R
Trademark
Please do not return unit to retailer.
Por favor, no devuelva el aparato al lugar de compra.
Veuillez ne pas retourner l’outil au détaillant.
1-800-554-6723
Operator’s Manual
Manual del Operador
Manuel de L’utilisateur
t
t
TWIST N’ EDGE
XT 35
WARNING:
Read and follow all Safety Rules and Operating Instructions before
using this product. Failure to do so can result in serious injury.
ADVERTENCIA:
Lea el manual del operador y siga todas las advertencias e instruc-
ciones de seguridad. El no hacerlo puede resultar en lesiones graves.
AVERTISSEMENT:
Lire le manuel de l’utilisateur et bien respecter tous les avertisse-
ments et toutes les instructions de sécurité. Tout défaut de le faire
pourrait entraîner des blessures graves.
Frigidaire Home Products, Augusta, GA 30907
WCI Outdoor Products, Inc.
530083927 05/03/99
Download from Www.Somanuals.com. All Manuals Search And Download.
retor by starting the engine and letting it run S Securely tighten wing nut onto bolt.
until it stops.
Slot
S Store unit and fuel in an area where fuel va-
pors cannot reach sparks or open flames
from water heaters, electric motors or
switches, furnaces, etc.
Shield
Bracket
S Store unit so line limiter cannot accidentally
cause injury. Unit can be hung by the tube.
S Store the unit out of the reach of children
SPECIAL NOTICE: This unit is not
equipped with a temperature limiting muffler
and spark arresting screen which meets there-
quirements of California Codes 4442 and 4443.
All U.S. forest land and the states of California,
Idaho, Maine, Minnesota, New Jersey, Ore-
gon, and Washington require by law that many
internal combustion engines to be equipped
with a spark arrestor screen. If you operate in
a locale where such regulations exist, you are
legally responsible for installing and maintain-
ing the operating condition of these parts. Fail-
ure to do so is a violation of the law. If a spark
arrestor is required in your area, contact your
Authorized Service Dealer for the proper kit.
Wing
Nut
Line Limiter Blade
FUELING ENGINE
This engine is certified to operate on unleaded
gasoline. Gasoline must be mixed with a good
quality 2-cycle air-cooled engine oil designed
to be mixed at a ratio of 40:1. Poulan/Weed
Eater brand oil is recommended. (A 40:1 ratio is
obtained by mixing 3.2 ounces of oil with 1 gal-
lon of unleaded gasoline). When mixing fuel fol-
low the instructions printed onthe container. Al-
ways read and follow the safety rules under
FUEL SAFETY.
SPECIAL NOTICE: Exposure to vibrations
through prolonged use of gasoline powered
hand tools could cause blood vessel or nerve
damage in the fingers, hands, and joints of
people prone to circulation disorders or abnor-
mal swellings. Prolonged use in cold weather
has been linked to blood vessel damage in
otherwise healthy people. If symptoms occur
such as numbness, pain, loss of strength,
change in skin color or texture, or loss of feeling
in the fingers, hands, or joints, discontinue the
use of this tool and seek medical attention. An
anti-vibration system does not guarantee the
avoidance of these problems. Users who oper-
ate power tools on acontinualand regular basis
must monitor closely their physical condition
and the condition of this tool.
OPERATION
For occasional use only.
HOW TO STOP YOUR UNIT
Push and hold engine stop switch in the STOP
or OFF position until the unit has fully stopped.
WARNING: The trimmer head will turn
while starting the engine. A hot muffler can
cause serious burns.
HOW TO START YOUR UNIT
WARNING: The trimmer head will turn
while starting the engine. A hot muffler can
cause serious burns.
Starting Position
ASSEMBLY
ATTACHING THE SHIELD
WARNING: The shield helps to protect the
operator and others from thrown objects, and is
equipped with a linelimiter blade which cuts ex-
cess line. This blade (on underside of shield) is
sharp and can cut you.
Knob
S Remove wing nut from shield.
Trigger
S Insert bracket into slot as shown.
S Pivot shield until bolt passes through hole
in bracket.
Primer Bulb
3
Download from Www.Somanuals.com. All Manuals Search And Download.
COLD ENGINE STARTING OR
Small
Hole
STARTING AFTER REFUELING
S Set unit on a flat surface.
Spool
S Slowly press the primer bulb 6 to 8 times.
S Move knob to FULL CHOKE position.
S Squeeze and hold trigger through all remain-
ing steps.
S Pull starter handle until engine attempts to
start, but no more than 5 pulls.
Line in Notch
S Move knob to HALF choke position.
S Pull starter handle until engine runs.
S Allow engine to run 10 seconds, then move
knob to OFF choke position.
RESTARTING A WARM ENGINE
S Move knob to OFF choke position.
S Pull starter handle until engine starts.
S If engine does not start in 5 pulls, follow
instructions in STARTING A COLD ENGINE.
Line exit hole
S Wind the line evenly and tightly onto the
spool. Wind inthedirectionof the arrow found
on the spool.
OPERATING POSITION
S Push the line into the notch, leaving 3 to 5 in-
ches (7 -- 12 cm) unwound.
ALWAYS WEAR:
Eye Protection
S Insert the line into the the exit hole in the hub
as shown in the illustration.
S Align the notch with the line exit hole.
S Push spool into hub until it snaps into place.
S Pull the line extending outside of the hub to
release it from the notch.
Long Pants
Heavy Shoes
MAINTENANCE
Cut from your right to your left.
We recommend all service and adjustments
not listed in this manual be performedby anAu-
thorized Service Dealer.
ADVANCING THE CUTTING LINE
Advance line by tapping the bottom of the cut-
ting head lightly on the ground while engine is
running at full speed. A metal blade attached to
the shield will cut the line to the proper length.
CARBURETOR ADJUSTMENTS
Your carburetor is equipped with limiter caps.
Carburetor adjustment is a complicated task.
We recommend that you take your unit to an
Authorized Service Dealer. Damage will occur
if you turn the needles beyond the limiter stops.
TWIST-N-EDGE
S Pull the tab toward the engine.
S Twist the tube to the edging position; release
the tab.
IGNITION TIMING
The ignition timing is fixed, non-adjustable.
SPARK PLUG
Replace the spark plug yearly using a Cham-
pion RCJ8Y plug. Spark plug gap is .025”.
REPLACING THE LINE
S Remove spool by firmly pulling on tap button.
S Clean entire surface of hub and spool.
S Replace with a pre-wound spool, or cut a
length of 20 feet of .080” (2 mm) diameter
Weed Eaterr brand line. Never use wire,
rope, string, etc., which can break off and be-
come a dangerous missile.
S Insert one end of the line about 1/2 inch (1
cm) into the small hole on the inside of spool.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
TROUBLESHOOTING
Engine will not start.
LIMITED WARRANTY
S Fuel tank empty.
FRIGIDAIRE HOME PRODUCTS, Div. WCI
Outdoor Products, Inc. warrants to the origi-
nal purchaser that each new Weed Eater
brand gasoline tool or attachment is free from
defects in material and workmanship and
agrees to repair or replace under this warranty
any defective gasoline product or attachment
as follows from the original date of purchase.
2 YEARS - Parts and Labor, when used for
household purposes.
90 DAYS - Parts and Labor, when used for
commercial, professional, or incomeproducing
purposes.
30 DAYS - Parts and Labor, if used for rental
purposes.
This warranty is not transferable and does not
cover damage or liability caused by improper
handling, improper maintenance, or the use of
accessories and/or attachments not specifical-
ly recommended by FRIGIDAIRE HOME
PRODUCTS for this tool. Additionally, this war-
ranty does not cover tune-ups, spark plugs, fil-
ters, starter ropes, starter springs, cutting line,
or rotating head parts that will wear and require
replacement with reasonable use during the
warranty period. This warranty does not cover
predelivery setup or normal adjustments ex-
plained in the operator’s manual.
S Engine flooded.
S Spark plug not firing.
S Fuel not reaching carburetor.
S Carburetor requires adjustment.
Engine will not idle properly.
S Carburetor requires adjustment.
S Throttle trigger screw too tight.
Engine will not accelerate, lacks
power, or dies under a load.
S Air filter dirty.
S Spark plug fouled.
S Carburetor requires adjustment.
Engine smokes excessively.
S Air filter dirty.
S Too much oil mixed with gasoline.
S Carburetor requires adjustment.
Line does not advance or breaks while
cutting.
S Line improperly routed in head.
S Line improperly wound on spool.
S Line size incorrect.
Line welds onto spool.
S Line size incorrect
S Line improperly wound on spool.
S Crowding line on material being cut.
Line pulls back into head
S Too little line outside of head.
S Line size incorrect.
THIS WARRANTY GIVES YOU SPECIFIC
LEGAL RIGHTS, AND YOU MAY HAVE
OTHER RIGHTS WHICH VARY FROM
STATE TO STATE.
Need Assistance?
Call 1-800-554-6723.
NO CLAIMS FOR CONSEQUENTIAL OR
OTHER DAMAGES WILL BE ALLOWED,
AND THERE ARE NO OTHER EXPRESS
WARRANTIES EXCEPT THOSE EX-
PRESSLY STIPULATED HEREIN.
Need Service Part?
Contact your dealer or place of purchase.
SOME STATES DO NOT ALLOW LIMITA-
TIONS ON HOW LONG AN IMPLIED WAR-
RANTY LASTS OR THE EXCLUSION OR
LIMITATIONS OF INCIDENTAL OR CONSE-
QUENTIAL DAMAGES, SO THE ABOVE
LIMITATIONS OR EXCLUSION MAY NOT
APPLY TO YOU.
FRIGIDAIRE HOME PRODUCTS policy is to
continuously improve its products. Therefore,
FRIGIDAIRE HOME PRODUCTS reserves
the right to change, modify, or discontinue mod-
els, designs, specifications, and accessories
of all products at any time without notice or obli-
gation to any purchaser.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
POULAN/WEED EATER at 1--800--554--6723.
WARRANTY COMMENCEMENT DATE: The
warranty period begins on the date the lawn
and garden equipment engine is purchased.
LENGTH OF COVERAGE: This warranty
shall be for a period of two years from the initial
date of purchase. WHAT IS COVERED: RE-
PAIR OR REPLACEMENT OF PARTS. Re-
pair or replacement of any warranted part will
be performed at no charge to the owner at an
approved POULAN/WEED EATER servicing
center. If you have any questions regarding
your warranty rights and responsibilities, you
should contact your nearest authorizedservice
center or call POULAN/WEED EATER at
1--800--554--6723 WARRANTY PERIOD: Any
warranted part which is not scheduled for re-
placement as required maintenance, or which
is scheduled only for regular inspection to the
effect of “repair or replace as necessary” shall
be warranted for 2 years. Any warranted part
which is scheduled for replacement as required
maintenance shall be warranted for the period
of time up to the first scheduled replacement
point for that part. DIAGNOSIS: The owner
shall not be charged for diagnostic labor which
leads to the determination that a warranted part
is defective if the diagnostic work is performed
at an approved POULAN/WEED EATER serv-
icing center. CONSEQUENTIAL DAMAGES:
POULAN/WEED EATER may be liable for
damages to other engine components caused
by the failure of a warranted part still under war-
ranty. WHAT IS NOT COVERED: All failures
caused by abuse, neglect, or improper mainte-
nance are not covered. ADD -ON OR MODI-
FIED PARTS: The use of add--on or modified
parts can be grounds for disallowing a warranty
claim. POULAN/WEED EATER is not liable to
cover failures of warranted parts caused by the
use of add--on or modified parts. HOW TO FILE
A CLAIM: If you have any questions regarding
your warranty rights and responsibilities, you
should contact your nearest authorizedservice
center or call POULAN/WEED EATER at
1--800--554--6723. WHERE TO GET WAR-
RANTY SERVICE: Warranty services or repairs
shall be provided at all POULAN/WEED EATER
service centers. call: 1--800--554--6723 MAINTE-
NANCE, REPLACEMENT AND REPAIR OF
EMISSION RELATED PARTS: Any POULAN/
WEED EATER approved replacement part
used in the performance of any warranty main-
tenance or repair on emission related parts will
be provided without charge to the owner if the
part is under warranty. EMISSION CONTROL
WARRANTY PARTS LIST: Carburetor, Igni-
tion System: Spark Plug (covered up tomainte-
nance schedule), Ignition Module. MAINTE-
NANCE STATEMENT: The owner is
responsible for the performance of all required
maintenance as defined in the owner’s manual.
U.S. EPA/CALIFORNIA
EMISSION CONTROL
WARRANTY STATEMENT
YOUR WARRANTY RIGHTS AND OBLIGA-
TIONS: The U. S. Environmental Protection
Agency/California Air Resources Board and
POULAN/WEED EATER, DIVISION OF WCI
OUTDOOR PRODUCTS are pleased to ex-
plain the emissions control system warranty on
your lawn and garden equipment engine. All
new utility and lawn and garden equipment en-
gines must be designed, built, and equipped to
meet the stringent anti--smog standards. POU-
LAN/WEEDEATER must warrant theemission
control system on your lawn and garden equip-
ment engine for the periods of time listed below
provided there has been no abuse, neglect, or
improper maintenance of your lawn and garden
equipment engine. Your emission control sys-
tem includes parts such as the carburetor and
the ignition system. Where
a
warrantable
condition exits, POULAN/WEED EATER will
repair your lawn and garden equipment engine
at no cost to you. Expenses covered under
warranty include diagnosis, parts and labor.
MANUFACTURER’S WARRANTY COVER-
AGE: If any emissions related part on your en-
gine (as listed under Emissions Control War-
ranty Parts List) is defective or a defect in the
materials or workmanship of the engine causes
the failure of such an emission related part, the
part will be repaired or replaced by POULAN/
WEED EATER. OWNER’S WARRANTY RE-
SPONSIBILITIES: As the lawn and garden
equipment engine owner, you are responsible
for the performance of the required mainte-
nance listed in your Owner’s Manual. POU-
LAN/WEED EATER recommends that you re-
tain all receipts covering maintenance on your
lawn and garden equipment engine, but POU-
LAN/WEED EATER cannot deny warranty
solely for the lack of receipts or for your failure
to ensure the performance of all scheduled
maintenance. As the lawn and garden equip-
ment engine owner, you should be aware that
POULAN/WEED EATER may deny you war-
ranty coverage if your lawn and garden equip-
ment engine or a part of it has failed due to
abuse, neglect, improper maintenance, unap-
proved modifications, or the use of parts not
made or approved by the original equipment
manufacturer. You areresponsible for present-
ing your lawn and garden equipment engine to
a POULAN/WEED EATER authorized repair
center as soon as a problem exists. Warranty
repairs should be completed in a reasonable
amount of time, not to exceed 30 days. If you
have any questions regarding your warranty
rights and responsibilities, you should contact
your nearest authorized service center or call
6
Download from Www.Somanuals.com. All Manuals Search And Download.
|