NOTE:
Please read all instructions
carefully before using this
product
Table of Contents
Safety Notice
Hardware Pack
Assembly Instruction
Parts List
CLUB REVOLUTION
CYCLE
H2502C
Warranty
Ordering Parts
Model
H2502C
Retain This
Manual for
Reference
110624
IMPEX® INC.
ASSEMBLY &
OWNER'S
2801 S. Towne Ave, Pomona, CA 91766
Tel: (800) 999-8899 Fax: (626) 961-9966
MANUAL
Download from Www.Somanuals.com. All Manuals Search And Download.
IMPORTANT SAFETY NOTICE
PRECAUTIONS
This exercise bike is built for optimum safety. However, certain precautions apply
whenever you operate a piece of exercise equipment. Be sure to read the entire manual
before you assemble or operate your bike. In particular, note the following safety
precautions:
1. Keep children and pets away from the exercise bike at all times. DO NOT leave
children unattended in the same room with the bike.
2. Only one person at a time should use the bike.
3. If the user experiences dizziness, nausea, chest pain, or any other abnormal symptoms,
STOP the workout at once. CONSULT A PHYSICIAN IMMEDIATELY.
4. Position the bike on a clear, leveled surface. DO NOT use the bike near water or
outdoors.
5. Keep hands away from all moving parts.
6. Always wear appropriate workout clothing when exercising. DO NOT wear robes or
other clothing that could become caught in the bike. Running or aerobic shoes are also
required when using the bike.
7. Use the bike only for its intended use as described in this manual. DO NOT use
attachments not recommended by the manufacturer.
8. Do not place any sharp object around the bike.
9. Disabled person should not use the bike without a qualified person or physician in
attendance.
10. Before using the bike to exercise, always do stretching exercises to properly warm up.
11. Never operate the bike if it is not functioning properly.
12. Read all warnings posted on the exercise bike.
13. Inspect the exercise bike for worn or loose component prior to use. Tighten/replace any
loose or wore components prior to use.
14. Care should be taken in mounting or dismounting the exercise bike.
15. This exercise bike is for consumer and home use only.
WARNING: BEFORE BEGINNING ANY EXERCISE PROGRAM, CONSULT YOUR
PHYSICIAN. THIS IS ESPECIALLY IMPORTANT FOR INDIVIDUALS OVER THE AGE
OF 35 OR PERSONS WITH PRE-EXISTING HEALTH PROBLEMS. READ ALL
INSTRUCTIONS BEFORE USING ANY FITNESS EQUIPMENT. IMPEX INC. ASSUMES
NO RESPONSIBILITY FOR PERSONAL INJURY OR PROPERTY DAMAGE
SUSTAINED BY OR THROUGH THE USE OF THIS PRODUCT.
SAVE THESE INSTRUCTIONS.
© IMPEX INC.
2
Download from Www.Somanuals.com. All Manuals Search And Download.
WARNING LABEL PLACEMENT
The Warning Labels and Caution Label shown here have been placed on the Rear Stabilizer, Main Frame.
If the labels are missing or illegible, please call customer service at 1-800-999-8899 for replacement. Apply the
labels in location shown.
© IMPEX INC.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
HARDWARE PACK
NOTE: The following parts are not drawn to scale. Please use your own ruler to measure the size.
No. Description
Identifier
Q’ty
8
4
Lever Knob
9
4
4
4
4
4
4
1
M8 x 5/8” Allen Bolt
16
17
18
19
20
M8 x 2 7/8” Carriage Bolt
Ø 7/8” Curved Washer
M8 Acorn Nut
Ø 5/8” x Ø 3/8” Flat Washer
Ø ½” x Ø 3/8” Lock Washer
#6 Allen Wrench
Crossing Wrench
1
© IMPEX INC.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
COMPONENTS FOR ASSEMBLY
© IMPEX INC.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
ASSEMBLY INSTRUCTION
Tools Required For Assembling the Bike: One Crossing Wrench and Allen Wrench,
provided by manufacturer.
NOTE: It is strongly recommended that two or more people assemble this bike to
avoid possible injury.
STEP-1
A.) Do not tighten Bolts until instructed to do so.
B.) Thread two Level Adjustment Knobs (#8) each onto the Front & Rear Stabilizer (#2 & #3).
C.) Attach the Front Stabilizer (#2) to the Main Frame (#1). Secure it with two M8 x 2 ¾” Carriage Bolts
(#16), two Ø 5/8” Curved Washers (#17), and two M8 Acorn Nuts (#18).
D.) Attach the Rear Stabilizer (#3) to the Main Frame (#1). Secure it with two M8 x 2 ¾” Carriage Bolts
(#16), two Ø 5/8” Curved Washers (#17), and two M8 Acorn Nuts (#18).
E.) Securely tighten all Bolts.
F.) Adjust the Level Adjustment Knob to stabilize the Bike on floor.
G.) Thread the Right Pedal (#15) clockwise onto the right Crank (#38).
H.) Thread the Left Pedal (#14) counterclockwise onto the left Crank (#38)
© IMPEX INC.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
STEP 2
A.) Insert the Handle Post (#6) into the front opening on Main Frame (#1). Use the Lock Knob (#11) to
hold the Handle Post at selected height.
B.) Attach the Handle (#7) to the Handle. Secure them together with four M8 x 5/8” Allen Bolts (#9),
four Ø 5/8” Lock Washers (#20), and four Ø 5/8” Flat Washers (#19).
C.) Insert the Seat Post (#4) into the opening on Main Frame. Use the Lock Knob (#11) to hold the
Seat Post at selected height.
D.) Flip over the Seat Pad (#12). Insert the tube of the Seat Support into the open slot and securely
fasten the two nuts to secure the Seat Pad to the tube.
E.) Insert the Seat Support (#5) through the open slot on Seat Post. Use the Lock Knob (#11) to hold
the Seat at selected position.
© IMPEX INC.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
EXPLODED DIAGRAM
© IMPEX INC.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS LIST
PART
NO.
DESCRIPTION
SPEC.
QUANTITY
1
2
3
4
5
6
7
8
Main Frame
Front Stabilizer
Rear Stabilizer
Vertical Seat Post
Seat Support
Handle Post
Handle
Level Adjustment Knob
Allen Bolt
Tension Adjustment Knob
Lock Knob
1
1
1
1
1
1
1
4
4
1
3
1
1
1
1
4
4
4
4
4
2
2
4
4
1
2
1
1
1
1
2
4
2
2
2
1
1
1
1
2
9
M8 x 5/8”
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
Seat Pad
Brake Handle
Left Pedal
Right Pedal
Carriage Bolt
Curved Washer
Acorn Nut
Flat Washer
Lock Washer
Handle Grip
Round End Cap
Rectangle End Cap
Sleeve
M8 x 2 7/8”
Ø 7/8”
M8
Ø 5/8” x Ø 3/8”
Ø ½” x Ø 3/8”
Ø 1”
7/8” x 2”
Bottle Rack
Philips Screw
Brake Bracket
Brake Pad
M4 x ¾”
Flywheel
Flywheel Axle
Flywheel Ball Bearing
Stabilizer End Cap
Aircraft Nut
Roller Wheel
Allen Bolt
Shroud
Chain Belt
Crank
Crank Axle
6001
M8
M8 x 1 5/8”
40
Crank Ball Bearing
6203
© IMPEX INC.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
CARE, MAINTENANCE AND STORAGE
1. Inspect and tighten all parts each time you use the bike. Replace any worn parts immediately.
2. The bike can be cleaned using a damp cloth and mild non-abrasive detergent. Do not use
solvents.
3. Store the bike IN-DOOR. Excess moisture and water would cause rust on the frame.
4. The Bike shall be placed at least 24 inches away from the wall or/and any other object such as
furniture to provide safe access to and passage around the bike.
5. To avoid possible injury, the help of two or more people are needed when moving the bike
around.
6. Disposal Instructions – The equipment can be safely disassembled and disposed without
unreasonable hazards. Call your local recycle agency regarding details of recycling.
7. The maximum user weight is 300 lbs.
8. Assembled Dimension: 51” x 20” x 41”
OPERATING NOTES
ADJUSTMENT
1. Use the Tension Adjustment Knob (#10) to adjust the resistance for exercise.
2. The seat height adjustment is in approximately 1” increment.
*The seat height can be adjusted for 6 different height ranges from 36” to 41”.
3. Loosen and pull out the Lock Knob (#11). Slide the Seat/ Seat Post/ Handle bar to the
desired position on the Seat Post, Seat Support, Handle Post, and then release the Lock
Knob and securely fasten the Knob to lock the Seat Post, Seat Support, and Handle Post.
Stopping the Exercise
1. Press down on the Brake Handle to stop the fly wheel. ONLY when the flywheel
has stopped, will it be safe to remove feet from pedals.\
2. DO NOT stop pedaling: doing so could result in serious injury.
3. DO NOT attempt to stop the Fly Wheel by hands, feet or any other device not
indicated in this instruction.
TRANSPORT
The Bike has a pair Roller Wheels on Front Stabilizer.
To move, carefully tilt the cycle forward, and then roll.
© IMPEX INC.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
EXERCISE GUIDELINES
Using your Bike will provide you with several benefits, it will improve your physical fitness, tone
muscle and in conjunction with calorie controlled diet help you lose weight.
1. The Warm Up Phase
This stage helps get the blood flowing around the body and the muscles working properly. It will
also reduce the risk of cramp and muscle injury. It is advisable to do a few stretching exercises as
shown below. Each stretch should be held for approximately 30 seconds, do not force or jerk your
muscles into a stretch - if it hurts, STOP.
INNER THIGH
FORWARD
BENDS
CALF / ACHILLES
SIDE BENDS
OUTER THIGH
2. The Exercise Phase
This is the stage where you put the effort in. After regular use, the muscles in your legs will become
more flexible. Work to your but it is very important to maintain a steady tempo throughout. The
rate of work should be sufficient to raise your heartbeat into the target zone shown on the graph
below.
This stage should last for a minimum of 12 minutes though most people start at about 15-20
minutes
© IMPEX INC.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
3. The Cool Down Phase
This stage is to let your Cardio-vascular System and muscles wind down. This is a repeat of the
warm up exercise e.g. reduce your tempo, continue for approximately 5 minutes. The stretching
exercises should now be repeated, again remembering not to force or jerk your muscles into the
stretch.
As you get fitter you may need to train longer and harder. It is advisable to train at least three times
a week, and if possible space your workouts evenly throughout the week.
MUSCLE TONING
To tone muscle while on your MAGNETIC BIKE you will need to have the resistance set quite
high. This will put more strain on our leg muscles and may mean you cannot train for as long as
you would like. If you are also trying to improve your fitness you need to alter your training
program. You should train as normal during the warm up and cool down phases, but towards the
end of the exercise phase you should increase resistance making your legs work harder. You will
have to reduce your speed to keep your heart rate in the target zone.
WEIGHT LOSS
The important factor here is the amount of effort you put in. The harder and longer you work
the more calories you will burn. Effectively this is the same as if you were training to
improve your fitness, the difference is the goal.
© IMPEX INC.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
IMPEX® INC.
LIMITED WARRANTY
IMPEX Inc. ("IMPEX®") warrants this product to be free from defects in workmanship and material, under normal use
and service conditions, for a period of two years on the Frame from the date of purchase. This warranty extends only
to the original purchaser. IMPEX's obligation under this Warranty is limited to replacing or repairing, at IMPEX's
option.
All returns must be pre-authorized by IMPEX. Pre-authorization may be obtained by calling IMPEX Customer Service
Department at 1-800-999-8899. All freights for products return to IMPEX must be prepaid by the customer. This
warranty does not extend to any product or damage to a product caused by or attributable to freight damage, abuse,
misuse, improper or abnormal usage or repairs not provided by an IMPEX authorized service center or for products
used for commercial or rental purposes. No other warranty beyond that specifically set forth above is authorized by
IMPEX.
IMPEX is not responsible or liable for indirect, special or consequential damages arising out of or in connection with
the use or performance of the product or other damages with respect to any economic loss, loss of property, loss of
revenues or profits, loss of enjoyments or use, costs of removal, installation or other consequential damages or
whatsoever natures. Some states do not allow the exclusion or limitation of incidental or consequential damages.
Accordingly, the above limitation may not apply to you.
The warranty extended hereunder is in lieu of any and all other warranties and any implied warranties of
merchantability or fitness for a particular purpose is limited in its scope and duration to the terms set forth herein.
Some states do not allow limitations on how long an implied warranty lasts. Accordingly, the above limitation may not
apply to you.
This warranty gives you specific legal right.
You may also have other rights which vary from state to state.
IMPEX® INC.
2801 S. Towne Ave.
Pomona, CA 91766
ORDERING REPLACEMENT PARTS
Replacement parts can be ordered by calling our Customer Service Department toll-free at 1-800-999-8899 during our
regular business hours: Monday through Friday, 9 am until 5 pm Pacific standard time.
When ordering replacement part, always give the following information.
1.
2.
3.
4.
Model
Description of Parts
Part Number
Date of Purchase
© IMPEX INC.
13
Download from Www.Somanuals.com. All Manuals Search And Download.
© IMPEX INC.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
|