K 2.01
English
Please keep the original box, packaging and receipt. Before operating this
unit, please read this manual thoroughly and retain it for future reference.
5.961-519.0 01/05
Download from Www.Somanuals.com. All Manuals Search And Download.
MODEL OVERVIEW
Item Description:
1 ON/OFF switch
ƽ CAUTION
Follow the maintenance instructions
specified in the manual
This machine has been designed for
use with cleaning detergents by the ma-
nufacturer. The use of other cleaning
detergents may affect the operation of
the machine and void the warranty.
2 Connector for detergent suction tube
3 High pressure outlet
4 Water inlet with
garden hose connector
5 Detergent suction tube with filter
6 Vario power spray wand
7 Trigger gun
8 Trigger gun safety lock
9 High pressure hose
10 Power cord
For household use only !
English 3
Download from Www.Somanuals.com. All Manuals Search And Download.
IMPORTANT SAFETY INSTRUCTIONS
WARNING!
! The Trigger Gun Safety Lock PRE-
VENTS the trigger from accidentally
being engaged. This safety feature
DOES NOT lock trigger in the ON
position.
When using this product basic
precautions should always be
followed, including the following:
! Read all the instructions before
using the product.
ƽ WARNING
!
!
!
DO NOT SPRAY ELECTRICAL AP-
PARATUS AND WIRING.
! To reduce the risk of injury, close su-
pervision is neccessary when a pro-
duct is used near children.
! Know how to stop the product and
bleed pressures quickly. Be thoroug-
hly familiar with the controls.
DO NOT USE WITH FLAMMABLE LI-
QUIDS AND TOXIC CHEMICALS.
INJECTION HAZARD: EQUIPMENT
CAN CAUSE SERIOUS INJURY IF
THE SPRAY PENETRATES THE
SKIN. DO NOT POINT THE GUN AT
ANYONE OR ANY PART OF THE BO-
DY. IN CASE OF PENETRATION
SEEK MEDICAL AID IMMEDIATELY.
THIS SYSTEM IS CAPABLE OF
PRODUCING 1400 PSI TO AVOID
RUPTURE AND INJURY, DO NOT
OPERATE THIS PUMP WITH COM-
PONENTS RATED LESS THAN 1400
PSI WORKING PRESSURE (INCLU-
DING BUT NOT LIMITED TO SPRAY
GUNS, HOSE AND HOSE CONNEC-
TIONS).
!
Stay alert — watch what you are doing.
! Do not operate the product when fa-
tigued or under the influence of alco-
hol or drugs.
! Keep operating area clear of all per-
sons.
! Do not overreach or stand on unsta-
ble support. Keep good footing and
balance at all times.
! Follow the maintenance instructions
specified in the manual.
!
! Risk of Injection or Injury to persons
- Do not direct discharge stream at
persons.
!
BEFORE SERVICING, CLEANING
OR REMOVING ANY PARTS, SHUT
OFF POWER AND RELIEVE PRES-
SURE.
!
High pressure jets can be dangerous if
subject to misuse. The jet must not be
directed at persons, animals, electrical
devices, or the machine itself.
! Wear safety goggles.
! Do not use acids and solvents in this
SAVE THESE
product. These products can cause INSTRUCTIONS !
physical injuries to the operator and
irreversible damage to the machine.
! To reduce the risk of electrocution,
keep all connections dry and off the
ground.
! Do not touch plug with wet hands.
4 English
Download from Www.Somanuals.com. All Manuals Search And Download.
Extension Cords
WATER SUPPLY (Cold Water Only)
! Use only extension cords with a suf-
ficient gauge.
ƽ CAUTION
Dirt in the feed water will damage the
unit. To avoid this risk, we recommend
fitting a water filter.
Up to 25 ft = 12/3 AWG;
25 to 50 ft = 10/3 AWG.
! Water hose must be at least 1/2 inch
or 5/8 inch in diameter.
! Flow rate of water supply must not
fall below 2 GPM (gallons per minu-
te).
! Flow rate can be determined by run-
ning the water for one minute into an
empty 5-gallon container.
! The water supply temperature must
not exceed 104°F/40°C.
! Use only extension cords that are in-
tended for outdoor use. These ex-
tension cords are identified by the
marking “Acceptable for use with
outdoor appliances; store indoors
while not in use.”
! Use only extension cords having an
electrical rating not less than the ra-
ting of the product.
! Do not use damaged extension
cords.
! Examine extension cord before
using and replace if damaged.
! Do not abuse extension cord and do
! Never use the pressure washer to
draw in water contaminated with sol-
vents, e.g. paint thinners, gasoline,
oil, etc.
not yank on any cord to disconnect. ! Always prevent debris from being
drawn into the unit by using a clean
water source.
! Keep cord away from heat and sharp
edges.
! Always disconnect the extension
cord from the receptacle before dis-
connecting the product from the ex-
tension cord.
!
If you are using an extension cord, it
should always be completely un-
wound from the cable drum.
ƽ WARNING
To reduce the risc of electrocution, keep
all connections dry and off the ground.
Do not touch plug with wet hands.
English 5
Download from Www.Somanuals.com. All Manuals Search And Download.
ASSEMBLY INSTRUCTIONS
Attach the high pressure hose to the
" STEP 4: Connect the detergent suc-
trigger gun:
tion tube to the pressure washer.
" STEP 1: Pull out the locking slide
from the right side of the trigger gun
handle.
" STEP 2: Insert the small end of the
high pressure hose into place
" STEP 3: Push the locking slide back
into the trigger gun (C) to lock the
hose in position.
6 English
Download from Www.Somanuals.com. All Manuals Search And Download.
OPERATING INSTRUCTIONS
" STEP 1: Connect the high pressure " STEP 4: Connect garden hose to the
hose to the unit’s high pressure out-
let.
cold water source and turn water on
completely. Plug the power cord into
the power outlet.
" STEP 2: Insert the spray wand to the
trigger gun. Press in against the
spring tension and twist into locked
position.
" STEP 5: Unlock the Safety lock (A).
Trigger the gun (B) to eliminate trap-
ped air, wait for a steady flow of wa-
ter to emerge from the spray nozzle.
" STEP 3: Connect garden hose to
" STEP 6: Turn on the high pressure
washer (I/ON).
unit’s water inlet.
The motor starts only if the trigger
of the gun is pulled and shuts off
when the trigger is released.
English 7
Download from Www.Somanuals.com. All Manuals Search And Download.
USING THE ACCESSORIES
ƽ WARNING
To avoid serious injury never point
spray nozzle at yourself, other per-
sons or animals.
Vario Power Spray Wand
! The vario power spray wand allows
you to adjust the cleaning pressure.
! To clean at maximum pressure, the
wand must be positioned to the high
pressure setting (Max).
! For lower pressure turn the wand
collar in the minus (Min) direction.
! To apply detergent, the wand must
be positioned to the low pressure
setting (Min).
8 English
Download from Www.Somanuals.com. All Manuals Search And Download.
WORKING WITH DETERGENTS
Detergents can only be applied at
low pressure (Min).
" STEP 1: Install the vario power
spray wand. Set the spray wand to
the low pressure setting (Min).
For best results see Cleaning Tips on
pages 12 & 13 for specific informati-
on on how to clean different sur-
faces.
Always Use Kärcher Detergent for
Best Results
Kärcher biodegradable detergents are
specially formulated to protect the envi-
ronment and your pressure washer.
Special formula won’t clog the suction
tube filter and will protect the internal
parts of the pressure washer for a lon-
ger life. For Kärcher Detergents, check
your retailer or call our service center for
" STEP 2: Fill a container with Kärcher help.
detergent. Place the filter end of de-
tergent suction tube into the contai-
ner.
The following Kärcher detergents are
available:
! Pressure wash
! Deck + Fence wash
! Degreaser
! Vehicle wash
ƽ CAUTION
Never use:
– Bleach, Chlorine products and other
corrosive chemicals
– Liquids containing solvents (i.e.,
paint thinners, gasoline, oils)
– Tri-sodium phosphate products
– Ammonia products
" STEP 3: Turn on the pressure was-
her (1). Pull trigger to operate unit:
Liquid detergent is drawn into the
unit and mixed with water. Apply de-
tergent to work area. Do not allow
detergent to dry on surface.
– Acid-based products
These chemicals will harm the unit and
will damage the surface being cleaned.
English 9
Download from Www.Somanuals.com. All Manuals Search And Download.
SHUTTING DOWN
STEP 1: Turn the switch to 0/OFF posi- STEP 5: Disconnect the high pressure
tion and unplug cord from outlet.
hose from the high pressure outlet.
STEP 6: Release trigger (A) and enga-
ge gun safety lock (B).
STEP 2: Turn off the water source.
STEP 3: Press trigger to release water
pressure.
3
2
B
A
STEP 4: Disconnect the garden hose
from the water inlet on the unit..
TAKING A BREAK ..five minutes or more
STEP 1: Release trigger (A) and enga-
ge gun safety lock (B).
STEP 2: Turn pressure washer to
(0/OFF) position.
10 English
Download from Www.Somanuals.com. All Manuals Search And Download.
WINTERIZING AND LONG-TERM STORAGE
" 1: Disconnect all water connections.
" 2: Turn on the machine for a few se-
conds, until the water which had
remained in the pump exits, turn off
immediately.
" 3: Do not allow high pressure hose
to become kinked.
" 4: Store the machine and accesso-
ries in a room which does not reach
freezing temperatures. DO NOT
store near furnace or other sources
of heat as it may dry out the pump
seals.
ƽ CAUTION
Failure to follow the above directions
will result in damage to the pump as-
sembly and accessories.
CARE AND MAINTENANCE INSTRUCTIONS
Cleaning the water inlet filter
Maintenance
Pull out the water inlet filter with flat-
nose pliers and rinse out in warm water.
The appliance is maintenance-free.
Cleaning the detergent inlet filter
Pull it out and rinse out in warm water.
English 11
Download from Www.Somanuals.com. All Manuals Search And Download.
CLEANING TIPS
keeping the spray nozzle approximately
6 inches from the cleaning surface.
Deck Cleaning
(with or without detergent). Pre-rinse
deck and surrounding area with fresh
water. If using Kärcher Deck Wash, ap-
ply to surface at low pressure. For best
results, limit your work area to smaller
sections of approximately 25 square
feet. Allow Deck Wash to remain on sur-
face 1-3 minutes. Do not allow deter-
gent to dry on surface. Rinse at high
pressure in a long sweeping motion
keeping the spray nozzle approximately
3-6 inches from the cleaning surface.
Always clean from top to bottom and
from left to right. When moving on to a
new section of the cleaning surface, be
sure to overlap the previous section to
eliminate stop marks and ensure a more
even cleaning result.
ƽ CAUTION
Do not use rotating jet on siding as it
may cause damage.
Cement Patios, Brick and Stone
(with or without detergent). Pre-rinse
cleaning surface with fresh water. If
using Kärcher Pressure Wash or De-
greaser, apply to surface at low pressu-
re. For best results, limit your work area
to smaller sections of approximately 25
square feet. Allow Pressure Wash or
Degreaser to remain on surface 1-3 mi-
nutes. Do not allow detergent to dry on
surface. Rinse at high pressure in a
sweeping motion keeping the spray
nozzle approximately 3-6 inches from
the cleaning surface. Always clean from
ƽ CAUTION
Do not use rotating jet on wood surfaces top to bottom and from left to right. For
as it may cause damage.
removing extremely stubborn stains,
use the rotating jet.
House Siding
Cars, Boats & Motorcycles
(with or without detergent). Pre-rinse
cleaning surface with fresh water. If
(with or without detergent). Pre-rinse
using Kärcher Pressure Wash, apply to vehicle with fresh water. If using
surface at low pressure (for best results, Kärcher Vehicle Wash, apply to surface
limit your work area to sections of ap-
proximately 6 feet and always apply de- one side of vehicle at a time and always
tergent from bottom to top). Allow apply detergent from bottom to top, do
at low pressure. For best results, clean
Pressure Wash to remain on surface 1- not allow detergent to dry on surface. If
3 minutes. Do not allow detergent to dry needed, use special wash brush attach-
on surface, if surface appears to be
drying, simply wet down surface with
ment to remove stubborn dirt. Rinse at
high pressure in a sweeping motion
fresh water. If needed, use special wash keeping the spray nozzle approximately
brush attachment to remove stubborn
dirt. Rinse at high pressure from top to
bottom in an even sweeping motion
6-8 inches from the cleaning surface (di-
stance should increase when rinsing
pin-striping or other sensitive surfaces).
Always clean from top to bottom and
12 English
Download from Www.Somanuals.com. All Manuals Search And Download.
from left to right. For best results, wipe
surface dry with a chamois or soft dry
cloth.
Patio & Lawn Furniture
(with or without detergent). Pre-rinse
furniture and surrounding area with
fresh water. If using Pressure Wash, ap-
ply to surface at low pressure. Allow
Pressure Wash to remain on surface 1-
3 minutes. Do not allow detergent to dry
on surface. If needed use special Wash
Brush Attachment to remove stubborn
dirt. Rinse at high pressure in a
ƽ CAUTION
Do not use rotating jet on vehicles as it
may cause damage.
Barbecue Grills, Outdoor Power
Equipment & Gardening Tools
(with or without detergent). Pre-rinse
cleaning surface with fresh water. If
using Kärcher Pressure Wash or De-
greaser, apply detergent at low pressu-
re. Allow Pressure Wash to remain on
surface 1-3 minutes.Do not allow deter-
gent to dry on surface. Rinse at high
pressure keeping the spray nozzle ap-
proximately 3-6 inches from the cle-
aning surface. For removing extremely
stubborn dirt, it may be necessary to
move the spray nozzle even closer to
the surface for greater dirt cutting ac-
tion.
sweeping motion keeping the spray
nozzle approximately 3-6 inches from
the cleaning surface. For best results,
clean from top to bottom and from left to
right.
ƽ CAUTION
Do not use rotating jet on patio or lawn
furniture as it may cause damage.
Recommendations
! Before cleaning any surface an in-
conspicuous area should be cleaned
to test spray pattern and distance for
maximum cleaning results.
! If painted surfaces are peeling or
chipping, use extreme caution as
pressure washer may remove the
loose paint from the surface.
ƽ CAUTION
Do not use rotating jet on cloth, plastic
or other sensitive surfaces as it may
cause damage.
! When using on surfaces which might
come in contact with food, flush sur-
faces with plenty of drinking water.
OPTIONAL CLEANING ACCESSORIES
Optional cleaning accessories are
available to further enhance your cle-
aning capabilities: For details call
1-800-465-4980 or visit
! Rotating Wash Brush
! Pipe Drain Cleaner
! Sandblasting Attachment
! Extension Wand
! Water Siphon Kit
! 25 Ft. Extension Hose
! T-Racer
! Wash Brush
! Underbody Wand
English 13
Download from Www.Somanuals.com. All Manuals Search And Download.
TROUBLESHOOTING
Disconnect the machine from the power
source before making any repair.
ƽ CAUTION
Symptom
Cause
Solution
Motor will not start
On/Off switch is in the “OFF”
(O) position.
Turn switch to the “ON” (I) posi-
tion
Power cord is not plugged in.
Extension cord is too long.
Plug in power cord.
Replace extension cord with
either a 25 ft. 12/3 gauge cord
or a 50 ft. 10/3 gauge cord.
Extension cord is not proper
gauge.
Extension cord is damaged.
Electrical outlet does not supply Try a different outlet.
adequate power.
Unit does not reach
high pressure.
Diameter of garden hose is too Replace with a 1/2 inch or 5/8
small.
inch garden hose.
Water supply is restricted.
Check garden hose for kinks,
leaks and blockage.
Not enough inlet water supply. Open water source full force.
Water inlet filter is clogged.
Remove filter and rinse out in
warm water.
Spray wand is in low pressure Turn spray wand to high pres-
position. sure position.
Output pressure va-
ries high and low.
Not enough inlet water supply. Turn water on full force. Check
garden hose for kinks, leaks or
blockage.
Pump is sucking air.
Check that hoses and fittings
are air tight. Turn off machine
and purge pump by squeezing
trigger gun until a steady flow of
water emerges through the
nozzle.
Water inlet filter is clogged.
Remove filter and rinse out in
warm water.
Discharge nozzle is obstructed. Blow out or remove debris with
a fine needle.
Calcified gun, hose or spray
wand.
Run distilled vinegar through
detergent suction tube.
14 English
Download from Www.Somanuals.com. All Manuals Search And Download.
Symptom
Cause
Solution
No detergent.
Detergent suction tube not pro- Check connection.
perly connected to the machi-
ne.
Detergent is too thick.
Dilute detergent, for best resul-
ts use Kärcher detergent.
Filter on detergent suction tube Run warm water through filter
is clogged. to remove debris.
Damaged or clogged detergent Remove obstruction or replace
suction tube. detergent suction tube.
Spray wand is in high pressure Turn spray wand tip to low pres-
position. sure position.
Discharge nozzle is obstructed. Blow out or remove debris with
fine needle.
Garden hose connec- Loose fittings.
tion leaks.
Tighten fittings.
Missing/worn rubber washer.
Insert new washer.
Spray wand leaks.
Spray wand not properly atta-
ched.
Insert the spray wand into the
trigger gun. Carefully press in
against the spring tension and
twist into the locked position.
Broken o-ring or plastic insert. Call service center.
Pump is sucking air. Check that hoses and fittings
Pump is noisy.
are air tight. Turn off machine
and purge pump by squeezing
trigger gun until a steady flow of
water emerges through the
nozzle.
Water leaks from
pump (up to 10 drops
per minute is permis-
sible).
Loose fittings.
Check that all fittings are tight.
Call service center.
Water seals are damaged or
worn.
Oil Drip.
Oil seals are damaged or worn. Call service center.
Kärcher Customer Service CDN
Call: 1-800-465-4980 for help or visit
our website: www.karcher.ca
If you encounter any additional difficul-
ties not listed, please call for help.
English 15
Download from Www.Somanuals.com. All Manuals Search And Download.
|