Samsung ML-3050 / Dell 1815dn MFP
Oasis Imaging Products, Inc. Technical Support: 800- 322- 8992 ext 110
Reference Information:
OEM Cartridge
Standard
High Yield
Yield @ 5%
4000
8000
Tools Required
Phillips Screwdriver
Small Flathead Screwdriver
Needle Nose Pliers
Supplies Required
Toner
Drum
Wiper Blade
Chip
1. Place the unit on a work bench with the OPC
drum facing up. Using a small flathead
screwdriver, pry off the axle bearing bushing
drum lock. Repeat process on opposite side
(Fig. 1).
Fig. 1
2. Using a Phillips screwdriver, remove the three
screws on the contact side end cap (Fig. 2).
Fig. 2
Samsung ML-3050 / Dell 1815dn MFP
1
Download from Www.Somanuals.com. All Manuals Search And Download.
7. Using a Phillips screwdriver, remove the three
screws on the gear side end cap (Fig. 7).
Fig. 7
8. Using a small flathead screwdriver, depress
the locking tab on the gear side end cap (Fig. 8).
Pry off the end cap as in step 4.
Fig. 8
Fig. 9
9. Remove the PCR cleaning roller housing
and clean the roller with compressed air and
vacuum
(Fig. 9).
10. Spread tabs apart on both sides of the
cartridge while lifting on the OPC drum axle to
separate the toner hopper from the waste
hopper (Fig. 10).
Fig. 10
Samsung ML-3050 / Dell 1815dn MFP
3
Download from Www.Somanuals.com. All Manuals Search And Download.
11. Toner and waste hopper separated (Fig. 11).
Fig. 11
Toner Hopper Disassembly
12. Use a small flathead screwdriver to
unsnap the release lock on the developer
roller end cap (Fig. 12).
Fig. 12
13. Use needle nose pliers to remove the
developer roller end cap (Fig. 13).
Fig. 13
14. Slide the developer roller drive gear off
the developer roller shaft and out of the
housing end (Fig. 14).
Fig. 14
Samsung ML-3050 / Dell 1815dn MFP
4
Download from Www.Somanuals.com. All Manuals Search And Download.
15. Slide the developer roller to the left (1), then
right and out of the hopper section (2).
Clean the developer roller with compressed air
and vacuum. Clean with a cloth and Isopropyl
Alcohol if necessary (Fig 15).
1
2
Fig. 15
Fig. 16
Fig. 17
16. Remove the two screws that hold the doctor
blade with a Phillips screwdriver (Fig. 16). Clean
the doctor blade with compressed air and
vacuum. Clean with a cloth and Isopropyl Alcohol
if necessary.
17. Gently remove the fill plug with a small flat
screwdriver and blow out and vacuum the
inside of the toner hopper (Fig. 17).
Waste Hopper Disassembly
18. Use a small flathead screwdriver to pry off the
E clip from the OPC drum axle (Fig. 18).
Fig. 18
Samsung ML-3050 / Dell 1815dn MFP
5
Download from Www.Somanuals.com. All Manuals Search And Download.
19. Pull the drum axle out towards the direction of
the OPC drum drive gear (grey colored gear)
(Fig. 19).
Note: During reassembly, reinsert the drum axle
into the contact side (thin black gear side) to
alleviate damaging the contact inside the drum.
Fig. 19
20. Hold the PCR by the white gear, push
towards the opposite side until it pops out of
the contact saddle, then pull out of the opposite
side saddle. Remove the PCR and clean with a
lint-free cloth and water (Fig. 20).
Fig. 20
21. Remove the two screws that hold the wiper
blade with a Phillips screwdriver. Clean the
wiper blade with compressed air and vacuum
(Fig. 21).
Fig. 21
22. Clean the waste hopper using compressed
air and vacuum. Check the recovery blade and
replace if necessary (Fig. 22).
Fig. 22
Samsung ML-3050 / Dell 1815dn MFP
6
Download from Www.Somanuals.com. All Manuals Search And Download.
23. The chip is located on the center of the
waste hopper. Use a small flathead screwdriver
to snap off the two ultrasonic weld pins holding
the chip cover in place (Fig. 23).
Fig. 23
24. Remove the chip cover and replace the
chip (Fig. 24).
Fig. 24
25. Stick double sided tape on broken weld
area and reattach the cover (Fig. 25).
Fig. 25
Replace defective parts, add appropriate toner,
and reassemble cartridge in reverse order.
To reach all office in the US & Canada call (800) 322 -8992
Samsung ML-3050 / Dell 1815dn MFP
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Illinois
California
Texas
Canada
North Carolina
Fax: (972) 692-6976
Fax: (714) 908-7788
Fax: (972) 692-6976
Fax: (972) 692-6976
Fax: (603) 386-7575
Corporate Offices
New Hampshire
(603) 880-3991
Tennessee
R & D Center
Fax: (901) 366-9756
South America
International:
(603) 880-1552
Fax: (603) 386-7575
Europe
Netherlands
011-31-24-388-2233
Fax: 011-31-24-355-7373
Fax: (603) 598-4277
© 1998 Oasis Imaging Products, Inc. Any attempt to reproduce any part of these instructions without the written consent of Oasis
Imaging Products, Inc. may result in legal action. All registered trademarks are the property of their respective owners.
Samsung ML-3050 / Dell 1815dn MFP
8
Download from Www.Somanuals.com. All Manuals Search And Download.
|
Nady Systems Portable Speaker PCS 15 User Manual
NEC Life Jacket HX4500 User Manual
NETGEAR Network Router WNDR3800 100NAS User Manual
Nikon Webcam N1405 User Manual
Omron Network Card CJ Series User Manual
OPPO Digital Blu ray Player BDP 105 User Manual
Optimus Car Amplifier 120 1971B User Manual
Panasonic Blood Pressure Monitor EW3006 User Manual
Panasonic Network Card 2SC6054G User Manual
Panasonic TV Mount ETPKE200H User Manual