KPS-PT
POWER TOWER
Questions?
Call our toll free Keys Fitness Helpline
1-800-683-1236
Download from Www.Somanuals.com. All Manuals Search And Download.
BEFORE YOU START
Prior to assembly, remove components from the box and verify that all the listed parts
were supplied.
SAFETY INFORMATION WARNING!
Before using this unit or starting any exercise program, consult your physician. This is
especially important for persons over the age of 35 and/or persons with pre-existing
health problems. Keys Fitness Products LP assumes no responsibility for personal
injury or property damage sustained by or through the use of this product.
It is the owner 's responsibility to ensure that all users of this unit have read the Owner
's Manual and are familiar with safety information and precautions.
SAFETY PRECATIONS
• This Power System unit should only be used on a level surface and is intended for
indoor use only. Keys Fitness recommends an equipment mat be placed under the
unit to protect the floor or carpet and for easier cleaning.
• Wear comfortable, good-quality walking or running shoes and appropriate clothing.
Do not use this unit with bare feet, sandals, socks or stockings!
• Always examine your unit before using to ensure all parts are in working order.
• Do not leave children unsupervised near or on the unit.
• Service to your Power System unit should only be performed by an authorized serv-
ice representative, unless authorized and/or instructed by a Keys Fitness technician.
Failure to follow these instructions will void the warranty.
X
Download from Www.Somanuals.com. All Manuals Search And Download.
ASSEMBLY
NOTE: Hand tighten bolts and nylon nuts until machine is fully assembled.
STEP 1
Connect Upright Frame (1) to Base Frame (8) using Bolt (22),
Washers (19) and Nylon Lock Nut (25).
Connect Elbow Pad Support Frame (4) to Upright Frame (1)
using Bolts (24), Washers (19), Large Washers (21) and Nylon
Lock Nuts (25).
Repeat Step 1 for other side of KPS-PT.
Y
Download from Www.Somanuals.com. All Manuals Search And Download.
ASSEMBLY
NOTE: Hand tighten bolts and nylon nuts until machine is fully assembled.
1
11
19
23
5
1
23
11
19
23
23
3
23
19
2
19
19
23
19
23
19
25
25
22
9
8
19
23
8
STEP 2
Connect Back Pad Support Frame (5) to both Upright Frames
(1) using Bolts (23), Washers (19), Nylon Lock Nuts (25) and
Small Plates (11). NOTE: Small Plates (11) are to be placed
on the outside of the machine.
Connect Left and Right Angle Supports (2,3) to Base Frame
(8) and Cross Frame (9) using Bolts (23), Washers (19) and
Nylon Lock Nuts (25).
Z
Download from Www.Somanuals.com. All Manuals Search And Download.
ASSEMBLY
NOTE: Hand tighten bolts and nylon nuts until machine is fully assembled.
STEP 3
Connect Right and Left Chin-Up Bars (6,7) to Upright Frames
using Bolts (22), Washers (19), Nylon Lock Nuts (25) and Big
Plates (12). Attach Bolt Cap (20) On The Bolt (22) End.
NOTE: Big Plates (12) are to be placed on the outside of the
machine.
[
Download from Www.Somanuals.com. All Manuals Search And Download.
ASSEMBLY
NOTE: Hand tighten bolts and nylon nuts until machine is fully assembled.
STEP 4
Connect Back Pad (13) to Back Pad Support Frame using
Bolts (27) and Washers (19).
Connect Elbow Pads (10) to Elbow Pad Support Frames using
Bolts (27) and Washers (19).
\
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS LIST
#
1
2
3
4
5
6
7
DESCRIPTION
QTY
2
Upright Frame
Left Angle Support
Right Angle Support
Elbow Pad Support Frame
Back Pad Support Frame
Right Chin-Up Bar
Left Chin-Up Bar
Base Frame
1
1
2
1
1
1
2
8
9
Cross Frame
Elbow Pad
Small Plate
Big Plate
Back Pad
Plug OD32
Rubber Grip
Grip
Plug 50.8x76.2
End Cap 50.8x76.2
Washer 10
Bolt Cap
Large Washer
Bolt M10x75
1
2
2
2
1
4
2
6
2
4
42
2
4
8
8
4
20
3
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
Bolt M10x80
Bolt M10x100
Nylon Lock Nut
Plug 50.8x50.8
Bolt M10x72
6
]
Download from Www.Somanuals.com. All Manuals Search And Download.
EXPLODED VIEW
^
Download from Www.Somanuals.com. All Manuals Search And Download.
KEYS FITNESS PRODUCTS, L.P.
POWER SYSTEM SERIES
LIFETIME WARRANTY
This Warranty applies in the United States and Canada to products manufactured or distributed by
Keys Fitness Products, LP (“Keys”) under the KEYS brand name. The warranty period to the origi-
nal purchaser is lifetime of the original purchaser.
Keys warrants that the Product you have purchased for non-commercial, personal, family, or
househould use from Keys or from an authorized Keys reseller is free from defects in materials or
workmanship under normal use during the warranty period. Your sales receipt, showing the date
of purchase of the Product, is your proof of purchase. This warranty only extends to you, the origi-
nal purchaser. It is not transferable to anyone who subsequently purchases the Product from you.
It excludes expendable parts (wear items). Wear items pertain to components that might need to be replaced due to nor-
mal wear and tear. These items vary per product but will include grips, chains, cables, pads, upholstery, pulleys, bearings,
etc. Please contact a Keys customer service representative for specifics on wear items. This Warranty becomes VALID
ONLY if the product is purchased through a Keys Fitness authorized dealer unless otherwise authorized by Keys Fitness
in writing and must be assembled / installed according to the instructions included with the Product.
In a light institutional setting, Keys will extend a one year warranty to the the original purchaser.
During the warranty period Keys will repair or replace (at Keys' option) the product if it becomes defective, malfunctions, or
otherwise fails to conform with this Warranty under normal use. In repairing the Product, Keys may replace defective parts,
or at the option of Keys, serviceable used parts that are equivalent to new parts in performance. All exchanged parts and
Products replaced under this warranty will become the property of Keys. Keys reserves the right to change manufacturers
of any part to cover any existing warranty.
This warranty DOES NOT COVER shipping charges, export taxes, custom duties and taxes, or any other charges associ-
ated with transportation of the parts or Product. To obtain warranty service, you must contact a Keys authorized retailer,
service technician or Keys Fitness at our phone number located in this manual. Any parts determined to be defective must
be returned to Keys to obtain warranty service. You must prepay any shipping charges, export taxes, custom duties and
taxes, or any other charges associated with transportation of the parts or Product. In addition, you are responsible for
insuring any parts or Product shipped or returned. You assume the risk of loss during shipment. You must present Keys
with proof-of-purchase documents (including the date of purchase). Any evidence of alteration, erasing or forgery of proof-
of-purchase documents will be cause to void this Warranty.
This Warranty does not extend to any product not purchased from Keys or from an authorized Keys reseller. This Limited
Warranty does not extend to any Product that has been damaged or rendered defective; (a) as a result of accident, mis-
use, or abuse; (b) by the use of parts not manufactured or sold by Keys; (c) by modification of the Product or normal wear
and tear; (d) operation on incorrect power supplies; or (e) as a result of service by anyone other than Keys, or an author-
ized Keys warranty service provider. Product on which the serial number has been defaced or removed is not eligible for
warranty service. Should any Product submitted for warranty service be found ineligible, an estimate of repair cost will be
furnished and the repair will be made if requested by you upon Keys' receipt of payment or acceptable arrangements for
payment.
EXCEPT AS EXPRESSLY SET FORTH IN THIS WARRANTY, KEYS MAKES NO OTHER WARRANTIES, EXPRESSED
OR IMPLIED, INCLUDING ANY IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR
PURPOSE. KEYS EXPRESSLY DISCLAIMS ALL WARRANTIES NOT STATED IN THIS LIMITED WARRANTY. ANY
IMPLIED WARRANTIES THAT MAY BE IMPOSED BY LAW ARE LIMITED TO THE TERMS OF THIS LIMITED WARRAN-
TY. NEITHER KEYS NOR ANY OF ITS AFFILIATES SHALL BE RESPONSIBLE FOR INCIDENTAL OR CONSEQUEN-
TIAL DAMAGES. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS OR
THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE ABOVE LIMITATIONS
OR EXCLUSION MAY NOT APPLY TO YOU. This Limited Warranty gives you specific legal rights and you may also have
other rights that may vary from state to state. This is the only express warranty applicable to Keys-branded products.
Keys neither assumes nor authorizes anyone to assume for it any other express warranty.
TEN (10) DAYS OF PURCHASE TO REGISTER YOUR UNIT WITH KEYS FITNESS PRODUCTS, LP. MAIL WARRAN-
TY CARD TO: KEYS FITNESS PRODUCTS, PO BOX 551239, DALLAS, TX 75355
Download from Www.Somanuals.com. All Manuals Search And Download.
Download from Www.Somanuals.com. All Manuals Search And Download.
Keys Fitness Products, L.P.
4009 Distribution Drive, Suite 250
Garland, Texas 75041
Customer Service: 1-800-683-1236
Download from Www.Somanuals.com. All Manuals Search And Download.
|