Instructions for Installation and Use
60cm slot-in double oven Dual Fuel cooker
EG94
To the Installer:
Before installation, fill in the product details on the back cover of this book.
The information can be found on the rating plate.
To the User:
You must read the instructions prior to installing and using the appliance and
then retain them for future reference.
Download from Www.Somanuals.com. All Manuals Search And Download.
Introduction
The cooker must be installed in accordance with the regulations in force and only used in
a well ventilated space.
To help you make the best use of your cooker, PLEASE READ THIS BOOKLET CAREFULLY.
Your new cooker is guaranteed and will give lasting service. The guarantee is only
applicable if the cooker has been installed in accordance with the Installation Instructions.
The cooker is designed specifically for domestic use and responsibility will not be
accepted for use in any other installation.
When first using the cooker ensure that the room is well ventilated (e.g. open a window or
use an extractor fan) and that persons who may be sensitive to the odour avoid any
fumes.
It is suggested that any pets be removed from the room until the smell has ceased. This
odour is due to any temporary finish and also any moisture absorbed by the insulation.
Our policy is one of continual improvement in design and development, therefore strict
accuracy of illustrations and descriptions cannot be guaranteed.
This appliance conforms to the following EEC Directives:
Gas Appliances
90/396/EEC
Low Voltage Equipment
73/23/EEC
93/68/EEC
Electromagnetic Compatibility
89/336/EEC
92/31/EEC
93/68/EEC
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Safety Information
PLEASE READ THE PRECAUTIONS BELOW BEFORE USING YOUR APPLIANCE.
Always
G Always understand the controls prior to using the appliance.
G Always turn controls off when not in use.
G Always stand back when opening an oven door to allow any build up of steam or heat
to disperse.
G Always use dry good quality oven gloves when removing items from the ovens/grill.
G Always take care when removing items from the top oven/grill when the main oven is on,
as the contents may be hot.
G Always keep the oven/grill door closed when the appliance is not in use.
G Always place pans centrally over the hotplate burners and position them so that the
handles cannot accidentally be caught or knocked or become heated by other burners.
G Always keep the cooker clean, as a build up of grease or fat from cooking can cause a
fire.
G Always allow the cooker to cool before cleaning.
G Always follow the basic principles of food handling and hygiene to prevent the possibility
of bacterial growth.
G Always keep ventilation slots clear of obstructions.
G Always turn off the electricity supply before cleaning or replacing the oven lamp.
G Always refer servicing to CORGI registered appliance service engineers.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Safety Information
Never
G Never leave children unsupervised where the cooker is installed as all surfaces will be
hot during and after its use.
G Never allow anyone to sit on or stand on any part of the cooker.
G
Never store items above the cooker that children may attempt to reach.
G Never heat up unopened food containers as pressure can build up causing the
container to burst.
G Never store chemicals, food stuffs or pressurised containers in or on the appliance,
or in cabinets immediately above or next to the appliance.
G Never place flammable or plastic items on or near the hotplates.
G Never fill a deep fat frying pan more than 1/3 full of oil, and never use a lid.
DO NOT LEAVE DEEP FAT FRYING PANS UNATTENDED WHILE COOKING.
G Never use proprietary spillage collectors on the hotplate.
G Never use the appliance as a room heater.
G Never dry clothes or place any items over or near to the hotplate or oven/grill doors.
G Never install the appliance next to curtains or other soft furnishings.
G Never wear garments with long flowing sleeves whilst cooking.
NOTE: The use of a gas cooking appliance results in the production of heat and moisture
in the room in which it is installed. Always ensure that the kitchen is well ventilated; keep
natural ventilation holes open or install a mechanical ventilation device (mechanical
extractor hood).
In particular when using more than one hotplate burner, open a window if a mechanical
ventilation device is not operating.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Features
WARNING: DO NOT touch the oven doors when the oven is in use, as these
areas can become hot.
Gas Burner
Gas Burner
Gas Burner
Gas Wok Burner
Timer
Control panel
Ignition button
Solarplus Grill
Oven Light
Top Oven wire
Grill pan and
food support
work shelf support
Top Oven/Grill
rod shelf
‘Stay Clean’ liners
Removable
Inner door glass
Top Oven door
Main Oven
door
Oven light
Meat pan
and food
support
Telescopic meat
pan runners
Door Switch
Main Oven wire
work shelf support
Oven
fan
‘Stay Clean’ liners
Main oven
rod shelf
Model number &
Serial number label
Main oven seal
split at these corners
Removable
Inner door glass
NOTE: To keep the controls cool when the appliance is used, a flow of air may be blown
from beneath the control panel. If the appliance is still warm, this cooling fan will run
on when all controls have been turned off. This is normal and is not a fault.
The fan will stop once the appliance has cooled.
NOTE: Children should not be allowed to play with the appliance or tamper with the controls.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
The controls
Switch on the electricity supply to the cooker at the Cooker Control Unit.
Main
Ignition
Button
Top
Oven
Control
Oven
Control
Grill
Control
Gas Hob Controls
Timer
Gas Hob Controls
Press the ignition button and then push in and turn the control
knob of the chosen burner anti-clockwise to the large flame symbol.
Continue to press the ignition button until the sparks light the gas.
Turn the control knob anti-clockwise to reduce the heat input.
Only turn the control between the large flame symbol and the small
flame symbol when adjusting the setting.
To turn off, turn the control knob fully clockwise to the symbol ‘O’,
its off position.
Main Oven Light
The main oven light can be switched on, when the oven is not in use,
by pressing the oven light button on the display. The oven light will
also operate whenever the main oven door is opened.
NOTE: The oven light can be switched off when the door is opened
by pressing the oven light button on the display, or by
closing the door.
Cooling Fan
The cooling fan operates with the ovens and grill. The fan will
operate at full speed for a few seconds and then reduce to a lower
speed. The cooling fan will only increase to full speed if the
temperature inside the cooker reaches above a certain limit.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
The controls
continued...
Main Oven Functions (1-7):
4.ROAST
2.TRADITIONAL
6.BREAD
CHICKEN
OVEN
3.ROAST
1.FAN
Main Oven Select
control
Grill
control
Top Oven
control
7.CAKES
MEAT
5.FISH
OVEN
+
-
Set
Time
Main Oven:
- Recommended
Shelf Position
and
Top Oven:
- ‘ON’ Indicator
and
- Preheat
Temperature
Indicator
Time / Mode
Main Oven
Light
End
Time
+/- Control
Knob
- Preheat
Cooking
Duration
Temperature
Indicator
Minute
Minder
The grill control will not operate unless the top oven control is in
the ‘O’ off position.
Grill Control -
Top Oven
The grill control provides fully variable heat control for either the
twin grill or single (left hand side) grill by selecting any number
between 1 & 4.
When turned clockwise the twin grill will be switched on and any
power setting from 1 - 4 can be selected. The power level numbers
are indicated on the control knob.
When turned anti-clockwise the single grill will be switched on and
any power setting from 1 - 4 can be selected.
The power level numbers are indicated on the control knob.
The off position is identified by an ‘O’.
This control switches on the top and bottom heating elements in
the top oven. The temperature in the oven can be set anywhere
between 100˚C and 220˚C.
Top Oven Control
The top oven ON indicator (TOP) and the top oven preheat
temperature indicator (
left hand corner).
symbol) will be on the display (bottom
The top oven preheat temperature indicator (
symbol) will switch
OFF and an audible tone will sound when the top oven has reached
the required temperature.
When in operation the oven light will be illuminated.
The off position is identified by an ‘O’.
If both the top oven and grill controls are turned on together, the
Notes
(TOP) and (
symbol) will flash on the display. The cooker will
continue to operate in the function which was selected first.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
The controls
continued...
Main Oven Control
This control switches on the top and rear heating elements at
various times in the main oven, dependent on which mode has been
set. The temperature of the main oven can be set anywhere
between 80˚C and 230˚C in cooking modes 1 - 5.
The main oven preheat temperature indicator (
the display (middle, left hand side).
symbol) will be on
The main oven preheat temperature indicator ( symbol) will switch
OFF and an audible tone will sound when the main oven has reached
the required temperature.
The Main Oven
Cooking Functions
The main oven has eight cooking functions. Use the main oven
control to select the cooking mode you require. The display will show
the function you have selected, across the top (1 - 7) with the
eighth function being shown on the clock display as ‘(RISE)’.
Adjusting the Main
Oven Temperature
When a program is set (position 1 - 5), the display will automatically
suggest a cooking temperature. If you wish you can use the +/-
control knob to change the suggested temperature to one of your
own choice, within a range which is suitable for the particular
cooking mode.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
The Cooking Modes in your Cooker
Your new cooker is equipped with a number of different cooking modes:
Conventional Heating (Top Oven)
- with upper and lower heat. This system is particularly suitable for
roasting and baking on one shelf only.
Variable Grilling (Top Oven)
- the oven can also be used for conventional grilling with a full or
half width fully controllable grill.
Note: The Top Oven door should be open when grilling.
Fan Oven (Main Oven)
- the fan oven operates by constantly blowing heated air, from an
element wrapped around the fan, into the oven. This gives improved
efficiency and in general, enables the use of lower temperatures
for cooking. It also means that there is less need to be particular
about shelf positions and that you can bake at more than one level
simultaneously (Batch Baking).
Traditional (Main Oven)
- the upper and rear heating elements are switched on in this
position. The traditional oven brings an outstanding level of
temperature distribution and reduced consumption. In traditional
cooking use only one rack to ensure good heat distribution. By using
the various shelf positions available you can balance the quantity of
heat between the upper and lower part. If cooking requires more
heat from below or above, use the lower or higher shelves respectively.
Roast Meat (Main Oven)
- specially created for cooking joints of meat. This mode raises the
temperature in the oven to a very high heat for the first part of the
cooking cycle, to seal the outside of the joint and retain the juices
of the meat throughout cooking. After this the temperature is
reduced to the set temperature using each heating element in turn
to guarantee a homogeneous temperature for the cooking period.
A temperature is suggested on this mode but this can be altered
using the '+/-' control knob.
Roast Chicken (Main Oven)
- specially created for cooking excellent roast poultry. This mode
can be used to roast chickens, duck, turkey and other poultry to
perfection. Each heating element is used in the cycle to guarantee a
homogeneous temperature within the oven.
A temperature is suggested on this mode but this can be altered
using the '+/-' control knob.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
The Cooking Modes in your Cooker
continued...
Fish (Main Oven)
- this mode provides gently pulsing top and rear heat to lightly
poach fish dishes without overcooking or drying out.
A temperature is suggested on this mode but this can be altered
using the '+/-' control knob.
Rising (Main Oven)
- this mode heats and holds the oven at 40˚C. It is ideal for proving
bread and yeast based dough mixtures. When this mode is selected
a cooking duration of 14 minutes is automatically set, this can be
altered by pressing the 'time/mode' button until the cooking
duration icon flashes. Then use the '+/-' control knob to adjust the
cooking duration.
Bread cycle - Auto
- this mode is fully automatic and lasts for 1 hour. When this mode
is selected the time and temperature cannot be adjusted.
It is suitable for baking bread weighing up to 1.5kg, either in a tin or
on a baking tray.
This mode includes a proving cycle and a baking cycle. If an initial
proving cycle is needed this can be done using the RISE mode (8).
Some recipe ideas are included in the recipe book supplied with the
cooker.
Cake cycle - Auto
- this mode is fully automatic and lasts for 1 hour. When this mode
is selected the time and temperature cannot be adjusted.
it is suitable for baking sponge based cakes that take between 30
minutes and 1 hour to cook.
Some recipe ideas are included in the recipe book supplied with the
cooker.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
Electronic Clock &
Automatic Cooking Feature
When you first switch on the appliance you will be prompted to set the ‘Time of Day’ on
the display. You must ensure you have done this before attempting to use the
automatic cooking feature.
The main oven can be controlled automatically.
AUTOMATIC COOKING
- Select food which will require the same cooking time and temperature.
- To ensure food does not cool down and require reheating, set the end
time so the food is ready when you require it.
HINTS ON AUTOMATIC
COOKING
- Always ensure that meat and poultry is defrosted before placing in the
oven.
- Whenever possible, take food out of the refrigerator and keep it as cool
as possible.
- If cooking food that requires frying before placing in the oven for
automatic cooking, keep the delay time to a minimum.
- Never place hot or warm food in the oven for delayed start cooking as it
could cause the oven to be warm and produce harmful bacteria in the
food.
- We advise that dishes containing left-over cooked poultry and meat, eg.
shepherds pie, should not be cooked automatically if there is to be a delay
period.
- Ensure that delay start times are kept to a minimum to prevent bacterial
growth in food.
- Wine or beer may ferment and cream may curdle during the delay period,
so it is best to add these ingredients just before serving.
- Foods which discolour should be protected by coating in fat or tossing in
water to which lemon juice has been added, prior to placing food in the
oven.
- Dishes containing liquid should not be filled too full to prevent boiling over.
- Food should be well sealed (but not airtight) in a container to prevent the
loss of liquid during cooking. Aluminium foil gives a good seal.
- Always ensure that food is piping hot and cooked thoroughly before
serving.
- Only reheat food once.
SETTING THE TIME OF DAY:
STEP 1.
STEP 2.
Check the electricity supply to the cooker is turned
on.
When switched on the display will show both 00:00
and the ‘set time’ symbol flashing. Wait until these
stop flashing.
Main Oven
Time/Mode
Light
STEP 3.
STEP 4.
Press the Time/Mode button once, so that the ‘Set
Time’ symbol and the display are flashing. Turn the
+/- control knob until the correct hour is set.
+
-
Press the Time/Mode button once, so that the ‘Set
Time’ symbol and the display are flashing. Turn the
+/- control knob until the correct minutes are set.
Press the Time/Mode button again.
TIME OF DAY IS NOW SET.
To alter the time of day after the first setting, simply
press the Time/Mode button. The ‘Set Time’ symbol
and the display will flash. Repeat STEPS 3 and 4.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
Electronic Clock &
Automatic Cooking Feature
SETTING THE MINUTE MINDER:
STEP 1.
STEP 2.
Press the Time/Mode button, until the ‘bell’ symbol is
flashing.
Turn the +/- control knob to set the duration in
minute increments until the required time is set.
After a few seconds the ‘bell’ symbol will stop
flashing and the time will count down.
Main Oven
Light
Time/Mode
+
-
THE MINUTE MINDER IS NOW SET.
At the end of the set time an audible tone will be
heard and the ‘bell’ symbol will go out. After a few
seconds the audible tone will stop and after a few
seconds the display will revert back to the time of
day.
The minute minder can be cancelled at any time by following
STEPS 1 and 2, setting the time period to zero using the +/-
control knob.
The display will revert back to the time of day.
The display shows HOURS and MINUTES
eg. 1 hour 38 minutes
Main Oven
Light
Time/Mode
+
-
13
Download from Www.Somanuals.com. All Manuals Search And Download.
Electronic Clock &
Automatic Cooking Feature
AUTO COOKING TIMER
There are two Auto Cooking programmes for the main oven, that can be selected using the display:
(a)
To set the main oven to switch ON immediately and OFF automatically after a time of
your choice.
To set the main oven to switch ON and OFF automatically, at the times of your choice.
(b)
(a) To set the main oven to switch ON immediately and OFF automatically:
This allows you to cook for a specified duration, after which the oven will automatically
switch off.
STEP 1.
Check that the correct time of day is set, if not
follow instructions for setting the time of day.
STEP 2.
STEP 3.
Place food to be cooked on shelf in the oven.
Switch the main oven control to the desired mode.
The display will automatically suggest a cooking
temperature. This can be changed by turning the +/-
control knob.
Main Oven
Light
Time/Mode
(The oven will start).
+
-
STEP 4.
STEP 5.
Press the Time/Mode button, until the ‘cooking
duration’ symbol is flashing.
Turn the +/- control knob to set the cooking duration
you require. After a few seconds the ‘cooking
duration’ symbol will stop flashing and the display will
show the temperature that has been set. This will
change every few seconds when the display will show
the cooking duration remaining.
THE COOKING DURATION IS NOW SET.
At the end of the set cooking duration, ‘End’ will show
in the display and an audible tone will be heard for a
few seconds.
Main Oven
Light
Time/Mode
+
-
Turn the main oven control to ‘O’, the OFF position to switch the
oven off. The display will revert back to the time of day.
To cancel the automatic mode at any time turn the main oven
control to ‘O’, the OFF position.
Note: During the cooking period the cooking duration will be shown in the display for a few
seconds and then revert to the temperature set.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
Electronic Clock &
Automatic Cooking Feature
(b) To set the main oven to switch ON and OFF automatically:
This allows you to cook for a specified duration and additionally choose the time you wish
the cooking cycle to finish. From this information the system works out when the cooking
cycle will need to start and automatically switches the oven on at the required time.
- Follow STEPS 1 to 5 in the previous section (a) entitled: ‘To set the main oven to switch ON
immediately and OFF automatically’, then continue as below:
STEP 6.
STEP 7.
Press the Time/Mode button, until the ‘end time’
symbol is flashing. The display will show a default
cooking end time (this will be the current time plus
the cooking duration you set in STEP 5).
The ‘end time’ symbol will flash.
Main Oven
Light
Turn the +/- control knob to set the time you wish
the cooking to end.
Time/Mode
After a few seconds the display the temperature,
cooking duration and end time in turn.
+
-
THE COOKING DURATION AND END TIME IS NOW SET.
The display will show the temperature and cooking
duration when the programme has started.
At the end of the cooking duration, ‘End’ and the ‘cooking
duration’ symbol will show in the display and an audible tone will
be heard for a few seconds.
Main Oven
Light
Time/Mode
+
-
Turn the main oven control to ‘O’, the OFF position to switch the
oven off. The display will revert back to the time of day.
To cancel the automatic mode at any time turn the main oven
control to ‘O’, the OFF position.
Note: At any time up to the start of cooking, the cooking end time, cooking duration and
the temperature will be shown in the display.
15
Download from Www.Somanuals.com. All Manuals Search And Download.
Temperature Conversion Chart
Main
Conventional
Oven
Main
Fan
Oven
Gas
Mark
˚F
1
2
/
100
120
130
140
160
170
180
200
210
220
250
275
300
325
350
375
400
425
450
120
140
150
160
180
190
200
220
–
1
2
3
4
5
6
7
8
–
9
475
Temperatures
The recommended temperatures given are for conventional and fan
ovens. When using a fan oven it will be necessary to reduce the
cooking time by 10 minutes per hour and lower the temperature by
up to 20˚C.
Also, in the majority of cases, it is not necessary to pre-heat the
oven.
However, pre-heating is recommended when cooking items such as
Yorkshire puddings, whisked sponges and bread. Your experience
with the cooker will enable you to select the cooking time and
temperature best suited for your recipe.
Condensation may become evident on the inner door and water may
drip through the vent. This is normal when heat and moisture are
present and may be a result of any of the following:
1. Kitchen temperature and ventilation.
Condensation
2. The moisture content of the food
eg. meat, roast potatoes, Yorkshire pudding, roasting meat, etc.
3. The quantity of the food being cooked at any one time.
16
Download from Www.Somanuals.com. All Manuals Search And Download.
Hotplate
The EG94 hotplate has one very high speed wok burner, one high speed burner and two
simmering burners.
1
Burners will accommodate pans between 100mm (4”) and 240mm (9 /2”) diameter.
All pans should be positioned centrally over the burners.
TO USE THE HOTPLATE
1. Press the ignition button and then push in and turn the control knob of the
chosen burner anti-clockwise to the large flame symbol. Continue to press the
ignition button until the sparks light the gas.
2. Turn the control knob anti-clockwise to reduce the heat input.
Only turn the control knob between the large flame symbol and the small flame
symbol when adjusting the setting.
3. To turn off, turn the control knob fully clockwise to the symbol O.
DO NOT use the hotplate unless all pan supports are in position.
DO NOT use mis-shapen pans which may be unstable.
DO NOT use round base woks directly on the pan supports.
Each burner is fitted with a spark ignitor for lighting the gas. To ensure rapid lighting of
the burners every time they are used, the ignitors must be kept clean and dry. Remove
any food spillage or cleaning materials from the ignitor using a small nylon brush such as
a tooth brush. Access to the ignitor can be achieved by lifting off the loose burner parts
carefully when the burners are cool.
When the hotplate burner bodies and caps are removed for cleaning, be careful not to
drop any food particles or cleaning materials into the burner bases, to avoid the
possibility of blocking the gas jets.
If aluminium based pans are used, a silvery deposit may appear on the top edge of the pan
support fingers. See ‘Care and Cleaning’ section for cleaning information.
17
Download from Www.Somanuals.com. All Manuals Search And Download.
Hotplate
SAFETY REQUIREMENTS FOR DEEP FAT FRYING
1. Never fill chip pans more than one third full with oil or fat.
2. Never leave oil or fat unattended during the heating or cooling period.
3. Never heat fat or fry with a lid on the pan.
4. Always dry food thoroughly before frying, and lower it slowly into the hot oil
or fat. Frozen foods in particular will cause frothing and spitting if added too
quickly.
5. Always keep the outside of the pan clean and free from streaks of oil or fat.
HOW TO DEAL WITH A FAT FIRE
1. Do not move the pan.
2. Turn off the hotplate burners.
3. Smother the flames with a fire blanket or damp cloth to extinguish the fire.
Do not use water or a fire extinguisher as the force of it may spread the
burning fat or oil over the edge of the pan.
4. Leave the pan for at least 60 minutes before moving it.
18
Download from Www.Somanuals.com. All Manuals Search And Download.
Solarplus Grill
CAUTION: Accessible parts may become hot when the grill is in use
- children should be kept away.
Your cooker is not fitted with a conventional type of grill. The
solarplus grill is designed to reduce your grilling times. It is quicker
because it takes less time to warm up from cold. Conventional grills
require 5 minutes pre-heat before food is placed beneath them, but
for normal grilling the solarplus grill can be used from cold without any
pre-heat. However, when toasting, optimum performance is achieved
by pre-heating the grill for about 1 minute.
Notes
You will notice that the grill elements are protected by a wire mesh.
This stops you from touching live parts.
DO NOT under any circumstances insert objects into the grill mesh
as this could damage or break the element tubes OR if the grill is
on cause an electric shock.
During use the mesh may become soiled. Do not attempt to clean it
while the grill is still on. Turn the cooker off at the control unit and
wait until it has cooled down before cleaning.
Care must be taken to ensure the grill mesh is not distorted - DO
NOT store the grill pan handle on the grill pan grid when the grill pan
runners are on the top runner position.
There are two halves to the grill, one on the left and one on the
right. You can choose to have both sides on or just the left side on.
Turning the control knob clockwise, will switch both sides on. Turning
it anti-clockwise, will only switch the left side on.
The numbers which are displayed indicate the heat setting:
Number 4 is the hottest and number 1 the coolest.
GRILLING SHOULD NOT BE UNDERTAKEN WITH THE TOP OVEN/GRILL DOOR CLOSED
- This will cause overheating.
The grill will not operate unless the top oven control is in the Off
position, ‘O’.
1. Open the grill/top oven door fully.
2. Position the rod shelf as recommended, in the chart (next page),
for the food being cooked.
To operate the grill
proceed as follows:
3. Place the grill pan on the rod shelf, ensuring it is positioned
centrally under the element.
4. Never line the grill pan with aluminium foil as this may cause
overheating of fat in the grill pan.
19
Download from Www.Somanuals.com. All Manuals Search And Download.
Solarplus Grill
continued...
Guide to grilling successfully:
Shelf
Position
from base
of oven
Pre-
heat
Comments
Food
Setting
Approx. Cooking Time
3-5 minutes.
Toasting of Bread
Products
Maximum
3 or 2
3 or 2
1 min.
None
Grill pan and grid.
Maximum for 4
minutes, then
reduce to 3
10-15 minutes.
Grill pan and grid.
Small cuts of meat
– Sausages, Bacon
Maximum for
6-8 minutes.
Chops, etc.
Gammon Steaks,
Chicken pieces
25-30 minutes.
Grill pan and grid.
None
2
reduce to 3-21/2
6-8 minutes.
In base of grill pan.
Fish Whole:
Fillets:
Maximum
Maximum
None
None
2
NOTE: Position 1
is bottom runner
from the base of
the oven.
3 or 2
10-15 minutes.
Grill pan and grid.
Fish in
breadcrumbs
3 or 2
3 or 2
None
3
Pre-cooked
Potato
Products
10-12 minutes.
None
3
10-15 minutes.
Pizzas
None
1 min.
3
3 or 2
1 or 2
Grill pan and grid.
5-7 minutes.
Dish placed directly on
shelf.
Browning of Food
Maximum
Grill Pan Handle
The grill pan handle is detachable from the pan, to facilitate
cleaning and storage. The handle can be either detachable from OR
fixed to the pan.
For a fixed handle:
Remove the screw and washers from the grill pan bracket, tilt the
handle over the recess adjacent to the bracket (A), slide it towards
the centre of the pan (B) and let the handle locate over the bracket
(C). Replace the screw and washers and ensure they are fully
tightened up.
For a detachable handle:
Remove the screw and washers from the grill pan and keep safe.
Please note: If a fixed handle is required, the grill pan cannot be
kept in the Fan Oven with the door closed but may be stored in the
top oven.
WARNING: Ensure that when using the grill pan handle in the detachable manner, it is
centralised and secure.
Recess
Fig. C
Fig. A
Fig. B
20
Download from Www.Somanuals.com. All Manuals Search And Download.
Top Oven – Conventional Cooking
The heat for conventional cooking in the top oven is provided by the
grill element and the element under the floor of the oven. It is ideal
for the slow cooking of cheaper cuts of meat in casseroles etc. but
can also be used for small joints of meat up to 1.5kg (3lb).
The operation of the controls is covered on page 8.
See cooking charts for temperatures and shelf positioning (pages
22 and 23).
The top oven can be used either independently to cook small
quantities of food or in conjunction with the main oven to provide
additional cooking space.
G
The shelf should be positioned on the first or second runner
from the bottom.
To use the oven
G
Set the top oven control to the required temperature, the top
oven light will come on and wait for the Preheat Temperature
Indicator to go off, indicating that the oven has reached the
right temperature.
proceed as follows:
25mm (1 in)
G
G
The food to be cooked should be placed in the centre of the
shelf with a gap of at least 25mm (1in) between it and the grill
element. This should avoid burning and ensure even cooking.
Do not place food or dishes on the floor of the oven.
Plate warming
in the top oven
Plates and dishes placed on shelf 1 of the top oven will be heated
when the main oven is in use.
When the main oven is not in use, for instance when a meal is being
cooked on the hob, place the plates and serving dishes on the shelf
using the bottom runner and turn the top oven control to
approximately 100˚C. A maximum time of 10-12 minutes is all that is
required to heat the plates and dishes.
NEVER operate the grill control when using the top oven for
cooking or warming plates and dishes.
WARNING: DO NOT put delicate items china or items which could be affected by heat
into the oven.
21
Download from Www.Somanuals.com. All Manuals Search And Download.
Top Oven Temperature Charts – Meat
Position in
Oven
Pre-
heat
Temperature
˚C
Meat
Time (approx.)
Beef/ Lamb
35 mins per 450g (1lb)
+ 35 mins over.
Yes
170/180
190/200
170/180
190/200
(slow roasting)
Beef/ Lamb
(foil covered)
35-40 mins per 450g
(1lb)
Yes
Yes
Yes
Yes
Pork
(slow roasting)
40 mins per 450g (1lb)
+ 40 mins over
Pork
(foil covered)
40 mins per 450g (1lb)
Runner 1
from
bottom
of oven.
Veal
(slow roasting)
40-45 mins per 450g
(1lb) + 40 mins over
170/180
190/200
170/180
190/200
150
Veal
(foil covered)
40-45 mins per 450g
(1lb)
Yes
Yes
Yes
Yes
Poultry/Game
(slow roasting)
25-30 mins per 450g
(1lb) + 25 mins over
Poultry/Game
(foil covered)
25-30 mins per 450g
(1lb)
1
2
2-2 / hrs
Casserole
If using aluminium foil, never:
1. Allow foil to touch sides of oven.
2. Cover oven interior with foil.
3. Cover shelves with foil.
The most accurate method of testing the readiness of joints of meat or whole poultry is
to insert a meat thermometer into the thickest part of a joint, or the thickest part of
poultry thighs, during the cooking period. The meat thermometer will indicate when the
required internal temp has been reached.
Beef - Rare:
Medium:
Well Done:
60˚C
70˚C
75˚C
Lamb:
Pork:
Veal:
80˚C
80˚C
75˚C
Poultry:
90˚C
22
Download from Www.Somanuals.com. All Manuals Search And Download.
Top Oven Temperature Charts – Baking
Position in
Pre- Temperature
Food
Time in mins.
10-15
Oven
heat
˚C
Runner 2 from
bottom of oven.
Scones
210/220
Yes
Runner 2 from
bottom of oven.
Small Cakes
Victoria Sandwich
180/190
170/180
180/190
200/210
20-25
Yes
Yes
Yes
Yes
Runner 2 from
bottom of oven.
20-30
Runner 2 from
bottom of oven.
Sponge Sandwich
(fatless)
20-25
Runner 2 from
bottom of oven.
10-15
Swiss Roll
Runner 1 from
bottom of oven.
Semi-rich Fruit
cakes
150/160
Yes
60-75 7 inch
Time Dependent
on size
Runner 1 from
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
140/150
190/200
200/210
190/200
200/210
Rich Fruit cakes
Shortcrust Pastry
Puff Pastry
bottom of oven.
Time Dependent
on recipe
Runner 1 or 2 from
bottom of oven.
Time Dependent
on recipe
Runner 1 from
bottom of oven.
Runner 1 or 2 from
bottom of oven.
Yorkshire Pudding
30-40
20-30
Runner 2 from
bottom of oven.
Individual Yorkshire
Puddings
Runner 1 from
bottom of oven.
Milk Pudding
Baked Custard
Bread
140/150
150/160
200/210
100
90-120
40-50
Runner 1 from
bottom of oven.
Runner 1 from
bottom of oven.
30-45
Runner 2 from
bottom of oven.
Meringues
150-180
Note: If soft margarine is used for cake making, temperatures recommended by the
manufacturers should be followed. Temperatures recommended in this chart refer to
cakes made with block margarine only.
23
Download from Www.Somanuals.com. All Manuals Search And Download.
Main Oven – The Intelligent Cooking System
The main oven of your new cooker is equipped with an intelligent
electronic cooking system that gives you additional cooking
performance, flexibility and features over traditional cooking products.
The operation of the controls is covered on page 9.
See cooking charts for temperatures and shelf positioning (pages
25 to 27).
The intelligent cooking system will automatically suggest a suitable
cooking temperature for several cooking modes. It is possible
however to modify the suggested temperature within a range
specific to each cooking mode.
Cooking
temperature
ranges
User adjustable temperature ranges by cooking mode:
Mode
Suggested
Minimum
Maximum
Fan oven
200˚C
190˚C
160˚C
190˚C
180˚C
80˚C
80˚C
80˚C
80˚C
80˚C
230˚C
230˚C
230˚C
230˚C
230˚C
Traditional
Roast meat
Roast chicken
Fish
Telescopic runners The main oven on this cooker comes equipped with telescopic
and Meat pan
runners, meat pan and a food support.
The meat pan is suitable for cooking joints of meat and poultry
using the intelligent cooking system (Fan, Traditional, Roast Meat
and Roast Chicken).
Use the information given in the ‘Cook Charts’ for the shelf
positioning of the pan and runners.
To reposition the telescopic runners unclip the runners from
position, move them to the position you require and re-clip them to
secure.
24
Download from Www.Somanuals.com. All Manuals Search And Download.
Main Oven – The Intelligent Cooking System
continued...
COOK CHART - Fan oven mode:
MEAT
Beef
Lamb
Pork
Preheat
Temperature
160/180˚C
160/180˚C
160/180˚C
Cooking Time
no
no
no
20-25 minutes per 450g (1lb)
+ 20 minutes extra
25 minutes per 450g (1lb)
+ 25 minutes extra
25 minutes per 450g (1lb)
+ 25 minutes extra
Chicken/Turkey
(up to 4kg/8lb)
no
no
160/180˚C
150/160˚C
18-20 minutes per 450g (1lb)
+ 20 minutes extra
Turkey
(4-5.5kg/8-12lb)
12-14 minutes per 450g (1lb)
+ 15 minutes extra
Notes:
Internal Temperatures:
Beef
rare
medium
well done
60˚C
70˚C
75˚C
80˚C
80˚C
90˚C
Lamb
Pork
Poultry
BAKING
Preheat
Temperature
Cooking Time
Scones
Small cakes
Victoria sandwich no
Fatless sponge
yes
no
210/220˚C
170/180˚C
160/170˚C
10-15 minutes
15-25 minutes
20-30 minutes
sandwich
Swiss roll
Semi rich fruit cake no
Rich fruit cake no
Shortcrust pastry no
Puff pastry no
yes
yes
180/190˚C
190/200˚C
140/150˚C
130/140˚C
190/200˚C
190/200˚C
180/190˚C
10-20 minutes
10-15 minutes
60-75 minutes
depending on size
depending on recipe
depending on recipe
30-45 minutes
Yorkshire pudding yes
Yorkshire pudding:
Individual
Bread
Meringues
yes
yes
no
190/200˚C
200/210˚C
80/90˚C
20-25 minutes
30-45 minutes
180-240 minutes
Notes:
Use up to 2 shelves when cooking (ensure they are evenly spaced).
It is not necessary to preheat the oven for some items.
25
Download from Www.Somanuals.com. All Manuals Search And Download.
Main Oven – The Intelligent Cooking System
continued...
COOK CHART - Traditional mode:
MEAT
Preheat
Temperature Shelf Position Cooking Time
Beef
yes
190/200˚C
2
or
0
+ 25 minutes extra
325-3 minutes
p
p
Beef
(foil
covered)
yes
yes
190/200˚C
190/200˚C
or
2
or 5-45 33
Lamb
2
0 325-3 minutes
+ 25 minutes extra
Lamb
(foil
covered)
yes
yes
190/200˚C
190/200˚C
2
or 5-45 33
Pork
2 or 3
30-35 minutes per 450g (1lb)
+ 30 minutes extra
Pork
(foil
covered)
yes
yes
190/200˚C
190/200˚C
or
2
or
340
Poultry
2
320-25
+ 20 minutes extra
minutes
Poultry
(foil
covered) yes
190/200˚C
2
or
0
325-3 minutes
Notes:
Internal Temperatures:
Beef
rare
medium
well done
60˚C
70˚C
75˚C
80˚C
80˚C
90˚C
Lamb
Pork
Poultry
BAKING
Preheat Temperature Shelf Position Cooking Time
Scones
Small
Victoria sandwich yes
Fatless sponge
sandwich
Swiss
Semi rich fruit cake yes
Rich fruit cake yes
Shortcrust pastry yes
Puff pastry
yes
cakes
220˚C
yes
170/1800˚C
310-15
180/190˚C
320-3 minutes
minutes
315-25
minutes
minutes
yes
190/200˚C
yes
150/160˚C
130/140˚C
190/200˚C
yes
315-20
200/210˚C
minutes
roll
310-15
60-75 minutes
depending on size
2
2
2
or
2
minutes
3depending
or 3depending
on
190/200˚C
33
Yorkshire pudding yes
Yorkshire pudding:
1905/-24050˚C
Individual
Bread
Meringues
yes
yes
yes
200/2010˚C
200-/42510˚C
80/90˚C
320-3 minutes
33 minutes
3180-240
minutes
Notes:
For best results use one shelf.
Preheat the oven before use.
26
Download from Www.Somanuals.com. All Manuals Search And Download.
Main Oven – The Intelligent Cooking System
continued...
COOK CHART - Roast Chicken mode:
MEAT
Preheat
no
Temperature Shelf Position Cooking Time
Chicken
Turkey
170˚C
170˚C
2
2
or
or
320
minutes
minutes
no
315-20
Notes:
Internal Temperatures:
Poultry
90˚C
If the poultry is covered with foil, the cooking time will need to be extended.
COOK CHART - Roast Meat mode:
MEAT
Preheat
Temperature Shelf Position Cooking Time
Beef
no
170˚C
170˚C
170˚C
2
2
2
or
or
or
320-25
+ 20 minutes extra
minutes
Lamb
Pork
no
no
325
minutes
+ 25 minutes extra
325
minutes
+ 25 minutes extra
Notes:
Internal Temperatures:
Beef
rare
medium
well done
60˚C
70˚C
75˚C
80˚C
80˚C
Lamb
Pork
If the meat is covered with foil, the cooking time will need to be extended.
COOK CHART - Fish mode:
FISH
Preheat
steaks
Temperature Shelf Position Cooking Time
yes 170˚C 315-25
Fish
minutes
(open roasted)
Whole
(foil baked)
fish
yes
180˚C
2
2
or
or
320-25
Whole
fish (foil baked)
stuffed yes
180˚C
0
325-3 minutes
27
Download from Www.Somanuals.com. All Manuals Search And Download.
Care and Cleaning
WARNING: BEFORE CLEANING, SWITCH THE COOKER OFF AT THE MAINS COOKER
CONTROL PANEL AND ALLOW IT TO COOL. IT IS ESSENTIAL THAT THE OVENS ARE
CLEANED AND KEPT FREE FROM FATS, OIL AND GREASE.
‘Stay Clean’ Liners ‘Stay Clean’ liners are covered with a special enamel which absorbs
cooking soils. At higher temperatures the soiling is slowly destroyed.
In most cases normal cooking at higher temperatures will permit
this cleaning to take place automatically.
However, if higher cooking temperatures are not used regularly
then it may be necessary, in order to prevent heavy soiling, to run
the oven at maximum temperature for at least two hours, from
time to time.
The ‘Stay Clean’ liners can be washed in warm soapy water followed
by rinsing in clear water. Dry well with a soft cloth.
NOTE: Do not use enzyme washing powder, harsh abrasives or
chemical oven cleaners of any kind.
Oven Fittings
Oven Interiors
The oven shelves can be cleaned either in a dishwasher or by using a
fine steel wool soap pad. The grill and meat pans can be cleaned in
warm soapy water using a fine steel wool soap pad to remove
stubborn stains or in a dishwasher.
They should be cleaned after each use.
To clean the oven interiors remove all the oven fittings and where
applicable the ‘Stay Clean’ liners.
All types of oven cleaners can be used, but do not allow abrasive
cleaners or oven spray to come into contact with the ‘Stay Clean’
liners.
Use a fine steel wool soap pad to remove stubborn stains.
Oven Door Cleaning The inner door glass panel can be removed for easy cleaning, see
page 30.
Cooker Exterior
The outside of the cooker should be cleaned regularly to keep it
looking like new.
Wipe over with a soft cloth wrung out in warm water and dry with a
soft clean cloth.
You can use mild non abrasive cleaners but always read the
manufacturer’s instructions first. Always test their suitability on a
small
area of the cooker not noticeable in normal use.
NOTE: DO NOT use scouring pads or abrasive cleaners as they may
scratch the surface.
Wear protective gloves when cleaning any part of your cooker.
28
Download from Www.Somanuals.com. All Manuals Search And Download.
Care and Cleaning
continued...
Hotplate Burner
Caps and Pan
Supports
Cloth wrung out in warm soapy water. Stubborn stains can be
removed with a cream paste, liquid cleaner or by rubbing with fine
steel wool soap pads.
NB. Check that the cleaning agent is approved by the Vitreous
Enamel Association.
Hotplate Burner
Bodies
Use a nylon brush to remove any cleaning materials, water or dirt
from the hotplate burner bodies.
Door and Control
Panel (Glass)
Regularly wipe with a clean, damp cloth and polish with a clean, dry
cloth.
Door and Control
Panel Trims
(Stainless Steel)
Regularly wipe with a clean, damp cloth and polish with a clean, dry
cloth.
Solarplus Grill
To clean the solarplus grill use a clean, damp cloth and wipe over. If
stubborn stains remain, gently clean with a well soaped nylon
scouring pad and wipe over with a damp cloth.
NOTE: DO NOT use metal cleaning utensils, wire wool or proprietary
oven cleaners on the grill element mesh.
WARNING: TO AVOID ELECTRIC SHOCK, BEFORE REPLACING THE OVEN LIGHT,
SWITCH THE COOKER OFF AT THE COOKER CONTROL UNIT
(and allow to cool if the oven has been used).
Replacement of
the Oven Light
Unscrew the glass cover, using a suitable cloth to protect the
fingers and remove carefully. Unscrew the existing light bulb, and
remove. Screw the new bulb into position and replace the glass
cover, with metal washer, until positioned securely.
29
Download from Www.Somanuals.com. All Manuals Search And Download.
Care and Cleaning
continued...
CLEANING THE DOORS
Take particular care not to damage the inner surface of the door inner glass that is
coated with a heat reflective layer. Do not use scouring pads, or abrasive powder,
which will scratch the glass.
Ensure that the glass panel is not subjected to any sharp mechanical blows.
Stubborn stains can be removed by using a fine steel wool soap pad. For slight soiling the
inner glass panel may be cleaned, while still warm, without removing it from the door. After
cleaning, rinse and dry with a soft cloth.
SIDE OPENING DOORS
Cleaning the door glass is the same as the drop down doors, except take care to
support the weight of the inner glass when removing and refitting.
DROP DOWN DOORS
Remove the door inner glass as follows.
1.
Open the door fully and remove the extrusion end caps (This should be done by
hand but if it proves too difficult, simply lift the inner glass to ease the end
caps out of position).
NOTE: If you need to use a tool - be careful not to damage the extrusion or end cap.
2.
Carefully slide the inner glass towards you and
withdraw it from its locating slots. Ensure
that the door is not allowed to slam shut, due
to the reduction in door weight.
Clean the glass as described above.
3.
The inside of the outer door glass can now be
cleaned while still fitted to the cooker.
NEVER OPERATE THE COOKER WITHOUT THE INNER DOOR GLASS IN POSITION.
Refit the door inner glass as follows.
1.
Open the door fully.
2.
Locate the inner door glass into its slots, so that the printing is readable from the
face nearest the oven in the closed position and the widest black band is towards
the bottom of the door. The inner door glass has a special reflective coating on
one side, in order to minimise surface temperatures and energy consumption
during use, it is important it is fitted correctly.
3.
Carefully slide the glass into its slots as far as it will go and replace the end caps.
30
Download from Www.Somanuals.com. All Manuals Search And Download.
If something goes wrong ...
Before contacting your Service Centre or Installer, check the problem guide below,
there may be nothing wrong with your cooker.
PROBLEM
CHECK
If all burners fail to ignite:
Check that sparks appear at the burners; a clicking
noise should be heard.
Burner will not light:
If not;
Check that the electricity supply is turned on.
If the electricity supply has failed, the hotplate burners
can be lit by a match.
Hotplate burner
If only one burner fails to ignite:
Check that the burner is dry and that spillage of food
or cleaning fluid remains are not affecting the ignitor
or burner ports.
Clean away any debris with a dry nylon brush such as an
old toothbrush. If a wire wool pad has been used for
cleaning around the burner ensure the ignitor is free
from any stray strands. Any water on the burner
should be dried with a cloth or kitchen towel.
Burner ports
Ignitor
On the hotplate make sure that all the burner parts
are correctly seated.
Slight odour or small
This is normal and should cease after a short period.
amount of smoke when grill
/ oven used first time
If you find that the timer display is blank, then it is likely
that
Nothing works
there is no electricity supply to your oven.
Check:
(i) That the main cooker wall is switched on
(ii) Other appliances, to see if you have had a power cut
(iii) The main circuit breaker for the property
Top oven, grill and main
oven do not work.
Operating the cooker under the following conditions may
cause a safety device to operate:
(a) Grilling with the door closed - Always grill with the
door fully open
(b) Grilling for an excessively long period at maximum
setting - see Grilling guide.
Switch off appliance and allow to cool for approx 30 mins.
Switch the cooker back on and check that the Grill, Top
oven and Main Oven are now operating.
Grill keeps turning
on and off.
When the Grill control is operated, the Grill will cycle on
and off, this is normal and not a fault.
31
Download from Www.Somanuals.com. All Manuals Search And Download.
If something goes wrong ...
continued...
PROBLEM
CHECK
The power supply to your oven has possibly been
Timer is flashing
interrupted, but has now come back on again. Reset the
timer to the correct time of day using the instructions
given in the timer section of the book.
‘00.00
’
Check temperature and shelf positions are as
recommended in the Oven Temperature Charts.
It may be necessary to increase or decrease the
recommended temperature slightly to suit your taste.
Oven temperatures too
high or low
Check:
Oven does not cook
evenly
(a) Temperature and shelf positions are as recommended
in the Oven Temperature Charts.
(b) Oven utensils being used allow sufficient air flow
around them.
The oven light is not covered by the guarantee. The part is
easily changed (see section 'Replacement of Oven Light').
A new light bulb may be obtained from our Parts
department see Key Contacts, back page.
Oven light does not
work
A gentle flow of air will be blown from beneath the control
panel when the appliance is used. If the appliance is still
warm, this cooling fan may run on, or restart itself when all
controls have been turned off.
Draught from beneath
control panel
The fan will stop once the appliance has been cooled. This is
normal and not a fault.
Steam is a by - product of cooking any food with a high
water contact. To help minimise always:
(a) Try to avoid leaving food in the oven to cool after
being cooked.
Steam / Condensation in
the oven after use.
(b) Use a covered container, wherever possible.
Disposal of your product
To minimise the risk of injury to children please dispose of your product carefully and
safely. Remove all doors and lids. Remove the mains cable (where fitted) by cutting off
flush with the appliance and always ensure that no plug is left in a condition where it
could be connected to the electricity supply.
To help the environment, Local Authority instructions should be followed for the disposal
of your product.
Disposal of old electrical appliances
The European Directive 2002/96/EC on Waste Electrical and Electronic Equipment
(WEEE), requires that old household electrical appliances must not be disposed of in the
normal unsorted municipal waste stream. Old appliances must be collected separately in
order to optimise the recovery and recycling of the materials they contain and reduce
the impact on human health and the environment.
The crossed out “wheeled bin” symbol on the product reminds you of your
obligation, that when you dispose of the appliance it must be separately collected.
Consumers should contact their local authority or retailer for information
concerning the correct disposal of their old appliance.
32
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
Prior to installation, ensure that the local distribution conditions (nature of the
gas and gas pressure) and the adjustment conditions are compatible. The
adjustment conditions for this appliance are stated on the data badge which is
fitted on the back panel.
This appliance is not designed to be connected to a combustion products
evacuation device. It must be installed and connected in accordance with
current installation regulations. particular attention should be given to the
relevant requirements regarding ventilation.
MODEL NUMBERS EG94
Category II2H3+ (GB)
These models are set to burn NATURAL GAS (G20) at 20 mbar but can be
converted for use on BUTANE (G30) at 28-30mbar or PROPANE (G31) at 37mbar
with the use of the LPG conversion kit that can be obtained, free of charge, if
you contact our Genuine Parts and Accessories department (see Key Contacts,
back page).
GAS SAFETY (INSTALLATION & USE) REGULATIONS
It is the law that all gas appliances are installed by competent persons in
accordance with the current edition of the above regulations. It is in your
interest and that of safety to ensure compliance with the law.
In the UK, CORGI registered installers work to safe standards of practice.
The cooker must also be installed in accordance with BS 6172.
Failure to install the cooker correctly could invalidate the warranty liability
claims and could lead to prosecution.
LOCATION
The cooker may be located in a kitchen, kitchen/diner or a bed-sitting room, but
not in a room containing a bath or shower. The cooker must not be installed in a
bed-sitting room of less than 20m3.
When adjusted for use on Butane (G30) or Propane (G31), the cooker must not
be installed in a room or internal space below ground level, e.g. in a basement.
PROVISION FOR VENTILATION
The room containing the cooker should have an air supply in accordance with
BS 5440: Part 2.
The room must have an opening window or equivalent; some rooms may also
require a permanent vent. If the room has a volume between 5 and 10m3, it will
require an air vent of 50cm2 effective area unless it has a door which opens
directly to outside. If the room has a volume of less than 5m3, it will require an
air vent of 100cm2 effective area. If there are other fuel burning appliances in
the same room, BS 5440: Part 2 should be consulted to determine air vent
requirements.
33
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
continued...
TECHNICAL DATA
1
1
2
2
Gas connection
Rp / ( / ” BSP female)
Pressure test point
Gas rate adjustment
Aeration adjustment
Front left hotplate injector
None
None
Electrical connection
4mm2 twin and earth
230/240V a.c. 50Hz.
G30 at 28-30mbar
G31 at 37mbar
EG94
G20 at 20mbar
HEAT
INPUT
HEAT
INPUT
INJECTOR
INJECTOR
BURNER
HOTPLATE
Front left
3.9 kW
131
3.5 kW (255g/h) 87
HOTPLATE
Rear right
3.0 kW
2.0 kW
116
103
3.0 kW (220g/h) 86
2.0 kW (145g/h) 70
HOTPLATE
Front right and
Rear left
GRILL
2.2 / 2.4 kW
MAIN OVEN
TOP OVEN
1.8 / 2.0 kW
1.7 / 1.9 kW
34
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
continued...
SPACE FOR FIXING
The cooker can be close fitted below hotplate level. This requires a minimum
distance of 600mm between cupboard units of hotplate height.
When installing next to a tall cupboard, partition or wall, for a minimum distance
of 400mm above hotplate level, allow a side clearance of at least 65mm.
The diagram below illustrates the minimum clearance between the cooker and
adjacent walls, cupboards etc.
The wall behind the cooker, 50mm below and 450mm above, and the width of the
cooker, must be a non-combustible material such as ceramic wall tiles.
If the cooker is to be fitted close to a corner on the left hand side, ensure that
there is a clearance of at least 50mm to allow the main oven door to open fully
for when removing oven shelves.
65 mm Min
600 mm Min
COOKER HOODS
If a cooker hood is to be installed, refer to the cooker hood manufacturers’
instructions regarding fixing height.
35
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
continued...
UNPACKING THE COOKER
Unpack the components from inside the grill and oven: Check that the following
parts are present.
Grill pan and grid
Baking dish
Main oven shelves (2)
Top oven/grill shelf (1)
Aluminium burner bodies(4)
Pan supports
Enamelled burner caps (5)
Literature
LEVELLING
Four skid feet are fitted which can be adjusted up or down to level the cooker.
CONVERSION FOR USE ON BUTANE (G30) OR PROPANE (G31)
Each burner requires the injector to be replaced and bypass screws adjusted or
replaced as follows:
1.
Remove the loose hotplate burner parts.
2.
Using a 7mm socket, replace the hotplate injectors as appropriate (see table
on previous page).
3.
4.
5.
Re-position the loose burner parts.
Carefully pull off the hotplate control knobs.
Using a narrow flat bladed screwdriver rotate the bypass screws fully
clockwise. The hotplate tap bypass screws are located down the centre of
the spindle.
6.
7.
Re-assemble the control panel parts.
Secure the self-adhesive LPG conversion label over the gas details on the
data badge.
36
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
continued...
STABILITY CHAIN
A hole in the gas inlet valve bracket can be used to engage a stability chain.
CONNECTING TO GAS SUPPLY
670
3
Connection to the cooker should be made with an approved appliance flexible
connection to BS 669. A length of 0.9 to 1.25m is recommended. The length of
hose chosen should be such that when the cooker is in situ, the hose does not
touch the floor.
Those cookers converted to use on LPG should be connected with a hose
suitable for LPG and capable of withstanding a pressure of 50 mbar.
An adaptor backplate should be fitted within the shaded area shown, to allow
the cooker to be pushed fully to the wall and to ensure that the flexible hose is
only likely to come into contact with areas at the rear of the cooker that do not
exceed a temperature rise of 70˚C.
37
Download from Www.Somanuals.com. All Manuals Search And Download.
Electrical Connection
continued...
Warning - THIS APPLIANCE MUST BE EARTHED
The cooker must be connected by a qualified electrician to a suitable double -
pole control unit with a minimum rating of 32A and a minimum contact
clearance of 3mm, which should be fitted adjacent to (but not above) the cooker,
in accordance with IEE regulations.
The power supply cable should conform to BS6004 with a conductor size of
4mm2.
The control unit should be easily accessible in the event of an emergency.
This appliance conforms to EN55014 regarding suppression of radio and
television interference.
Access to the cooker terminals is by un-clipping the cover. The mains cable must
pass through the cable clamp and the screws must be fully tightened.
Sufficient cable should be used to allow the cooker to be pulled out for
servicing. Ensure that the cover is fully closed and secure afterwards.
Take care not to trap the mains cable when pushing the cooker into its final
position.
Operational Checks
After installation, check for gas soundness. The supply pressure can be checked
at one of the hotplate burner injectors.
Check that the hotplate burners ignite correctly and burn with a steady flame.
Check for a steady flame at the low setting.
Instruct the user on the operation of the cooker.
38
Download from Www.Somanuals.com. All Manuals Search And Download.
Hotpoint Service Cover
Satisfaction Guaranteed or Your
Hotpoint’s Extended Warranties
Whether you have just one or a number of Hotpoint
appliances in your kitchen, Hotpoint has a range of
Service Plans to give you complete peace of mind.
They enable you to extend your one year labour
guarantee so that you can have repairs completed
FREE during the membership period.
Money Back
Hotpoint gives you a unique ‘Satisfaction Guaranteed’
promise – valid for ninety days after you have purchased
your Hotpoint product. If there is a technical problem
with your Hotpoint appliance, just call Hotpoint Service
(see back page). If necessary we will arrange for an
engineer to call. If the technical problem is not
resolved under this Guarantee, Hotpoint will replace
your appliance or, if you prefer, give you your money
back. Your statutory rights are not affected, and the
Guarantee is additional and subject to the terms of
Hotpoint’s Five Year Parts Guarantee.
Service Cover
We offer a number of payment methods; cheque,
credit card or you can spread the cost and pay by
direct debit (full details can be obtained on Free
phone 0800 716356). This covers you for all repairs
during the period of cover, which can be from 1 to 4
years. Service Cover also includes loss of food, up
to the value of £250, in refrigeration appliances.
There is also an option of Service Cover with
Maintenance at an additional cost. This includes an
annual Electrical and Safety check and replacement
of any parts as necessary.
Hotpoint’s Free Five Year Guarantee
From the moment your appliance is delivered Hotpoint
guarantees it for FIVE YEARS.
G
In the Five Years all replacement parts are FREE
provided that they are fitted by our own Service
Engineer. During the first year our Engineer’s time
and labour is also free.
Kitchen Cover
An annual payment covers you for all repairs for all
your Hotpoint appliances which are less than ten
years old. It also covers the cost of loss of food up
to £250 in our refrigeration and freezer products.
There is also the option of Kitchen Cover with
Maintenance at an additional cost. Any additional
Hotpoint appliances purchased after you have
joined Hotpoint Kitchen Cover will automatically be
included during the annual period of cover without
further charge.
G
Our guarantee covers loss of food in our
refrigeration and freezer products up to £250
during the first year, subject to verification by one
of our engineers.
G
After the first year we will charge for our
Engineer’s time and labour. We do, however,
operate a range of Service Plans (see opposite)
which, for an annual payment, enables you to cover
any repair costs which may be necessary.
G
All our service repairs are guaranteed for twelve
months in respect of our labour and any parts
fitted.
The appliance must be used in the United Kingdom,
and must not be tampered with or taken apart by
anyone other than our own Service Engineers.
You may, however, buy parts which can be safely
fitted without specialist knowledge or equipment.
The correct fitting of such parts, provided they are
genuine Hotpoint spares, will not affect your
Guarantee. Parts are available from our Hotpoint
Spares Centres (see back page).
Appliance Registration
To ensure that you have the opportunity to benefit
from any of the above Service Schemes and other
offers you should complete and return immediately
the Appliance Registration Form/Questionnaire
supplied with this appliance. Full details and costs
of our Service Schemes, together with an application
form, will be sent to you at the end of the first year
of the guarantee.
G
G
Annual Safety/Maintenance Checks
Hotpoint strongly recommends that all its
appliances are regularly checked for electrical and
mechanical safety, whether or not they are covered
by a Service Plan. Worn door gaskets or hoses may
cause a leak on an appliance, which could become
dangerous if neglected.
G
Our guarantee does not cover the cost of any
repair, or loss of food in refrigeration products,
due to power failure, accidents or misuse. Nor does
it cover the cost of any visits to advise you on the
use of your appliance. Please read thoroughly the
instruction book supplied with this appliance.
G
If at any time during the Guarantee period we are
unable to repair your appliance, we will refund any
repair costs paid to us in the previous twelve
months. We will also offer you a new appliance at
a reduced charge instead of a repair.
Our Guarantee is in addition to and does not affect
your legal rights.
Proof of Purchase
For future reference please attach your purchase
receipt to this booklet and keep it in a safe place.
G
Spares and Accessories
Spares and accessories can be ordered from your
local Hotpoint Spares Centre (see back page), using
the order form enclosed.
G
Should you need independent advice on your
consumer rights, help is available from your
Consumer Advice Centre, Law Centre, Trading
Standards Department and Citizens Advice Bureau.
NOTE: Our Engineers will use every effort to avoid
damage to floor coverings and adjacent units when
carrying out repairs/service work, but in locations
where the Engineer advises you that it will be
impossible to move appliances without risk of
damage, he will only proceed with your approval that
no liability is accepted.
G
All Hotpoint servicing is carried out by our own
Service Organisation located throughout the
United Kingdom and Eire. We will be happy to deal
with any problems which you may have.
39
Download from Www.Somanuals.com. All Manuals Search And Download.
Key Contacts
After Sales Service
Over 1100 trained specialists, directly employed by us, ensure that you can have
complete confidence in both the appliances and services we offer.
Repair Service and Information Help Desk
UK: 08709 066 066
Monday to Friday, 8am to 7.30pm
Saturday, 8.30am to 5.30pm
Sunday, 9.30am to 3.30pm
Republic of Ireland: 0818 313 413
Note: Our operators will require the following information:
Model number
Serial number
Extended Warranties
UK: 08709 088 088
Monday to Sunday, 8am to 8pm
Republic of Ireland: 0123 002 333
Genuine Parts and Accessories
UK: 08709 077 077
Monday to Friday, 8.30am to 5pm
Saturday, 8.30am to 12noon
Republic of Ireland: 0818 313 413
Indesit Company UK Limited, Morley Way, Peterborough, PE2 9JB
.
PRINTED BY SIMLEX FOUR ASHES, WOLVERHAMPTON.
08/2006 Part no. 195058098.00
Download from Www.Somanuals.com. All Manuals Search And Download.
|