Lenovo Tablet T420 User Manual

ThinkPad T420 and T420i  
Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Contents  
Power management  
41  
41  
41  
41  
43  
43  
45  
46  
46  
46  
48  
48  
Hibernation mode  
1
2
3
Electrical safety .  
Safety inspection guide .  
Error messages  
discharge.  
3
4
5
translations) .  
17  
23  
23  
board  
24  
24  
Screw notices .  
57  
58  
25  
25  
unit  
58  
59  
59  
FRU identification for CTO, CMV, and GAV  
products .  
Retaining the UUID .  
25  
28  
29  
29  
31  
33  
34  
34  
34  
35  
35  
62  
63  
64  
65  
(SSD)  
66  
69  
1050 DIMM slot cover.  
computer)  
70  
71  
73  
77  
79  
81  
1080 Keyboard  
1100 Backup battery .  
37  
38  
38  
38  
39  
39  
39  
Passwords .  
Bluethooth daughter card  
83  
88  
90  
91  
© Copyright Lenovo 2011  
i
Download from Www.Somanuals.com. All Manuals Search And Download.  
1180 CPU  
93  
97  
101  
125  
127  
128  
cable  
102  
106  
1200 Magnesium structure frame  
130  
150  
154  
156  
158  
159  
160  
166  
LCD FRUs  
Keyboard.  
assembly .  
108  
110  
112  
113  
115  
117  
119  
Miscellaneous parts  
Power cords  
Recovery discs  
120  
122  
Trademarks . .  
168  
169  
ii ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
About this manual  
This manual contains service and reference information for the following ThinkPad® products.  
ThinkPad T420 and T420i  
Machine Type 4177, 4178, 4179, 4180, 4236, 4237, and 4238  
Use this manual along with the advanced diagnostic tests to troubleshoot problems.  
Important:  
This manual is intended only for trained service technicians who are familiar with ThinkPad products. Use this  
manual along with the advanced diagnostic tests to troubleshoot problems effectively.  
Before servicing a ThinkPad product, be sure to read all the information under Chapter 1 “Safety information” on  
© Copyright Lenovo 2011  
iii  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
iv ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Chapter 1. Safety information  
This chapter presents following safety information that you need to be familiar with before you service  
a ThinkPad Notebook.  
“Electrical safety” on page 2  
“Safety inspection guide” on page 3  
“Grounding requirements” on page 4  
General safety  
Follow these rules to ensure general safety:  
• Observe good housekeeping in the area of the machines during and after maintenance.  
• When lifting any heavy object:  
1. Make sure that you can stand safely without slipping.  
2. Distribute the weight of the object equally between your feet.  
3. Use a slow lifting force. Never move suddenly or twist when you attempt to lift.  
4. Lift by standing or by pushing up with your leg muscles; this action removes the strain from the  
muscles in your back. Do not attempt to lift any object that weighs more than 16 kg (35 lb) or that  
you think is too heavy for you.  
• Do not perform any action that causes hazards to the customer, or that makes the equipment unsafe.  
• Before you start the machine, make sure that other service technicians and the customer's personnel are  
not in a hazardous position.  
• Place removed covers and other parts in a safe place, away from all personnel, while you are servicing  
the machine.  
• Keep your toolcase away from walk areas so that other people will not trip over it.  
• Do not wear loose clothing that can be trapped in the moving parts of a machine. Make sure that your  
sleeves are fastened or rolled up above your elbows. If your hair is long, fasten it.  
• Insert the ends of your necktie or scarf inside clothing or fasten it with a nonconductive clip, about 8  
centimeters (3 inches) from the end.  
• Do not wear jewelry, chains, metal-frame eyeglasses, or metal fasteners for your clothing.  
Attention: Metal objects are good electrical conductors.  
• Wear safety glasses when you are hammering, drilling, soldering, cutting wire, attaching springs, using  
solvents, or working in any other conditions that might be hazardous to your eyes.  
• After service, reinstall all safety shields, guards, labels, and ground wires. Replace any safety device  
that is worn or defective.  
• Reinstall all covers correctly before returning the machine to the customer.  
• Fan louvers on the machine help to prevent overheating of internal components. Do not obstruct fan  
louvers or cover them with labels or stickers.  
© Copyright Lenovo 2011  
1
Download from Www.Somanuals.com. All Manuals Search And Download.  
       
Electrical safety  
Observe the following rules when working on electrical equipment.  
Important:  
Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does  
not insulate you when working with live electrical currents.  
Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease  
electrostatic discharges. Do not use this type of mat to protect yourself from electrical shock.  
• Find the room emergency power-off (EPO) switch, disconnecting switch, or electrical outlet. If an electrical  
accident occurs, you can then operate the switch or unplug the power cord quickly.  
• Do not work alone under hazardous conditions or near equipment that has hazardous voltages.  
• Disconnect all power before:  
– Performing a mechanical inspection  
– Working near power supplies  
– Removing or installing main units  
• Before you start to work on the machine, unplug the power cord. If you cannot unplug it, ask the customer  
to power-off the wall box that supplies power to the machine, and to lock the wall box in the off position.  
• If you need to work on a machine that has exposed electrical circuits, observe the following precautions:  
– Ensure that another person, familiar with the power-off controls, is near you.  
Attention: Another person must be there to switch off the power, if necessary.  
– Use only one hand when working with powered-on electrical equipment; keep the other hand in your  
pocket or behind your back.  
Attention: An electrical shock can occur only when there is a complete circuit. By observing the above  
rule, you may prevent a current from passing through your body.  
– When using testers, set the controls correctly and use the approved probe leads and accessories for  
that tester.  
– Stand on suitable rubber mats (obtained locally, if necessary) to insulate you from grounds such as  
metal floor strips and machine frames.  
Observe the special safety precautions when you work with very high voltages; Instructions for these  
precautions are in the safety sections of maintenance information. Use extreme care when measuring  
high voltages.  
• Regularly inspect and maintain your electrical hand tools for safe operational condition.  
• Do not use worn or broken tools and testers.  
Never assume that power has been disconnected from a circuit. First, check that it has been powered off.  
• Always look carefully for possible hazards in your work area. Examples of these hazards are moist floors,  
nongrounded power extension cables, power surges, and missing safety grounds.  
• Do not touch live electrical circuits with the reflective surface of a plastic dental mirror. The surface is  
conductive; such touching can cause personal injury and machine damage.  
• Do not service the following parts with the power on when they are removed from their normal operating  
places in a machine:  
– Power supply units  
– Pumps  
– Blowers and fans  
– Motor generators  
– Similar units to listed above  
This practice ensures correct grounding of the units.  
• If an electrical accident occurs:  
2
ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
– Use caution; do not become a victim yourself.  
– Switch off power.  
– Send another person to get medical aid.  
Safety inspection guide  
The purpose of this inspection guide is to assist you in identifying potentially unsafe conditions. As each  
machine was designed and built, required safety items were installed to protect users and service technicians  
from injury. This guide addresses only those items. You should use good judgment to identify potential  
safety hazards due to attachment of non-ThinkPad features or options not covered by this inspection guide.  
If any unsafe conditions are present, you must determine how serious the apparent hazard could be and  
whether you can continue without first correcting the problem.  
Consider these conditions and the safety hazards they present:  
• Electrical hazards, especially primary power (primary voltage on the frame can cause serious or fatal  
electrical shock)  
• Explosive hazards, such as a damaged CRT face or a bulging capacitor  
• Mechanical hazards, such as loose or missing hardware  
To determine whether there are any potentially unsafe conditions, use the following checklist at the beginning  
of every service task. Begin the checks with the power off, and the power cord disconnected.  
Checklist:  
1. Check exterior covers for damage (loose, broken, or sharp edges).  
2. Power off the computer. Disconnect the power cord.  
3. Check the power cord for:  
a. A third-wire ground connector in good condition. Use a meter to measure third-wire ground  
continuity for 0.1 ohm or less between the external ground pin and the frame ground.  
b. The power cord should be the type specified in the parts list.  
c. Insulation must not be frayed or worn.  
4. Check for cracked or bulging batteries.  
5. Remove the cover.  
6. Check for any obvious non-ThinkPad alterations. Use good judgment as to the safety of any  
non-ThinkPad alterations.  
7. Check inside the unit for any obvious unsafe conditions, such as metal filings, contamination, water or  
other liquids, or signs of fire or smoke damage.  
8. Check for worn, frayed, or pinched cables.  
9. Check that the power-supply cover fasteners (screws or rivets) have not been removed or tampered with.  
Handling devices that are sensitive to electrostatic discharge  
Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to  
electrostatic discharge(ESD). ESD damage can occur when there is a difference in charge between objects.  
Protect against ESD damage by equalizing the charge so that the machine, the part, the work mat, and the  
person handling the part are all at the same charge.  
Chapter 1. Safety information  
Download from Www.Somanuals.com. All Manuals Search And Download.  
3
       
Notes:  
1. Use product-specific ESD procedures when they exceed the requirements noted here.  
2. Make sure that the ESD protective devices you use have been certified (ISO 9000) as fully effective.  
When handling ESD-sensitive parts:  
• Keep the parts in protective packages until they are inserted into the product.  
• Avoid contact with other people.  
• Wear a grounded wrist strap against your skin to eliminate static on your body.  
• Prevent the part from touching your clothing. Most clothing is insulative and retains a charge even when  
you are wearing a wrist strap.  
• Use a grounded work mat to provide a static-free work surface. The mat is especially useful when  
handling ESD-sensitive devices.  
• Select a grounding system, such as those listed below, to provide protection that meets the specific  
service requirement.  
Note: The use of a grounding system to guard against ESD damage is desirable but not necessary.  
– Attach the ESD ground clip to any frame ground, ground braid, or green-wire ground.  
– When working on a double-insulated or battery-operated system, use an ESD common ground or  
reference point. You can use coax or connector-outside shells on these systems.  
– Use the round ground prong of the ac plug on ac-operated computers.  
Grounding requirements  
Electrical grounding of the computer is required for operator safety and correct system function. Proper  
grounding of the electrical outlet can be verified by a certified electrician.  
4
ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
     
Safety notices (multilingual translations)  
The safety notices in this section are provided in the following languages:  
• English  
• Arabic  
• Brazilian Portuguese  
• French  
• German  
• Hebrew  
• Japanese  
• Korean  
• Spanish  
Traditional Chinese  
DANGER  
Before the computer is powered on after FRU replacement, make sure all screws, springs, and other small  
parts are in place and are not left loose inside the computer. Verify this by shaking the computer and listening  
for rattling sounds. Metallic parts or metal flakes can cause electrical shorts.  
DANGER  
Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery,  
recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances  
or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result  
in ignition or explosion of the battery.  
DANGER  
The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or  
short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the  
battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result  
in ignition or explosion of the battery.  
DANGER  
The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized  
connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water.  
Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate  
parts listing. Use of an incorrect battery can result in ignition or explosion of the battery.  
Chapter 1. Safety information  
Download from Www.Somanuals.com. All Manuals Search And Download.  
5
   
DANGER  
If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash  
the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are  
present after washing.  
DANGER  
To avoid shock, do not remove the plastic cover that protects the lower part of the inverter card.  
DANGER  
Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to  
burn personnel or combustible materials.  
DANGER  
Unless hot swap is allowed for the FRU being replaced, do as follows before removing it: power off the  
computer, unplug all power cords from electrical outlets, remove the battery pack, and disconnect any  
interconnecting cables.  
6
ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
PERIGO  
Chapter 1. Safety information  
Download from Www.Somanuals.com. All Manuals Search And Download.  
7
 
Antes de ligar o computador após a substituição da FRU, certifique-se de que todos os parafusos, molas e  
outras peças pequenas estejam no lugar e não estejam soltos dentro do computador. Verifique isso sacudindo  
o computador e procurando ouvir sons de peças soltas. Peças metálicas ou lascas de metal podem causar  
curto-circuito.  
PERIGO  
Algumas baterias reserva contêm uma pequena quantidade de níquel e cádmio. Não desmonte uma bateria  
reserva, recarregue-a, jogue-a no fogo ou na água, ou deixe-a entrar em curto-circuito. Descarte a bateria  
conforme requerido pelas leis ou regulamentos locais. Use somente a bateria nas partes listadas apropriadas.  
O uso de uma bateria incorreta pode resultar em combustão ou explosão da bateria.  
PERIGO  
O pacote da bateria contém uma pequena quantidade de níquel. Não o desmonte, jogue-o no fogo ou na  
água, ou deixe-o entrar em curto-circuito. Descarte o pacote da bateria conforme requerido pelas leis ou  
regulamentos locais. Use somente a bateria nas partes listadas apropriadas ao substituir o pacote da bateria.  
O uso de uma bateria incorreta pode resultar em combustão ou explosão da bateria.  
PERIGO  
A bateria de lítio pode causar incêndio, explosão ou graves queimaduras. Não a recarregue, remova seu  
conector polarizado, desmonte-a, aqueça-a acima de 100°C (212°F), incinere-a, ou exponha o conteúdo de  
sua célula à água. Descarte a bateria conforme requerido pelas leis ou regulamentos locais. Use somente  
a bateria nas partes listadas apropriadas. O uso de uma bateria incorreta pode resultar em combustão  
ou explosão da bateria.  
PERIGO  
Se o LCD quebrar e o fluido de dentro dele entrar em contato com seus olhos ou com suas mãos, lave as  
áreas afetadas imediatamente com água durante pelo menos 15 minutos. Procure cuidados médicos se algum  
sintoma causado pelo fluido surgir após a lavagem.  
PERIGO  
Para evitar choque elétrico, não remova a capa plástica que protege a parte inferior da placa inversora.  
PERIGO  
8
ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Embora as principais baterias possuam baixa voltagem, uma bateria em curto-circuito ou aterrada pode  
produzir corrente o bastante para queimar materiais de pessoal ou inflamáveis.  
PERIGO  
A menos que uma hot swap seja permitida para a FRU que está sendo substituída, faça o seguinte antes de  
removê-la: desligue o computador, desconecte todos os cabos de energia das tomadas, remova o pacote de  
baterias e desconecte quaisquer cabos de interconexão.  
DANGER  
Avant de remettre l'ordinateur sous tension après remplacement d'une unité en clientèle, vérifiez que tous les  
ressorts, vis et autres pièces sont bien en place et bien fixées. Pour ce faire, secouez l'unité et assurez-vous  
qu'aucun bruit suspect ne se produit. Des pièces métalliques ou des copeaux de métal pourraient causer  
un court-circuit.  
DANGER  
Certaines batteries de secours contiennent du nickel et du cadmium. Ne les démontez pas, ne les rechargez  
pas, ne les exposez ni au feu ni à l'eau. Ne les mettez pas en court-circuit. Pour les mettre au rebut,  
conformez-vous à la réglementation en vigueur. Lorsque vous remplacez la pile de sauvegarde ou celle de  
l'horloge temps réel, veillez à n'utiliser que les modèles cités dans la liste de pièces détachées adéquate. Une  
batterie ou une pile inappropriée risque de prendre feu ou d'exploser.  
DANGER  
La batterie contient du nickel. Ne la démontez pas, ne l'exposez ni au feu ni à l'eau. Ne la mettez pas en  
court-circuit. Pour la mettre au rebut, conformez-vous à la réglementation en vigueur. Lorsque vous remplacez  
la batterie, veillez à n'utiliser que les modèles cités dans la liste de pièces détachées adéquate. En effet, une  
batterie inappropriée risque de prendre feu ou d'exploser.  
DANGER  
La pile de sauvegarde contient du lithium. Elle présente des risques d'incendie, d'explosion ou de brûlures  
graves. Ne la rechargez pas, ne retirez pas son connecteur polarisé et ne la démontez pas. Ne l'exposez pas à  
une temperature supérieure à 100°C, ne la faites pas brûler et n'en exposez pas le contenu à l'eau. Mettez la  
pile au rebut conformément à la réglementation en vigueur. Une pile inappropriée risque de prendre feu ou  
d'exploser.  
Chapter 1. Safety information  
Download from Www.Somanuals.com. All Manuals Search And Download.  
9
 
DANGER  
Si le panneau d'affichage à cristaux liquides se brise et que vous recevez dans les yeux ou sur les mains une  
partie du fluide, rincez-les abondamment pendant au moins quinze minutes. Consultez un médecin si des  
symptômes persistent après le lavage.  
DANGER  
Afin d'éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure  
de la carte d'alimentation.  
DANGER  
Bien que le voltage des batteries principales soit peu élevé, le court-circuit ou la mise à la masse d'une  
batterie peut produire suffisamment de courant pour brûler des matériaux combustibles ou causer des  
brûlures corporelles graves.  
DANGER  
Si le remplacement à chaud n'est pas autorisé pour l'unité remplaçable sur site que vous remplacez,  
procédez comme suit avant de retirer l'unité : mettez l'ordinateur hors tension, débranchez tous les  
cordons d'alimentation des prises de courant, retirez le bloc de batterie et déconnectez tous les câbles  
d'interconnexion.  
VORSICHT  
Bevor nach einem FRU-Austausch der Computer wieder angeschlossen wird, muß sichergestellt werden, daß  
keine Schrauben, Federn oder andere Kleinteile fehlen oder im Gehäuse vergessen wurden. Der Computer muß  
geschüttelt und auf Klappergeräusche geprüft werden. Metallteile oder-splitter können Kurzschlüsse erzeugen.  
VORSICHT  
Die Bereitschaftsbatterie, die sich unter dem Diskettenlaufwerk befindet, kann geringe Mengen Nickel  
und Cadmium enthalten. Sie darf nur durch die Verkaufsstelle oder den IBM Kundendienst ausgetauscht  
werden. Sie darf nicht zerlegt, wiederaufgeladen, kurzgeschlossen, oder Feuer oder Wasser ausgesetzt  
werden. Die Batterie kann schwere Verbrennungen oder Verätzungen verursachen. Bei der Entsorgung die  
örtlichen Bestimmungen für Sondermüll beachten. Beim Ersetzen der Bereitschafts-oder Systembatterie nur  
Batterien des Typs verwenden, der in der Ersatzteilliste aufgeführt ist. Der Einsatz falscher Batterien kann  
zu Entzündung oder Explosion führen.  
10 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
VORSICHT  
Akkus enthalten geringe Mengen von Nickel. Sie dürfen nicht zerlegt, wiederaufgeladen, kurzgeschlossen,  
oder Feuer oder Wasser ausgesetzt werden. Bei der Entsorgung die örtlichen Bestimmungen für Sondermüll  
beachten. Beim Ersetzen der Batterie nur Batterien des Typs verwenden, der in der Ersatzteilliste aufgeführt  
ist. Der Einsatz falscher Batterien kann zu Entzündung oder Explosion führen.  
VORSICHT  
Die Systembatterie ist eine Lithiumbatterie. Sie kann sich entzünden, explodieren oder schwere Verbrennungen  
hervorrufen. Batterien dieses Typs dürfen nicht aufgeladen, zerlegt, über 100°C erhitzt oder verbrannt werden.  
Auch darf ihr Inhalt nicht mit Wasser in Verbindung gebracht oder der zur richtigen Polung angebrachte  
Verbindungsstecker entfernt werden. Bei der Entsorgung die örtlichen Bestimmungen für Sondermüll  
beachten. Beim Ersetzen der Batterie nur Batterien des Typs verwenden, der in der Ersatzteilliste aufgeführt  
ist. Der Einsatz falscher Batterien kann zu Entzündung oder Explosion führen.  
VORSICHT  
Die Leuchtstoffröhre im LCD-Bildschirm enthält Quecksilber. Bei der Entsorgung die örtlichen Bestimmungen  
für Sondermüll beachten. Der LCD-Bildschirm besteht aus Glas und kann zerbrechen, wenn er unsachgemäß  
behandelt wird oder der Computer auf den Boden fällt. Wenn der Bildschirm beschädigt ist und die darin  
befindliche Flüssigkeit in Kontakt mit Haut und Augen gerät, sollten die betroffenen Stellen mindestens 15  
Minuten mit Wasser abgespült und bei Beschwerden anschließend ein Arzt aufgesucht werden.  
VORSICHT  
Aus Sicherheitsgründen die Kunststoffabdeckung, die den unteren Teil der Spannungswandlerplatine umgibt,  
nicht entfernen.  
VORSICHT  
Obwohl Hauptbatterien eine niedrige Spannung haben, können sie doch bei Kurzschluß oder Erdung genug  
Strom abgeben, um brennbare Materialien zu entzünden oder Verletzungen bei Personen hervorzurufen.  
VORSICHT  
Chapter 1. Safety information 11  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Wenn ein Austausch der FRU bei laufendem Betrieb nicht erlaubt ist, gehen Sie beim Austausch der FRU wie  
folgt vor: Schalten Sie den Computer aus, ziehen Sie alle Netzkabel von den Netzsteckdosen ab, entfernen  
Sie den Akku und ziehen Sie alle miteinander verbundenen Kabel ab.  
12 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Chapter 1. Safety information 13  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
14 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Antes de encender el sistema despues de sustituir una FRU, compruebe que todos los tornillos, muelles y  
demás piezas pequeñas se encuentran en su sitio y no se encuentran sueltas dentro del sistema. Compruébelo  
agitando el sistema y escuchando los posibles ruidos que provocarían. Las piezas metálicas pueden causar  
cortocircuitos eléctricos.  
Algunas baterías de reserva contienen una pequeña cantidad de níquel y cadmio. No las desmonte, ni  
recargue, ni las eche al fuego o al agua ni las cortocircuite. Deséchelas tal como dispone la normativa local.  
Utilice sólo baterías que se encuentren en la lista de piezas. La utilización de una batería no apropiada  
puede provocar la ignición o explosión de la misma.  
Las baterías contienen pequeñas cantidades de níquel. No las desmonte, ni recargue, ni las eche al fuego  
o al agua ni las cortocircuite. Deséchelas tal como dispone la normativa local. Utilice sólo baterías que se  
encuentren en la lista de piezas al sustituir la batería. La utilización de una batería no apropiada puede  
provocar la ignición o explosión de la misma.  
La batería de repuesto es una batería de litio y puede provocar incendios, explosiones o quemaduras graves.  
No la recargue, ni quite el conector polarizado, ni la desmonte, ni caliente por encima de los 100°C (212°F), ni  
la incinere ni exponga el contenido de sus celdas al agua. Deséchela tal como dispone la normativa local.  
Si la LCD se rompe y el fluido de su interior entra en contacto con sus ojos o sus manos, lave inmediatamente  
las áreas afectadas con agua durante 15 minutos como mínimo. Obtenga atención medica si se presenta  
algún síntoma del fluido despues de lavarse.  
Chapter 1. Safety information 15  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Para evitar descargas, no quite la cubierta de plástico que rodea la parte baja de la tarjeta invertida.  
Aunque las baterías principales tienen un voltaje bajo, una batería cortocircuitada o con contacto a tierra  
puede producir la corriente suficiente como para quemar material combustible o provocar quemaduras en  
el personal.  
Salvo que se permita el intercambio en caliente para la unidad sustituible localmente, realice lo siguiente antes  
de extraerla: apague el sistema, desconecte todos los cables de alimentación de las tomas de alimentación  
eléctrica, extraiga la batería y desconecte los cables de interconexión.  
16 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Laser compliance statement (multilingual translations)  
The laser compliance statements in this section are provided in the following languages:  
• English  
• Arabic  
• Brazilian Portuguese  
• French  
• German  
• Hebrew  
• Japanese  
• Korean  
• Spanish  
Traditional Chinese  
Chapter 1. Safety information 17  
Download from Www.Somanuals.com. All Manuals Search And Download.  
     
18 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
Chapter 1. Safety information 19  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
20 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
Chapter 1. Safety information 21  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
22 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Chapter 2. Important service information  
This chapter presents following important service information that applies to all machine types supported by  
this manual:  
“Product definition” on page 25  
“FRU identification for CTO, CMV, and GAV products” on page 25  
Important:  
Advise customers to contact the Lenovo Customer Support Center if they need any assistance in obtaining or  
installing any software fixes, drivers, and UEFI BIOS downloads. Telephone numbers forLenovo Support are  
available at http://www.lenovo.com/support.  
System Disassembly/Reassembly videos that show the FRU removals or replacements for the Lenovo® authorized  
service technicians are available in the following support site:  
Strategy for replacing FRUs  
Before replacing parts:  
Make sure that all software fixes, drivers, and UEFI BIOS downloads are installed before replacing any  
FRUs listed in this manual.  
After a system board is replaced, ensure that the latest UEFI BIOS is loaded to the system board before  
completing the service action.  
To download software fixes, drivers, and UEFI BIOS, go to http://www.lenovo.com/support and click  
Download Drivers & Software. Then follow the instructions on the screen to install the necessary software.  
Use the following strategy to prevent unnecessary expense for replacing and servicing FRUs:  
If you are instructed to replace a FRU but the replacement does not correct the problem, reinstall  
the original FRU before you continue.  
• Some computers have both a processor board and a system board. If you are instructed to replace either  
the processor board or the system board, and replacing one of them does not correct the problem,  
reinstall that board, and then replace the other one.  
• If an adapter or a device consists of more than one FRU, any of the FRUs may be the cause of the error.  
Before replacing the adapter or device, remove the FRUs, one by one, to see if the symptoms change.  
Replace only the FRU that changed the symptoms.  
Attention: The setup configuration on the computer you are servicing may have been customized. Running  
Automatic Configuration may alter the settings. Note the current configuration settings (using the View  
Configuration option); then, when service has been completed, verify that those settings remain in effect.  
Strategy for replacing a hard disk drive  
Always try to run a low-level format before replacing a hard disk drive. This will cause all customer data on  
the hard disk to be lost. Be sure that the customer has a current backup of the data before doing this task.  
© Copyright Lenovo 2011  
23  
Download from Www.Somanuals.com. All Manuals Search And Download.  
       
Attention: The drive startup sequence in the computer you are servicing may have been changed. Be  
extremely careful during write operations such as copying, saving, or formatting. If you select an incorrect  
drive, data or programs can be overwritten.  
If your computer is shipped with an mSATA drive and a solid state drive or hard disk drive, the mSATA drive  
will be seen as hard disk 0 in the system, and assigned drive C:. The solid state drive or hard disk drive will  
be seen as hard disk 1, and assigned drive D:. The mSATA drive is installed in the wireless WAN card slot of  
the computer. The Lenovo preloaded software is installed on the mSATA drive.  
Always try to run a low-level format before replacing a hard disk drive. This will cause all customer data on  
the hard disk to be lost. Be sure that the customer has a current backup of the data before doing this task.  
Attention: The drive startup sequence in the computer you are servicing may have been changed. Be  
extremely careful during write operations such as copying, saving, or formatting. If you select an incorrect  
drive, data or programs can be overwritten.  
Important notice for replacing a system board  
Some components mounted on a system board are very sensitive. Improper handling of a system board can  
cause damage to those components, and may cause a system malfunction.  
Attention: When handling a system board:  
• Do not drop a system board or apply any excessive force to it.  
• Avoid rough handling of any kind.  
• Avoid bending a system board and hard pushing to prevent cracking at each BGA (Ball Grid Array) chipset.  
How to use error message  
Use the error codes displayed on the screen to diagnose failures. If more than one error code is displayed,  
begin the diagnosis with the first error code. Whatever causes the first error code may also cause false error  
codes. If no error code is displayed, see whether the error symptom is listed in the Symptom-to-FRU  
Index for the computer you are servicing.  
24 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
     
Strategy for replacing FRUs for CTO, CMV, and GAV  
Product definition  
Dynamic Configure To Order (CTO)  
This provides the ability for a customer to configure a Lenovo solution from an eSite, and have this  
configuration sent to fulfillment, where it is built and shipped directly to the customer. The machine label,  
Product Entitlement Warehouse (PEW), eSupport, and the HMM will load these products as the 4-digit MT  
and 3-digit model, where model = “CTO” (Example: 1829-CTO).  
Custom Model Variant (CMV)  
This is a unique configuration that has been negotiated between Lenovo and the customer. A unique 4-digit  
MT and 3-digit model is provided to the customer to place orders (Example: 1829-W15). A CMV is a special  
bid offering. Therefore, it is NOT generally announced.  
• The MTM portion of the machine label is the 4-digit MT and 3-digit model, where model = “CTO”  
(Example: 1829-CTO). The PRODUCT ID portion of the machine label is the 4-digit MT and 3-digit CMV  
model (Example: 1829-W15).  
• The PEW record is the 4-digit MT and 3-digit model, where model = “CTO” (Example: 1829-CTO).  
• eSupport will show both the CTO and CMV machine type models (Example: 1829-CTO and 1829-W15  
will be found on the eSupport site.)  
• The HMM will have the 4-digit MT and 3-digit CTO model only (Example: 1829-CTO). Again, CMVs are  
custom models and are not found in the HMM.  
General Announce Variant (GAV)  
This is a standard model (fixed configuration). GAVs are announced and offered to all customers. The MTM  
portion of the machine label is a 4-digit MT and 3-digit model, where model = a “fixed part number”, not  
“CTO” (Example: 1829-F1U). Also, PEW, eSupport, and the HMM will list these products under the same  
fixed model number.  
FRU identification for CTO, CMV, and GAV products  
There are three information resources to identify which FRUs are used to support CTO, CMV, and GAV  
products. These sources are PEW, eSupport, and the HMM.  
Using PEW  
PEW is the primary source for identifying FRU part numbers and FRU descriptions for the key commodities  
for CTO, CMV and GAV products at a MT - serial number level. An example of key commodities are hard  
disk drives, system boards, microprocessors, Liquid Crystal Displays (LCDs), and memory.  
• Remember, all CTO and CMV products are loaded in PEW under the 4-digit MT and 3-digit model, where  
model = “CTO” (Example: 1829-CTO). GAVs are loaded in PEW under the 4-digit MT and 3-digit model,  
where model = a “fixed part number”, not “CTO” (Example: 1829-F1U).  
• PEW can be accessed at the following Web site:  
Select Warranty lookup. Input the MT and the Serial number and the list of key commodities will be  
returned in the PEW record under COMPONENT INFORMATION.  
Using eSupport  
For Key Commodities (Examples - hard disk drive, system board, microprocessor, LCD, and memory)  
Chapter 2. Important service information 25  
Download from Www.Somanuals.com. All Manuals Search And Download.  
     
• eSupport can be used to view the list of key commodities built in a particular machine serial (this is the  
same record found in PEW).  
• eSupport can be accessed at the following Web site:  
http://www.lenovo.com/support  
To view the key commodities, do the following:  
1. Click Products & Service Warranty.  
2. Click Check Warranty Status.  
3. On the Warranty Status Lookup page, click Parts Lookup.  
4. Type your machine type and serial number, and then click Submit. The key commodities will be  
displayed.  
For the Remaining FRUs (the complete list of FRUs at the MT Model level)  
• eSupport can be used to view the complete list of FRUs for a machine type and model.  
To view the complete list of FRUs, do the following:  
1. Click Product & Parts Detail and then follow the instructions on the screen to reach the Product  
and Parts Details page.  
2. Click the Parts Detail tab to view the list of service parts.  
Using the HMM  
For Key Commodities (Examples - hard disk drive, system board, microprocessor, LCD, and memory)  
Use the HMM as a back-up to PEW and eSupport to view the complete list of FRUs at the MT Model level.  
26 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Chapter 3. General checkout  
This chapter presents following information:  
“FRU tests” on page 33  
The descriptions in this chapter apply to any ThinkPad model that supports the PC-Doctor® for DOS  
diagnostics program. Some descriptions might not apply to your particular computer.  
Before you go to the checkout guide, be sure to read the following important notes.  
Important notes:  
Only certified trained personnel should service the computer.  
Before replacing any FRU, read the entire page on removing and replacing FRUs.  
When you replace FRUs, use new nylon-coated screws.  
Be extremely careful during such write operations as copying, saving, or formatting. Drives in the computer  
that you are servicing sequence might have been altered. If you select an incorrect drive, data or programs  
might be overwritten.  
Replace a FRU only with another FRU of the correct model. When you replace a FRU, make sure that the model  
of the machine and the FRU part number are correct by referring to the FRU parts list.  
A FRU should not be replaced because of a single, unreproducible failure. Single failures can occur for a  
variety of reasons that have nothing to do with a hardware defect, such as cosmic radiation, electrostatic discharge,  
or software errors. Consider replacing a FRU only when a problem recurs. If you suspect that a FRU is defective,  
clear the error log and run the test again. If the error does not recur, do not replace the FRU.  
Be careful not to replace a nondefective FRU.  
© Copyright Lenovo 2011  
27  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
What to do first  
When you do return a FRU, you must include the following information in the parts exchange form or  
parts return form that you attach to it:  
1. Name and phone number of service technician  
2. Date of service  
3. Date on which the machine failed  
4. Date of purchase  
5. Failure symptoms, error codes appearing on the display, and beep symptoms  
6. Procedure index and page number in which the failing FRU was detected  
7. Failing FRU name and part number  
8. Machine type, model number, and serial number  
9. Customer's name and address  
Note: During the warranty period, the customer may be responsible for repair costs if the computer damage  
was caused by misuse, accident, modification, unsuitable physical or operating environment, or improper  
maintenance by the customer. Following is a list of some common items that are not covered under warranty  
and some symptoms that might indicate that the system was subjected to stress beyond normal use.  
Before checking problems with the computer, determine whether the damage is covered under the warranty  
by referring to the following list:  
The following are not covered under warranty:  
• LCD panel cracked from the application of excessive force or from being dropped  
• Scratched (cosmetic) parts  
• Distortion, deformation, or discoloration of the cosmetic parts  
• Plastic parts, latches, pins, or connectors that have been cracked or broken by excessive force  
• Damage caused by liquid spilled into the system  
• Damage caused by the improper insertion of a PC Card or the installation of an incompatible card  
• Improper disc insertion or use of an optical drive  
• Diskette drive damage caused by pressure on the diskette drive cover, foreign material in the drive,  
or the insertion of a diskette with multiple labels  
• Damaged or bent diskette eject button  
• Fuses blown by attachment of a nonsupported device  
• Forgotten computer password (making the computer unusable)  
• Sticky keys caused by spilling a liquid onto the keyboard  
• Use of an incorrect ac power adapter on laptop products  
The following symptoms might indicate damage caused by nonwarranted activities:  
• Missing parts might be a symptom of unauthorized service or modification.  
• If the spindle of a hard disk drive becomes noisy, it may have been subjected to excessive force,  
or dropped.  
28 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
Checkout guide  
Use the following procedures as a guide in identifying and correcting problems with the ThinkPad Notebook.  
Note: The diagnostic tests are intended to test only ThinkPad products. The use of non-ThinkPad products,  
prototype cards, or modified options can lead to false indications of errors and invalid system responses.  
1. Identify the failing symptoms in as much detail as possible.  
2. Verify the symptoms. Try to re-create the failure by running the diagnostic test or by repeating the  
operation.  
Diagnostics using PC-Doctor for DOS  
The ThinkPad Notebook has a test program called PC-Doctor for DOS (hereafter called PC-Doctor.) You can  
detect errors by running the diagnostics test included in PC-Doctor.  
Note: PC-Doctor for DOS is available at the following Web site:  
http://www.lenovo.com/support  
To create the PC-Doctor diagnostic CD, follow the instructions on the Web site.  
For some possible configurations of the computer, PC-Doctor might not run correctly. To avoid this problem,  
you need to initialize the computer setup by use of the ThinkPad Setup program before you run PC-Doctor.  
To enter the ThinkPad Setup program, do as follows:  
1. Turn on the computer.  
2. When the ThinkPad logo comes up, immediately press F1 to enter the ThinkPad Setup program.  
Note: If a supervisor password has been set by the customer, the ThinkPad Setup program menu appears  
after the password is entered. You can start the ThinkPad Setup program by pressing Enter instead of  
entering the supervisor password; however, you cannot change the parameters that are protected by the  
supervisor password.  
On the ThinkPad Setup program screen, press F9, Enter, F10, and then Enter.  
Note: When you initialize the computer configuration, some devices are disabled, such as the serial port. If  
you test one of these devices, you will need to enable it by using Configuration utility for DOS. The utility is  
available on the following Web site:  
http://www.lenovo.com/support  
PC-Doctor cannot be used to test a device that is in the docking station, even if the computer supports the  
docking station. To test a USB device, connect it to the USB connector of the computer.  
Testing the computer  
Note: The PC-Doctor for DOS CD-R/CD-RW disc supports only test of internal optical disc drives (CD-RW,  
CD-RW/DVD Combo, and DVD Multi drives) on ThinkPad computers. It does not support test of any optical  
disc drives connected through USB devices, PC cards, CardBus cards, or similar. The USB limitation only  
applies to testing of the device. Using a bootable PC-Doctor for DOS CD/DVD, the system can be started  
from a USB attached optical drive.  
To run the test, do as follows:  
1. Turn off the computer.  
2. Make sure that the optical drive that is supported as a startup device is installed to the computer.  
Chapter 3. General checkout 29  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
3. Turn on the computer. If the computer cannot be powered on, go to “Power system checkout” on  
page 34, and check the power sources.  
If an error code appears, go to “Symptom-to-FRU index” on page 43.  
4. When the ThinkPad logo comes up, immediately press F12 to enter the Boot Menu.  
5. Insert the PC-Doctor CD into the optical drive.  
6. Press cursor keys to select ATAPI CDx (x: 0, 1, ...) and then press Enter.  
7. Follow the instructions on the screen.  
8. The main panel of PC-Doctor appears.  
9. Select Diagnostics with the arrow keys, and press Enter.  
Note: You can select an item not only with the arrow keys, but also with the TrackPoint® pointer.  
Instead of pressing Enter, click the left button.  
A pull-down menu appears. (Its exact form depends on the model.)  
Note: PC-Doctor menu does not mean the formal support device list. Some unsupported device names  
may appear in the PC-Doctor menu.  
Diagnostics  
Interactive Tests  
Hardware Info  
Utility  
Quit  
F1=Help  
Run Normal Test  
Run Quick Test  
CPU/Coprocessor  
System Memory  
Systemboard  
Video Adapter  
Fixed Disks  
Diskette Drives  
Other Devices  
Communication  
Wireless LAN  
PC-DOCTOR 2.0 Copyright 2008 PC-Doctor, Inc. All Rights Reserved.  
Use the cursor keys and ESC to move in menus. Press ENTER to select.  
The options on the test menu are as follows:  
Diagnostics  
Interactive Tests  
• Run Normal Test  
• Run Quick Test  
• CPU/Coprocessor  
• System Memory  
• Systemboard  
• Video Adapter  
• Fixed Disks  
• Diskette Drives  
• Other Devices  
• Communication  
• Wireless LAN  
• Keyboard  
• Video  
• Internal Speaker  
• Mouse  
• Diskette  
• System Load  
• Optical Drive Test  
• Intel WLAN Radio Test  
Notes:  
• In the Keyboard test in Interactive Tests, the Fn key should be held down for at least 2 seconds; otherwise, it  
cannot be sensed.  
Video Adapter test supports only the LCD display on the ThinkPad Notebook. If you have an external monitor  
attached to your computer, detach it before running PC-Doctor for DOS.  
To test Digital Signature Chip, the security chip must be set to Active.  
10. Run the applicable function test.  
30 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
11. Follow the instructions on the screen. If there is a problem, PC-Doctor shows messages describing it.  
12. To exit the test, select Quit — Exit Diag. To cancel the test, press Esc.  
Note: After running PC-Doctor, check the time and date on the system and reset them if they are incorrect.  
Detecting system information with PC-Doctor  
PC-Doctor can detect the following system information:  
Hardware Info  
• System Configuration  
• Memory Contents  
• Physical Disk Drives  
• VGA Information  
• ATA Drive Info  
• PCI Information  
• PNPISA Info  
• SMBIOS Info  
• VESA LCD Info  
• Hardware Events Log  
Utility  
• Run External Tests  
• Benchmark System  
• DOS Shell  
Tech Support Form  
• Battery Rundown  
• Erase Drive Contents  
• View PCDR Host Log  
Lenovo ThinkVantage Toolbox  
Lenovo ThinkVantage® Toolbox is a diagnostic program that works through the Windows operating system.  
It enables you to view symptoms of computer problems and solutions for them, and includes automatic  
notification when action is required, computing assistance, advanced diagnostics, and diagnostic history.  
Notes:  
• The latest Lenovo ThinkVantage Toolbox is available at the following Web site:  
http://web.lenovothinkvantagetoolbox.com/  
To install the latest Lenovo ThinkVantage Toolbox on the computer, click Download Lenovo ThinkVantage  
Toolbox, and then follow the instructions on the Web site.  
To run this program, do as follows:  
Windows 7:  
While the Windows operating system is running, press the ThinkVantage button.  
To start this program, do the following:  
• Click Start Control Panel System and Security Lenovo – System Health and Diagnostics.  
Windows VistaR and Windows XP:  
Click Start All Programs ThinkVantage Lenovo ThinkVantage Toolbox  
Follow the instructions on the screen. Lenovo ThinkVantageToolbox also has problem determination aids  
that determine software and usage problems.  
Chapter 3. General checkout 31  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
For additional information about this program, see the Help for the program.  
32 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
FRU tests  
The following table shows the test for each FRU.  
Table 1. FRU tests  
FRU  
Applicable test  
Systemboard  
1. Diagnostics CPU/Coprocessor  
2. Diagnostics Systemboard  
3. If the docking station or the port replicator is attached to the ThinkPad Notebook,  
detach it.  
4. Place the computer on a horizontal surface, and run Diagnostics ThinkPad  
Devices HDD Active Protection Test.  
Note: Do not apply any physical shock to the computer while the test is running.  
Power  
Diagnostics ThinkPad Devices ac power adapter, Battery 1 (Battery2)  
1. Diagnostics Video Adapter  
2. Interactive Tests Video  
LCD unit  
Audio  
Enter the ThinkPad Setup program and change Serial ATA (SATA) setting to  
Compatibility, and run Diagnostics Other Device Conexant Audio.  
Speaker  
Interactive Tests Internal Speaker  
Note: Once Audio test is done, the no sound is heard this test. In this case, turn off  
and turn on the computer. Then, run this test again.  
Keyboard  
1. Diagnostics Systemboard Keyboard  
2. Interactive Tests Keyboard  
Hard disk drive or solid state  
drive  
Enter the ThinkPad Setup program and change Serial ATA (SATA) setting to  
Compatibility, and run Diagnostics Fixed Disks.  
Diskette drive  
Optical drive  
Memory  
1. Diagnostics Diskette Drives  
2. Interactive Tests Diskette  
1. Diagnostics Other Devices Optical Drive  
2. Interactive Tests Optical Drive Test  
1. If two DIMMs are installed, remove one of them and run Diagnostics System  
Memory.  
2. If the problem does not recur, return the DIMM to its place, remove the other one,  
and run the test again.  
TrackPoint or pointing  
device  
If the TrackPoint does not work, check the configuration as specified in the ThinkPad  
Setup program. If the TrackPoint is disabled, select Automatic to enable it.  
After you use the TrackPoint, the pointer may drift on the screen for a short time. This  
drift can occur when a slight, steady pressure is applied to the TrackPoint pointer.  
This symptom is not a hardware problem. If the pointer stops after a short time, no  
service action is necessary.  
If enabling theTrackPoint does not correct the problem, continue with the following:  
Interactive Tests Mouse  
Touch Pad  
If the Touch Pad does not work, check the configuration as specified in the ThinkPad  
Setup program. If the Touch Pad is disabled, select Automatic to enable it. If enabling  
the Touch Pad does not correct the problem, continue with the following:  
Interactive Tests Mouse  
Chapter 3. General checkout 33  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
Power system checkout  
To verify a symptom, do the following:  
1. Turn off the computer.  
2. Remove the battery pack.  
3. Connect the ac power adapter.  
4. Check that power is supplied when you turn on the computer.  
5. Turn off the computer.  
6. Disconnect the ac power adapter and install the charged battery pack.  
7. Check that the battery pack supplies power when you turn on the computer.  
If you suspect a power problem, see the appropriate one of the following power supply checkouts:  
Checking the ac power adapter  
You are here because the computer fails only when the ac power adapter is used.  
• If the power problem occurs only when the docking station or the port replicator is used, replace the  
docking station or the port replicator.  
• If the power-on indicator does not turn on, check the power cord of the ac power adapter for correct  
continuity and installation.  
• If the computer does not charge during operation, go to “Checking operational charging” on page 34.  
To check the ac power adapter, do the following:  
1. Unplug the ac power adapter cable from the computer.  
2. Measure the output voltage at the plug of the ac power adapter cable. See the following figure:  
Pin  
1
Voltage (V dc)  
+20  
0
3
2
2
3
Ground  
1
(20V)  
Note: Output voltage of pin no.2 of the ac power adapter may different from the one you are servicing.  
3. If the voltage is not correct, replace the ac power adapter.  
4. If the voltage is acceptable, do the following:  
• Replace the system board.  
• If the problem persists, go to “FRU tests” on page 33.  
Note: Noise from the ac power adapter does not always indicate a defect.  
Checking operational charging  
To check whether the battery charges properly during operation, use a discharged battery pack or a battery  
pack that has less than 50% of the total power remaining when installed in the computer.  
34 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
     
Perform operational charging. If the battery status indicator or icon does not turn on, remove the battery  
pack and let it return to room temperature. Reinstall the battery pack. If the charge indicator or icon still does  
not turn on, replace the battery pack.  
If the charge indicator still does not turn on, replace the system board. Then reinstall the battery pack. If it is  
still not charged, go to the next section.  
Checking the battery pack  
Battery charging does not start until the Power Manager Battery Gauge shows that less than 96% of the  
total power remains; under this condition the battery pack can charge to 100% of its capacity. This protects  
the battery pack from being overcharged or from having a shortened life.  
To check your battery, move your cursor to the Power Manager Battery Gauge icon in the icon tray of the  
Windows taskbar and wait for a moment (but do not click), and the percentage of battery power remaining  
is displayed. To get detailed information about the battery, double-click the Power Manager Battery  
Gauge icon.  
Note: If the battery pack becomes hot, it may not be able to charge. Remove it from the computer and leave  
it at room temperature for a while. After it cools down, reinstall and recharge it.  
To check the battery pack, do the following:  
1. Power off the computer.  
2. Remove the battery pack and measure the voltage between battery terminals 1 (+) and 7 (-). See the  
following figure:  
Terminal  
Voltage (V dc)  
+ 0 to + 16.8  
Ground (-)  
1
7
7(-)  
6(-)  
5
4
3
2(+)  
1(+)  
3. If the voltage is less than +11.0 V dc, the battery pack has been discharged.  
Note: Recharging will take at least 3 hours, even if the indicator does not turn on.  
If the voltage is still less than +11.0 V dc after recharging, replace the battery.  
4. If the voltage is more than +11.0 V dc, measure the resistance between battery terminals 5 and 7.  
The resistance must be 4 to 30 K Ω. If the resistance is not correct, replace the battery pack. If the  
resistance is correct, replace the system board.  
Checking the backup battery  
Do the following:  
1. Power off the computer, and unplug the ac power adapter from it.  
2. Turn the computer upside down.  
3. Remove the battery pack (see “1010 Battery pack” on page 63).  
4. Remove the backup battery (see “1100 Backup battery” on page 79).  
5. Measure the voltage of the backup battery. See the following figure.  
Chapter 3. General checkout 35  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
Wire  
Red  
Voltage (V dc)  
+2.5 to +3.2  
Ground  
Black  
• If the voltage is correct, replace the system board.  
• If the voltage is not correct, replace the backup battery.  
• If the backup battery discharges quickly after replacement, replace the system board.  
36 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Chapter 4. Related service information  
This chapter presents following information:  
“Passwords” on page 38  
“Power management” on page 41  
Service Web site:  
When the latest maintenance diskette and the system program service diskette become available, they will be posted  
on  
http://www.lenovo.com/support  
Restoring the factory contents by using Recovery Disc Set  
When the hard disk drive (HDD) or solid state drive (SSD) is replaced because of a failure, no product recovery  
program is on the new drive. In this case, you must use the Recovery Disc Set for the computer. Order the  
Recovery Disc Set and the drive at the same time so that you can recover the new drive with the pre-installed  
software when they arrive. For information on which discs to order, see “Recovery discs” on page 160.  
The recovery disc set consists of the user instructions and the following set of DVDs to restore the computer  
to the original factory configuration.  
Operating System Recovery Disc (one disc)  
This disc restores the Microsoft® Windows operating  
system. Use this disc to start the recovery process.  
This disc restores the preinstalled applications and  
drivers on the computer.  
Applications and Drivers Recovery Disc (one or  
more discs)  
This disc contains additional content, such as  
updates to the software that was preinstalled on the  
computer. Not all recovery disc sets come with a  
Supplemental Recovery Disc.  
Supplemental Recovery Disc  
Notes:  
You must have a DVD drive to use the recovery discs. If you do not have an internal DVD drive, you  
can use an external USB DVD drive.  
• During the recovery process, all data on the drive will be deleted. If possible, copy any important data  
or personal files that you want to keep onto removable media or a network drive before you start the  
recovery process.  
To restore the computer to the original factory configuration using the recovery disc set, do the following:  
Note: Recovery can take one to two hours to complete. The length of time depends on the method you use. If you  
use recovery discs, the recovery process will take about two hours.  
1. Make the CD/DVD drive the first startup device in the startup sequence using the following procedure:  
a. Press and hold down the F1 key, and then turn on the computer. When the logo screen is displayed  
or if you hear repeating beeps, release the F1 key. The ThinkPad Setup program opens.  
b. Use the arrow keys to select Startup Boot.  
c. Select the CD/DVD drive as the 1st Boot Device.  
© Copyright Lenovo 2011  
37  
Download from Www.Somanuals.com. All Manuals Search And Download.  
     
2. Insert the Operating System Recovery Disc into the DVD drive.  
3. Press F10 to save the ThinkPad Setup program configuration changes. Follow the instructions on the  
screen to begin the recovery process.  
4. Select your language and click Next.  
5. Read the license. If you agree with the terms and conditions, select I accept these terms and  
conditions and then click Next. If you do not agree with the terms and conditions, follow the  
instructions on the screen.  
6. Click Yes in the displayed window to begin the operating system recovery process.  
7. Insert the Applications and Drivers Recovery Disc when prompted and then click OK to begin the  
applications and drivers recovery process.  
8. If you have a Supplemental Recovery Disc, insert it when prompted and click Yes. If you do not have a  
Supplemental Recovery Disc, click No.  
9. When all of the data has been copied from the last disc in the set and has been processed, remove the  
disc and restart the computer.  
Note: The rest of the recovery process is fully automated and no action is required by you. The  
computer will restart into the Microsoft Windows desktop several times and you might experience  
periods when no activity is apparent on the screen for several minutes at a time. This is normal.  
10. When the recovery process is complete, the Set Up Windows screen is displayed. Follow the  
instructions on the screen to complete the Windows setup.  
11. After you have completed the Windows setup, you might want to restore the original startup sequence.  
Start the ThinkPad Setup program and then press F9 to restore the default settings. Press F10 to save  
and exit the ThinkPad Setup program.  
Note: After restoring a drive to the factory default settings, you might need to reinstall some device drivers.  
Passwords  
As many as three passwords may be needed for any ThinkPad Notebook: the power-on password (POP),  
the hard-disk password (HDP), and the supervisor password (SVP).  
If any of these passwords has been set, a prompt for it appears on the screen whenever the computer is  
turned on. The computer does not start until the password is entered.  
Note: If only an SVP is installed, the password prompt does not appear when the operating system is booted.  
Power-on password  
A power-on password (POP) protects the system from being powered on by an unauthorized person. The  
password must be entered before an operating system can be booted. For how to remove the POP, see  
Hard-disk password  
There are two hard-disk passwords (HDPs):  
• User HDP—for the user  
• Master HDP—for the system administrator, who can use it to get access to the hard disk even if the user  
has changed the user HDP  
Note: There are two modes for the HDP: User only and Master + User. The Master + User mode requires  
two HDPs; the system administrator enters both in the same operation. The system administrator then  
provides the user HDP to the system user.  
38 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
       
Attention: If the user HDP has been forgotten, check whether a master HDP has been set. If it has, it can be  
used for access to the hard disk drive. If no master HDP is available, neither Lenovo nor Lenovo authorized  
service technicians provide any services to reset either the user or the master HDP, or to recover data from  
the hard disk drive. The hard disk drive can be replaced for a scheduled fee.  
For how to remove the POP, see “How to remove the hard-disk password” on page 39.  
Supervisor password  
A supervisor password (SVP) protects the system information stored in the ThinkPad Setup program.  
The user must enter the SVP in order to get access to the ThinkPad Setup program and change the  
system configuration.  
Attention: If the SVP has been forgotten and cannot be made available to the service technician, there is no  
service procedure to reset the password. The system board must be replaced for a scheduled fee.  
How to remove the power-on password  
To remove a POP that you have forgotten, do the following:  
(A) If no SVP has been set:  
1. Turn off the computer.  
2. Remove the battery pack. For how to remove the battery pack, see “1010 Battery pack” on page 63.  
3. Remove the backup battery. For how to remove the backup battery, see “1100 Backup battery” on  
page 79.  
4. Turn on the computer and wait until the POST ends. After the POST ends, the password prompt does  
not appear. The POP has been removed.  
5. Reinstall the backup battery and the battery pack.  
(B) If an SVP has been set and is known by the service technician:  
1. Turn on the computer.  
2. When the ThinkPad logo comes up, immediately press F1 to enter the ThinkPad Setup program. When  
the POP icon is appearing on the screen, enter the POP.  
3. Select Security, using the cursor directional keys to move the menu.  
4. Select Password.  
5. Select Power-On Password.  
6. Type the current SVP in the Enter Current Password field. then leave the Enter New Password field  
blank, and press Enter twice.  
7. In the Changes have been saved window, press Enter.  
8. Press F10; then, in the Setup confirmation window, select Yes.  
How to remove the hard-disk password  
Attention: If User only mode is selected and the user HDP has been forgotten and cannot be made  
available to the service technician, neither Lenovo nor Lenovo authorized service technicians provide any  
services to reset the user HDPs or to recover data from the hard disk drive. The hard disk drive can be  
replaced for a scheduled fee.  
To remove a user HDP that has been forgotten, when the SVP and the master HDP are known, do the  
following:  
1. Turn on the computer.  
Chapter 4. Related service information 39  
Download from Www.Somanuals.com. All Manuals Search And Download.  
     
2. When the ThinkPad logo comes up, immediately press F1 to enter the ThinkPad Setup program. When  
the POP icon is appearing on the screen, enter the POP.  
3. Select Security, using the cursor directional keys to move the menu.  
4. Select Password.  
5. Select Hard-disk x password, where x is the letter of the hard disk drive. A pop-up window opens.  
6. Select Master HDP.  
7. Type the current master HDP in the Enter Current Password field. then leave the Enter New Password  
field blank, and press Enter twice.  
8. Press F10.  
9. Select Yes in the Setup Configuration window. Both user HDP and master HDP will have been removed.  
40 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Power management  
To reduce power consumption, the computer has three power management modes: screen blank, sleep  
(standby in Windows XP), and hibernation.  
Screen blank mode  
If the time set on the “Turn off monitor” timer in the operating system expires, the LCD backlight turns off.  
To put the computer into screen blank mode, do as follows:  
1. Press Fn+F3. A panel for selecting a power plan (in Windows XP, power scheme) appears.  
2. Select Power off display (keep current power plan) (in Windows XP, keep current power scheme).  
To end screen blank mode and resume normal operation, press any key.  
Sleep (standby) mode  
When the computer enters sleep (standby) mode, the following events occur in addition to what occurs  
in screen blank mode:  
• The LCD is powered off.  
• The hard disk drive is powered off.  
• The CPU stops.  
To enter sleep (standby) mode, press Fn+F4.  
Note: You can change the action of the Fn+F4 key combination by changing the settings in Power Manager.  
In certain circumstances, the computer goes into sleep (standby) mode automatically:  
• If a “suspend time” has been set on the timer, and the user does not do any operation with the keyboard,  
the TrackPoint, the hard disk, the parallel connector, or the diskette drive within that time.  
• If the battery indicator blinks orange, indicating that the battery power is low.  
Note: Even if you do not set the low-battery alarm, the charge indicator notifies you when the battery is low,  
and then the computer enters the power-saving mode automatically.  
To cause the computer to return from sleep (standby) mode and resume operation, do one of the following:  
• Press the Fn key.  
• Open the LCD cover.  
Turn on the power switch.  
Also, in either of the following events, the computer automatically returns from sleep (standby) mode and  
resumes operation:  
• The ring indicator (RI) is signaled by a serial device or a PC Card device.  
• The time set on the resume timer elapses.  
Note: The computer does not accept any input immediately after it enters sleep (standby) mode. Wait a  
few seconds before taking any action to reenter operation mode.  
Hibernation mode  
In hibernation mode, the following occurs:  
• The system status, RAM, VRAM, and setup data are stored on the hard disk.  
Chapter 4. Related service information 41  
Download from Www.Somanuals.com. All Manuals Search And Download.  
       
• The system is powered off.  
Note: If the computer enters the hibernation mode while it is docked to the docking station, do not undock it  
before resuming normal operation. If you do undock it and then try to resume normal operation, you will get  
an error message, and you will have to restart the system.  
To cause the computer to enter hibernation mode, do any of the following:  
• Press the Fn+F12 keys.  
• If you have defined one of the following actions as the event that causes the system to go into hibernation  
mode, perform that action.  
– Closing the lid.  
– Pressing the power button.  
– Pressing Fn+F4 keys.  
Also, the computer goes into hibernation mode automatically in either of the following conditions:  
• If a “hibernation time” has been set on the timer, and if the user does not do any operation with the  
keyboard, the TrackPoint, the hard disk drive, the parallel connector, or the diskette drive within that time.  
• If the timer conditions are satisfied in suspend mode.  
When the power is turned on, the computer returns from hibernation mode and resumes operation. The  
hibernation file in the boot record on the hard disk drive is read, and system status is restored from the  
hard disk drive.  
42 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Symptom-to-FRU index  
This section contains following information:  
“Numeric error codes” on page 43  
“Error messages” on page 45  
“No-beep symptoms” on page 46  
“Intermittent problems” on page 48  
“Undetermined problems” on page 48  
The symptom-to-FRU index in this section lists symptoms and errors and their possible causes. The most  
likely cause is listed first, in boldface type.  
Note: Do the FRU replacement or other actions in the sequence shown in the column headed “FRU or  
action, in sequence.” If replacing a FRU does not solve the problem, put the original part back in the  
computer. Do not replace a nondefective FRU.  
This index can also help you determine, during regular servicing, what FRUs are likely to need to be  
replaced next.  
A numeric error is displayed for each error detected in POST or system operation. In the displays, n can  
be any number.  
If no numeric code is displayed, check the narrative descriptions of symptoms. If the symptom is not  
described there, go to “Intermittent problems” on page 48.  
Note: For a device not supported by diagnostic codes in the ThinkPad Notebooks, see the manual for that device.  
Numeric error codes  
Table 2. Numeric error codes  
FRU or action, in sequence  
System board.  
Symptom or error  
0177  
Bad SVP data, stop POST task—The checksum of the  
supervisor password in the EEPROM is not correct.  
0182  
1. Run the ThinkPad Setup program. Press F9, and  
Enter to load the default setting. Then save the  
current setting by pressing F10.  
Bad CRC2. Enter the ThinkPad Setup program and load  
Setup defaults.—The checksum of the CRS2 setting in  
the EEPROM is not correct.  
2. System board.  
0183  
Bad CRC of Security Settings in EFI Variable. Enter the  
ThinkPad Setup program.  
0187  
System board.  
System board.  
System board.  
EAIA data access error—The access to EEPROM is failed.  
0188  
Invalid RFID Serialization Information Area.  
0189  
Invalid RFID configuration information area—The  
EEPROM checksum is not correct.  
0190  
1. Charge the battery pack.  
2. Battery pack.  
Critical low-battery error  
Chapter 4. Related service information 43  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
Table 2. Numeric error codes (continued)  
FRU or action, in sequence  
Symptom or error  
0191  
1. Run the ThinkPad Setup program, and then save  
current setting by pressing F10.  
2. System board.  
System Security—Invalid Remote Change requested.  
0199  
1. Run the ThinkPad Setup program, and then save  
the current setting by pressing F10.  
2. System board.  
System Security— Security password retry count  
exceeded.  
0251  
1. Charge the backup battery for more than 8 hours  
by connecting the ac power adapter.  
2. Replace the backup battery and run the ThinkPad  
setup program to reset the time and date.  
System CMOS checksum bad— Default configuration  
used.  
0271  
Run the ThinkPad Setup program to reset the time  
and date.  
Real-time clock error. Check date and time settings.  
1802  
1. Remove Mini PCI network card.  
2. System board.  
Unauthorized network card is plugged in—Turn off and  
remove the miniPCI network card.  
1820  
Remove all but the reader that you set up for the  
authentication.  
More than one external fingerprint reader is attached.  
Power off and remove all but the reader that you set up  
within your main operating system.  
2000  
1. Undock docking station or port replicator if it is  
attached to the ThinkPad Notebook.  
2. Place the ThinkPad Notebook on a horizontal surface.  
Do not apply any physical shock to the computer.  
3. Run Diagnostics ThinkPad Devices HDD  
Active Protection Test.  
Hard Drive Active Protection sensor diagnostics  
failed.Press <Esc> to continue.Press <F1> to enter  
SETUP  
2100  
1. Reseat the hard disk drive.  
2. Main hard disk drive.  
3. System board.  
Detection error on HDD0 (Main HDD)  
2101  
1. Reseat the hard disk drive.  
2. Ultrabay hard disk drive.  
3. System board.  
Detection error on HDD1 (Ultrabay HDD)  
2102  
1. Reseat the Mini SATA device.  
2. Mini SATA device.  
Detection error on HDD2 (Mini SATA)  
3. System board.  
2110  
1. Reseat the hard disk drive.  
2. Main hard disk drive.  
3. System board.  
Read error on HDD0 (Main HDD)  
2111  
1. Reseat the hard disk drive.  
2. Ultrabay hard disk drive.  
3. System board.  
Read error on HDD1 (Ultrabay HDD)  
2112  
1. Reseat the Mini SATA device.  
2. Mini SATA device.  
Read error on HDD2 (Mini SATA)  
3. System board.  
2200  
System board.  
System board.  
Machine Type and Serial Number are invalid.  
2201  
Machine UUID is invalid  
44 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Error messages  
Table 3. Error messages  
Symptom or error  
Fan error.  
FRU or action, in sequence  
1. Fan.  
2. Thermal grease.  
3. System board.  
Thermal sensing error.  
System board.  
This system does not support batteries that are not  
genuine Lenovo-made or authorized. This system will  
continue to boot, but may not charge unauthorized  
batteries.  
Replace the battery.  
Attention: Lenovo has no responsibility for the  
performance or safety of unauthorized batteries, and  
provides no warranties for failures or damage arising out  
of their use.  
Chapter 4. Related service information 45  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
Beep symptoms  
Table 4. Beep symptoms  
FRU or action, in sequence  
Symptom or error  
One beep and a blank, unreadable, or flashing LCD.  
1. Reseat the LCD connector.  
2. LCD assembly.  
3. External CRT.  
4. System board.  
One long and two short beeps, and a blank or unreadable  
LCD.  
1. System board.  
2. LCD assembly.  
3. DIMM.  
Two short beeps with error codes.  
Two short beeps and a blank screen.  
POST error. See “Numeric error codes” on page 43.  
1. System board.  
2. DIMM.  
Two or more beeps, or a continuous beep. Operating  
system starts successfully.  
If a mini-PCI Ethernet card is installed, confirm that Alert  
On LAN 2 in the ThinkPad Setup program is disabled.  
Three short beeps, pause, three more short beeps, and  
one short beep.  
1. DIMM.  
2. System board.  
One short beep, pause, three short beeps, pause, three  
more short beeps, and one short beep.  
Reinstall the operating system.  
System board (security chip)  
System board  
Only the cursor appears.  
Four cycles of four short beeps and a blank screen.  
Five short beeps and a blank screen.  
No-beep symptoms  
Table 5. No-beep symptoms  
Symptom or error  
FRU or action, in sequence  
1. Make sure that every connector is connected  
tightly and correctly.  
No beep, power-on indicator on, LCD blank, and no  
POST.  
2. DIMM.  
3. System board.  
1. Reseat DIMM.  
No beep, power-on indicator on, and LCD blank during  
POST.  
2. System board.  
The power-on password prompt appears.  
The hard-disk password prompt appears.  
A power-on password or a supervisor password is set.  
Type the password and press Enter.  
A hard-disk password is set. Type the password and  
press Enter.  
LCD-related symptoms  
Important: The TFT LCD for the notebook computer contains many thin-film transistors (TFTs). The presence of a  
small number of dots that are missing, discolored, or always lighted is characteristic of TFT LCD technology, but  
excessive pixel problems can cause viewing concerns.  
If the LCD you are servicing has two or less visible defective pixels, it should not be considered faulty. However, if the  
LCD has three or more visible defective pixels, it will be deemed as defective by Lenovo and it should be replaced.  
Notes:  
• This policy applies to all ThinkPad Notebooks purchased on 1 January, 2008 or later.  
46 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
     
• Lenovo will not provide replacement if the LCD is within specification as we cannot guarantee that any  
replacement LCD will have zero pixel defects.  
• One pixel consists of R, G, B sub-pixels.  
Table 6. LCD-related symptoms  
FRU or action, in sequence  
Symptom or error  
No beep, power-on indicator on, and a blank LCD during System board.  
POST.  
• LCD backlight not working.  
• LCD too dark.  
• LCD brightness cannot be adjusted.  
• LCD contrast cannot be adjusted.  
1. Reseat the LCD connectors.  
2. LCD assembly.  
3. System board.  
• LCD screen unreadable.  
• Characters missing pixels.  
• Screen abnormal.  
1. See important note for “LCD-related symptoms.”  
2. Reseat all LCD connectors.  
3. LCD assembly.  
• Wrong color displayed.  
4. System board.  
Horizontal or vertical lines displayed on LCD.  
LCD assembly.  
Chapter 4. Related service information 47  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Intermittent problems  
Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardware  
defect, such as cosmic radiation, electrostatic discharge, or software errors. FRU replacement should be  
considered only when a problem recurs.  
When analyzing an intermittent problem, do the following:  
1. Run the diagnostic test for the system board in loop mode at least 10 times.  
2. If no error is detected, do not replace any FRUs.  
3. If any error is detected, replace the FRU shown by the FRU code. Rerun the test to verify that no  
more errors exist.  
Undetermined problems  
If the diagnostic tests did not identify the adapter or device that has failed, if wrong devices are installed,  
or if the system simply is not operating, follow these procedures to isolate the failing FRU (do not isolate  
FRUs that have no defects).  
Verify that all attached devices are supported by the computer.  
Verify that the power supply being used at the time of the failure is operating correctly. (See “Power system  
checkout” on page 34.)  
1. Turn off the computer.  
2. Visually check each FRU for damage. Replace any damaged FRU.  
3. Remove or disconnect all of the following devices:  
a. Non-ThinkPad devices  
b. Devices attached to the docking station or the port replicator  
c. Printer, mouse, and other external devices  
d. Battery pack  
e. Hard disk drive  
f. External diskette drive or optical drive  
g. DIMM  
h. Optical disk or diskette in the internal drive  
i. PC Cards  
4. Turn on the computer.  
5. Determine whether the problem has been solved.  
6. If the problem does not recur, reconnect the removed devices one at a time until you find the failing FRU.  
7. If the problem remains, replace the following FRUs one at a time (do not replace a nondefective FRU):  
a. System board  
b. LCD assembly  
48 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
Chapter 5. Status indicators  
This chapter presents the system status indicators that show the status of the computer.  
© Copyright Lenovo 2011  
49  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Table 7. Status indicators  
Indicator  
Meaning  
Orange:  
1
Speaker mute  
The speaker is on mute. To set the speakers on mute or unmute,  
press the speaker mute button.  
2
3
Microphone mute  
Orange:  
Green:  
The microphone is on mute. None of the recording devices is  
available while the microphone mute is on by default.  
Wireless LAN, Wireless WAN,  
or WiMAX status  
The wireless LAN feature (the IEEE 802.11 b/g standard, 802.11  
a/b/g, or 802.11n), wireless WAN feature, or WiMax feature is  
on, and the radio link is ready for use.  
Data is being transmitted.  
4
5
Bluetooth wireless or Wireless  
USB status  
Green:  
Green:  
The Bluetooth wireless feature is on, and the radio link is ready  
for use.  
R
Data is being transmitted.  
Device access  
Data is being read from or written to the hard disk drive, the  
diskette drive, or the drive in the Serial Ultrabay Enhanced  
device. When this indicator is on, do not put the computer into  
sleep (standby) mode or turn off the computer.  
Note: Do not move the system while the green device access light is on.  
Sudden physical shock could cause drive errors.  
50 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 7. Status indicators (continued)  
Indicator  
Meaning  
Green:  
6
Power on  
The computer is on and ready to use. This indicator stays lit  
around the power-on button whenever the computer is on and  
is not in sleep (standby) mode.  
Note: This indicator blinks when the computer is in sleep mode.  
7
8
Numeric lock (On-screen  
indicator)  
By default, when the numeric lock is on, the numeric lock indicator is  
displayed on the screen.  
Serial Ultrabay Enhanced  
device status  
Green:  
A Serial Ultrabay Enhanced device is installed and in use.  
Blinking green:  
A Serial Ultrabay Enhanced device is in the process of being  
detached.  
Turn off:  
A Serial Ultrabay Enhanced device is ready to be attached or  
detached.  
9
Caps lock  
Green:  
Caps Lock mode is enabled. To enable or disable Caps Lock  
mode, press the Caps Lock key.  
10  
Battery status  
Green:  
The battery charge level is 20% or higher.  
Orange:  
The battery charge level is between 5% and 20%.  
Fast blinking orange:  
The battery charge level is lower than 5% .  
Slow blinking orange:  
The battery is being charged. When it reaches 20%, the blinking  
color changes to green.  
Slow blinking green:  
The battery charge level is between 20% and 80%, and  
charging is continuing. When the battery reaches 80% charge,  
the battery status indicator stops blinking, but the charging may  
continue until the battery is 100% charged.  
Note: If the computer is operating on battery power, the battery  
status indicator does not work while the computer is turned off  
or is in sleep (standby) mode or hibernation mode.  
Quick blinking orange:  
An error occurred in the battery.  
The battery status indicator blinks three times:  
Chapter 5. Status indicators 51  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 7. Status indicators (continued)  
Indicator  
Meaning  
The ac power adapter is attached to the computer.  
The battery status indicator is off:  
The battery pack of the computer is fully charged or detached.  
11  
Sleep (standby for Windows  
XP) status  
Green:  
The computer is in sleep (standby) mode.  
Blinking green:  
The computer is entering sleep (standby) mode or hibernation  
mode, or is resuming normal operation.  
52 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Chapter 6. Fn key combinations  
The following table shows the function of each combination of Fn with a function key.  
Table 8. Fn key combinations  
Key combination  
Fn+F1  
Description  
Reserved.  
Fn+F2  
Lock the computer.  
Fn+F3  
Select a power plan (in Windows XP, power scheme) that has been created by Power Manager,  
or adjust the power level by using the slider control. When you press this combination, a  
panel for selecting a power plan (power scheme) appears.  
Notes:  
To use this combination of the keys, ThinkPad PM device driver must have been installed  
on the computer.  
If you have logged on with an administrator user ID in Windows XP, and you press Fn+F3,  
the panel for selecting a power scheme appears. If you have logged on with another user  
ID in Windows XP, and you press Fn+F3, the panel does not appear.  
Fn+F4  
Put the computer in sleep (standby) mode. To return to normal operation, press the Fn key  
only, without pressing a function key.  
Notes:  
To use this combination of the keys, ThinkPad PM device driver must have been installed  
on the computer.  
If you want to use the combination to put the computer into hibernation mode or  
do-nothing mode (in Windows XP, shut the computer down or show the panel for turning  
off the computer), change the settings in the Power Manager.  
Fn+F5  
Enable or disable the built-in wireless networking features. If you press Fn+F5, a list of wireless  
features is displayed. You can quickly change the power state of each feature in the list.  
Notes: If you want to use Fn+F5 to enable or disable the wireless features, the following  
device drivers must be installed on the computer beforehand:  
• Power Management driver  
• OnScreen Display Utility  
• Wireless device drivers  
Fn+F6  
Fn+F7  
Change the camera and audio settings. When you press Fn+F6, the camera and audio setting  
window is opened and the camera preview is turned on.  
Note: The camera settings area only appears if the computer has an integrated camera.  
Apply a presentation scheme directly, with no need to start Presentation Director.  
To disable this function and use the Fn+F7 key combination for switching a display output  
location, start Presentation Director, and change the settings.  
Note: If the computer is an Windows 7 model, it does not support presentation schemes,  
however the Fn+F7 combination might still be used to switch display output location.  
For Windows 7:  
Switch between the computer display and an external monitor. Windows will show these  
display options:  
• Computer display only (LCD)  
• Computer display and external monitor (same image)  
• Computer display and external monitor (extended desktop function)  
• External monitor only  
© Copyright Lenovo 2011  
53  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Table 8. Fn key combinations (continued)  
Key combination  
Description  
Note: To switch between the computer display and an external monitor, the Win+P key  
combination is also available.  
For Windows Vista and Windows XP:  
Switch between the computer display and an external monitor. If an external monitor is  
attached, computer output is displayed in the following three patterns by turns:  
• External monitor (CRT display)  
• Computer display and external monitor (LCD + CRT display)  
• Computer display (LCD)  
Notes:  
This function is not supported if different desktop images are displayed on the computer  
display and the external monitor (the Extend desktop function).  
This function does not work while a DVD movie or a video clip is playing.  
To enable this function, start Presentation Director, and change the settings.  
Note: Multiple users can log on to a single operating system by using different user IDs. Each  
user needs to do the following: Click Start All Programs ThinkVantage Presentation  
Director, and change the Fn+F7 settings.  
Change the settings of the UltraNav® pointing device.  
Fn+F8  
Fn+F9  
Reserved.  
Reserved.  
Reserved.  
Fn+F10  
Fn+F11  
Fn+F12  
Put the computer into hibernation mode. To return to normal operation, press the power  
button for less than four seconds.  
Notes:  
To use this combination of the keys, ThinkPad PM device driver must have been installed  
on the computer.  
Though the screen fades out immediately after Fn+F12 are pressed, the computer  
does not enter the hibernation mode immediately. Do not move the system until the  
sleep (standby) status indicator stops blinking. Moving the computer when it is entering  
hibernation might cause corruption of the hard disk drive.  
Fn+PgUp  
Fn+Home  
Turn the ThinkLight® on or off.  
Note: This function is supported only on the ThinkPad Notebooks that have the ThinkLight.  
The on or off status of the ThinkLight is shown on the screen for a few seconds when you  
press Fn+PgUp.  
The computer display becomes brighter.  
The purpose of this method is to change the brightness level temporarily. On Windows Vista,  
the default brightness level is loaded after sleep (standby), hibernation, reboot, or detaching or  
attaching an ac power adapter. To change the default brightness level, change the settings of  
the Power Option in the Control Panel or use the Power Manager.  
Fn+End  
The computer display becomes dimmer.  
The purpose of this method is to change the brightness level temporarily. On Windows Vista,  
the default brightness level is loaded after sleep (standby), hibernation, reboot, or detaching or  
attaching an ac power adapter. To change the default brightness level, change the settings of  
the Power Option in the Control Panel or use the Power Manager.  
Fn+Spacebar  
Enable the Full Screen Magnifier function.  
54 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 8. Fn key combinations (continued)  
Key combination  
Fn+PrtSc  
Description  
Have the same function as the SysRq key.  
Fn+ScrLk  
Enable or disable the numeric keypad. The indicator of numeric lock will be displayed on  
the screen.  
Fn+Pause  
Have the same function as the Break key.  
Fn+cursor keys  
These key combinations work with Windows Media Player. They have the following functions:  
• Fn + down arrow key: Play or Pause  
• Fn + up arrow key: Stop  
• Fn + right arrow key: Next Track  
• Fn + left arrow key: Previous Track  
Chapter 6. Fn key combinations 55  
Download from Www.Somanuals.com. All Manuals Search And Download.  
56 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Chapter 7. FRU replacement notices  
This chapter presents notices related to removing and replacing parts. Read this chapter carefully before  
replacing any FRU.  
External CRU statement to customers:  
Some problems with your product can be resolved with a replacement part you can install yourself, called  
a “Customer Replaceable Unit” or “CRU.” Some CRUs are designated as Self-service CRUs and others  
are designated as Optional-service CRUs. Installation of Self-service CRUs is your responsibility; you may  
request that Lenovo installs an Optional-service CRU according to the warranty service for your product.  
Where you are installing the CRU, Lenovo will ship the CRU to you. CRU information and replacement  
instructions are shipped with your product and are available from Lenovo at any time upon request. You may  
find a list of CRUs in the publications that ship with your product or at http://www.lenovo.com/CRUs. You  
may be required to return the defective part that is replaced by the CRU. When return is required: (1) return  
instructions, a prepaid shipping label, and a container will be included with the replacement CRU; and (2) you  
may be charged for the replacement CRU if Lenovo does not receive the defective part within thirty (30) days  
of your receipt of the replacement CRU. See your Lenovo Limited Warranty documentation for full details.  
Screw notices  
Loose screws can cause a reliability problem. In the ThinkPad Notebook, this problem is addressed with  
special nylon-coated screws that have the following characteristics:  
• They maintain tight connections.  
• They do not easily come loose, even with shock or vibration.  
• They are harder to tighten.  
• Each one should be used only once.  
Do the following when you service this machine:  
• Keep the screw kit (for the P/N, see “Miscellaneous parts” on page 156) in your tool bag.  
• Always use new screws.  
• Use a torque screwdriver if you have one.  
Tighten screws as follows:  
Plastic to plastic  
Turn an additional 90 degrees after the screw head touches the surface of the plastic part:  
Logic card to plastic  
Turn an additional 180 degrees after the screw head touches the surface of the logic card:  
© Copyright Lenovo 2011  
57  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
Torque driver  
If you have a torque driver, refer to the “Torque” column for each step.  
• Make sure that you use the correct screw. If you have a torque screwdriver, tighten all screws firmly to the  
torque shown in the table. Never use a screw that you removed. Use a new one. Make sure that all  
of the screws are tightened firmly.  
• Ensure torque screw drivers are calibrated correctly following country specifications.  
Retaining serial numbers  
This section includes the following descriptions:  
“Retaining the UUID” on page 59  
Restoring the serial number of the system unit  
When the computer was manufactured, the EEPROM on the system board was loaded with the serial  
numbers of the system and all major components. These numbers need to remain the same throughout  
the life of the computer.  
If you replace the system board, you must restore the serial number of the system unit to its original value.  
Before replacing the system board, save the original serial number by doing the following:  
1. Install the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later, and restart the  
computer.  
2. From the main menu, select 1. Set System Identification.  
3. Select 2. Read S/N data from EEPROM.  
The serial number of each device in your computer is displayed; the serial number of the system unit is  
listed as follows:  
• 20: Serial number  
Write down that number.  
Note: The serial number of the system unit is also written on the label attached to the bottom of the computer.  
After you have replaced the system board, restore the serial number by doing the following:  
1. Install the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later and restart the  
computer.  
2. From the main menu, select 1. Set System Identification.  
3. Select 1. Add S/N data from EEPROM. Follow the instructions on the screen.  
If the MTM and Product ID numbers differ from each other on the rear label, use what is shown for the  
Product ID field. See example below:  
58 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
MTM on rear label:  
TTTT-CTO S/N SSSSSSS  
Product ID on rear label:  
TTTT-MMM (Use this number when setting Serial  
Number)  
In the example, the Serial Number to be input is “1STTTTMMMSSSSSSS”.  
Retaining the UUID  
The Universally Unique Identifier (UUID) is a 128-bit number uniquely assigned to your computer at  
production and stored in the EEPROM of your system board. The algorithm that generates the number is  
designed to provide unique IDs until the year A.D. 3400. No two computers in the world have the same  
number.  
When you replace the system board, you must set the UUID on the new system board as follows:  
1. Install the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later, and restart the  
computer.  
2. From the main menu, select 4. Assign UUID. A new UUID is created and written. If a valid UUID already  
exists, it is not overwritten.  
Reading or writing the ECA information  
Information on Engineering Change Announcements (ECA) are stored in the EEPROM of the system board.  
The electronic storage of this information simplifies the procedure to check if the ECA has been previously  
applied to a machine. The machine does not need to be disassembled to check for the ECA application.  
To check what ECAs have been previously applied to the machine, use the ECA Information Read/Write  
function on the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later.  
1. Insert the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later, and restart the  
computer.  
2. From the main menu, select 6. Set ECA Information.  
3. To read ECA information, select 2. Read ECA/rework number from EEPROM and follow the  
instruction.  
4. To read box build date, select 5. Read box build date from EEPROM, and follow the instruction on  
the screen.  
After an ECA has been applied to the machine, the EEPROM must be updated to reflect the ECA's  
application. Use the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later to update the  
EEPROM.  
Note: Only the ECA number is stored in the EEPROM. The machine type of the ECA is assumed be the same  
as the machine type of the machine that had the ECA applied to it.  
1. Insert the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later, and restart the  
computer.  
2. From the main menu, select 6. Set ECA Information.  
3. To write ECA information, select 1. Write ECA/rework number from EEPROM, and follow the  
instruction.  
4. To write box build date, select 4. Write box build date from EEPROM, and follow the instruction on  
the screen.  
If the system board is being replaced, try to read the ECA information from the old system board and transfer  
the information to the new system. If the system board is inoperable, this will not be possible.  
Chapter 7. FRU replacement notices 59  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
60 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Chapter 8. Removing and replacing a FRU  
This chapter presents directions and drawings for use in removing and replacing a FRU.  
External CRU statement to customers:  
Some problems with your product can be resolved with a replacement part you can install yourself, called  
a “Customer Replaceable Unit” or “CRU.” Some CRUs are designated as Self-service CRUs and others  
are designated as Optional-service CRUs. Installation of Self-service CRUs is your responsibility; you may  
request that Lenovo installs an Optional-service CRU according to the warranty service for your product.  
Where you are installing the CRU, Lenovo will ship the CRU to you. CRU information and replacement  
instructions are shipped with your product and are available from Lenovo at any time upon request. You may  
find a list of CRUs in the publications that ship with your product or at http://www.lenovo.com/CRUs. You  
may be required to return the defective part that is replaced by the CRU. When return is required: (1) return  
instructions, a prepaid shipping label, and a container will be included with the replacement CRU; and (2) you  
may be charged for the replacement CRU if Lenovo does not receive the defective part within thirty (30) days  
of your receipt of the replacement CRU. See your Lenovo Limited Warranty documentation for full details.  
Be sure to observe the following general rules:  
1. Do not try to service any computer unless you have been trained and certified. An untrained person runs  
the risk of damaging parts.  
2. Before replacing any FRU, review Chapter 7 “FRU replacement notices” on page 57.  
3. Begin by removing any FRUs that have to be removed before replacing the failing FRU. Any such FRUs  
are listed at the top of each FRU replacement page. Remove them in the order in which they are listed.  
4. Follow the correct sequence in the steps for removing a FRU, as given in the drawings by the numbers  
in square callouts.  
5. When turning a screw to replace a FRU, turn it in the direction as given by the arrow in the drawing.  
6. When removing a FRU, move it in the direction as given by the arrow in the drawing.  
7. To put the new FRU in place, reverse the removal procedure and follow any notes that pertain to  
replacement. For information about connecting and arranging internal cables, see Chapter 9 “Locations”  
on page 125.  
8. When replacing a FRU, use the correct screw(s) as shown in the procedures.  
DANGER  
Before removing any FRU, turn off the computer, unplug all power cords from electrical outlets,  
remove the battery pack, and then disconnect any interconnecting cables.  
Attention: After replacing a FRU, do not turn on the computer until you have made sure that all screws,  
springs, and other small parts are in place and none are loose inside the computer. Verify this by shaking  
the computer gently and listening for rattling sounds. Metallic parts or metal flakes can cause electrical  
short circuits.  
Attention: The system board is sensitive to, and can be damaged by, electrostatic discharge. Before  
touching it, establish personal grounding by touching a ground point with one hand or by using an  
electrostatic discharge (ESD) strap (P/N 6405959).  
© Copyright Lenovo 2011  
61  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Before servicing ThinkPad T420 and T420i  
Some models of the ThinkPad T420 and T420i you are servicing might have the SIM card that the customer  
has installed.  
If the computer you are servicing has the SIM card, remove it before you start the servicing.  
To remove the SIM card, you need to remove the battery pack first. (See “1010 Battery pack” on page 63.)  
After you finish the servicing, make sure that you insert the card back into the slot firmly.  
62 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
1010 Battery pack  
Important notice for replacing a battery pack:  
Lenovo ThinkVantage Toolbox (in Windows 7) has an automatic battery diagnostic that determines if the  
battery pack is defective. A battery pack FRU should not be replaced unless this diagnostic shows that  
the battery is defective.  
The only exception to this is if the battery pack is physically damaged or a customer is reporting a possible  
safety issue.  
If Lenovo ThinkVantage Toolbox is not installed in the computer, the customer should download this program  
before a non-physically damaged battery pack is replaced. Note that the replacement of a physically  
damaged battery pack is not covered by the warranty.  
Removal steps of battery pack  
DANGER  
Use only the battery specified in the parts list for your computer. Any other battery could ignite  
or explode.  
Unlock the battery latch 1 . Holding the battery latch in the unlocked position 2 , remove the battery pack in  
the direction shown by arrow 3 .  
When installing: Install the battery pack in the slot. Make sure that the battery latch is in the locked position.  
Chapter 8. Removing and replacing a FRU 63  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
1020 ExpressCard blank bezel  
Removal steps of ExpressCard blank bezel  
When you press the ExpressCard blank bezel 1 , it pops out 2 .  
When installing: Make sure that the bezel is correctly oriented as shown in the following figure.  
64 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
1030 Serial Ultrabay Enhanced device or travel bezel  
For access, remove this FRU:  
Removal steps of Serial Ultrabay Enhanced device or travel bezel  
Holding the bay lock latch in the unlocked position 1 , slide the bay eject latch in the direction shown by  
arrow 2 , and then pull out the Serial Ultrabay Enhanced device or the travel bezel in the direction shown by  
arrow 3 to completely remove it.  
Chapter 8. Removing and replacing a FRU 65  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
1040 Hard disk drive (HDD) and solid state drive (SSD)  
For access, remove this FRU:  
Attention:  
• Do not drop the drive or apply any physical shock to it. The drive is sensitive to physical shock. Improper  
handling can cause damage and permanent loss of data.  
• Before removing the drive, have the user make a backup copy of all the information on it if possible.  
• Never remove the drive while the system is operating or is in suspend mode.  
Removal steps of hard disk drive and solid state drive  
Note: Loosen the screw 1 , but do not remove it.  
4
1
2
Torque  
Step  
Screw (quantity)  
Color  
1
Black  
0.181 Nm  
Capture screw (1)  
(1.85 kgfcm)  
66 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
For HDD and HDD rubber rails (9.5 mm):  
4
4
For HDD and HDD rubber rails (7.0mm) :  
4
4
For SSD and spacers:  
4
4
Chapter 8. Removing and replacing a FRU 67  
Download from Www.Somanuals.com. All Manuals Search And Download.  
When installing: Make sure that SSD spacers or HDD rubber rails are attached firmly.  
68 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
1050 DIMM slot cover  
For access, remove this FRU:  
Removal steps of DIMM slot cover  
Note: Loosen the screw 1 , but do not remove it.  
Chapter 8. Removing and replacing a FRU 69  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
1060 DIMM (in the slot on the underside of the computer)  
For access, remove these FRUs in order:  
Note: Your computer has two DIMM slots: one under the keyboard and another on the underside of the  
computer. If you install a DIMM in only one of the two slots, install it in the slot located under the keyboard.  
Removal steps of DIMM (in the slot on the underside of the computer)  
When installing: Insert the notched end of the DIMM into the socket. Press the DIMM firmly, and pivot it  
until it snaps into place. Make sure that it is firmly fixed in the slot and does not move easily.  
70 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
1070 PCI Express Mini Card for wireless WAN  
For access, remove these FRUs in order:  
Removal steps of PCI Express Mini Card for wireless WAN  
In step 1 , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159), or pick the  
connectors with your fingers and gently unplug them in the direction of the arrow.  
Torque  
Step  
Screw (quantity)  
Color  
2
Black  
0.181 Nm  
M2 × 3 mm, wafer-head, nylon-coated (1)  
(1.85 kgfcm)  
Chapter 8. Removing and replacing a FRU 71  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
3
Note: Plug the yellow cable into the jack labeled MAIN, and the blue cable into the jack labeled AUX  
on the card.  
If the computer you are servicing is a wireless WAN-ready model and does not have a wireless WAN card,  
route the antenna cables and secure them with a tape as shown in the following figure.  
72 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
1080 Keyboard  
For access, remove these FRUs in order:  
Removal steps of keyboard  
Torque  
Step  
Screw (quantity)  
Color  
1
0.181 Nm  
M2 × 10 mm, wafer-head, nylon-coated (1)  
Silver  
(1.85 kgfcm)  
Push down the keyboard a little and slide it toward the arrow 2 to detach the front edge of the keyboard  
from the frame.  
Chapter 8. Removing and replacing a FRU 73  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Lift the keyboard a little in the direction shown by arrow 3 , and then detach the connector 4 .  
Installation steps of keyboard  
When installing the keyboard, do the following:  
1. Attach the keyboard connector.  
74 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
2. Attach the keyboard so that the keyboard edges a are under the frame.  
3. To make sure that the front edge of the keyboard is housed firmly, gently press the keys with your palms  
and slightly slide the keyboard toward you until it snaps into position.  
Chapter 8. Removing and replacing a FRU 75  
Download from Www.Somanuals.com. All Manuals Search And Download.  
4. Make sure that the front edge of the keyboard b is attached firmly.  
5. Secure the keyboard by tightening the screws from the bottom side of the computer.  
76 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
1090 DIMM (in the slot under the keyboard)  
For access, remove these FRUs in order:  
Note: Your computer has two DIMM slots: one under the keyboard and another on the underside of the  
computer. If you install a DIMM in only one of the two slots, install it in the slot located under the keyboard.  
Removal steps of DIMM (in the slot under the keyboard)  
Chapter 8. Removing and replacing a FRU 77  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
When installing: Insert the notched end of the DIMM into the socket. Press the DIMM firmly, and pivot it  
until it snaps into place. Make sure that it is firmly fixed in the slot and does not move easily.  
78 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
1100 Backup battery  
For access, remove these FRUs in order:  
Removal steps of backup battery  
DANGER  
Use only the battery specified in the parts list for your computer. Any other battery could ignite  
or explode.  
Cable routing: Attach the backup battery and route the cable as shown in the figure below and make  
sure that the battery connector is attached firmly.  
Chapter 8. Removing and replacing a FRU 79  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
80 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
1110 PCI Express Mini Card for wireless LAN  
For access, remove these FRUs in order:  
Removal steps of PCI Express Mini Card for wireless LAN  
In step 1 , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159), or pick the  
connectors with your fingers and gently unplug them in the direction of the arrow.  
Note: Some models might have only two antenna cables.  
Torque  
Step  
Screw (quantity)  
Color  
2
0.181 Nm  
M2 × 10 mm, wafer-head, nylon-coated (1)  
Silver  
(1.85 kgfcm)  
Chapter 8. Removing and replacing a FRU 81  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
3
When installing:  
• In models with a wireless LAN card that has two antenna connectors, plug the gray cable into the jack  
marked MAIN or M, and the black cable into the jack marked AUX or A on the card. If the computer  
you are servicing has three cables, put the white cable in the cable protection tube and secure it with a  
tape as shown in this figure.  
• In models with a wireless LAN card that has three antenna connectors, plug the gray cable (MAIN) into  
the jack marked TR1, the white cable (third) into the jack marked RO or TR3, and the black cable (AUX)  
into the jack marked TR2 on the card.  
.
82 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
1120 Keyboard bezel assembly, FPC cable, and Bluethooth daughter  
card  
For access, remove these FRUs in order:  
Note: The FPC cable is attached on the underside of the keyboard bezel assembly. In some models, the  
Bluetooth daughter card is also attached on the underside of the keyboard bezel assembly. For the models  
that do not have a Bluetooth daughter card, skip steps 8 to 10 .  
Removal steps of keyboard bezel assembly, FPC cable, and Bluetooth daughter card  
Torque  
Step  
Screw (quantity)  
Color  
1
Black  
0.181 Nm  
M2 × 3 mm, wafer-head, nylon-coated (1)  
(1.85 kgfcm)  
2
Black  
0.181 Nm  
M2 × 15 mm, wafer-head, nylon-coated (4)  
(1.85 kgfcm)  
Chapter 8. Removing and replacing a FRU 83  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Torque  
Step  
Screw (quantity)  
Color  
3
Black  
0.181 Nm  
M2 × 3 mm, wafer-head, nylon-coated (1)  
(1.85 kgfcm)  
4
0.181 Nm  
Shoulder screw (2)  
Silver  
(1.85 kgfcm)  
84 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
When installing: Make sure that the connector is attached firmly.  
Chapter 8. Removing and replacing a FRU 85  
Download from Www.Somanuals.com. All Manuals Search And Download.  
When installing: Make sure that the connectors are attached firmly.  
Torque  
Step  
Screw (quantity)  
Color  
13  
Black  
0.181 Nm  
M2 × 3 mm, wafer-head, nylon-coated (1)  
(1.85 kgfcm)  
86 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
When installing: Make sure that the connector is attached firmly.  
Chapter 8. Removing and replacing a FRU 87  
Download from Www.Somanuals.com. All Manuals Search And Download.  
1130 SmartCard  
For access, remove these FRUs in order:  
Removal steps of SmartCard  
Torque  
Step  
Screw (quantity)  
Color  
1
Black  
0.181 Nm  
M2 × 3 mm, wafer-head, nylon-coated (2)  
(1.85 kgfcm)  
3
2
88 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
When installing: Make sure that the connector is attached firmly.  
Removal steps of SmartCard dummy spacer  
Some models have a SmartCard dummy spacer as a miscellaneous part. For those models, remove the  
spacer as shown:  
Torque  
Step  
Screw (quantity)  
Color  
1
Black  
0.181 Nm  
M2 × 3 mm, wafer-head, nylon-coated (2)  
(1.85 kgfcm)  
Chapter 8. Removing and replacing a FRU 89  
Download from Www.Somanuals.com. All Manuals Search And Download.  
1140 Modem daughter card (MDC)  
For access, remove these FRUs in order:  
Removal steps of modem daughter card (MDC)  
1
1
2
Torque  
Step  
Screw (quantity)  
Color  
1
Black  
0.181 Nm  
M2 × 3 mm, wafer-head, nylon-coated (2)  
(1.85 kgfcm)  
When installing: Make sure that the connector is attached firmly.  
90 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
1150 Speaker assembly  
For access, remove these FRUs in order:  
Removal steps of speaker assembly  
Torque  
Step  
Screw (quantity)  
Color  
1
Black  
0.181 Nm  
M2 × 3 mm, wafer-head, nylon-coated (3)  
(1.85 kgfcm)  
Chapter 8. Removing and replacing a FRU 91  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
When installing: Attach the speaker assembly and route the cable as shown in the following figure, and  
make sure that the speaker connector is attached firmly.  
92 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
1160 LCD unit  
For access, remove these FRUs in order:  
Removal steps of LCD unit  
Torque  
Step  
Screw (quantity)  
Color  
1
Black  
0.392 Nm  
M2.5 × 6 mm, wafer-head, nylon-coated (2)  
(4.0 kgfcm)  
Chapter 8. Removing and replacing a FRU 93  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Torque  
Step  
Screw (quantity)  
Color  
2
Black  
0.181 Nm  
M2 × 3 mm, wafer-head, nylon-coated (1)  
(1.85 kgfcm)  
94 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Torque  
Step  
Screw (quantity)  
Color  
6
Black  
0.392 Nm  
M2.5 × 6 mm, wafer-head, nylon-coated (2)  
(4.0 kgfcm)  
When installing:  
• Make sure that you attach the connectors firmly.  
• Make sure that you route the cables correctly and you tape up in the proper positions as shown in  
the above figure.  
• When you route the cables, make sure that they are not subjected to any tension. Tension could cause  
the cables to be damaged by the cable guides, or a wire to be broken.  
Chapter 8. Removing and replacing a FRU 95  
Download from Www.Somanuals.com. All Manuals Search And Download.  
96 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
1170 Fan assembly  
For access, remove these FRUs in order:  
Removal steps of fan assembly  
Note: Loosen the screws 1a to 1d in order, but do not remove them.  
For Discrete Graphics models:  
2
1a  
1d  
1c  
1b  
For Integreted Graphics models:  
Chapter 8. Removing and replacing a FRU 97  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
1a  
1d  
1c  
1b  
Torque  
Step  
Screw (quantity)  
Color  
1
0.181 Nm  
Capture shoulder screw (4)  
Silver  
(1.85 kgfcm)  
2
black  
0.181 Nm  
M2 × 3 mm, wafer-head, nylon-coated (1)  
(1.85 kgfcm)  
For Discrete Graphics models:  
3
4
98 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
For Integreted Graphics models:  
When installing:  
• Before you attach the fan assembly to the computer, apply thermal grease, at an amount of 0.2 grams, on  
the parts marked a as in the following figures. Either too much or too less application of grease can  
cause a thermal problem due to imperfect contact with a component. For the fan in the integrated  
graphics models, you need to peel the thin film off from the thermal rubber marked b .  
For Discrete Graphics models:  
a
b
For Integrated Graphics models:  
Chapter 8. Removing and replacing a FRU 99  
Download from Www.Somanuals.com. All Manuals Search And Download.  
a
• When attaching the fan assembly to the frame, take care not to damage the heat sink a of the fan  
assembly.  
• Make sure that the fan connector is attached firmly.  
100 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
1180 CPU  
For access, remove these FRUs in order:  
Attention: The CPU is extremely sensitive. When you service the CPU, avoid any kind of rough handling.  
Removal steps of CPU  
Rotate the head of the screw in the direction shown by arrow 1 to release the lock, and then remove the  
CPU 2 . After that peel the mylar off from the CPU as shown by arrow 4 .  
2
4
3
1
When installing: Make sure that the mylar is attached to the CPU. Place the CPU on the CPU socket, and  
then rotate the head of the screw in the direction shown by arrow 3 to secure the CPU.  
Chapter 8. Removing and replacing a FRU 101  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
1190 Base cover assembly and DC-in connector cable  
For access, remove these FRUs in order:  
Removal steps of base cover assembly and DC-in connector cable  
Torque  
Step  
Screw (quantity)  
Color  
1
Black  
0.181 Nm  
M2 × 8 mm, wafer-head, nylon-coated (5)  
(1.85 kgfcm)  
102 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
2
2
2
2
2
2
2
2
3
4
Torque  
Step  
Screw (quantity)  
Color  
2
Black  
0.181 Nm  
M2 × 5 mm, wafer-head, nylon-coated (8)  
(1.85 kgfcm)  
When installing: Make sure that the connector is attached firmly.  
When installing: Make sure that the wireless switch is adjusted as shown in callout a .  
Chapter 8. Removing and replacing a FRU 103  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Torque  
Step  
Screw (quantity)  
Color  
7
Black  
0.181 Nm  
M2 × 3 mm, wafer-head, nylon-coated (1)  
(1.85 kgfcm)  
Note: Applying labels to the base cover  
The new base cover FRU is shipped with a kit containing labels of several kinds.  
When you replace the base cover, you need to apply the following label:  
17  
Homologation label  
The following labels need to be peeled off from the old base cover, and need to be put on the new base cover.  
Note: If the COA label 1 is attached to a part that is replaced, return the old part with the label attached to  
the customer, or provide a letter to the customer stating what the label was originally on the system and  
what the label part number, serial number, and product key were.  
1
Windows Certificate of Authentication label (COA)  
2
Wireless LAN MAC address label  
3
Information label  
4
Ethernet MAC address label  
104 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
5
Wireless WAN MAC address label  
China mobile IMEI label  
China telecom IMEI label  
SIRM labels (only for Malaysia)  
Wireless card label (only for Brazil)  
Anatel label (only for Brazil)  
Modem AMOM label (only for Brazil)  
Bluetooth label (only for Brazil)  
Israel label (50 mm x 19 mm)  
No MIC label (only for TAA module assembled in Mexico)  
Vodafone label  
6
7
8
9
10  
11  
12  
13  
14  
15  
16  
18  
19  
20  
21  
22  
FCC label  
Asset tag  
Serial number label  
Product label  
China wireless WAN label  
China modem label  
For some models, you need to apply two FCC labels. Check the old base cover; if it has two FCC labels,  
apply both to the new base cover.  
For the location of each label, refer the following figure:  
Chapter 8. Removing and replacing a FRU 105  
Download from Www.Somanuals.com. All Manuals Search And Download.  
1200 Magnesium structure frame  
For access, remove these FRUs in order:  
“1180 CPU” on page 101  
Removal steps of magnesium structure frame  
Torque  
Step  
Screw (quantity)  
Color  
2
Black  
0.181 Nm  
M2 × 5 mm, wafer-head, nylon-coated (2)  
(1.85 kgfcm)  
106 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
3
4
Black  
Silver  
0.181 Nm  
(1.85 kgfcm)  
M2 × 8 mm, wafer-head, nylon-coated (2)  
Hex stud, nylon-coated (2)  
0.392 Nm  
(4.0 kgfcm)  
Chapter 8. Removing and replacing a FRU 107  
Download from Www.Somanuals.com. All Manuals Search And Download.  
1210 System board and ExpressCard slot assembly  
For access, remove these FRUs in order:  
“1180 CPU” on page 101  
Important notices for handling the system board:  
When handling the system board, bear the following in mind.  
• The system board has an accelerometer, which can be broken by applying several thousands of G-forces.  
Note: Dropping a system board from a height of as little as 6 inches so that it falls flat on a hard bench can subject  
the accelerometer to as much as 6,000 G's of shock.  
• Be careful not to drop the system board on a bench top that has a hard surface, such as metal, wood, or composite.  
• If a system board is dropped, you must test it, using PC-Doctor for DOS, to make sure that the HDD Active  
Protection Systemstill functions.  
Note: If the test shows that HDD Active Protection System is not functioning, be sure to document the drop in a  
reject report, and replace the system board.  
• Avoid rough handling of any kind.  
• At every point in the process, be sure not to drop or stack the system board.  
• If you put a system board down, be sure to put it only on a padded surface such as an ESD mat or a corrugated  
conductive surface.  
After replacing the system board, run PC-Doctor for DOS to make sure that HDD Active Protection System still  
functions. The procedure is as follows:  
1. Place the computer on a horizontal surface.  
2. Run Diagnostics ThinkPad Devices HDD Active Protection Test.  
Attention: Do not apply physical shock to the computer while the test is running.  
Removal steps of system board and ExpressCard slot assembly  
The following components soldered on the top side of the system board are extremely sensitive. When you  
service the system board, avoid any kind of rough handling.  
a
CPU  
b
Accelerometer chip for the HDD Active Protection System  
108 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
c
d
Platform Controller Hub (PCH)  
Graphic Processing Unit (GPU) (Discrete graphics chip)  
Note: The GPU d is only for models with switchable graphics. Models with integrated graphics  
do not have a GPU on the system board.  
For Switchable Graphics models:  
For Integrated Graphics models:  
Chapter 8. Removing and replacing a FRU 109  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Torque  
Step  
Screw (quantity)  
Color  
1
Black  
0.181 Nm  
M2 × 3 mm, wafer-head, nylon-coated (1)  
(1.85 kgfcm)  
When installing: Make sure that the connector is attached firmly.  
1220 mSATA solid state drive  
For access, remove these FRUs in order:  
Attention:  
• Do not drop the drive or apply any physical shock to it. The drive is sensitive to physical shock. Improper  
handling can cause damage and permanent loss of data.  
• Before removing the drive, have the user make a backup copy of all the information on it if possible.  
• Never remove the drive while the system is operating or is in suspend mode.  
110 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Removal steps of mSATA solid state drive  
Torque  
Step  
Screw (quantity)  
Color  
1
Black  
0.181 Nm  
M2 × 3 mm, wafer-head, nylon-coated (1)  
(1.85 kgfcm)  
2
Chapter 8. Removing and replacing a FRU 111  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
2010 LCD bezel assembly  
For access, remove the following FRU:  
Removal steps of LCD bezel assembly  
112 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
2020 LED board  
For access, remove these FRUs in order:  
Removal steps of LED board  
Torque  
Step  
Screw (quantity)  
Color  
1
Black  
0.181 Nm  
M2 × 3 mm, flat-head, nylon-coated (1)  
(1.85 kgfcm)  
Chapter 8. Removing and replacing a FRU 113  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
When installing: Make sure that the connector is attached firmly.  
114 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
2030 Integrated camera  
For access, remove these FRUs in order:  
Removal steps of integrated camera  
1
Torque  
Step  
Screw (quantity)  
Color  
1
Black  
0.181 Nm  
M2 × 3 mm, flat-head, nylon-coated (1)  
(1.85 kgfcm)  
Chapter 8. Removing and replacing a FRU 115  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
116 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
2040 LCD panel and LCD cable  
For access, remove these FRUs in order:  
“2020 LED board” on page 113  
Removal steps of LCD panel and LCD cable  
Torque  
Step  
Screw (quantity)  
Color  
1
Black  
0.181 Nm  
M2 × 3 mm, wafer-head, nylon-coated (4)  
(1.85 kgfcm)  
When installing: When attaching the LCD panel to the cover, gently press the left and right edges covered  
with metal. DO not press the surface of the panel or apply any excessive force to the panel.  
Chapter 8. Removing and replacing a FRU 117  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
When installing: Make sure that the connector is attached firmly.  
118 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
2050 Camera cable  
For access, remove these FRUs in order:  
“2020 LED board” on page 113  
Removal steps of camera cable  
Chapter 8. Removing and replacing a FRU 119  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
2060 Wireless LAN antenna assembly or wireless LAN/WAN antenna  
assembly  
For access, remove these FRUs in order:  
“2020 LED board” on page 113  
Removal steps of wireless LAN antenna assembly or wireless LAN/WAN antenna assembly  
2
2
2
2
1
1
1
1
1
1
1
1
When installing: When you install the antenna kit, route the cables as shown in the figure above. As you  
route the cables, make sure that they are not subjected to any tension. Tension could cause the cables to be  
damaged by the cable guides, or a wire to be broken.  
120 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
3
3
4
4
Torque  
Step  
Screw (quantity)  
Color  
3
Black  
0.181 Nm  
M2 × 3 mm, flat-head, nylon-coated (2)  
(1.85 kgfcm)  
5
5
Chapter 8. Removing and replacing a FRU 121  
Download from Www.Somanuals.com. All Manuals Search And Download.  
2070 Hinges and LCD rear cover assembly  
For access, remove these FRUs in order:  
“2020 LED board” on page 113  
Removal steps of hinges and LCD rear cover assembly  
Torque  
Step  
Screw (quantity)  
Color  
1
Black  
0.392 Nm  
M2.5 × 4 mm, wafer-head, nylon-coated (4)  
(4.0 kgfcm)  
When installing: Attach the hinges as shown in the following figure.  
122 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Chapter 8. Removing and replacing a FRU 123  
Download from Www.Somanuals.com. All Manuals Search And Download.  
124 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Chapter 9. Locations  
This chapter presents the locations of ThinkPad T420 and T420i hardware components.  
Front view  
1
Integrated camera (for some models)  
2
ThinkLight  
3
Built-in microphone  
4
Built-in speakers  
5
Security keyhole  
6
Universal serial bus (USB)/eSATA combo connector  
7
USB connector  
8
Media Card Reader slot  
9
ExpressCard slot  
10  
Serial Ultrabay Enhanced drive or travel bezel  
11  
Combo audio jack  
12  
Fingerprint reader  
13  
Touch pad buttons  
14  
Touch pad  
15  
TrackPoint buttons  
16  
TrackPoint pointing stick  
17  
UltraNav  
18  
Volume control buttons  
19  
ThinkVantage button  
20  
Power switch  
21  
Status indicators  
Note: For the description of each indicator, see Chapter 5 “Status indicators” on page 49.  
© Copyright Lenovo 2011  
125  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
126 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Rear view  
1
Status indicators  
Note: For the description of each indicator, see Chapter 5 “Status indicators” on page 49.  
2
3
4
5
6
7
8
9
SmartCard slot  
DisplayPort connector  
USB connector  
RJ-45 (Ethernet) connector  
External monitor connector  
Power jack  
USB connector  
Modem connector or IEEE 1394  
Chapter 9. Locations 127  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Bottom view  
1
Battery pack  
2
3
4
5
6
7
Battery pack latch  
DIMM slot  
Docking connector  
LCD cover latch  
Serial Ultrabay Enhanced lock latch  
Serial Ultrabay Enhanced eject latch  
128 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Chapter 10. Parts list  
This chapter contains following lists of the service parts.  
“Overall” on page 130  
“LCD FRUs” on page 150  
“Keyboard” on page 154  
“Miscellaneous parts” on page 156  
“Power cords” on page 159  
“Recovery discs” on page 160  
Notes:  
• Each FRU is available for all types or models, unless specific types or models are specified.  
• FRU with specific models listed and described as xxU (where U is an example of a country designator) should be  
used for all models ending in U.  
• FRU with specific models listed and described as 3Dx (where 3D is an example of a unique configuration) should be  
used for all of these models, unless specific country or region designator is specified.  
• A CRU (customer replaceable unit) is identified by a single asterisk (*) or two asterisks (**) in the CRU ID column. An  
N in the CRU ID column means that the part is not a CRU. A single asterisk (*) means that the part is a Self-service  
CRU; two asterisks (**) means that the part is an Optional-service CRU.  
External CRU statement to customers:  
Some problems with your product can be resolved with a replacement part you can install yourself, called  
a “Customer Replaceable Unit” or “CRU.” Some CRUs are designated as Self-service CRUs and others are  
designated as Optional-service CRUs. Installation of Self-service CRUs is your responsibility; you may request  
that Lenovo installs an Optional-service CRU according to the warranty service for your product. Where you are  
installing the CRU, Lenovo will ship the CRU to you. CRU information and replacement instructions are shipped  
with your product and are available from Lenovo at any time upon request. You may find a list of CRUs in the  
publications that ship with your product or at http://www.lenovo.com/CRUs. You may be required to return the  
defective part that is replaced by the CRU. When return is required: (1) return instructions, a prepaid shipping label,  
and a container will be included with the replacement CRU; and (2) you may be charged for the replacement CRU if  
Lenovo does not receive the defective part within thirty (30) days of your receipt of the replacement CRU. See your  
Lenovo Limited Warranty documentation for full details.  
ThinkPad Notebooks contain the following types of CRUs:  
Self-service CRUs: These CRUs unplug or are held by no more than two screws. Examples of these types  
of CRUs include the ac power adapter, power cord, battery, and hard disk drive. Other Self-service CRUs  
depending on product design may include the memory module, wireless card, keyboard, and palm rest with  
finger print reader and touchpad.  
Optional-service CRUs: These CRUs are isolated parts within the computer that are concealed by an access  
panel that is typically secured by more than two screws. Once the access panel is removed, the specific  
CRU is visible.  
• FRUs marked with OP are available as options.  
© Copyright Lenovo 2011  
129  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
Overall  
1
30  
29  
2
3
4
28  
27  
a
26  
b
5
c
25  
24  
6
7
23  
22  
8
21  
9
10  
20  
11  
12  
19  
18  
13  
14  
3
17  
16  
15  
130 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Table 9. Parts list—Overall  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
a - c  
See “Miscellaneous parts” on page 156.  
LCD unit (see “LCD FRUs” on page 150.)  
1
2
60Y3247  
60Y3249  
**  
ThinkPad b/g/n Wireless (1x1 BGN)  
• 4177-CTO, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Kx,  
2Lx, 2Mx, 2Xx, 2Yx, 36x, GFx, GKx, GLx, GMx, Q7x, QDx, QQx, QRx, QSx,  
R4x, RDx, RFx, RNx, RPx  
• 4178-CTO, 53x, 6Bx, 6Cx, 6Dx, 6Ex, 9Fx, 9Gx, 9Hx, 9Jx, 9Kx, 9Lx, 9Mx, 9Nx,  
9Sx, 9Tx, 9Ux, 9Vx, 9Wx, 9Xx, 9Yx, AGx, AHx, AMx, AQx, ARx, AZx, B2x, B3x,  
B4x, B5x, B6x, BDx, BEx, BFx, BHx, BJx, BMx, BNx, CCx, CDx, CRx, CSx  
• 4179-CTO, G2x, G3x, G4x, G5x, G6x, G7x, G8x, G9x, GGx, GHx, GJx, GMx,  
GNx, GPx, GSx, GTx, GUx, GXx  
• 4180-CTO, LEx, LFx, LGx, LHx, LJx, LKx, LNx, LPx, LRx, LSx, LTx, MAx, PDx,  
PEx  
• 4236-CTO, N6x, N7x, N8x, N9x, NCx, NKx, NLx, P4x, PBx, PPx, PQx  
• 4237-CTO  
• 4238-CTO  
Intel® Centrino® Wireless-N 1000  
2
60Y3241  
**  
• 4177-CTO, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 32x, 33x, 34x, QGx, QJx, QKx,  
QLx, QMx, QPx, QTx, QVx, QWx, QXx, QYx, QZx, R2x, R3x, R5x, R6x, R9x,  
RBx, RCx, RGx, RHx, RJx, RQx, RRx, RSx, RTx, RUx, RVx, RYx, RZx  
• 4178-CTO, 5Jx, 66x, 6Mx, 6Nx, 6Tx, 82x, 83x, 84x, A5x, A6x, A7x, AAx, ACx,  
ADx, AEx, AFx, AJx, AKx, AUx, AVx, B7x, B8x, B9x, BAx, BBx, BCx, BKx, BPx,  
BQx, BRx, BUx, BVx, BWx, BXx, C2x, C9x, CEx, CFx, CGx, CHx, CJx, CKx,  
CLx, CMx, CNx, CPx, CQx, CUx, CXx  
• 4179-CTO, GCx, GDx, GEx, GVx, GWx  
• 4180-CTO, J4x, MTx, MUx, MVx, MWx, MXx, N3x, N4x, N5x, PJx, PKx, PLx,  
PMx, PNx, PPx, PQx, Q6x, Q7x, Q8x, Q9x  
• 4236-CTO, NXx, NYx, P7x, P8x, PCx, PDx, PEx, PJx  
• 4237-CTO  
• 4238-CTO  
2
60Y3253  
**  
Intel Centrino Advanced-N 6205 (2x2 AGN)  
• 4177-CTO, 22x, 23x, 24x, 2Nx, 2Px, 35x, Q2x, Q3x, Q4x, Q5x, QHx, QNx,  
R8x, RAx, RKx, RLx, RMx, RWx, RXx  
• 4178-CTO, 52x, 54x, 55x, 56x, 57x, 58x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Fx,  
5Gx, 5Hx, 5Kx, 5Lx, 5Mx, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx, 5Wx, 5Xx,  
5Yx, 5Zx, 68x, 69x, 6Ax, 6Fx, 6Gx, 6Hx, 6Jx, 6Kx, 6Lx, 6Px, 6Qx, 6Rx, 6Sx,  
6Ux, 6Vx, 6Wx, 6Xx, 6Yx, 6Zx, 92x, 93x, 94x, 95x, 96x, 97x, 98x, 9Dx, 9Ex,  
9Qx, 9Rx, 9Zx, A2x, A3x, A4x, A8x, A9x, ABx, ALx, ANx, APx, ASx, ATx, AWx,  
AXx, AYx, BGx, BSx, BTx, BYx, BZx, C3x, C4x, C5x, C6x, C7x, C8x, CAx,  
CVx, CWx, CYx  
• 4179-CTO, GBx, GQx, GRx  
• 4180-CTO, 62x, 63x, 64x, 65x, J2x, J3x, K2x, K3x, K4x, K5x, K6x, K7x, K8x,  
K9x, KAx, KBx, KCx, KDx, KEx, KFx, KHx, KJx, KKx, KLx, KMx, KNx, KPx,  
KQx, KRx, KSx, KTx, KUx, KVx, KWx, L4x, L5x, L6x, L7x, L8x, L9x, LAx, LBx,  
LCx, LDx, LLx, LMx, LQx, LUx, LVx, LWx, LXx, LYx, LZx, M2x, M3x, M4x, M7x,  
M8x, M9x, MBx, MCx, MDx, MEx, MFx, MGx, MHx, MJx, MKx, MLx, MMx,  
MNx, MQx, MRx, MSx, MYx, MZx, N2x, N6x, N7x, N8x, N9x, NBx, NCx, NDx,  
NEx, PAx, PBx, PCx, PFx, PGx, PHx, PRx, PSx, PUx, PVx, PWx, PXx, PYx,  
PZx, Q2x, Q3x, Q4x  
• 4236-CTO, 62x, 63x, 64x, 65x, MBx, N2x, N3x, N5x, NAx, NBx, NDx, NEx, NHx,  
NMx, NNx, NSx, NTx, NUx, NVx, P3x, P5x, P6x, PAx, PHx, PKx, PLx, PNx, PRx,  
PSx, PTx, PUx, PVx, PWx, PXx, PYx  
• 4237-CTO  
• 4238-CTO  
Chapter 10. Parts list 131  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
2
60Y3233  
**  
Intel Centrino Ultimate-N 6300  
• 4177-CTO, 2Hx, 2Jx, Q8x, QFx  
• 4178-CTO, 67x, 99x, 9Ax, 9Bx, 9Cx, CBx  
• 4179-CTO  
• 4180-CTO, KGx, KXx, KYx, KZx, L2x, L3x, M5x, M6x, NAx, NFx, PTx, Q5x  
• 4236-CTO, N4x, NFx, NGx, NPx, NQx, NRx, NWx, P2x, P9x, PFx, PGx, PMx  
• 4237-CTO  
• 4238-CTO  
2
2
3
3
60Y3195  
60Y3209  
55Y3715  
55Y3716  
**  
**  
**  
**  
Intel Centrino Advanced-N + WiMAX 6250, WW SKU  
• 4177-CTO, QAx, QBx, QEx, QUx, R7x  
• 4178-CTO, 9Px  
• 4179-CTO  
• 4180-CTO, MPx  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
Intel Centrino Advanced-N + WiMAX 6250, Russia SKU  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
1-GB DDR3-1333 SDRAM SO-DIMM (PC3-10600) card  
• 4177-CTO, 2Fx, Q7x, QAx  
• 4178-CTO, 5Lx, 5Mx, 6Tx, 92x, 94x, 96x, 97x, 9Ux, ADx, AKx  
• 4179-CTO  
• 4180-CTO, N3x, N6x, N7x  
• 4236-CTO, P5x, P6x, P7x  
• 4237-CTO  
• 4238-CTO  
2-GB DDR3-1333 SDRAM SO-DIMM (PC3-10600) card  
• 4177-CTO, 22x, 23x, 24x, 25x, 26x, 28x, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Qx, 2Rx,  
2Xx, 36x, GFx, GKx, GLx, GMx, Q2x, Q4x, Q7x, QCx, QEx, QFx, QQx, QRx,  
QSx, QTx, R5x, R6x, R9x, RNx, RUx  
• 4178-CTO, 56x, 57x, 58x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Fx, 5Gx, 5Hx, 5Kx,  
5Lx, 5Mx, 66x, 6Jx, 6Mx, 6Nx, 6Sx, 6Tx, 83x, 84x, 92x, 94x, 96x, 97x, 98x, 99x,  
9Ax, 9Bx, 9Dx, 9Ex, 9Fx, 9Gx, 9Hx, 9Jx, 9Kx, 9Lx, 9Mx, 9Nx, 9Px, 9Qx, 9Ux,  
9Vx, A5x, A6x, A7x, AAx, ABx, ADx, AEx, AGx, AJx, AKx, ALx, AQx, ARx, ASx,  
AUx, AVx, BBx, BCx, BGx, BKx, CDx, CNx, CYx  
• 4179-CTO, G2x, G3x, G4x, G5x, G6x, G7x, G8x, G9x, GCx, GDx, GEx, GGx,  
GHx, GJx, GPx, GQx, GSx, GTx, GUx, GVx, GWx  
• 4180-CTO, 62x, 63x, 64x, 65x, J2x, J3x, J4x, K3x, K6x, K7x, KQx, LCx, LDx,  
LEx, LFx, LGx, LHx, LJx, LKx, LLx, LMx, LNx, LRx, LSx, LTx, LUx, LVx, LWx,  
M7x, M8x, M9x, MAx, MCx, MGx, MLx, MPx, MTx, MUx, MVx, MWx, MXx,  
MYx, N3x, N6x, N7x, NAx, PDx, PHx, PJx, PKx, PLx, PPx, Q6x, Q7x, Q9x  
• 4236-CTO, 62x, 63x, 64x, 65x, N6x, N7x, N8x, N9x, NAx, NBx, NCx, NKx, NLx,  
NXx, P3x, P4x, P5x, P6x, P7x, PBx, PJx  
• 4237-CTO  
• 4238-CTO  
132 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
3
55Y3717  
**  
4-GB DDR3-1333 SDRAM SO-DIMM (PC3-10600) card  
• 4177-CTO, 27x, 29x, 2Ax, 2Bx, 2Cx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Sx,  
2Tx, 2Ux, 2Vx, 2Wx, 2Yx, 32x, 33x, 34x, 35x, Q3x, Q5x, Q8x, QBx, QDx, QFx,  
QGx, QHx, QJx, QKx, QLx, QMx, QNx, QPx, QUx, QVx, QWx, QXx, QYx, QZx,  
R2x, R3x, R4x, R7x, R8x, RAx, RBx, RCx, RDx, RFx, RGx, RHx, RJx, RKx, RLx,  
RMx, RPx, RQx, RRx, RSx, RTx, RVx, RWx, RXx, RYx, RZx  
• 4178-CTO, 52x, 53x, 54x, 55x, 5Jx, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx,  
5Wx, 5Xx, 5Yx, 5Zx, 67x, 68x, 69x, 6Ax, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx, 6Hx,  
6Kx, 6Lx, 6Px, 6Qx, 6Rx, 6Ux, 6Vx, 6Wx, 6Xx, 6Yx, 6Zx, 82x, 93x, 95x, 99x,  
9Ax, 9Bx, 9Cx, 9Rx, 9Sx, 9Tx, 9Wx, 9Xx, 9Yx, 9Zx, A2x, A3x, A4x, A8x, A9x,  
ACx, AEx, AFx, AHx, AMx, ANx, APx, ATx, AWx, AXx, AYx, AZx, B2x, B3x, B4x,  
B5x, B6x, B7x, B8x, B9x, BAx, BDx, BEx, BFx, BHx, BJx, BMx, BNx, BPx, BQx,  
BRx, BSx, BTx, BUx, BVx, BWx, BXx, BYx, BZx, C2x, C3x, C4x, C5x, C6x, C7x,  
C8x, C9x, CAx, CBx, CCx, CEx, CFx, CGx, CHx, CJx, CKx, CLx, CMx, CPx,  
CQx, CRx, CSx, CUx, CVx, CWx, CXx, CYx  
• 4179-CTO, GBx, GMx, GNx, GRx, GXx  
• 4180-CTO, K2x, K4x, K5x, K8x, K9x, KAx, KBx, KCx, KDx, KEx, KFx, KGx, KHx,  
KJx, KKx, KLx, KMx, KNx, KPx, KRx, KSx, KTx, KUx, KVx, KWx, KXx, KYx,  
KZx, L2x, L3x, L4x, L5x, L6x, L7x, L8x, L9x, LAx, LBx, LPx, LQx, LXx, LYx, LZx,  
M2x, M3x, M4x, M5x, M6x, MBx, MDx, MEx, MFx, MHx, MJx, MKx, MMx,  
MNx, MQx, MRx, MSx, MZx, N2x, N4x, N5x, N8x, N9x, NBx, NCx, NDx, NEx,  
NFx, PAx, PBx, PCx, PEx, PFx, PGx, PMx, PNx, PQx, PRx, PSx, PTx, PUx,  
PVx, PWx, PXx, PYx, PZx, Q2x, Q3x, Q4x, Q5x, Q8x  
• 4236-CTO, MBx, N2x, N3x, N4x, N5x, NDx, NEx, NFx, NGx, NHx, NMx, NNx,  
NPx, NQx, NRx, NSx, NTx, NUx, NVx, NWx, NYx, P2x, P8x, P9x, PAx, PCx,  
PDx, PEx, PFx, PGx, PHx, PKx, PLx, PMx, PNx, PPx, PQx, PRx, PSx, PTx, PUx,  
PVx, PWx, PXx, PYx  
• 4237-CTO  
• 4238-CTO  
4
Keyboard bezel assembly with fingerprint reader  
04W1371  
N
• 4177-CTO, 22x, 23x, 24x, 27x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,  
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx,  
32x, 33x, 34x, 35x, 36x, GFx, GKx, GLx, GMx, Q2x, Q3x, Q4x, Q7x, Q8x, QAx,  
QBx, QCx, QEx, QHx, QNx, QPx, QQx, QRx, QTx, QUx, QVx, QWx, QXx, QYx,  
QZx, R4x, R5x, R6x, R7x, R8x, R9x, RAx, RBx, RCx, RDx, RFx, RGx, RHx, RJx,  
RKx, RLx, RMx, RNx, RPx, RQx, RRx, RSx, RTx, RUx, RWx, RXx, RYx, RZx  
• 4178-CTO, 52x, 53x, 54x, 55x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Fx, 5Gx, 5Hx, 5Jx,  
5Kx, 5Lx, 5Mx, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx, 5Wx, 5Xx, 5Yx, 5Zx,  
66x, 67x, 68x, 69x, 6Ax, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx, 6Hx, 6Jx, 6Kx, 6Lx,  
6Mx, 6Nx, 6Px, 6Qx, 6Rx, 6Sx, 6Tx, 6Ux, 6Vx, 6Wx, 6Xx, 6Yx, 6Zx, 82x, 83x,  
84x, 92x, 93x, 94x, 95x, 96x, 97x, 98x, 99x, 9Ax, 9Bx, 9Cx, 9Dx, 9Ex, 9Jx, 9Kx,  
9Lx, 9Mx, 9Px, 9Qx, 9Sx, 9Tx, 9Ux, 9Vx, 9Wx, 9Xx, 9Yx, 9Zx, A2x, A3x, A4x,  
A8x, A9x, ABx, ADx, AEx, AFx, AGx, AHx, AJx, AKx, ALx, AMx, ANx, APx, ASx,  
ATx, AUx, AVx, AWx, AXx, AYx, AZx, B2x, B3x, B4x, B5x, B6x, B7x, B8x, B9x,  
BAx, BBx, BCx, BDx, BEx, BFx, BGx, BHx, BJx, BKx, BMx, BNx, BPx, BQx,  
BRx, BSx, BTx, BUx, BYx, BZx, C2x, C3x, C4x, C5x, C6x, C7x, C8x, C9x, CAx,  
CBx, CCx, CDx, CEx, CFx, CGx, CHx, CJx, CKx, CLx, CMx, CNx, CPx, CQx,  
CRx, CSx, CUx, CVx, CWx, CXx, CYx  
• 4179-CTO, G3x, G4x, G5x, G6x, G7x, G8x, G9x, GBx, GCx, GDx, GGx, GHx,  
GJx, GMx, GNx, GPx, GQx, GRx, GSx, GTx, GUx, GVx, GWx, GXx  
• 4180-CTO, 63x, 65x, J2x, J3x, J4x, K2x, K3x, K4x, K5x, K6x, K7x, K8x, K9x,  
KAx, KBx, KCx, KDx, KEx, KFx, KGx, KHx, KJx, KKx, KLx, KMx, KNx, KPx,  
KQx, KRx, KSx, KTx, KUx, KVx, KWx, KXx, KYx, KZx, L2x, L3x, L4x, L5x, L6x,  
L7x, L8x, L9x, LAx, LBx, LCx, LDx, LNx, LPx, LQx, LRx, LSx, LTx, LUx, LVx,  
LWx, LXx, LYx, LZx, M2x, M3x, M4x, M5x, M6x, M7x, M8x, MAx, MBx, MCx,  
MDx, MEx, MFx, MGx, MHx, MJx, MKx, MMx, MNx, MPx, MQx, MRx, MSx,  
MTx, MUx, MVx, MWx, MXx, MYx, MZx, N2x, N3x, N4x, N5x, N6x, N7x, N8x,  
Chapter 10. Parts list 133  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
N9x, NAx, NBx, NFx, PAx, PBx, PCx, PFx, PGx, PHx, PKx, PLx, PMx, PNx,  
PPx, PQx, PRx, PSx, PTx, PUx, PVx, PWx, PXx, PYx, PZx, Q3x, Q4x, Q5x,  
Q6x, Q7x, Q8x, Q9x  
• 4236-CTO, 63x, MBx, N2x, N3x, N4x, N5x, N8x, N9x, NAx, NBx, NCx, NDx,  
NEx, NFx, NGx, NHx, NKx, NLx, NMx, NNx, NPx, NQx, NRx, NSx, NTx, NUx,  
NVx, NWx, NXx, NYx, P2x, P3x, P4x, P5x, P6x, P7x, P8x, P9x, PAx, PBx, PCx,  
PDx, PEx, PFx, PGx, PHx, PJx, PKx, PLx, PMx, PNx, PPx, PQx, PRx, PSx,  
PTx, PUx, PVx, PWx, PXx, PYx  
• 4237-CTO  
• 4238-CTO  
4
Keyboard bezel assembly without fingerprint reader  
• 4177-CTO, 25x, 26x, 28x, Q5x, QDx, QFx, QGx, QJx, QKx, QLx, QMx, QSx,  
R2x, R3x, RVx  
04W1372  
N
• 4178-CTO, 56x, 57x, 58x, 59x, 9Fx, 9Gx, 9Hx, 9Nx, 9Rx, A5x, A6x, A7x, AAx,  
ACx, AQx, ARx, BVx, BWx, BXx  
• 4179-CTO, G2x, GEx  
• 4180-CTO, 62x, 64x, LEx, LFx, LGx, LHx, LJx, LKx, LLx, LMx, M9x, MLx, NCx,  
NDx, NEx, PDx, PEx, PJx, Q2x  
• 4236-CTO, 62x, 64x, 65x, N6x, N7x  
• 4237-CTO  
• 4238-CTO  
5
60Y3207  
N
Modem daughter card (MDC)  
• 4177-CTO, 22x, 23x, 24x, 25x, 29x, 2Ax, 2Bx, 2Cx, 2Ex, 2Jx, 2Xx, 36x, GFx,  
GKx, GLx, GMx, Q4x, Q7x, QAx, QCx, QPx, QQx, QRx, QSx, R9x, RBx, RCx,  
RFx  
• 4178-CTO, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Fx, 5Gx, 5Hx, 5Jx, 5Kx, 5Lx, 5Mx, 5Nx,  
5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx, 5Wx, 5Xx, 5Yx, 5Zx, 66x, 67x, 68x, 69x,  
6Ax, 6Hx, 6Jx, 6Kx, 6Lx, 6Qx, 6Rx, 6Sx, 6Tx, 6Xx, 6Yx, 6Zx, 82x, 83x, 84x, 92x,  
93x, 94x, 95x, 96x, 97x, 98x, 99x, 9Ax, 9Bx, 9Cx, 9Dx, 9Ex, A5x, A6x, A7x, AJx,  
AKx, AQx, ARx, BDx, BEx, BFx, BHx, BJx, BMx, BNx, BPx, BQx, BRx, BUx,  
BVx, BWx, BXx, BYx, BZx, C2x, C3x, C4x, CBx  
• 4179-CTO, G2x, G3x, G4x, G5x, G6x, G7x, G8x, G9x, GCx, GDx, GGx, GHx,  
GJx, GMx, GNx, GPx, GQx, GRx, GSx, GTx, GUx, GVx, GWx, GXx  
• 4180-CTO, J2x, J3x, J4x, K2x, K3x, K4x, K5x, K6x, K7x, K8x, K9x, KAx, KBx,  
KCx, KDx, KEx, KFx, KGx, KHx, KJx, KKx, KLx, KMx, KNx, KPx, KQx, KRx,  
KSx, KTx, KUx, KVx, KWx, KXx, KYx, KZx, L2x, L3x, L4x, L5x, L6x, L7x, L8x,  
L9x, LAx, LBx, LCx, LDx, LEx, LFx, LGx, LHx, LJx, LKx, LLx, LMx, LNx, LPx,  
LQx, LRx, LSx, LTx, LYx, LZx, M2x, M3x, M4x, M5x, M6x, M9x, MAx, MBx,  
MCx, MDx, MEx, MFx, MGx, MQx, MRx, MSx, MTx, MUx, MVx, MWx, MXx,  
MZx, N2x, N3x, N4x, N5x, N6x, N7x, N8x, N9x, NAx, NCx, NFx, PDx, PKx, PLx,  
PMx, PNx, PPx, PQx, PSx, PXx, Q3x, Q6x, Q7x, Q8x, Q9x  
• 4236-CTO, MBx, N2x, N3x, N4x, N5x, N6x, N7x, N8x, N9x, NAx, NBx, NCx,  
NDx, NEx, NFx, NGx, NHx, NKx, NLx, NMx, NNx, NPx, NQx, NRx, NSx, NTx,  
NWx, NXx, NYx, P2x, P3x, P4x, P5x, P6x, P8x, P9x, PBx, PCx, PDx, PEx,  
PHx, PJx  
• 4237-CTO  
• 4238-CTO  
6
7
04W1633  
04W1634  
N
N
Speaker assembly  
Magnesium structure frame assembly  
04W1629  
134 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
8
75Y5115  
75Y5113  
75Y5111  
*
DVD-RAM/RW drive  
• 4177-CTO, 22x, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex,  
2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx,  
2Wx, 2Xx, 2Yx, 32x, 33x, 34x, 35x, 36x, GFx, GKx, GLx, GMx, Q2x, Q3x, Q4x,  
Q5x, Q8x, QAx, QBx, QCx, QEx, QGx, QHx, QJx, QKx, QLx, QMx, QNx, QPx,  
QQx, QRx, QSx, QTx, QUx, QVx, QWx, QXx, QYx, QZx, R2x, R3x, R4x, R5x,  
R6x, R7x, R8x, R9x, RAx, RBx, RCx, RDx, RFx, RGx, RHx, RJx, RKx, RLx, RMx,  
RNx, RPx, RQx, RRx, RSx, RTx, RUx, RVx, RWx, RXx, RYx, RZx  
• 4178-CTO, 52x, 53x, 54x, 55x, 56x, 57x, 58x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex,  
5Fx, 5Gx, 5Hx, 5Jx, 5Kx, 5Lx, 5Mx, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx,  
5Wx, 5Xx, 5Yx, 5Zx, 66x, 67x, 68x, 69x, 6Ax, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx,  
6Hx, 6Jx, 6Kx, 6Lx, 6Mx, 6Nx, 6Px, 6Qx, 6Rx, 6Sx, 6Tx, 6Ux, 6Vx, 6Wx, 6Xx,  
6Yx, 6Zx, 82x, 83x, 84x, 92x, 93x, 94x, 95x, 96x, 97x, 98x, 99x, 9Ax, 9Bx, 9Cx,  
9Dx, 9Ex, 9Fx, 9Gx, 9Hx, 9Jx, 9Kx, 9Lx, 9Mx, 9Nx, 9Px, 9Qx, 9Rx, 9Sx, 9Tx,  
9Ux, 9Vx, 9Wx, 9Xx, 9Yx, 9Zx, A2x, A3x, A4x, A5x, A6x, A7x, A8x, A9x, AAx,  
ABx, ACx, ADx, AEx, AFx, AGx, AHx, AJx, AKx, ALx, AMx, ANx, APx, AQx, ARx,  
ASx, ATx, AUx, AVx, AWx, AXx, AYx, AZx, B2x, B3x, B4x, B5x, B6x, B7x, B8x,  
B9x, BAx, BBx, BCx, BDx, BEx, BFx, BGx, BHx, BJx, BKx, BMx, BNx, BPx,  
BQx, BRx, BSx, BTx, BUx, BVx, BWx, BXx, BYx, BZx, C2x, C3x, C4x, C5x,  
C6x, C7x, C8x, C9x, CAx, CBx, CCx, CDx, CEx, CFx, CGx, CHx, CJx, CKx,  
CLx, CMx, CNx, CPx, CQx, CRx, CSx, CUx, CVx, CWx, CXx, CYx  
• 4179-CTO, G2x, G3x, G4x, G5x, G6x, G7x, G8x, G9x, GBx, GCx, GDx, GEx,  
GGx, GHx, GJx, GMx, GNx, GPx, GQx, GRx, GSx, GTx, GUx, GVx, GWx, GXx  
• 4180-CTO, 62x, 63x, 64x, 65x, J2x, J3x, J4x, K2x, K3x, K4x, K5x, K6x, K7x,  
K8x, K9x, KAx, KBx, KCx, KDx, KEx, KFx, KGx, KHx, KJx, KKx, KLx, KMx, KNx,  
KPx, KQx, KRx, KSx, KTx, KUx, KVx, KWx, KXx, KYx, KZx, L2x, L3x, L4x, L5x,  
L6x, L7x, L8x, L9x, LAx, LBx, LCx, LDx, LEx, LFx, LGx, LHx, LJx, LKx, LLx,  
LMx, LNx, LRx, LSx, LTx, LUx, LVx, LWx, LXx, LYx, LZx, M2x, M3x, M4x, M5x,  
M6x, M7x, M8x, M9x, MAx, MBx, MCx, MDx, MEx, MFx, MGx, MHx, MJx,  
MKx, MLx, MMx, MNx, MPx, MQx, MRx, MSx, MTx, MUx, MVx, MWx, MXx,  
MYx, MZx, N2x, N3x, N4x, N5x, N6x, N7x, N8x, N9x, NAx, NBx, NCx, NDx,  
NEx, NFx, PAx, PBx, PCx, PDx, PEx, PFx, PGx, PHx, PJx, PKx, PLx, PMx, PNx,  
PPx, PQx, PRx, PSx, PTx, PUx, PVx, PWx, PXx, PYx, PZx, Q2x, Q3x, Q4x, Q5x,  
Q6x, Q7x, Q8x, Q9x  
• 4236-CTO, 62x, 63x, 64x, 65x, MBx, N2x, N3x, N4x, N5x, N6x, N7x, N8x, N9x,  
NAx, NBx, NCx, NFx, NGx, NHx, NKx, NLx, NMx, NNx, NPx, NQx, NRx, NSx,  
NTx, NUx, NVx, NWx, NXx, NYx, P2x, P3x, P4x, P5x, P6x, P7x, P8x, P9x, PAx,  
PBx, PCx, PDx, PEx, PFx, PGx, PHx, PJx, PKx, PLx, PMx, PNx, PPx, PQx, PRx,  
PSx, PTx, PUx, PVx, PWx, PXx, PYx  
• 4237-CTO  
• 4238-CTO  
8
75Y5117  
*
DVD-ROM drive  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
Chapter 10. Parts list 135  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
8
Travel Bezel  
• 4177-CTO, Q7x, QDx, QFx  
• 4178-CTO  
60Y5512  
*
• 4179-CTO  
• 4180-CTO, LPx, LQx  
• 4236-CTO, NDx, NEx  
• 4237-CTO  
• 4238-CTO  
9
Audio sub card  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
04W1623  
04W1624  
N
N
10 Audio sub card cable  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
11  
12  
04W1635  
04W1630  
N
N
DC-in cable  
I/O sub card (USB only)  
• 4177-CTO, 22x, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex,  
2Jx, 2Xx, 32x, 33x, 34x, 36x, GFx, GKx, GLx, GMx, Q2x, Q3x, Q4x, Q5x, Q7x,  
QAx, QCx, QDx, QFx, QGx, QJx, QKx, QLx, QPx, QQx, QRx, QSx, QTx, QUx,  
QVx, QWx, QXx, QYx, QZx, R2x, R3x, R5x, R6x, R7x, R9x, RBx, RCx, RFx,  
RGx, RHx, RJx, RNx, RPx, RVx, RYx, RZx  
• 4178-CTO, 52x, 53x, 54x, 55x, 56x, 57x, 58x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex,  
5Fx, 5Gx, 5Hx, 5Jx, 5Kx, 5Lx, 5Mx, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx,  
5Wx, 5Xx, 5Yx, 5Zx, 66x, 67x, 68x, 69x, 6Ax, 6Hx, 6Jx, 6Kx, 6Lx, 6Qx, 6Rx,  
6Sx, 6Tx, 6Xx, 6Yx, 6Zx, 82x, 83x, 84x, 92x, 93x, 94x, 95x, 96x, 97x, 98x, 99x,  
9Ax, 9Bx, 9Cx, 9Dx, 9Ex, 9Px, 9Qx, 9Rx, A5x, A6x, A7x, AAx, ABx, ACx, AGx,  
AHx, AJx, AKx, ALx, AMx, ANx, APx, AQx, ARx, ASx, AUx, AVx, B5x, B6x, B7x,  
B8x, B9x, BAx, BBx, BCx, BDx, BEx, BFx, BHx, BJx, BMx, BNx, BPx, BQx,  
BRx, BUx, BVx, BWx, BXx, BYx, BZx, C2x, C3x, C4x, CBx, CCx, CDx, CHx,  
CJx, CRx, CSx, CUx  
• 4179-CTO, G2x, G3x, G4x, G5x, G6x, G7x, G8x, G9x, GCx, GDx, GGx, GHx,  
GJx, GMx, GNx, GPx, GQx, GRx, GSx, GTx, GUx, GVx, GWx, GXx  
• 4180-CTO, J2x, J3x, J4x, K2x, K3x, K4x, K5x, K6x, K7x, K8x, K9x, KAx, KBx,  
KCx, KDx, KEx, KFx, KGx, KHx, KJx, KKx, KLx, KMx, KNx, KPx, KQx, KRx, KSx,  
KTx, KUx, KVx, KWx, KXx, KYx, KZx, L2x, L3x, L4x, L5x, L6x, L7x, L8x, L9x,  
LAx, LBx, LCx, LDx, LEx, LFx, LGx, LHx, LJx, LKx, LLx, LMx, LNx, LPx, LQx,  
LRx, LSx, LTx, LUx, LVx, LWx, LXx, LYx, LZx, M2x, M3x, M4x, M5x, M6x, M7x,  
M8x, M9x, MAx, MBx, MCx, MDx, MEx, MFx, MGx, MLx, MPx, MQx, MRx,  
MSx, MTx, MUx, MVx, MWx, MXx, MYx, MZx, N2x, N3x, N4x, N5x, N6x, N7x,  
N8x, N9x, NAx, NBx, NCx, NFx, PAx, PDx, PEx, PFx, PGx, PHx, PJx, PKx, PLx,  
PMx, PNx, PPx, PQx, PSx, PTx, PXx, Q2x, Q3x, Q4x, Q5x, Q6x, Q7x, Q8x, Q9x  
• 4236-CTO, MBx, N2x, N3x, N4x, N5x, N6x, N7x, N8x, N9x, NAx, NBx, NCx,  
NDx, NEx, NFx, NGx, NHx, NKx, NLx, NMx, NNx, NPx, NQx, NRx, NSx, NTx,  
NWx, NXx, NYx, P2x, P3x, P4x, P5x, P6x, P8x, P9x, PAx, PBx, PCx, PDx, PEx,  
PFx, PGx, PHx, PJx, PLx, PPx, PQx  
• 4237-CTO  
• 4238-CTO  
136 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
12  
04W1631  
N
I/O sub card (1394 and USB)  
• 4177-CTO, 2Fx, 2Gx, 2Hx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux,  
2Vx, 2Wx, 2Yx, 35x, Q8x, QBx, QEx, QHx, QMx, QNx, R4x, R8x, RAx, RDx,  
RKx, RLx, RMx, RQx, RRx, RSx, RTx, RUx, RWx, RXx  
• 4178-CTO, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx, 6Mx, 6Nx, 6Px, 6Ux, 6Vx, 6Wx, 9Fx,  
9Gx, 9Hx, 9Jx, 9Kx, 9Lx, 9Mx, 9Nx, 9Sx, 9Tx, 9Ux, 9Vx, 9Wx, 9Xx, 9Yx, 9Zx,  
A2x, A3x, A4x, A8x, A9x, ADx, AEx, AFx, ATx, AWx, AXx, AYx, AZx, B2x, B3x,  
B4x, BGx, BKx, BSx, BTx, C5x, C6x, C7x, C8x, C9x, CAx, CEx, CFx, CGx, CKx,  
CLx, CMx, CNx, CPx, CQx, CVx, CWx, CXx, CYx  
• 4179-CTO, GBx, GEx  
• 4180-CTO, 62x, 63x, 64x, 65x, MHx, MJx, MKx, MMx, MNx, NDx, NEx, PBx,  
PCx, PRx, PUx, PVx, PWx, PYx, PZx  
• 4236-CTO, 62x, 63x, 64x, 65x, NUx, NVx, P7x, PKx, PMx, PNx, PRx, PSx,  
PTx, PUx, PVx, PWx, PXx, PYx  
• 4237-CTO  
• 4238-CTO  
RJ11 cable with connector  
• 4177-CTO  
04W1632  
N
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
13  
42T4883  
42T4885  
*
Battery pack, Li-ion (4-cell) 55  
• 4177-CTO, 2Dx, GFx, GKx, QDx, QEx, QMx, RRx, RSx, RTx, RUx  
• 4178-CTO, 66x, 67x, 68x, 9Fx, 9Gx, 9Hx, 9Jx, 9Kx, 9Lx, 9Mx, 9Nx, A5x, A6x,  
A7x, AAx, AGx, BUx, BVx, BWx, BXx, CKx, CLx, CMx, CNx, CPx, CQx  
• 4179-CTO  
• 4180-CTO, PJx  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
13  
42T4791  
42T4793  
42T4795  
42T4911  
*
Battery pack, Li-ion (6-cell) 55+  
• 4177-CTO, 22x, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Ex, 2Fx,  
2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx,  
2Xx, 2Yx, 32x, 33x, 34x, 35x, 36x, GLx, GMx, Q2x, Q5x, Q8x, QAx, QCx, QGx,  
QHx, QJx, QKx, QLx, QNx, QPx, QQx, QRx, QSx, QTx, QUx, QVx, QWx, QXx,  
QYx, QZx, R2x, R3x, R4x, R5x, R6x, R7x, R8x, R9x, RAx, RBx, RCx, RDx, RFx,  
RGx, RHx, RJx, RKx, RLx, RMx, RNx, RPx, RQx, RVx, RWx, RXx, RYx, RZx  
• 4178-CTO, 52x, 53x, 54x, 55x, 56x, 57x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Fx,  
5Gx, 5Hx, 5Jx, 5Kx, 5Lx, 5Mx, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx, 5Wx,  
5Xx, 5Yx, 5Zx, 69x, 6Ax, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx, 6Hx, 6Jx, 6Kx, 6Lx,  
6Mx, 6Nx, 6Qx, 6Rx, 6Sx, 6Tx, 6Ux, 6Xx, 6Yx, 6Zx, 82x, 83x, 84x, 92x, 93x,  
94x, 95x, 96x, 97x, 98x, 99x, 9Ax, 9Bx, 9Cx, 9Dx, 9Ex, 9Px, 9Qx, 9Rx, 9Sx,  
9Tx, 9Ux, 9Vx, 9Wx, 9Xx, 9Yx, 9Zx, A2x, A3x, A8x, A9x, ABx, ACx, ADx, AEx,  
AFx, AHx, AJx, AKx, ALx, AMx, ANx, APx, AQx, ARx, ASx, ATx, AUx, AVx, AWx,  
AXx, AYx, AZx, B2x, B3x, B4x, B5x, B6x, B7x, B8x, B9x, BAx, BBx, BCx, BDx,  
BEx, BFx, BGx, BHx, BJx, BKx, BMx, BNx, BPx, BQx, BRx, BSx, BTx, BYx,  
BZx, C2x, C3x, C4x, C7x, C8x, C9x, CBx, CCx, CDx, CEx, CFx, CGx, CHx,  
CJx, CRx, CSx, CUx, CVx, CWx, CXx, CYx  
• 4179-CTO, G2x, G3x, G4x, G5x, G6x, G7x, G8x, G9x, GBx, GCx, GDx, GEx,  
GGx, GHx, GJx, GMx, GNx, GPx, GQx, GRx, GSx, GTx, GUx, GVx, GWx, GXx  
• 4180-CTO, 62x, 63x, 64x, J2x, J3x, J4x, K2x, K3x, K4x, K5x, K6x, K7x, K8x,  
K9x, KAx, KBx, KCx, KDx, KEx, KFx, KGx, KHx, KJx, KKx, KLx, KMx, KNx,  
KPx, KQx, KRx, KSx, KTx, KUx, KVx, KWx, KXx, KYx, L2x, L3x, L4x, L5x, L6x,  
Chapter 10. Parts list 137  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
L7x, L8x, L9x, LAx, LBx, LCx, LDx, LEx, LFx, LGx, LHx, LJx, LKx, LLx, LMx,  
LNx, LPx, LQx, LRx, LSx, LTx, LUx, LVx, LWx, LXx, LYx, LZx, M2x, M3x, M4x,  
M5x, M6x, M7x, M8x, M9x, MBx, MCx, MDx, MEx, MGx, MHx, MJx, MKx,  
MLx, MNx, MPx, MQx, MRx, MSx, MTx, MUx, MVx, MWx, MXx, MYx, MZx,  
N2x, N3x, N4x, N5x, N6x, N7x, N8x, NBx, NCx, NDx, NEx, NFx, PAx, PBx, PCx,  
PDx, PEx, PFx, PGx, PHx, PKx, PLx, PMx, PNx, PPx, PQx, PTx, PUx, PVx,  
PWx, PXx, PYx, PZx, Q2x, Q3x, Q6x, Q7x, Q8x, Q9x  
• 4236-CTO, 62x, 63x, 64x, MBx, N2x, N3x, N4x, N5x, N6x, N7x, N8x, N9x, NAx,  
NBx, NCx, NDx, NEx, NFx, NGx, NHx, NKx, NLx, NMx, NNx, NPx, NQx, NRx,  
NSx, NTx, NUx, NWx, NXx, NYx, P3x, P4x, P5x, P6x, P7x, P8x, P9x, PAx,  
PBx, PCx, PDx, PEx, PGx, PHx, PJx, PLx, PMx, PPx, PQx, PSx, PTx, PUx,  
PVx, PWx, PXx, PYx  
• 4237-CTO  
• 4238-CTO  
13  
13  
42T4817  
42T4819  
*
Battery pack, Li-ion (6-cell) 26+  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
42T4799  
42T4801  
42T4912  
*
Battery pack, Li-ion (9-cell) 55++  
• 4177-CTO, Q3x, Q4x, Q7x, QBx, QFx  
• 4178-CTO, 58x, 6Px, 6Vx, 6Wx, A4x, C5x, C6x, CAx  
• 4179-CTO  
• 4180-CTO, 65x, KZx, MAx, MFx, MMx, N9x, NAx, PRx, PSx, Q4x, Q5x  
• 4236-CTO, 65x, NVx, P2x, PFx, PKx, PNx, PRx  
• 4237-CTO  
• 4238-CTO  
14 Base cover assembly  
• 4177-CTO  
04W1626  
04W1627  
N
N
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
14  
Base cover assembly (Taiwan 90 W)  
• 4177-CTO, RRx, RSx, RTx, RUx  
• 4178-CTO, 5Fx, 5Hx, 9Hx, 9Jx, 9Kx, 9Lx, 9Mx, 9Nx, A5x, A6x, A7x, BUx, BVx,  
BXx, CKx, CLx, CMx, CNx, CPx, CQx  
• 4179-CTO  
• 4180-CTO, 64x, 65x, MMx  
• 4236-CTO, 64x, 65x, NVx, PRx  
• 4237-CTO  
• 4238-CTO  
14  
04W1628  
N
Base cover assembly (Taiwan 65 W)  
• 4177-CTO, QMx  
• 4178-CTO, 5Bx, 5Dx, 5Kx, 66x, 67x, 68x, 9Fx, 9Gx, BWx  
• 4179-CTO  
• 4180-CTO, 62x, 63x, MBx, MNx, PAx  
• 4236-CTO, 62x, 63x, MBx, NHx, NUx, PAx  
• 4237-CTO  
• 4238-CTO  
138 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
15  
42T4739  
*
Slice battery  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
16 DIMM slot door  
04W1636  
60Y3257  
**  
**  
17  
17  
17  
Integrated Mobile Broadband (Gobi 3000 3G with GPS)  
• 4177-CTO  
• 4178-CTO, APx  
• 4179-CTO  
• 4180-CTO, PFx  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
60Y3283  
60Y3279  
**  
**  
Integrated Mobile Broadband (Gobi 3000 3G with GPS for Malaysia)  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
Integrated Mobile Broadband (Ericsson F5521gw)  
• 4177-CTO, Q7x, QFx  
• 4178-CTO, 54x, 55x, 5Ax, 5Cx, 5Ex, 5Gx, 5Tx, 6Px, 6Yx, 82x, 94x, 99x, AMx,  
ANx, B6x, B8x, BHx, BJx, BMx, BNx, BRx, C2x, C6x, CHx, CSx  
• 4179-CTO  
• 4180-CTO, K9x, KAx, KBx, KCx, KFx, KJx, KMx, KNx, KSx, KUx, KVx, KYx,  
KZx, L2x, L4x, L8x, LBx, LHx, LJx, LKx, M5x, MDx, MFx, PBx, PTx  
• 4236-CTO, N2x, N4x, NAx, NBx, NFx, NGx, NMx, NNx, P2x, P3x, PFx, PGx,  
PQx  
• 4237-CTO  
• 4238-CTO  
17  
17  
60Y3267  
60Y3261  
**  
**  
Integrated Mobile Broadband (Ericsson F5521gw for Malaysia)  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
Integrated China Telecom Mobile Broadband TD-SCDMA (Leadcore LC5740)  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
Chapter 10. Parts list 139  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
17  
60Y3239  
**  
Integrated China Telecom Mobile Broadband (Huawei EM660)  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
45N8259  
**  
mSATA Solida State Drive  
• 4177-CTO, Q3x, QAx, QCx  
• 4178-CTO, 5Ux, 67x, 68x, 6Ax, 9Cx, A8x, A9x, AXx  
• 4179-CTO  
• 4180-CTO, M6x, PYx  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
18 HDD rubber rails  
41V9756  
04W1640  
04W1641  
**  
**  
**  
18  
18  
HDD rubber rails (7.0 mm-high HDD rubber rails for 9.5 mm-high bay)  
SSD spacers  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
19  
19  
45N7217  
45N7229  
45N7305  
45N7285  
42T1153  
42T1167  
**  
**  
SATA hard disk drive, 250 GB, 5,400 rpm  
• 4177-CTO, 26x, GKx, QAx, QCx  
• 4178-CTO, 6Tx, AJx  
• 4179-CTO  
• 4180-CTO, K3x, K4x, KQx, MFx, MVx, MWx, PDx  
• 4236-CTO, N5x, P4x  
• 4237-CTO  
• 4238-CTO  
45N7219  
45N7297  
45N7315  
45N7307  
45N7287  
42T1155  
SATA hard disk drive, 320 GB, 5,400 rpm  
• 4177-CTO, 22x, 25x, 28x, 2Dx, 2Ex, GLx, GMx, QDx, QNx, QQx, QRx, QSx,  
QUx, R7x, RNx  
• 4178-CTO, 5Ax, 5Bx, 5Cx, 5Dx, 9Vx, AAx, ABx, AGx, AQx, ARx, CDx  
• 4179-CTO, G2x, G4x, G5x, G6x, G7x, G8x, G9x  
• 4180-CTO, KWx, LEx, LNx, LUx, M7x, MAx, PJx, Q2x  
• 4236-CTO, N2x, N6x, NCx, NXx, NYx, PCx, PDx, PEx  
• 4237-CTO  
• 4238-CTO  
19  
45N7221  
45N7309  
**  
SATA hard disk drive, 500 GB, 5,400 rpm  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
140 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
19  
45N7251  
45N7271  
45N7317  
45N7323  
42T1157  
42T1169  
**  
SATA hard disk drive, 160 GB, 7200 rpm  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
19  
19  
42T1163  
42T1173  
**  
**  
SATA hard disk drive, 250 GB, 7200 rpm  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
45N7255  
45N7275  
45N7319  
45N7325  
42T1159  
42T1171  
SATA hard disk drive, 320 GB, 7200 rpm  
• 4177-CTO, 23x, 29x, 2Ax, 2Fx, 36x, GFx, Q2x, Q4x, Q5x, QGx, QJx, QKx,  
QLx, QTx, R2x, R3x, R5x, R6x, RVx  
• 4178-CTO, 52x, 53x, 54x, 56x, 58x, 59x, 5Ex, 5Fx, 5Gx, 5Hx, 5Kx, 6Hx, 6Jx,  
83x, 84x, 9Ex, 9Px, 9Qx, 9Rx, 9Ux, 9Wx, 9Xx, 9Yx, ACx, ADx, AKx, AMx, ANx,  
APx, AUx, AVx, B3x, B4x, B5x, B6x, BAx, BBx, BCx, CRx, CSx  
• 4179-CTO, GCx, GEx, GGx, GHx, GQx, GSx, GTx, GVx  
• 4180-CTO, 62x, 63x, 64x, K2x, K6x, K7x, K8x, K9x, KCx, KEx, KFx, KHx, KJx,  
KLx, KMx, KPx, KRx, KSx, KTx, KUx, KYx, L2x, L9x, LAx, LCx, LDx, LVx, LWx,  
M9x, MBx, MCx, MGx, MJx, MLx, MPx, MSx, MXx, MYx, MZx, NBx, NCx, NDx,  
NEx, PBx, PCx, PEx, PFx, PHx, PKx, PPx, Q6x  
• 4236-CTO, 62x, 63x, 64x, MBx, N3x, N4x, NHx, NKx, NLx, NNx, P3x  
• 4237-CTO  
• 4238-CTO  
19  
45N7257  
45N7277  
45N7321  
**  
SATA hard disk drive, 500 GB, 7200 rpm  
• 4177-CTO, 24x, 27x, 2Bx, 2Cx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px,  
2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 32x, 33x, 34x, 35x, Q3x, QBx,  
QHx, QMx, QPx, QVx, QWx, QXx, QYx, QZx, R4x, R8x, R9x, RAx, RBx, RCx,  
RDx, RFx, RGx, RHx, RJx, RKx, RLx, RMx, RPx, RQx, RRx, RSx, RTx, RUx,  
RWx, RYx, RZx  
• 4178-CTO, 55x, 57x, 5Jx, 5Lx, 5Mx, 5Nx, 5Px, 5Qx, 5Tx, 5Ux, 5Vx, 5Wx, 5Xx,  
5Yx, 5Zx, 66x, 67x, 68x, 69x, 6Ax, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Kx, 6Lx, 6Mx,  
6Nx, 6Qx, 6Rx, 6Sx, 6Ux, 6Vx, 6Wx, 6Xx, 6Yx, 6Zx, 82x, 92x, 93x, 94x, 95x,  
96x, 97x, 98x, 9Ax, 9Bx, 9Cx, 9Dx, 9Fx, 9Gx, 9Hx, 9Jx, 9Kx, 9Lx, 9Mx, 9Nx,  
9Sx, 9Tx, 9Zx, A2x, A3x, A4x, A5x, A6x, A7x, A8x, A9x, AFx, AHx, ALx, ASx,  
AXx, AYx, AZx, B2x, B8x, B9x, BDx, BEx, BFx, BGx, BHx, BJx, BKx, BPx, BQx,  
BRx, BSx, BTx, BUx, BVx, BWx, BXx, BYx, BZx, C2x, C3x, C4x, C5x, C7x, C8x,  
C9x, CAx, CBx, CCx, CEx, CFx, CGx, CHx, CJx, CKx, CLx, CMx, CNx, CPx,  
CQx, CVx, CWx, CXx, CYx  
• 4179-CTO, G3x, GBx, GDx, GJx, GMx, GNx, GPx, GRx, GUx, GWx, GXx  
• 4180-CTO, 65x, J2x, J3x, J4x, K5x, KDx, KGx, KKx, KNx, KVx, KXx, KZx, LBx,  
LFx, LGx, LHx, LJx, LKx, LLx, LMx, LPx, LQx, LRx, LSx, LTx, LXx, LYx, LZx,  
M2x, M3x, M4x, M5x, M6x, M8x, MHx, MKx, MMx, MNx, MRx, MTx, MUx, N2x,  
N3x, N4x, N5x, N6x, N7x, N8x, N9x, NAx, PGx, PLx, PMx, PNx, PQx, PRx, PSx,  
PTx, PUx, PVx, PXx, PYx, Q3x, Q4x, Q5x, Q7x, Q8x, Q9x  
• 4236-CTO, 65x, N7x, N8x, N9x, NAx, NBx, NDx, NEx, NFx, NGx, NPx, NQx,  
NRx, NUx, NVx, NWx, P2x, P5x, P6x, P7x, P8x, P9x, PFx, PGx, PHx, PJx, PKx,  
PLx, PMx, PNx, PPx, PQx, PRx, PSx, PTx, PUx, PVx, PWx, PXx, PYx  
• 4237-CTO  
• 4238-CTO  
Chapter 10. Parts list 141  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
19  
45N8081  
45N8007  
45N7981  
**  
Solid state drive, 128 GB  
• 4177-CTO, Q7x  
• 4178-CTO, 5Rx, ATx, B7x, CUx  
• 4179-CTO  
• 4180-CTO, KAx, L3x, L6x, L7x, PAx  
• 4236-CTO, NMx, PAx, PBx  
• 4237-CTO  
• 4238-CTO  
19  
19  
45N8057  
45N8085  
**  
Solid state drive, 160 GB  
• 4177-CTO, Q8x, QEx, QFx, RXx  
• 4178-CTO, 5Sx, 6Gx, 6Px, 99x, AEx, AWx, BMx, BNx, C6x  
• 4179-CTO  
• 4180-CTO, KBx, L4x, L5x, L8x, MDx, MEx, MQx, NFx, PWx, PZx  
• 4236-CTO, NSx, NTx  
• 4237-CTO  
• 4238-CTO  
Solid state flash drive, 4 GB  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
20 HDD cover  
04W1637  
04W2045  
**  
N
21  
System board assembly, integrated graphics, AMT, TPM  
• 4177-CTO, Q2x, Q5x, Q8x, QAx, QNx, RMx  
• 4178-CTO, 52x, 56x, 57x, 59x, 5Ax, 5Bx, 5Vx, 5Wx, 5Xx, 67x, 68x, 6Fx, 6Gx,  
6Qx, 6Ux, 6Zx, 9Bx, 9Cx, 9Px, 9Qx, ABx, ALx, ANx, APx, ASx, ATx, AWx,  
AYx, C8x  
• 4179-CTO, GBx, GQx, GRx  
• 4180-CTO, 62x, 63x, K2x, K3x, K4x, K5x, K6x, K7x, K8x, K9x, KAx, KBx, KCx,  
KDx, KEx, KFx, KGx, KHx, KJx, KKx, LDx, LUx, LWx, M2x, M7x, M8x, M9x,  
MBx, MDx, MEx, MJx, MLx, MNx, MPx, MQx, MSx, MYx, N2x, NBx, NDx, NFx,  
PAx, PBx, PCx, PFx, PGx, PHx, PVx, PXx, Q2x, Q3x  
• 4236-CTO, 62x, 63x, MBx, N2x, N3x, N5x, NGx, NHx, NMx, NNx, NTx, NUx,  
P3x, P5x, P9x, PAx, PGx, PLx, PMx, PXx  
• 4237-CTO  
• 4238-CTO  
21  
04W2046  
N
System board assembly, integrated graphics, AMT, non-TPM  
• 4177-CTO, 2Hx  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO, MCx  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
142 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
21  
04W2047  
N
System board assembly, integrated graphics, non-AMT, TPM  
• 4177-CTO, 25x, 26x, 27x, 28x, 29x, 2Dx, 2Ex, 2Qx, 2Rx, 2Sx, 35x, 36x, GKx,  
GMx, Q7x, QCx, QDx, QGx, QJx, QKx, QLx, QMx, QQx, QSx, QTx, QUx, QVx,  
R2x, R3x, R5x, R6x, R7x, R8x, R9x, RBx, RFx, RGx, RNx, RPx, RRx, RSx,  
RVx, RYx  
• 4178-CTO, 53x, 5Cx, 5Dx, 5Jx, 5Kx, 5Lx, 5Mx, 5Nx, 5Px, 5Rx, 5Tx, 5Ux, 66x,  
69x, 6Bx, 6Cx, 6Dx, 6Ex, 6Hx, 6Jx, 6Kx, 6Lx, 6Mx, 6Nx, 83x, 84x, 92x, 93x,  
95x, 96x, 97x, 98x, 9Fx, 9Gx, 9Rx, 9Zx, A7x, A8x, AAx, ACx, AFx, AGx, AHx,  
AMx, ARx, AUx, AVx, AZx, B2x, B3x, B4x, B5x, B6x, B7x, B9x, BAx, BBx, BCx,  
BDx, BEx, BGx, BJx, BKx, BMx, BNx, BPx, BSx, BWx, BYx, C2x, C3x, C9x,  
CBx, CCx, CDx, CEx, CFx, CJx, CKx, CLx, CRx, CSx, CUx, CWx, CXx  
• 4179-CTO, G2x, G3x, G4x, G5x, G6x, G7x, G8x, GEx, GGx, GSx  
• 4180-CTO, LEx, LFx, LGx, LHx, LJx, LKx, LNx, LPx, LRx, LSx, LTx, MUx, MVx,  
MWx, NCx, PDx, PEx, PJx  
• 4236-CTO, N6x, N7x, N8x, NCx, NKx, NLx, NXx, NYx, P4x, P6x, P7x, P8x, PBx,  
PCx, PDx, PEx, PHx, PJx, PPx, PQx, PSx, PTx, PUx, PVx  
• 4237-CTO  
• 4238-CTO  
21  
21  
04W2048  
04W2049  
N
N
System board assembly, integrated graphics, non-AMT, non-TPM  
• 4177-CTO, 2Fx, 2Gx  
• 4178-CTO, 6Tx, 9Vx, 9Wx, 9Yx, ADx, AJx, AKx  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
System board assembly, discrete graphics, AMT, TPM  
• 4177-CTO, 2Jx, 2Nx, 2Px, Q3x, Q4x, QBx, QFx, RKx, RLx  
• 4178-CTO, 54x, 55x, 58x, 5Ex, 5Fx, 5Yx, 5Zx, 6Ax, 6Px, 6Rx, 6Vx, 6Wx, 6Xx,  
6Yx, 99x, 9Ax, A3x, A4x, A9x, C5x, C6x, C7x, CAx  
• 4179-CTO  
• 4180-CTO, 64x, 65x, J2x, J3x, KLx, KMx, KNx, KPx, KQx, KRx, KSx, KTx,  
KUx, KVx, KWx, KXx, KYx, KZx, L2x, L3x, L4x, L5x, L6x, L7x, L8x, L9x, LAx,  
LBx, LCx, LLx, LMx, LQx, LVx, LXx, LYx, LZx, M4x, M5x, M6x, MFx, MGx,  
MHx, MKx, MMx, MRx, N6x, N7x, N8x, N9x, NAx, NEx, PRx, PSx, PTx, PUx,  
PWx, PYx, PZx, Q4x, Q5x  
• 4236-CTO, 64x, 65x, N4x, NAx, NBx, NDx, NEx, NFx, NPx, NQx, NRx, NSx,  
NVx, NWx, P2x, PFx, PKx, PNx, PRx, PYx  
• 4237-CTO  
• 4238-CTO  
21  
04W2050  
N
System board assembly, discrete graphics, AMT, non-TPM  
• 4177–CTO  
• 4178–CTO, AXx  
• 4179–CTO  
• 4180–CTO, MZx  
• 4236–CTO  
• 4237–CTO  
• 4238–CTO  
Chapter 10. Parts list 143  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
21  
04W2051  
N
System board assembly, discrete graphics, non-AMT, TPM  
• 4177-CTO, 22x, 23x, 24x, 2Ax, 2Bx, 2Cx, 2Kx, 2Lx, 2Mx, 2Tx, 2Ux, 2Vx, 2Wx,  
2Xx, 2Yx, 32x, 33x, 34x, GFx, GLx, QEx, QHx, QPx, QRx, QWx, QXx, QYx, QZx,  
R4x, RAx, RCx, RDx, RHx, RJx, RQx, RTx, RUx, RWx, RXx, RZx  
• 4178-CTO, 5Gx, 5Hx, 5Qx, 5Sx, 6Sx, 82x, 94x, 9Dx, 9Ex, 9Hx, 9Jx, 9Kx, 9Lx,  
9Mx, 9Nx, A2x, A5x, A6x, AQx, B8x, BFx, BHx, BQx, BRx, BTx, BUx, BVx, BXx,  
BZx, C4x, CGx, CHx, CMx, CNx, CPx, CQx, CVx, CYx  
• 4179-CTO, G9x, GCx, GDx, GHx, GJx, GMx, GNx, GPx, GTx, GUx, GVx, GWx,  
GXx  
• 4180-CTO, J4x, M3x, MAx, MTx, MXx, N3x, N4x, N5x, PKx, PLx, PMx, PNx,  
PPx, PQx, Q6x, Q7x, Q8x, Q9x  
• 4236-CTO, N9x, PWx  
• 4237-CTO  
• 4238-CTO  
21  
22  
04W2052  
04W0492  
N
N
System board assembly, discrete graphics, non-AMT, non-TPM  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO, 9Sx, 9Tx, 9Ux, 9Xx, AEx  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
CPU assembly, i5-2520M (2.50 GHz)  
• 4177-CTO, 2Fx, 2Nx, Q5x, Q8x, QNx  
• 4178-CTO, 52x, 56x, 58x, 5Ax, 5Bx, 5Ex, 5Fx, 5Vx, 5Zx, 68x, 6Fx, 6Qx, 6Ux,  
6Vx, 6Xx, 6Yx, 6Zx, 9Ax, 9Bx, 9Cx, 9Kx, 9Px, 9Qx, 9Tx, 9Wx, A3x, A9x, AAx,  
ABx, ACx, ALx, ANx, APx, ASx, C6x  
• 4179-CTO, G2x, G3x, G4x, GBx, GEx, GQx  
• 4180-CTO, 62x, 64x, J2x, J3x, K2x, K3x, K4x, K6x, K7x, K8x, KPx, KQx, KRx,  
KSx, L6x, L7x, L8x, LEx, LFx, LGx, LHx, LNx, LUx, LVx, LWx, LXx, LYx, M2x,  
M7x, M8x, M9x, MCx, MDx, MEx, MGx, MHx, MJx, MLx, MNx, MPx, MSx, MYx,  
MZx, N6x, N7x, N8x, NBx, PAx, PBx, PCx, PDx, PEx, PFx, PHx, PJx, PVx, PWx  
• 4236-CTO, 62x, 64x, N3x, N6x, N7x, N8x, N9x, NCx, NMx, NNx, NUx, P3x,  
P4x, PAx, PBx  
• 4237-CTO  
• 4238-CTO  
22  
04W0493  
N
CPU assembly, i5-2540M (2.60 GHz)  
• 4177-CTO, 2Gx, 2Px, Q2x, Q3x, Q4x, QLx, RLx, RMx  
• 4178-CTO, 54x, 55x, 57x, 59x, 5Wx, 6Px, 6Rx, 9Lx, ATx, BEx, BNx, C7x, C8x  
• 4179-CTO  
• 4180-CTO, 63x, 65x, K5x, K9x, KAx, KEx, KFx, KHx, KJx, KKx, KLx, KMx,  
KNx, KTx, KUx, KVx, KWx, L5x, L9x, LAx, LBx, LCx, LDx, LJx, LKx, LLx, LMx,  
LZx, M4x, MBx, MKx, MQx, NDx, NEx  
• 4236-CTO, 63x, 65x, MBx, N2x, N5x, NAx, NBx, NHx, NSx, NTx, P5x, PCx, PDx  
• 4237-CTO  
• 4238-CTO  
144 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
22  
04W0494  
N
CPU assembly, i7-2620M (2.70 GHz)  
• 4177-CTO, 2Hx, 2Jx, Q7x, QAx, QBx, QFx  
• 4178-CTO, 5Xx, 5Yx, 67x, 6Ax, 6Gx, 6Wx, 99x, 9Mx, 9Sx, A4x, AEx, AFx, AWx,  
AXx, AYx  
• 4179-CTO, GRx  
• 4180-CTO, J2x, K8x, KCx, KFx, KMx, KRx, L2x, LAx, LBx, PEx, PJx, PQx,  
PXx, Q5x, Q6x  
• 4236-CTO, N4x, NDx, NEx, NFx, NGx, NPx, NQx, NRx, NVx, NWx, P2x, P9x,  
PEx, PKx  
• 4237-CTO  
• 4238-CTO  
22  
04W0495  
N
CPU assembly, i3-2310M (2.10 GHz)  
• 4177-CTO, 22x, 23x, 24x, 26x, 28x, 29x, 2Ax, 2Bx, 2Dx, 2Ex, 2Qx, 2Rx, 2Sx,  
2Tx, 2Ux, 2Xx, 2Yx, QCx, QDx, QGx, QMx, QTx, QUx  
• 4178-CTO, 5Cx, 5Dx, 5Gx, 5Hx, 5Jx, 5Kx, 5Lx, 5Mx, 6Bx, 6Cx, 6Hx, 6Jx, 6Mx,  
6Nx, 6Tx, 84x, 98x, 9Fx, 9Gx, 9Hx, 9Nx, 9Ux, 9Vx, A5x, A6x, A7x, ADx, AGx,  
AJx, AKx, AUx, AVx  
• 4179-CTO, G5x, G6x, G8x, G9x, GCx, GDx  
• 4180-CTO, LRx, LSx, MAx, MTx, MUx, MVx, MWx, MXx  
• 4236-CTO, NLx, NXx, NYx  
• 4237-CTO  
• 4238-CTO  
22  
22  
04W1891  
04W0496  
N
N
CPU assembly, Intel Dual Core i3-2330M (2.20 GHz)  
• 4177-CTO, QVx, QWx, QXx, R9x, RBx, RCx, RDx  
• 4178-CTO, AZx, B2x, B3x, B4x, BGx, BKx, BPx, BQx, BRx, BWx, BXx, CDx  
• 4179-CTO, GGx, GHx, GJx, GMx  
• 4180-CTO  
• 4236-CTO, PSx, PTx  
• 4237-CTO  
• 4238-CTO  
CPU assembly, i5-2410M (2.30 GHz)  
• 4177-CTO, 25x, 27x, 2Cx, 2Kx, 2Lx, 2Mx, 2Vx, 2Wx, QEx, QHx, QJx, QKx, QPx  
• 4178-CTO, 53x, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 66x, 69x, 6Dx, 6Ex, 6Kx,  
6Lx, 6Sx, 82x, 83x, 92x, 93x, 94x, 95x, 96x, 97x, 9Dx, 9Ex, 9Jx, 9Rx, 9Xx,  
9Yx, 9Zx, A2x, A8x, AHx, AMx  
• 4179-CTO, G7x  
• 4180-CTO, J4x, LTx, M3x, N3x, N4x, N5x, NCx  
• 4236-CTO, NKx, P6x, P7x, P8x  
• 4237-CTO  
• 4238-CTO  
22  
04W1893  
N
CPU assembly, Intel Dual Core i5-2430M (2.40 GHz)  
• 4177-CTO, QYx, QZx, R3x, R4x, R8x, RAx, RFx, RPx, RXx  
• 4178-CTO, B5x, B6x, B7x, B8x, B9x, BDx, BFx, BHx, BJx, BMx, BSx, BTx,  
BUx, BVx, BYx, BZx, C2x, C3x, C4x, CBx, CCx  
• 4179-CTO  
• 4180-CTO, PKx, PLx, PMx, PNx, PPx, PQx  
• 4236-CTO, PHx, PJx, PPx, PQx, PUx, PVx, PWx  
• 4237-CTO  
• 4238-CTO  
Chapter 10. Parts list 145  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
22  
04W1895  
N
CPU assembly, Intel Pentium B950 (2.10 GHz)  
• 4177-CTO, GFx, GKx, GLx, GMx  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
22  
04W1894  
N
CPU assembly, Intel Pentium B940 (2.0 GHz)  
• 4177-CTO, QQx, QRx, QSx  
• 4178-CTO, AQx, ARx  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
23 Backup battery  
02K7078  
04W1642  
**  
N
24  
04W1639  
SmartCard Reader FPC cable  
• 4177-CTO, 2Fx, 2Gx, 2Hx, Q7x, Q8x, QAx, QBx, QPx, R9x, RBx, RCx, RLx,  
RMx, RRx, RSx, RTx, RUx  
• 4178-CTO, 5Lx, 5Mx, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx, 5Wx, 5Xx,  
5Yx, 5Zx, 66x, 67x, 68x, 6Ax, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx, 6Qx, 6Rx, 6Xx,  
6Yx, 6Zx, 92x, 93x, 94x, 95x, 96x, 97x, 98x, 99x, 9Ax, 9Bx, 9Cx, AEx, AXx,  
AYx, AZx, B2x, B3x, B4x, BDx, BEx, BFx, BHx, BJx, BMx, BNx, BPx, BQx,  
BRx, BUx, BZx, C3x, C4x, C5x, C6x, CBx, CFx, CHx, CKx, CLx, CMx, CNx,  
CPx, CQx, CXx, CYx  
• 4179-CTO, GXx  
• 4180-CTO, KEx, KFx, L9x, LAx, LBx, LPx, LQx, LVx, LXx, M8x, MCx, MDx, MEx,  
MRx, MSx, MZx, N2x, NFx, PBx, PCx, PUx, PVx, PWx, PXx, PYx, PZx, Q3x  
• 4236-CTO, N3x, NDx, NEx, PDx, PJx, PKx, PMx, PPx, PQx  
• 4237-CTO  
• 4238-CTO  
25  
04W1638  
04W2084  
N
SmartCard Reader  
• 4177-CTO, 2Fx, 2Gx, 2Hx, Q7x, Q8x, QAx, QBx, QPx, R9x, RBx, RCx, RLx,  
RMx, RRx, RSx, RTx, RUx  
• 4178-CTO, 5Lx, 5Mx, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx, 5Wx, 5Xx, 5Yx,  
5Zx, 66x, 67x, 68x, 6Ax, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx, 6Qx, 6Rx, 6Xx, 6Yx,  
6Zx, 92x, 93x, 94x, 95x, 96x, 97x, 98x, 99x, 9Ax, 9Bx, 9Cx, A5x, A6x, A7x, AEx,  
AXx, AYx, AZx, B2x, B3x, B4x, BDx, BEx, BFx, BHx, BJx, BMx, BNx, BPx, BQx,  
BRx, BUx, BVx, BWx, BXx, BZx, C3x, C4x, C5x, C6x, CBx, CFx, CHx, CKx,  
CLx, CMx, CNx, CPx, CQx, CXx, CYx  
• 4179-CTO, GXx  
• 4180-CTO, KEx, KFx, L9x, LAx, LBx, LPx, LQx, LVx, LXx, M8x, MCx, MDx,  
MEx, MRx, MSx, MZx, N2x, NDx, NEx, NFx, PBx, PCx, PUx, PVx, PWx, PXx,  
PYx, PZx, Q3x  
• 4236-CTO, N3x, NDx, NEx, PDx, PJx, PKx, PMx, PPx, PQx  
• 4237-CTO  
• 4238-CTO  
146 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
26 Fan assembly, integrated  
04W0407  
04W0409  
N
• 4177-CTO, 25x, 26x, 27x, 28x, 29x, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Qx, 2Rx, 2Sx,  
35x, 36x, GKx, GMx, Q2x, Q5x, Q7x, Q8x, QAx, QCx, QDx, QGx, QJx, QKx,  
QLx, QMx, QNx, QQx, QSx, QTx, QUx, QVx, R2x, R3x, R5x, R6x, R7x, R8x,  
R9x, RBx, RFx, RGx, RMx, RNx, RPx, RRx, RSx, RVx, RYx  
• 4178-CTO, 52x, 53x, 56x, 57x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Jx, 5Kx, 5Lx, 5Mx,  
5Nx, 5Px, 5Rx, 5Tx, 5Ux, 5Vx, 5Wx, 5Xx, 66x, 67x, 68x, 69x, 6Bx, 6Cx, 6Dx,  
6Ex, 6Fx, 6Gx, 6Hx, 6Jx, 6Kx, 6Lx, 6Mx, 6Nx, 6Qx, 6Tx, 6Ux, 6Zx, 83x, 84x,  
92x, 93x, 95x, 96x, 97x, 98x, 9Bx, 9Cx, 9Fx, 9Gx, 9Px, 9Qx, 9Rx, 9Vx, 9Wx,  
9Yx, 9Zx, A7x, A8x, AAx, ABx, ACx, ADx, AFx, AGx, AHx, AJx, AKx, ALx, AMx,  
ANx, APx, ARx, ASx, ATx, AUx, AVx, AWx, AYx, AZx, B2x, B3x, B4x, B5x, B6x,  
B7x, B9x, BAx, BBx, BCx, BDx, BEx, BGx, BJx, BKx, BMx, BNx, BPx, BSx,  
BWx, BYx, C2x, C3x, C8x, C9x, CBx, CCx, CDx, CEx, CFx, CJx, CKx, CLx,  
CRx, CSx, CUx, CWx, CXx  
• 4179-CTO, G2x, G3x, G4x, G5x, G6x, G7x, G8x, GBx, GEx, GGx, GQx, GRx,  
GSx  
• 4180-CTO, 62x, 63x, K2x, K3x, K4x, K5x, K6x, K7x, K8x, K9x, KAx, KBx, KCx,  
KDx, KEx, KFx, KGx, KHx, KJx, KKx, LDx, LEx, LFx, LGx, LHx, LJx, LKx, LNx,  
LPx, LRx, LSx, LTx, LUx, LWx, M2x, M7x, M8x, M9x, MBx, MCx, MDx, MEx,  
MJx, MLx, MNx, MPx, MQx, MSx, MUx, MVx, MWx, MYx, N2x, NBx, NCx,  
NDx, NFx, PAx, PBx, PCx, PDx, PEx, PFx, PGx, PHx, PJx, PVx, PXx, Q2x, Q3x  
• 4236-CTO, 62x, 63x, MBx, N2x, N3x, N5x, N6x, N7x, N8x, NCx, NGx, NHx,  
NKx, NLx, NMx, NNx, NTx, NUx, NXx, NYx, P3x, P4x, P5x, P6x, P7x, P8x,  
P9x, PAx, PBx, PCx, PDx, PEx, PGx, PHx, PJx, PLx, PMx, PPx, PQx, PSx,  
PTx, PUx, PVx, PXx  
• 4237-CTO  
• 4238-CTO  
26 Fan assembly, discrete  
04W0408  
04W0410  
N
• 4177-CTO, 22x, 23x, 24x, 2Ax, 2Bx, 2Cx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Tx,  
2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 32x, 33x, 34x, GFx, GLx, Q3x, Q4x, QBx, QEx, QFx,  
QHx, QPx, QRx, QWx, QXx, QYx, QZx, R4x, RAx, RCx, RDx, RHx, RJx, RKx,  
RLx, RQx, RTx, RUx, RWx, RXx, RZx  
• 4178-CTO, 54x, 55x, 58x, 5Ex, 5Fx, 5Gx, 5Hx, 5Qx, 5Sx, 5Yx, 5Zx, 6Ax, 6Px,  
6Rx, 6Sx, 6Vx, 6Wx, 6Xx, 6Yx, 82x, 94x, 99x, 9Ax, 9Dx, 9Ex, 9Hx, 9Jx, 9Kx,  
9Lx, 9Mx, 9Nx, 9Sx, 9Tx, 9Ux, 9Xx, A2x, A3x, A4x, A5x, A6x, A9x, AEx, AQx,  
AXx, B8x, BFx, BHx, BQx, BRx, BTx, BUx, BVx, BXx, BZx, C4x, C5x, C6x, C7x,  
CAx, CGx, CHx, CMx, CNx, CPx, CQx, CVx, CYx  
• 4179-CTO, G9x, GCx, GDx, GHx, GJx, GMx, GNx, GPx, GTx, GUx, GVx, GWx,  
GXx  
• 4180-CTO, 64x, 65x, J2x, J3x, J4x, KLx, KMx, KNx, KPx, KQx, KRx, KSx, KTx,  
KUx, KVx, KWx, KXx, KYx, KZx, L2x, L3x, L4x, L5x, L6x, L7x, L8x, L9x, LAx,  
LBx, LCx, LLx, LMx, LQx, LVx, LXx, LYx, LZx, M3x, M4x, M5x, M6x, MAx, MFx,  
MGx, MHx, MKx, MMx, MRx, MTx, MXx, MZx, N3x, N4x, N5x, N6x, N7x, N8x,  
N9x, NAx, NEx, PKx, PLx, PMx, PNx, PPx, PQx, PRx, PSx, PTx, PUx, PWx,  
PYx, PZx, Q4x, Q5x, Q6x, Q7x, Q8x, Q9x  
• 4236-CTO, 64x, 65x, N4x, N9x, NAx, NBx, NDx, NEx, NFx, NPx, NQx, NRx,  
NSx, NVx, NWx, P2x, PFx, PKx, PNx, PRx, PWx, PYx  
• 4237-CTO  
• 4238-CTO  
Chapter 10. Parts list 147  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
27  
04W1625  
N
FPC cable (touch pad with fingerprint reader and Bluetooth)  
• 4177-CTO, 22x, 23x, 24x, 27x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx,  
2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx,  
32x, 33x, 34x, 35x, 36x, GFx, GKx, GLx, GMx, Q2x, Q3x, Q4x, Q7x, Q8x, QAx,  
QBx, QEx, QHx, QNx, QPx, QQx, QRx, QTx, QUx, QVx, QWx, QXx, QYx, QZx,  
R4x, R5x, R6x, R7x, R8x, R9x, RAx, RBx, RCx, RDx, RFx, RGx, RHx, RJx, RKx,  
RLx, RMx, RNx, RPx, RQx, RRx, RSx, RTx, RUx, RWx, RXx, RYx, RZx  
• 4178-CTO, 52x, 53x, 54x, 55x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Fx, 5Gx, 5Hx, 5Jx,  
5Kx, 5Lx, 5Mx, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx, 5Wx, 5Xx, 5Yx, 5Zx,  
66x, 67x, 68x, 69x, 6Ax, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx, 6Hx, 6Jx, 6Kx, 6Lx,  
6Mx, 6Nx, 6Px, 6Qx, 6Rx, 6Sx, 6Tx, 6Ux, 6Vx, 6Wx, 6Xx, 6Yx, 6Zx, 82x, 83x,  
84x, 92x, 93x, 94x, 95x, 96x, 97x, 98x, 99x, 9Ax, 9Bx, 9Cx, 9Dx, 9Ex, 9Jx, 9Kx,  
9Lx, 9Mx, 9Px, 9Qx, 9Sx, 9Tx, 9Ux, 9Vx, 9Wx, 9Xx, 9Yx, 9Zx, A2x, A3x, A4x,  
A8x, A9x, ABx, ADx, AEx, AFx, AGx, AHx, AJx, AKx, ALx, AMx, ANx, APx, ASx,  
ATx, AUx, AVx, AWx, AXx, AYx, AZx, B2x, B3x, B4x, B5x, B6x, B7x, B8x, B9x,  
BAx, BBx, BCx, BDx, BEx, BFx, BGx, BHx, BJx, BKx, BMx, BNx, BPx, BQx,  
BRx, BSx, BTx, BUx, BYx, BZx, C2x, C3x, C4x, C5x, C6x, C7x, C8x, C9x, CAx,  
CBx, CCx, CDx, CEx, CFx, CGx, CHx, CJx, CKx, CLx, CMx, CNx, CPx, CQx,  
CRx, CSx, CUx, CVx, CWx, CXx, CYx  
• 4179-CTO, G3x, G4x, G5x, G6x, G7x, G8x, G9x, GBx, GCx, GDx, GGx, GHx,  
GJx, GMx, GNx, GPx, GQx, GRx, GSx, GTx, GUx, GVx, GWx, GXx  
• 4180-CTO, 63x, 65x, J2x, J3x, J4x, K2x, K3x, K4x, K5x, K6x, K7x, K8x, K9x,  
KAx, KBx, KCx, KDx, KEx, KFx, KGx, KHx, KJx, KKx, KLx, KMx, KNx, KPx,  
KQx, KRx, KSx, KTx, KUx, KVx, KWx, KXx, KYx, KZx, L2x, L3x, L4x, L5x, L6x,  
L7x, L8x, L9x, LAx, LBx, LNx, LPx, LQx, LRx, LSx, LTx, LUx, LVx, LWx, LXx,  
LYx, LZx, M2x, M3x, M4x, M5x, M6x, M7x, M8x, MAx, MBx, MCx, MDx, MEx,  
MFx, MGx, MHx, MJx, MKx, MMx, MNx, MPx, MQx, MRx, MSx, MTx, MUx,  
MVx, MWx, MXx, MYx, MZx, N2x, N3x, N4x, N5x, N6x, N7x, N8x, N9x, NAx,  
NBx, NFx, PAx, PBx, PCx, PFx, PGx, PHx, PKx, PLx, PMx, PNx, PPx, PQx, PRx,  
PSx, PTx, PUx, PVx, PWx, PXx, PYx, PZx, Q3x, Q4x, Q5x, Q6x, Q7x, Q8x, Q9x  
• 4236-CTO, 63x, MBx, N2x, N3x, N4x, N5x, N8x, N9x, NAx, NBx, NCx, NDx,  
NEx, NFx, NGx, NHx, NKx, NLx, NMx, NNx, NPx, NQx, NRx, NSx, NTx, NUx,  
NVx, NWx, NXx, NYx, P2x, P3x, P4x, P5x, P6x, P7x, P8x, P9x, PAx, PBx, PCx,  
PDx, PEx, PFx, PGx, PHx, PJx, PKx, PLx, PMx, PNx, PPx, PQx, PRx, PSx,  
PTx, PUx, PVx, PWx, PXx, PYx  
• 4237-CTO  
• 4238-CTO  
28  
60Y3271  
60Y3275  
N
Bluetooth daughter card (BDC-3.0)  
• 4177-CTO, 22x, 23x, 24x, 25x, 29x, 2Ax, 2Bx, 2Cx, 2Ex, 2Jx, 2Xx, 36x, GFx,  
GKx, GLx, GMx, Q4x, Q7x, QAx, QCx, QPx, QQx, QRx, QSx, R9x, RBx, RCx,  
RFx  
• 4178-CTO, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Fx, 5Gx, 5Hx, 5Jx, 5Kx, 5Lx, 5Mx, 5Nx,  
5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx, 5Wx, 5Xx, 5Yx, 5Zx, 66x, 67x, 68x, 69x,  
6Ax, 6Hx, 6Jx, 6Kx, 6Lx, 6Qx, 6Rx, 6Sx, 6Tx, 6Xx, 6Yx, 6Zx, 82x, 83x, 84x, 92x,  
93x, 94x, 95x, 96x, 97x, 98x, 99x, 9Ax, 9Bx, 9Cx, 9Dx, 9Ex, A5x, A6x, A7x, AJx,  
AKx, AQx, ARx, BDx, BEx, BFx, BHx, BJx, BMx, BNx, BPx, BQx, BRx, BUx,  
BVx, BWx, BXx, BYx, BZx, C2x, C3x, C4x, CBx  
• 4179-CTO, G2x, G3x, G4x, G5x, G6x, G7x, G8x, G9x, GCx, GDx, GGx, GHx,  
GJx, GMx, GNx, GPx, GQx, GRx, GSx, GTx, GUx, GVx, GWx, GXx  
• 4180-CTO, J2x, J3x, J4x, K2x, K3x, K4x, K5x, K6x, K7x, K8x, K9x, KAx, KBx,  
KCx, KDx, KEx, KFx, KGx, KHx, KJx, KKx, KLx, KMx, KNx, KPx, KQx, KRx,  
KSx, KTx, KUx, KVx, KWx, KXx, KYx, KZx, L2x, L3x, L4x, L5x, L6x, L7x, L8x,  
L9x, LAx, LBx, LCx, LDx, LEx, LFx, LGx, LHx, LJx, LKx, LLx, LMx, LNx, LPx,  
LQx, LRx, LSx, LTx, LYx, LZx, M2x, M3x, M4x, M5x, M6x, M9x, MAx, MBx,  
MCx, MDx, MEx, MFx, MGx, MQx, MRx, MSx, MTx, MUx, MVx, MWx, MXx,  
MZx, N2x, N3x, N4x, N5x, N6x, N7x, N8x, N9x, NAx, NCx, NFx, PDx, PKx, PLx,  
PMx, PNx, PPx, PQx, PSx, PXx, Q3x, Q6x, Q7x, Q8x, Q9x  
148 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 9. Parts list—Overall (continued)  
No.  
FRU no.  
FRU (Overall)  
CRU ID  
• 4236-CTO, MBx, N2x, N3x, N4x, N5x, N6x, N7x, N8x, N9x, NAx, NBx, NCx,  
NDx, NEx, NFx, NGx, NHx, NKx, NLx, NMx, NNx, NPx, NQx, NRx, NSx, NTx,  
NWx, NXx, NYx, P2x, P3x, P4x, P5x, P6x, P8x, P9x, PBx, PCx, PDx, PEx,  
PHx, PJx  
• 4237-CTO  
• 4238-CTO  
29  
Keyboard (see “Keyboard” on page 154.)  
30 TrackPoint caps  
91P9642  
91P8835  
*
Thermal grease  
N
ac power adapter (see “Information about ac power adapters” on page 158.)  
Chapter 10. Parts list 149  
Download from Www.Somanuals.com. All Manuals Search And Download.  
LCD FRUs  
10  
1
2
3
9
8
4
5
7
6
Table 10. Parts list—LCD FRUs  
No. FRU  
FRU no.  
CRU  
ID  
a,  
b
See “Miscellaneous parts” on page 156.  
LCD bezel assembly  
1
04W1609  
N
150 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Table 10. Parts list—LCD FRUs (continued)  
No. FRU  
FRU no.  
CRU  
ID  
2
60Y9994  
N
Camera module  
• 4177-CTO, 22x, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx,  
2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 32x,  
33x, 34x, 35x, 36x, GFx, GKx, GLx, GMx, Q2x, Q3x, Q4x, Q5x, Q8x, QAx, QBx, QDx,  
QEx, QGx, QHx, QJx, QKx, QLx, QMx, QNx, QPx, QQx, QRx, QSx, QUx, QVx, QWx,  
QXx, QYx, QZx, R2x, R3x, R4x, R7x, R8x, R9x, RAx, RBx, RCx, RDx, RFx, RGx, RHx,  
RJx, RKx, RLx, RMx, RNx, RPx, RQx, RRx, RSx, RTx, RUx, RVx, RWx, RXx, RYx, RZx  
• 4178-CTO, 52x, 53x, 54x, 55x, 56x, 57x, 58x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Fx, 5Gx,  
5Hx, 5Jx, 5Kx, 5Lx, 5Mx, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx, 5Wx, 5Xx, 5Yx,  
5Zx, 66x, 67x, 68x, 69x, 6Ax, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx, 6Hx, 6Jx, 6Kx, 6Lx, 6Mx,  
6Nx, 6Px, 6Qx, 6Rx, 6Sx, 6Tx, 6Ux, 6Vx, 6Wx, 6Xx, 6Yx, 6Zx, 82x, 83x, 84x, 92x, 93x,  
94x, 95x, 96x, 97x, 98x, 99x, 9Ax, 9Bx, 9Cx, 9Dx, 9Ex, 9Fx, 9Gx, 9Hx, 9Jx, 9Kx, 9Lx,  
9Mx, 9Nx, 9Px, 9Qx, 9Rx, 9Sx, 9Tx, 9Ux, 9Vx, 9Wx, 9Xx, 9Yx, 9Zx, A2x, A3x, A4x,  
A5x, A6x, A7x, A8x, A9x, AAx, ABx, ADx, AEx, AFx, AGx, AHx, AJx, AKx, ALx, AMx,  
ANx, APx, AQx, ARx, ASx, ATx, AUx, AVx, AWx, AXx, AYx, AZx, B2x, B3x, B4x, B5x,  
B6x, B7x, B8x, B9x, BAx, BBx, BCx, BDx, BEx, BFx, BGx, BHx, BJx, BKx, BMx, BNx,  
BPx, BQx, BRx, BSx, BTx, BUx, BVx, BWx, BXx, BYx, BZx, C2x, C3x, C4x, C5x, C6x,  
C7x, C8x, C9x, CAx, CBx, CCx, CDx, CEx, CFx, CGx, CHx, CJx, CKx, CLx, CMx,  
CNx, CPx, CQx, CRx, CSx, CUx, CVx, CWx, CXx, CYx  
• 4179-CTO, G3x, G4x, G5x, G6x, G7x, G8x, G9x, GBx, GCx, GDx, GGx, GHx, GJx,  
GMx, GNx, GPx, GQx, GRx, GSx, GTx, GUx, GVx, GWx, GXx  
• 4180-CTO, 62x, 63x, 64x, 65x, J2x, J3x, J4x, K7x, K8x, K9x, KAx, KBx, KCx, KDx,  
KEx, KFx, KGx, KHx, KJx, KKx, KLx, KMx, KNx, KQx, KRx, KSx, KTx, KUx, KVx, KWx,  
KXx, KYx, KZx, L2x, L3x, L4x, L5x, L6x, L7x, L8x, L9x, LAx, LBx, LCx, LDx, LFx,  
LGx, LHx, LLx, LMx, LNx, LPx, LQx, LRx, LSx, LTx, LVx, LWx, LXx, LYx, LZx, M2x,  
M3x, M4x, M5x, M6x, M7x, M8x, M9x, MAx, MBx, MCx, MDx, MEx, MGx, MHx, MJx,  
MKx, MMx, MNx, MPx, MQx, MRx, MSx, MTx, MUx, MVx, MWx, MXx, MYx, MZx,  
N2x, N3x, N4x, N5x, N6x, N7x, N8x, N9x, NAx, NBx, NCx, NFx, PAx, PBx, PCx, PFx,  
PGx, PKx, PLx, PMx, PNx, PPx, PQx, PRx, PSx, PTx, PUx, PVx, PWx, PXx, PYx, PZx,  
Q2x, Q3x, Q4x, Q5x, Q6x, Q7x, Q8x, Q9x  
• 4236-CTO, 62x, 63x, 64x, 65x, MBx, N2x, N4x, N5x, N7x, N8x, N9x, NAx, NBx, NCx,  
NDx, NEx, NFx, NGx, NHx, NKx, NLx, NPx, NQx, NRx, NSx, NTx, NUx, NVx, NWx,  
NXx, NYx, P2x, P3x, P4x, P5x, P6x, P7x, P8x, P9x, PAx, PBx, PCx, PDx, PEx, PFx,  
PGx, PHx, PJx, PKx, PLx, PMx, PNx, PPx, PQx, PRx, PSx, PTx, PUx, PVx, PWx,  
PXx, PYx  
• 4237-CTO  
• 4238-CTO  
2
04W1613  
N
Camera module (No camera and with microphone)  
• 4177-CTO, Q7x, QCx, QFx, QTx, R5x, R6x  
• 4178-CTO, ACx  
• 4179-CTO, G2x, GEx  
• 4180-CTO, K2x, K3x, K4x, K5x, K6x, KPx, LEx, LJx, LKx, LUx, MFx, MLx, NDx, NEx,  
PDx, PEx, PHx, PJx  
• 4236-CTO, N3x, N6x, NMx, NNx  
• 4237-CTO  
• 4238-CTO  
2
04W1614  
N
Camera module (No camera and no integrated microphone)  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
Chapter 10. Parts list 151  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 10. Parts list—LCD FRUs (continued)  
No. FRU  
FRU no.  
CRU  
ID  
3
93P5691  
93P5687  
04W0476  
93P5697  
N
LCD module, 14.0-inch HD (1366 x 768) LED backlight Anti-Glare Display  
• 4177-CTO, 25x, 26x, 27x, 28x, 2Dx, 2Jx, 2Mx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 32x,  
33x, 34x, Q2x, Q5x, Q7x, QCx, QEx, QGx, QJx, QLx, QNx, QPx, QTx, QUx, QWx,  
QXx, QYx, QZx, R2x, R3x, R5x, R6x, R7x, R9x, RBx, RCx, RFx, RGx, RHx, RJx, RNx,  
RPx, RRx, RSx, RTx, RUx, RVx, RYx, RZx  
• 4178-CTO, 52x, 56x, 57x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Fx, 5Gx, 5Hx, 5Jx, 5Kx, 5Lx,  
5Mx, 69x, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx, 6Hx, 6Jx, 6Mx, 6Qx, 6Tx, 6Ux, 6Zx, 83x,  
84x, 92x, 93x, 94x, 95x, 98x, 9Fx, 9Gx, 9Hx, 9Nx, 9Ux, 9Vx, 9Wx, 9Yx, A5x, A6x, A7x,  
AAx, ABx, ACx, ADx, AGx, AHx, AJx, AKx, AMx, ANx, APx, ATx, AUx, AVx, AWx,  
AYx, AZx, B2x, B3x, B4x, B5x, B6x, B7x, B9x, BAx, BBx, BCx, BKx, BPx, BVx, BWx,  
BXx, BYx, BZx, C2x, C3x, C4x, CCx, CDx, CFx, CJx, CKx, CLx, CMx, CNx, CPx,  
CQx, CRx, CSx, CUx, CXx  
• 4179-CTO, G2x, G3x, G4x, G5x, G6x, G7x, GEx, GQx, GRx, GVx, GWx  
• 4180-CTO, 62x, 64x, K2x, K3x, K4x, K5x, K6x, K7x, K8x, K9x, KAx, KBx, KCx, KDx,  
KEx, KFx, KGx, KLx, KMx, KNx, L7x, L8x, L9x, LCx, LDx, LEx, LFx, LGx, LHx, LJx,  
LKx, LLx, LMx, LNx, LPx, LRx, LSx, LTx, LUx, LVx, LWx, LXx, LYx, M2x, M3x, M4x,  
M5x, M6x, M7x, M9x, MCx, MLx, MNx, MTx, MUx, MVx, MWx, N6x, NCx, NDx, NEx,  
PAx, PBx, PCx, PDx, PEx, PFx, PHx, PJx, PTx, PXx, Q2x, Q6x, Q7x, Q8x, Q9x  
• 4236-CTO, 62x, 64x, N2x, N3x, N5x, NCx, NDx, NKx, NLx, NMx, NQx, NRx, NUx, NXx,  
NYx, P3x, P4x, P5x, P6x, P7x, P8x, P9x, PAx, PBx, PCx, PDx, PEx, PHx, PJx, PLx,  
PQx, PSx, PTx, PUx, PVx, PWx, PXx, PYx  
• 4237-CTO  
• 4238-CTO  
3
93P5693  
93P5689  
N
LCD module, 14.0-inch HD+ (1600 x 900) LED backlight Anti-Glare Display  
• 4177-CTO, 2Kx, 2Lx, 2Nx, 2Px, 2Qx, 2Yx, 35x, Q3x, Q4x, Q8x, QAx, QBx, QFx, QHx,  
QKx, QVx, R4x, R8x, RAx, RDx, RKx, RLx, RMx, RQx  
• 4178-CTO, 54x, 55x, 58x, 59x, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx, 5Wx, 5Xx,  
5Yx, 5Zx, 66x, 67x, 68x, 6Ax, 6Kx, 6Lx, 6Nx, 6Px, 6Rx, 6Sx, 6Vx, 6Wx, 6Xx, 6Yx, 82x,  
96x, 97x, 99x, 9Ax, 9Bx, 9Cx, 9Jx, 9Kx, 9Lx, 9Mx, 9Px, 9Qx, 9Rx, 9Sx, 9Tx, 9Xx,  
9Zx, A2x, A3x, A4x, A8x, A9x, AEx, AFx, ALx, ASx, AXx, B8x, BDx, BEx, BFx, BGx,  
BHx, BJx, BMx, BNx, BQx, BRx, BSx, BTx, BUx, C5x, C6x, C7x, C8x, C9x, CAx,  
CBx, CEx, CGx, CHx, CVx, CWx, CYx  
• 4179-CTO  
• 4180-CTO, 63x, 65x, J2x, KHx, KJx, KKx, KPx, KQx, KRx, KSx, KTx, KUx, KVx, KWx,  
KXx, KYx, KZx, L2x, L3x, L4x, L5x, L6x, LAx, LBx, LQx, LZx, M8x, MBx, MDx, MEx,  
MFx, MHx, MJx, MKx, MMx, MPx, MQx, MRx, MSx, MYx, MZx, N2x, N5x, N7x, N8x,  
N9x, NAx, NBx, NFx, PGx, PNx, PRx, PSx, PUx, PVx, PWx, PYx, PZx, Q3x, Q4x, Q5x  
• 4236-CTO, 63x, 65x, MBx, N4x, N6x, N7x, N8x, N9x, NAx, NBx, NEx, NFx, NGx, NHx,  
NNx, NSx, NTx, NVx, P2x, PFx, PGx, PKx, PMx, PNx, PRx  
• 4237-CTO  
• 4238-CTO  
4
5
Hinges  
04W1610  
04W1612  
04W1611  
N
N
Wireless antenna set  
04W1615  
04W1616  
6
7
04W1608  
04W1619  
N
N
LCD rear cover assembly  
LED cable with camera bracket  
152 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 10. Parts list—LCD FRUs (continued)  
No. FRU  
FRU no.  
CRU  
ID  
8
04W1617  
N
LCD cable (for 14.0-inch HD LCD module)  
• 4177-CTO, 25x, 26x, 27x, 28x, 2Dx, 2Jx, 2Mx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 32x,  
33x, 34x, Q2x, Q5x, Q7x, QCx, QEx, QGx, QJx, QLx, QNx, QPx, QTx, QUx, QWx,  
QXx, QYx, QZx, R2x, R3x, R5x, R6x, R7x, R9x, RBx, RCx, RFx, RGx, RHx, RJx, RNx,  
RPx, RRx, RSx, RTx, RUx, RVx, RYx, RZx  
• 4178-CTO, 52x, 56x, 57x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Fx, 5Gx, 5Hx, 5Jx, 5Kx, 5Lx,  
5Mx, 69x, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx, 6Hx, 6Jx, 6Mx, 6Qx, 6Tx, 6Ux, 6Zx, 83x,  
84x, 92x, 93x, 94x, 95x, 98x, 9Fx, 9Gx, 9Hx, 9Nx, 9Ux, 9Vx, 9Wx, 9Yx, A5x, A6x, A7x,  
AAx, ABx, ACx, ADx, AGx, AHx, AJx, AKx, AMx, ANx, APx, ATx, AUx, AVx, AWx,  
AYx, AZx, B2x, B3x, B4x, B5x, B6x, B7x, B9x, BAx, BBx, BCx, BKx, BPx, BVx, BWx,  
BXx, BYx, BZx, C2x, C3x, C4x, CCx, CDx, CFx, CJx, CKx, CLx, CMx, CNx, CPx,  
CQx, CRx, CSx, CUx, CXx  
• 4179-CTO, G2x, G3x, G4x, G5x, G6x, G7x, GEx, GQx, GRx, GVx, GWx  
• 4180-CTO, 62x, 64x, K2x, K3x, K4x, K5x, K6x, K7x, K8x, K9x, KAx, KBx, KCx, KDx,  
KEx, KFx, KGx, KLx, KMx, KNx, L7x, L8x, L9x, LCx, LDx, LEx, LFx, LGx, LHx, LJx,  
LKx, LLx, LMx, LNx, LPx, LRx, LSx, LTx, LUx, LVx, LWx, LXx, LYx, M2x, M3x, M4x,  
M5x, M6x, M7x, M9x, MCx, MLx, MNx, MTx, MUx, MVx, MWx, N6x, NCx, NDx, NEx,  
PAx, PBx, PCx, PDx, PEx, PFx, PHx, PJx, PTx, PXx, Q2x, Q6x, Q7x, Q8x, Q9x  
• 4236-CTO, 62x, 64x, N2x, N3x, N5x, NCx, NDx, NKx, NLx, NMx, NQx, NRx, NUx, NXx,  
NYx, P3x, P4x, P5x, P6x, P7x, P8x, P9x, PAx, PBx, PCx, PDx, PEx, PHx, PJx, PLx,  
PQx, PSx, PTx, PUx, PVx, PWx, PXx, PYx  
• 4237-CTO  
• 4238-CTO  
8
04W1618  
LCD cable (for 14.0-inch HD+ LCD module)  
• 4177-CTO, 2Kx, 2Lx, 2Nx, 2Px, 2Qx, 2Yx, 35x, Q3x, Q4x, Q8x, QAx, QBx, QFx, QHx,  
QKx, QVx, R4x, R8x, RAx, RDx, RKx, RLx, RMx, RQx  
• 4178-CTO, 54x, 55x, 58x, 59x, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx, 5Wx, 5Xx,  
5Yx, 5Zx, 66x, 67x, 68x, 6Ax, 6Kx, 6Lx, 6Nx, 6Px, 6Rx, 6Sx, 6Vx, 6Wx, 6Xx, 6Yx, 82x,  
96x, 97x, 99x, 9Ax, 9Bx, 9Cx, 9Jx, 9Kx, 9Lx, 9Mx, 9Px, 9Qx, 9Rx, 9Sx, 9Tx, 9Xx,  
9Zx, A2x, A3x, A4x, A8x, A9x, AEx, AFx, ALx, ASx, AXx, B8x, BDx, BEx, BFx, BGx,  
BHx, BJx, BMx, BNx, BQx, BRx, BSx, BTx, BUx, C5x, C6x, C7x, C8x, C9x, CAx,  
CBx, CEx, CGx, CHx, CVx, CWx, CYx  
• 4179-CTO  
• 4180-CTO, 63x, 65x, J2x, KHx, KJx, KKx, KPx, KQx, KRx, KSx, KTx, KUx, KVx, KWx,  
KXx, KYx, KZx, L2x, L3x, L4x, L5x, L6x, LAx, LBx, LQx, LZx, M8x, MBx, MDx, MEx,  
MFx, MHx, MJx, MKx, MMx, MPx, MQx, MRx, MSx, MYx, MZx, N2x, N5x, N7x, N8x,  
N9x, NAx, NBx, NFx, PGx, PNx, PRx, PSx, PUx, PVx, PWx, PYx, PZx, Q3x, Q4x, Q5x  
• 4236-CTO, 63x, 65x, MBx, N4x, N6x, N7x, N8x, N9x, NAx, NBx, NEx, NFx, NGx, NHx,  
NNx, NSx, NTx, NVx, P2x, PFx, PGx, PKx, PMx, PNx, PRx  
• 4237-CTO  
• 4238-CTO  
9
LED sub card  
Clear plate kit  
04W1370  
04W1620  
N
N
10  
Chapter 10. Parts list 153  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Keyboard  
Table 11. Parts list—Keyboard  
Language  
FRU no.  
CRU  
ID  
Arabic  
45N2076  
45N2077  
45N2075  
45N2078  
45N2073  
45N2072  
45N2079  
45N2080  
45N2097  
45N2082  
45N2083  
45N2084  
45N2085  
45N2086  
45N2087  
63Y0219  
45N2088  
45N2102  
45N2089  
45N2103  
45N2074  
45N2091  
45N2092  
45N2093  
45N2094  
45N2095  
45N2096  
45N2081  
45N2098  
45N2105  
45N2104  
45N2099  
45N2100  
45N2071  
45N2101  
45N2146  
45N2147  
45N2145  
45N2148  
45N2143  
45N2142  
45N2149  
45N2150  
45N2167  
45N2152  
45N2153  
45N2154  
45N2155  
45N2156  
45N2157  
63Y0221  
45N2158  
45N2172  
45N2159  
45N2173  
45N2144  
45N2161  
45N2162  
45N2163  
45N2164  
45N2165  
45N2166  
45N2151  
45N2168  
45N2175  
45N2174  
45N2169  
45N2170  
45N2141  
45N2171  
45N2216  
45N2217  
45N2215  
45N2218  
45N2213  
45N2212  
45N2219  
45N2220  
45N2237  
45N2222  
45N2223  
45N2224  
45N2225  
45N2226  
45N2227  
63Y0223  
45N2228  
45N2242  
45N2229  
45N2243  
45N2214  
45N2231  
45N2232  
45N2233  
45N2234  
45N2235  
45N2236  
45N2221  
45N2238  
45N2245  
45N2244  
45N2239  
45N2240  
45N2211  
45N2241  
**  
Belgian  
Brazilian Portuguese  
Bulgarian  
Canadian French (058)  
Canadian French (Acnor)  
Czech  
Danish  
Finnish, Swedish  
French  
German  
Greek (U. S. English and Greek layout)  
Hebrew  
Hungarian  
Icelandic  
Indian  
Italian  
Japanese  
Kazakhstan  
Korean  
Latin American Spanish  
Norwegian  
Polish  
Portuguese  
Russian  
Slovak  
Slovenian  
Spanish  
Swiss  
Thai  
Traditional Chinese  
Turkish  
U.K. English  
U.S. English  
U.S. English (International, with a Euro symbol)  
154 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Table 11. Parts list—Keyboard (continued)  
Language  
FRU no.  
CRU  
ID  
Netherlands  
45N2090  
60Y9552  
45N2160  
60Y9554  
45N2230  
60Y9550  
Turkish (F Type)  
Chapter 10. Parts list 155  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Miscellaneous parts  
Table 12. Parts list—Miscellaneous parts  
FRU  
FRU no.  
CRU  
ID  
04W1605  
N
Screw and seal kit:  
• M2 × 3 mm, black (50)  
• M2 × 5 mm, black (20)  
• M2 × 8 mm, black (15)  
• M2 × 10 mm, Silver (4)  
• M2 × 15 mm, black (8)  
• M2.5 × 4 mm, black (8)  
• M2.5 × 6 mm, black (8)  
• M2 (shoulder), black (4)  
• Hex stud, Silver (4)  
Tape 10 x 20 mm (10)  
Tape 10 x 25 mm (5)  
• DDR3 tape (5)  
Base miscellaneous parts:  
• Foot rubber - front left  
• Foot rubber - front right  
• Foot rubber - rear  
• Bottom shield  
04W1602  
N
• Insulation sheet - CPU  
• Insulation sheet - system board  
• Insulation sheet - touchpad  
• Insulation sheet - battery connector  
• Lens, LED (RJ-45)  
• Knob, wireless switch  
• Lever, wireless switch  
• ODD lock button  
• ODD eject spring  
• ODD eject button  
• ODD eject brecket  
• Dust filter 1  
• Dust filter 2  
• Dust filter 3  
• Dust filter 4  
• Dust filter 5  
• ODD stop rubber  
• Sponge L43W4H5  
• Sponge L15W4H5  
• Sponge L110W4H5  
• Sponge L85W3H3  
• Sponge L26W4H1  
Keyboard bezel miscellaneous parts:  
• Magnet - suspend switch  
• Bracket - touchpad  
04W1603  
N
• Bracket - right speaker  
• Bracket - left speaker  
• Bracket - left speaker EMI spring  
• Bracket - FPR EMI  
• Speaker mesh  
• Face sheet - touchpad  
• ThinkPad logo  
• Bracket - touchpad button  
• Bracket - FPR  
• Insulation sheet - touchpad  
156 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Table 12. Parts list—Miscellaneous parts (continued)  
FRU  
FRU no.  
CRU  
ID  
• Insulation sheet - fingerprint  
• LCD latch left  
• LCD latch right  
• LCD link  
• LCD latch spring  
04W1604  
N
System miscellaneous parts:  
(a) Express dummy card  
(b) LCD connector bracket  
(c) Fan bracket, discrete  
• CPU mylar for 35W SV GT2  
• 1394 cover  
• Dummy cover, RJ-11  
• Plastic support for smart card  
• Blind sheet for SIM card  
• SIM dummy card  
Note: Italicized letters in parentheses are references to the exploded view in “Overall”  
on page 130.  
04W1601  
N
System board miscellaneous parts:  
• Insulation sheet - MB  
• Insulation sheet - DDR  
• Insulation sheet - express card  
• Insulation sheet - battery  
• Insulation sheet - docking  
• Insulation sheet - bottom hole  
• Insulation sheet - DC-in  
• Bracket - express card  
• SIM guide bracket sub accessory  
• CPU bracket sub accessory  
• SIM slide spacer  
• SIM pull tab  
• Sponge for RJ45 connector  
• Sponge for display port connector  
• Sponge for HDD 1  
• Sponge for HDD 2  
• Sponge for HDD 3  
• Sponge for ODD 1  
• Sponge for ODD 2  
04W1607  
N
LCD miscellaneous parts:  
• LCD front bezel  
• Rubber - LCD front bezel  
• Stopper - LCD front bezel  
• LED lens - LCD front bezel  
• Shield - EMC  
• Clear plate - LCD rear cover  
• LED lens - LCD rear cover  
• ThinkPad logo  
• Lenovo logo  
• LCD latch - right  
• LCD latch - left  
• Sponge - center  
• Sponge - upper  
• Sponge - lower  
• Stopper - upper right  
• Stopper - upper left  
• Stopper - lower right  
• Stopper - lower left  
Chapter 10. Parts list 157  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Information about ac power adapters  
Table 13. Parts list—2-pin ac power adapters  
FRU  
FRU no.  
CRU  
ID  
42T5282  
42T4423  
42T4419  
42T4427  
42T4431  
42T4435  
42T4439  
*
2-pin (65 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)  
2-pin (65 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)  
2-pin (65 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)  
2-pin (90 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)  
2-pin (90 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)  
2-pin (90 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)  
2-pin (90 W, 20 V) adapter (models CTO, xxE, xxF, xxJ, xxL, xxP, xxS, xxU, xxY)  
Table 14. Parts list—3-pin ac power adapters  
FRU  
FRU no.  
CRU  
ID  
42T5283  
42T4421  
42T4417  
42T4425  
42T4429  
42T4433  
45N0068  
*
3-pin (65 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)  
3-pin (65 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)  
3-pin (65 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)  
3-pin (90 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)  
3-pin (90 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)  
3-pin (90 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)  
3-pin (90 W, 20 V) adapter (models CTO, xxA, xxB, xxG, xxH, xxK, xxM, xxQ, xxT, xxV)  
158 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
Power cords  
A ThinkPad power cord for a specific country or region is usually available only in that country or region:  
Table 15. Parts list—2-pin power cords  
FRU no.  
Country or region  
CRU  
ID  
Argentina  
• models -CTO, xxY  
42T5020 42T5105  
42T5180 42T5183  
42T5008 42T5093  
42T5014 42T5099  
*
Brazil  
• models -CTO, xxP  
Canada, U.S.  
• models -CTO, xxF, xxL, xxS, xxU  
Japan  
• models -CTO, xxE, xxJ  
Table 16. Parts list—3-pin power cords  
FRU no.  
Country or region  
CRU  
ID  
Australia, New Zealand  
• models -CTO, xxM  
42T5050 42T5135  
42T5056 42T5141  
42T5004 42T5089  
42T5065 42T5150  
42T5041 42T5126  
42T5029 42T5114  
42T5083 42T5168  
42T5062 42T5147  
42T5047 42T5132  
42T5077 42T5162  
42T5044 42T5129  
42T5071 42T5156  
42T5035 42T5120  
*
Bangladesh, Sri Lanka, South Africa  
• models -CTO, xxG  
Canada, U.S.  
• models -CTO, xxG, xxT  
China (P.R.C.) (other than Hong Kong S.A.R.)  
• models -CTO, xxC  
Denmark  
• models -CTO, xxG  
European countries  
• models -CTO, xxG  
India  
• models -CTO, xxQ  
Israel  
• models -CTO, xxG  
Italy  
• models -CTO, xxG  
Korea  
• models -CTO, xxK  
Switzerland  
• models -CTO, xxG  
Taiwan  
• models -CTO, xxV  
U.K., China (Hong Kong S.A.R.)  
• models -CTO, xxB, xxG, xxH  
Chapter 10. Parts list 159  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Recovery discs  
Windows XP Professional DVDs  
Note: The Windows XP Professional recovery DVDs are available only for models with a valid Microsoft  
Windows XP Professional certificate of authenticity (COA) affixed to the system. Due to a Microsoft licensing  
limitation, if a model came with Windows XP Professional preinstalled from the factory, but has either a  
Windows 7 or Windows Vista COA affixed to the system, that model is eligible only for recovery DVDs that  
match the operating system specified on the COA.  
Windows XP Professional is preinstalled as the operating system in the following models:  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
Table 17. Parts list—Windows XP Professional recovery DVDs  
Language  
P/N  
CRU  
ID  
French  
04T1306  
04T1307  
04T1308  
04X0075  
04T1305  
04X0076  
*
German  
Italian  
Japanese  
Simplified Chinese  
US English  
Windows Vista Business (32 bit) SP2 DVDs  
Note: The Windows Vista recovery DVDs are available only for models with a valid Microsoft Windows Vista  
certificate of authenticity (COA) affixed to the system. Due to a Microsoft licensing limitation, if a model came  
with Windows Vista Business or Windows Vista Ultimate preinstalled from the factory, but has a Windows 7  
COA affixed to the system, that model is eligible only for recovery DVDs that match the operating system  
specified on the COA.  
Windows Vista Business (32 bit) SP2 is preinstalled as the operating system in the following models:  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
Table 18. Parts list—Windows Vista Business (32 bit) SP2 recovery DVDs  
Language  
P/N  
CRU  
ID  
04T1309  
04T1311  
*
English (for India)  
US English  
160 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Windows Vista Home Basic (32 bit) SP2 DVDs  
Note: The Windows Vista recovery DVDs are available only for models with a valid Microsoft Windows Vista  
certificate of authenticity (COA) affixed to the system. Due to a Microsoft licensing limitation, if a model came  
with Windows Vista Business or Windows Vista Ultimate preinstalled from the factory, but has a Windows 7  
COA affixed to the system, that model is eligible only for recovery DVDs that match the operating system  
specified on the COA.  
Windows Vista Home Basic (32 bit) SP2 is preinstalled as the operating system in the following models:  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
Table 19. Parts list—Windows Vista Home Basic (32 bit) SP2 recovery DVDs  
Language  
P/N  
CRU  
ID  
04T1312  
*
US English  
Windows 7 Professional (32 bit) DVDs  
Windows 7 Professional (32 bit) is preinstalled as the operating system in the following models:  
• 4177-CTO, Q7x, QAx, QDx, QTx, R5x, R6x  
• 4178-CTO, 9Px, 9Qx, 9Ux, 9Vx, ACx, ALx, ASx, AUx, AVx, BBx, BCx  
• 4179-CTO, G3x, G7x, GQx, GRx  
• 4180-CTO, K3x, K6x, K7x, KLx, KQx, L7x, LCx, LDx, LGx, LHx, LKx, LMx, LPx, LQx, LRx, LSx, LTx, MFx,  
MLx, MPx, MYx, PHx, PJx, PPx, Q9x  
• 4236-CTO, N6x, N7x, N8x, N9x, NAx, NDx, NEx, NLx  
• 4237-CTO  
• 4238-CTO  
Table 20. Parts list—Windows 7 Professional (32 bit) recovery DVDs  
Language  
P/N  
CRU  
ID  
French  
04T1314  
04T1315  
04T1316  
04T1319  
04T1320  
04T1317  
04T1313  
04T1611  
04T1318  
*
German  
Japanese  
C&L Nordics (Danish, Finnish, Swedish, Norwegian, and English)  
C&L EMEA (Dutch, French, German, Italian, and English)  
Spanish  
Simplified Chinese  
Traditional Chinese with English (Hong Kong S.A.R)  
US English  
Windows 7 Professional (64 bit) DVDs  
Windows 7 Professional (64 bit) is preinstalled as the operating system in the following models:  
• 4177-CTO, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Kx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Ux, 2Wx, 32x,  
33x, 35x, Q2x, Q3x, Q4x, Q5x, Q8x, QBx, QCx, QEx, QGx, QHx, QKx, QLx, QMx, QNx, QPx, QVx,  
Chapter 10. Parts list 161  
Download from Www.Somanuals.com. All Manuals Search And Download.  
QXx, QYx, R2x, R3x, R4x, R8x, R9x, RAx, RBx, RCx, RDx, RFx, RGx, RJx, RKx, RLx, RMx, RNx, RPx,  
RQx, RRx, RTx, RVx, RWx, RXx, RYx  
• 4178-CTO, 52x, 53x, 54x, 55x, 56x, 57x, 58x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Fx, 5Gx, 5Hx, 5Kx, 5Mx,  
5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Vx, 5Wx, 5Xx, 5Yx, 5Zx, 66x, 67x, 68x, 6Ax, 6Cx, 6Ex, 6Fx, 6Gx, 6Hx,  
6Kx, 6Mx, 6Nx, 6Px, 6Qx, 6Rx, 6Ux, 6Vx, 6Wx, 6Yx, 82x, 83x, 84x, 93x, 96x, 99x, 9Ax, 9Bx, 9Cx, 9Gx,  
9Hx, 9Jx, 9Kx, 9Lx, 9Mx, 9Rx, 9Sx, 9Tx, 9Wx, 9Xx, 9Yx, 9Zx, A2x, A3x, A4x, A5x, A7x, A8x, A9x, AAx,  
ABx, ADx, AEx, AFx, AGx, AHx, AKx, AMx, ANx, APx, ATx, AWx, AXx, AYx, B2x, B3x, B5x, B6x, B7x, B8x,  
B9x, BAx, BDx, BEx, BFx, BGx, BHx, BJx, BKx, BMx, BNx, BPx, BQx, BRx, BSx, BTx, BUx, BVx, BXx,  
C3x, C4x, C5x, C6x, C7x, C8x, C9x, CAx, CBx, CCx, CDx, CEx, CFx, CGx, CHx, CJx, CKx, CPx, CQx,  
CRx, CSx, CUx, CVx, CWx, CXx, CYx  
• 4179-CTO, GBx, GEx  
• 4180-CTO, 62x, 63x, 64x, 65x, K2x, K4x, K5x, K8x, K9x, KAx, KBx, KCx, KDx, KEx, KFx, KGx, KHx, KJx,  
KKx, KMx, KNx, KPx, KRx, KSx, KTx, KUx, KVx, KWx, KXx, KYx, KZx, L2x, L3x, L4x, L5x, L6x, L8x,  
L9x, LAx, LBx, LUx, LVx, LWx, LXx, LYx, LZx, M2x, M3x, M4x, M5x, M6x, M7x, M8x, M9x, MBx, MCx,  
MDx, MEx, MHx, MJx, MKx, MMx, MNx, MQx, MRx, MSx, MTx, MUx, MVx, MZx, N2x, N4x, N5x, N8x,  
N9x, NAx, NBx, NDx, NEx, NFx, PAx, PBx, PCx, PEx, PFx, PGx, PMx, PNx, PRx, PSx, PTx, PUx, PVx,  
PWx, PXx, PYx, PZx, Q2x, Q3x, Q4x, Q5x, Q8x  
• 4236-CTO, 62x, 63x, 64x, 65x, MBx, N2x, N3x, N4x, N5x, NBx, NFx, NGx, NHx, NMx, NNx, NSx, NTx,  
NUx, NVx, NXx, NYx, P2x, P3x, P5x, P6x, P7x, P8x, P9x, PAx, PCx, PFx, PGx, PHx, PJx, PKx, PLx, PMx,  
PNx, PPx, PQx, PRx, PTx, PVx, PWx, PXx, PYx  
• 4237-CTO  
• 4238-CTO  
Table 21. Parts list—Windows 7 Professional (64 bit) recovery DVDs  
Language  
P/N  
CRU  
ID  
Arabic with English  
04T1322  
04T1323  
04T1326  
04T1346  
04T1347  
04T1348  
04T1327  
04T1328  
04T1329  
04T1330  
04T1331  
04T1333  
04T1334  
04T1335  
04T1336  
04T1337  
04T1338  
04T1339  
04T1340  
04T1341  
*
Brazilian Portuguese  
Czech with English  
C&L Nordics (Danish, Finnish, Swedish, Norwegian, and English)  
C&L EMEA (Dutch, French, German, Italian, and English)  
C&L Croatian (Slovenian, Croatian, and English)  
English (for India)  
French  
Greek with English  
German  
Hebrew with English  
Hungarian with English  
Japanese  
Korea with English  
Polish  
Portuguese with English  
Romanian with English  
Russian  
Slovak with English  
Spanish  
162 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 21. Parts list—Windows 7 Professional (64 bit) recovery DVDs (continued)  
Language  
P/N  
CRU  
ID  
04T1342  
04T1324  
04T1332  
04T1343  
04T1325  
04T1344  
04T1345  
Serbian-Latin with English  
Simplified Chinese  
Traditional Chinese with English (Hong Kong S.A.R.)  
Turkish with English  
Traditional Chinese with English  
US English (Disabled)  
US English  
Windows 7 Home Basic (32 bit) DVDs  
Windows 7 Home Basic (32 bit) is preinstalled as the operating system in the following models:  
• 4177-CTO, 22x, 23x, 24x, 2Ex, 2Xx, 36x, GFx, GKx, GLx, GMx, QQx, QRx, QSx  
• 4178-CTO, 6Sx, 9Dx, 9Ex, AQx, ARx  
• 4179-CTO, G8x, G9x, GCx, GDx, GGx, GHx, GJx, GPx, GSx, GTx, GUx, GVx, GWx  
• 4180-CTO, J2x, J3x, J4x, MAx, MGx, MXx, N3x, N6x, N7x, PKx, PLx, Q6x, Q7x  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
Table 22. Parts list—Windows 7 Home Basic (32 bit) recovery DVDs  
Language  
P/N  
CRU  
ID  
Arabic with English  
Brazilian Portuguese  
English (for India)  
French  
04T1350  
04T1351  
04T1353  
04T1354  
04T1355  
04T1356  
04T1352  
04T1357  
04T1358  
04T1359  
04T1360  
*
Portuguese with English  
Russian  
Simplified Chinese  
Spanish  
Serbian-Latin with English  
Turkish with English  
US English  
Windows 7 Home Premium (32 bit) DVDs  
Windows 7 Home Premium (32 bit) is preinstalled as the operating system in the following models:  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO, G4x  
• 4180-CTO, LNx  
• 4236-CTO, NCx  
• 4237-CTO  
• 4238-CTO  
Chapter 10. Parts list 163  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 23. Parts list—Windows 7 Home Premium (32 bit) recovery DVDs  
Language  
P/N  
CRU  
ID  
04T1362  
04T1361  
04T1363  
*
English (for India)  
Simplified Chinese  
US English  
Windows 7 Home Premium (64 bit) DVDs  
Windows 7 Home Premium (64 bit) is preinstalled as the operating system in the following models:  
• 4177-CTO, 2Jx, 2Lx, 2Mx, 2Tx, 2Vx, 2Yx, 34x, QFx, QJx, QUx, QWx, QZx, R7x, RHx, RSx, RUx, RZx  
• 4178-CTO, 9Fx, 9Nx, A6x, BWx, CLx, CMx, CNx  
• 4179-CTO, GMx, GNx  
• 4180-CTO, NCx, PQx  
• 4236-CTO, NPx, NQx, NRx, NWx  
• 4237-CTO  
• 4238-CTO  
Table 24. Parts list—Windows 7 Home Premium (64 bit) recovery DVDs  
Language  
P/N  
CRU  
ID  
Arabic with English  
04T1364  
04T1365  
04T1368  
04T1387  
04T1388  
04T1389  
04T1369  
04T1370  
04T1371  
04T1372  
04T1374  
04T1375  
04T1376  
04T1377  
04T1378  
04T1379  
04T1380  
04T1381  
04T1366  
04T1382  
04T1383  
04T1367  
04T1373  
*
Brazilian Portuguese  
Czech with English  
C&L Nordics (Danish, Finnish, Swedish, Norwegian, and English)  
C&L EMEA (Dutch, French, German, Italian, and English)  
C&L Croatian (Slovenian, Croatian, and English)  
French  
Greek with English  
German  
Hebrew with English  
Hungarian with Engish  
Japanese  
Korea with English  
Polish  
Portuguese with English  
Romanian with English  
Russian  
Slovak with English  
Simplified Chinese  
Spanish  
Serbian-Latin with English  
Traditional Chinese with English  
Traditional Chinese with English (Hong Kong S.A.R.)  
164 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Table 24. Parts list—Windows 7 Home Premium (64 bit) recovery DVDs (continued)  
Language  
P/N  
CRU  
ID  
Turkish with English  
US English (Disabled)  
US English  
04T1384  
04T1385  
04T1386  
Windows 7 Ultimate (32 bit) DVDs  
Windows 7 Ultimate (32 bit) is preinstalled as the operating system in the following models:  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
Table 25. Parts list—Windows 7 Ultimate (32 bit) recovery DVDs  
Language  
P/N  
CRU  
ID  
04T1321  
*
US English  
Windows 7 Ultimate (64 bit) DVDs  
Windows 7 Ultimate (64 bit) is preinstalled as the operating system in the following models:  
• 4177-CTO  
• 4178-CTO  
• 4179-CTO  
• 4180-CTO  
• 4236-CTO  
• 4237-CTO  
• 4238-CTO  
Table 26. Parts list—Windows 7 Ultimate (64 bit) recovery DVDs  
Language  
P/N  
CRU  
ID  
04T1349  
*
US English  
Chapter 10. Parts list 165  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Common service tools  
Table 27. Parts list—Common service tools  
Tool  
P/N  
95F3598  
1650840  
93F2838  
00P6967  
08K7159  
40Y8687  
40Y8704  
05K9283  
27L3452  
42W7820  
Screwdriver kit  
1/4" drive spinner handle  
1/4" Sq. to 1/4" hex torx adapter  
TR7-TR-10 tamper resistant torx bits  
Removal tool antenna RF connector  
USB 2.0 CD-RW/DVD-ROM combo drive II  
USB cable  
USB floppy diskette drive for maintenance diskette  
USB floppy diskette drive tool kit  
Test card for integrated Smart Card  
LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later  
Note: Download the file from the following Web site:  
http://www.lenovo.com/support  
166 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Appendix A. Notices  
Lenovo may not offer the products, services, or features discussed in this document in all countries. Consult  
your local Lenovo representative for information on the products and services currently available in your  
area. Any reference to a Lenovo product, program, or service is not intended to state or imply that only that  
Lenovo product, program, or service may be used. Any functionally equivalent product, program, or service  
that does not infringe any Lenovo intellectual property right may be used instead. However, it is the user’s  
responsibility to evaluate and verify the operation of any other product, program, or service.  
Lenovo may have patents or pending patent applications covering subject matter described in this  
document. The furnishing of this document does not give you any license to these patents. You can send  
license inquiries, in writing, to:  
Lenovo (United States), Inc.  
1009 Think Place - Building One  
Morrisville, NC 27560  
U.S.A.  
Attention: Lenovo Director of Licensing  
LENOVO GROUP LTD. PROVIDES THIS PUBLICATION “AS IS” WITHOUT WARRANTY OF ANY KIND,  
EITHER EXPRESS OR IMPLIED, INCLUDING, BUT NOT LIMITED TO, THE IMPLIED WARRANTIES  
OF NON-INFRINGEMENT, MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. Some  
jurisdictions do not allow disclaimer of express or implied warranties in certain transactions, therefore,  
this statement may not apply to you.  
This information could include technical inaccuracies or typographical errors. Changes are periodically  
made to the information herein; these changes will be incorporated in new editions of the publication.  
Lenovo may make improvements and/or changes in the product(s) and/or the program(s) described in this  
publication at any time without notice.  
The products described in this document are not intended for use in implantation or other life support  
applications where malfunction may result in injury or death to persons. The information contained in this  
document does not affect or change Lenovo product specifications or warranties. Nothing in this document  
shall operate as an express or implied license or indemnity under the intellectual property rights of Lenovo  
or third parties. All information contained in this document was obtained in specific environments and is  
presented as an illustration. The result obtained in other operating environments may vary.  
Lenovo may use or distribute any of the information you supply in any way it believes appropriate without  
incurring any obligation to you.  
Any references in this publication to non-Lenovo Web sites are provided for convenience only and do not in  
any manner serve as an endorsement of those Web sites. The materials at those Web sites are not part of  
the materials for this Lenovo product, and use of those Web sites is at your own risk.  
Any performance data contained herein was determined in a controlled environment. Therefore, the result  
obtained in other operating environments may vary significantly. Some measurements may have been  
made on development-level systems and there is no guarantee that these measurements will be the same  
on generally available systems. Furthermore, some measurements may have been estimated through  
extrapolation. Actual results may vary. Users of this document should verify the applicable data for their  
specific environment.  
© Copyright Lenovo 2011  
167  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Electronic emissions notices  
For electronic emission information on Class B digital devices, refer to the corresponding information in  
the User Guide.  
168 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
Trademarks  
The following terms are trademarks of Lenovo in the United States, other countries or both:  
Active Protection System  
Lenovo  
ThinkLight  
ThinkPad  
ThinkVantage  
TrackPoint  
Ultrabay  
The following terms are trademarks of Microsoft group of companies:  
Windows  
Microsoft  
The following terms are trademarks of Intel Corporation or its subsidiaries in the United States, other  
countries, or both:  
Intel  
Intel Centrino  
Intel Core  
Other company, product, or service names may be the trademarks or service marks of others.  
Appendix A. Notices 169  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
170 ThinkPad T420 and T420i Hardware Maintenance Manual  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Download from Www.Somanuals.com. All Manuals Search And Download.  
Part Number: 0A60007_03  
(1P) P/N: 0A60007_03  
*0A60007_03*  
Download from Www.Somanuals.com. All Manuals Search And Download.  

KTI Networks Switch KS 115F Series User Manual
Kyocera All in One Printer FS C8520MFP User Manual
Leica GPS Receiver GPS1200+ User Manual
Lennox International Inc Furnace EL280DF User Manual
Lightolier Indoor Furnishings V7009 User Manual
Lochinvar Boiler G936199 User Manual
Marantz CD Player DR6050 User Manual
Maxtor Computer Drive 15TB User Manual
Melissa Vacuum Cleaner 640 174 User Manual
Memorex Mouse MX2710 User Manual