OWNER’S MANUAL
ASSEMBLY AND OPERATING INSTRUCTIONS
TWO BURNER PROPANE
CAMPING STOVE
WARNING
READ AND FOLLOW ALL WARNINGS AND
INSTRUCTIONS IN THIS MANUAL TO AVOID
PERSONAL INJURY OR PROPERTY DAMAGE.
Propane cylinder not included.
Download from Www.Somanuals.com. All Manuals Search And Download.
WARNING
•
•
•
Keep hands, face and hair away from burners. Use long matches or long-nosed lighter to light the burners. Do
not wear loose clothing or allow long hair to hang freely while lighting or using stove.
Do not leave stove unattended when hot or in use. Only adults are to operate this stove; keep children and pets
safely away. Carefully monitor all activity around stove to avoid burns or other injuries.
Always snap down legs to form a "V" with the stove base to prevent the stove from becoming unstable while
in use.
•
•
•
•
Do not move stove while in use or while pot contains hot liquid.
Avoid touching hot surfaces, wear oven mitts to protect your hands and non-slick shoes.
Avoid bumping into stove or boiling pot to prevent hot liquid spills or overturning stove.
Do not use or store stove near gasoline or other flammable liquids, gases or where flammable vapors may be
present.
•
•
Do not use this stove and boiling pot for other than its intended purpose.
Only use replacement/accessory parts manufactured by The Brinkmann Corporation. Repairs should be
performed by The Brinkmann Corporation.
•
Properly dispose of all packaging materials.
USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR STOVE.
FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS
MANUAL COULD RESULT IN BODILY INJURY OR PROPERTY DAMAGE.
SAVE THIS MANUAL FOR FUTURE REFERENCE.
ASSEMBLY INSTRUCTIONS
READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY
BEFORE ASSEMBLING OR OPERATING YOUR STOVE.
Inspect contents of the box to ensure all parts are included and undamaged.
FOR MISSING PARTS, PLEASE CALL CUSTOMER SERVICE AT 1-800-527-0717.
(Proof of purchase will be required.)
1
PARTS LIST:
2
1
2
Cooking Grid
Cook Top
9
3
3
4
5
Burner Assembly
Wind Guard
Leg Wire
4
6
7
Case
Control Knob
Regulator/Valve Assembly
Lid Assembly
8
9
5
8
6
7
2
Download from Www.Somanuals.com. All Manuals Search And Download.
Step 1
Snap down legs to form a "V" with the stove
base.
Notched Support Arm
Step 2
Open lid and align the two wind guards by
inserting notched support arms into wind
guards.
Step 3
Remove regulator/valve assembly.
Regulator Knob
Burner Control Knobs
WARNING: Always snap down legs to form a "V" with the stove
base to prevent the stove from becoming unstable
while in use.
Regulator/Valve Assembly
Step 4
Before attaching propane cylinder, make
sure the regulator and burner control knobs
are in the "OFF" position.
Step 5
Attach propane cylinder to regulator/valve
assembly by turning propane cylinder
counter-clockwise. HAND TIGHTEN ONLY.
NOTE: Use propane cylinder upright when
possible to prevent flare-ups.
Step 6
Attach regulator/valve assembly to stove
fitting. HAND TIGHTEN ONLY.
Stove Fitting
3
Download from Www.Somanuals.com. All Manuals Search And Download.
GAS LEAK TESTING
THE GAS LEAK TESTING PROCEDURE MUST BE PERFORMED
EVERY TIME THE CYLINDER IS CONNECTED TO STOVE.
WARNING
Gas leak testing must be performed outdoors in a well ventilated area.
During the gas leak testing procedure, always keep unit away from open flames, sparks or lit cigarettes.
Never use a flame to check for gas leaks.
•
•
•
•
Always use the regulator valve knob to turn the unit "OFF". The control knobs are used when lighting the burners
and to adjust the flame.
•
Never use a unit that has a gas leak. Contact The Brinkmann Corporation’s Customer Service Department for
replacement parts at 1-800-527-0717.
Step 1
Make sure the regulator knob and control knobs are in
the "OFF" position.
Step 2
Regulator/Valve
Assembly
Propane Cylinder Valve
Make sure regulator/valve assembly is properly attached
to propane cylinder refer to "Assembly Instructions".
Attach regulator/valve assembly to the side of the
Camping Stove. HAND TIGHTEN ONLY.
Step 3
Prepare a soapy water solution (one part dishwashing
liquid to three parts water) to test for gas leaks in the
assembly hose and connections. Apply a generous
amount of the soapy mixture to the regulator stem, the
entire length of hose and Camping Stove fitting (located
on the right side of stove).
Step 4
With the control knobs in the "OFF" position, open the
regulator valve two full turns (counter-clockwise). Next,
check for bubbles at regulator valve, along the entire
length of hose and at the Camping Stove fitting. DO NOT
LEAVE GAS ON FOR MORE THAN 10 SECONDS. If soapy
mixture starts bubbling, gas is leaking through the
connection or hose. Turn the regulator valve "OFF" and
retighten the connection that is leaking gas. Repeat
procedure with soapy mixture until gas no longer leaks.
NEVER USE A FLAME TO CHECK FOR GAS LEAKS. Turn
the regulator valve "OFF" after each test.
Stove Fitting
NOTE: Use propane cylinder upright when
possible to prevent flare-ups. Make
sure not to cross-thread fittings
while tightening.
Watch for Bubbles
Step 5
Once all gas leaks have been sealed, WAIT AT LEAST 5
MINUTES FOR GAS FUMES TO DISSIPATE BEFORE
LIGHTING THE BURNERS.
Carefully follow "Operating Instructions" to light the
burner and properly operate this unit.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
OPERATING INSTRUCTIONS
PLACE THE STOVE OUTDOORS ON A HARD, LEVEL, NONCOMBUSTIBLE
SURFACE AWAY FROM ANY COMBUSTIBLE MATERIAL. IN WINDY WEATHER,
THE STOVE SHOULD BE LOCATED IN AN OUTDOOR AREA THAT IS
PROTECTED FROM THE WIND. GAS LEAK TESTING PROCEDURE MUST
BE PERFORMED EVERY TIME THE STOVE IS USED.
READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY BEFORE
OPERATING YOUR STOVE.
Step 1
Make sure the regulator knob and control knobs are in the "OFF" position.
Step 2
Fully open the propane cylinder valve by turning regulator knob
counter-clockwise.
Step 3
Using a long match, hold the flame beside burner. Turn the control knob
SLOWLY until the burner lights.
WARNING: If the burner does not light within 5 seconds, turn the regulator
knob and control knobs "OFF" immediately. Wait at least
5 minutes until gas fumes have dissipated before attempting to
light burner again.
Step 4
To light the second burner, reduce the flame on the first, lit burner and
repeat Step 3.
NOTE: Use propane cylinder
Step 5
upright when possible
When food is done, turn stove "OFF". Always turn regulator knob "OFF"
to prevent flare-ups.
first, then turn the control knobs "OFF".
Step 6
Allow stove to cool completely, then follow instructions in the
"After-Use Safety" and "Proper Care & Maintenance" sections of this
manual.
Regulator Knob
Burner Control Knobs
5
Download from Www.Somanuals.com. All Manuals Search And Download.
AFTER-USE SAFETY
WARNING
•
•
Always allow the stove to cool completely before handling.
Always disconnect the propane cylinder from stove when not in use - a safety cap should be placed on the
propane cylinder.
PROPER CARE & MAINTENANCE
•
•
Cover and store stove in a protected area away from children and pets.
Never store propane cylinder in an enclosed area (house, garage, etc.). Store outdoors in a well ventilated, shaded
area away from any heat source or open flame.
•
•
Due to the intense heat from burner, it is normal for paint burn off and discoloration to occur on stove during the
first few uses.
To protect your stove from excessive rust, the unit must be kept clean and covered at all times when not in use.
We strongly suggest storing the stove indoors in a shed, garage or storage room. Disconnect the LP cylinder and
leave the LP cylinder outdoors.
•
If rust appears on the exterior surface of your stove, clean and buff the affected area with steel wool or fine grit
emery cloth. Touch-up with a good quality high-temperature resistant paint.
•
•
Wash cooking grill with hot, soapy water, rinse well and dry.
Clean inside and outside of stove by wiping off with a damp cloth.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
©2002 The Brinkmann Corporation
Dallas, Texas 75244 U.S.A
ONE YEAR LIMITED WARRANTY
For one year from date of purchase, The Brinkmann Corporation warrants the Tabletop Camping Stove against defects due to
workmanship or materials to the original purchaser. The Brinkmann Corporation’s obligations under this warranty are limited to
the following guidelines:
•
This warranty does not cover stoves that have been altered or damaged due to: normal wear, abuse, improper
maintenance, improper use, disassembly of parts and/or attempted repair by anyone other than an authorized employee of
The Brinkmann Corporation.
•
•
•
This warranty does not cover surface scratching or heat damage to the finish, which is considered normal wear.
The Brinkmann Corporation may elect to repair or replace damaged units covered by the terms of this warranty.
This warranty extends to the original purchaser only and is not transferable or assignable to subsequent purchasers.
The Brinkmann Corporation requires reasonable proof of purchase. Therefore, we strongly recommend that you retain your sales
receipt or invoice. To obtain replacement parts for your Tabletop Camping Stove under the terms of this warranty, please call
Customer Service Department at 1-800-527-0717. A receipt will be required. The Brinkmann Corporation will not be
responsible for any stoves forwarded to us without prior authorization.
EXCEPT AS ABOVE STATED, THE BRINKMANN CORPORATION MAKES NO OTHER EXPRESS WARRANTY.
THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION
TO ONE YEAR FROM THE DATE OF PURCHASE. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED
WARRANTY LASTS, SO THE ABOVE LIMITATION MAY NOT APPLY TO YOU.
ANY LIABILITY FOR INDIRECT, INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM THE FAILURE OF THE TABLETOP
CAMPING STOVE TO COMPLY WITH THIS WARRANTY OR ANY IMPLIED WARRANTY IS EXCLUDED. CUSTOMER
ACKNOWLEDGES THAT THE PURCHASE PRICE CHARGED IS BASED UPON THE LIMITATIONS CONTAINED IN THE WARRANTY
SET OUT ABOVE. SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL
DAMAGES, SO THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC
LEGAL RIGHTS, AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE.
140-0100-1
3/02
Owner’s Manual for Model
842-0100-0
Download from Www.Somanuals.com. All Manuals Search And Download.
|