Portable System
Owners Manual
Customer Service Center
• N53 W24700 South Corporate Circle • Sussex, WI 53089 • U.S.A.
REQUIRED TOOLS AND
MATERIALS:
WARNING!
READ AND UNDERSTAND
OPERATOR'S MANUAL
BEFORE USING THIS UNIT.
• (2 each) Wrenches and/or
Socket Wrenches and
Sockets.
1/2"
3/4"
FAILURE TO FOLLOW
AND/OR
OPERATING INSTRUCTIONS
COULD RESULT IN INJURY
OR DAMAGE TO PROPERTY.
1/2"
3/4"
Manufactured & Distributed By:
Model #
A
Company
Toll-Free Customer Service Number for U.S.: 1-800-558-5234
1
12/28/04
P/N 21173402
© COPYRIGHT 2004 by HUFFY SPORTS
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS LIST
Item Qty. Part No. Description
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
1
1
2
1
1
1
1
1
1
2
1
1
1
1
1
2
4
1
206646 Tank (Black)
200628 Wheel Axle
226401 Wheel
900060 Top Pole Section
908057 Middle Pole Section with Label
900254 Bottom Pole Section Assembly
203041 Nut, Hex Flange, 3/8-16
Net
201342 Wheel Bracket
201651 Spacer, Wheel Axle
201568 T-Strap
206219 Cap
266001 Bolt, Carriage, 3/8-16 x 1.5 Long
203617 Tank Cap
200439 Label, Moving System and Height Adjust.
203084 Bolt, Carriage, 5/16-18 x 1.75 Long
201344 Knob, Plastic, 3-sided
Rim
19 12* 201219 Smart Clip, Net Holder
20
21
22
23
24
25
26
27
28
29
30
31
32
2
1
3
2
2
4
1
1
1
1
1
1
4
900057 Backboard Mounting Bracket
203124 Tie Down Stake
203309 Washer, .406 I.D. x 1.0 O.D.
203053 Bolt, Carriage 5/16-18 x 4
200837 Board Spacer
203100 Nut, Hex Flange, 5/16-18
900033 Slam Jam Bracket, Black
203796 Bolt, “Tee” 3/8 - NC x 5 Long
200318 Bracket Reinforcement, Slam Jam
203472 Spring, Black
203795 Nut, Special 3/8-NC
203470 Washer, Flat 5/8 I.D. x 1-1/2 O.D.
203104 Bolt, Hex-Flange 5/16-18 x 2" Long
* YOU MAY HAVE EXTRA PARTS WITH THIS MODEL.
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
3
12/28/04
P/N 21173402
Download from Www.Somanuals.com. All Manuals Search And Download.
WARNING
FAILURE TO FOLLOW THESE WARNINGS MAY RESULT
IN SERIOUS INJURY AND/OR PROPERTY DAMAGE.
Owner must ensure that all players know and follow
these rules for safe operation of the system.
• DO NOT HANG on the rim or any part of the system
including backboard, support braces or net.
• During play, especially when performing dunk type
activities, keep player's face away from the backboard, rim
and net. Serious injury could occur if teeth/face come in
contact with backboard, rim or net.
• Do not slide, climb, shake or play on base and/or pole.
• After assembly is complete, fill system completely with
water or sand and stake to the ground. Never leave system
in an upright position without filling base with weight, as
system may tip over causing injuries.
• When adjusting height or moving system, keep hands and
fingers away from moving parts.
• Do not allow children to move or adjust system.
• During play, do not wear jewelry (rings, watches, necklaces,
etc.). Objects may entangle in net.
• Surface beneath the base must be smooth and free of
gravel or other sharp objects. Punctures cause leakage and
could cause system to tip over.
• Keep organic material away from pole base. Grass, litter,
etc. could cause corrosion and/or deterioration.
• Check pole system for signs of corrosion (rust, pitting,
chipping) and repaint with exterior enamel paint. If rust has
penetrated through the steel anywhere, replace pole
immediately.
• Check system before each use for proper ballast, loose
hardware, excessive wear and signs corrosion and repair
before use.
• Check system before each use for instability.
• Do not use system during windy and/or severe weather
conditions; system may tip over. Place system in the
storage position and/or in an area protected from the wind
and free from personal property and/or overhead wires.
• Never play on damaged equipment.
• See instruction manual for proper installation and
maintenance.
• When moving system, use caution to keep mechanism from
shifting.
• Keep pole top covered with cap at all times.
• Do not allow water in tank to freeze. During sub-freezing
weather add non-toxic antifreeze, sand or empty tank
completely and store. (Do not use salt.)
• Use extreme caution if placing system on sloped surface.
System may tip over more easily.
In the U.S.:1-800-558-5234 and Canada: 1-800-284-8339
201241
2/99
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
4
P/N 21173402 12/28/04
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS IDENTIFIER- Hardware is actual size
32. Bolt, Hex Flange, 5/16-18 x 2"-Qty (4)
13. Bolt, Carriage, 3/8-16 x 1.5 Long-Qty (1)
22. Washer, .406 I.D. x 1.0 O.D.-Qty (3)
25. Nut, Hex Flange, 5/16-18-Qty (4)
16. Bolt, Carriage, 5/16-18 x 1.75 Long-Qty (2)
7. Nut, Hex Flange, 3/8-16-Qty (1)
23. Bolt, Carriage, 5/16-18 x 4 Long-Qty (2)
10. Spacer, Wheel Axle-Qty (2)
31. Washer, 5/8 I.D. x 1/2 O.D.-Qty (1)
30. Special Nut-.-Qty (1)
27. "T" Bolt-Qty(1)
PARTS IDENTIFIER- Not actual size
9. Wheel Bracket-Qty (1)
29. Spring-Qty (1)
26. Slam Jam Bracket-Qty (1)
20. Backboard Mounting Bracket-Qty (2)
28. Reinforcement Bracket-Qty (1)
17. Knob-Qty (4)
24. Board Spacer-Qty (2)
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
5
12/28/04
P/N 21173402
Download from Www.Somanuals.com. All Manuals Search And Download.
Get to know the basic parts of your basketball system.....
BOARD
RIM
POLE
BASE
WHEEL
CARRIAGE
ASSEMBLY
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
Download from Www.Somanuals.com. All Manuals Search And Download.
6
P/N 21173402 12/28/04
Correctly identify each pole section. Poles have an identification
sticker that will be used as a reference point in the next step.
1.
Reference Stickers
4
5
6
TOP
MIDDLE
BOTTOM
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
7
12/28/04
P/N 21173402
Download from Www.Somanuals.com. All Manuals Search And Download.
IMPORTANT!
ONCE POLE SECTIONS ARE POUNDED TOGETHER- THEY CANNOT BE TAKEN APART
Align poles using alignment marks. First, pound top and
middle poles together by bouncing them on a scrap piece of
2. wood on the ground as shown in FIG B. until they no
alignment mark
longer move toward pole identification stickers. THEN add
bottom pole section and pound together in the same way.
TOP
CAUTION!
LOCATED 5" FROM THE END OF
THE POLE. WHEN PROPERLY
4
THE IDENTIFICATION STICKER IS
POUNDED TOGETHER, THE POLE
SECTIONS SHOULD HAVE A 3-1/2"
MINIMUM OVERLAP, LEAVING 1-
1/2" BETWEEN THE OVERLAPPING
POLE AND THE IDENTIFICATION
STICKER.
alignment mark
MIDDLE
FIG B.
5
5"
IDENTIFICATION
STICKER
middle pole
scrap wood
(Not Supplied)
alignment mark
IDENTIFICATION
STICKER
BOTTOM
1-1/2"
middle pole
6
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
8
P/N 21173402 12/28/04
Download from Www.Somanuals.com. All Manuals Search And Download.
Install wheel axle (2) through wheel bracket (9) and install wheels (3) onto
wheel axle (2) with spacers (10) as shown.
3.
4.
IMPORTANT!:
9
2
3
10
THE SPACER (10) WILL
FIT LOOSELY UNTIL
SECURED INTO THE
CAVITY OF THE BASE.
Attach wheel carriage assembly to base (1) with bolt (13), washer (22), and
nut (7) as shown. FINGER TIGHTEN - NO TOOLS REQUIRED. Assembly
will be fully tightened in next step.
7
IMPORTANT!:
22
BE SURE THAT THE
SQUARE PORTION OF THE
CARRIAGE BOLT IS
PROPERLY SEATED IN
THE SQUARE CUT-OUT OF
THE WHEEL BRACKET.
1
13
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
9
12/28/04
P/N 21173402
Download from Www.Somanuals.com. All Manuals Search And Download.
Attach pole assembly to tank assembly as shown. Secure pole assembly to
tank and wheel bracket by turning the pole assembly clockwise as shown.
Tighten pole completely and further rotate pole until struts are aligned
correctly as shown in FIG B.
5.
WARNING!
TWO PEOPLE REQUIRED
FOR THIS PROCEDURE.
FAILURE TO FOLLOW THIS
WARNING COULD RESULT IN
SERIOUS INJURY AND/OR
PROPERTY DAMAGE.
IMPORTANT!:
The pole should be turned
approximately 7 complete
rotations to tighten properly.
When properly tightened, the
wheel bracket will be tight
against the base. An assistant is
recommended to hold the base
in place during this step.
FIG B
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
Download from Www.Somanuals.com. All Manuals Search And Download.
10
P/N 21173402 12/28/04
Rotate struts down and bend struts outward to line up with holes on base as
shown. Secure free ends of tank struts to tank with carriage bolt (16), washer (22),
and knob (17) as shown. Repeat for other side.
6.
WARNING!
KNOBS MUST BE TIGHTENED
COMPLETELY AND
CHECKED PERIODICALLY
FOR TIGHTNESS.
16
22
17
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
11
12/28/04
P/N 21173402
Download from Www.Somanuals.com. All Manuals Search And Download.
Mount brackets (20 & 26) to backboard and finger tighten as shown.
NOTE: Final adjustments will be made in Step 10.
7.
27
26
32
27
26
25
24
20
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
12
P/N 21173402 12/28/04
Download from Www.Somanuals.com. All Manuals Search And Download.
Install Slam Jam Rim to Backboard
A • Fit rim (18) securely into bracket (26) as shown (Allow "T"-bolt (27) to slip
through center hole in rim (18).
B • Install reinforcement bracket (28) onto “T” bolt (27) as shown.
C • Install spring (29) onto “T” bolt (27) as shown.
8.
D • Install special nut (30) and washer (31) onto “T” bolt (27).
E • Tighten nut (30) until flush with end of “T” bolt (27).
B
A
28
18
27
#28
27
26
31
30
C
D
29
27
31
27
E
30
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
13
12/28/04
P/N 21173402
Download from Www.Somanuals.com. All Manuals Search And Download.
Support pole and tank assembly over support
table. Carefully slide backboard components
9. onto pole.
WARNING!
TWO PEOPLE REQUIRED
FOR THIS PROCEDURE.
FAILURE TO FOLLOW THIS
WARNING COULD RESULT IN
SERIOUS INJURY AND/OR
PROPERTY DAMAGE.
WARNING!
DO NOT LEAVE
ASSEMBLY UNATTENDED
WHEN EMPTY; IT MAY TIP
OVER.
SAWHORSE OR SUPPORT TABLE
While still in the horizontal position, carefully slide backboard components onto pole.
Secure hardware at desired position as shown and tighten all hardware completely at
this time.
10.
17
12
NOTE:
Peel protective
film from surface
of acrylic
backboard prior
23
to use.
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
Download from Www.Somanuals.com. All Manuals Search And Download.
14
P/N 21173402 12/28/04
Place assembled unit in desired location. Fill tank with water (26 gallons/98.4 liters) or
sand (approx. 360 lb./163 kg) and snap tank cap (14) in place.
Insert T-strap (11) through slot on back of base as shown. Secure unit to ground by
twisting tie down stake (21) into ground and hooking T-strap (11) onto tie down stake
(21).
11.
CAUTION!
ADD TWO GALLONS (7.6
LITERS) OF NON-TOXIC
ANTIFREEZE IN SUB-
FREEZING CLIMATES.
11
21
11
21
14
11
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
15
12/28/04
P/N 21173402
Download from Www.Somanuals.com. All Manuals Search And Download.
Attach net clips to rim as shown.
12.
WARNING!
CLIP “ARM”
USE OF THIS PRODUCT
19
WITHOUT PROPER
INSTALLATION OF SMART
CLIPS®, OR WHEN ALL SMART
CLIPS® ARE NOT PRESENT
COULD RESULT IN BODILY
HARM. BE SURE TO FOLLOW
DIRECTIONS CAREFULLY.
CLIP “BODY”
Insert one “arm” of clip into ram as shown. Twist “body” of clip
slightly so that second “arm” slides over the top of the first “arm” as
shown.
19
Push in direction indicated by arrows.
A
Push second “arm” back and into ram as shown.
B
Twist “body” of clip slightly again to spread “arms” of clip.
Clip “arms” must be flat and touching edge to edge as shown, not
overlapping.
C
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
16
P/N 21173402 12/28/04
Download from Www.Somanuals.com. All Manuals Search And Download.
Install net.
13.
SIDE VIEW
NETCLIP
NET
Insert net into bottom of clip as shown.
SIDE VIEW
Twist net until it snaps into position.
Net must be centered through clip.
NETCLIP
NET
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
17
12/28/04
P/N 21173402
Download from Www.Somanuals.com. All Manuals Search And Download.
Attach height and moving label (15) to
front of pole as shown. Regulation rim
height is 10 feet.
14.
HEIGHT ADJUSTMENT
Rest unit on support table. Remove adjustment knobs (A)
and carriage bolts (B) to extend or retract backboard and rim.
Height adjustment from
7
1/2’ to 10’.
A
CAUTION!
HEIGHT AND MOVING LABEL
MUST NOT OBSTRUCT
FACTORY ATTACHED
WARNING LABEL.
WARNING
Backboard
may rotate during
height adjustment.
B
WARNING
Do not adjust height of system
in upright position. System must
be in down position to adjust
MOVING SYSTEM
1. While holding pole, rotate
basketball system forward
until wheels engage with
ground.
2. Move basketball system to
desired location.
3. Carefully rotate basketball
system upright.
1
4. Reattach ground restraint and
check system for stability.
2
3
200439
11/00
15
10 feet
(3.05 m)
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
18
P/N 21173402 12/28/04
Download from Www.Somanuals.com. All Manuals Search And Download.
|