
:CHIP
F
F:CHIP
AGC FILTER II
4.5V
C224
0.01
R230
10
R231
10
C219
3.3
IF AGC
DET
4.5V
IF AGC ADJ 24
1
AGC FILTER I
B:CHIP
:CHIP
:CHIP
30V
2
1
1
Q010
XN1115
5
2
3
5
4
30V
R046
47k
R047
10k
4
:CHIP
:CHIP
B-¥SS10904.<U..>-T1.
G
Q011
XN4215
6
3
Q012
XN2210
Download from Www.Somanuals.com. All Manuals Search And Download.
– 15 –
– 16 –
T1
[
]
ELECTRONIC TUNRTR, VIF, SIF
– T1 Board –
T1 BOARD IC VOLTAGE LIST
T1 BOARD
DIODE
Pin Volt
Pin Volt
20 2.2
21 2.9
22 0.8
23 2.1
24 2.1
Pin Volt
*
7
3
4
1
5
6
7
8
9
2
D001
D002
B-7
B-2
8
IC001
1
2
3
4
5
6
7
8
9
2.7
0
7
8
9
3.4
GND
4.3
0.3
0.5
2.5
2.5
2.5
4.3
-
IC
10 1.6
11 1.6
12 GND
13 1.8
14 3.5
15 2.1
16 1.5
17 2.4
18 2.0
19 1.9
20 1.9
21 3.4
22 3.4
23 0.4
24 1.7
IC001 C-2
IC201 B-6
A
25
-
TRANSISTOR
26 1.7
27 3.8
*
Q001
Q002
Q003
Q004
Q007
D-8
D-8
B-8
B-8
B-2
1
!•
1
1
2
28
0
10 0.7
11 2.5
29 GND
30
31
32
1
0
0
0
3.4
3.4
1.6
3.3
4.2
3.4
12
0
Q010 D-10
B
C
13 0.3
14 0.0 IC201
15 3.7
Q011
Q012
Q201
Q202
Q203
D-7
D-7
D-6
B-3
D-4
!¶
1
2
1
1
2
3
16
17
18
-
-
0
4
5
6
19 2.2
VARIABLE
RESISTOR
RV001 B-3
RV002 B-3
RV004 B-3
RV201 B-3
T1 BOARD TRANSISTOR VOLTAGE LIST
D
E
B
0
C
E
Q003
3.7 GND
Q004 3.7 0.7 4.3
Q007 2.6 0.5 4.3
Q201 1.0 4.2 0.3
Q202 1.9 GND 2.6
Q203
0
1
0
3.5 GND
< Component Side >
< Conductor Side >
2
3
4
5
6
Q002
1.7 2.2 29.5 1.7 2.2
Download from Www.Somanuals.com. All Manuals Search And Download.
– 18 –
– 17 –
3
4
1
5
6
7
8
9
2
A
TO SPEAKER
2
J501
CN501
2P
UNREG
Q401
POWER SUPPLY,
LCD BACK LIGHT,
HEADPHONE AMP
D406
UN2215
MA157-TX
A
R513
2.2
B
C
CN602
12P
:CHIP
CN601
12P
R450
100k
R451
AUDIO
82k
C506
0.1
1
2
D.GND
VHF
H.P
4.5V
AUDIO
30V
H.SYNC
IND
VIDEO
A.GND
UP DOWN SW
UB
C502
:CHIP
:CHIP
3
100
6.3V
:7L
2
25V
1
1
2
D.GND
VHF
H.P.
F:CHIP
RV450
50k
C505
100
NC
NC
V+
3
30V
C501
0.01
R504
6.3V
:7L
470
4
+IN
-IN
3
B:CHIP
:CHIP
AUDIO
OUTPAT
GND
5
4
4.5V
BRT
C504
10
R509
120k
C507
TO
T1 BOARD
CN201
GND
6
5
D.GND
A.GND
H.SYNC
IND
VIDEO
A.GND
BRT
0.22
25V
16V
:7L
:CHIP
TO
B BOARD
CN301
R505
7
6
F:CHIP
470
:CHIP
IC501
8
7
R501
4.7
VIDEO
NJM2070M-TE2
1
R510
10k
:CHIP
9
8
:CHIP
CH -
S001
RV501
10k
10
11
12
VOL
9
3
2
R506
390
C503
VIDEO
1
2
0.01
10
11
12
:CHIP
B:CHIP
3
NC
S002
CH +
1
2
3
R028
10k
:CHIP
R616
VIDEO
D605
VIDEO
10k
4.5V
:CHIP
1SS355TE
30V
D
E
30V
R610
100
R615
10k
T601
D602
Q610
R605
100 :CHIP
UNREG
SB01-15CP
:CHIP
:CHIP
2SB709A-R
9
1
6
7
3
2
Q603
2SD1119-Q
D603
SB05-05CP
Q602
D601
MA8043-M
R601
47k
2SD601A-R
R617
8
UHF
68
:CHIP
R611
4.5V
L601
47µH
:CHIP
2.2k
C603
0.1
:CHIP
:FR-CP
C619
0.01
C616
0.01
R608
47k
VHF
OFF
R612
25V
330
B:CHIP
B:CHIP
B:CHIP
:CHIP
S601
:CHIP
C611
1
4
5
Q601
2SD601A-R
10
RV601
C610
220p
:7L
220
C602
0.1
R602 R603 C604
3
C617
220
16V
:7L
:CHIP
47k
22 0.0047
CH:CHIP
:CHIP :CHIP B:CHIP
25V
C605
100p
+4.5V
2
F601
F:CHIP
R604
R613
560
1A
CH:CHIP
330
125V
:CHIP
:CHIP
DRY BATTERY
3PCS. 4.5V
B-¥SS10904.<U..>-A.. (02)
L701
F
G
H
100µH
A BOARD : IC501 NJM2070M
R701
330
1/8W
:CHIP
2
3
4
1
5
NC
1
8
NC
V+
Q701
2SC2873Y
9
8
C703
22p
2kV
C702
0.22
:PP
FR701
+INPUT
-INPUT
2
3
BIAS
7
C701
100
7
6
Q702
2SC2873Y
6.3V
:7L
D701
11EQS04-TA1B
C704
0.1
+
-
J701
T701
6
5
OUTPUT
1
+
-
25V
3
2
DC IN 4.5V
F:CHIP
300Ω
50kΩ
100kΩ
GND
4
POWER
GND
Download from Www.Somanuals.com. All Manuals Search And Download.
– 19 –
– 20 –
A
[
]
AUDIO AMP, PC IN, BACK LIGHT
– A Board –
3
4
1
5
2
A BOARD
DIODE
A
*
D406
D601
D602
D603
D604
D605
D701
G-5
6
G-4
D-4
G-4
C-5
C-4
D-3
3
5
4
3
3
–
B
C
IC
IC501 G-5
TRANSISTOR
*
Q401
Q601
Q602
Q603
Q610
Q701
Q702
G-5
C-4
D-4
F-4
C-5
G-3
G-3
1
2
2
2
2
2
2
VARIABLE
RESISTOR
RV450 C-6
RV501 D-5
RV601 C-5
D
E
A BOARD IC VOLTAGE LIST
Pin Volt
< Component Side >
IC501
1
2
3
4
5
6
7
8
-
0
0.6
GND
GND
1.3
3.4
-
F
G
H
I
A BOARD TRANSISTOR VOLTAGE LIST
B
C
E
Q401 13.9 30.5 13.4
Q601 0.5 1.2 GND
Q602 0.7 3.1 0.2
Q603 0.2 3.0 GND
Q610 30.7 0.5 30.7
Q701
Q702
0
0
3.0 GND
3.0 GND
< Conductor Side >
Download from Www.Somanuals.com. All Manuals Search And Download.
– 22 –
– 21 –
• B BOARD WAVEFORMS
1
2
3
7
4
8
2.0Vp-p (4.5MHz)
1.1Vp-p (4.43MHz)
1.0Vp-p (H)
0.7Vp-p (H)
1.4Vp-p (H)
5
6
4.1Vp-p (H)
1.4Vp-p (H)
1.4Vp-p (H)
10
3
4
11
1
5
6
7
8
9
2
A
C411
0.47
C414
R415
22k
R403
47
R409
68k
D404
1SS355TE
100p
4.5V
25V
CH:CHIP
:CHIP
:CHIP
:CHIP
F:CHIP
Q402
Q407
XP4601
R405
C409
C410
Q406
XP4601
2SD1819A-R
68k
0.1
25V
0.1
25V
:CHIP
C405
R401
B:CHIP
B:CHIP
22
R411
100
6.3V
:7L
1M
R414
:CHIP
:CHIP
22k
:CHIP
FP401
1
R406
680
R413
22k
:CHIP
N.C.
TPR2
VSS
VM
VDD
TPR1
N.C.
N.C.
D1
:CHIP
R410
2
3
39k
C412
0.47
R402
100
:CHIP
R407
2.2k
C402
4.7
C406
22
Y/C JUNGLE,
R431
33k
25V
:CHIP
:CHIP
F:CHIP
35V
:7L
6.3V
:7L
C408
0.01
4
:CHIP
B
C
B
B:CHIP
MONITOR CONTROL
5
R408
2.2k
C407
47
6
:CHIP
D403
1SS355TE
6.3V
:7L
C413
100p
R412
22k
7
D401
1SS355TE
CH:CHIP :CHIP
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
D4
D3
D2
C403
22
6.3V
:7L
R404
100
R430
0
CN301
12P
:CHIP :CHIP
RESTB
VS1
VS2
VDB
VDG
VDR
VD1
CLA
CLB
CL2
VM
1
2
D.GND
VHF
H.P.
4.5V
3
R301
R307
R309
10
0
47k
4
4.5V
:CHIP
:CHIP
:CHIP
5
D.GND
A.GND
H.SYNC
IND
VIDEO
A.GND
BRT
RV301
47k
R308
4.7k
C303
C311
0.01
C301
47
6
180p
TO
A BOARD
CN601
:CHIP
:CHIP
B:CHIP :CHIP
6.3V
:7L
7
C306
8
C302
15p
R416
0.033
25V
2
4
2
4
2
4
2
4
RB405
2.2kx2 1/16W :CHIP
47
4
2
3
1
CH:CHIP
9
:CHIP
TO
LCD UNIT
B:CHIP
C415
100
R303
470
10
11
12
6.3V
:7L
X301
4.5V
:CHIP
3.58MHz
D
E
C304
0.1
CP
D1
D4
D3
VCXO
D303
MA8051
1
3
1
3
1
3
1
3
25V
NC
C432
0.001
B:CHIP
11 10
9
8
7
6
5
4
3
2
1
B:CHIP
2
24 23 22 21 20 19 18 17 16 15 14 13
VIDEO
RB401
2.2kx2
1/16W
:CHIP
RB402
2.2kx2
1/16W
:CHIP
RB403
2.2kx2
1/16W
:CHIP
RB404
2.2kx2
1/16W
:CHIP
D2
C418
0.1
12 TPR1B
13 TPR1
14 VDDC
15 CV3
VSSB 44
4.5V
IC301
RESTB
VS1
VS2
VDB
VDG
VDR
VD1
CLA
CLB
CL2
VM
25V
SGD1B 43
MUTEB 42
G2 41
5
7
4.5V
F:CHIP
M52042FP
R427
1k
:CHIP
C419
0.1
8
6
R317
4.7k
R418
1.5k
25V
3
1
2
3
4
5
6
7
8
9
10 11 12
16 CV2
R2 40
:CHIP
B:CHIP
:CHIP
IC401
A71-2980
Q408
UN5210
VIDEO
17 CV1
B2 39
R419
D301
1SS355TE
18 PLLO
19 PLLO2
20 XTI
INB 38
HSO 37
VS2 36
HIN 35
VIN 34
C420
12p
C307
4.7
10k :CHIP
4.5V
4
25V
:7L
R420
CH:CHIP
R310
R318
1k :CHIP
68k
R312
G
39k
R315
22k
:CHIP
560
:RN-CP
1
:CHIP
:CHIP
21 XTO
22 VSSC
Q302
R314
100k
X401 4.5MHz
UN5210
R311
150k
C421
12p
:CHIP
R
B
C308
R429
3.3k
R322
68k
:CHIP
680p
C315
47p
CH:CHIP
C310
0.01
CP
B:CHIP
:CHIP
R436
10k
:RN-CP
CH:CHIP
B:CHIP
N.C.
N.C.
N.C.
:CHIP
C422
23 24 25 26 27 28 29 30 31 32 33
0.001
B:CHIP
B
R320
1.5k
Q303
2SB709A-R
G
C312
0.1
R
B
:CHIP
F
25V
C423
0.001 B:CHIP
G
R
F:CHIP
R417
C314
4.7
C424
R423
R323
4.7k
0.001 B:CHIP
6.8k :CHIP
2.2M
:CHIP
Q403
UN2215
25V
:7L
:CHIP
R428
R422 10k :CHIP
C313
0.0015
B:CHIP
R316
270k
:CHIP
47k
:CHIP
R324
10k
C427
0.1
C425
4.7
4.5V
:CHIP
D302
MA8051
R421
RV402
47k
C428
0.01
10k
25V
25V
:7L
:CHIP
F:CHIP
:CHIP
B:CHIP
G
B-¥SS10904.<U..>-B.. (02)
Download from Www.Somanuals.com. All Manuals Search And Download.
– 23 –
– 24 –
B
[
]
CHROMA, LCD INTERFACE
– B Board –
3
4
1
5
2
A
B BOARD IC VOLTAGE LIST
B BOARD
DIODE
Pin Volt
Pin Volt
24 4.2
Pin Volt
23 3.4
*
IC301
1
2
3
4
5
6
7
8
9
3.0
3.1 IC401
D301
D302
D303
D401
D403
D404
D405
B-2
B-2
F-2
C-3
F-4
F-4
B-3
3
1
2
3
4
5
6
7
8
9
1.3
0
24
-
3
3
3
3
3
3
B
C
0.6
-
3.5
2.5
-
25 3.8
26 3.3
27 0.9
28 0.9
29 0.9
30 0.8
31 0.3
32 3.8
33 GND
34 1.8
35 1.1
0.8
0.8
2.7
2.7
2.8
2.8
3.3
-
IC
2.8
IC301 C-3
IC401 C-4
10 3.0
11 2.9
12 3.1
13 GND
14 0.3
10 1.9
11 3.9
12 3.9
TRANSISTOR
*
Q302
Q303
Q402
Q403
Q406
Q407
Q408
C-3
B-2
B-3
C-3
C-5
B-5
C-3
2
13
0
36
0
2
2
2
@º
@º
2
15
16
-
-
14 3.9
15 1.7
16 1.7
17 1.7
18 1.7
19 1.7
20 2.0
21 2.0
22 GND
37 0.3
38 3.6
39 GND
< Component Side >
17 1.5
18 3.7
19 1.6
20 2.0
21 3.4
40
41 2.1
42
0
D
E
0
VARIABLE
RESISTOR
RV301 B-2
RV402 C-4
43 3.5
44 GND
22
23 2.0
-
F
B BOARD TRANSISTOR VOLTAGE LIST
B
C
E
Q302 0.3 3.5 GND
Q303 3.6 1.8 4.1
Q402 3.9 4.4 3.2
Q403 2.1
0
GND
< Conductor Side >
Q408
0
1
3.8 GND
2
G
3
4
5
6
Q406 GND -0.7 6.5 12.4 13.3 6.5
Q407 1.8 6.5 1.8 1.8 13.3
0
Download from Www.Somanuals.com. All Manuals Search And Download.
– 26 –
– 25 –
SECTION 5
EXPLODED VIEW
NOTE:
4-5. SEMICONDUCTORS
• Items with no part number and no
description are not stocked because they
are seldom required for routine service
• The construction parts of an assembled part
are indicated with a collation number in the
remark column.
• Items marked " " are not stocked since
*
they are seldom required for routine
service. Some delay should be anticipated
when ordering these items.
The components identified by shading and
mark are critial for safety.
Replace only with part number specified.
A71-2980
XN4601
SB-01-15CP
SB05-05CP
!
6
5
5
3
4
5-1. CHASSIS SECTION
1
2
2
1
1
6
3
r : 7-685-104-19
+P 2x6
TOP VIEW
3
1
2
4
44 pin QFP
2
1
2
1
3
12
MA8043
MA8051
MA8240
MA8360
1SS355
AN5707NFAP
3
XP4601
13
14
6
9
5
4
15
1
1
2
TOP VIEW
6
4
5
3
ANODE
32 pin QFP
5
16
4
1
A
CATHODE
CATHODE
ANODE
2
17
3
M51348AFP
M52042FP
18
11EQS04
2SC2873Y
2SD1119-Q
20
6
19
1
19
TOP VIEW
B
C
E
24 pin SOP
NJM2070M
2SD1819A
7
22
A
21
8 7 6 5
8
3
C
1 2 3 4
2
E
23
8 pin SOP
1
B
UN2110
UN211D
UN2210
MA152WK
11
25
24
UN2215
3
UN5210
2
1
2SB709A
2SC3837KQ
2SD601A
REF. NO. PART NO.
–––––––– –––––––––
DESCRIPTION
–––––––––––––
REMARK REF. NO. PART NO.
––––––––– –––––––– –––––––––
DESCRIPTION
–––––––––––––
REMARK
–––––––––
3
1
2
3
4
5
4-561-075-51 CABINET, FRONT
4-561-076-01 SWITCH, POWER
4-561-093-03 BUTTON, CHANNEL
4-561-090-01 SHIELD, PANEL
14
15
16
4-561-097-01 INSULATING SHEET (2)
! 1-693-467-11 TUNER UNITPLETE
* A-1395-039-AT1 BOARD, COMPLETE
2
C
1
B
E
1-803-293-11 MODULE, INDICATOR (NTSC)
17
18
19
20
21
4-561-081-01 SPRING (C), BATTERY
4-561-080-01 SPRING (B), BATTERY
4-561-079-01 SPRING (A), BATTERY
4-561-078-02 CASE, BATTERY
MA157
6
7
8
* 4-048-325-01 ILLUMINATOR
* A-1136-215-AB BOARD, COMPLETE
1-517-702-11 LIGHT, BACK
XN4215
3
1-504-847-11 SPEAKER (2.8cm)
9
11
* 3-703-044-26 LABEL, CAUTION
* A-1299-522-AA BOARD, COMPLETE
2
1
22
4-561-130-01 PLATE, LOCK
3
12
13
4-561-096-01 INSULATING SHEET
4-561-091-01 SHIELD, TU
23
24
4-561-077-01 CABINET, REAR
1-754-205-11 ANTENNA, STRAP
2
1
Download from Www.Somanuals.com. All Manuals Search And Download.
– 27 –
– 28 –
FDL-PT222
T1
SECTION 6
ELECTRICAL PARTS LIST
• Items marked " * " are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these
items.
• CAPACITORS
PF : µµ F
The components identified by shading and
mark are critial for safety.
Replace only with part number specified.
!
• There are some cases the reference
number on one board overlaps on the
other board. Therefore, when ordering
parts by the reference number, please
include the board name.
• All variable and adjustable resistors have
characteristic curve B, unless otherwise noted.
When indicating parts by reference number,
please include the board name.
RESISTORS
• All resistors are in ohms
• F : nonflammable
REF. NO. PART NO.
–––––––– –––––––––
DESCRIPTION
–––––––––––––
REMARK REF. NO. PART NO.
––––––––– –––––––– –––––––––
DESCRIPTION
–––––––––––––
REMARK
–––––––––
* A-1395-039-A T1 BOARD, COMPLETE
*********************
4-561-091-01 SHIELD, TU
4-561-096-01 INSULATING SHEET
4-561-097-01 INSULATING SHEET (2)
<FILTER>
<CAPACITOR>
CF201
CF202
CF203
1-527-943-00 CERAMIC TRAP
1-760-642-11 DISCRIMINATOR, CERAMIC
1-577-559-21 FILTER, CERAMIC
C001
C002
C003
C004
C005
1-126-794-11 ELECT
1-126-513-11 ELECT
1-163-135-00 CERAMIC CHIP 560pF
1-126-513-11 ELECT
1-163-021-91 CERAMIC CHIP 0.01µF
4.7µF
20% 25V
20% 6.3V
47µF
5%
50V
47µF
20% 6.3V
10% 50V
<CONNECTOR>
C006
C007
C008
C011
C012
1-163-038-91 CERAMIC CHIP 0.1µF
25V
CN201 1-785-361-11 CONNECTOR, BOARD TO BOARD
<DIODE>
1-163-009-91 CERAMIC CHIP 0.001µF 10% 50V
1-164-005-11 CERAMIC CHIP 0.47µF
1-126-791-11 ELECT
25V
20% 16V
16V
10µF
1-164-346-11 CERAMIC CHIP 1µF
D001
D002
8-719-801-78 DIODE MA152WK-TX
8-719-800-76 DIODE MA157-TX
C014
C015
C016
C021
C101
1-163-038-91 CERAMIC CHIP 0.1µF
1-163-251-11 CERAMIC CHIP 100pF
1-163-038-91 CERAMIC CHIP 0.1µF
1-163-038-91 CERAMIC CHIP 0.1µF
1-164-346-11 CERAMIC CHIP 1µF
25V
5%
50V
25V
25V
16V
<IC>
IC001
IC201
8-759-332-43 IC AN5707NFAP
8-759-176-91 IC M51348AFP-E1
C105
C202
C203
C204
C205
1-163-005-91 CERAMIC CHIP 470pF
1-163-021-91 CERAMIC CHIP 0.01µF
1-163-038-91 CERAMIC CHIP 0.1µF
10% 50V
10% 50V
25V
1-163-009-91 CERAMIC CHIP 0.001µF 10% 50V
1-126-791-11 ELECT 10µF 20% 16V
<JACK>
J101
1-568-027-21 JACK, SMALL TYPE (EXT ANT)
C206
C207
C209
C210
C211
1-163-237-11 CERAMIC CHIP 27pF
1-163-227-11 CERAMIC CHIP 10pF
1-163-021-91 CERAMIC CHIP 0.01µF
1-163-021-91 CERAMIC CHIP 0.01µF
1-163-021-91 CERAMIC CHIP 0.01µF
5%
50V
0.50pF 50V
10% 50V
10% 50V
10% 50V
<COIL>
L201
L205
L206
1-412-953-11 INDUCTOR
1-412-938-11 INDUCTOR
1-412-939-11 INDUCTOR
15µH
0.82µH
1µH
C212
C213
C215
C218
C219
1-163-021-91 CERAMIC CHIP 0.01µF
1-163-021-91 CERAMIC CHIP 0.01µF
10% 50V
10% 50V
20% 6.3V
10% 50V
20% 50V
1-126-513-11 ELECT
1-163-021-91 CERAMIC CHIP 0.01µF
1-115-873-11 ELECT
47µF
<TRANSISTOR>
3.3µF
Q001
Q002
Q003
Q004
Q007
8-729-216-22 TRANSISTOR 2SB709A-R-TX
8-729-402-84 TRANSISTOR XN4601-TW
8-729-424-76 TRANSISTOR UN2210-TX
8-729-424-38 TRANSISTOR UN2110-TX
8-729-424-45 TRANSISTOR UN211D-TX
C222
C223
C224
C225
C226
1-126-791-11 ELECT
1-115-871-11 ELECT
1-163-021-91 CERAMIC CHIP 0.01µF
1-163-021-91 CERAMIC CHIP 0.01µF
1-163-021-91 CERAMIC CHIP 0.01µF
10µF
20% 16V
20% 50V
10% 50V
10% 50V
10% 50V
1µF
Q010
Q011
Q012
Q201
Q202
8-729-403-45 TRANSISTOR XN1115-TX
8-729-422-54 TRANSISTOR XN4215-TW
8-729-424-76 TRANSISTOR UN2210-TX
8-729-031-37 TRANSISTOR 2SC3837KT146Q
8-729-216-22 TRANSISTOR 2SB709A-R-TX
C228
C229
C234
C235
C236
1-163-021-91 CERAMIC CHIP 0.01µF
1-163-021-91 CERAMIC CHIP 0.01µF
1-163-021-91 CERAMIC CHIP 0.01µF
10% 50V
10% 50V
10% 50V
1-163-009-91 CERAMIC CHIP 0.001µF 10% 50V
1-126-514-11 ELECT 22µF 20% 6.3V
Download from Www.Somanuals.com. All Manuals Search And Download.
– 29 –
FDL-PT222
The components identified by
shading and mark ! are criti-
cal for safety.
Replace only with part number
specified.
T1 B
REF. NO. PART NO.
–––––––– –––––––––
DESCRIPTION
–––––––––––––
REMARK REF. NO. PART NO.
––––––––– –––––––– –––––––––
DESCRIPTION
–––––––––––––
REMARK
–––––––––
R235
R240
R241
1-216-067-00 RES-CHIP
1-216-073-91 RES-CHIP
1-216-103-00 RES-CHIP
5.6K
10K
180K
5%
5%
5%
1/10W
1/10W
1/10W
Q203
8-729-424-76 TRANSISTOR UN2210-TX
<RESISTOR>
R242
R243
1-216-041-00 RES-CHIP
1-216-081-00 RES-CHIP
470
22K
5%
5%
1/10W
1/10W
R001
R002
R003
R004
R005
1-216-097-11 RES-CHIP
1-216-097-11 RES-CHIP
1-216-093-91 RES-CHIP
1-216-089-91 RES-CHIP
1-216-101-00 RES-CHIP
100K
100K
68K
47K
150K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
<VARIABLE RESISTOR>
RV001 1-223-588-11 RES, ADJ, CARBON 47K (CHANNEL
DISPLAY POSITION 13ch)
RV002 1-223-588-11 RES, ADJ, CARBON 47K (CHANNEL
DISPLAY POSITION 1ch)
RV004 1-223-589-11 RES, ADJ, CARBON 100K (CHANNEL
DISPLAY POSITION 12ch)
R008
R009
R010
R011
R012
1-218-762-11 METAL CHIP
1-216-687-11 METAL CHIP
1-216-298-00 RES-CHIP
1-216-073-91 RES-CHIP
1-216-109-00 RES-CHIP
270K
33K
2.2
10K
330K
0.5% 1/10W
0.5% 1/10W
5%
5%
5%
1/10W
1/10W
1/10W
RV201 1-223-583-11 RES, ADJ, CARBON 1K (RF AGC)
R013
R014
R016
R017
R018
1-216-091-00 RES-CHIP
1-216-689-11 RES-CHIP
1-216-689-11 RES-CHIP
1-216-079-00 RES-CHIP
1-216-097-11 RES-CHIP
56K
39K
39K
18K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
<SAW FILTER>
SWF201 1-767-766-12 FILTER, SAW
R021
R022
R023
R029
R030
1-216-097-11 RES-CHIP
1-216-083-00 RES-CHIP
1-216-295-91 SHORT
1-216-041-00 RES-CHIP
1-216-295-91 SHORT
100K
27K
0
470
0
5%
5%
1/10W
1/10W
<TRANSFORMER>
T101
T201
T202
1-437-418-21 TRANSFORMER, BALUN
1-411-278-11 COIL
1-411-278-11 COIL
5%
1/10W
R031
R032
R046
R047
R101
1-216-095-00 RES-CHIP
1-216-057-00 RES-CHIP
1-216-089-91 RES-CHIP
1-216-073-91 RES-CHIP
1-216-025-11 RES-CHIP
82K
2.2K
47K
10K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
<TUNER>
TU101! 1-693-467-11 TUNER UNIT
R201
R202
R205
R206
R208
1-216-045-00 RES-CHIP
1-216-033-00 RES-CHIP
1-216-097-11 RES-CHIP
1-216-055-00 RES-CHIP
1-216-045-00 RES-CHIP
680
220
100K
1.8K
680
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
*************************************************************************************************************
* A-1136-215-A B BOARD, COMPLETE
*********************
R209
R210
R212
R213
R214
1-216-055-00 RES-CHIP
1-216-085-91 RES-CHIP
1-216-045-00 RES-CHIP
1-216-073-91 RES-CHIP
1-216-049-11 RES-CHIP
1.8K
33K
680
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
<CAPACITOR>
C301
C302
C303
C304
C306
1-126-513-11 ELECT
47µF
20% 6.3V
1-163-231-11 CERAMIC CHIP 15pF
1-163-257-11 CERAMIC CHIP 180pF
1-164-004-11 CERAMIC CHIP 0.1µF
5%
5%
50V
50V
R215
R216
R217
R218
R219
1-216-001-00 RES-CHIP
1-216-051-00 RES-CHIP
1-216-061-91 RES-CHIP
1-216-021-00 RES-CHIP
1-216-039-00 RES-CHIP
10
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1.2K
3.3K
68
10% 25V
1-163-989-11 CERAMIC CHIP 0.033µF 10% 25V
390
C307
C308
C309
C310
C311
1-126-794-11 ELECT
4.7µF
20% 25V
10% 50V
10% 25V
10% 50V
10% 50V
1-163-007-11 CERAMIC CHIP 680pF
1-164-004-11 CERAMIC CHIP 0.1µF
1-163-021-91 CERAMIC CHIP 0.01µF
1-163-021-91 CERAMIC CHIP 0.01µF
R220
R221
R223
R224
R225
1-216-017-91 RES-CHIP
1-216-049-11 RES-CHIP
1-216-049-11 RES-CHIP
1-216-053-00 RES-CHIP
1-216-065-91 RES-CHIP
47
1K
1K
1.5K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C312
C313
C314
C402
C403
1-163-038-91 CERAMIC CHIP 0.1µF
25V
1-163-011-11 CERAMIC CHIP 0.0015µF 10% 50V
R226
R228
R229
R230
R231
1-216-061-91 RES-CHIP
1-216-073-91 RES-CHIP
1-216-071-00 RES-CHIP
1-216-001-00 RES-CHIP
1-216-001-00 RES-CHIP
3.3K
10K
8.2K
10
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1-126-794-11 ELECT
1-115-866-11 ELECT
1-126-514-11 ELECT
4.7µF
4.7µF
22µF
20% 25V
20% 35V
20% 6.3V
10
C405
C406
C407
1-126-514-11 ELECT
1-126-514-11 ELECT
1-126-513-11 ELECT
22µF
22µF
47µF
20% 6.3V
20% 6.3V
20% 6.3V
R233
R234
1-216-025-11 RES-CHIP
1-216-051-00 RES-CHIP
100
1.2K
5%
5%
1/10W
1/10W
Download from Www.Somanuals.com. All Manuals Search And Download.
– 30 –
FDL-PT222
B
REF. NO. PART NO.
–––––––– –––––––––
DESCRIPTION
–––––––––––––
REMARK REF. NO. PART NO.
––––––––– –––––––– –––––––––
DESCRIPTION
–––––––––––––
REMARK
–––––––––
C408
C409
1-163-021-91 CERAMIC CHIP 0.01µF
10% 50V
10% 25V
1-164-004-11 CERAMIC CHIP 0.1µF
R307
R308
R309
R310
R311
1-216-089-91 RES-CHIP
1-216-073-91 RES-CHIP
1-216-001-00 RES-CHIP
1-216-093-91 RES-CHIP
1-216-101-00 RES-CHIP
47K
10K
10
68K
150K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C410
C411
C412
C413
C414
1-164-004-11 CERAMIC CHIP 0.1µF
1-164-005-11 CERAMIC CHIP 0.47µF
1-164-005-11 CERAMIC CHIP 0.47µF
1-163-251-11 CERAMIC CHIP 100pF
1-163-251-11 CERAMIC CHIP 100pF
10% 25V
25V
25V
5%
5%
50V
50V
R312
R313
R314
R315
R316
1-216-043-91 RES-CHIP
1-216-113-00 RES-CHIP
1-216-097-11 RES-CHIP
1-216-081-00 RES-CHIP
1-216-107-00 RES-CHIP
560
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
470K
100K
22K
C415
C418
C419
C420
C421
1-126-382-11 ELECT
100µF
20% 6.3V
25V
10% 25V
1-163-038-91 CERAMIC CHIP 0.1µF
1-164-004-11 CERAMIC CHIP 0.1µF
1-163-229-11 CERAMIC CHIP 12pF
1-163-229-11 CERAMIC CHIP 12pF
270K
5%
5%
50V
50V
R317
R318
1-216-065-91 RES-CHIP
1-216-689-11 METAL
4.7K
CHIP
5%
1/10W
39K 0.5%
1/10W
1/10W
68K 0.5%
1/10W
1/10W
C422
C423
C424
C425
C427
1-163-009-91 CERAMIC CHIP 0.001µF 10% 50V
1-163-009-91 CERAMIC CHIP 0.001µF 10% 50V
1-163-009-91 CERAMIC CHIP 0.001µF 10% 50V
R320
R322
1-216-053-00 RES-CHIP
1-216-695-11 METAL
1.5K
CHIP
5%
1-126-794-11 ELECT
1-163-038-91 CERAMIC CHIP 0.1µF
4.7µF
20% 25V
25V
R323
1-216-129-00 RES-CHIP
2.2M
5%
C428
C432
1-163-021-91 CERAMIC CHIP 0.01µF
10% 50V
R324
R401
R402
R403
R404
1-216-073-91 RES-CHIP
1-216-025-11 RES-CHIP
1-216-025-11 RES-CHIP
1-216-017-91 RES-CHIP
1-216-025-11 RES-CHIP
10K
100
100
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1-163-009-91 CERAMIC CHIP 0.001µF 10% 50V
<CONNECTOR>
100
CN301 * 1-779-896-11 CONNECTOR, BOARD TO BOARD 12P
<DIODE>
R405
R406
R407
R408
R409
1-216-093-91 RES-CHIP
1-216-045-00 RES-CHIP
1-216-057-00 RES-CHIP
1-216-057-00 RES-CHIP
1-216-093-91 RES-CHIP
68K
680
2.2K
2.2K
68K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
D301
D302
D303
D401
D403
8-719-988-61 DIODE 1SS355TE-17
8-719-422-37 DIODE MA8051-TX
8-719-422-37 DIODE MA8051-TX
8-719-988-61 DIODE 1SS355TE-17
8-719-988-61 DIODE 1SS355TE-17
R410
R411
R412
R413
R414
1-216-689-11 RES-CHIP
1-216-121-11 RES-CHIP
1-216-081-00 RES-CHIP
1-216-081-00 RES-CHIP
1-216-081-00 RES-CHIP
39K
1M
22K
22K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
D404
D405
8-719-988-61 DIODE 1SS355TE-17
8-719-988-61 DIODE 1SS355TE-17
R415
R416
R417
R418
R419
1-216-081-00 RES-CHIP
1-216-017-91 RES-CHIP
1-216-065-91 RES-CHIP
1-216-053-00 RES-CHIP
1-216-073-91 RES-CHIP
22K
47
4.7K
1.5K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
<IC>
IC301
IC401
8-759-332-41 IC M52042FP-600C
8-759-368-68 IC A71-2980
R420
R421
R422
R423
R424
1-216-049-11 RES-CHIP
1-216-073-91 RES-CHIP
1-216-073-91 RES-CHIP
1-216-069-00 RES-CHIP
1-216-059-00 RES-CHIP
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
10K
10K
6.8K
2.7K
<TRANSISTOR>
Q302
Q303
Q402
Q403
Q406
8-729-420-44 TRANSISTOR UN5210-TX
8-729-216-22 TRANSISTOR 2SB709A-R-TX
8-729-402-32 TRANSISTOR 2SD1819A-R-TX
8-729-902-99 TRANSISTOR UN2215-QRS(TX)
8-729-427-74 TRANSISTOR XP4601-TXE
R427
R428
R429
R430
R431
1-216-049-11 RES-CHIP
1-216-089-91 RES-CHIP
1-216-061-91 RES-CHIP
1-216-295-91 SHORT
1K
5%
5%
5%
1/10W
1/10W
1/10W
47K
3.3K
0
1-216-085-91 RES-CHIP
33K
5%
5%
1/10W
1/10W
Q407
Q408
8-729-427-74 TRANSISTOR XP4601-TXE
8-729-420-44 TRANSISTOR UN5210-TX
R436
1-216-073-91 RES-CHIP
10K
<RESISTOR>
<NETWORK RESISTOR>
R301
R303
R304
R305
R306
1-216-295-91 SHORT
0
RB401 1-236-416-11 NETWORK, RES 2.2K
RB402 1-236-416-11 NETWORK, RES 2.2K
RB403 1-236-416-11 NETWORK, RES 2.2K
RB404 1-236-416-11 NETWORK, RES 2.2K
RB405 1-236-416-11 NETWORK, RES 2.2K
1-216-041-00 RES-CHIP
1-216-061-91 RES-CHIP
1-216-089-91 RES-CHIP
1-216-121-11 RES-CHIP
470
3.3K
47K
1M
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
Download from Www.Somanuals.com. All Manuals Search And Download.
– 31 –
FDL-PT222
The components identified by
shading and mark ! are criti-
cal for safety.
Replace only with part number
specified.
A
REF. NO. PART NO.
–––––––– –––––––––
DESCRIPTION
–––––––––––––
REMARK REF. NO. PART NO.
––––––––– –––––––– –––––––––
DESCRIPTION
–––––––––––––
REMARK
–––––––––
D603
D604
8-719-938-75 DIODE SB05-05CP-TB
8-719-018-15 DIODE MA8360-TX
<VARIABLE RESISTOR>
D605
D701
8-719-988-61 DIODE 1SS355TE-17
8-719-210-21 DIODE 11EQS04-TA1B
RV301 1-223-588-11 RES, ADJ, CARBON 47K (TINT)
RV402 1-223-588-11 RES, ADJ, CARBON 47K (CONTRAST)
<FUSE>
<CRYSTAL>
F601 ! 1-533-631-31 FUSE, MICRO 1A 125V
X301
X401
1-567-505-11 OSCILLATOR, CRYSTAL 3.58MHz
1-760-601-21 VIBRATOR, CRYSTAL 4.5MHZ
<IC>
IC501
8-759-046-84 IC NJM2070M-TE2
<JACK>
*************************************************************************************************************
* A-1299-522-A A BOARD, COMPLETE
*********************
J501
J701
1-563-282-11 JACK, SMALL TYPE (2)
1-568-907-21 JACK, DC(POLARITY UNIFIED TYPE)
(DC IN 4.5V)
<CAPACITOR>
C501
C502
C503
C504
C505
1-163-021-91 CERAMIC CHIP 0.01µF
1-126-382-11 ELECT 100µF
10% 50V
20% 6.3V
<COIL>
1-163-017-00 CERAMIC CHIP 0.0047µF 10% 50V
L601
L701
1-412-031-11 INDUCTOR
1-408-615-31 INDUCTOR
47µH
100µH
1-126-791-11 ELECT
1-126-382-11 ELECT
10µF
100µF
20% 16V
20% 6.3V
C506
C507
C601
C602
C603
1-163-038-91 CERAMIC CHIP 0.1µF
25V
25V
20% 10V
25V
<TRANSISTOR>
1-164-222-91 CERAMIC CHIP 0.22µF
1-126-382-11 ELECT
1-163-038-91 CERAMIC CHIP 0.1µF
1-164-004-11 CERAMIC CHIP 0.1µF
100µF
Q401
Q601
Q602
Q603
Q610
8-729-902-99 TRANSISTOR UN2215-QRS(TX)
8-729-422-29 TRANSISTOR 2SD601A-R-TX
8-729-422-29 TRANSISTOR 2SD601A-R-TX
8-729-421-15 TRANSISTOR 2SD1119-Q-TX
8-729-216-22 TRANSISTOR 2SB709A-R-TX
10% 25V
C604
C605
C610
C611
C612
1-163-017-00 CERAMIC CHIP 0.0047µF 10% 50V
1-163-251-11 CERAMIC CHIP 100pF
1-163-259-91 CERAMIC CHIP 220pF
5%
5%
50V
50V
20% 50V
10% 50V
Q701
Q702
8-729-807-51 TRANSISTOR 2SC2873Y-TE12L
8-729-807-51 TRANSISTOR 2SC2873Y-TE12L
1-126-795-11 ELECT
1-163-021-91 CERAMIC CHIP 0.01µF
10µF
C613
C614
C615
C616
C617
1-128-499-11 ELECT
220µF
20% 16V
10% 50V
10% 50V
10% 50V
20% 16V
<RESISTOR>
1-163-021-91 CERAMIC CHIP 0.01µF
1-163-021-91 CERAMIC CHIP 0.01µF
1-163-021-91 CERAMIC CHIP 0.01µF
R028
R450
R451
R501
R504
1-216-073-91 RES-CHIP
1-216-097-11 RES-CHIP
1-216-095-00 RES-CHIP
1-216-308-00 RES-CHIP
1-216-041-00 RES-CHIP
10K
100K
82K
4.7
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1-128-499-11 ELECT
220µF
C619
C701
C702
C703
C704
1-163-021-91 CERAMIC CHIP 0.01µF
1-126-382-11 ELECT
1-136-169-00 FILM
1-109-879-11 CERAMIC
1-163-038-91 CERAMIC CHIP 0.1µF
10% 50V
20% 6.3V
470
100µF
0.22µF
22pF
5%
5%
50V
2KV
25V
R505
R506
R509
R510
R513
1-216-041-00 RES-CHIP
1-216-039-00 RES-CHIP
1-216-099-00 RES-CHIP
1-216-073-91 RES-CHIP
1-216-298-00 RES-CHIP
470
390
120K
10K
2.2
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
<CONNECTOR>
R601
R602
R603
R604
R605
1-216-089-91 RES-CHIP
1-216-089-91 RES-CHIP
1-216-009-91 RES-CHIP
1-216-037-00 RES-CHIP
1-216-025-11 RES-CHIP
47K
47K
22
330
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
CN501 1-568-951-11 PIN, CONNECTOR 2P
CN601 * 1-770-605-11 CONNECTOR, BOARD TO BOARD 12P
CN602 * 1-770-605-11 CONNECTOR, BOARD TO BOARD 12P
<DIODE>
R608
R610
R611
R612
R613
1-216-089-91 RES-CHIP
1-216-025-11 RES-CHIP
1-216-057-00 RES-CHIP
1-216-037-00 RES-CHIP
1-216-043-91 RES-CHIP
47K
100
2.2K
330
560
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
D406
D601
D602
8-719-800-76 DIODE MA157-TX
8-719-421-82 DIODE MA8043-M(TX)
8-719-989-93 DIODE SB01-15CP-TB
Download from Www.Somanuals.com. All Manuals Search And Download.
– 32 –
FDL-PT222
The components identified by
shading and mark ! are criti-
cal for safety.
Replace only with part number
specified.
A
REF. NO. PART NO.
–––––––– –––––––––
DESCRIPTION
–––––––––––––
REMARK
–––––––––
R614
R615
R616
R617
R701
1-216-085-91 RES-CHIP
1-216-073-91 RES-CHIP
1-216-073-91 RES-CHIP
1-216-021-00 RES-CHIP
1-216-186-00 RES-CHIP
33K
10K
10K
68
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
330
<VARIABLE RESISTOR>
RV450 1-223-901-21 RES, VAR 50K (BRT)
RV501 1-223-900-21 RES, VAR 10K (VOL)
RV601 1-223-581-11 RES, ADJ, CARBON 220 (+4.5V)
<SWITCH>
S001
S002
S601
1-571-532-21 SWITCH, TACTIL (CH -)
1-571-532-21 SWITCH, TACTIL (CH +)
1-762-368-11 SWITCH, SLIDE (OFF/VHF/UHF)
<TRANSFORMER>
T601 ! 1-431-580-11 TRANSFORMER, DC-DC CONVERTER
T701 1-427-918-11 TRANSFORMER, CONVERTER
************************************************************************************************************
MISCELLANEOUS
*****************
1-504-847-11 SPEAKER (2.8cm)
1-517-702-11 LIGHT, BACK
1-754-205-11 ANTENNA, STRAP
1-803-293-11 MODULE, INDICATOR (NTSC)
************************************************************************************************************
ACCESSORIES
*************
4-083-376-11 MANUAL, INSTRUCTION
Download from Www.Somanuals.com. All Manuals Search And Download.
– 33 –
FDL-PT222
Sony EMCS Corporation
IchinomiyaTec.
Quality Assurance Division
English
2001DR02-1
©2001.4
9-965-300-01
Download from Www.Somanuals.com. All Manuals Search And Download.
– 34 –
|