Owner’s Manual
Health Trainer 440 Elliptical
Customer Service
1.888.340.0482
Keys Fitness
4009 Distribution Drive
Suite 250
Garland, TX 75041
Model Name : HT440EL
Serial Number :
Write down for future reference
Serial Number Decal Location
315-00104
Rev A 06/07
Download from Www.Somanuals.com. All Manuals Search And Download.
Important Safety Information
WARNING! Before using this unit or starting any exercise program, consult your physician.
This is especially important for persons over the age of 35 and/or persons with pre-existing
health problems. The manufacturer or distributor assumes no responsibility for personal injury
or property damage sustained by or through the use of this product.
SAFETY PRECAUTIONS AND TIPS
1. It is the owner's responsibility to ensure that all users of this unit have read the Owner's
Manual and are familiar with warnings and safety precautions.
2. This unit has a user maximum capacity of 250 pounds.
3. The unit should only be used on a level surface and is intended for indoor use only. The unit
should not be placed in a garage, patio, or near water and should never be used while you are
wet. Keys Fitness recommends a mat be placed under the unit to protect floor or carpet and for
easier cleaning.
4. Wear comfortable, good-quality walking or running shoes and appropriate clothing. Do not
use the unit with bare feet, sandals, socks or stockings.
5. Always examine your unit before using to ensure all parts are in working order.
6. Allow the unit to fully stop before dismounting.
7. Pets should never be allowed near the unit.
8. Do not leave children unsupervised near or on the unit.
9. Never operate the unit where oxygen is being administered, or where aerosol products are
being used.
10. Never insert any object or body parts into any opening.
11. For safety and to prevent damage to your unit, no more than one person should use the
unit at a time.
12. Service to your unit should only be performed by an authorized service representative,
unless authorized and/or instructed by the manufacturer.
13. Failure to follow these instructions will void the unit warranty.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Before You Start
Thank you for purchasing the Health Trainer HT440EL Elliptical! This quality product you
have chosen was designed to meet your needs for cardiovascular exercise. Before you start,
please read the Owner's Manual and become familiar with the operation of your new unit.
Remember to take the time to perform the stretching exercises provided to avoid
injury.
If you are taking medication, consult your physician to see if the medication will affect your exer-
cise heart rate.
If you have heart problems, you are not active, and/or are over the age of 35 years, do not use
the pre-set programs or start an exercise program without first contacting and receiving approval
from your physician.
To avoid the risk of electrical shock, always keep the console dry. Do not spill liquids on the con-
sole. Keys Fitness recommends a sealed water bottle for beverages consumed while using the
unit.
Please review the following drawing below to familiarize yourself with the listed
parts.
Console
Pulse Handlebar
Pedals
Transport Wheels
Front Stabilizer
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Assembly
INSTRUCTIONS FOR ASSEMBLY:
Unpack the box in a clear area. Check to make sure all components are present and in good
condition. Do not dispose of the packing material until the assembly is completed. Tools have
been provided for you to use when assembling this product.
Locate the hardware pack and identify the following parts required for assembly.
M8X70mm Carriage Bolt(35)-4
M8 Cap Nut(33)-4
8X19 Arc Washer(34)-8
10*26*2.0 Washer(48)-4
3/8" Nylon Locknut(47)-4
3/8" Nylon Locknut(49)-4
M6X40mm Carriage Bolt(62)-4
6*13*1.0 Washer(63)-4
M6 cap nut(64)-4
M5 Allen Wrench
M8x15 Screw (65)-4
M5 Allen Wrench
19
13
14
10
15
10x13x14x15x17x19 Screw Driver
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Assembly
Assembly Part Identifier
1
2
3
4
5
6
7
8
9
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Assembly
Figure 1
FIGURE 1
Step 1:
34
Attach the Front Stabilizer (54)
onto Main Frame (1) with the
carriage screws (35), cap nuts
(33), and arc washers (34).
33
35
54
34
33
1
Figure 2
FIGURE 2
Step 1:
Attach the rear frame
w/aluminum rails 2 to the
main frame (1) and secure it
with carriage bolts (35), arc
washers (34) and cap nuts
(33).
33
34
33
34
35
2
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Assembly
Figure 3
FIGURE 3
Step 1:
Secure left pedal (5a) to left
pedal tube (4a) with screws
(47), nylock nuts (49) and
washers (48). Then secure left
pedal tube (4a) to unit by lin-
ing up the pedal tube to the
axle with screws (50), nylock
nuts (49) and washer (48).
Repeat on right side.
50
47
5a
48
49
4a
48
49
FIGURE 4
Step 1:
Figure 4
Connect the extension wires
(72) to the sensor Wires (73);
Connect the tension cable (68)
to the tension controller (66) as
following steps 2-3:
4A
4B
68
68
66
66
Step 2:
Put the cable end (66) into the
spring hook (68) (figure 4A).
3
Step 3:
Pull the knob and insert the
short cable (66) into the gap of
the bracket (68) (pic 4B).
Tension is increased by turning
the knob clockwise.
66
72
68
73
34
Step 4:
65
Secure the upright post (3)
onto Main Frame (1) with
Washers (34) and Screws (65).
8
Download from Www.Somanuals.com. All Manuals Search And Download.
Assembly
FIGURE 5
Step 1:
Figure 5
Install the left sleeve (6a) to
the axle on the upright tube
(3) and secure with washer
(46), nut (45), and nut cap
(44). Connect the pulse wire
(42) with the pulse wire (87).
Connect pulse wire (88) to
the second connector on the
pulse wire (87). Connect
the upper handlebar (7a)
to the lower left handlebar
(6a) with carriage bolts (62),
washers (63) and cap nuts
(64). Attach the pedal tube
to the lower left handlebar
(6a) with nut caps (67).
Finally, insert plastic cap (85)
into the opening as shown.
Repeat on right side.
7a
88
67
7b
85
42
64
63
87
46
45
44
62
3
6b
6a
36 71
27
40
FIGURE 6
Step 1:
Figure 6
9
Connect the sensor wire (72)
and the pulse wires to the con-
sole (9). Attach the console
(9) to the top of the upright
tube (3) and secure it using
screws (69) attached to the
console.
72
69
3
ꢀ
Download from Www.Somanuals.com. All Manuals Search And Download.
Assembly
Congratulations!
You have completed assembly of your new HT440EL Elliptical!
10
Download from Www.Somanuals.com. All Manuals Search And Download.
Console Overview
CONSOLE BUTTONS:
ENTER/RESET:
Used to enter edit mode for a setting when using target training. If held for over 3 seconds,
will reset console, and change all of the settings back to 0.
PULSE RECOVERY:
Used to enter "Pulse Recovery" mode during workout. This will begin the fitness test. Fitness
Test is described in more detail in the following pages.
DOWN and UP:
Use to select which setting will be edited. When editing setting, use to scroll up or down until
selected setting is found.
CONSOLE FUNCTIONS
TIME:
Count up - No preset target, Time will count up from 00:00 to maximum 99:59 with each
increment is 1 second. Count down - If training with preset Time, Time will count down from
preset to 00:00. Each preset increment or decrement is 1 minute between 1:00 to 99:00.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
Console Overview
SPEED:
Display current training speed from 0.0 to maximum 99.9 MPH.
DISTANCE:
Count up - No preset target, Distance will count up from 0.00 to maximum 99.90 with each
Increment 0.1 MPH. Count down - If training with preset target, Distance will count down from
preset to 0.00. Each preset increment or decrement is 0.1 MPH between 0.00 to 99.90.
CALORIES:
Count up - No preset target, Calories will count up from 0 to maximum 990 with each 1 cal
increment. Count down - If training with preset target, Calories will count down from preset
calorie to 0. Each preset increment or decrement is 10 cal from 0 to 990 cal.
PULSE:
Displays your current heart beat figures as soon as both hands are holding the pulse sensor.
The console will detect your heart rate through hand grip sensors.
PULSE RECOVERY:
After exercising for a period of time, keep holding on to the handgrips and press the “PULSE
RECOVERY” button. Screen will display your heart rate recovery status with the F1, F2 to F6.
F1 is the best, F6 is the worst. User may keep exercising to improve the heart rate recovery
status. (Press the RECOVERY button again to return the main display.)
GENERAL INFORMATION:
1. Start pedaling or press any button to start Console.
2. The Console will shut down after 4 minutes of no activity. Note: Values will be reset to zero.
3. To Reset Console press and hold the ENTER/RESET button for 5 seconds.
Note: The values calculated or measured by the console are for exercise purposes only, not for
medical purposes.
4. Console uses two standard AA batteries. To install, remove battery cover located behind con-
sole. Replace battery cover when finished installing new batteries.
GETTING STARTED:
Quick Start:
Turn console on by pedaling or pressing any button. To begin working out without setting any
targets, start pedaling. The time will begin to count up.
Target Workout:
Turn console on by pedaling or pressing any button. Using the "Up" and "Down" buttons,
select the setting you wish to set first (Time, Cal, Pulse), press "Enter/Reset" when ready to
edit. The current setting will flash. Use the "Up" and "Down" buttons until desired setting
is reached. Press "Enter/Reset" move to next setting. When all desired settings have been
entered, start pedaling to begin workout.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
Console Overview
FITNESS TEST: (Pulse Recovery Feature)
The fitness test compares your pulse rate before and after training. You will notice that your
fitness will improve with regular exercise.
Press the PULSE RECOVERY button immediately after your workout. Grasp the Pulse Grips.
Timer will count down from 60 seconds. Your personal fitness will display on the screen.
(F1-F6)
F1 = Excellent
F2 = Good
F3 = Fair
F4 = Below Average
F5 = Poor
F6 = Very Poor
13
Download from Www.Somanuals.com. All Manuals Search And Download.
Monitoring Your Heart Rate
Monitoring Your Heart Rate
To obtain the greatest cardiovascular benefits from your exercise workout, it is important to
work within your target heart rate zone. The American Heart Association (AHA) defines this tar-
get as 60%-75% percent of your maximum heart rate.
Your maximum heart rate may be roughly calculated by subtracting your age from 220. Your
maximum heart rate and aerobic capacity naturally decreases as you age. This may vary from
one person to another, but use this number to find your approximate effective target zone. For
example, the maximum heart rate for an average 40 year-old is 180 bpm. The target heart
rate zone is 60%-75% of 180 or 108-135 bpm. See Fitness Safety below.
Before beginning your workout, check your normal resting heart rate. Place your fingers lightly
against your neck, or against your wrist over the main artery. After finding your pulse, count
the number of beats in 10 seconds. Multiply the number of beats by six to determine your
pulse rate per minute. We recommend taking your heart rate at these times; at rest, after
warming up, during your workout and two minutes into your cool down, to accurately track
your progress as it relates to better fitness.
During your first several months of exercising, the AHA recommends aiming for the lower part
of the target heart rate zone-60%, then gradually progressing up to 75%.
According to the AHA, exercising above 75% of your maximum heart rate may be too strenu-
ous unless you are in top physical condition. Exercising below 60% of your maximum will result
in minimal cardiovascular conditioning.
Check your pulse recovery rate – If your pulse is over 100 bpm five minutes after you stop
exercising, or if it’s higher than normal the morning after exercising, your exertion may have
been too strenuous for your current fitness level. Rest and reduce the intensity next time.
Fitness Safety The target heart rate chart indicates average rate zones for different ages. A
variety of different factors (including medication, emotional state, temperature and other condi-
tions) can affect the target heart rate zone that is best for you. Your physician or health care
professional can help you determine the exercise intensity that is appropriate for your age and
condition.
(MHR) = Maximum Heart Rate
(THR) = Target Heart Rate
220 - age = maximum heart rate (MHZ)
MHZ x .60 = 60% of your maximum heart rate.
MHZ x .75 = 75% of your maximum heart rate.
For example, if you are 30 years old, your calculations will be as
follows:
220 - 30 = 190
190 x .60 = 114 (low end or 60% of MHZ)
190 x .75 = 142 (high end or 75% of MHZ)
30 year-old (THR) Target Heart Rate would be 114-142
See Heart Rate Table (on next page) for additional calculations.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
Monitoring Your Heart Rate
TARGET HEART RATE ZONE
200
100%
195
190
185
180
175
Serious
athletic
170
165
160
training range
155
132
85%
170
150
166
146
162
143
157
139
153
135
Cardiovascular
conditioning
range
149
131
105
145
128
102
140
124
99
136
120
96
75%
Fat burning
range
116
93
120
60%
117
114
111
108
20 25 30 35
40 45 50 55 60 65
AGE
15
Download from Www.Somanuals.com. All Manuals Search And Download.
Moving Instructions
CAUTION! TO REDUCE THE POSSIBILITY OF INJURY WHILE LIFTING, BEND YOUR LEGS AND
KEEP YOUR BACK STRAIGHT. AS YOU LEAN THE UNIT, LIFT USING YOUR LEGS, NOT YOUR
BACK.
First, kneel down and grasp the rear support tube with both hands as shown in Figure 1.
Next, with a firm grasp on rear support tube stand up bringing the rear of the bike up in the
air and tilt the unit until it rolls freely on the transport wheels. Using extreme caution, move
the unit to the desired location as shown in Figure 2. Do not attempt to move the unit over an
uneven or rough surface.
Note: The unit you purchased may not be identical to the one pictured.
Note: This unit may not be identical to your unit.
16
Download from Www.Somanuals.com. All Manuals Search And Download.
Warm Up Exercises
EXERCISE GUIDELINES
WARNING! Before beginning this or any exercise program, you should consult your physi-
cian. This is especially important for individuals over the age of 35 or individuals with pre-exist-
ing health problems.
Warming up prepares the body for the exercise by increasing circulation, supplying more oxy-
gen to the muscles and raising body temperature. Begin each workout with 5 to 10 minutes of
stretching and light exercise to warm up. The photos on this page show several forms of basic
stretching you may perform before your workouts. In order to achieve an adequate warm-up,
perform each stretch three times.
TOE TOUCH STRETCH
Stand bending your knees slightly and slowly bend forward from
your hips. Allow your back and shoulders to relax as you reach
down toward your toes as far as possible. Hold for 15 counts,
then relax. This will stretch your hamstrings, back of knees, and
back.
HAMSTRING STRETCH
Sit with one leg extended. Bring the sole of the opposite foot
toward you and rest it against the inner thigh of your extended
leg. Reach toward your toes as far as possible. Hold for 15
counts, then relax. This will stretch your hamstrings, lower back,
and groin.
CALF/ACHILLES STRETCH
With one leg in front of the other, reach forward and place your
hands against a wall. Keep your back leg straight and your back
foot flat on the floor. Bend your front leg, lean forward and move
your hips toward the wall. Hold for 15 counts, then relax. To
cause further stretching of the Achilles tendon, bend your back
leg as well. This will stretch your calves, Achilles tendons, and
ankles.
QUADRICEPS STRETCH
With one hand against a wall for balance, reach back and grasp
one foot with your other hand. Bring your heel as close to your
buttocks as possible. Hold for 15 counts, then relax. This will
stretch your quadriceps and hip muscles.
INNER THIGH STRETCH (Image not Shown)
Sit with the soles of your feet together and your knees outward.
Pull your feet toward your groin area as far as possible. Hold for
15 counts, then relax. This will stretch your quadriceps and hip
muscles.
17
Download from Www.Somanuals.com. All Manuals Search And Download.
Exploded View
18
Download from Www.Somanuals.com. All Manuals Search And Download.
Parts List
HT440EL Parts List Rev A
Ref #
2
3
Part #
Description
Qty
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
2
1
3
1
1
2
4
1
1
5
8
1
1
2
2
1
4
8
4
6
2
8
2
4
2
2
2
6
Ref #
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
#
Part #
Description
Qty
6
8
4
6
7
2
4
4
2
1
2
4
4
2
2
2
2
4
4
4
4
1
1
1
2
2
2
1
1
1
2
2
1
1
1
1
4
1
3
2
2
2
2
2
2
1
2
1
323-00529 FRAME, REAR HT440EL
302-00497 NYLOCK NUT 1/2"
302-00723 WASHER 13X26X2
302-00695 HEX HEAD BOLT, 3/8" X 45
302-00506 WASHER 10X26X2.0(MM)
302-00519 NYLOCK NUT 3/8"
323-00530 POST, UPRIGHT 50.8X1.8X750 HT440EL
323-00531 TUBE, PEDAL LEFT 27X40X1.5X950 HT440EL
323-00532 TUBE, PEDAL RIGHT 27X40X1.5X950 HT440EL
306-00794 PEDAL, LEFT HT440EL
4a
4b
5a
5b
6a
6b
7a
7b
8
306-00795 PEDAL, RIGHT HT440EL
302-01116 HEX HEAD BOLT, 3/8"*50
331-00109 BEARING, CHROME 15.8
331-00110 BEARING, CHROME 10X15X7
319-00375 U-JOINT, PEDAL 75X40X3.0 TUBE HT440EL
323-00537 FRAME, FRONT 60X1.5X500
306-00797 CAP. PLASTIC HT440EL
302-01465 SPACER, SMALL 12.7X8.5X7
331-00111 BEARING, ABECS 608ZZ
323-00538 TUBE, RAIL HT440EL-#58
302-01466 SPACEER, BIG 12.7X8.5X9.8
306-00799 ROLL, PLASTIC HT440EL
306-00800 ROLL, PLASTIC HT440EL
302-01121 CARRIAGE BOLT M6*35 TRI-5.3E
302-00529 WASHER 6X13X1.0(MM)
302-01467 CAP, NUT M6
323-00533 HANDLEBAR, LOWER LEFT HT440EL
323-00534 HANDLEBAR, LOWER RIGHT HT440EL
323-00535 HANDLEBAR, UPPER LEFT 28.6X2.0X700 HT440
323-00536 HANDLEBAR, UPPER RIGHT 28.6X2.0X700
304-00025 BELT, 400J6
9
307-00147 CONSOLE, HT440
10
11
12
13
311-00018 FLYWHEEL (CRANK PULLEY) ALL INNOFIT EXCE
331-00056 OUTSIDE BEARING COLLAR
302-01463 BIG WASHER, HT440EL
330-00097 PULLEY AXLE, HT440EL
14a 311-00095 CRANK, LEFT HT440EL
14b 311-00096 CRANK, RIGHT HT440EL
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
302-00561 NYLOCK NUT M10
302-01436 C-CLIP, S-17
331-00009 BEARING 6003Z, BRONZE
311-00018 FLYWHEEL (CRANK PULLEY) ALL INNOFIT EXCE
331-00057 BEARING 6000ZZ
302-00569 BOLT M8X15
310-00220 KNOB, TENSION HT440EL
302-01468 BOLT, TENSION KNOB
319-00377 CABLE, TENSION 1550 HT440EL
302-01469 BOLT, COMPUTER
302-01137 FLYWHEEL SPACER 10*13*4MM CM700
302-00684 BC NUT 3/8"
302-01464 ZIP, (#22) HT440EL
302-00709 WASHER 10X19X1.5
302-00502 NUT 3/8"
330-00096 AXLE, FLYWHEEL 9.98X126
331-00054 GREASED BEARING 8x13x6
302-00500 NYLOCK NUT M8
306-00802 SPACER, HT440EL
302-01470 BOLT, HT440EL (#71)
313-00395 WIRE, EXTENSION 900MM
313-00404 WIRE, SENSOR 1350MM
311-00097 ARM, IDLER HT440EL
310-00222 GRIP, UPPER FOAM 28.6X3.0X350
306-00803 CAP, HANDLEBAR 28.6 HT440EL
305-00218 COVER, PLASTIC LEFT HT440EL
306-00801 SPACER, IDLER HT440EL
305-00219 COVER, PLASTIC RIGHT HT440EL
310-00223 IDLER, HT440EL
302-00029 SPRING FOR MAGNETIC PLATE CM530/ET530D
319-00078 MAGNETIC PLATE
302-00553 HEX HEAD BOLT M8X60MM
302-00515 NUT M8
302-01145 MAGNET, 12.5 * 5
302-01442 NUT CAP, M8 HT440
302-00588 BOLT M4X16
302-00490 ARC WASHER 8X19X1.5 (MM)
302-00658 CARRIAGE SCREW M8X70
302-00699 WASHER, 8X19X1.5, 120E
302-01104 HEX HEAD BOLT M8*40
331-00108 BEARING, CHROME 12.7
319-00374 U-JOINT, 26*21*2.5
302-01107 HEX HEAD BOLT M8*55 TRI-5.3E
306-00796 CAP, LOWER HANDLEBAR HT440EL
313-00403 WIRE, PULSE 500MM
302-00705 HEX HEAD BOLT 3/8 * 25
302-01132 SCREW M4*44 TRI-5.3E
306-00210 WHEEL CAP U/R CM520/530/580 DCV5.2
306-00798 PLUG, WIRE 12.5 HT440EL
310-00221 FOAM, 31.8X5X60 L HT440EL
313-00405 WIRE, PULSE 1 HT440EL
313-00406 WIRE, PULSE 2 HT440EL
302-01127 SPACER 12.7*37.1 TRI-5.3E
302-01471 SPRING, IDLER HT440EL
313-00401 HAND PULSE, PE18 HT440
302-01462 BOLT PACK, HT440EL
319-00376 TUBE, JOINT 21.3X21.3X2.0X475 HT440EL
306-00797 CAP. PLASTIC HT440EL
1ꢀ
Download from Www.Somanuals.com. All Manuals Search And Download.
Warranty Information
Residential and Personal Use Limited Warranty
PLEASE READ THESE WARRANTY TERMS AND CONDITIONS FULLY AND CAREFULLY BEFORE USING YOUR KEYS FITNESS EQUIPMENT. BY
USING THE EQUIPMENT, YOU ARE CONSENTING TO BE BOUND BY THE FOLLOWING TERMS AND CONDITIONS.
Frame: Lifetime
Limited Warranty
Electronics and *Parts: 1 yrs
Missing/Cosmetic Parts: 30 Days
The warranty covering the replacement Product shall expire on the
This Limited Warranty applies in the United States and Canada to
Products manufactured or distributed by Keys Fitness Products, L.P.
under the Keys Fitness (“Keys”) brand name (as used herein, the
“Product” or “Products”). The warranty period to the original
purchaser is listed above, and commences on the date of original
purchase of the product, unless otherwise authorized by Keys. Keys
warrants that the Product purchased from Keys or from an
authorized Keys Fitness reseller “dealer” (for residential or personal
use only, unless otherwise authorized by Keys in writing), is free
from defects in Materials and Workmanship relevant to the
functionality of the Product at initial startup, under normal use, and
during the applicable warranty period, unless otherwise determined
by Keys.
date the original warranty for the replaced Product would have expired,
unless otherwise determined by Keys. Note that a non-defective
Product may not be eligible for return or replacement after 30 days from
date of purchase.
Conditions and Restrictions
This warranty DOES NOT (A) cover shipping and handling charges,
export taxes, custom duties and taxes, or any other charges associated
with transportation of the parts or Product, beyond the initial courtesy
period of 60 days from original date of purchase of the Product; (B)
extend to Products not purchased from Keys or from an authorized
Keys reseller; (C) extend to Products purchased from online auction
sites; (D) cover any extended, additional, or third party warranties if
not offered exclusively by Keys in writing; (E) cover Products installed
at fee based facilities/commercial environments (gyms, homes used as
wellness centers, etc.); (F) cover Products installed in light institutional
environments (non fee-based facilities with total Product use time not
exceeding 5 hours daily, to include for example, and not be way of
limitation, fire houses, police departments, rehab centers, hospitals,
clinics, apartment complexes, club houses, etc.); (G) cover service calls
to correct installation, perform maintenance, or instruct owners on how
to use the equipment; or (H) cover a Product on which the serial
number has been purposefully or accidentally defaced or removed and
there is no proof of purchase available (if serial number is applicable),
unless authorized by Keys in writing or otherwise stated on this
warranty.
This warranty excludes expendable parts if primary cause for
warranty claim is wear. Expendable parts pertain to components on
the Product that are prone to normal wear and tear. These items
vary by Product, and can include (but not limited to) hand grips, skid
pads, pedals, pedal straps, poly-v belts, console overlays, toggle
switch/button overlays, (luster free or dull) ekg plates, decals, and
any other items that are not essential to the operation of the Product,
unless otherwise determined by Keys.
This warranty extends only to you, the original purchaser. It is not
transferable to anyone who subsequently purchases (or receives as a
gift) the Product from you. Your sales receipt, showing the
date/place of purchase and serial number (if applicable) of the
Product, is your proof of purchase, and may be required by Keys any
time a warranty parts (or service) claim is made or if no warranty
record exists for the product.
This Limited Warranty becomes void for Products that have been
damaged or rendered defective as a result of (a) accident, misuse, or
abuse (including but not limited to exceeding the Keys listed, maximum
weight limit); (b) use of parts not manufactured or sold by Keys; (c)
modification of the Product; (d) normal wear and tear; (e) operation on
incorrect power supplies; (f) ***failure to perform (or performing
improper) maintenance; (g) service by anyone other than Keys, or an
authorized Keys warranty service provider; (h) floods, fires,
earthquakes, lightning strikes, power surges, and other unavoidable
acts of nature; (j) residential mis-wires; or (k) incorrect setup,
installation, or assembly. Should any Product (submitted for warranty
parts replacement) be found ineligible under the terms outlined on this
warranty, an estimate for parts purchase (if available) can be furnished
at your request.
Exclusive Remedies
During the warranty period listed above, Keys will repair a Product
by correcting any minor issues (either by phone or online support)
that might be causing the Product failure. Should a technical service
and support representative be unable to correct the issue, Keys
may replace the parts (with new parts or at the option of Keys, with
serviceable used parts, that are equivalent to new parts in
performance) that become defective, malfunction, or otherwise fail
to conform to this Limited Warranty under normal use.
Replacement parts shall be warranted for 30 days from the shipment
reception date or through the end of the ‘replaced’ part warranty
period, whichever is longer. Any replacement parts, required past
the warranty period listed above, shall be subject to purchase at
retail price, plus any added shipping and handling charges associated
to the delivery of the part. Note that replacement parts may be
available only through the lifetime (as defined) of the Product. In
conforming to this warranty, Keys (as the manufacturer) reserves
the right to change manufacturers or vendors of any part to cover
the existing warranty.
*Parts is herein defined exclusively, for all intents and purposes, and
pertaining to this Limited Manufacturer Warranty, as components or
Materials essential to the functionality of the Product.
**Lifetime of a Product, is herein defined exclusively, for all intents and
purposes, and pertaining to this Limited Manufacturer Warranty, as the time
period 7 years beyond the end of production cycle of a Product in question.
*** Includes proper lubrication of the running deck and walk belt area, as
indicated in the owner’s manual.
Keys may also provide service (if deemed necessary and if applicable)
at no charge to you during (and not to exceed) the service warranty
period listed above, in an attempt to repair the Product. Should the
Product require service at your request or out of the limited warranty
period, Keys can furnish contact information for local (to your area)
Keys authorized service providers. Service quotes, costs, and
scheduling will be strictly dependent on service provider rates and
mutual (consumer/provider) service agreements. Keys is not
responsible for any service repair costs accrued through the use of
authorized Keys service providers at your request or out of the
limited warranty period (without written consent from Keys), beyond
the limitations outlined on this warranty.
Disclaimer and Release
EXCEPT AS EXPRESSLY SET FORTH IN THIS WARRANTY, KEYS MAKES NO
OTHER WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING ANY IMPLIED
WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR
PURPOSE. KEYS EXPRESSLY DISCLAIMS ALL WARRANTIES NOT STATED IN
THIS LIMITED WARRANTY. ANY IMPLIED WARRANTIES THAT MAY BE
IMPOSED BY LAW ARE LIMITED TO THE TERMS OF THIS LIMITED WARRANTY.
NEITHER KEYS NOR ANY OF ITS AFFILIATES SHALL BE RESPONSIBLE FOR
INCIDENTAL OR CONSEQUENTIAL DAMAGES. SOME STATES DO NOT ALLOW
LIMITATIONS ON IMPLIED WARRANTIES OR THE EXCLUSION OR
LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE ABOVE
LIMITATIONS OR EXCLUSIONS MAY NOT APPLY TO YOU. THIS LIMITED
WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE
OTHER RIGHTS THAT MAY VARY FROM STATE TO STATE. THIS IS THE ONLY
EXPRESS WARRANTY APPLICABLE TO KEYS-BRANDED PRODUCTS. KEYS
NEITHER ASSUMES NOR AUTHORIZES ANYONE TO ASSUME FOR IT ANY
OTHER EXPRESS WARRANTY.
Replacements and Returns
If after a reasonable number of attempts, a defect has not been
repaired (or the Product is deemed non-repairable by Keys technical
service and support staff), Keys, based on a case by case review,
may opt to replace the Product, or recommend an alternate
resolution, such as a warranty buy-out (Product cost, subject to
deduction of a reasonable charge for usage) or a credit. Keys, as a
manufacturer, reserves the right to replace the Product with a
Factory-Reconditioned Product that meets or exceed standards
comparable to those of the replaced Product.
20
Download from Www.Somanuals.com. All Manuals Search And Download.
Customer Service
1.888.340.0482
Keys Fitness
400ꢀ Distribution Drive
Suite 250
Garland, TX 75041
Download from Www.Somanuals.com. All Manuals Search And Download.
|