Operating Instructions
50cm ꢀree Standing Gas Cooker
Contents
GB
Introduction, 2
GB
Installation, 3-7
Gas connection
Electrical connection
English,1
Adapting the cooker to different types of gas
Burner and Nozzle Specifications
Safety Information, 8
ꢀeatures, 9
Control Panel, 10
Use of hotplates, 11
Grilling, 12
KD3G2/G
Oven, 13
KD3G2S/IR
KD3G2SL/IR
KD3G21/G
Oven cooking charts, 14
Care and Cleaning, 15
Cooking Results Not Satisfactory?, 16
Something Wrong With Your Cooker?, 17
If it Still Won’t Work..., 18
Technical Characteristics, 19
Key Contacts, 20
KD3G21S/IR
KD3G21SL/IR
You must read these instructions prior to using
your appliance and retain them for future use.
Download from Www.Somanuals.com. All Manuals Search And Download.
Correcting Errata
Operating Instructions:
19508240301; 19506068209; 19507127104; 19506068008; 19508240501
The following information DO NOT apply to the models listed in the instruction booklet:
MAIN OVEN:
"Each shelf has a safety stop to prevent it from being pulled out too far when attending to food.
Shelves are removed from the oven by pulling them out to the stop and then lifting them at the front to withdraw."
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
The appliance must only be installed by a
competent person. In the UK, CORGI registered
installers undertake to work to safe and
satisfactory standards.
! This appliance must not be fitted on a platform.
The cooker is designed to fit between kitchen
cabinets spaced 500mm apart. The space either
side need only be sufficient to allow withdrawal of
the cooker for servicing. It can be used with
cabinets one side or both as well as in a corner
setting. It can also be used free-standing.
Adjacent side walls which project above hob level,
must not be nearer to the cooker than 150mm or
65mm (?ig. A) and should be protected by heat
resistant material. Any overhanging surface or
cooker hood should not be nearer than 750mm.
(?ig.A)
GB
Before moving your cooker check that it is cool, and
switch off at the cooker control unit. Movement of
your cooker is most easily achieved by lifting the
front as follows:
Open the grill door sufficiently to allow a comfortable
grip on the underside front edge of the oven roof,
avoiding any grill elements.
! Take care in moving the
Moving the Cooker
cooker as it is heavy. Take
care to ensure that any floor
covering is not damaged. (see
figure)
a .The cooker may be located in a kitchen, a
diner or bed sitting room, but not in a bathroom or
shower room.
Splashplate optional, apply to
Parts Department (see Back
Cover for contact number.)
b .The hoods must be installed according to the
requirements in the hood handbook.
c .The wall in contact with the back of the cooker
must be of flameproof material.
The following instructions should be read by a
qualified technician to ensure that the appliance is
installed, regulated and technically serviced
correctly in compliance with current regulations.
! remember to unplug the appliance from the
mains before regulating the appliance or carrying
out any maintenance work.
d .The cooker is fitted with a safety chain that must
be attached to a hook, secured to the wall behind
the appliance.
! some models can have their gas connection
inverted. It is important to make sure the safety
chain is always situated on the side which
corresponds to the hose holder (?ig. B).
Positioning
Tall cupboard on the right hand
side of 50cm gas cooker
Tall cupboard on the left hand
side of 50cm gas cooker
! this unit may be installed and used only in
permanently ventilated rooms according to the
British Standards Codes Of Practice: B.S. 6172/B.S.
5440, Par. 2 and B.S. 6891 Current Editions. The
following requirements must be observed:
a. The cooker should not be installed in a bed sitting
room with a volume of less than 20m3. If it is
installed in a room of volume less than 5m3 an air
vent of effective area of 110cm2 is required, if it is
installed in a room of volume between 5m3 and
10m3 a supplementary airvent area of 50cm2 is
required, if the volume exceeds 11m3 no airvent is
required. However, if the room has a door or a
window which opens directly to the outside no air
vent is required even when the volume is between
5m3 and 11m3.
150 mm min
400 mm min
65 mm min
400 mm min
500 mm min
500 mm min
?ig. A
b. During prolonged use of the appliance you may
consider it necessary to open a window to the
outside to improve ventilation.
c. If there are other fuel burning appliances in the
same room, B.S.5440 Part 2 Current Edition,
should, be consulted to determine the requisite air
vent feet in the plinth (900mm - 915mm). Adjust
the feet by tilting the cooker from the side. Then
install the product into position.
?ig. B
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Gas connection
Electrical connection
GB
The cooker should be connected to the gas-supply
by a corgi registered installer. During installation of
this product it is essential to fit an approved gas tap
to isolate the supply from the appliance for the
convenience of any subsequent removal or
Power supply voltage and frequency: 230-240V a.c.
50Hz.
! the supply cable must be positioned so that it
never reaches at any point a temperature 50°C
higher than the room temperature. The cable must
be routed away from the rear vents. Should you
require it, you may use a longer cable, however, you
must ensure that the cable supplied with the
appliance is replaced by one of the same
specifications in accordance with current standards
and legislation.
servicing. Connection of the appliance to the gas
mains or liquid gas must be carried out according to
the prescribed regulation in force, and only after it is
ascertained that it is adaptable to the type of gas to
be used. If not, follow the instructions indicated in
the paragraph headed “Adaptation to different gas
types”. On some models the gas supply can be
connected on the left or on the right, as necessary;
to change the connection, reverse the position of the
hose holder with that of the cap and replace the
gasket (supplied with the appliance). In the case of
connection to liquid gas, by tank, use pressure
regulators that conform to the regulation in force. The
gas supply must be connected to the left of the
appliance. Be sure that the hose does not pass
through the rear of the cooker touching hot parts.
Your appliance is supplied with a 13 amp fused plug
that can be plugged into a 13 amp socket for
immediate use. Before using the appliance please
read the instructions below.
WARNING - THIS APPLIANCE MUST BE
EARTHED.
THE ꢀOLLOWING OPERATIONS SHOULD BE
CARRIED OUT BY A QUALIꢀIED ELECTRICIAN.
Replacing the fuse
! make sure the supply pressure conforms with
the values shown in the table entitled
When replacing a faulty fuse, a 13 amp ASTA
approved fuse to BS 1362 should always be used,
and the fuse cover re-fitted. If the fuse cover is lost,
the plug must not be used until a replacement is
obtained.
“Caracteristics of the burners and nozzles”.
When the cooker is installed between cabinets
(recessed), the gas connection must be effected
by an approved flexible hose with bayonet fitting
(BS 669 Current Edition). The gas inlet for the
cookers is a threaded G 1/2 gas female fitting.
Replacement fuse covers:
If a replacement fuse cover is fitted, it must be of
the correct colour as indicated by the coloured
marking or the colour that is embossed in words on
the base of the plug. Replacements can be obtained
directly from your nearest Service Depot.
Connecting the gas supply
To make the connection, a
flexible hose should be used
HOT PARTS
corresponding to the current
gas regulations which are:
Removing the plug:
•
the hose must never be at
any point in its lenght in
contact with the “hot” parts of
the cooker;
If your appliance has a non-rewireable moulded plug
and you should wish to remove it to add a cable
extension or to re-route the mains cable through
partitions, units etc., please ensure that either:
• the plug is replaced by a fused 13 amp re-
wireable plug bearing the BSI mark of approval.
or:
• the hose must never be longer than 1,5 metre;
• the hose must not be subject to any tension or
torsional stress and it must not have any
excessively narrow curves or bottlenecks;
• the hose must be easy to inspect along its entire
length to check its condition;
• the mains cable is wired directly into a 13 amp
cable outlet, controlled by a switch, (in
• the hose must always be in good condition, never
attempt to repair.
compliance with BS 5733) which is accessible
without moving the appliance.
! the installation must comply with gas safety
(installation and use) regulations 1984. In all cases
for the above, by low, a qualified, corgi approved
engineer must be called for installation.
Please note: for appliances with a rating greater
than 13 amp (eg: electric hob, double ovens and
freestanding electric cookers etc.) the mains cable
must be wired into a cooker output point with a
4
Download from Www.Somanuals.com. All Manuals Search And Download.
rating of 45 amp. In this case the cable is not
supplied.
a)replace the hose holder mounted on the appliance
with that supplied in the bag of “cooker
accessories”.
GB
Disposing of the plug:
b)Replacing the burner nozzles on the hob:
• remove the grids and slide the burners from their
housings;
Ensure that before disposing of the plug itself, you
make the pins unusable so that it cannot be
accidentally inserted into a socket. Instructions for
connecting cable to an alternative plug:
•
unscrew the nozzles using
a 7 mm socket spanner, and
replace them with nozzles for
the new type of gas (see table
1 “Burner and nozzle
! the wires in the mains lead are coloured in
accordance with the following code:
Green & Yellow
Blue - Neutral
Brown- Live
- Earth
characteristics”).
•
replace all the components
If the colours of the wires in the mains lead do not
correspond with the coloured markings identifying
the terminals in your plug, proceed as follows:
Connect Green & Yellow wire to terminal marked “E”
by repeating the steps in
reverse order.
c)Minimum regulation of the hob burners:
or
or coloured Green or Green & Yellow.
•
•
turn the tap to minimum;
remove the knob and
Connect Brown wire to terminal marked “L” or
coloured Red.
adjust the regulation screw,
which is positioned in or next
to the tap pin, until the flame
Connect Blue wire to terminal marked “N” or
coloured Black.
If a 13 amp plug (BS 1363) is used it must be fitted
with a 13 amp fuse. A 15 amp plug must be
protected by a 15 amp fuse, either in the plug or
adaptor or at the distribution board. If you are in any
doubt about the electrical supply to your machine,
consult a qualified electrician before use.
is small but steady.
! in the case of liquid gas, the
regulation screw must be
screwed in to the bottom.
• check that the flame does not turn off when you
turn the tap quickly from high to low.
How to connect an alternative plug:
d)Regulating the primary air of the burners:
The primary air of the burners requires no regulation.
The wires in this mains lead
GREEN &
YELLOW
are coloured in accordance
with the following code:
Adapting to different types of gas
13 amp fuse
BROWN
BLUE
“NEUTRAL” (“N”)
In order to adapt the oven to a different type of gas
with respect to the gas for which it was
manufactured (indicated on the label), follow these
simple steps:
CROSS-BAR
CORD GRIP
BLUE
BROWN “LIVE” (“L”)
GREEN AND YELLOW
“EARTH” (“E”)
a) Replacing the oven burner nozzle
• open the oven door fully
Disposing of the appliance
• pull out the sliding oven bottom
When disposing of the appliance please remove the
plug by cutting the mains cable as close as
possible to the plug body and dispose of it as
described above.
Z
V
Adapting the cooker to different types of
gas
V
In order to adapt the cooker to a different type of
gas with respect to the gas for which it was
produced (indicated on the label attached to the lid),
follow these steps:
5
Download from Www.Somanuals.com. All Manuals Search And Download.
• Pry the fixing tab “V” and remove the oven burner
• Unscrew the oven burner nozzle using the socket
spanner for the nozzles “Z”, or a 7 mm socket
spanner, and replace it with a nozzle suited to the
new type of gas (see Table 1).
Important
GB
On completion of the operation, replace the old
rating sticker with one indicating the new type of gas
used. This sticker is available from our Service
Centres.
Take particular care handling the spark
plug wires and the thermocouple pipes.
• Replace all the parts, following the steps
described above in the reverse order.
Note
Should the pressure of the gas used be different (or
vary) from the recommended pressure, it is
necessary to fit a suitable pressure regulator onto
the inlet pipe in compliance with current National
Regulations relative to “regulators for channelled
gas”.
b)Minimum regulation of the gas oven burner with
thermostat:
• light the burner as described in the paragraph
“the oven knob” of the instruction booklet.
• turn the knob to Max for about 10 minutes and
then turn the knob to the Min setting;
• remove the knob;
• regulate the screw positioned outside the
thermostat pin until the flame is small but steady.
! in the case of liquid gas, the regulation screw
must be screwed in to the bottom.
• check that the burner does not turn off when you
turn the knob from Max to Min and and when
you open and close the oven door quickly.
Adapting the gas grill to different types of gas
Replacing the nozzle of the grill burner:
• remove the screw and then slide out the grill
burner “V” (see ?igure);
• unscrew the grill burner nozzle using the special
socket spanner for the nozzles (see ?igure) or
better still a 7mm socket spanner; replace the
nozzle with a nozzle for the new type of gas (see
table 1).
V
I
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Burner and Nozzle Specifications
GB
Liquid Gas
By-Pass Nozzle
Natural Gas
Burner
Diameter
Thermal Power
kW (p.c.s.*)
Flow*
g/h
Nozzle
1/100
Flow*
l/h
1/100
1/100
(mm)
Nominal Reduced
(mm)
(mm)
***
**
(mm)
Fast
(Large)(R)
100 94
3,00
1,90
1,00
0,7
0,4
0,4
41
30
30
87
70
52
218
214
136
71
128
286
181
95
Semi Fast
(Medium)(S)
75 69
51 46
138
73
104
76
Auxiliary
(Small)(A)
Oven
Grill
-
-
2,60
2,50
0,6
1,3
36
63
71
80
189
182
186
179
115
122
248
238
Nominal (mbar)
Minimum (mbar)
Maximum (mbar)
28-30
20
35
37
25
45
20
17
25
Supply
Pressures
*
At 15°C and 1013 mbar- dry gas
**
***
Propane
Butane
Natural
P.C.S. = 50,37 MJ/Kg
P.C.S. = 49,47 MJ/Kg
P.C.S. = 37,78 MJ/m3
S
A
S
R
KD3G2/G
KD3G2S/IR
KD3G2SL/IR
KD3G21/G
KD3G21S/IR
KD3G21SL/IR
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Safety Information
When used properly your appliance is completely
safe but as with any electrical product there are
certain precautions that must be observed.
PLEASE READ THE PRECAUTIONS BELOW
BEꢀORE USING YOUR APPLIANCE.
• Never leave anything on the hob surface when
unattended and not in use.
GB
• Never remove the oven shelves whilst the oven is
hot.
• Never heat up unopened food containers as
pressure can build up causing the container to
burst.
Always
• Remove all packing from inside the oven and grill
compartments before switching on for the first time.
• Understand the controls prior to using the appliance.
• Keep children away from the appliance when grilling
as the surfaces will get extremely hot during and
after use.
• Never store chemicals/food stuffs, pressurised
container in or on the appliance, or in cabinets
immediately above or next to the appliance.
• Never place flammable or plastic items on or near
the hob.
• Never fill a deep fat frying pan more than 1/3 full of
oil, or use a lid. DO NOT LEAVE UNATTENDED
WHILE COOKING.
• Turn controls off when you have finished cooking
and when not in use.
• Stand back when opening an oven door to allow any
build up of steam or heat to disperse.
• Never operate the grill with the grill door closed as
this will cause the appliance to overheat.
• Never use the appliance as a room heater.
• Never use the grill to warm plates.
• Use dry good quality oven gloves when removing
items from the oven/grill.
• Place pans centrally over the hotplate making sure
handles are kept away from the edge of the hob and
cannot become heated by other hotplate/pans.
• Take care to avoid heat/steam burns when operating
the controls.
• Never dry any items on either the hob or oven doors.
• Never install the appliance next to curtains or other
soft furnishings.
• Never use steam cleaners.
• The appliance should not be operated by people
(including children) with reduced physical, sensory
or mental capacities, by inexperienced individuals
or by anyone who is not familiar with the product.
These individuals should, at the very least, be
supervised by someone who assumes responsibility
for their safety or receive preliminary instructions
relating to the operation of the appliance.
• Do not let children play with the appliance.
• Turn off the electricity supply at the wall switch
before cleaning and allow the appliance to cool.
• Make sure the shelves are in the correct position
before switching on the oven.
• Keep the oven and grill doors closed when the
appliance is not in use.
• Take care when removing items from the grill when
the lower oven is on as the contents will be hot.
• Keep the appliance clean, as a build up of
grease or fat from cooking can cause a fire.
• ?ollow the basic principles of food handling and
hygiene to prevent the possibility of bacterial
growth.
SAꢀETY ADVICE IN CASE Oꢀ A CHIP-PAN ꢀIRE
In the event of a chip pan fire or any other pan fire.
1. TURN O?? THE COOKER APPLIANCE AT THE
WALL SWITCH.
• Keep ventilation slots clear of obstructions.
• Refer servicing to a qualified appliance service
engineer.
2. COVER THE PAN WITH A ?IRE BLANKET OR
DAMP CLOTH, this will smother the flames and
extinguish the fire.
• Take care to avoid touching heating elements inside
the oven, as during use the oven becomes hot.
3. LEAVE THE PAN TO COOL ?OR AT LEAST 60
MINUTES BE?ORE MOVING IT. Injuries are often
caused by picking up a hot pan and rushing outside
with it.
Never
• Never line the interior of the oven with foil as this
may cause the appliance to overheat.
• Never leave children unsupervised where a cooking
appliance is installed as all surfaces will be hot
during and after its use.
NEVER USE A ꢀIRE EXTINGUISHER TO PUT OUT
A PAN ꢀIRE as the force
of the extinguisher is likely to tip the pan over.
Never use water to extinguish oil or fat fires.
• Do not allow children or persons who are not familiar
with the appliance to use it, without supervision.
• Never allow anyone to sit or stand on any part of the
appliance.
!
The appliance must be used by adults only for the
preparation of food, in accordance with the
instructions outlined in this booklet. Any other use
of the appliance (e.g. for heating the room)
constitutes improper use and is dangerous. The
manufacturer may not be held liable for any
damage resulting from improper, incorrect and
unreasonable use of the appliance.
• Never store items above the appliance that children
may attempt to reach.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
ꢀeatures
GB
HOB VENTILATION SLOTS
1900W
3000W
1900W
1000W
CONTROL
PANEL
GRILL/MEAT PAN
WITH REMOVABLE
HANDLE AND WIRE
FOOD SUPPORT
GRILL
MODEL & SERIAL
NUMBER
GRILL DOOR
REMOVABLE
INNER GLASS
DOOR
MAIN OVEN
WIREWORK
SHELF
SUPPORTS
OVEN ROD
SHELVES
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Control Panel
TIMER*
GB
RIGHT
FRONT
BURNER
GRILL
RIGHT
REAR
BURNER
LEFT
REAR
BURNER
LEFT
FRONT
BURNER
ELECTRONIC*
Ig GNITION
BUTTON
MAIN
OVEN
Control Knobs for the gas burners
Models with Hob Gas Burner Safety Devices to
Prevent Leaks *
The position of the gas burner controlled by each
one of the knobs is shown by a solid ring •. To light
one of the burners, hold a lighted match or lighter
near the burner and, at the same time, press down
and turn the corresponding knob counter clockwise
These models can be identified by the presence of
the device itself.
! Since the hob burners are equipped with a safety
device, you must hold the control knob in for about
3-7 seconds after the burner has been lighted to
allow the gas to pass until the safety thermocouple
has heated.
to the maximum E setting. Each burner can be
operated at its maximum, minimum or intermediate
power. Shown on the knob are the different symbols
for off • (the knob is on this setting when the symbol
corresponds with the reference mark on the control
HOB GAS BURNER
SAFETY DEVICE
panel), for maximum E and minimum C. To obtain
these settings, turn the knob counter clockwise with
respect to the off position. To turn off the burner,
turn the knob clockwise until it stops (corresponding
again with the • symbol).
ELECTRONIC
LIGHTING DEVICE
Electronic Ignition for the Gas Hob*
This device operates when a slight pressure is
applied to the button marked with
symbol. To
Timer *
light a specific burner just press the button
while
To use the timer, the buzzer must be wound up by
turning the knob one full turn clockwise; then turn it
back to the desired time so that the number of
minutes on the knob matches the reference mark on
the panel.
pushing the corresponding knob all the way in and
turning it counter-clockwise until it lights. 2or
immediate lighting, first press the button
and then turn the knob.
! Should the burner flames accidentally go out,
turn off the control knob and wait at least 1
minute before trying to relight.
* (only available on certain models)
10
Download from Www.Somanuals.com. All Manuals Search And Download.
Use of Hotplates
Practical Advice on Using the Burners
Each burner is fitted with a spark ignitor for lighting
the gas. To ensure rapid lighting of the burners
every time they are used, the ignitors must be kept
clean and dry. Remove any food spillage or
cleaning materials from the electrode using a small
nylon brush such as a tooth brush. Access to the
electrode can be achieved by lifting off the loose
burner parts carefully when the burners are cool.
When the hotplate burner bodies and caps are
removed for cleaning, be careful not to drop any
food particles or cleaning materials into the burner
bases, to avoid the possibility of blocking the gas
jets.
GB
To use the burners as efficiently as possible, some
basic guidelines should be followed:
• Use cookware that is the right size for each burner
(see table) in order to prevent the flame from
spreading beyond the bottom of the cookware.
• Only use cookware with flat bottoms.
• As soon as the boiling point is reached, turn the
knob to the lowest setting.
• Always use lids with pots and pans.
Burner
ø Cookware diameter (cm)
Fast (R)
24 - 26
16 - 20
10 - 14
If aluminium based pans are used, a silvery deposit
may appear on the top edge of the pan support
fingers. See 'Care and Cleaning' section for cleaning
information.
Semi Fast (S)
Auxiliary (A)
! On models equipped with a reduction grid, the
grid should only be used with the auxiliary burner
when cookware with a diameter of less than 12 cm is
used.
SA-ETY REQUIREMENTS -OR DEEP -AT
-RYING
1. Never fill chip pans more than one third full with oil
or fat.
1. Press the ignition button and then push in and
turn the control knob of the chosen burner anti-
clockwise to the large flame symbol. Continue to
press the ignition button until the sparks light the
gas.
2. Never leave oil or fat unattended during the
heating or cooling period.
3. Never heat fat or fry with a lid on the pan.
4. Always dry food thoroughly before frying, and
lower it slowly into the hot oil or fat. ?rozen foods
in particular will cause frothing and spitting if
added too quickly.
2. Turn the control knob anti-clockwise to the desired
setting. Only turn the control knob between the
large flame symbol and the small flame symbol
for adjusting the setting.
5. Always keep the outside of the pan clean and free
from streaks of oil or fat.
3. To turn off, turn the control knob fully clockwise to
the symbol O.
HOW TO DEAL WITH A ꢀAT ꢀIRE
DO NOT use the hotplate unless all pan supports
are in position.
1. Do not move the pan.
DO NOT use mis-shapen pans which may be
unstable.
2. Turn off the hotplate burners.
3. Smother the flames with a fire blanket or damp
cloth to extinguish the fire. Do not use water or a
fire extinguisher as the force of it may spread the
burning fat or oil over the edge of the pan.
4. Leave the pan for at least 60 minutes before
moving it.
DO NOT use round base woks directly on the
pan supports.
DO NOT use the glass lid (if fitted) as a working
surface.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
Grilling
Relighting‘ the burner
GRILLING MUST BE DONE WITH THE GRILL
DOOR OPEN.
GB
In the event of the burner flames being accidentally
extinguished, turn off the burner control and do not
attempt to re-ignite the burner for at least one
minute.
CONTROL KNOBS MAY BECOME HOT DURING
GRILLING.
CAUTION: ACCESSIBLE PARTS WILL BECOME
HOT WHEN THE GRILL
IS USED - CHILDREN SHOULD BE KEPT AWAY.
Using the grill pan kit
The grill pan handle is detachable from the pan to
facilitate cleaning and storage. ?ix the pan handle
securely before use:
To operate the grill proceed as follows:
• Open the grill door and remove the grill pan.
• Press the ignition button and then push in and
turn the grill control knob anti-clockwise to the
large flame symbol. Continue to press the ignition
button until the spark lights the gas.
1. ?it the handle to the grill pan so that the external
‘hooks’ embrace the edge of the pan (fig. 1)
2. Make sure that the middle part of the handle fits
exactly the protruding support of the pan (fig .2)
and holds the pan from the bottom.
The food must be placed on the rack in the grill pan.
Position the grill pan on top of the oven rack. The
best results are achieved by placing the oven rack
on the uppermost shelves. Pouring a little water into
the grill pan will make the collection of grease
particles more efficient and prevent the formation of
smoke.
• Turn the control knob anti-clockwise to the desired
setting. There is a delay of about six seconds
whilst the safety device operates before the
burner comes on full. Only turn the control knob
between the large flame symbol and the small
flame symbol when adjusting the setting.
• To turn off, turn the control knob fully clockwise to
the symbol O
! (only on a few models):
A
when using the grill, the oven
door must be left open by
positioning the deflector “B”
between control panel and
deflector “A” to prevent the
cooker knobs from
B
2
1
overheating.
Slide the grill pan along the runner towards the rear
of the grill compartment until it stops. An odour may
be noticed when first using the grill - this schould
cease after a short period of use.
Grill can be started from cold but for the
best result preheat for approximately five
minutes. Most cooking is done with the heat on
full, but it may be necessary after sealing the food
to reduce the heat as required.
?or au gratin dishes eg. Macaroni Cheese and
meringue toppings eg. Baked Alaska place the dish
on the floor of the grill compartment. The base of the
grill pan can be used for warming fruit garnishes on
the reduced setting.
DO NOT cover the grill pan or grid with aluminium
foil as this can hold fat, intensify the heat and
create a fire hazard.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
Oven
The oven has different heat zones - the thermostat
settings refer to the temperature on the middle shelf;
above this shelf it is hotter and below it is cooler.
Two shelves enable full use of the temperatures
inside the oven.
COLD START COOKING
GB
Anything requiring long slow cooking such as
casseroles and rich fruit cakes can be put into a
cold oven. Satisfactory results can also be obtained
with creamed mixture, rich pastries or yeast
mixtures, but for perfection we recommend
preheating the oven for about 15 minutes.
The grill pan without the handle can be used in the
oven. The maximum size of baking tray that should
be used is 300mm x 330mm (12" x 13").
ROASTING Oꢀ LARGE POULTRY
TO USE THE OVEN
The maximum weight of poultry that can be
accommodated is 8kg (18 Ibs) of suitable shape. It
is important to check that the bird DOES NOT
overhang the burner at the back of the oven.
1. Place oven shelves in the chosen positions (refer
to cooking charts).
2. Press the ignition button and then push in and
turn the oven control knob fully anti-clockwise.
Continue to press the ignition button until the
spark lights the gas.
STORAGE AND RE-HEATING Oꢀ ꢀOOD
3. Turn the control knob clockwise to the required
setting (refer to cooking chart). There is a delay of
about six seconds whilst the safety device
operates before the burner comes on full.
4. To turn off, turn the control knob fully clockwise
the the symbol 0.
It is vitally important to strictly adhere to the basic
principles of food handling and hygiene to prevent
the possibility of bacterial growth.
1. If food is to be frozen or not served immediately,
cool it in a clean container as quickly as possible.
2. Completely thaw frozen food in the refrigerator
before reheating.
Never place dishes on the oven base over the
burner.
3. Re-heat food thoroughly and quickly either on the
hotplate or in a hot oven, Mk. 6, and then serve
immediately.
An odour may be noticed when first using the
oven - this should cease after a short period of
use.
4. Only re-heat food once.
5. The oven temperature control marking are gas
marked 0 to 9.
‘COOK CHILL’ DISHES
The equivalent degrees Celsius (sometimes called Centi-
grade) and degrees Fahrenheit are shown below as a gui-
de.
These should always be placed in a pre-heated oven
ideally on the first or second shelf position. ?ollow
the packet instructions for cooking time.
MAIN OVEN
(Centre Oven Temperature)
MAIN OVEN
Gas Mark
(Centre Oven Temperature)
Celsius
Fahrenheit °F
°C
Gas Mark
Celsius
Fahrenheit °F
°C
ALUMINIUM ꢀOIL
5
210
220
230
235
240
410
430
445
455
465
1
120
150
175
195
250
300
350
385
6
7
8
9
If using Aluminium ?oil:
2
3
4
1. Remember that it is important to increase the
cooking time by one third.
2. Never allow the foil to touch the sides of the oven.
3. Never cover the oven interior with foil.
4. Never cover the oven shelves with foil.
RELIGHTING THE BURNER
In the event of the burner flames being accidentally
extinguished, turn off the burner control and do not
attempt to re-ignite the burner for at least one minute
13
Download from Www.Somanuals.com. All Manuals Search And Download.
Oven Cooking Chart
The following times and setting are for guidance
only. You may wish to alter the setting to give a
result more to your satisfaction. When a different
setting to that shown below is given in a recipe, the
recipe instructions should be followed. Allow 15
minutes preheat for best results. Always turn the
thermostat knob to Mark 9 before selecting the
appropriate gas Mark. Shelf position 1 is the
highest.
GB
Food
Gas
Mark
Shelf
Position
Approx. Cooking Time and Comments
Fish
Oily and white fish
3 or 4
4
25-60 m ins. depending on recipe
Meat and Poultry
Beef
Ham
4 or 5
5
4
4
25-30 mins per 450g (1 Ib) + 25 mins. extra
40 mins per 450g (1 Ib) covered in foil plus 40 mins.
extra
Lamb
Pork
5
5
4
4
30 mins per 450g (1 Ib) + 30 mins extra
40 mins per 450g (1 Ib) + 40 mins extra
25 mins per 450g (1 Ib) + 25 mins extra
25 mins per 450g (1 Ib) + 25 mins extra
15-20 mins per 450g (1 Ib) + 20 mins
2-6 hrs. depending on cut of meat
Chicken
5
4
Duckling & Goose
Turkey
5
4
4 or 5
3
4 or 5
3or4
Casseroles
Vegetables
Baked jacket potatoes
4 or 5
3
4
1½ - 3 hrs. until soft, depending on size
Puddings
1¾-2½ stand dish on baking tray and started with
warm milk
Milk Puddings (500ml/1 pt)
3
Baked Custard (500ml/1 pt)
Baked Sponge Puddings
Baked Apples
3
4
3
1
6
5
4
45-60 mins. bain-marie
40-50 mins
3
3
30-45 mins depending on type and size of apples
15 mins or until "tinged" with brown
45-60 mins
Meringue Topped Puddings
Apple Tart (1 x205mm/8//)
3or4
2
2
Fruit Crumble
35 -45 mins
Cakes, Pastries & Biscuits
Small Cakes 2 trays
1 tray
Victoria sandwich (2 x
5
5
4
5
1
2
4
2
7
2
4
6
5
7
6
2 and 4
15-25 mins.
2
15-22mins.
7"
)
2 and 4
20-30 mins
Swiss Roll (3 egg quantity)
Meringues
2
3
15-20 mins.
2-3 hrs
Christmas cake (1 x 205mm / 8")
3
Time depending on recipe
1¼-1½ hrs.
7")
Madeira cake (1 x 180mm /
4
7")
Rich Fruit cake (1 x 180mm /
Scones
Shortbread (1 x 180mm /
Biscuits
4
Tim e depending on recipe
10-20 mins.
1 and 3
7")
3
55 -65 mins.
1 and 3
10-20 mins.
Shortcrust Pastry
Rich Short Crust
Flaky/Puff Pastry
Choux Pastry
2
15 - 60 mins depending on use.
20-30 mins.
1 and 3
2
2
10-30 mins.
20-30mins.
Yeast Mixtures
Bread - rolls
7
2 and 4
20-30 mins.
Miscellaneous
Yorkshire Pudding:- large
individual
7
7
1
2
30-40 mins
20-30mins
When baking with two trays or tins on two levels, the
top tray is removed first and the lower tray moved
up to the top position for a few minutes longer.
Soft Margarine -
Use the oven settings recommended by the
margarine manufacturer and not those indicated on
the cooking chart.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
Care and Cleaning
Grill
! Oven must not be operated with inner door
glass removed.
GB
Remove the grill pan and the wire grid food support,
it is best to wash these items immediately after use
to prevent stains from being burnt on when used
again. Wipe out the Grill compartment, use a fine
steel wool soap pad to remove stubborn stains from
the grill runners and the floor of the compartment.
Wipe over the control panel with a damp cloth and
polish with a dry cloth.
Take care during cleaning not to damage or distort
the door seals. Do not lift the door seal from the
oven chassis, if necessary remove the seal by
carefully unhooking the corner clips.
Take care that the rating label edges are not lifted
during cleaning, and furthermore that the lettering is
not blurred or removed.
Ovens
Control Panel
Remove the rod shelves and grill pan. Use a fine
steel wool soap pad to remove stubborn stains from
the rod shelves, grill pan and the floor of the oven.
Do not use cream cleaners, oven cleaners or
aerosols, scouring pads or abrasive powder for
cleaning the plastic knobs as damage will occur.
Oven Shelf Supports
Decorative Trims
The shelf supports are removable and dishwasher
safe.
It is advisable to clean the decorative trims regularly
to prevent any build up of soiling. The
To remove hold the support at the front and pull
away from the oven side, this can then be cleaned in
a sink or a dishwasher. When removed it allows
access to the oven side, which can be cleaned with
warm soapy water.
recommended method of cleaning is to wipe over
the trims with a soft cloth wrung out in warm water or
mild non-abrasive cleaner. (If in doubt try the cleaner
on a small area of trim which is not noticeable in
normal use). Then, after wiping with a cloth wrung
out in clear water, dry with a soft clean cloth.
To refit the support, insert the longer leg into the
rear fixing hole and push in the front leg.
Doors
Oven Lamp Replacement
Wipe over the outer door glass panels with a cloth
wrung out in warm soapy water, then after wiping
with a cloth wrung out in clear water, dry with a soft
clean cloth. Ensure that glass doors are not
subjected to any sharp mechanical blows.
Glass Inner Door Panel (where fitted) – open
the door fully and unscrew the two screws securing
the glass panel, taking care not to allow the glass to
fall. The glass panel may now be washed at the
sink. Stubborn stains can be removed by using a
fine steel wool soap pad. Ensure the glass panel
is not subjected to any sharp mechanical
blows. Take particular care not to damage the inner
surface which is coated with a heat reflective layer.
After cleaning, rinse and dry with a soft cloth. ?or
slight soiling the inner glass panel may be cleaned,
while still warm, without removing it from the door.
Open the oven door and remove the rod shelves.
Using a suitable cloth to protect the fingers grip the
light glass dome, unscrew anti-clockwise and lift.
Reach into the aperture with fingers, and unscrew
the lamp anticlockwise. ?it replacement lamp (15W
300°C rated SES), refit dome.
! To avoid electric shocks - please ensure that the
electricity supply to the appliance is switched off
and the appliance is fully cold, before removing
the lamp lens.
15
Download from Www.Somanuals.com. All Manuals Search And Download.
Cooking Results
Not Satisfactory?
GB
Problem
Grilling
Check
Uneven cooking front to Ensure that the grill pan is positioned centrally below
the grill element.
back
Fat splattering
Ensure that the grill is not set to too high a
temperature.
Oven Baking
Uneven rising of cake
Ensure that the oven shelves are level by using a
spirit level on the rod shelf and adjusting, using
suitable packing e.g. wood, under the feet of the
appliance. This should be checked both left to right
and front to back. Ensure that the food is positioned
centrally in the oven.
Sinking of cakes
The following may cause cakes to sink:
1. Cooking at too high a temperature.
2. Using normal creaming method with soft margarine.
Over/Under cooking
Fast/Slow cooking
Refer to the cooking times and temperatures given in
the oven temperature charts, however, it may be
necessary to increase or decrease temperatures by
10°C to suit personal taste.
Do not use utensils greater than 2¼ ins in height.
Uneven cooking of
cakes
1. Too large baking sheet used. (See 'Cookery Notes')
2. Over loading of oven and always ensure even air
gaps around baking tins.
Uneven rising of cake
Ensure that the shelf is level (see above) and that the
food is positioned centrally in the oven.
Food is taking too long Only cook one item at a time to avoid overloading the
to cook
oven.
16
Download from Www.Somanuals.com. All Manuals Search And Download.
Something Wrong with
your Cooker?
Before contacting your nearest Service Centre/Installer, check the problem guide below; there may be nothing
wrong with your cooker.
GB
Problem
Ignition does not work
Check
If all burners fail to ignite:
Check that sparks appear at the burners;
A clicking noise should be heard.
If not
Check that the plug is plugged in to a
13amp Electric socket and the supply
is switched on.
If all burners still fail to ignite
Top Cavity
Grill Burner
Check and replace if necessary the 13amp fuse
If only one burner fails to ignite
Check that the burner is dry and that spillage of food or
cleaning fluid remains are not affecting the Ignitor or burner
ports.
Clean away any debris with a dry nylon brush such as an
old dry toothbrush.
If a wire wool pad has been used for cleaning around the
burner ensure the Ignitor is free from any stray strands.
Any water on the burner should be dried with a cloth or
kitchen towel.
Burner Ports
Burner Ports
Oven Control
Ignitor
Hotplate Burner
Hob Top
On the hotplate make sure that all burner
parts are correctly seated
Ignitor
For correct ignition of oven/grill burners press the ignition button
and then push in and turn control knobs anti-clockwise.
Continue to press the ignition button until the spark lights the gas.
Once alight release the ignition button and continue to hold the
control knob in for a further 6 to 10 seconds.
Oven or Grill will not stay lit
when the control knob is released
Control Panel
Control Knobs
Then release the control knob and set to the required temperature.
The flame should now stay alight.
If the flame does not hold and goes out wait 30 seconds and try
again
Grill Control
Check that the temperature has been set in accordance with
the temperature charts. It may be necessary to increase or
decrease the recommended temperature by 10 C to suit your
taste
Oven Temperature seems too
high or too low
Check the temperature and shelf position are as recommended
in the temperature charts
Oven does not cook evenly.
Check that the Utensil being used in the oven allow sufficient
air flow around them.
Check that the cooker is level.
Check that your pans conform to the recommendations in
these instructions.
Hotplates are slow to boil or will
not simmer
This is normal and should cease after a short period.
Condensation and steam is a by product of cooking food
with a water content.
Odour or smoke when using your new cooker
Condensation / Steam in the Oven After Use
To help minimise always:
A) Try to avoid leaving food in the oven to cool after being cooked
B) Use a coved Utensil wherever possible
Steam and/or condensation may appear from the vent at the rear of
the appliance when using an oven, particularly when cooking foods
with a high water content (Such as Oven Chips or Chicken).
This is normal and any excess should be wiped off
Condensation on the Wall at the Rear of the Cooker
17
Download from Www.Somanuals.com. All Manuals Search And Download.
If It Still Won’t Work...
Contact the Service Office
Spare Parts
GB
Please remember your new appliance is a complex
piece of equipment.
If something is still wrong with your appliance after
you have been through the ‘Something Wrong’ list:
‘DIY’ repairs or unqualified and untrained service
people may put you in danger, could damage the
appliance and might mean you lose cover under the
Parts Guarantee.
1. Switch off and unplug the appliance from the
mains.
2. Call your nearest Service Office or local importer.
If you do experience a problem with the appliance
don’t take risks, call in our Service Engineer. Our
Parts are designed exclusively to fit your appliance.
Do not use them for any other purpose as you may
create a safety hazard.
When you contact us we will want to know the
following:
1. Your name, address and postcode.
2. Your telephone number.
3. Clear and concise details of the fault.
4. The Model number and the Serial number of your
appliance.
Disposal of your product
To minimise the risk of injury to children please
dispose of your product carefully and safely.
Remove all doors and lids. Remove the mains cable
(where fitted) by cutting off flush with the appliance
and always ensure that no plug is left in a condition
where it could be connected to the electricity
supply.
5. The date of purchase (please keep the receipt as
evidence will be required when an engineer calls)
enter the date here:
.............................................................................
Please make sure you have all these details ready
when you call.
To help the environment, Local Authority instructions
should be followed for the disposal of your product.
18
Download from Www.Somanuals.com. All Manuals Search And Download.
Technical Characteristics
The European Directive 2002/96/EC on Waste Electrical and Electronic Equipment (WEEE), requires that old
household electrical appliances must not be disposed of in the normal unsorted municipal waste stream. Old
appliances must be collected separately in order to optimise the recovery and recycling of the materials they
contain and reduce the impact on human health and the environment. The crossed out “wheeled bin” symbol on
the product reminds you of your obligation, that when you dispose of the appliance it must be separately
collected.
GB
Consumers should contact their local authority or retailer for information concerning the correct disposal of their
old appliance.
Mains frequency and voltage of the electric section and characteristics of the gas section
Model
Gas section
Rated power
Electric section
Class
Voltage
kW (1)
KD3G2/G
KD3G2S/IR
KD3G2SL/IR
KD3G21/G
12,90 (938 g/h - G30)
(921 g/h - G31)
II2H3+
220-240V~
50/60Hz
KD3G21S/IR
KD3G21SL/IR
(1) The values in g/h refer to the capacities with liquid gas (Butane, Propane).
TABLE Oꢀ CHARACTERISTSICS
width 39 cm
Main oven
dimensions
height 34 cm
depth 34 cm
Main oven
45 l
Volume
Adaptable for use with all the types
of gas indicated on the data plate.
Burners
Voltage and
frequency
see data plate
This appliance conforms to the
following European Economic
Community directives: 2006/95/EC
dated 12/12/06 (Low Voltage) and
subsequent amendments -
04/108/EC dated 15/12/04
(Electromagnetic Compatibility) and
subsequent amendments -
90/396/EEC of 29/06/90 (Gas) and
subsequent modifications (only for
models which use gas) - 93/68/EEC
dated 22/07/93 and subsequent
amendments.
2002/96/EC
19
Download from Www.Somanuals.com. All Manuals Search And Download.
GB
20
Download from Www.Somanuals.com. All Manuals Search And Download.
GB
21
Download from Www.Somanuals.com. All Manuals Search And Download.
GB
22
Download from Www.Somanuals.com. All Manuals Search And Download.
Guarantee
GB
12 months Parts and Labour Guarantee
Your appliance has the benefit of our manufacturer’s guarantee, which covers the cost of breakdown
repairs for twelve months from the date of purchase.
This gives you the reassurance that if, within that time, your appliance is proven to be defective
because of either workmanship or materials, we will, at our discretion, either repair or replace the
appliance at no cost to you.
This guarantee is subject to the following conditions:
-
The appliance has been installed and operated correctly and in accordance with our operating and
maintenance instructions.
-
-
-
The appliance is used only on the electricity or gas supply printed on the rating plate.
The appliance has been used for normal domestic purposes only.
The appliance has not been altered, serviced, maintained, dismantled, or otherwise interfered with
by any person not authorised by us.
-
-
-
Any repair work must be undertaken by us or our appointed agent.
Any parts removed during repair work or any appliance that is replaced become our property.
The appliance is used in the United Kingdom or Republic of Ireland.
The guarantee does not cover:
-
-
-
Damage resulting from transportation, improper use, neglect or interference or as a result of
improper installation.
Replacement of any consumable item or accessory. These included but not limited to: plugs, cables,
batteries, light bulbs, fluorescent tubes and starters, covers and filters.
Replacement of any removable parts made of glass or plastic.
THIS GUARANTEE WILL NOT APPLY IF THE APPLIANCE HAS BEEN USED IN COMMERCIAL OR NON-
DOMESTIC PREMISES.
5 Year Parts Guarantee
Indesit also offers you a free 5 year parts guarantee. This additional guarantee is conditional on you
registering your appliance with us and the parts being fitted by one of our authorised engineers. There
will be a charge for our engineer’s time. To activate the extra parts warranty on your appliance, simply
call our registration line on 08448 24 24 24 (Republic of Ireland 01 230 0800)
Extended Guarantees
We offer a selection of protection plans that enable you to fully cover yourself against the expense of
repair bills for the life of your policy. To find the ideal plan for you please call our advice line on 08448
226 226 (Republic of Ireland 01 230 0233).
Free Helpdesk Service
We have a dedicated team who can provide free advice and assistance with your appliance if you
experience any technical difficulties within the first 90 days of ownership. Simply call our Indesit
Service Hotline on 08448 224 224 (Republic of Ireland 0818 313 413) for telephone assistance, or, where
necessary, to arrange for an engineer to call.
23
Download from Www.Somanuals.com. All Manuals Search And Download.
Key Contacts
2
09/2009 - 195048072.1
XEROX ,ABRIANO
After Sales Service
GB
No one is better placed to care for your Indesit appliance during the course of its working life than us – the
manufacturer.
Essential Contact Information
Indesit Service
We are the largest service team in the UK and Ireland offering you access to 400 skilled telephone advisors and
1000 fully qualified engineers on call to ensure you receive fast, reliable, local service.
UK: 08448 224 224
Republic of Ireland: 0818 313 413
Please note: Our advisors will require the following information:
Model number:
Serial number:
Parts and Accessories
We supply a full range of genuine replacement parts as well as accessory products that protect and hygienically
clean your appliance to keep it looking good and functioning efficiently throughout its life.
UK: 08448 225 225
Republic of Ireland: 0818 313 413
Appliance Registration
We want to give you additional benefits of Indesit ownership. To activate your free 5 year parts guarantee you must
register your appliance with us.
UK: 08448 24 24 24
Republic of Ireland: 01 230 0800
Indesit Company UK Ltd. Morley Way, Peterborough, PE2 9JB
Indesit Company Unit 49 Airways Industrial Estate, Dublin 17
Recycling and Disposal Information
As part of Indesit’s continued commitment to helping the environment, Indesit reserves the right to use quality,
recycled components to keep down customer costs and minimise material wastage.
Please dispose of packaging and old appliances carefully. To minimise the risk of injury to children, remove the
door, plug, and cut the mains cable off flush with the appliance. Dispose of these parts separately to ensure that
the appliance can no longer be plugged into mains socket, and the door cannot be locked shut.
24
Download from Www.Somanuals.com. All Manuals Search And Download.
|