DSC250 SCALE
for LF1050 and LF1090 Lifts
USER MANUAL
Read these instructions before using the Lumex Lift Scale.
Save these instructions for future reference.
The most current version of these instructions can be
DSC250-INS-LAB-RevB13
Download from Www.Somanuals.com. All Manuals Search And Download.
INTRODUCTION
Safety
WARNING: Important! Read and understand
these instructions before assembling or using
the Lumex Lift Scale. If you do not understand
any part of these warnings or instructions,
contact a healthcare professional for direction
in the use of this product. If the Lift Scale is not
properly assembled, personal injury and damage
to the Lift Scale could result.
WARNING: DO NOT use this product
without proper instruction from a healthcare
professional.
WARNING: If components are damaged or
missing, contact your GF distributor immediately.
DO NOT use substitute parts. Use only Lumex
replacement parts. Non-Lumex replacement parts
could cause personal injury and damage to the
Lift Scale.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
WARNING: This product has a maximum weight
capacity of 600 lb (300 kg). If patient weight
exceeds maximum weight capacity, the scale will
designate overload by displaying “-oL-”. DO not
exceed the maximum weight capacity of the lift
being used for measurement.
WARNING: California Proposition 65 WARNING:
This product contains a chemical known to
the State of California to cause cancer and
reproductive or developmental harm.
WARNING: GF Health Products, Inc. assumes no
responsibility for any damage or injury caused
by improper assembly, installation or use of this
product.
Intended Use
The intended use of the Lift Scale is the measurement
of patient weight.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
ASSEMBLY INSTRUCTIONS
Components
Ensure all components shown below are included in
the package.
Item
Qty
Picture
Description
1
1
Scale
2
3
4
2
2
1
Bushing 1220
Bushing 1020
Universal bracket
5
6
2
2
Pin
Key ring
5
Download from Www.Somanuals.com. All Manuals Search And Download.
1. Follow these instructions to attach the scale to the
LF1050 or LF1090 Lift using the included mounting
hardware. Do not use any other mounting hardware
than that provided.
2. Keep the scale in a cool, dry place. If operation
temperature is over 104°F (40°C), the tolerance will
not be accurate within 0.2 lb (0.1 kg). The storage
temperature is 32°F ~158°F C (0°C ~ 70°).
3. When the low battery indicator ( ) appears in the
lower right corner of the display, replace the
battery (see MAINTENANCE section).
4. If the scale is not used for an extended period of
time, remove the battery.
5. This scale maximum weight capacity is 600 lb
(300 kg). If patient weight exceeds maximum weight
capacity, the scale will designate overload by
displaying “-oL-”.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation on Lumex LF1050 Patient Lift
Install on Lumex LF1050 Patient Lift as shown above.
Item numbers shown are those listed in the table
shown on page 5.
WARNING: Ensure scale is securely mounted as
shown above before proceeding.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation on Lumex LF1090 Patient Lift
Install on Lumex LF1090 Patient Lift as shown above.
Item numbers shown are those listed in the table
shown on page 5.
WARNING: Ensure scale is securely mounted as
shown above before proceeding.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
OPERATION INSTRUCTIONS
Keyboard Illustration
Display Illustration
Instructions for Use
1. Place sling to be used onto spreader bar without
patient/resident/user.
2. Press the On/Zero button on the scale faceplate
to zero-out the weight of the sling (this weight will
remain zeroed out until the Off button is pressed).
3. Press the Kg/lb button to select mode you prefer.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
4. Carefully lift the patient/resident/user in the sling
and perform the lift so that all of the weight is
supported by the lift. Stabilize the movement of the
sling after lifting.
5. Weight will display on the scale. Press the
Operate/Hold button to hold the weight displayed.
To reset the scale to zero, press the Operate/Hold
button again.
6. Lower patient/resident/user safely.
7. If you are weighing another individual using the
same sling, perform the lift and their weight will
display. Press Operate/Hold to maintain their
weight on the scale display.
8. Press the Off button when weighing procedure is
complete.
9. The scale will automatically power off five minutes
after measurement has been completed.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
MAINTENANCE
Cleaning
As needed, wipe scale gently, using mild soap or a mild
disinfectant.
s NOTICE: DO NOT wash under water pressure
or steam clean. DO NOT use solvents, abrasive
cleaners, or scouring pads to clean scale.
Battery Replacement
When the low battery indicator ( ) appears in the
display’s right corner, replace the battery:
1. Open the scale back battery compartment.
2. Remove battery and replace with a 9V alkaline
battery. Ensure that battery polarity is correct.
3. Close the scale back battery compartment.
If the scale is not used for an extended period of time,
remove the battery.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
SPECIFICATIONS
Model Number
Capacity
DSC250
600 lb (300 kg)
Resolution
1/3,000 ±1d
Division
0.2 lb (0.1 kg)
Power Source
Temperature
9V alkaline battery x 1
Operating 32°F ~ 104°F (0°C ~ 40°C)
Storage
32°F ~ 158°F (0°C ~ 70°C)
Dimensions (W x H x D)
Product Weight
3.54 x 2.83 x 2.17 in. (90 x 72 x 55 mm)
24 oz ± .35 oz / 1.5 lb ± .02 lb (675 g ±10 g)
2.60 x 1.28 in. (66.0 x 32.4 mm)
Five digit indication
LCD Display
Display Description
Kg/lb selectable unit mode
Low power alarm battery symbol
S1 “Zero” indication
S4 “Hold” indication
(S2 and S3 are not used)
12
Download from Www.Somanuals.com. All Manuals Search And Download.
LIMITED WARRANTY
GF Health Products, Inc. (“Graham-Field”) guarantees
the Lumex DSC250 Lift Scale free from defects in
materials and workmanship under normal use for two
years from the date of purchase.
If a product is deemed to be under warranty,
GF Health Products, Inc. shall provide, at its option,
(1) replacement of any defective part or product
or (2) a credit of the original selling price made
to GF Health Products, Inc.’s initial customer. The
warranty does not include any labor charges incurred
in replacement part(s) installation or any associated
freight or shipping charges to GF Health Products, Inc.
The warranties contained herein contain all the
representations and warranties with respect to the
subject matter of this document, and supersede all
prior negotiations, agreements and understandings
with respect thereto. The recipient of this document
hereby acknowledges and represents that it has not
13
Download from Www.Somanuals.com. All Manuals Search And Download.
relied on any representation, assertion, guarantee,
warranty, collateral contract or other assurance,
except those set out in this document.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
NOTES
15
Download from Www.Somanuals.com. All Manuals Search And Download.
GF Health Products, Inc.
2935 Northeast Parkway
Atlanta, GA 30360
telephone: 770-368-4700
fax: 770-368-2386
© 2013 GF Health Products, Inc.
Made in Taiwan
Download from Www.Somanuals.com. All Manuals Search And Download.
|