Mazda North American Operations
Irvine, CA 92618-2922
Service Bulletin
© 2006 Mazda Motor of America, Inc.
Subject:
Bulletin No: 09-033/06
CENTER CONSOLE LID WILL NOT STAY CLOSED
Last Issued: 7/21/2006
2006 MX-5 - CENTER CONSOLE LID WILL NOT STAY CLOSED
APPLICABLE MODEL(S)/VINS
2006 MX-5
DESCRIPTION
On some vehicles, the center console lid may not stay in the closed position due to a broken latch.
Customers having this concern should have the console lid replaced using the following repair procedure.
REPAIR PROCEDURE
1. Verify customer concern.
2. Remove the center console from the vehicle. Refer to Workshop Manual section 09-17 CONSOLE
REMOVAL / INSTALLATION.
3. Remove the cup holder from the center console. Refer to Workshop Manual section 09-17 CONSOLE DIS-
ASSEMBLY / ASSEMBLY.
4. Slide open center console lid fully to rear position.
5. Identify rear guides for console lid.
CENTER CONSOLE LID
REAR GUIDES
FRONT GUIDES
1653a
Page 1 of 5
CONSUMER NOTICE: The information and instructions in this bulletin are intended for use by skilled technicians. Mazda technicians utilize the proper tools/
equipment and take training to correctly and safely maintain Mazda vehicles. These instructions should not be performed by “do-it-yourselfers.” Customers
should not assume this bulletin applies to their vehicle or that their vehicle will develop the described concern. To determine if the information applies,
customers should contact their nearest authorized Mazda dealership. Mazda North American Operations reserves the right to alter the specifications and
contents of this bulletin without obligation or advance notice. All rights reserved. No part of this bulletin may be reproduced in any form or by any means,
electronic or mechanical---including photocopying and recording and the use of any kind of information storage and retrieval system ---without permission in
writing.
Download from Www.Somanuals.com. All Manuals Search And Download.
Bulletin No: 09-033/06
Last Issued: 7/21/2006
© 2006 Mazda Motor of America, Inc.
9. Remove guides from old console lid.
NOTE:
•
Make note of sides of cup holder assembly guides are removed from for installation. Guides
cannot be installed backward or on opposite sides. Attempting to do so may damage the guides
and/or the cup holder assembly.
10. Install old guides onto new console lid. Line up with front edge of guides with front of lid.
PLACE GUIDES
ONTO NEW CENTER
CONSOLE LID
1653e
11. Insert first tab of both guides into cup holder assembly.
INSERT FIRST TAB OF BOTH GUIDES
INTO CUP HOLDER ASSEMBLY
1653f
Page 3 of 5
Download from Www.Somanuals.com. All Manuals Search And Download.
Bulletin No: 09-033/06
Last Issued: 7/21/2006
© 2006 Mazda Motor of America, Inc.
12. Carefully lay lid and guides down to line up remaining tabs.
13. Using a flat-tipped screwdriver, slide guide forward to engage tabs to sides of cup holder assembly.
PLACE FLAT TIPPED SCREWDRIVER
INTO SLOT AND SLIDE GUIDE TOWARD
FRONT OF CUP HOLDER TO ENGAGE
TABS (REPEAT FOR BOTH SIDES)
1653g
GUIDE TAB SHOWN DISENGAGED
1653h
GUIDE TAB SHOWN ENGAGED
14. Slide center console lid to fully closed position.
Page 4 of 5
Download from Www.Somanuals.com. All Manuals Search And Download.
Bulletin No: 09-033/06
Last Issued: 7/21/2006
© 2006 Mazda Motor of America, Inc.
15. Press down on rear of guides to ensure they are properly seated into cup holder assembly.
FIRMLY PRESS DOWN ON REAR
OF GUIDES TO ENSURE REAR
TABS LOCK INTO POSITION
1653i
16. Install cup holder to center console.
17. Install center console to vehicle.
18. Verify repair.
PART(S) INFORMATION
Part Number
Description
Qty.
1
Notes
Black
Tan
NE51-64-390 -02
NE51-64-390 -89
Center Console Lid Ass’y
Center Console Lid Ass’y
1
WARRANTY INFORMATION
NOTE:
•
•
This warranty information applies only to verified customer complaints on vehicles eligible for war-
ranty repair. Refer to the Warranty Wizard for warranty term information.
Additional diagnostic time cannot be claimed for this repair.
Warranty Type
A
Symptom Code
64
Damage Code
9A
SEE PART(S) INFORMATION
1
Part Number Main Cause
Quantity
Operation Number / Labor Hours:
XXB337RX / 0.4 Hrs
Page 5 of 5
Download from Www.Somanuals.com. All Manuals Search And Download.
|